TB-08-258
Service Bulletin/Repair Instructions
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE
Vehicle report
1998 FORD F SERIES
Service bulletins
87 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
042107
Service Bulletin/Repair Instructions
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
04217
Service Bulletin/Repair Instructions
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
11675
Service Bulletin/Repair Instructions
ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT
03181
Service Bulletin/Repair Instructions
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
16683
Service Bulletin/Repair Instructions
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
03261
Service Bulletin/Repair Instructions
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
15901
Service Bulletin/Repair Instructions
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
15708
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT
15761
Service Bulletin/Repair Instructions
SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT
15605
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT
15504
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT
15373
Service Bulletin/Repair Instructions
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
15397
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT
15355
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT
15225
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A DIFFICULT TO REMOVE WHEEL RIM CONDITION. *TT
14821
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
14864
Service Bulletin/Repair Instructions
SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
8058
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR
13832
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
99242
Service Bulletin/Repair Instructions
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
99222
Service Bulletin/Repair Instructions
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
13322
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
13331
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
13342
Service Bulletin/Repair Instructions
VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE. *TT
7155
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
7194
Service Bulletin/Repair Instructions
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) ASSEMBLY LAUNCH OF 4.6L 2V ENGINE. *TT
99E03
Service Bulletin/Repair Instructions
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
13180
Service Bulletin/Repair Instructions
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
13187
Service Bulletin/Repair Instructions
INFORMATION REGARDING E40D/4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *MJS
13285
Service Bulletin/Repair Instructions
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6997
Service Bulletin/Repair Instructions
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
6999
Service Bulletin/Repair Instructions
SUBJECT REGARDING E40D / 4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *TT
991413
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT
6350
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6505
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT
6573
Service Bulletin/Repair Instructions
INFORMATION ON VARIOUS ENGINES AVAILABLE FOR THE FORD QUALTY RENEWAL (FQR) ENGINE ASSEMBLY. *TT
6585
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DIT DIESEL ENGINES MAY DEVELOP A CRACKED FLEXPLATE. *TT
99133
Service Bulletin/Repair Instructions
SUBJECT REGARDING INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED. *TT
991210
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
12890
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT
6386
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE AVAILABILITY OF ENGINE ASSEMBLY FOR VARIOUS VEHICLES. *TT
9983
Service Bulletin/Repair Instructions
EXPERIENCING VARIOUS INTERMITTENT CONCERNS, SUCH AS LOW COOLANT LEVEL SENSOR LEAKING COOLANT INTO WIRING HARNESS. *TT
12743
Service Bulletin/Repair Instructions
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
12744
Service Bulletin/Repair Instructions
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
12767
Service Bulletin/Repair Instructions
EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT
12798
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
996130
Service Bulletin/Repair Instructions
INFORMATION ON THE IMPROVED LOWER INTAKE MANIFOLD SIDE GASKETS. *TT
12556
Service Bulletin/Repair Instructions
SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT
12560
Service Bulletin/Repair Instructions
BIEF INFORMATION REGARDING DIAGNOSTIC CODE RETRIVAL ON BI-FUEL VEHICLES. *TT
12564
Service Bulletin/Repair Instructions
SUBJECT REGARDING PROPER OPERATION AND INTERPRETATION OF DUAL AIR PRESSURE GAUGE READINGS. *TT
5890
Service Bulletin/Repair Instructions
INFORMATION ON RETRIEVING DIAGNOSTIC CODES FOR BASE ENGINE / GASOLINE FUEL SYSTEM OR THE ALTERNATE FUEL SYSTEM. *TT
5892
Service Bulletin/Repair Instructions
SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT
5899
Service Bulletin/Repair Instructions
CLARIFICATION PERTAINING TO THE DUAL AIR PRESSURE GAUGE FUNCTION. *TT
98246
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
12230
Service Bulletin/Repair Instructions
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
12298
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
5203
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
982323
Service Bulletin/Repair Instructions
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
12134
Service Bulletin/Repair Instructions
INFORMATION REGARDING VEHICLES MODELS OF THE 4R100 THAT ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *MJS
12174
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
985072
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
985183
Service Bulletin/Repair Instructions
EFFECTIVE NOVEMBER 2, 1998 CERTAIN VEHICLES OF THE 4R100 ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
4747
Service Bulletin/Repair Instructions
INFORMATION ON ADDITIONS TO THE FORD QUALITY RENEWAL ASSEMBLY PROGRAM.
9811339
Service Bulletin/Repair Instructions
INFORMATION ON THE REVISED FUEL INJECTOR O-RING KIT. *TT
99-4694
Service Bulletin/Repair Instructions
SUBJECT REGARDING VEHICLES WITH FACTORY INSTALLED CD CHANGERS HAVING REVISED SHIPPING LOCATIONS FOR THE CD MAGAZINE. *TT
98163
Service Bulletin/Repair Instructions
LOCKS FAILED. YD
11776
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
11781
Service Bulletin/Repair Instructions
INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT
4658
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
4664
Service Bulletin/Repair Instructions
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. *TT
4694
Service Bulletin/Repair Instructions
SOME FACTURY INSTALLED CD CHANGERS MAY HAVE REVISED SHIPPING LOCATIONS FOR THE CD MAGAZINE. *TT
9852
Service Bulletin/Repair Instructions
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
11482
Service Bulletin/Repair Instructions
FOR CERTAIN MODEL VEHICLES, THE 4R70W TRANSMISSION SOLENOID MOLDED LEADFRAME MUST BE REPLACED WHEN REMOVED. *TT
980307
Service Bulletin/Repair Instructions
CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC
982691
Service Bulletin/Repair Instructions
CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE. *YC
982733
Service Bulletin/Repair Instructions
VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC
98614
Service Bulletin/Repair Instructions
THE COOLANT TEMPERATURE GAUGE READING MAY BE INACCURATE. *YC
9844
Service Bulletin/Repair Instructions
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
983084
Service Bulletin/Repair Instructions
INFORMATION ON ADDING OR INSTALLING A PULLEY. *TT
983170
Service Bulletin/Repair Instructions
CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR. *TT
983180
Service Bulletin/Repair Instructions
INFORMATION ON THE NEW 4R100 TRANSMISSION. *TT
983316
Service Bulletin/Repair Instructions
SOME CUSTOMER MAY COMPLAIN OF A TICKING NOISE ON INITIAL COLD START-UP IN PARK POSITION AND NEUTRAL POSITION. *TT
9811337
Service Bulletin/Repair Instructions
SUBJECT REGARDING CHANGES TO THE MIDLINE RADIO. *TT
976011
Service Bulletin/Repair Instructions
TECHNICIANS EXPERIENCING YELLOW POP-UPS ON SERVICE BAY DIAGNOSTIC SYSTEM (SBDS)." *TT
970902971814
Service Bulletin/Repair Instructions
SERVICE TIPS ON AIR BRAKE GOVERNOR OPERTIONAL SPECIFICATIONS. *YC
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.