02138
Service Bulletin/Repair Instructions
LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT
Vehicle report
1995 FORD RANGER
Service bulletins
155 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
17254
Service Bulletin/Repair Instructions
CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT
03181
Service Bulletin/Repair Instructions
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
03148
Service Bulletin/Repair Instructions
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
02221
Service Bulletin/Repair Instructions
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
870197
Service Bulletin/Repair Instructions
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
02176
Service Bulletin/Repair Instructions
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
02142
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION AND A 4.0L OHV ENGINE MAY EXHIBIT A NOISE / VIBRATION, NO DRIVE, UNUSUAL NOISE DURING CRANKING OR A NO CRANK CONDITION. *TT
16040
Service Bulletin/Repair Instructions
EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT
15887
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT
0282
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT
01246
Service Bulletin/Repair Instructions
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
01212
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT A LOUD A/C CLUTCH ENGAGEMENT. *TT
01197
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT
01B77
Service Bulletin/Repair Instructions
OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT
01181
Service Bulletin/Repair Instructions
BRAKE SHIFT INTERLOCK.*JB
01186
Service Bulletin/Repair Instructions
INFORMATION ON CLIMATE CONTROL, LOUD A/C CLUTCH CYCLING NOISE.*JB
01156
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
Service Bulletin/Repair Instructions
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
15167
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A LOUD COMPRESSOR CYCLING NOISE. *YH
15198
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT LOUD A/C CLUTCH CYCLING NOISE CONDITION. *JG
01124
Service Bulletin/Repair Instructions
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
0146
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CHATTER OR BINDING CONDITION WHEN OPERATING THE POWER SIDE WINDOWS EITHER IN THE DOWN OR UP MODE. *TT
002310
Service Bulletin/Repair Instructions
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
8164
Service Bulletin/Repair Instructions
INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR
0015
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
13745
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
99235
Service Bulletin/Repair Instructions
DURING EXTREME COLD AMBIENT TEMPERATURES AND UNDER CERTAIN DRIVING CONDITIONS, MOISTURE IN THE CRANKCASE MAY ENTER THE PCV SYSTEM, FREEZE AND CAUSE PRESURE IN THE ENGINE CRANKCASE. THE PCV FITTING IN THE UPPER INTAKE MANIFOLD MAY FREEZE OR THE FRESH AIR LINE MAY BECOME BLOCKED. IT IS ALSO POSSIBLE, BUT LESS LIKELY, THAT ICE MAY BUILD UP ON THE THROTTLE PLATE OR THE THROTTLE BODY AND CAUSE THROTTLE STICKING. *TT
99238
Service Bulletin/Repair Instructions
A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT
13440
Service Bulletin/Repair Instructions
EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT
13505
Service Bulletin/Repair Instructions
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
7353
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
7366
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). *TT
7494
Service Bulletin/Repair Instructions
ALL VEHICLES WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF WHAT THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
99222
Service Bulletin/Repair Instructions
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
13412
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
13423
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL AND CLUTCH ENGAGED. *TT
13426
Service Bulletin/Repair Instructions
EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT
99194
Service Bulletin/Repair Instructions
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
99183
Service Bulletin/Repair Instructions
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
13180
Service Bulletin/Repair Instructions
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
6997
Service Bulletin/Repair Instructions
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
99161
Service Bulletin/Repair Instructions
EXPERIENCING AN AUDIBLE PINGING OR CREAKING (NOT A CLUNKING NOISE) HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE SUCH AS WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE. *TT
99162
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0125 STORED IN MEMORY, AND / OR LACK OF HEAT WITH THE CLIMATE CONTROL. *TT
13118
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
6896
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
99152
Service Bulletin/Repair Instructions
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
6574
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN OCCASIONAL HOOT / MOAN FROM THE IDLE AIR CONTROL (IAC) VALVE. *TT
6603
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN AUDIBLE PINGING OR CREAKING NOISE THAT MAY BE HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE. *TT
99139
Service Bulletin/Repair Instructions
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
99111
Service Bulletin/Repair Instructions
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
99129
Service Bulletin/Repair Instructions
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
12905
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
99-8-15
Service Bulletin/Repair Instructions
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
99816
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
995157
Service Bulletin/Repair Instructions
INFORMATION ON MAINTAINING TIRE PRESSURE. *TT
9943
Service Bulletin/Repair Instructions
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
98246
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
5249
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
98L20
Service Bulletin/Repair Instructions
SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT
982310
Service Bulletin/Repair Instructions
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
12138
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT A CLIMATE CONTROL ISSUE OF LACK OF HEAT. *MJS
985045
Service Bulletin/Repair Instructions
REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT
985085
Service Bulletin/Repair Instructions
SOME VEHICLES WITH POWER WINDOWS MAY EXHIBIT WINDOW CHATTERING OR JERKING MOTION WHEN OPERATING IN THE DOWN MODE. *AK *TT
985178
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CLIMATE CONTROL ISSUE OF LACK OF HEAT. *TT
982010
Service Bulletin/Repair Instructions
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
98-4732
Service Bulletin/Repair Instructions
STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS..
981516
Service Bulletin/Repair Instructions
OUTSIDE REARVIEW MIRROR MANUAL REPLACEMENT.
98158
Service Bulletin/Repair Instructions
THE DRIVER'S AND PASSENGER'S DOOR GLASS CHATTER WHEN OPERATING THE WINDOW IN DOWN MODE.
11761
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 2.3L ENGINES MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP LIGHT WITH DIAGNOSTIC TROUBLE CODE P0340. *TT
4634
Service Bulletin/Repair Instructions
STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
4644
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 2.3L ENGINES MAY EXPERIENCE A MALFUNCTION INDICATOR LIGHT WITH DIAGNOSTIC TROUBLE CODE P0340. *TT
9888
Service Bulletin/Repair Instructions
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
9852
Service Bulletin/Repair Instructions
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
980319
Service Bulletin/Repair Instructions
CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC
980324
Service Bulletin/Repair Instructions
CONCERNS OF COLD ENGINE UPPER KNOCK / TICK. *YC
9811488
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A CTM (CENTRAL TIMER MODULE) MAY EXPERIENCE INTERMITTENT WIPER OPERATION WITHOUT COMMAND; DOME LIGHTS REMAINING ON; OR THE DOOR CHIMES REMAINING ON. *TT
982526
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE VARIOUS CONCERNS SUCH AS INTERMITTENT WINDSHIELD WIPER OPERATION WITHOUT COMMAND, DOME LIGHTS REMAINING ON, AND/OR THE DOOR CHIMES REMAING ON. *YC
9864
Service Bulletin/Repair Instructions
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
985A11
Service Bulletin/Repair Instructions
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
985A12
Service Bulletin/Repair Instructions
RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT
985A13
Service Bulletin/Repair Instructions
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC
985A36
Service Bulletin/Repair Instructions
A GRABBING AND/OR STICKING CONDITION DURING THE FIRST FEW BRAKE APPLICATIONS WHEN THE BRAKES ARE COLD OR IN THE MORNING AFTER AN OVERNIGHT RAIN MAY OCCUR ON SOME VEHICLES. *YC
985A5
Service Bulletin/Repair Instructions
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
9845
Service Bulletin/Repair Instructions
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
983074
Service Bulletin/Repair Instructions
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
9839
Service Bulletin/Repair Instructions
THE DRIVER'S AND/OR PASSENGER DOOR GLASS MAY
98112
Service Bulletin/Repair Instructions
SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT
9814
Service Bulletin/Repair Instructions
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
980320
Service Bulletin/Repair Instructions
GEAR DTC'S AND EXTENDED/DELAYED/ NO SHIFT. *AK
971110972312
Service Bulletin/Repair Instructions
CONCERNS WITH "PINGING" OR "CREAKING" BEING HEARD FROM THE DRIVELINE WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE, OR WHEN ENGAGING THE CLUTCH. *YC
97090297189
Service Bulletin/Repair Instructions
EXPERIENCING A "THUMPING" NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC
BC106029705
Service Bulletin/Repair Instructions
ONLY RANGERS EQUIPPED WITH POWER DOOR LOCKS AND POWER WINDOWS WILL HAVE RIGHT HAND ILLUMINATED ENTRY. *TW
BC2244970501
Service Bulletin/Repair Instructions
ONLY VEHICLES EQUIPPED WITH POWER DOOR LOCKS AND POWER WINDOWS WILL HAVE RIGHT HAND ILLUMINATED ENTRY. *TW
BC2301970501
Service Bulletin/Repair Instructions
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
BC2361970501
Service Bulletin/Repair Instructions
AUTHORIZED WARRANTY PART REPLACEMENT OF BRAKE PADS TO CORRECT EXCESSIVE BRAKE NOISE. *TW
97615
Service Bulletin/Repair Instructions
BRAKES- "SQUEALING" NOISE AND/OR STICKING DURING FIRST FEW BRAKE APPLICATIONS AFTER A RAINFALL AND/OR WHEN BRAKES ARE COLD. *JD
9768
Service Bulletin/Repair Instructions
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
97511
Service Bulletin/Repair Instructions
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
9747
Service Bulletin/Repair Instructions
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
BC3282970206
Service Bulletin/Repair Instructions
GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW
97313
Service Bulletin/Repair Instructions
LAMP- "CHECK ENGINE" MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED- DIAGNOSTIC TROUBLE CODE (DTC) P1405 STORED IN MEMORY- NO DRIVE CONCERNS- VEHICLES WITH 3.0L ENGINE. *JD
BC4244970201
Service Bulletin/Repair Instructions
ELECTRONIC CONTROL MODULES VARY ON VEHICLES BASED ON OPTION CONTENT & HAVE DIFFERENT DIAGNOSTIC CODE RETRIEVAL METHODS. *JD
BC0316972301
Service Bulletin/Repair Instructions
TIRE WEAR- CANNOT ADJUST CAMBER TO SPECS. *JD
BC0324972301
Service Bulletin/Repair Instructions
REAR BRAKES "GRAB" WHEN COLD OR DAMP. *JD
BC1019997230
Service Bulletin/Repair Instructions
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
BC1020697230
Service Bulletin/Repair Instructions
IF DTC P1443 RETURNS AFTER TSB 96-06-08 HAS BEEN PERFORMED, LAY OUT A CLEAN WHITE PIECE OF PAPER ON A FLAT SURFACE, REMOVE THE PURGE FLOW SENSOR, TAP THE CANISTER HOSE PORT SIDE OF THE SENSOR ON THE PAPER AND LOOK FOR PIECES OF CHARCOAL. *JD
BC1022797230
Service Bulletin/Repair Instructions
THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD
BC3363972301
Service Bulletin/Repair Instructions
THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD
BC3382972301
Service Bulletin/Repair Instructions
VEHICLES WITH AN UNUSUAL NEGATIVE CAMBER READING, AND CANNOT BE ADJUSTED TO WITHIN THE PROPER CAMBER SPECIFICATION, CAN BE REPAIRED BY NEW SPRINGS. *JD
BC3450972301
Service Bulletin/Repair Instructions
IF DTC P1443 RETURNS AFTER TSB 96-0608 HAS BEEN PERFORMED, LAY OUT A CLEAN WHITE PIECE OF PAPER ON FLAT SURFACE, REMOVE PURGE FLOW SENSOR, TAP THE CLEAN HOSE PORT SIDE OF THE SENSOR ON THE PAPER AND LOOK FOR PIECES OF CHARCOAL. *JD
BC3485972301
Service Bulletin/Repair Instructions
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
BC0123970201
Service Bulletin/Repair Instructions
DIAGNOSING FOUR WHEEL DRIVE ELECTRONIC SHIFT OPERATION CONCERNS ON 95/96 MODEL YEAR RANGER. *JD
BC0185970201
Service Bulletin/Repair Instructions
SOME VEHICLES MAY NOT BE PUT INTO ALIGNMENT- CAMBER READINGS. *JD
BC0316970201
Service Bulletin/Repair Instructions
TIRE WEAR- CANNOT ADJUST CAMBER TO SPECS. *JD
BC0324970201
Service Bulletin/Repair Instructions
COLD ENGINE KNOCK/TICK NOISE. *JD
BC1013197020
Service Bulletin/Repair Instructions
FOUR WHEEL DIRVE ELECTRONIC SHIFT OPERATION. *JD
BC1015197020
Service Bulletin/Repair Instructions
CLUTCH COVER ADJUSTMENT PROCEDURE PRIOR TO INSTALLATION WAS OMITTED FROM THE SERVICE MANUAL. *JD
962612
Service Bulletin/Repair Instructions
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
962511
Service Bulletin/Repair Instructions
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
962417
Service Bulletin/Repair Instructions
NOISE - PINGING OR CREAKING FROM DRIVELINE WHEN VEHICLE IS PUT INTO GEAR. *TW
96246
Service Bulletin/Repair Instructions
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
96249
Service Bulletin/Repair Instructions
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
BC0407961115
Service Bulletin/Repair Instructions
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW
BC0324961101
Service Bulletin/Repair Instructions
COLD ENGINE KNOCK/TICK NOISE. *TW
BC9714961101
Service Bulletin/Repair Instructions
DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW
BC0678961025
Service Bulletin/Repair Instructions
INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT
BC0692961023
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE UNEXPLAINED MIL LIGHT CODES &/OR IRREGULAR SHIFTING (A4LD). *TT
96221
Service Bulletin/Repair Instructions
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
96222
Service Bulletin/Repair Instructions
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
96223
Service Bulletin/Repair Instructions
LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 -STALL - AFTER STARTING WHEN ENGINE ALLOWED TO SOAK FROM 1-4 HOURS - STICKING IDLE AIR CONTROL (IAC) VALVE. *TW
96225
Service Bulletin/Repair Instructions
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
96226
Service Bulletin/Repair Instructions
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
BC0740961018
Service Bulletin/Repair Instructions
VEHICLES EXPERIENCE CHAFFING ON THE 14401 WIRE HARNESS CAUSING THE ACCESSORY FUSES TO BECOME OPEN (PRIMARILY THE CIGAR FUSE. *TT
BC0741961018
Service Bulletin/Repair Instructions
FOR STALLING CONCERNS, REFLASH THE PCM W/ 96 CALIBRATION (R11 LEVEL). *TT
BC9666961001
Service Bulletin/Repair Instructions
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
96726
Service Bulletin/Repair Instructions
WHEN REPLACING AN INTERNAL WIRING HARNESS ON 4R44E/4R55E TRANSMISSIONS BUILT BEFORE 11/30/95 WITH A NEW HARNESS, THE FLUID PAN MUST BE REPLACED ALSO. FAILURE TO CHANGE OVER OR CONVERT THE FLUID PAN MAY RESULT IN A TRANSMISSION FLUID LEAK OR A DAMAGED WIRING HARNESS. *TT
BC0103960102
Service Bulletin/Repair Instructions
RANGERS W/ 2.3L, FOR ALL ISSUES RELATING TO WATER PUMP LEAKAGE DURING WARRANTY PERIOD, CALL JIM SHOPP ON PAGER 1-800-961-6829 PRIOR TO REPAIR. WILL ADVISE WHETHER PROBLEM RELATES TO PUMP OR THE INLET LINE.
BC0131960102
Service Bulletin/Repair Instructions
4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING. IT IS NOT RECOMMENDED TO USE HEAVIER WEIGHT LUBES IN THESE FRONT AXLES.
95212
Service Bulletin/Repair Instructions
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
951912
Service Bulletin/Repair Instructions
ON TRANSMISSIONS BUILT BEFORE 6/20/95 (FIG 1) AN EXTENDED SHIFT AND A HIGHER ENGINE RPM THAN EXPECTED AND/OR NO SHIFT CONDITION, POSSIBLY ALONG WITH A FLASHING 'O/D OFF' LAMP AND/OR THE DIAGNOSTIC TROUBLE CODES (DTCS) LISTED ABOVE, MAY OCCUR. THIS MAY BE CAUSED BY A DAMAGED INTERMEDIATE AND/OR OVERDRIVE SERVO SEAL.
BC4380950906
Service Bulletin/Repair Instructions
AVAILABILITY OF HIGH ALTITUDE TRANSMISSION. *TW
951617
Service Bulletin/Repair Instructions
LAMP - 'CHECK ENGINE' MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODE (DTC) 1405 STORED IN MEMORY - NO DRIVE CONCERNS-VEHICLES WITH 3.0L ENGINE.*SD
95109
Service Bulletin/Repair Instructions
EXHUAST LEAK OR TICKING NOISE WHILE ACCELERATING. *TW
BC2701950503
Service Bulletin/Repair Instructions
LIGHT CLICKING SENSATION OR LOOSENESS AS THE STEERING WHEEL IS TURNED. *TW
BC2831950401
Service Bulletin/Repair Instructions
THE SPEED CONTROL SWITCH ILLUMINATION MAY FLICKER AND HORN OPERATION MAY BE INTERMITTENT WHEN STEERING WHEEL IS TURNED. *TW
BC2992950401
Service Bulletin/Repair Instructions
VEHICLES MAY HAVE EXHAUST LEAK AT Y-PIPE TO EXHAUST MANIFOLD. *TW
BC4204950401
Service Bulletin/Repair Instructions
SPEED CONTROL SWITCH ILLUMINATION MAY FLICKER AND HORN OPERATION MAY BE INTERMITTENT WHEN STEERING WHEEL IS TURNED DUE TO AN INTERMITTENT GROUND CONCERN. *TW
SFA/94L04
Service Bulletin/Repair Instructions
UNKNOWN
BC3423950201
Service Bulletin/Repair Instructions
VEHICLES MAY HAVE FLASHING O/D OFF INDICATOR LIGHT, CHECK ENGINE LIGHT ON AND/OR IMPROPER TRANSMISSION FUNCTION. *TW
9524
Service Bulletin/Repair Instructions
NEW RADIATOR MANUFACTURING PROCESS/MODIFICATION. *TW
BC0121950103
Service Bulletin/Repair Instructions
FAST BURN PROCESS INTRODUCED TO IMPROVE FUEL ECONOMY CAUSES A LOW FREQUENCY METALLIC NOISE DURING THE FIRST MILE OF OPERATION. *TW
94239
Service Bulletin/Repair Instructions
EXCESSIVE CLUTCH AIR GAP ON FS-10 A/C COMPRESSORS CAN ALLOW THE CLUTCH DISC TO MOVE AWAY FROM THE PULLEY. *TW
942416
Service Bulletin/Repair Instructions
NEW ELECTRONICALLY CONTROLLED TRANSMISSION FOR 1995 EXPLORER AND RANGER. *TW
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.