02169
Service Bulletin/Repair Instructions
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT
Vehicle report
1997 FORD L SERIES
Service bulletins
33 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
99205
Service Bulletin/Repair Instructions
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
991413
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT
12116
Service Bulletin/Repair Instructions
INFORMATION ON SERVICING THE AIR CLEANER ELEMENT ON ALL 1995- 1996-1997 L-SERIES EQUIPPED WITH CAT 3306 ENGINES. *MJS
98214
Service Bulletin/Repair Instructions
CONCERNS OF AIR CLEANER COVER MAY RUB A HOLE IN THE HOOD AT THE FRONT EDGE OF THE AIR CLEANER INLET " WAGON WHEEL " ON SOME VEHICLES. *YC
9852
Service Bulletin/Repair Instructions
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
9833
Service Bulletin/Repair Instructions
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
970902971817
Service Bulletin/Repair Instructions
SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC
BC2312970501
Service Bulletin/Repair Instructions
NEW THROTTLE CABLE TO REDUCE VIBRATION ATTHE ACCELERATOR PEDAL. *TW
97716
Service Bulletin/Repair Instructions
FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD
97630
Service Bulletin/Repair Instructions
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD
97517
Service Bulletin/Repair Instructions
ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD
97411
Service Bulletin/Repair Instructions
FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD
97412
Service Bulletin/Repair Instructions
COOLING SYSTEM- ENGINE COOLING FAN CRACKS AT CENTER HUB. *JD
BC3201970214
Service Bulletin/Repair Instructions
HENDRICKSON AIR RIDE SUSPENSION WITH TRANSVERSE MOUNTED TORQUE RODS- THE FLAT WASHERS USED ON THE ROD TO AXLE ATTATCHING BOLT MAY DEFORM. *TW
BC3236970211
Service Bulletin/Repair Instructions
FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW
97315
Service Bulletin/Repair Instructions
NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD
BC1018797230
Service Bulletin/Repair Instructions
DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
BC3505972301
Service Bulletin/Repair Instructions
THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
97115
Service Bulletin/Repair Instructions
SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
97117
Service Bulletin/Repair Instructions
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD
97118
Service Bulletin/Repair Instructions
ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
BC0193970201
Service Bulletin/Repair Instructions
REVISED FAN ASSEMBLIES FOR PREMIUM DIESEL ENGINES ARE NOW AVAILABLE. *JD
96246
Service Bulletin/Repair Instructions
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
BC0465961115
Service Bulletin/Repair Instructions
DRIVER MAY EXPERIENCE A SIDE TO SIDE MOVEMENT OR WOBBLE OF THE SEAT. *TW
BC0480961113
Service Bulletin/Repair Instructions
REPLACEMENT LEVELING VALVE EXTENTION ROD FOR HENDRICKSON AIR-RIDE SUSPENSION. *TW
BC0018961101
Service Bulletin/Repair Instructions
ON L SERIES EQUIPPED WITH CUSH-N-AIR SEATS, THE DRIVER MAY EXPERIENCE A SIDE TO SIDE MOVEMENT OR WOBBLE OF THE SEAT DUE TO INADEQUATE WELDS. *TW
BC0601961101
Service Bulletin/Repair Instructions
MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW
BC0604961101
Service Bulletin/Repair Instructions
NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW
962217
Service Bulletin/Repair Instructions
ENGINE - WILL NOT ACCELERATE ABOVE IDLE SPEED - VEHICLES EQUIPPED WITH CUMMINS M11, N14 OR DETROIT DIESEL SERIES 60 ENGINE. *TW
962218
Service Bulletin/Repair Instructions
STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW
BC0813961011
Service Bulletin/Repair Instructions
THROTTLE POSITION SENSOR &/OR IDLE VALIDATION SWITCH FAILS, IN MAY GENERATE ECM SERVICE CODES OR DRIVEABILITY CONCERNS. A REVISED ONE PIECE SENSOR & SWITCH IS NOW AVAILABLE. *TT
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.