Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 46085
Service Bulletin/Repair Instructions
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
ASI-44408
Service Bulletin/Repair Instructions
FORD: THE RESTRAINT CONTROL MODULE (RCM) WHEN USING VCM II, WOULD HAVE AN ERROR CODE 35 AND DIAGNOSTIC TROUBLE CODE (DTC) B1035, AND DIFFICULTY ATTEMPTING PROGRAMMABLE MODULE INSTALLATION (PMI). MODEL 2001-2004 F-SUPER DUTY. *PE
TSB-12-7-4
Service Bulletin/Repair Instructions
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
TSB-10-12-6
Service Bulletin/Repair Instructions
FORD: RUNS ROUGH, LACKS POWER, HARD START, NO START. SOME VEHICLES AND TRUCKS EQUIPPED WITH 6.0L ENGINE MAY EXHIBIT A RUNS ROUGH, LACKS POWER, HARD TO START, NO START CONCERN WITH OR WITHOUT DIAGNOSTIC TROUBLE CODE (DTC) P0611 CODE OR VARIOUS INJECTOR CIRCUIT CODES. *PE
TSB-09-15-6
Service Bulletin/Repair Instructions
FORD: SOME VEHICLES EQUIPPED WITH THE 6.0L ENGINE MAY EXPERIENCE A P006A, P132, P0401 OR P0402 DIAGNOSTIC TROUBLE CODE (DTC) WITH A LACK OF POWER CONDITION, SURGE, OR TURBOCHARGER FLUTTER AFTER PERFORMING FIELD SERVICE ACTION (FSA) 06E17, OR AFTER RECALIBRATING THE VEHICLE WITH THE INFERRED EXHAUST PRESSURE (EBP) STRATEGY. *PE
SB-09B09
Service Bulletin/Repair Instructions
FORD: CERTAIN VEHICLES WITH AMBULANCE PREP PACKAGE AMBULANCE CLASS ACTION SETTLEMENT; PCM PART NUMBER INSPECTION. AWARENESS COMMUNICATION DATED 4/20/09. *PE
SB-09M02
Service Bulletin/Repair Instructions
FORD: CERTAIN VEHICLES WITH AMBULANCE PREP PACKAGE AMBULANCE CLASS ACTION SETTLEMENT; SPECIFIC COMPONENT WARRANTY EXTENSION. AWARENESS COMMUNICATION, DATED 4/20/09. *PE
SB-09M03
Service Bulletin/Repair Instructions
FORD: CERTAIN VEHICLES, E SERIES AND F SUPER DUTY, WITH AMBULANCE PREP PACKAGE AMBULANCE CLASS ACTION SETTLEMENT-6.0L DIESEL ENGINE REPLACEMENT WARRANTY EXTENSION. AWARENESS COMMUNICATION DATED 4/20/09. *PE
SB-20937
Service Bulletin/Repair Instructions
FORD: MULTIPLE VEHICLES WITH A TORQ SHIFT TRANSMISSION INTERMITTENT CLUNK WHEN SHIFTING BETWEEN DRIVE, REVERSE AND PARK AND/OR DURING 2-3 UPSHIFT. MODELS F SUPER DUTY; E SERIES; EXCURSION; F53 MOTORHOME CHASSIS AND LOW CAB FORWARD. *PE
TSB-08-26-3
Service Bulletin/Repair Instructions
FORD: SOME VEHICLES WITH DIESEL ENGINES MAY EXPERIENCE NO STARTS, HARD STARTS OR ROUGH RUNNING WHEN COLD AND MAY BE ACCOMPANIED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0611, P1378 AND/OR ALL 8 INJECTOR CIRCUIT CODES. *PE
TSB-08-16-13
Service Bulletin/Repair Instructions
FORD: SOME VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINE MAY EXHIBIT ANY ONE OR COMBINATION OF THE FOLLOWING CONCERNS-LACK OF POWER, WHITE/BLACK SMOKE OR A SURGE. *PE
TSB-08-20-1
Service Bulletin/Repair Instructions
FORD TRUCKS: MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE, CRANK/NO START-DIAGNOSTICS FOR FUEL SYSTEM. THERE ARE SEVERAL POTENTIAL CAUSES FOR THESE SYMPTOMS. *PE
TSB-08-23-8
Service Bulletin/Repair Instructions
FORD: VEHICLES MAY EXHIBIT FUEL IN THE ENGINE COOLANT, DUE TO LEAKS IN THE CYLINDER HEAD FUEL INJECTOR AREA. SYMPTOMS MAY INCLUDE FUEL IN ENGINE COOLANT AND COOLANT EXPULSION FROM THE DEGAS BOTTLE. *PE UPDATED 3/20/09. *PE
CSP-48B01
Service Bulletin/Repair Instructions
FORD: VEHICLES MISTAKENLY CHARGED $100 POWERTRAIN WARRANTY DEDUCTIBLE FOR FUEL INJECTOR REPAIR OR REPAIRS. NO MODEL OR MODEL YEARS PROVIDED. *PE ECONOLINE, EXCURSION AND F-SERIES SUPER DUTY VEHICLES, MODEL YEARS 2002-2005. UPDATED 10/24/08. *PE CSC LETTER WAS RECEIVED. UPDATED 10/27/08. *PE
07212
Service Bulletin/Repair Instructions
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE