Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 52567
Motorcraft® Continuously Variable Chain-Type Transmission Fluid (XT-7-QCFT in non-Canadian markets, CXT-7-LCF12 in Canada) is no longer manufactured and will only be available until inventory depletes. The recommended replacement fluids are Phillips 66 VersaTrans® CVT Plus Fluid or Kendall VersaTrans® CVT Plus Fluid. Mixing Motorcraft® CVT fluid (blue-green color) with these replacement fluids (red color) in the same transmission is acceptable.
SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
CSP-12N03
FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. MOMENTARY ENGINE IDLE RPM SURGE MAY BE INTERMITTENT AND MAY OCCUR, DUE TO DEPOSITS BUILDUP IN THROTTLE BODY, AT LOW SPEEDS, WHILE PARKING OR ENTERING DRIVEWAY AND CHECK ENGINE LAMP MAY ILLUMINATE. MODELS 2005-07 FREESTYLE, 500, MONTEGO. *PE
0710
FORD MERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN 2005 THROUGH 2007 FWD AND AWD FORD FIVE HUNDRED, FREESTYLE AND MERCURY MONTEGO VEHICLES - REAR BRAKE WEAR. ALSO HAVE AN OWNER'S LETTER. *NJ UPDATED 1/25/08. *NJ
19722
MIL WITH DTC P0106 AND/OR P0109. *KB
19312
BATTERY LIGHT ILLUMINATED. *KB
06114
CONTINUOUSLY VARIABLE TRANSAXLE (CVT) NOISE DIAGNOSIS. *TT
06211
HEATED SEATS INOPERATIVE. *TT
06411
OIL LEAK FROM POWER TRANSFER UNIT. *TT
0662
INTERMITTENT INSTRUMENT CLUSTER GAUGE SWEEP/RESET - MULTIPLE WARNING LIGHTS ON - REVERSE LIGHTS ON - VEHICLES BUILT BEFORE 2/17/2006. *TT
0664
SECOND ROW SEAT RECLINE CONCERN. *TT
19005
GRUNT OR SQUEAK FROM FRONT SUSPENSION DURING FULL LOCK TURNS - SERVICE TIP. *TT
041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
05175
ENGINE RPM FLUCTUATION AT HIGHWAY CRUISING SPEEDS - VEHICLES BUILT PRIOR TO 8/2/2005. *TT
05179
INTERMITTENT SPEED CONTROL DEACTIVATION AND/OR SPEED CONTROL WILL NOT SET. *TT
0532
SQUEAK/CLUNK NOISE FROM REAR LOWER CONTROL ARM - VEHICLES BUILT 7/12/2004 THROUGH 9/21/2004. *TT
0551
INTERMITTENT HEADLAMP FLICKER WITH NO KEY IN THE IGNITION - VEHICLES BUILT BEFORE 2/21/2005. *TT
0547
THUMPING NOISE OR ROUGHNESS FROM REAR BRAKES. *TT
18452
ENGINE SERVICE PROCEDURES. *EH
18479
SQUEAK FROM REAR OF VEHICLE WHEN DRIVING OVER BUMPS. *EH
18504
INCORRECT COMPASS INFORMATION IN OWNERS GUIDE AND WORK SHOP MANUAL. *EH
18399
MEMORY SEAT, ADJUSTABLE PEDALS AND MIRRORS OPERATION CONCERNS. *TT
18412
MEMORY SEAT, MIRRORS AND PEDALS OPERATION. *TT
18432
VEHICLE MAY EXHIBIT AN OIL LIFE XX% MESSAGE INTHE ODOMETER MESSAGE CENTER DISPLAY PRIOR TO THE VEHICLE REACHING 5000 MILES. *EH
18378
OIL LEAK FROM POWER TRANSFER UNIT. *TT
042616
WELD BONDING PROCEDURE. *TT
04189
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT
042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
04242
DRIVEABILITY CONCERNS DURING DECELERATION. *TT
18329
AUDIO UNIT BACKLIGHT INOPERATIVE AND OR DTC B2477. *EH
18353
SQUEAK FROM REAR OF VEHICLE WHEN DRIVING OVER BUMPS. *EH
18361
OIL LEAK FROM POWER TRANSFER UNIT. *EH
18178
WRENCH LIGHT ON, NO ENGAGEMENT IN DRIVE OR REVERSE AND DIAGNOSTIC TROUBLE CODE P0942. *TT
18179
WRENCH LIGHT ON, DIAGNOSTIC TROUBLE CODE P0562 AND TRANSAXLE IN LIMP HOME MODE AFTER BATTERY JUMP START. *TT
06154
PREMATURE SHOULDER (TOE) WEAR ON INSIDE EDGE OF THE FRONT TIRES. *KB
06172
FUEL GAUGE ERRATIC/INACCURATE AND/OR MIL ON WITH DTC P0463, B1202, B2627, B2879, AND/OR P2068. *KB
06179
INTERMITTENT INSTRUMENT CLUSTER OPERATION - INCLUDING GAUGES SWEEP/RESET - MULTIPLE WARNING LIGHTS ILLUMINATED AND/OR REVERSE LIGHTS STAY ON. THIS APPLIES TO VEHICLES BUILT BEFORE 02-17-06. *KB
0718
TRANSMISSION SHIFTER BINDING / HIGH EFFORT BEZEL REPLACEMENT. *KB
0747
MIL ON WITH DTC P0191 - FUEL RAIL PRESSURE SENSOR CIRCUIT PERFORMANCE. *KB
0759
REAR BRAKE DRAG, NOISE, DUST, AND/OR PREMATURE PAD WEAR. *KB
19083
INTERMITTENT BOUNCE-BACK OF THE DRIVER'S WINDOW DURING ONE TOUCH UP OPERATION. *TT
19087
TENTHS DIGIT NOT DISPLAYED ON ODOMETER AFTER 10,000 MILES/KILOMETERS. *TT
19107
NOISE IN RIGHT FRONT OF PASSENGER COMPARTMENT - AIR INLET DOOR ACTUATOR INOPERATIVE (RECIRCULATION). *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.