Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
16-0065
For 1999-2003 Windstar vehicles Safety Recall 11S16 has been issued for vehicles that are operated in high corrosion areas for an extended period, where a front subframe lower control arm (LCA) rear attaching flange or rear body mount could separate from the vehicle subframe. Separation of one LCA attachment or both rear body mounts may result in a loss of vehicle directional control, increasing the risk of a crash.
17358
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT
03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
16987
SLIGHT AMOUNT OF FLUID RESIDUE ON THE OUTSIDE OF THE REAR WHEEL CYLINDER DUST BOOT ON VEHICLES WITH REAR DRUM BRAKES. *TT
03123
TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT
02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
02152
SOME VEHICLES MAY EXHIBIT A POPPING / GRINDING NOISE FROM THE FRONT OF THE VEHICLE WHEN GOING OVER BUMPS OR MAKING TURNS. *TT
02132
GRUNT / POPPING NOISE COMING FROM THE FRONT SUSPENSION AT SPEEDS BELOW 20 MPH WHEN TURNING. *TT
15767
SUBJECT REGARDING POWER STEERING LINE PART ORDERING INFORMATION. *TT
15682
EXHIBITING INTERMITTENT ANTI-SKID BRAKE SYSTEM AND / OR RED BRAKE LAMP ON AT TIMES WHILE DRIVING. *TT
15719
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
15370
SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT
15373
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
15392
SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT
01181
BRAKE SHIFT INTERLOCK.*JB
01171
TRANSAXLE - AX4S - REPLACEMENT APPLICATION CHART - WINDSTAR VEHICLES ONLY. *NLM
01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
011701
INFORMATION REGARDING REPLACEMENT APPLICATION CHART. *ET
01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
14773
INFORMATION ON INDEXING ORANGE DOT ON TORQUE CONVERTER TO FLEXPLATE. *TT
14656
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
14222
CONCERNS WITH SUBFRAME CLUNK ON ACCELERATION / DECELERATION FROM FRONT OF VEHICLE. *TT
13931
SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT
8249
SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT
0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
13309
SOME VEHICLES WITH 3.8L ENGINE MAY EXHIBIT BLACK SOOT ON THE LOWER SECTION OF THE RIGHT REAR QUARTER PANEL. *TT
7120
SOME VEHICLES MAY EXHIBIT BLACK SOOT EMITTED FROM THE TAILPIPE LEAVING DEPOSITS ON RIGHT REARL LOWER QUARTER PANEL. *TT
607465
CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND OR BINDING BLEND DOORS ON SOME VEHICLES. *TT
99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
99184
SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT
13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
13242
INFORMATION REGARDING TSB 97-20-08 FOR 3.8L ENGINES ONLY. *MJS
6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
9913073
CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND / OR BINDING BLEND DOORS. *TT
996735
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT
99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
13024
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT
99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
12808
SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO DTC (DIAGNOSTIC TROUBLE CODE). *TT
6392
SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO (DTC) DIAGNOSTIC TROUBLE CODE. *TT
99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
12559
CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT
12616
INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT
5518
INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT
BPI9904
CONDITIONS WITH THE TRAC OFF LAMP ILLUMINATING INTERMITTENTLY AND THER MAY ALSO BE STORED TROUBLE CODES U1009 AND / OR U1027.
982511
SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC
98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
5131
SUBJECT REGARDING VEHICLES WITH THE AX4S TRANSAXLE HAVING AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *TT
5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
98221
INTERMITTENT NEUTRAL CONDITION AFTER DRIVING AND COMING TO A STOP. *YC
12099
VEHICLES WITH THE AX4S TRANSAXLE HAVE AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *MJS
12114
SOME VEHICLES MAY EXHIBIT A FRONT END GRIND/CRUNCH NOISE DURING A SLOW SPEED TURN. *MJS
12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
985020
SOME VEHICLES BUILT THROUGH 9/8/97 MAY EXHIBIT A CONDITION OF MULTIPLE DIAGOSTIC TROUBLE CODES. THIS MAY BE CAUSED BY BRAKE FLUID AND WATER CONTAMINATION OF CIRCUIT 361 AND CONNECTOR C102 UNDER THE MASTER CYLINDER. *AK
985086
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN DESCRIBED AS AN AIR CONDITIONER HISS NOISE. *TT
985137
SOME VEHICLES MAY EXHIBIT A FRONT END GRIND / CRUNCH NOISE DURING A SLOW SPEED TURN. *TT
982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
982011
CONCERNS OF WEBBING TWISTS OR BINDS ON INTEGRATED CHILD SAFETY SEAT (ICS) BELT. *YC
98-4723
ENGINE CHECK LAMP ON, AND MISFIRE DTC (S) PO300-PO306 ACTION.
981519
TRACTION CONTROL LAMP FLASING INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODES U1009 AND/OR U1027. *AK
98153
THIS TSB IS BEING REPUBLISHED IN ITS ENTIRETY TO REVISE THE POWER TRAIN CONTROL MODULE (PCM) CALIBRATION CROSS REFERENCE AND REVISE PCM SERVICE PART NUMBERS. *AK
11505
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
4639
INFORMATION ON DIAGNOSTIC PROCEDURES FOR VEHICLES EXHIBITING CHECK ENGINE LAMP ON AND MISFIRE DIAGNOSTIC TROUBLE CODES P0300 - P0306. *TT
97120897251
THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY SLIP MOMENTARILY IN WET CONDITIONS CAUSING A REDUCTION IN POWER STEERING ASSIST OR THE GENERATOR LAMP. *YC
9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
11474
SOME MODEL YEAR VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *TT
980311
CHECK ENGINE LAMP ON AND MISFIRE DTC (S) P0300-P0306. *YC
9811484
SOME HIGH MILEAGE VEHICLE MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *TT
982465
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEEZING TEMPERATURES. *YC
982512
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *YC
982535
EXHIBITING A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *YC
982675
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC
982677
SOME VEHICLES MAY EXHIBIT A HIGH PITCH WHISTLE FROM THE HEATER CORE HOUSING CASE. *YC
9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
985A13
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC
985A28
SOME VEHICLES EXPERIENCE THE PARKING BRAKE MAY NOT RELEASE. *YC
985A47
SOME VEHICLES MAY EXHIBIT A BRAKE MALFUNCTION INDICATOR LAMP ILLUMINATED IMMEDIATELY AFTER START-UP AND AN ABS CODE 1226 MAY BE STORED IN MEMORY. *TT
985A48
ON SOME VEHICLES THE ANTI-LOCK BRAKE SYSTEM (ABS) PUMP MOTOR MAY RUN WHILE APPLYING THE BRAKE WHEN TURNING AND DRIVING OVER A BUMP. *TT
985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
985A51
ON SOME VEHICLES REPEAT REPAIRS MAY BE MADE TO 4-WHEEL ANTI-LOCK BRAKING SYSTEMS (4WABS) DUE TO MISDIAGNOSIS OF 4WABS CONCERNS WHICH MAY RESULT IN REPLACEMENT OF FUNCTIONAL COMPONENTS. *TT
98515
SOME VEHICLES MAY EXHIBIT A SQUEAKING, RATTLING, CHIRPING, TICKING AND / OR BUZZING NOISE HEARD FROM THE INSTRUMENT PANEL AREA. *YC
9855
WET CARPET AND/OR HEADLINER IN CARGO AREA. *YC
98416
EXPERIENCING A GRINDING NOISE OR INOPERATIVE DOOR LOCK MAY OCCUR WHEN CYCLING THE POWER FRONT DOOR LOCKS ON SOME VEHICLES. *TT
9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
983094
SOME VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT
983223
INFORMATION REGARDING REMOTE KEYLESS ENTRY (RKE) MODULE REPLACEMENT. *TT
983303
CONCERNS OF BROKEN AND OR BINDING BLEND DOOR. *TT
9811349
VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT
983108
EFFECTIVE MARCH 2, 1998M3.8L ENGINE ASSEMBLY IS ADDED TO FQR(FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *AK
98125
VEHICLE MAY EXHIBIT A "WHISTLING" NOISE HEARD FROM THE A/C PLENUM. *TT
98127
EXPERIENCING ACCELERATOR PEDAL "BUZZING" NOISE AND / OR EXHAUST "DRONING" NOISE AT APPROXIMATELY 1700 RPM WHLE DRIVING. *TT
9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
98-0316
CONCERNS WITH SLOW FUEL FILL, DISTORTED FUEL TANK, FUEL GAGE ERRATIC, FUEL ODOR. *TT
980304
INTERMITTENT NO FORWARD ENGAGEMENT WITH OR WITHOUT DTC P1784 ACTION. *AK
983581
SOME VEHICLES MAY EXHIBIT CONDITIONS OF EXHAUST DRONE AT 1700 RPM. *TT
97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
97111097237
CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC
BC105909705
INSTRUCTIONS ON HOW TO IDENTIFY FUEL TANK SIZES. *TW
BC2295970501
INSTRUCTIONS ON HOW TO IDENTIFY 20 GALLON OR 25 GALLON FUEL TANKS - 1996 SERVICE MANUAL INCORRECTLY LISTS FUEL TANK AT 16 GALLONS. *TW
BC2380970501
HARSH 1-2 UPSHIFT. *TW
9775
HOOD- SERVICE REPAIR TIPS. *JD
97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
97613
TRANSAXLE- AX4S/AX4N- DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744 STORED IN MEMORY AFTER TRANSAXLE EXCHANGE. *JD
97624
AIR CONDITIONING- WATER DRIPPING ONTO FLOOR DRAIN TUBE DURING A/C SYSTEM OPERATION. *JD
9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
97516
ENGINE- 3.8L - "CHIRPING" NOISE DURING NORMAL ENGINE OPERATION. *JD
9743
BLOWER MOTOR- "CHIRP" OR "SQUEAK" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
BC0011972301
BUZZ NOISE IN AX4S TRANSAXLES. *JD
BC1016397230
BUZZ NOISE IN AX4S TRANSAXLES AT ALL SPEEDS OR IDLE ON VEHICLES. *JD
BC1022097230
ADAPTERS ARE AVAILABLE TO CONVERT WINDSTAR "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE TO ALLOW THE USE AFTER MARKET BOOTED WINTER BLADES. *JD
BC1024997230
A HARSH 1-2 SHIFT ON LIGHT THROTTLE, AT NORMAL SHIFT SPEEDS OF 10-15 MPH. *JD
BC3370972301
THE ILLUMINATION OF MALFUNCTION INDICATOR LIGHT, ON AND DIAGNOSTIC TROUBLE CODES P1131, P1151, P1132, P1152. *JD
BC3381972301
ADAPTERS ARE AVAILABLE TO CONVERT VEHICLE "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE. *JD
BC3524972301
VEHICLES BUILT BETWEEN 2/95 AND 9/01/96 MAY EXPERIENCE ROUGH/HARSH OR IRREGULAR SHIFTS DUE TO WATER ENTERING INTO THE TRANSAXLE RANGE SENSOR. *JD
97211
BRAKES - ANTI-LOCK - ABS PUMP MOTOR ACTIVATION WHILE BRAKING OVER A BUMP OR AN INCLINE - VEHICLES WITH TRACTION CONTROL - VEHICLES BUILT THROUGH 9/15/96. *TW
97212
NO START - INTERMITTENT - AFTER HOT SOAK IN FREEZING AMBIENT TEMPERATURES. *TW
97110
SUSPENSION-DIAGNOSTIC AAN INSPECTION FOR FRONT SUSPENSION NOISE (S)- SERVICE TIP. *AK TIP.
BC0011970201
A BUZZ NOISE IN AX4S TRANSAXLES ON 1996/97 TAURUS/SABLE AND WINDSTARS. *JD
BC0083970201
IF RED BRAKE LAMP OR THE YELLOW ABS LAMP IS ON, VERIFY THE MASTER CYLINDER IS FULL WITH BRAKE FLUID. *JD
BC0141970201
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD
BC101209702
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD
BC1014497020
COMPLAINTS OF THE RED BRAKE LAMP OR THE YELLOW ABS LAMP ON, CHECKING THE MASTER CYLINDER BRAKE FLUID LEVEL SHOULD BE THE FIRST STEP. *JD
962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
962613
TRANSAXLE - AX4S - EXTENDED 2-3 SHIFT AND/OR HIGHER THAN EXPECTED ENGINE RPM DURING 2-3 SHIFT AT LIGHT TO MEDIUM THROTTLE AND/OR NO 2-3 SHIFT - VEHICLES EQUIPPED WITH 3.0L ENGINE - SERVICE TIP. *TW
96265
MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED IN MEMORY. *TW
962510
MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 AND/OR P0308 STORED IN MEMORY. *TW
96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
BC0543961107
VEHICLES MAY NOT START DUE TO MOISTURE FREEZING IN FUEL PUMP RELAY CONTAINED WITHIN CONSTANT CONTROL RELAY MODULE. *TW
BC0313961101
CHECK ENGINE LIGHT, CODE P030X, WITH NO DRIVEABILITY COMPLAINT. *TW
BC0605961101
BUFFALO, NY AREA ONLY - THE WINDSTAR ASSEMBLY PLANT WOULD LIKE TOP BE NOTIFIED OF ANY CRACKED WINDSHIELDS AND WOULD LIKE TO EXAMINE THE CRACKED WINDSHIELD BEFORE REPLACEMENT. *TW
96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
96223
LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 -STALL - AFTER STARTING WHEN ENGINE ALLOWED TO SOAK FROM 1-4 HOURS - STICKING IDLE AIR CONTROL (IAC) VALVE. *TW
96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
BC0880961004
LACK OF COOLING DUE TO COMPLETE LOSS OF CHARGE. MAY HAVE A MACHINING DEFECT IN THE HIGH PRESSURE RELIEF VALVE. *TT
BC5191961001
FOR CONCERNS OF STALLING, REFLASH PCM W/ 1996 CALIBRATION (R11 LEVEL). *TT
BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
96716
CUSTOMER CONCERN OF AN OBJECTIONABLE ODOR EMITTED FROM THE CARPET UNDER CERTAIN CONDITIONS. *TT
96724
EXPERIENCING A MUSTY SMELL WITHIN THE VEHICLE WITH THE AIR CONDITIONER OPERATING ON SOME VEHICLES BUILT THROUGH 2/15/96. *TT
9678
CONCERNS WITH THE RIGHT SIDE ENGINE BLOCK DRAIN PLUG HOLE AND PLUG IS OVERSIZED. *TT
BC0247960102
THE WHEEL BEARING ASSEMBLY PART # IN TSB 95-22-14 (F58Z-1104-A) IS INCORRECT. THE PART # LISTED IS FOR THE HUB ASSEMBLY WHICH DOES NOT INCLUDE THE WHEEL BEARING ASSEMBLY. THE CORRECT PART # FOR THE FRONT RIGHT/LEFT WHEEL BEARING ASSEMBLY IS E9DZ-1215-A.
95212
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
951911
EXCESSIVE WINDNOISE MAY BE HEARD AROUND THE UPPER DOOR OR DOOR GLASS AREAS. THIS MAY BE CAUSED BY POOR GLASS SEATING OF THE WEATHERSTRIPS DURING INITIAL INSTALLATION WHICH RESULTS IN SMALL GAPS. PROPERLY SEAT THE WEATHERSTRIPS TO REDUCE THE POSSIBILITY OF WINDNOISE.
95199
THE AX4S TRANSAXLES CONTAIN ELASTOMERIC GASKETS FOR THE MAIN CONTROL COVER AND THE BOTTOM PAN. THESE NEW GASKETS REPLACE THE CORK-STYLE GASKETS. THE ELASTOMERIC GASKET HAS IMPROVED DUABILITY AND SEALING CAPABILITY AND IS REUSABLE.
95161
SHEET METAL-ROOF PANEL AND DRIP RAIL REPLACEMENT- SEAM SEALER APPLICATION PROCEDURE.*SD
BC2190950601
UNKNOWN
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.