TB-08-258
Service Bulletin/Repair Instructions
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE
Vehicle report
1999 FORD F SERIES
Service bulletins
80 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
CSP-08B01
Service Bulletin/Repair Instructions
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. *PE
042107
Service Bulletin/Repair Instructions
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
04217
Service Bulletin/Repair Instructions
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
11456
Service Bulletin/Repair Instructions
CORRECT FUEL PRESSURE TEST ADAPTER. FORD SPECIAL SERVICE MESSAGE. *TT
11672
Service Bulletin/Repair Instructions
7.3L DIT TURBOCHARGER REPLACEMENT UNDER WARRANTY. FORD SPECIAL SERVICE MESSAGE. *TT
11675
Service Bulletin/Repair Instructions
ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT
03181
Service Bulletin/Repair Instructions
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
16891
Service Bulletin/Repair Instructions
CLEAR GEL-LIKE SUBSTANCE IN THE HYDRAULIC BRAKE MASTER CYLINDER RESERVOIR. THIS SUBSTANCE IS A SILICONE BASE LUBRICANT USED DURING ASSEMBLY OF THE MASTER CYLINDER. *TT
16683
Service Bulletin/Repair Instructions
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
03261
Service Bulletin/Repair Instructions
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
15851
Service Bulletin/Repair Instructions
SOME 5.4L WINDSOR POWER IMPROVED ENGINES MAY EXHIBIT A SLIGHT OIL LEAK OR WEEP AT THE CYLINDER HEAD TO BLOCK JOINT. *TT
15708
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT
15757
Service Bulletin/Repair Instructions
SUBJECT REGARDING VEHICLES EXHIBITING COLD START ROLLING IDLE. *TT
15761
Service Bulletin/Repair Instructions
SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT
02L08
Service Bulletin/Repair Instructions
SUBJECT REGARDING FIELD SERVICE ACTION 02L08 FOR MISSING IMPORTANT ENGINE INFORMATION LABEL. *TT
15605
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT
15504
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT
15373
Service Bulletin/Repair Instructions
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
15397
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT
15355
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT
15225
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A DIFFICULT TO REMOVE WHEEL RIM CONDITION. *TT
14821
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
14864
Service Bulletin/Repair Instructions
SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
13846
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAT GASKET AREA. *TT
13870
Service Bulletin/Repair Instructions
CONCERNS WITH A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT
8093
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
8138
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT
14233
Service Bulletin/Repair Instructions
SOME VEHICLES EQUPPED WITH A 5.4L OR 6.8L ENGINE MAY EXHIBIT A ROLLING / ROUGH IDLE. *TT
99242
Service Bulletin/Repair Instructions
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
99222
Service Bulletin/Repair Instructions
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
13343
Service Bulletin/Repair Instructions
SOME SUPER DUTY F SERIES 250 - 350 MAY EXHIBIT A SQUEAKING NOISE IN THE FRONT END. *TT
13290
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CD CHANGER WITH A CD MAGAZINE THAT JAMS / WILL NOT EJECT. *TT
13322
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
13331
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
7155
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
7207
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CD CHANGER WITH A CD MAGAZINE THAT JAMS / WILL NOT EJECT. *TT
99E03
Service Bulletin/Repair Instructions
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
13180
Service Bulletin/Repair Instructions
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
13187
Service Bulletin/Repair Instructions
INFORMATION REGARDING E40D/4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *MJS
13285
Service Bulletin/Repair Instructions
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6935
Service Bulletin/Repair Instructions
SUBJECT REGARDING NEW ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR STRAGETY. *TT
6997
Service Bulletin/Repair Instructions
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
6999
Service Bulletin/Repair Instructions
SUBJECT REGARDING E40D / 4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *TT
13163
Service Bulletin/Repair Instructions
SUBJECT REGARDING A NEW ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR STRATEGY. *TT
991413
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT
6350
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6505
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT
6585
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DIT DIESEL ENGINES MAY DEVELOP A CRACKED FLEXPLATE. *TT
12890
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT
12743
Service Bulletin/Repair Instructions
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
12744
Service Bulletin/Repair Instructions
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
12798
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
9942
Service Bulletin/Repair Instructions
CUSTOMER MAY COMPLAIN OF BRAKE FLUID LEAKING AT THE LEFT REAR WHEEL. *TT
9946
Service Bulletin/Repair Instructions
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
12556
Service Bulletin/Repair Instructions
SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT
12564
Service Bulletin/Repair Instructions
SUBJECT REGARDING PROPER OPERATION AND INTERPRETATION OF DUAL AIR PRESSURE GAUGE READINGS. *TT
5892
Service Bulletin/Repair Instructions
SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT
5899
Service Bulletin/Repair Instructions
CLARIFICATION PERTAINING TO THE DUAL AIR PRESSURE GAUGE FUNCTION. *TT
98L17S2
Service Bulletin/Repair Instructions
SUBJECT REGARDING INCORRECT IMPORTANT VEHICLE AND ENGINE CONTROL INFORMATION LABELS. *TT
98246
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
12230
Service Bulletin/Repair Instructions
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
12231
Service Bulletin/Repair Instructions
ON SOME SUPER DUTY VEHICLES, THE CUPHOLDER MAY NOT FULLY RETRACT INTO THE CUPHOLDER INSTRUMENT PANEL OPENING, NOT ALLOWING THE CUPHOLDER FINISH PANEL TO FIT FLUSH WITH THE INSTRUMENT PANEL. *TT
5203
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
5205
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NGS ERROR MESSAGE, TOTAL CHECKSUM ERROR AFTER NGS / SBTS PCM REPROGRAMMING. *TT
982310
Service Bulletin/Repair Instructions
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
98238
Service Bulletin/Repair Instructions
CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC
12134
Service Bulletin/Repair Instructions
INFORMATION REGARDING VEHICLES MODELS OF THE 4R100 THAT ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *MJS
12169
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NGS ERROR MESSAGE AFTER NGS/SBTS PCM REPROGRAMMING. *MJS
12174
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
985072
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
985183
Service Bulletin/Repair Instructions
EFFECTIVE NOVEMBER 2, 1998 CERTAIN VEHICLES OF THE 4R100 ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
9811339
Service Bulletin/Repair Instructions
INFORMATION ON THE REVISED FUEL INJECTOR O-RING KIT. *TT
11776
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
4658
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
4711
Service Bulletin/Repair Instructions
SOME SUPER DUTY TRUCKS EQUIPPED WITH THE 7.3L DIT ENGINE MAY EXHIBIT A LACK OF POWER AND / OR A WHISTLE NOISE COMING FROM THE ENGINE COMPARTMENT. *TT
980307
Service Bulletin/Repair Instructions
CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC
983180
Service Bulletin/Repair Instructions
INFORMATION ON THE NEW 4R100 TRANSMISSION. *TT
983316
Service Bulletin/Repair Instructions
SOME CUSTOMER MAY COMPLAIN OF A TICKING NOISE ON INITIAL COLD START-UP IN PARK POSITION AND NEUTRAL POSITION. *TT
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.