Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 51536
Service Bulletin/Repair Instructions
For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
SSM 51120
Service Bulletin/Repair Instructions
Some Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should only be machined if directed by the WSM because one or more of the following conditions are present on the braking surface: scoring, excessive corrosion/rust or pitting, bluing/discoloration and/or heat spots. For additional information, refer to WSM section 206-00.
20M01
Service Bulletin/Repair Instructions
In the affected vehicles, it may be possible that certain driving maneuvers can result in an overheated catalytic converter, catalyst degradation, and an illuminated malfunction indicator light (MIL) with diagnostic trouble codes (DTCs) P0420 and/or P0430 stored in the powertrain control module (PCM).
SSM 48070
Service Bulletin/Repair Instructions
Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor function at various fan speed settings. This may be due to a poor electrical connection at the blower motor speed control. If the blower motor speed control is determined to be the causal part, replacement of the electrical connector pigtail harness (14S411) to the blower motor speed control is also recommended to avoid repeat repairs. Use pigtail harness service part numbers 3U2Z-14S411-ZEA or CU2Z-14S411-FA, as both parts are interchangeable. Refer to Wiring Diagram, Cell 5 for recommended splicing procedures.
17N04
Service Bulletin/Repair Instructions
Certain 2014-2015 Explorer and 2014-2016 Police Interceptor Utility Vehicles - Front Door Trim Panel Repair
TSB 16-0166
Service Bulletin/Repair Instructions
SUPERCEDES TSB 16-0165: SOME 2011-2015 EXPLORER VEHICLES MAY EXHIBIT AN EXHAUST ODOR IN THE VEHICLE WITH THE AUXILIARY CLIMATE CONTROL SYSTEM ON. CUSTOMERS MAY INDICATE THE ODOR SMELLS LIKE SULFUR, OR THAT EXHAUST ODORS ARE ENTERING THE VEHICLE CABIN. THIS CONDITION MAY BE WORSENED WHEN THE CLIMATE CONTROL SYSTEM IS IN RECIRCULATE MODE AND THE VEHICLE IS HEAVILY ACCELERATED FOR AN EXTENDED PERIOD. WHETHER AND TO WHAT EXTENT ANY CUSTOMER OR OCCUPANT OF A 2011-2015 EXPLORER VEHICLE EXPERIENCES THE EXHAUST ODOR WILL BE AFFECTED BY DRIVING HABITS, WEATHER AND INDIVIDUAL SENSITIVITIES. FOLLOW EACH AND EVERY STEP OF THE TSB SERVICE PROCEDURE IN PROCEDURE 1 TO IMPROVE THE CONDITION.
CSP-16-N-01
Service Bulletin/Repair Instructions
PAINT PEELING AND/OR RUST AROUND LOCK CYLINDER ON LIFTGATE OR LUGGAGE COMPARTMENT LID
SB45277
Service Bulletin/Repair Instructions
FORD: TRANSMISSION FLUID LEAK FROM CONVERTER HOUSING AREA ON POLICE UTILITY EQUIPPED WITH 6F50/6F55 TRANSMISSION *CN
14R01
Service Bulletin/Repair Instructions
FORD: SOME 2010 TO 2014 FORD TAURUS AND 2013 TO 2014 POLICE INCEPTOR SEDAN VEHICLES MANUFACTURED FROM 2010 TO 2014 ARE NOT INCLUDED IN THE 14S08 LICENSE PLATE LAMP ASSEMBLY REPLACEMENT SAFETY RECALL. *TA