TB-08-258
Service Bulletin/Repair Instructions
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE
Vehicle report
1997 FORD F SERIES
Service bulletins
141 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
042107
Service Bulletin/Repair Instructions
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
04217
Service Bulletin/Repair Instructions
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
11675
Service Bulletin/Repair Instructions
ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT
03181
Service Bulletin/Repair Instructions
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
16683
Service Bulletin/Repair Instructions
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
03261
Service Bulletin/Repair Instructions
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
02169
Service Bulletin/Repair Instructions
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT
15901
Service Bulletin/Repair Instructions
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
15708
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT
15605
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT
15504
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT
15373
Service Bulletin/Repair Instructions
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
15397
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT
01B77
Service Bulletin/Repair Instructions
OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT
15355
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT
15225
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A DIFFICULT TO REMOVE WHEEL RIM CONDITION. *TT
14484
Service Bulletin/Repair Instructions
SOME CALIFORNIA 7.3L ENGINE EQUIPPED VEHICLES MAY EXHIBIT A BUCK / SURGE / JERK (ALSO KNOWN AS HITCHING) DURING HIGHWAY DRIVING AT SPEEDS 40 MPH OR GREATER WITH THE CRUISE CONTROL ENGAGED. *TT
8058
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR
99B29#1
Service Bulletin/Repair Instructions
INFORMATION REGARDING REPLACMENT OF ENGINE FRONT COVER GASKET. **MR
13832
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
99B29
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE ENGINE COOLANT LEAKS AT THE ENGINE FRONT COVER GASKET. OWNER NOTIFICATION PROGRAM PROVIDING REPLACEMENT OF THE ENGINE FRONT COVER GASKET. *TT
99242
Service Bulletin/Repair Instructions
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
99222
Service Bulletin/Repair Instructions
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
99205
Service Bulletin/Repair Instructions
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT
13322
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
13331
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
13342
Service Bulletin/Repair Instructions
VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE. *TT
7155
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
99E03
Service Bulletin/Repair Instructions
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
13180
Service Bulletin/Repair Instructions
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
13285
Service Bulletin/Repair Instructions
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6997
Service Bulletin/Repair Instructions
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
991413
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT
6350
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6505
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT
6585
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DIT DIESEL ENGINES MAY DEVELOP A CRACKED FLEXPLATE. *TT
99133
Service Bulletin/Repair Instructions
SUBJECT REGARDING INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED. *TT
991210
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
12890
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT
6473
Service Bulletin/Repair Instructions
SOME MEDIUM TRUCKS PRODUCED AT KENTUCKY ASSEMBLY PLANT MAY EXHIBIT OIL LEAKING OUT OF THE TRANSMISSION SHIFT LEVER. *TT
9983
Service Bulletin/Repair Instructions
EXPERIENCING VARIOUS INTERMITTENT CONCERNS, SUCH AS LOW COOLANT LEVEL SENSOR LEAKING COOLANT INTO WIRING HARNESS. *TT
12743
Service Bulletin/Repair Instructions
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
12744
Service Bulletin/Repair Instructions
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
12767
Service Bulletin/Repair Instructions
EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT
12798
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
996130
Service Bulletin/Repair Instructions
INFORMATION ON THE IMPROVED LOWER INTAKE MANIFOLD SIDE GASKETS. *TT
12556
Service Bulletin/Repair Instructions
SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT
12564
Service Bulletin/Repair Instructions
SUBJECT REGARDING PROPER OPERATION AND INTERPRETATION OF DUAL AIR PRESSURE GAUGE READINGS. *TT
5892
Service Bulletin/Repair Instructions
SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT
5899
Service Bulletin/Repair Instructions
CLARIFICATION PERTAINING TO THE DUAL AIR PRESSURE GAUGE FUNCTION. *TT
98246
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
12230
Service Bulletin/Repair Instructions
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
12261
Service Bulletin/Repair Instructions
SUBJECT REGARDING ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIMBURSEMENT. *TT
12298
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
5203
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
5343
Service Bulletin/Repair Instructions
THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE, REQUIRES THAT THE REPLACED COMPONENT BE RETURNED WITH THE APPROPRIATE YEAR DIESEL ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIMBURSEMENT. *TT
982323
Service Bulletin/Repair Instructions
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
12174
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
98217
Service Bulletin/Repair Instructions
EXPERIENCING FLUID ON BRAKE SHOES AND REAR AXLE SEAL LEAK. *YC
985072
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
9811339
Service Bulletin/Repair Instructions
INFORMATION ON THE REVISED FUEL INJECTOR O-RING KIT. *TT
98163
Service Bulletin/Repair Instructions
LOCKS FAILED. YD
981511
Service Bulletin/Repair Instructions
HARD TO START VEHICLE AT COLD TEMPERATURE.*AK
11776
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
11781
Service Bulletin/Repair Instructions
INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT
4658
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
4664
Service Bulletin/Repair Instructions
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. *TT
9852
Service Bulletin/Repair Instructions
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
980301
Service Bulletin/Repair Instructions
EXPERIENCING ROUGH IDLE/MISS. *AK
980302
Service Bulletin/Repair Instructions
SOME VEHICLES EXPERIENCING HARD START/ NO START. *YC
980303
Service Bulletin/Repair Instructions
SYMPTOMS WITH LACK OF POWER. VERIFY ACTUAL ENGINE TURBO-BOOST AS OUTLINED ON THE DIAGNOSTIC SHEET. *AK
980304
Service Bulletin/Repair Instructions
COMPLAINTS REGARDING THE FUEL ECONOMY. *YC
980307
Service Bulletin/Repair Instructions
CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC
980323
Service Bulletin/Repair Instructions
CONCERNS WITH EXTERNAL OIL LEAKS. *YC
982544
Service Bulletin/Repair Instructions
SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE. *YC
982691
Service Bulletin/Repair Instructions
CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE. *YC
982733
Service Bulletin/Repair Instructions
VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC
98614
Service Bulletin/Repair Instructions
THE COOLANT TEMPERATURE GAUGE READING MAY BE INACCURATE. *YC
983106
Service Bulletin/Repair Instructions
INFORMATION REGARDING ENGINE ASSEMBLIES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) PROGRAM. *TT
983170
Service Bulletin/Repair Instructions
CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR. *TT
9833
Service Bulletin/Repair Instructions
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
9811337
Service Bulletin/Repair Instructions
SUBJECT REGARDING CHANGES TO THE MIDLINE RADIO. *TT
983592
Service Bulletin/Repair Instructions
SUBJECT PERTAINING TO RADIO INOPERATIVE CONDITIONS. *TT
97050110607
Service Bulletin/Repair Instructions
ENGINEERING IS INVESTIGATING CONCERNS OF THE REAR ABS LIGHT COMING ON WHEN THE IGNITION IS IN THE ON POSITION.
97050110608
Service Bulletin/Repair Instructions
VEHICLES BUILT WITH 4R70W TRANSMISSIONS BEARING A PREFIX OF F7 MUST BE OVERHAULED OR REPLACED WITH A NEW ASSEMBLY AS NO FQR ASSEMBLIES ARE AVAILABLE. *TW
BC2232970501
Service Bulletin/Repair Instructions
ENGINEERING IS INVESTIGATING CONDITIONS THAT CAUSE THE ABS LIGHT (RABS) TO ILLUMINATE. *TW
BC2233970501
Service Bulletin/Repair Instructions
1997 F SERIES TRUCKS EQUIPPED WITH TRANSMISSIONS BEARING F7 PREFIXES DO NOT HAVE ASSEMBLIES AVAILABLE -REPAIR BY OVERHAUL OR USE NEW ASSEMBLY. *TW
BC2308970501
Service Bulletin/Repair Instructions
NEW VOLUME CONTROL/ON-OFF SWITCH. *TW
BC2312970501
Service Bulletin/Repair Instructions
NEW THROTTLE CABLE TO REDUCE VIBRATION ATTHE ACCELERATOR PEDAL. *TW
BC2370970501
Service Bulletin/Repair Instructions
CUSTOMER COMPLAINTS OF POOR HEATER PERFORMANCE. *TW
97716
Service Bulletin/Repair Instructions
FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD
97630
Service Bulletin/Repair Instructions
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD
9768
Service Bulletin/Repair Instructions
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
97517
Service Bulletin/Repair Instructions
ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD
BC3070970227
Service Bulletin/Repair Instructions
CONCERNS OF CONDENSATE FORMING ON OUTSIDE OF EVAPORATOR CASE. *TW
BC3071970227
Service Bulletin/Repair Instructions
DIAGNOSTICS FOR POOR HEATER PERFORMANCE CONCERNS. *TW
97411
Service Bulletin/Repair Instructions
FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD
BC3172970217
Service Bulletin/Repair Instructions
CLUNK/GRUNT NOISE ON 5.4L F-SERIES 3.55 LIMITED SLIP AXLES. *TW
BC3230970211
Service Bulletin/Repair Instructions
CHECK ENGINE LIGHT - DTC P1450 - CHECK FOR MOLD FLASHING CAUSING A FLOW RESTRICTION IN THE 90 DEGREE ELBOW EVAP LINE COMING OUT OF THE CANNISTER ASSEMBLY AND GOING TO THE FUEL TANK . *TW
97315
Service Bulletin/Repair Instructions
NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD
BC1029097020
Service Bulletin/Repair Instructions
ILLUMINATION OF THE CHECK ENGINE LIGHT MAY OCCUR. *JD
BC1029697020
Service Bulletin/Repair Instructions
FD 1060 ENGINES THE LOWER COOLANT PIPE, BASE PART NUMBER -8291- WAS CHANGED. *JD
BC1033797020
Service Bulletin/Repair Instructions
CONDENSATE FORMING ON THE OUTSIDE OF THE EVAPORATOR. *JD
BC0322972301
Service Bulletin/Repair Instructions
1600-1900 RPM MOAN/DRONE WHILE DRIVING. *JD
BC1017697230
Service Bulletin/Repair Instructions
CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON VEHICLE APPLICATIONS. *JD
BC1018797230
Service Bulletin/Repair Instructions
DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
BC1022497230
Service Bulletin/Repair Instructions
INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD
BC1026797230
Service Bulletin/Repair Instructions
FD 1060 ENGINE HARD START OR NO START IN EXTREMELY COLD AMBIENTS. *JD
BC3360972301
Service Bulletin/Repair Instructions
INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD
BC3505972301
Service Bulletin/Repair Instructions
THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
97115
Service Bulletin/Repair Instructions
SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
97117
Service Bulletin/Repair Instructions
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD
97118
Service Bulletin/Repair Instructions
ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
BC0053970201
Service Bulletin/Repair Instructions
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
BC0255970201
Service Bulletin/Repair Instructions
4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE. *JD
BC0256970201
Service Bulletin/Repair Instructions
A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD
BC0322970201
Service Bulletin/Repair Instructions
1600-1900 RPM MOAN/DRONE WHILE DRIVING. *JD
BC1011097020
Service Bulletin/Repair Instructions
OVERHEATING ON 4.6/5.4L VEHICLES MAY BE CAUSED BY POSSIBLE WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER.
962529
Service Bulletin/Repair Instructions
FEAD BELT - HIGH WEAR AND/OR COMES OFF THE DRIVE PULLEY - VEHICLES BUILT FROM 4/1/92 THROUGH 9/1/96 WITH FD1060 ENGINE. *TW
962420
Service Bulletin/Repair Instructions
LACK OF POWER - ACCELERATOR CABLE DISLODGES FROM ACCELERATOR PEDAL - VEHICLES WITH 7.0L ENGINE - VEHICLES BUILT FROM 8/1/90 THROUGH 6/3/96. *TW
96246
Service Bulletin/Repair Instructions
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
BC0054961101
Service Bulletin/Repair Instructions
VEHICLES MAY HAVE BEEN BUILT WITH A 240 SECOND MISFIRE DELAY. *TW
BC0322961101
Service Bulletin/Repair Instructions
HARD STARTING WITH DTC'S P0341, P0344. *TW
BC0601961101
Service Bulletin/Repair Instructions
MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW
BC0602961101
Service Bulletin/Repair Instructions
INSTRUCTIONS ON SECURING SPARE TIRE TO UNDERBODY OF VEHICLE. *TW
BC0604961101
Service Bulletin/Repair Instructions
NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW
BC0693961023
Service Bulletin/Repair Instructions
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
BC0694961023
Service Bulletin/Repair Instructions
INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT
BC0696961023
Service Bulletin/Repair Instructions
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
962218
Service Bulletin/Repair Instructions
STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW
BC0750961017
Service Bulletin/Repair Instructions
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
BC0782961014
Service Bulletin/Repair Instructions
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
BC0844961008
Service Bulletin/Repair Instructions
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
BC0854961007
Service Bulletin/Repair Instructions
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT
BC0883961004
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
BC0884961004
Service Bulletin/Repair Instructions
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
BC5195961001
Service Bulletin/Repair Instructions
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
BC5197961001
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
BC5201961001
Service Bulletin/Repair Instructions
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.