17777
Service Bulletin/Repair Instructions
REAR LEAF SPRING NOISE. *TT
Vehicle report
1999 FORD SUPER DUTY F SERIES
Service bulletins
259 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
032150
Service Bulletin/Repair Instructions
HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TT
17320
Service Bulletin/Repair Instructions
BROKEN EXHAUST MANIFOLD STUDS. *TT
032129
Service Bulletin/Repair Instructions
SIGNIFICANT CHANGES HAVE BEEN MADE TO THE 7.3L DIT ENGINE EFFECTIVE WITH THE 1998 AND 1999 MODEL YEARS. THE AREAS AFFECTED ARE THE FUEL SYSTEM, HIGH PRESSURE OIL SYSTEM, TURBOCHARGER, AND ENGINE ACCESSORY DRIVE. *TT
032130
Service Bulletin/Repair Instructions
A CACKLING NOISE WITH THE ENGINE WARM AND SLIGHTLY ABOVE IDLE, AND/OR A BUZZING NOISE FROM THE FUEL PRESSURE REGULATOR WITH KEY ON ENGINE OFF (KOEO) DURING FUEL PUMP CYCLING. *TT
032131
Service Bulletin/Repair Instructions
ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT
032133
Service Bulletin/Repair Instructions
SIGNIFICANT 1999 7.3L DIESEL ENGINE CONTENT REVISIONS. *TT
032134
Service Bulletin/Repair Instructions
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE WITH A FALSE DIAGNOSTIC TROUBLE CODE (DTC) P1298 (INJECTOR DRIVE MODULE (IDM) FAILURE). *TT
032135
Service Bulletin/Repair Instructions
ON SOME VEHICLES NOT EQUIPPED WITH CRUISE CONTROL, THE ENGINE MAY IDLE AT THE NORMAL ENGINE RPM BUT LACKS THE COLD ENGINE IDLE KICKER FUNCTION TO RAISE THE ENGINE RPM SIMILAR TO THOSE VEHICLES EQUIPPED WITH CRUISE CONTROL. *TT
032137
Service Bulletin/Repair Instructions
FOR 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PURCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *TT
032138
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH 7.3L DIT ENGINE BUILT AFTER ENGINE SERIAL NUMBER 896812 MAY HAVE A INJECTION CONTROL PRESSURE (ICP) OIL AERATION READING THAT IS HIGHER THAN THE SPECIFICATION. *TT
032139
Service Bulletin/Repair Instructions
7.3L POWERSTROKE DIESEL ENGINE WITH ENGINE SERIAL NUMBER 661894 THROUGH 1311240 MAY EXHIBIT A KNOCK NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. THIS BULLETIN ALSO REPLACES 01146. *TT
032141
Service Bulletin/Repair Instructions
FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER, OR A ROUGH IDLE CONDITION DUE TO FUEL GELLING DURING EXTREME COLD WEATHER OPERATION. *TT
032142
Service Bulletin/Repair Instructions
A LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT BEFORE 11/25/2000 EQUIPPED WITH THE 7.3L DIT ENGINE. *TT
032145
Service Bulletin/Repair Instructions
EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT
032146
Service Bulletin/Repair Instructions
ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT
032149
Service Bulletin/Repair Instructions
A LOSS OF POWER, OIL LEAKS AROUND THE TURBO, AND/OR EXCESSIVE EXHAUST NOISE FROM THE TURBO. *TT
11606
Service Bulletin/Repair Instructions
OUTSIDE AIR TEMPERATURE OPTION OWNER'S GUIDE CORRECTION. FORD SPECIAL SERVICE MESSAGE. *TT
12389
Service Bulletin/Repair Instructions
COLD SHIFT CONCERNS ON VEHICLES EQUIPPED WITH 4R100 AUTOMATIC TRANSMISSIONS. *TT
13621
Service Bulletin/Repair Instructions
IMPROVEMENTS TO MALFUNCTION INDICATOR LAMP (MIL) DIAGNOSTICS. *TT
14248
Service Bulletin/Repair Instructions
FILM OF OIL/DUST AT THE CHARGE AIR COOLER (CAC) HOSE CONNECTIONS. *TT
16480
Service Bulletin/Repair Instructions
DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT
16589
Service Bulletin/Repair Instructions
GRADUAL LOSS OF POWER AT CRUISE. FORD SPECIAL SERVICE MESSAGE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT
16859
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT AFTER 12/7/1998 EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER. 2003 SUPER DUTY F SERIES ALSO INCLUDED. *TT
03205
Service Bulletin/Repair Instructions
NO START/REPEAT STARTER FAILURE OR A STICKING/BINDING IGNITION LOCK CYLINDER, STARTER STAYING ENGAGED AT START UP. ALSO INCLUDES 2003 SUPER DUTY F SERIES. *TT
031410
Service Bulletin/Repair Instructions
TURBO PEDESTAL SEAL OIL LEAK AROUND THE EXHAUST BACK PRESSURE (EBP) ACTUATOR. 2003 SUPER DUTY F SERIES INCLUDED. *TT
03144
Service Bulletin/Repair Instructions
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
03148
Service Bulletin/Repair Instructions
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
03149
Service Bulletin/Repair Instructions
A LOSS OF POWER, OIL LEAKS AROUND THE TURBO, AND/OR EXCESSIVE EXHAUST NOISE FROM THE TURBO. *TT
03112
Service Bulletin/Repair Instructions
ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT. INCLUDING 2003 AND 2004 SUPER DUTY F SERIES. *TT
16924
Service Bulletin/Repair Instructions
SLIGHT PURGE OF GREASE FROM THE HUB BEARING UNIT. THIS GREASE MAY BE NOTED BETWEEN THE HUB UNIT AND THE INBOARD ROTOR FLANGE AND ON THE INBOARD SIDE OF THE BEARING. 1999-2003 MODELS. *TT
16925
Service Bulletin/Repair Instructions
NO ENGAGEMENT OR DISENGAGEMENT OF HUB LOCKS AFTER REPLACEMENT OR SERVICE. TO INCLUDE 2000-2003 EXCURSIONS. *TT
16927
Service Bulletin/Repair Instructions
SEVERE DUTY AIR FILTER KIT DOES NOT FIT - INFORMATION. *TT
0398
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
02194
Service Bulletin/Repair Instructions
DRIVEABILITY-NO START/REPEAT STARTER FAILURE-REPEAT STARTER REPLACEMENT. ELECTRICAL-STICKING OR BINDING IGNITION LOCK CYLINDER BETWEEN START AND RUN. ENGINE-STARTING-STARTER STAYING ENGAGED AT START UP. *MJ
02176
Service Bulletin/Repair Instructions
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
02108
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT. *TT
15888
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FEAD BELT SQUEAL. *TT
15780
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FRONT OR REAR PINION SEAL LEAK. *TT
0245
Service Bulletin/Repair Instructions
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
15686
Service Bulletin/Repair Instructions
CONCERNS OF DIAGNOSTIC TROUBLE CODE P1280 RETRIVED FROMTHE POWER TRAIN CONTROL MODULE (PCM). *TT
0214
Service Bulletin/Repair Instructions
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
01246
Service Bulletin/Repair Instructions
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
15446
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT INCREASED STEERING EFFORTS AT VERY LOW SPEEDS OR WHEN STOPPED WITH THE BRAKES APPLIED. *TT
012113
Service Bulletin/Repair Instructions
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL MODULE (PCM). *TT
01214
Service Bulletin/Repair Instructions
INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES. *TT
01205
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
01181
Service Bulletin/Repair Instructions
BRAKE SHIFT INTERLOCK.*JB
01168
Service Bulletin/Repair Instructions
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *SLC
01156
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
Service Bulletin/Repair Instructions
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
15141
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE THE SEAT AND SEAT BACK MAY LOSE ITS MEMORY POSITION AND NOT LATCH OR LOCK IN THE DESIRED POSITION. *YH
011406
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A POWERSTROKE DIESEL ENGINE MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. *TT
01122
Service Bulletin/Repair Instructions
ON SOME VEHICLES THERE MAY BE AN OIL LEAK FROM THE RIGHT HAND HEAD GASKET AT THE REAR OF THE BLOCK / HEAD JOINT. *TT
15002
Service Bulletin/Repair Instructions
ON SOME VEHICLES, THE SEAT AND SEAT BACK MAY LOSE ITS MEMORY POSITION AND NOT LATCH / LOCK IN THE DESIRED POSITION. *TT
0195
Service Bulletin/Repair Instructions
A CONDITION MAY EXIST WITH LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT BEFORE 11/25/2000 EQUIPPED WITH THE 7.3L DIT ENGINE. THIS MAY BE CAUSED BY A COLLAPSED AIR FILTER ELEMENT OR DEFECTIVE AIR BOX / LID. *TT
14907
Service Bulletin/Repair Instructions
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT
14840
Service Bulletin/Repair Instructions
A SLIGHT PURGE OF GREASE FROM THE FRONT HUB BEARING UNIT THAT MAY BE NOTED BETWEEN THE HUB UNIT AND THE INBOARD ROTOR FLANGE. *TT
0142
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT THE ENGINE OIL SENDING UNIT CONTACTING THE OIL DRIP SHIELD ATTACHED TO THE FRONT AXLE. *TT
0144
Service Bulletin/Repair Instructions
FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER, OR A ROUGH IDLE CONDITION DUE TO FUEL GELLING DURING EXTREME COLD WEATHER OPERATION. *TT
0147
Service Bulletin/Repair Instructions
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
13724
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE AND THE CHARGE AIR COOLER (CAC) MAY EXHIBIT OIL LEAKS AROUND THE CAC TUBE ON THE HOT SIDE OF THE COOLER (DRIVERS SIDE OF THE VHEICLE NEAR THE INTERCOOLER) OR A REPEAT CONCERN WITH THE TUBE BLOWING OFF. *TT
13820
Service Bulletin/Repair Instructions
INFORMATION ON REPROGRAMMING A PCM WITH THE LATEST CALIBRATION ON CERTAIN VEHICLES EQUIPPED WITH A 7.3L DIESEL ENGINE. A NEW CALIBRATION WAS RECENTLY RELEASED TO PROVIDE IMPROVED MIL DIAGNOSTIC AND TO CORRECT A 4R100 TRANSMISSION SURGE AT LIGHT TO MEDIUM THROTTLE. *TT
13927
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES WITH REAR WHEEL ANTI-LOCK BRAKING SYSTEMS (ABS) THAT MAY EXHIBIT AN ABS LAMP ON WITH A STORED DIAGNOSTIC TROUBLE CODE (DTC) B1485 (BRAKE PEDAL POSITION (BPP) SWITCH CIRCUIT MALFUNCTION). *TT
13939
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT BEFORE 01/05/2000 MAY EXHIBIT A POWER STEERING COOLER LEAK DUE TO THE COOLER IMPACTING A SOLID OBJECT. ENGINEERING HAS RELEASED A REVISED COOLER WHICH WILL RELOCATE THE COOLER TO ABOVE THE FRONT BUMPER LINE. *TT
13993
Service Bulletin/Repair Instructions
SUBJECT REGARDING DIAGNOSTICS AND / OR MECHANICAL CONCERNS REGARDING THE NEW VENUTURE TRANSFER CASE. *TT
14743
Service Bulletin/Repair Instructions
INFORMATION ON REAR AXLE PINION SEAL PART USAGE. *TT
14776
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE AND ZF-M6HD 6 SPEED TRANSMISSION MAY EXHIBIT A SLIGHTLY HIGHER IDLE AT COLD TEMPERATURES. *TT
0132
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT STIFF STEERING, WANDERING, OR POOR RETURNABILITY AFTER TURNS. *TT
14652
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT HIGHER THAN NORMAL STEERING EFFORTS WHEN THE VEHICLES IS AT A VERY LOW SPEED OR STOPPED WITH THE BRAKES APPLIED. *TT
14570
Service Bulletin/Repair Instructions
CONCERNS WITH FREEPLAY / STEERING WANDER. *JB
14615
Service Bulletin/Repair Instructions
SQUEAK FROM THE FRONT LEAF SPRING AREA. *JB
00254
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE BUCK, SURGE, OR JERK (ALSO KNOWN AS HITCHING / HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT
00246
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 6.8L ENGINE AND 4R100 TRANSMISSION MAY EXHIBIT GEAR CHANGES THAT TAKE TOO LONG TO COMPLETE AND / OR TRANSMISSION SHIFTS THAT OCCUR TOO EARLY, TOO LATE AND TOO OFTEN. *TT
002310
Service Bulletin/Repair Instructions
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
00235
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A POWERSTROKE DIESEL ENGINE MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. *TT
002305
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH POWERSTROKE DIESEL MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. THIS NOISE MAY SOUND LIKE A ROD KNOCK, BUT IT IS INTERMITTENT AND IT INCREASES IN INTENSITY AS THE ENGINE WARMS UP TO OPERATING TEMPERATURE. *TT
00221
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH POWERSTROKE DIESEL ENGINES AFTER SERIAL NUMBER 0896812 (ENGINE BUILD DATE), MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION.*JB
14365
Service Bulletin/Repair Instructions
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
14184
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3 DIT ENGINE MAY EXHIBIT ENGINE ROUGHNESS, MISSES, BUCK / JERK, HESITATION / STUMBLE, SURGE, LACK OF POWER, VARIOUS IDLE SYMPTOMS, MALFUNCTION INDICATOR LAMP ON, ETC. *TT
0086
Service Bulletin/Repair Instructions
THE 4X4 SYSTEM, PARTICULARLY THE FRONT LOCKING HUBS. *MR
981610
Service Bulletin/Repair Instructions
THE SEAT BACK MAY NOT LATCH/ LOCK IN THE DESIRED POSITION AND REMAIN FOLDED FORWARD OVER THE SEAT CUSHION. YD
981611
Service Bulletin/Repair Instructions
AIR FILTER SATURATED WITH WATER. VEHICLES WITH 7.3L DESEL ENGINE AND BUILT. YD
98165
Service Bulletin/Repair Instructions
EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD
98168
Service Bulletin/Repair Instructions
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
8378
Service Bulletin/Repair Instructions
INFORMATION REGARDING ELECTRONIC CRASH SENSOR (ECS-2) CONFIGURATION. **MR
8488
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FUSE #19 BLOWN, OVERDRIVE CANCEL LIGHT (OCIL) FLASHING AND INSTRUMENT CLUSTER GAUGES INOPERATIVE. *TT
00610
Service Bulletin/Repair Instructions
INFORMATION ON THE 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PRUCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *MJS
13942
Service Bulletin/Repair Instructions
INFORMATION USED WHEN PERFORMING THE AIR CONDITIONER SYSTEM RECHARGE SERVICE ON CERTAIN VEHICLES. *TT
13989
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE ACCURACY OF THE AVERAGE FUEL ECONOMY AND FUEL RANGE DISPLAYED BY THE OVERHEAD TRIP COMPUTER. *TT
8245
Service Bulletin/Repair Instructions
SOME MAY EXHIBIT AN ANTI-LOCK BRAKE LAMP ILLUMINTED AND A B1845 STORED. *TT
8265
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT BEFORE 01/05/00 MAY EXHIBIT A POWER STEERING COOLER LEAK DUE TO THE COOLER IMPACTING A SOLID OBJECT. *TT
8268
Service Bulletin/Repair Instructions
INFORMATION ON PERFORMING AIR CONDITIONER SYSTEM RECHARGE SERVICE. *TT
8360
Service Bulletin/Repair Instructions
INFORMATION ON NORMALLY OCCURRING INTERMITTENT TRANSFER CASE BINDUP. *TT
8374
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH THE ZF 5 SPEED TRANSMISSION MAY EXHIBIT A SQUEAK NOISE FROM THE CLUTCH SYSTEM WHEN THE CLUTCH IS DEPRESSED AND RELEASED. *TT
8375
Service Bulletin/Repair Instructions
SUBJECT REGARDING THE ACCURACY OF THE AVERAGE FUEL ECONOMY AND FUEL RANGE. *TT
8379
Service Bulletin/Repair Instructions
A TECHNICAL ASSISTANCE HELPLINE HAS BEEN ESTABLISHED TO HELP WITH DIAGNOSTICS AND / OR MECHANICAL CONCERNS WITH THE NEW VENTURE TRANSFER CASE ON CERTAIN VEHICLES. *TT
0038
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
13859
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASE MAY EXHIBIT FRONT HUBS THAT WILL NOT UNLOCK / LOCK WITH MODE SWITCH; NOISE FROM THE FRONT AXLE WHILE IN 2 WHEEL DRIVE MODE, AIR CONDITIONING SWITCHING TO DEFROST WHEN SHIFTING INTO OR OUT OF 4 WHEEL DRIVE MODE. *TT
13860
Service Bulletin/Repair Instructions
RECENT REPORTS INDICATE DIFFICULTY LOCATING THE ELECTRONIC SHIFT ON THE FLY TRANSFER CASE RELAYS FOR CERTAIN VEHICLES. *TT
13870
Service Bulletin/Repair Instructions
CONCERNS WITH A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT
8046
Service Bulletin/Repair Instructions
INFORMATION ON REPROGRAMMING THE PCM WITH THE LATEST CALIBRATION. *TT
8120
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASE MAY EXHIBIT ONE OR MORE OF THE FOLLOWING CONDITIONS: FRONT HUBS WILL NOT UNLOCK / LOCK WITH MODE SWITCH, NOISE FROM THE FRONT AXLE WHILE DRIVING IN 2 WHEEL DRIVE MODE, AIR CONDITIONING SWITCHING TO DEFROST WHEN SHIFTING INTO OR OUT OF 4 WHEEL DRIVE MODE. *TT
8121
Service Bulletin/Repair Instructions
SUBJECT REGARDING TRANSFER CASE SHIFT RELAY LOCATION. *TT
8138
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT
0022
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE PARTICLE CONTAMINANTS, FROM PRIOR TRANSMISSIION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IF NOT PROPERLY FLUSHED. *MJS
0015
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
0016
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE FRONT STABILITY BAR BREAKING OFF, VEHICLES BUILT FROM 1/1/98. *MJS
13654
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A SLOW RELEASE OF THE HUBS, AT TIMES, WHICH MAY BE REGARDED AS NOT NORMAL BY THE OPERATOR. *MJS
13742
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EQUIPPED WITH 7.3L DIESEL ENGINE, OPERATING IN COLD CONDITIONS MAY EXHIBIT A GRADUAL LOSS OF POWER AT CRUISE. *MJS
7889
Service Bulletin/Repair Instructions
THE F-SERIES EQUIPPED WITH 7.3L DIT ENGINE AND THE CHARGE AIR COOLER (CAC) MAY EXHIBIT OIL LEAKS AROUND THE CAC TUBE ON THE HOT SIDE OF THE COOLER (DRIVERS SIDE OF THE VEHICLE NEAR THE INTERCOOLER) OR A REPEAT CONCERN WITH THE TUBE BLOWING OFF.
996889
Service Bulletin/Repair Instructions
INFORMATION ON 7.3L DIT VEHICLES EXHIBITING AN INTERMITTENT ENGINE KNOCK WHICH MAY BE PERCEIVED AS A ROD KNOCK. *TT
99246
Service Bulletin/Repair Instructions
VEHICLES BUILT THROUGH 11/29/1999 MAY EXPERIENCE A THUMPTING NOISE FROM THE AIR CONDITIONER SYSTEM DURING COLD ENGINE STARTUP. *TT
99232
Service Bulletin/Repair Instructions
SUBJECT REGARDING INCREASING FRONT AND / OR REAR GROSS AXLE WEIGHT RATINGS (GAWR). *TT
99236
Service Bulletin/Repair Instructions
SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT
99242
Service Bulletin/Repair Instructions
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
13439
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT AFTER 12/7/1998 EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER. *TT
13456
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT BRAKE VIBRATION OR SHUDDER WHILE BRAKING. ENGINEERING HAS RELEASED NEW BRAKE PAD WHICH IS EQUIPPED WITH A V-SPRING. *TT
13488
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT
13500
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L ENGINES MAY EXHIBIT AN INOPERATIVE VACUUM PUMP. *TT
13505
Service Bulletin/Repair Instructions
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
13548
Service Bulletin/Repair Instructions
INFORMATION ON THE IDLE KICKER FEATURE, WHICH UNDER CONDITIONS WILL AUTOMATICALLY ELEVATE THE IDLE SPEED AFTER 130 SECONDS OF IDLING AT COLD TEMPERATURES. *TT
13567
Service Bulletin/Repair Instructions
EXHIBITING ELECTRONC SHIFT ON THE FLY (ESOF) AND / OR RKE MALFUNCTION AFTER REPLACING A GEM DUE TO AN INCORRECT LEVEL GEM BEING INSTALLED. *TT
7353
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
7432
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT BRAKE VIBRATION OR SHUDDER WHILE BRAKING. *TT
7456
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A PULL TO THE LEFT CONDITION WHILE BRAKING. *TT
7475
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 73L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT
7488
Service Bulletin/Repair Instructions
SOME CUSTOMERS MAY COMMENT ABOUT THE CLIMATE CONTROL SYSTEM DEFAULTING TO DEFROST MODE AND / OR NO AIR DISTRIBUTION CONTROL. *TT
7529
Service Bulletin/Repair Instructions
SUBJECT REGARDING 5TH WHEEL LOWERING INFORMATION FOR VEHICLES BUILT AFTER 2/14/1999. *TT
99222
Service Bulletin/Repair Instructions
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
7127
Service Bulletin/Repair Instructions
SOME OPERATORS MAY REPORT THAT THE 4X4 SYSTEM IS STUCK IN 4-LOW. *TT
7149
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITHOUT POWER WINDOWS OR LOCKS, MAY EXHIBIT A MALFUNCTION INDICATOR LAMP, ERRATIC AUTOMATIC TRANSMISSION SHIFTING, DIAGNOSTIC TROUBLE CODE P0500 STORED IN MEMORY. *TT
99194
Service Bulletin/Repair Instructions
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
991810
Service Bulletin/Repair Instructions
A CONCERN WITH HARD SHIFTING WHEN VEHICLE IS CLOD OR SHIFT LEVER MAY BE BROKEN / BENT. *TT
99182
Service Bulletin/Repair Instructions
ON SOME VEHICLES NOT EQUIPPED WITH CRUISE CONTROL, THE ENGINE'S IDLE SPEED MAY BE TOO LOW WHEN ENGINE IS COLD. *TT
99187
Service Bulletin/Repair Instructions
EXPERIENCING A SQUAWKING NOISE WHILE IN REVERSE BACKING UP A SLIGHT GRADE AND / OR WHILE APPLYING THE BRAKES. *TT
01-SEP-99
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE OVERHEAD TRIP COMPUTER APPEARING TO HAVE STUCK DISPLAYS OR A DISPLAY NOT UPDATING QUICKLY. *TT
13195
Service Bulletin/Repair Instructions
INFORMATION REGARDING NEW CLUTCH AVAILABLE. *MJS
13206
Service Bulletin/Repair Instructions
INFORMATION REGARDING ANNOUNCING AVAILABILITY OF NEW CLUTCH RELEASE BEARING. *MJS
13211
Service Bulletin/Repair Instructions
INFORMATION REGARDING THUMP NOISE IN A/C AFTER START-UP. *MJS
13213
Service Bulletin/Repair Instructions
INFORMATION REGARDING RADIO LIGHTS AND DISPLAY FLICKER/FLASH WITH HEADLIGHTS ON. *MJS
13215
Service Bulletin/Repair Instructions
INFORMATION REGARDING FUEL CACKLE. *MJS
13216
Service Bulletin/Repair Instructions
INFORMATION REGARDING FRONT SWAY BAR BRACKET. *MJS
13237
Service Bulletin/Repair Instructions
INFORMATION REGARDING ANNOUNCEMENT OF NEW CLUTCH AVAILABILITY. *MJS
13245
Service Bulletin/Repair Instructions
INFORMATION REGARDING PROCEDURE FOR SHIFTING OUT OF 4 LOW. *MJS
13255
Service Bulletin/Repair Instructions
INFORMATION REGARDING VEHICLE PULLING LEFT DURING HARD BRAKING. *MJS
13277
Service Bulletin/Repair Instructions
SOME VEHICLES WITHOUT POWER WINDOWS OR LOCKS, BUILT FROM 1/1/1998 THROUGH 9/22/1998 MAY EXHIBIT ONE OR ALL OF THE FOLLOWING CONCERNS INTERMITTENTLY: MIL ON, ERRATIC AUTOMATIC TRANSMISSION SHIFTING, & DTC P0500 STORED IN MEMORY. *TT
6910
Service Bulletin/Repair Instructions
VEHICLES BUILT AFTER 5/19/1999 WITH THE 7.3L DIT WITH A ENGINE SERIAL # GREATER THAN 1039780 NOW HAVE A FILTER SCREEN ADDED TO THE HIGH PRESSURE OIL RESERVOIR. *TT
7007
Service Bulletin/Repair Instructions
INFORMATION REGARDING ANNOUNCEMENT OF NEW CLUTCH AVAILABLE. *MJS
7025
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE AVAILABILITY OF NEW CLUTCH RELEASE BEARING. *MJS
7075
Service Bulletin/Repair Instructions
INFORMATION REGARDING RADIO LIGHTS AND DISPLAY FLICKER/FLASH WITH HEADLIGHTS ON. *MJS
7077
Service Bulletin/Repair Instructions
INFORMATION REGARDING FRONT SWAY BAR BRACKET. *MJS
99164
Service Bulletin/Repair Instructions
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT
99169
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NO 3-4 UPSHIFT, OR A 3-4 / 4-3 SHIFT HUNT ONLY WHILE THE CRUISE CONTROL IS IN USE. *TT
13033
Service Bulletin/Repair Instructions
EXPERIENCING CONDENSATION LEAKS ON THE PASSENGER FLOOR COMING FROM THE FLOOR DUCT OR HEATER CORE SEAL. *TT
13044
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH DUAL REAR WHEELS (DRW) MAY EXHIBIT ERRATIC AUTOMATIC TRANSMISSION SHIFTING, ERRATIC SPEEDOMETER OPERATION AND CHECK ENGINE LIGHT AND DIAGNOSTIC TROUBLE CODE P0500 STORED IN MEMORY. *TT
13114
Service Bulletin/Repair Instructions
SUBJECT REGARDING MEDIUM TRUCKS EQUIPPED WITH 7.3L DIT EXHIBITING FUEL CACKLE. *TT
13116
Service Bulletin/Repair Instructions
SOME MEDIUM TRUCKS EQUIPPED WITH 7.3L DIT MAY EXHIBIT AN INTERMITTENT ENGINE KNOCK PERCEIVED TO BE FUEL CACKLE. *TT
13161
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH THE OVERHEAD TRIP COMPUTER MAY APPEAR TO HAVE STUCK DISPLAYS OR A DISPLAY NOT UPDATING QUICKLY. *TT
9913138
Service Bulletin/Repair Instructions
INFORMATION ON REPLACING AND REMOVING THE GENERIC ELECTRONIC MODULE (GEM). *TT
9913142
Service Bulletin/Repair Instructions
INFORMATION ON ALL VEHICLES BUILT AFTER 5/19/99 EQUIPPED WITH THE 7.3L DIT WITH A ENGINE SERIAL # GREATER THAN 1039780 NOW HAVE A FILTER SCREEN ADDED TO THE HIGH PRESSURE OIL RESERVOIR. *TT
996750
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT CONDENSATION LEAKS ON THE PASSENGER FLOOR COMING FROM THE FLOOR DUCT OR HEATER CORE SEAL. *TT
996768
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES BUILT FROM 2/22/99 THROUGH 7/3/99 EQUIPPED WITH DUAL REAR WHEELS (DRW) EXHIBITING ERRATIC AUTOMATIC TRANSMISSION SHIFTING, ERRATIC SPEEDOMETER OPERATION AND CHECK ENGINE LIGHT 'ON' AND DIAGNOSTIC TROUBLE CODE P0500 STORED IN MEMORY. *TT
99152
Service Bulletin/Repair Instructions
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
99147
Service Bulletin/Repair Instructions
INFORMATION ON USING THE SERVICE BAY TECHNICAL SYSTEM (SBTS) AND NEW GENERATION STAR (NGS) TESTER, AND TO UPDATE THE POWERTRAIN CONTROL MODULE (PCM) INFORMATION CHARTS. *TT
6690
Service Bulletin/Repair Instructions
SOME TRUCKS EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT SOME REDUCED POWER STEERING ASSIST UNDER HARD BRAKING. *TT
12980
Service Bulletin/Repair Instructions
SOME VEHCLES BUILT FROM JOB 1 TO 5/5/1999 MAY EXHIBIT A SQUEAKING NOISE EMANATING FROM THE FRONT SPRINGS. *TT
12984
Service Bulletin/Repair Instructions
EXHIBITING A SQUEAL TYPE NOISE FROM THE FRONT AXLE AREA. *TT
12988
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE A PULL UNDER HARD BRAKING. *TT
12989
Service Bulletin/Repair Instructions
SUBJECT REGARDING REQUEST FOR FIELD INPUT TO ENGINEERING FOR VEHICLES EXHIBITING A LACK OF ON-CENTER STEERING FEEL AND / OR STEERING WANDER, OR A CONSTANT PULL TO LEFT OR RIGHT. *TT
12995
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT SOME REDUCED POWER STEERING ASSIST UNDER HARD BRAKING. *TT
6575
Service Bulletin/Repair Instructions
SUBJECT REGARDING REMOVAL OF THE REDUNDANT FUEL CLIP. *TT
6578
Service Bulletin/Repair Instructions
SUBJECT REGARDING 5TH WHEEL LOWERING INFORMATION FOR VEHICLES BUILT AFTER 2/14/99. *TT
6581
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH EITHER DANA 80 OR S135 AXLE MAY EXHIBIT FLUID LEAKAGE FROM THE AXLE VENT TUBE DUE TO FLUID OVERFILL. *TT
6650
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT FROM JOB 1 TO 5/5/1999 MAY EXHIBIT A SQUEAKING NOISE EMANATING FROM THE FRONT SPRINGS. *TT
6662
Service Bulletin/Repair Instructions
SOME TRUCKS MAY EXHIBIT A SQUEAL TYPE NOISE FROM THE FRONT AXLE AREA. *TT
6684
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A LACK OF ON-CENTER STEERING FEEL AND / OR STEERING WANDER, OR A CONSTANT PULL TO LEFT OR RIGHT. *TT
99139
Service Bulletin/Repair Instructions
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
99111
Service Bulletin/Repair Instructions
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
991210
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
991212
Service Bulletin/Repair Instructions
INFORMATION REGARDING NEW DESIGN FRONT ROTORS AND HUBS SERVICE TIPS. *TT
99129
Service Bulletin/Repair Instructions
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
12812
Service Bulletin/Repair Instructions
EXHIBITING A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE (DTC) STORED. *TT
12855
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER. *TT
12856
Service Bulletin/Repair Instructions
INFORMATION ON TORQUING OF TRACKBAR WHEN PERFORMING ALIGNMENT. *TT
12859
Service Bulletin/Repair Instructions
SUBJECT REGARDING TRANSFER CASE ASSISTANCE - NEW VENTURE GEAR HOTLINE. *TT
12875
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A DISCOLORATION ON THE A-PILLAR OF THE CAB BETWEEN THE DOOR ON THE FRONT SEAL. *TT
12876
Service Bulletin/Repair Instructions
SUBJECT REGARDING ACCELERATOR PEDAL REPLACEMENT FOR VEHICLES EXHIBITING A SURGE DURING CRUISE AT HI-WAY SPEEDS. *TT
12883
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION TRANSFER CASE MAY DEVELOP A NEUTRALIZATION CONDITION OF THE TRANSFER CASE. *TT
12884
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A SQUEAKING NOISE EMANATING FROM THE FRONT SPRINGS. *TT
6324
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A POWERTRAIN MOAN AROUND 2200 RPM. *TT
6397
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LAMP ILLUMINATION, AND HAVE A P0500 DIAGNOSTIC TROUBLE CODE STORED IN MEMORY. *T
6449
Service Bulletin/Repair Instructions
EXPERIENCING HOOT OR HOWL NOISE FROM TURBOCHARGER. *TT
6451
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FLOORPAN VIBRATION DURING PART-THROTTLE ACCELERATION. *TT
6470
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A DISCOLORATION ON THE A-PILLAR OF THE CAB BETWEEN THE DOOR ON THE FRONT SEAL. *TT
6471
Service Bulletin/Repair Instructions
INFORMATION REGARDING ACCELERATOR PEDAL REPLACEMENT. *TT
6495
Service Bulletin/Repair Instructions
SOME VEHICLES MAY DEVELOP A NEUTRALIZATION CONDITION OF THE TRANSFER CASE. *TT
6496
Service Bulletin/Repair Instructions
EXHIBITING A FRONT SPRING PAD SQUEAK. *TT
99132
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH A FALSE DIAGNOSTIC TROUBLE CODE (DTC) P1298 (INJECTOR DRIVE MODULE (IDM) FAILURE). *TT
99-8-15
Service Bulletin/Repair Instructions
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
9981
Service Bulletin/Repair Instructions
EXPERIENCING A SHIFT FLARE (RISE IN ENGINE RPM) DURING 2-3 AND / OR 3-4 UPSHIFT. *TT
99816
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
12748
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH REAR WHEEL ANTI-LOCK BRAKES MAY EXHIBIT AN ABS LAMP ON AND DIAGNOSTIC TROUBLE CODE C1115. *TT
12754
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONCERN OF A/C BLOWS OUT DEFROST NOZZLE ONLY. *TT
13476
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A PULL TO THE LEFT WHILE BRAKING CONDITION. *TT
6162
Service Bulletin/Repair Instructions
EXPERIENCING THUMP NOISE IN AIR CONDITIONER (A/C) AFTER START-UP. *TT
6291
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON AND DIAGNOSTIC TROUBLE CODE (DTC) C1115). *TT
6294
Service Bulletin/Repair Instructions
SUBJECT REGARDING THE A/C BLOWING OUT DEFROST NOZZLE ONLY. *TT
996034
Service Bulletin/Repair Instructions
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
996101
Service Bulletin/Repair Instructions
AWARENESS MESSAGE REGARDING NEW DIESEL INJECTOR. *TT
996104
Service Bulletin/Repair Instructions
CONDITIONS WITH NORMALLY OCCURING INTERMITTENT TRANSFER CASE BINDUP. *TT
996109
Service Bulletin/Repair Instructions
INFORMATION ON WINDSHIELD REPAIRS. *TT
99S09
Service Bulletin/Repair Instructions
RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT. *TT
12509
Service Bulletin/Repair Instructions
7.3L DIT OIL FITER TORQUE SPECIFICATION. *TT
12540
Service Bulletin/Repair Instructions
DON NOT PERFORM TSB 98-17-02 IF BUILT AFTER 2/13/1999. *TT
12544
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT DIESEL ENGINE MAY EXHIBIT A 1-2 MPH SPEED VARIATION (SURGE / HITCH) AT CRUISE AND / OR WHEN THE SPEED CONTROL IS ENGAGED. *TT
12550
Service Bulletin/Repair Instructions
SUBJECT ON ANTI-LOCK BRAKE SYSTEM (ABS) LAMP STRATEGY CHANGE.
12555
Service Bulletin/Repair Instructions
EXPERIENCING A SQUEALING NOISE FROM THE FRONT AXLE. *TT
12573
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE AUDIO SYSTEM SELECTIVE LIGHTING FEATURE. *TT
12618
Service Bulletin/Repair Instructions
SUBJECT REGARDING RIDE HEIGHT PRODUCTION CHANGE. *TT
5811
Service Bulletin/Repair Instructions
INFORMATION ON OIL FILTER TORQUE SPECIFICATION. *TT
5868
Service Bulletin/Repair Instructions
DO NOT PERFORM TSB 98-17-02 (REAR OF VEHICLE IS TOO HIGH - 5TH WHEEL AND GOOSE NECK APPLICATIONS - 4X4 VEHICLES) ON VEHICLES BUILT AFTER 2/13/1999. *TT
5903
Service Bulletin/Repair Instructions
VEHICLE EXHIBITING A 1-2 MPH SPEED VARIATION (SURGE / HITCH) AT CRUISE AND / OR WHEN THE SPEED CONTROL IS ENGAGED. *TT
6012
Service Bulletin/Repair Instructions
PRODUCTION CHANGE TO LOWER REAR RIDE HEIGHT. *TT
98203
Service Bulletin/Repair Instructions
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
9946
Service Bulletin/Repair Instructions
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
98259
Service Bulletin/Repair Instructions
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
98244
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A
98246
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
5223
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DIESEN ENGINE AND 4R100 TRANSMISSION MAY EXHIBIT A RATTLE / SCRAPPING NOISE FROM THE BELL HOUSING AREA OF THE CASE. *TT
5261
Service Bulletin/Repair Instructions
BRIEF DIAGNOSTIC INFORMATION FOR VEHICLES WITH 7.3L DIT DIESEL EXHIBITING ROUGH IDLE. *TT
98238
Service Bulletin/Repair Instructions
CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC
98224
Service Bulletin/Repair Instructions
A NOISE FROM HYDRO-MAX BRAKE BOOSTER ASSEMBLY- MOTORHOME CHASSIS VEHICLES.
12143
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 4R1000 TRANSMISSION MAY EXHIBIT A CONCERN OF FUSE #19 BLOWN, OVERDRIVE CANCEL LIGHT (OCIL) FLASHING AND INSTRUMENT CLUSTER GAUGES INOPERATIVE. *MJS
12144
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE 1999 SCHEDULED MAINTENANCE GUIDE FOR ANY LIGHT TRUCK, SPORT UTILITY OR VAN EQUIPPED WITH A 4R100 TRANSMISSION NORMAL MAINTENANCE SCHEDULE, IS NOT CORRECT. *MJS
12158
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A DUAL MEDIA RADIO MAY EXHIBIT AN INTERMITTENT OR INOPERATIVE REAR SPEAKER (GENERALLY THE RIGHT SIDE) CAUSING BY A DUAL FAULT CONDITION. *MJS
12166
Service Bulletin/Repair Instructions
INFORMATION REGARDING ANTI-LOCK LIGHT ON REPAIR (H19 WARRANTY CLAIM), WHAT SHOULD BE INCLUDED IN THE CLAIM. *MJS
12188
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DEISEL ENGINE AND 4R100 TRANSMISSION MAY EXHIBIT A RATTLE/SCRAPPING NOISE FROM THE BELLHOUSING AREA OF THE CASE. *MJS
982117
Service Bulletin/Repair Instructions
A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC
982120
Service Bulletin/Repair Instructions
STEERING WHEEL ALIGNMENT- VEHICLES WITH MOTORHOME CHASSIS.
985054
Service Bulletin/Repair Instructions
REPEAT / REVISED MESSAGE REGARDING ROUGH IDLE. *TT
985198
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE ANTI-LOCK LIGHT ON REPAIR (H-19 WARRANTY CLAIM). *MJS
982010
Service Bulletin/Repair Instructions
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
982019
Service Bulletin/Repair Instructions
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC
98205
Service Bulletin/Repair Instructions
EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC
98209
Service Bulletin/Repair Instructions
A " TICKING " NOISE ON INITIAL STARTUP WITH SHIFT SELECTOR IN " P " OR " N " POSITION MAY OCCUR ON SOME VEHICLES. *YC
98810
Service Bulletin/Repair Instructions
SOME CUSTOMERS MAY REQUIRE A HEAVY DUTY 7-WAY TRAILER WIRING CONNECTOR SYSTEM WHEN THE VEHICLE IS EQUIPPED WITH A 4-WAY CONNECTOR. *YC
9888
Service Bulletin/Repair Instructions
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
9852
Service Bulletin/Repair Instructions
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
11503
Service Bulletin/Repair Instructions
A TEMPORARY TECHNICAL ASSISTANCE HOTLINE HAS BEEN ESTABLISHED TO HELP WITH DIAGNOSTICS AND / OR MECHANICAL CONCERNS WITH THE NEW VENTURE TRANSFER CASE ON CERTAIN TRUCKS. *TT
11506
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON AND POSSIBLE CODES 1933 AND / OR 1935. *TT
11513
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES WITH DOOR COURTESY LIGHTS. *TT
11521
Service Bulletin/Repair Instructions
EXHIBITING CONCERNS WITH REAR SEAT BACK OPERATION WHEN TRYING TO ACCESS OBJECTS BEHIND THE REAR SEAT. *TT
11522
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DI MAY EXHIBIT A GEAR ROLLOVER TYPE NOISE FROM THE ZF 6 SPEED MANUAL TRANSMISSION DURING SLOW SPEED OPERATION (PARKING LOT MANEUVERS) IN 1ST OR 2ND GEAR. *TT
9864
Service Bulletin/Repair Instructions
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
98422
Service Bulletin/Repair Instructions
SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS. *YC
9844
Service Bulletin/Repair Instructions
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
9845
Service Bulletin/Repair Instructions
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.