Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
16-0065
For 1999-2003 Windstar vehicles Safety Recall 11S16 has been issued for vehicles that are operated in high corrosion areas for an extended period, where a front subframe lower control arm (LCA) rear attaching flange or rear body mount could separate from the vehicle subframe. Separation of one LCA attachment or both rear body mounts may result in a loss of vehicle directional control, increasing the risk of a crash.
03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
16987
SLIGHT AMOUNT OF FLUID RESIDUE ON THE OUTSIDE OF THE REAR WHEEL CYLINDER DUST BOOT ON VEHICLES WITH REAR DRUM BRAKES. *TT
02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
02132
GRUNT / POPPING NOISE COMING FROM THE FRONT SUSPENSION AT SPEEDS BELOW 20 MPH WHEN TURNING. *TT
15767
SUBJECT REGARDING POWER STEERING LINE PART ORDERING INFORMATION. *TT
15682
EXHIBITING INTERMITTENT ANTI-SKID BRAKE SYSTEM AND / OR RED BRAKE LAMP ON AT TIMES WHILE DRIVING. *TT
15719
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
01181
BRAKE SHIFT INTERLOCK.*JB
01171
TRANSAXLE - AX4S - REPLACEMENT APPLICATION CHART - WINDSTAR VEHICLES ONLY. *NLM
01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
011701
INFORMATION REGARDING REPLACEMENT APPLICATION CHART. *ET
01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
14811
INFORMATION ON ADDITIONAL PARTS REQUIRED WHEN REPLACING TRANSFER CASE ON VEHICLES EQUIPPPED WITH AX4S TRANSAXLE. *TT
14773
INFORMATION ON INDEXING ORANGE DOT ON TORQUE CONVERTER TO FLEXPLATE. *TT
14656
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
00M10
INFORMATION REGARDING ENGINE REPLACEMENTS WARRANTY EXTENSION PROGRAM. *YH
00M09
INFORMATION REGARDING PREMATURE FAILURE OF HEAD GASKETS. *JB
14222
CONCERNS WITH SUBFRAME CLUNK ON ACCELERATION / DECELERATION FROM FRONT OF VEHICLE. *TT
13931
SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT
8249
SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT
0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
607465
CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND OR BINDING BLEND DOORS ON SOME VEHICLES. *TT
99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
99184
SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT
13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
9913073
CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND / OR BINDING BLEND DOORS. *TT
996735
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT
99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
13024
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT
99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
12808
SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO DTC (DIAGNOSTIC TROUBLE CODE). *TT
6392
SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO (DTC) DIAGNOSTIC TROUBLE CODE. *TT
99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
12559
CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT
12616
INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT
982511
SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC
98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
12244
SOME VEHICLES WITH 3.8L ENGINES MAY EXHIBIT A HESITATION ON ACCELERATION AFTER CAMSHAFT POSITION SENSOR (CMP) INSTALLATION. *TT
5312
CONCERNS WITH HESITATION ON ACCELERATION AFTER CAMSHAFT POSITION SENSOR (CMP) INSTALLATION. *TT
98L20
SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT
982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
12114
SOME VEHICLES MAY EXHIBIT A FRONT END GRIND/CRUNCH NOISE DURING A SLOW SPEED TURN. *MJS
12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
985020
SOME VEHICLES BUILT THROUGH 9/8/97 MAY EXHIBIT A CONDITION OF MULTIPLE DIAGOSTIC TROUBLE CODES. THIS MAY BE CAUSED BY BRAKE FLUID AND WATER CONTAMINATION OF CIRCUIT 361 AND CONNECTOR C102 UNDER THE MASTER CYLINDER. *AK
985086
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN DESCRIBED AS AN AIR CONDITIONER HISS NOISE. *TT
985137
SOME VEHICLES MAY EXHIBIT A FRONT END GRIND / CRUNCH NOISE DURING A SLOW SPEED TURN. *TT
982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
982011
CONCERNS OF WEBBING TWISTS OR BINDS ON INTEGRATED CHILD SAFETY SEAT (ICS) BELT. *YC
11505
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
97120897251
THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY SLIP MOMENTARILY IN WET CONDITIONS CAUSING A REDUCTION IN POWER STEERING ASSIST OR THE GENERATOR LAMP. *YC
98M01
PREMATURE FAILURE OF ENGINE HEAD GASKETS MAY OCCUR. THIS CONDITION MAY RESULT IN ENGINE COOLANT LEAKAGE, WHICH, IF NOT DETECTED OR IF IGNORED, WILL CAUSE ENGINE OVERHEATING, OR IN EXTREME CASES, COULD CAUSE ENGINE FAILURE IF OVERHEAT CONDITION IS IGNORED. *AK
9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
11474
SOME MODEL YEAR VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *TT
9811484
SOME HIGH MILEAGE VEHICLE MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *TT
982465
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEEZING TEMPERATURES. *YC
982512
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *YC
982535
EXHIBITING A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *YC
982675
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC
982677
SOME VEHICLES MAY EXHIBIT A HIGH PITCH WHISTLE FROM THE HEATER CORE HOUSING CASE. *YC
9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
985A13
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC
985A28
SOME VEHICLES EXPERIENCE THE PARKING BRAKE MAY NOT RELEASE. *YC
985A31
A GRINDING OR METAL-TO-METAL NOISE MAY BE HEARD FROM THE REAR BRAKES DURING BRAKING ON SOME VEHICLES. *TT
985A47
SOME VEHICLES MAY EXHIBIT A BRAKE MALFUNCTION INDICATOR LAMP ILLUMINATED IMMEDIATELY AFTER START-UP AND AN ABS CODE 1226 MAY BE STORED IN MEMORY. *TT
985A48
ON SOME VEHICLES THE ANTI-LOCK BRAKE SYSTEM (ABS) PUMP MOTOR MAY RUN WHILE APPLYING THE BRAKE WHEN TURNING AND DRIVING OVER A BUMP. *TT
985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
985A51
ON SOME VEHICLES REPEAT REPAIRS MAY BE MADE TO 4-WHEEL ANTI-LOCK BRAKING SYSTEMS (4WABS) DUE TO MISDIAGNOSIS OF 4WABS CONCERNS WHICH MAY RESULT IN REPLACEMENT OF FUNCTIONAL COMPONENTS. *TT
98515
SOME VEHICLES MAY EXHIBIT A SQUEAKING, RATTLING, CHIRPING, TICKING AND / OR BUZZING NOISE HEARD FROM THE INSTRUMENT PANEL AREA. *YC
9855
WET CARPET AND/OR HEADLINER IN CARGO AREA. *YC
98416
EXPERIENCING A GRINDING NOISE OR INOPERATIVE DOOR LOCK MAY OCCUR WHEN CYCLING THE POWER FRONT DOOR LOCKS ON SOME VEHICLES. *TT
9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
9849
CONCERNS WITH COOLANT MAY LEAK FROM THE HEAD GASKETS AND / OR THE VEHICLE MAY OVERHEAT. *YC
983094
SOME VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT
983303
CONCERNS OF BROKEN AND OR BINDING BLEND DOOR. *TT
9811329
INFORMATION REGARDING THE THE AVAILABILITY OF THE REVISED HEADGASKET FOR COOLANT LOSS CONDITIONS ON SOME ENGINES. *TT
9811349
VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT
98125
VEHICLE MAY EXHIBIT A "WHISTLING" NOISE HEARD FROM THE A/C PLENUM. *TT
9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
98-0316
CONCERNS WITH SLOW FUEL FILL, DISTORTED FUEL TANK, FUEL GAGE ERRATIC, FUEL ODOR. *TT
980304
INTERMITTENT NO FORWARD ENGAGEMENT WITH OR WITHOUT DTC P1784 ACTION. *AK
97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
97111097237
CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC
BC105909705
INSTRUCTIONS ON HOW TO IDENTIFY FUEL TANK SIZES. *TW
BC2295970501
INSTRUCTIONS ON HOW TO IDENTIFY 20 GALLON OR 25 GALLON FUEL TANKS - 1996 SERVICE MANUAL INCORRECTLY LISTS FUEL TANK AT 16 GALLONS. *TW
BC2361970501
AUTHORIZED WARRANTY PART REPLACEMENT OF BRAKE PADS TO CORRECT EXCESSIVE BRAKE NOISE. *TW
9775
HOOD- SERVICE REPAIR TIPS. *JD
97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
97613
TRANSAXLE- AX4S/AX4N- DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744 STORED IN MEMORY AFTER TRANSAXLE EXCHANGE. *JD
97624
AIR CONDITIONING- WATER DRIPPING ONTO FLOOR DRAIN TUBE DURING A/C SYSTEM OPERATION. *JD
9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
97516
ENGINE- 3.8L - "CHIRPING" NOISE DURING NORMAL ENGINE OPERATION. *JD
9743
BLOWER MOTOR- "CHIRP" OR "SQUEAK" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
BC1017197230
VEHICLES BUILT BETWEEN 2/95 AND 9/01/96 MAY EXPERIENCE ROUGH/HARSH OR IRREGULAR SHIFTS DUE TO WATER ENTRY INTO THE TRANSAXLE RANGE SENSOR. *JD
BC1022097230
ADAPTERS ARE AVAILABLE TO CONVERT WINDSTAR "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE TO ALLOW THE USE AFTER MARKET BOOTED WINTER BLADES. *JD
BC3370972301
THE ILLUMINATION OF MALFUNCTION INDICATOR LIGHT, ON AND DIAGNOSTIC TROUBLE CODES P1131, P1151, P1132, P1152. *JD
BC3381972301
ADAPTERS ARE AVAILABLE TO CONVERT VEHICLE "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE. *JD
BC3524972301
VEHICLES BUILT BETWEEN 2/95 AND 9/01/96 MAY EXPERIENCE ROUGH/HARSH OR IRREGULAR SHIFTS DUE TO WATER ENTERING INTO THE TRANSAXLE RANGE SENSOR. *JD
97211
BRAKES - ANTI-LOCK - ABS PUMP MOTOR ACTIVATION WHILE BRAKING OVER A BUMP OR AN INCLINE - VEHICLES WITH TRACTION CONTROL - VEHICLES BUILT THROUGH 9/15/96. *TW
97212
NO START - INTERMITTENT - AFTER HOT SOAK IN FREEZING AMBIENT TEMPERATURES. *TW
97110
SUSPENSION-DIAGNOSTIC AAN INSPECTION FOR FRONT SUSPENSION NOISE (S)- SERVICE TIP. *AK TIP.
BC0083970201
IF RED BRAKE LAMP OR THE YELLOW ABS LAMP IS ON, VERIFY THE MASTER CYLINDER IS FULL WITH BRAKE FLUID. *JD
BC0141970201
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD
BC101209702
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD
BC1014497020
COMPLAINTS OF THE RED BRAKE LAMP OR THE YELLOW ABS LAMP ON, CHECKING THE MASTER CYLINDER BRAKE FLUID LEVEL SHOULD BE THE FIRST STEP. *JD
962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
BC0543961107
VEHICLES MAY NOT START DUE TO MOISTURE FREEZING IN FUEL PUMP RELAY CONTAINED WITHIN CONSTANT CONTROL RELAY MODULE. *TW
BC0678961025
INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT
96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
96223
LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 -STALL - AFTER STARTING WHEN ENGINE ALLOWED TO SOAK FROM 1-4 HOURS - STICKING IDLE AIR CONTROL (IAC) VALVE. *TW
96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
96716
CUSTOMER CONCERN OF AN OBJECTIONABLE ODOR EMITTED FROM THE CARPET UNDER CERTAIN CONDITIONS. *TT
96724
EXPERIENCING A MUSTY SMELL WITHIN THE VEHICLE WITH THE AIR CONDITIONER OPERATING ON SOME VEHICLES BUILT THROUGH 2/15/96. *TT
95127
AUXILIARY BLOWER MOTOR CONTINUES TO RUN AFTER VEHICLE IS SHUT OFF. *TW
BC0247960102
THE WHEEL BEARING ASSEMBLY PART # IN TSB 95-22-14 (F58Z-1104-A) IS INCORRECT. THE PART # LISTED IS FOR THE HUB ASSEMBLY WHICH DOES NOT INCLUDE THE WHEEL BEARING ASSEMBLY. THE CORRECT PART # FOR THE FRONT RIGHT/LEFT WHEEL BEARING ASSEMBLY IS E9DZ-1215-A.
BC0256960102
A REAR END ADAPTOR, P/N 111933, IS NOW AVAILABLE FROM BENDIX THROUGH THE SDS PROGRAM. IT CAN BE USED TO REPAIR TF-550 AIR COMPRESSORS THAT HAVE ELONGATED OR DAMAGED REAR MOUNTING HOLES. THE DAMAGED MOUNTING HOLES MAY BE EVIDENT WHEN THE AIR COMPRESSOR IS REMOVED TO REPAIR A LEAKING FRONT COVER ON MID-RANGE 1060 OR 1460 DIESEL ENGINE.
95205
THE DRIVER OR PASSENGER SHOULDER BELT MAY TWIST OR BE DIFFICULT TO UNTWIST. THE D-RING ON THE SEAT BELT ASSEMBLY WAS DESIGNED TO EASE THE UNTWISTING OF THE BELT BY THE CUSTOMER, BUT MAY TEND TO CONTRIBUTE TO SEAT BELT TWIST. REPLACE THE SEAT BELT ASSEMBLIES W/ NEW BELTS WHICH HAVE A REVIEWED D-RING DESIGN.
95212
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
951911
EXCESSIVE WINDNOISE MAY BE HEARD AROUND THE UPPER DOOR OR DOOR GLASS AREAS. THIS MAY BE CAUSED BY POOR GLASS SEATING OF THE WEATHERSTRIPS DURING INITIAL INSTALLATION WHICH RESULTS IN SMALL GAPS. PROPERLY SEAT THE WEATHERSTRIPS TO REDUCE THE POSSIBILITY OF WINDNOISE.
BC1231950906
A POPPING OF CLUNK NOISE MAY INTERMITTENTLY BE HEARD FROM THE FRONT OF THE UNIT UNDER ACCELERATION, BRAKING OR TURNING. THE MAIN CAUSE OF THIS NOISE IS IS FROM STONES TRAPPED IN THE LOWER SPRING INSULATOR. *TW
BC1284950906
ENGINEERING IS LOOKING FOR VEHICLES WHICH EXHIBIT AN INOPERATIVE FUEL FUMP DUE TO FUSE BLOWING, AN INACCURATE FUEL GAUGE OR A FUEL TANK WHICH IS DIFFICULT TO FILL. *TW
BC1302950907
INOPERATIVE FUEL PUMP DUE TO FUSE BLOWING OR FUEL GAUGE INACCURACY MAY BE DUE TO INSUFFICIENT CLEARANCE BETWEEN THE UPPER SENDER MOUNTING SCREW AND THE EDGE OF THE PUMP MOUNTING FLANGE. *TW
BC1381950906
UNKNOWN
95161
SHEET METAL-ROOF PANEL AND DRIP RAIL REPLACEMENT- SEAM SEALER APPLICATION PROCEDURE.*SD
951613
BRAKES - GRINDING OR METAL-TO -METAL NOISE COMING FROM REAR BRAKES-VEHICLES BUILT THROUGH 12/15/94.
95168
AIR CONDITIONING-A/C COMPRESSOR MOAN - VEHICLES WITH 3.8L ENGINE. NOISE -'MOAN' - A/C COMPRESSOR-VEHICLES WITH 3.8L ENGINE.*SD
95177
TRANSAXLE-REVISED CLUTCH CLEARANCES-AXODE/AX4S. *SD
95157
THE TORQUE CONVERTER IDENTIFICATION CODES HAVE BEEN REVISED AS OF 3/1/95. *SD
95117
LIFTGATE NOISE - SQUEAK OR RATTLE. *TW
BC2190950601
UNKNOWN
9592
UNKNOWN
BC2701950503
LIGHT CLICKING SENSATION OR LOOSENESS AS THE STEERING WHEEL IS TURNED. *TW
BC2902950401
VEHICLES BUILT IN FEBRUARY 1995 MAY EXPERIENCE A CAMSHAFT POSITION SENSOR FAILURE READING DUE TO CHAFING AT THE ACCESSORY DRIVE BELT TENSIONER. *TW
BC4189950401
VEHICLES MAY EXPERIENCE AN INTERMITTENT CRANK/NO START CONDITION. *TW
95511
CHIRP OR SQUEAK FROM BLOWER MOTOR. *TW
9566
CHIRP OR SQUEAK NOISE FROM BLOWER MOTOR AT LOW SPEEDS. *TW
BC3245950301
VEHICLES MAY NOT START AFTER BEING PARKED FOR 15 MINUTES TO 2 HOURS IN FREEZING TEMPERATURES. *TW
BC3265950301
REVISED REAR BRAKE SHOES TO REDUCE NOISE. *TW
BC3520950301
HIGH EFFORTS IN OPENING THE SLIDING DOOR IN WARM AMBIENT TEMPERATURES. *TW
BC0062950201
MANUFACTURER RECALL 94S98 - THE MAIN SYSTEM ELECTRICAL WIRING HARNESS MAY CONTACT A BRACE THAT SUPPORTS THE INSTRUMENT PANEL. THIS MAY RESULT IN THE HARNESS CHAFING AGAINST THE BRACE. IN SOME CASES AN ELECTRICAL SHORT MAY OCCUR, WHICH COULD RESULT IN INTERMITTENT OPERATION OF ELECTRICAL COMPONENTS AND POTENTIALLY, COULD CAUSE AN ELECTRICAL FIRE. *TW
9524
NEW RADIATOR MANUFACTURING PROCESS/MODIFICATION. *TW
9529
VEHICLES MAY SHOW A FALSE ILLUMINATION OF THE DOME LAMP AND DOOR AJAR WARNING LAMP, OR FALSE DOOR CHIME, OR ANTI-THEFT ACTIVATION. *TW
94263
SOME VEHICLES MAY EXHIBIT A NO-CRANK CONDITION DUE TO CORROSION AT THE STARTER SOLENOID CONNECTOR. *TW
94267
A LOW TRANSMISSION FLUID LEVEL MAY IMPROPERLY SET CONTINUOUS MEMORY DTC'S FOR TRANSMISSION CONCERNS ON SOME VEHICLES. *TW
BC0540941201
A RATTLE FROM THE LIFTGATE HINGE AREA. *TW
94239
EXCESSIVE CLUTCH AIR GAP ON FS-10 A/C COMPRESSORS CAN ALLOW THE CLUTCH DISC TO MOVE AWAY FROM THE PULLEY. *TW
942414
CONDENSATE LEAK AT AUXILLARY A/C UNIT - EVAPORATOR HOSE DISCONNECTED. *TW
94247
THE FORWARD CLUTCH PISTON MAY CRACK ON ITS OUTSIDE DIAMETER. *TW
942210
RESTRAINT SYSTEM - INTERNAL SAFING SENSOR RATTLE UNDER DASH. *TW
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.