SS3124-FTL
Other
Service Solution for Legacy M2 Bulkhead Module (BHM) Replacement and Diagnosticlink Issue
Vehicle report
2016 FREIGHTLINER 114SD
Service bulletins
601 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
CXA 3_25_NOx
Other
CX Advocate for NOx conversion low faults
CXA 2_25_NOx
Other
CX Advocate for NOx conversion low faults
CXA 2_25_Turbo Oil Drain
Other
CX Advocate for turbo oil drain cracking
CXA 1_16_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
CXA 1_16_DD13 Altitude
Other
CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
CXA 1_16_NOx
Other
CX Advocate for NOx conversion low faults
CXA 1_16_Seat Occupancy
Other
CX Advocate for repairing seat occupancy sensor (TSB 91-016-FTL)
CXA 1_16_Turbo Oil Drain
Other
CX Advocate for turbo oil drain cracking
CXA 11_21_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
TSB91-016-FTL
Service Bulletin/Repair Instructions
Technical Service Bulletin for Repairing Seat Occupancy Sensor for ISRI, SEARS and National Truck Seats
WI24-019
Warranty Program/Extension
Warranty Information letter for Detroit Line or Line Seal, High Pressure Fuel Injector Standard Repair Time Updates
PB01-009
Other
Parts Bulletin for Powertrain Power Distribution Module (PTPDM) Kit Replacement
CXA_10_17_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
SS3146-FTL
Other
Service Solution for M2, 108SD, 114SD - Unable to Program Replacement Bulkhead Module - Certain Model Years
CXA 8_24_Bulkhead Module
Other
CX Advocate for bulkhead module reprogramming (SS 3146-FTL)
CXA 7_24_NOx
Other
CX Advocate for NOx conversion low faults. Update to CXA 6_24_NOx submission.
CXA 7_24_Oil Suction
Other
CX Advocate for Oil Suction manifolds
CXA 06_24_NOx
Other
CX Advocate communication for NOx conversion low faults
FL974
Service Bulletin/Repair Instructions
Revised Emissions Recall: Cummins DEF Sensor Shortage. REVISION: Some vehicles formerly in Group F have been moved to Group G and have been assigned a new part number as specified in Table 1. An SRT for 'Calibration Code Only: Update or Confirm' has been added, as shown in Table 2, to be used when a new DEF header is not required. There have been some other minor changes to the work instructions and SRT times.
ICI24-006
Service Bulletin/Repair Instructions
Important Campaign Information letter for FL974 - Revised Bulletin & Population
SB49-042
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for DEF Connector Reinforcement Caps.
SB54-320
Service Bulletin/Repair Instructions
Updated Service Bulletin for upgrading BHM software for switch expansion module fault SPN 698 FMI 7. This bulletin replaces the version dated 11/11/2019. Figure 3 has been updated with a new hardware part number. A procedure was added to the data download process.
16TS-08REV
Service Bulletin/Repair Instructions
Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
WI21-009
Service Bulletin/Repair Instructions
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Service Bulletin/Repair Instructions
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
SB83-155
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Espar Service Information. This bulletin replaces the version dated January 1, 2015. New Cascadia has been added to the model list.
WP21-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for battery tags. DTNA determined that since adopting the AutoMeter BCT-460DTNA Powernet Assessment Tool (AutoMeter) as the required powernet system tester, not all battery tags have to be retained support Warranty-related claims.
SB54-308
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
21OEM-06
Service Bulletin/Repair Instructions
Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available. Current subscribers of DiagnosticLink 8.11 or 8.12 may upgrade to DiagnosticLink 8.13 at no cost. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
ICI21-003
Service Bulletin/Repair Instructions
Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately. This letter supersedes ICI20-022R.
WI21-006
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes - Claim Guidelines.
WI20-014R
Service Bulletin/Repair Instructions
Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes. Revisions are in blue font.
WI21-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit Resources: Exploded View DD Platform and DT12 Posters. Detroit's TechComm team created visual aids for the network and released exploded view posters for DD platform engines. In early 2021, Detroit added multiple DT12 posters.
21TS-01
Service Bulletin/Repair Instructions
Technical Service Letter for Detroit Bearing Failures - Standard Diagnostic Times. DTNA is increasing repair strategies for determining the root cause of Detroit DD heavy duty lower end bearing failures. To support this strategy change, Detroit now has two (2) Standard Diagnostic Times (SDTs), easy and difficult, which can be applied to repair orders.
21TS-03
Service Bulletin/Repair Instructions
Technical Service Letter for GHG17 1-Box Inlet and Outlet Exhaust Clamps. There is a short supply of exhaust clamps, part number DDE A6809950502, used as inlet and outlet exhaust clamps on GHG17 heavy duty engines (DD13, DD15 and DD16) with a 1-Box aftertreatment configuration. Exhaust clamp part number TCX T130158342AC2 may be used as a substitute for DDE A6809950502, but be aware of the different torque specs between the two parts.
WI21-003
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit Bearing Failures - Standard Diagnostic Times. DTNA is increasing repair strategies for determining the root cause of Detroit DD heavy duty lower end bearing failures. To support this strategy change, Detroit now has two (2) Standard Diagnostic Times (SDTs), easy and difficult, which can be applied to repair orders.
SB35-036
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
WP20-018R
Service Bulletin/Repair Instructions
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
WP20-018
Service Bulletin/Repair Instructions
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
SB54-278
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeterî is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
20TS-06
Service Bulletin/Repair Instructions
DDC Technical Service Letter for GHG17 DD Platform Heavy Duty Oil Pan Drain Plug Inserts. Some GHG17 DD Platform Heavy Duty oil pans may experience an issue with the oil pan drain plug insert spinning during removal or installation while completing an oil change. Leaking may also be observed at the drain plug and/or other plugs in the oil pan.
JOYSON LTR
Service Bulletin/Repair Instructions
Joyson Safety Systems letter informing DTNA about Hikone Webbing Investigation. JSS is near completion of an initial investigation regarding data integrity issues at the seatbelt webbing manufacturing facility in Hikone, Japan acquired from Takata in April of 2018.
TechTalk4725
Service Bulletin/Repair Instructions
Tech Talk discussion about power steering fluid.
TechTalk7679
Service Bulletin/Repair Instructions
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
20CSA-15
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
ICI20-022R
Service Bulletin/Repair Instructions
Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately.
SB54-315
Service Bulletin/Repair Instructions
Service Bulletin for Powertrain PDM and Main PDM Bracket Modiï¬Âcation. This bulletin replaces the version dated 10/31/2019. The build date section has been added.
ICI20-022
Service Bulletin/Repair Instructions
Important Campaign Information letter announcing Dealer Travel for Campaign Performance. This letter is to announce a reimbursement available to dealers for travel to a customerÃÂÃÂÃÂâÃÂÃÂÃÂÃÂÃÂÃÂÃÂÃÂs location to perform a recall or field service campaign.
WI20-012
Service Bulletin/Repair Instructions
Warranty Information Letter informing that to ensure that DTNA policies and service network practices align, the Warranty Department will be revising the Warranty Manual.
WI20-014
Service Bulletin/Repair Instructions
Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes.
SB31-043
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change. With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
20CSA-10
Service Bulletin/Repair Instructions
Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkÃÂÃÂÃÂÃÂÃÂÃÂÃÂî 8.12 Standard and Professional is available to download from the Detroit Diesel server.
20OEM-05
Service Bulletin/Repair Instructions
OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
20TS-05
Service Bulletin/Repair Instructions
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility. Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
SB54-334
Service Bulletin/Repair Instructions
Service Bulletin for Front Lighting Ground Splice Pack Failure. The left and right hood lighting of these vehicles have separate ground paths to the frame and use the same splice pack parts. The splice packs are part of the hood commodity and located near the headlight assemblies. These splice packs can fail, resulting in either the left or right lighting becoming intermittent or inoperative.
20CSA-09
Service Bulletin/Repair Instructions
Customer Service Announcement for DiagnosticLink Software Update Reminder. Due to various software changes and fixes, vehicles will require DiagnosticLink 8.12 to perform functional programming. Failure to use this version may cause errors, incomplete programming, and poor vehicle performance. Because of this, all DiagnosticLink 8.09 installed versions will be disabled as of Thursday, July 23, 2020.
SB60-171
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
20CSA-08
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020, DiagnosticLink 8.12 will be made available for download from the ordering system. Current subscribers of DiagnosticLink 8.xx can upgrade to DiagnosticLink 8.12 at no cost. All DTNA service shops are required to maintain the latest version of software on each of their stations.
WI20-008
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
WP20-006
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers. To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
WP20-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for Chassis Progressive Damage Policy Change. Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
WP20-005
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program. DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
WI20-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Long Block Program Change. The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
SB54-327
Service Bulletin/Repair Instructions
Service Bulletin for Lengthening the Backup Light Harness. Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
SB32-033
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for Front Axle Spacer Replacement. This service bulletin replaces the version dated 05/01/2016. This bulletin is updated to include the parts list. Some vehicles may exhibit a lean (right or left) due to weight difference on the front suspension. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers. To correct this condition, replace the existing front axle spacer on the low side of the vehicle with a thicker one.
20CSA-04
Service Bulletin/Repair Instructions
Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLinkî 8.11 Standard and Professional will be available for download from the Detroit Diesel server.
03.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers.
SB00-038
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for vibration troubleshooting - finding the cause. This version replaces the version dated 5/1/14 and adds New Cascadia.
WP20-002
Service Bulletin/Repair Instructions
Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy, published in DTNA Workshop Manuals, which states that there are very few cases in which welding a heat-treated frame rail is allowed. Therefore, before welding anything on a frame rail, contact the applicable regional service representative for approval.
02.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers
SB54-290
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness. Use the guidelines in this bulletin to determine if a damaged electrical harness should be repaired or replaced.
20CSA-01
Service Bulletin/Repair Instructions
Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs) will now have a 60-day expiration, starting on the release day of the bulletin. The intent of a SIB is to notify the service network of a major change to one or more service procedures. Do not save SIBs nor reference them for repairs, as they are uncontrolled and never updated.
SB83-119
Service Bulletin/Repair Instructions
Service Bulletin for A/C system receiver-drier replacement guidelines.
WI19-022
Service Bulletin/Repair Instructions
Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment Systems
SB54-319
Service Bulletin/Repair Instructions
Service Bulletin for severe duty main PDM installation for vehicles operating in severe moisture and/or corrosive environments.
17TS9
Service Bulletin/Repair Instructions
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found on TechLit.
09-037
Service Bulletin/Repair Instructions
Service Bulletin for Air Cleaner Modifications for Dusty Environments
19TL-15
Service Bulletin/Repair Instructions
Tool Letter for ICC5 Programming Cable
SB32-054
Service Bulletin/Repair Instructions
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
SB47-027
Service Bulletin/Repair Instructions
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
15CSA-3REV
Service Bulletin/Repair Instructions
Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
19CSA-12 BCT
Service Bulletin/Repair Instructions
PowerNet Assessment Tool Repair Procedure
19TL-10 NVH
Service Bulletin/Repair Instructions
Communication to assist the field with service vibration issues on DTNA vehicles
D18M4
Service Bulletin/Repair Instructions
Field Service Campaign for Remanufactured Detroit DT12 Transmissions
19CSA-13
Service Bulletin/Repair Instructions
Service Systems Development provided document to service locations on price list reflects current charges to engine horsepower ratings for HDEP and MDEG engine platforms.
19-011WP
Service Bulletin/Repair Instructions
Warranty Policy Letter to communicate Detroit Return Changes
19-012WP
Service Bulletin/Repair Instructions
Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
19-013WI
Service Bulletin/Repair Instructions
Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized Demonstrator Program
sb32-054
Service Bulletin/Repair Instructions
Service Bulletin to fix vehicles which may have an incorrect transverse torque rod tower bracket installed on the rear drive axles at the factory. This can result in cracking at the transverse rod tower where it is welded to the axle housing, premature wearing of the transverse torque rod tapered pin and bushings, and damage to the transverse torque rod frame bracket.
sb54299
Service Bulletin/Repair Instructions
Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer installed in production, and has been superseded by the ICU3S. When replacing an ICU3, the ICU3S must be installed in its place.
19-010WI
Service Bulletin/Repair Instructions
Warranty Information Letter updated to communicate warranty system updates.
0107-19 GHG17
Service Bulletin/Repair Instructions
Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
0305-19 SPN 2000
Service Bulletin/Repair Instructions
Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC Heartbeat Message is no Longer Arriving)
0308-19 PTO
Service Bulletin/Repair Instructions
Service Information Bulletin regarding PTO Dosing. This feature enables Active Regeneration of the DPFs while in PTO mode.
0419-19SPN521030
Service Bulletin/Repair Instructions
Updates to troubleshooting guides in Diagnostic Link with newest version
0607-19
Service Bulletin/Repair Instructions
Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine Electrical section.
0609-19
Service Bulletin/Repair Instructions
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
0611-19
Service Bulletin/Repair Instructions
Service Information Bulletin was released, to add new procedures to address diagnostics near the high pressure pump
18SP725Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP726Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP730Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
19-008WI
Service Bulletin/Repair Instructions
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19TL-9
Service Bulletin/Repair Instructions
DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on DTNA products at DTNA service locations. The Axis4000 system uses the reference points required by DTNA for precise, accurate, and repeatable measurements. Axis4000 is a sophisticated, user-friendly system that utilizes computer based camera-radio technology and references the center line of the frame for measuring and providing alignment results to DTNA specifications.
19TS-6
Service Bulletin/Repair Instructions
The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
SPN 3563 / FMI 2
Service Bulletin/Repair Instructions
HDEP GHG17 engines are not equipped with turbo wastegates. Steps in this troubleshooting involving wastegates were removed.
19-009WI
Service Bulletin/Repair Instructions
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
DOC-1034452
Service Bulletin/Repair Instructions
Training Solution created by DTNA to provide guidance to customers when searching for service information for components and systems not owned by Daimler Trucks North America (DTNA).
sb54308
Service Bulletin/Repair Instructions
DiagnosticLink support programming of both chassis and powertrain ECUs
sb54311
Service Bulletin/Repair Instructions
Service Bulletin- sb54311 ICU Odometer Programming
fp00024
Service Bulletin/Repair Instructions
fp00024 Cable-Tie Reference
Ready Mix Bolts
Service Bulletin/Repair Instructions
Ready Mix Bolts
sb00044
Service Bulletin/Repair Instructions
Reminder: Paper Service Bulletin Mailings Are Discontinued
CALFTL54-001
Service Bulletin/Repair Instructions
Customer Advisory Letter on Powertrain PDM and Main PDM Bracket Modification
DOC-1034171
Service Bulletin/Repair Instructions
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
sb0039
Service Bulletin/Repair Instructions
Service Bulletin New "Natural Gas Vehicle Information" Webpage
1208-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
1212-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
1213-18
Service Bulletin/Repair Instructions
Service Information Bulletin
18TS4Rev DD
Service Bulletin/Repair Instructions
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
GHG17
Service Bulletin/Repair Instructions
Letter to customer on Coverage Extension GHG17 After Treatment
1001-18 Engine R
Service Bulletin/Repair Instructions
Engine Replacement Procedures
sb9815 Paint Fin
Service Bulletin/Repair Instructions
Service Bulletin 9815- Paint Finish Standards
Emission Recall
Service Bulletin/Repair Instructions
Emission Recall D18R5 GHG17 DD Platform Model Years 2016-2018 Software Reprogramming For California Onboard Diagnostics
Aftertreamtent F
Service Bulletin/Repair Instructions
Service Information Bulletin for Aftertreamtent Failure Guide
DD13, DD15, DD16
Service Bulletin/Repair Instructions
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
18-029 Auto Mete
Service Bulletin/Repair Instructions
Important Warranty Information on AutoMeter BCT-460DTNA Powernet Assessment Tool: Warranty Requirement and Claim Filing
18CSA16 Release
Service Bulletin/Repair Instructions
Release of DiagnosticLink® 8.08 Service Pack 2
sb3125 AirLiner
Service Bulletin/Repair Instructions
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
sb0036
Service Bulletin/Repair Instructions
Operating Hours for the Customer Assistance Center
sb54301
Service Bulletin/Repair Instructions
Indel B Refrigerator Loose Circuit Board
0505-18
Service Bulletin/Repair Instructions
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
0503-18
Service Bulletin/Repair Instructions
0503-18 Relative Cylinder Compression Test
0502-18
Service Bulletin/Repair Instructions
0502-18 Symptom Diagnostics - Low Engine Coolant Temperature
18SP734
Service Bulletin/Repair Instructions
18SP734 18SP734?GHG14 DD15AT Turbocharger
DOC-1033446
Service Bulletin/Repair Instructions
Vehicles with Meritor drivelines bene from a softer durometer center bearing support. Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
fp00020
Service Bulletin/Repair Instructions
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
sb31037
Service Bulletin/Repair Instructions
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed. The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
sb31038
Service Bulletin/Repair Instructions
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn. This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
0405-18
Service Bulletin/Repair Instructions
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
0404-18
Service Bulletin/Repair Instructions
0404-18 GHG17 DD8 - Aftertreatment Systems - Diesel Particulate Filter End Cap
0402-18
Service Bulletin/Repair Instructions
0402-18 SPN 625 (CPC) (GHG14)
0401-18
Service Bulletin/Repair Instructions
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
FL705
Service Bulletin/Repair Instructions
FL705 Bendix Rear Brake Calipers
DOC-1033354
Service Bulletin/Repair Instructions
SS 1033354 Remanufactured Engine Blocks with Closed Fuel Cooler Return Ports DD Engines
0312-18
Service Bulletin/Repair Instructions
0312-18 Installation Output Shaft Seal
0311-18
Service Bulletin/Repair Instructions
0311-18 Installation of the Main Shaft Speed Sensor
D17M1
Service Bulletin/Repair Instructions
D17M1 17M1 GHG17 DD15 Model Year 2016 Diesel Particulate Filter (DPF)
D17M2
Service Bulletin/Repair Instructions
D17M2 17M2-REV GHG17 Heavy Duty Engine Platform Front Engine Lifter Bracket
D17M2 17M2-REV
Service Bulletin/Repair Instructions
D17M2 17M2-REV GHG17 Heavy Duty Engine Platform Front Engine Lifter Bracket
D17M2-REV
Service Bulletin/Repair Instructions
D17M2-REV GHG17 Heavy Duty Engine Platform Front Engine Lifter Bracket
MY18M1
Service Bulletin/Repair Instructions
MY18M1a 05-MAR-2018 Vocational
aeo18M1
Service Bulletin/Repair Instructions
aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
sb00042
Service Bulletin/Repair Instructions
sb00042 Flood Damage Repair GuidelinesB
sb15020
Service Bulletin/Repair Instructions
sb15020 Alternator Remote Sense WiringB
sb2074
Service Bulletin/Repair Instructions
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2076
Service Bulletin/Repair Instructions
sb2076 114SD Radiator Mounting, Update?EPA10
sb2081
Service Bulletin/Repair Instructions
sb2081 Fan Shroud Fastener Retrofit, 114SD with DD13 Engine
sb2083
Service Bulletin/Repair Instructions
sb2083 FluidXchange Tool and FittingsB
sb2084
Service Bulletin/Repair Instructions
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
sb2085
Service Bulletin/Repair Instructions
sb2085 Isolated Radiator Mounting, Behr Mahle M80 FEPTO Radiator
sb31034
Service Bulletin/Repair Instructions
sb31034 Towing ProceduresB
sb4725
Service Bulletin/Repair Instructions
sb4725 DAVCO Preheater Fault Code SA 33 SPN 6897 FMI 6B
sb49040
Service Bulletin/Repair Instructions
sb49040 Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser ConnectionB
sb54148
Service Bulletin/Repair Instructions
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb54278
Service Bulletin/Repair Instructions
sb54278 Powernet Troubleshooting Guide Batteries, Path, Alternator, and Starter
sb54296
Service Bulletin/Repair Instructions
sb54296 Fuel Level Sending Unit RetrofitB
sb60157
Service Bulletin/Repair Instructions
sb60157 Roof Noise, M2 and 108SD 114SD Day CabsB
sb98020
Service Bulletin/Repair Instructions
sb98020 Axalta Paint Finish CareB
sb9815
Service Bulletin/Repair Instructions
sb9815 Paint Finish StandardsB
fsb42072
Service Bulletin/Repair Instructions
fsb42072 Diagnostic de fuite d'air
fsb42073
Service Bulletin/Repair Instructions
fsb42073 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
fsb49040
Service Bulletin/Repair Instructions
fsb49040 Conduite sous pression de fluide pour échappement diesel (DEF) débranchée au niveau du raccordement du doseur
sb0006
Service Bulletin/Repair Instructions
sb0006 Freightliner Courtesy Engineering PolicyB
17-029
Service Bulletin/Repair Instructions
Computer Hook-Up Standard Diagnostic Time Update
17CSA25
Service Bulletin/Repair Instructions
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17TL26
Service Bulletin/Repair Instructions
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17TL27
Service Bulletin/Repair Instructions
17TL27 Injector Cup Tool DSN930E17001
17TL28
Service Bulletin/Repair Instructions
17TL28 Fuel Injector Removal Tool DSN930E17004
17CSA24
Service Bulletin/Repair Instructions
17CSA24 Holiday Schedule for the Detroit Customer Support Center
ICI17-041
Service Bulletin/Repair Instructions
SF533 - Second Revised Bulletin
17-028
Service Bulletin/Repair Instructions
OWL Enhancement Service Model Field
17CSA23r
Service Bulletin/Repair Instructions
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
SF533
Service Bulletin/Repair Instructions
Instrument Cluster Update
17-026
Service Bulletin/Repair Instructions
17-026 Holiday Closure 2017
17-027
Service Bulletin/Repair Instructions
Warranty Classroom Training in 2018
17TL25
Service Bulletin/Repair Instructions
17TL25 TruckCam? Alignment System
42-073
Service Bulletin/Repair Instructions
Transport Dealer Air Leak Inspection
49-040
Service Bulletin/Repair Instructions
Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
1110-17
Service Bulletin/Repair Instructions
Exhaust and Exhaust Gas Recirculation
FL740
Service Bulletin/Repair Instructions
Brake Check Valve
1105-17
Service Bulletin/Repair Instructions
EPA10, GHG14 and GHG17 Diesel Particulate Filters
FL731
Service Bulletin/Repair Instructions
ICU3S Dual Cluster Displays
1102-17
Service Bulletin/Repair Instructions
SPN 157 (MCM) (GHG17)
1101-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Noisy One-Box Aftertreatment
14CSA23
Service Bulletin/Repair Instructions
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
17TS17Rev
Service Bulletin/Repair Instructions
Instructions for CSC Diagnostic Support
17-023
Service Bulletin/Repair Instructions
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
0903-17
Service Bulletin/Repair Instructions
Engine Manufacturer Diagnostics
0902-17
Service Bulletin/Repair Instructions
SPN 3556 (ACM) (GHG14)
17TS12Rev1
Service Bulletin/Repair Instructions
17TS12Rev1 GHG17 Heavy Duty Engine Platform 1-BOX? Aftertreatment System ATS Wire Harness
0806-17
Service Bulletin/Repair Instructions
0806-17 SPN 101 (MCM)(GHG17)
0803-17
Service Bulletin/Repair Instructions
0803-17 SPN 411 (MCM) (GHG17)
sb54298
Service Bulletin/Repair Instructions
sb54298 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil
SS1033180
Service Bulletin/Repair Instructions
Service Solution SS 1033180 BHM Fault Code SPN 524251 FMI 7 - Extr...
SS1032974
Service Bulletin/Repair Instructions
SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
0701-17
Service Bulletin/Repair Instructions
SPN 168 (CPC3) (GHG17)
RVSD-MY17M1
Service Bulletin/Repair Instructions
Bulletin_Revised_09May17 GHG17 DD15 Model Year 2016 Diesel Particulate Filter (DPF)
RVSD-aeo17M1
Service Bulletin/Repair Instructions
GHG17 DD15 Model Year 2016 Diesel Particulate Filter (DPF)
sb0002
Service Bulletin/Repair Instructions
Technical Publications Ordering
0609-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0608-17
Service Bulletin/Repair Instructions
Diagnostic tests - Two Filter System - FSIC Leak Test
0607-17
Service Bulletin/Repair Instructions
SPN 96 (MCM) (GHG17)
0606-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0604-17
Service Bulletin/Repair Instructions
SPN 712 (CPC) (GHG17)
0603-17
Service Bulletin/Repair Instructions
Fuel System Integrity Check Routine - Two-Filter Fuel System
0602-17
Service Bulletin/Repair Instructions
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
17TL7Rev
Service Bulletin/Repair Instructions
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
FL731 ICU3S
Service Bulletin/Repair Instructions
Dual Cluster Displays
17TS11
Service Bulletin/Repair Instructions
Detroit? DT12? Transmission Proper Moving Procedure
17TL8Rev1
Service Bulletin/Repair Instructions
Vehicle Interface Module
0412-17
Service Bulletin/Repair Instructions
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
0411-17
Service Bulletin/Repair Instructions
SPN 5741 (ACM) (GHG17)
0410-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Hard Start No Start
17TS10
Service Bulletin/Repair Instructions
Detroit? DT12? Split Rod Bushing Repair
0409-17
Service Bulletin/Repair Instructions
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0408-17 SPN 5242
Service Bulletin/Repair Instructions
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
0407-17
Service Bulletin/Repair Instructions
GHG17 Heavy Duty- Exhaust & EGR - EGR Actuator Coolant Lines
0406-17
Service Bulletin/Repair Instructions
SPN 521221 (TCM)
0405-17
Service Bulletin/Repair Instructions
SPN 521222 (TCM)
0403-17
Service Bulletin/Repair Instructions
SPN 677 FMI 2 Starter Switch Inconsistent Diagnostics
0402-17
Service Bulletin/Repair Instructions
SPN 1322 (MCM) (GHG17)
0401-17
Service Bulletin/Repair Instructions
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
2017-0938
Service Bulletin/Repair Instructions
E-ONE vehicles are designed with electrical circuit protection (e.g. fuses), to provide overcurrent protection during short-circuit conditions or malfunction of components. Fuses are sometimes shared amongst different circuits. For example, the circuits for the pump primer motor and chassis power share a common 300Amp fuse. If either of these circuits experiences an electrical overload, the fuse will act as designed to protect the users and the vehicle from further damage. As such, an overcurrent condition in the pump primer circuit will also disconnect main power from the cab and chassis and cause the engine to shut down.
0329-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Oil Leaks
0328-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0327-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0326-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0325-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0324-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0323-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0322-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0321-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0320-17
Service Bulletin/Repair Instructions
(MCM)(GHG17)
0319-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0318-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0317-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0316-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0315-17
Service Bulletin/Repair Instructions
GHG14 - Intake Manifold Pressure Too Low
ICI17-005
Service Bulletin/Repair Instructions
FL731 - Interim Recall Notice
0314-17
Service Bulletin/Repair Instructions
GHG14 Intake Manifold Pressure Too Low
0313-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0312-17
Service Bulletin/Repair Instructions
(MCM) GHG17
0311-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0310-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0309-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
TS1033014
Service Bulletin/Repair Instructions
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines. Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
0308-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0307-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0307-17 SPN
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0306-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0305-17
Service Bulletin/Repair Instructions
Diagnostic Tests
0304-17
Service Bulletin/Repair Instructions
Contaminated Fluids Diagnostic Tests
0303-17
Service Bulletin/Repair Instructions
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17
Service Bulletin/Repair Instructions
0301-17 Contaminated Fluids
0302-17
Service Bulletin/Repair Instructions
(CPC)(GHG17)
0346-17
Service Bulletin/Repair Instructions
(CPC) (GHG17)
0356-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0356-17 SPN
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0208-17 SPN 412
Service Bulletin/Repair Instructions
0208-17 SPN 412 (MCM) (GHG17)
0206-17 SPN 5210
Service Bulletin/Repair Instructions
0206-17_ SPN 521049 (MCM) (GHG17)
ICI17-002
Service Bulletin/Repair Instructions
FL721 Interim Recall Ending ? Final Recall to Begin
0205-17 SPN 5210
Service Bulletin/Repair Instructions
0205-17 SPN 521052 (MCM) (GHG17)
0204-17 SPN 5210
Service Bulletin/Repair Instructions
0204-17 SPN 521050 (MCM) (GHG17)
0203-17 SPN 5741
Service Bulletin/Repair Instructions
0203-17 SPN 5741 FMI 13 (GHG17) (MCM)
0202-17
Service Bulletin/Repair Instructions
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
18SP733
Service Bulletin/Repair Instructions
18SP733 GHG17 Medium Duty DD8 Oil Filter Kit
FL721
Service Bulletin/Repair Instructions
FL721 CNG Fuel Tank and CPDM Mounting Location
0131-17
Service Bulletin/Repair Instructions
0131-17 SPN 521054 (CPC3) (GHG17)
0132-17
Service Bulletin/Repair Instructions
0132-17 SPN 521005 (CPC3) (GHG17)
0133-17
Service Bulletin/Repair Instructions
0133-17 SPN 625 (CPC) (GHG17)
0134-17
Service Bulletin/Repair Instructions
0134-17 Medium Duty - DD5 GHG17 - Exhaust and EGR - EGR Cooler Lower Bracket
0135-17
Service Bulletin/Repair Instructions
0135-17 Diagnostic Test - Engine Brake Test Procedure
0136-17
Service Bulletin/Repair Instructions
0136-17 GHG17 DD5 Medium Duty - Exhaust and EGR - Turbocharger Oil
0137-17
Service Bulletin/Repair Instructions
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0138-17
Service Bulletin/Repair Instructions
0138-17 GHG17 DD5 Medium Duty - Exhaust and EGR - EGR Delivery
0139-17
Service Bulletin/Repair Instructions
0139-17 Coolant Housing
0140-17
Service Bulletin/Repair Instructions
0140-17 Turbocharger Compressor Outlet Pipe
0130-17
Service Bulletin/Repair Instructions
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0129-17
Service Bulletin/Repair Instructions
0129-17 SPN 102 (MCM) (GHG17)
0127-17
Service Bulletin/Repair Instructions
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0126-17
Service Bulletin/Repair Instructions
0126-17 SPN 520295 (MCM) (GHG17) - Smart Remote Actuator 1
0125-17
Service Bulletin/Repair Instructions
0125-17 SPN 4817 (MCM) (GHG17)
0124-17
Service Bulletin/Repair Instructions
0124-17 SPN 3720 FMI 14 - (MCM) (GHG17)
0123-17
Service Bulletin/Repair Instructions
0123-17 SPN 1483 (CPC3) (GHG17)
0122-17
Service Bulletin/Repair Instructions
0122-17 SPN 521058 (CPC3) (GHG17)
0121-17
Service Bulletin/Repair Instructions
0121-17 SPN 521050 (CPC3) (GHG17)
0120-17
Service Bulletin/Repair Instructions
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0119-17
Service Bulletin/Repair Instructions
0119-17 SPN 3217 (MCM) (GHG17)
0118-17
Service Bulletin/Repair Instructions
0118-17 Symptom Diagnostics - Oil Leaks
0117-17
Service Bulletin/Repair Instructions
0117-17 SPN 5928 (MCM) (GHG17) - EGR H Bridge circuit diagnostics
0116-17
Service Bulletin/Repair Instructions
0116-17 SPN 4752 (MCM) (GHG17) - EGR Cooler Efficiency Fault Codes
0115-17
Service Bulletin/Repair Instructions
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
0111-17
Service Bulletin/Repair Instructions
0111-17 SPN 1077 (MCM)(GHG17)
0107-17
Service Bulletin/Repair Instructions
0107-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0106-17
Service Bulletin/Repair Instructions
0106-17 SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17)
FAB210
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB210 USB Charging Ports
FL722AB
Service Bulletin/Repair Instructions
FL722AB Freightliner Brake Caliper Bolts
16TS25
Service Bulletin/Repair Instructions
16TS25 Single-Speed Fan Operation
1213-16
Service Bulletin/Repair Instructions
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
1207-16
Service Bulletin/Repair Instructions
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
16TS24
Service Bulletin/Repair Instructions
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
16M3
Service Bulletin/Repair Instructions
16M3_bulletin Motor Control Module (MCM)
18SP714
Service Bulletin/Repair Instructions
18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
18SP719
Service Bulletin/Repair Instructions
18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
54-267
Service Bulletin/Repair Instructions
54-267 Business Class M2 and 108SD114SD Virtual Technician
aeo16M3
Service Bulletin/Repair Instructions
aeo16M3 Field Service Campaign
16TL20
Service Bulletin/Repair Instructions
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
1021-16
Service Bulletin/Repair Instructions
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1020-16
Service Bulletin/Repair Instructions
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
1018-16
Service Bulletin/Repair Instructions
1018-16 SYMPTOM DIAGNOSTICS - NOISE
1017-16
Service Bulletin/Repair Instructions
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL17
Service Bulletin/Repair Instructions
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
18SP713REV 18SP7
Service Bulletin/Repair Instructions
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
FL718
Service Bulletin/Repair Instructions
FL718 FRONT AXLE HUB RATING
SB0006
Service Bulletin/Repair Instructions
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
16-032
Service Bulletin/Repair Instructions
16-032_DETROIT STANDARD DIAGNOSTIC TIME FOR GHG14 AFTERTREATMENT DEVICE CHECKLIST UPDATED
16 TS-18
Service Bulletin/Repair Instructions
16TS18 EPA10 AND LATER DD AUTO-ELEVATE FEATURE
09 10-16
Service Bulletin/Repair Instructions
0910-16 SPN 3251 (ACM) (GHG17)
09 09-16
Service Bulletin/Repair Instructions
0909-16 EXCESSIVE OIL CONSUMPTION
09 06-16
Service Bulletin/Repair Instructions
0906-16 LOW PRESSURE FUEL PUMP
09 05-16
Service Bulletin/Repair Instructions
0905-16 SPN 100 (MCM) (GHG17)
09 02-16
Service Bulletin/Repair Instructions
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
09 01-16
Service Bulletin/Repair Instructions
0901-16 SPN 5927 (MCM) (GHG17)
18SP732
Service Bulletin/Repair Instructions
GHG17 MEDIUM DUTY OIL FILTER KIT SPECIAL NOTICE
16 TL-15
Service Bulletin/Repair Instructions
16TL15 GHG17 HEAVY DUTY (HD) TEST ELECTRONIC CONTROL UNITS (ECUS)
16 TS-17
Service Bulletin/Repair Instructions
16TS17 GHG17 DD PLATFORM AMBIENT AIR TEMPERATURE SENSOR AND FAULT CODES
08 14-16
Service Bulletin/Repair Instructions
0814-16 SPN 5016 (ACM) (GHG17)
08 13-16
Service Bulletin/Repair Instructions
0813-16 SPN 3251 (ACM) (GHG17)
08 11-16
Service Bulletin/Repair Instructions
0811-16 CAMSHAFT AND IDLER GEAR
08 10-16
Service Bulletin/Repair Instructions
0810-16 SYMPTOM DIAGNOSTIC NOISE
16 TS-16
Service Bulletin/Repair Instructions
16TS16 DETROIT DT12 TRANSMISSION OIL AND OIL FILL/DRAIN PLUG WASHERS
08 09-16
Service Bulletin/Repair Instructions
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
16 TS-14
Service Bulletin/Repair Instructions
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
08 05-16
Service Bulletin/Repair Instructions
0808-16 SYMPTOM DIAGNOSTICS - ENGINE BRAKE
08 04-16
Service Bulletin/Repair Instructions
0804-16 SPN 5444 (MCM) (GHG17)
08 03-16
Service Bulletin/Repair Instructions
0803-16 SYMPTOM DIAGNOSTICS - COOLANT LOSS
ICI16-011
Service Bulletin/Repair Instructions
ALLISON TECH TIP #TT7831EN TRANSMISSION PROGRAMMING
06 12-16
Service Bulletin/Repair Instructions
0612-16 SPN 175 (MCM) (GHG17) AND SPN 175 (MCM); ( EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 11-16
Service Bulletin/Repair Instructions
0611-16 SPN 110 (MCM) (GHG17) AND SPN 110 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 10-16
Service Bulletin/Repair Instructions
0610-16 SPN 111 (CPC) (GHG17) AND SPN 111 (CPC); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 09-16
Service Bulletin/Repair Instructions
0609-16 SPN 174 (MCM) (GHG17), SPN 174 (MCM) (EPA07), SPN 174; (MCM) (EPA10), AND SPN 174 DIAGNOSTIC PROCEDURE
16-022
Service Bulletin/Repair Instructions
NEW DETROIT DIESEL EXHAUST FLUID AWNING STANDARD REPAIR TIME
06 05-16
Service Bulletin/Repair Instructions
0605-16 SPN 625 (CPC)(GHG17) AND SPN 625 (CPC) (EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 01-16
Service Bulletin/Repair Instructions
0601-16 SPN 103 (MCM) (GHG17) AND SPN 103 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0502-16
Service Bulletin/Repair Instructions
FMI 3 Engine Oil Pressure Sensor Circuit Failed High
0504-16
Service Bulletin/Repair Instructions
Inspection of the DD13 Turbocharger
0507-16
Service Bulletin/Repair Instructions
FMI 5 Oil Pressure Sensor Stuck High
0510-16 SPN 2623
Service Bulletin/Repair Instructions
SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
0511-16
Service Bulletin/Repair Instructions
FMI 2 CPC Clock Data Invalid
0513-16
Service Bulletin/Repair Instructions
FMI 2, 3, 4 Remote Accelerator Pedal Supply Voltage
0514-16
Service Bulletin/Repair Instructions
Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
0519-16
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (EPA10;GHG14)
0521-16
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 1 13 Circuit
0524-16
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 3 10 Circuit
0525-16
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 2 10 Circuit
0526-16
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 3 12 Circuit
0527-17
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 1 13 Circuit
0532-16
Service Bulletin/Repair Instructions
SPN 524286 (TCM)
sb2535
Service Bulletin/Repair Instructions
Clutch Release Bearing Grease Hose
sb3233
Service Bulletin/Repair Instructions
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
Service Bulletin/Repair Instructions
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16TL4
Service Bulletin/Repair Instructions
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS9
Service Bulletin/Repair Instructions
16TS9 DD Platform High Pressure Fuel Lines
16TS8
Service Bulletin/Repair Instructions
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16TL5
Service Bulletin/Repair Instructions
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16-010
Service Bulletin/Repair Instructions
Warranty Recognition Program Suspension
16-011
Service Bulletin/Repair Instructions
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
Service Bulletin/Repair Instructions
16TS7 Reman Diesel Particulate Filter Serial Number
16TL3
Service Bulletin/Repair Instructions
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
16-008
Service Bulletin/Repair Instructions
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
Service Bulletin/Repair Instructions
16-009R_OWL Enhancements
16_TL-2
Service Bulletin/Repair Instructions
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0307-16 SPN 723
Service Bulletin/Repair Instructions
0307-16 SPN 723 (MCM) March
16-007
Service Bulletin/Repair Instructions
Canadian Warranty Parts Return Address Change
16TS5
Service Bulletin/Repair Instructions
16TS5 Release of the DD Platform Bearing Failure Guide
0304-16 SPN 2791
Service Bulletin/Repair Instructions
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0302-16
Service Bulletin/Repair Instructions
Contaminated Fluids
0301-16 SPN 625
Service Bulletin/Repair Instructions
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
0303-16
Service Bulletin/Repair Instructions
Hydrocarbon Doser Coolant Lines
18SP731
Service Bulletin/Repair Instructions
18SP731 GHG17 Heavy Duty Flywheel Special Notice
SB54-295
Service Bulletin/Repair Instructions
Vehicles built in model year 2016 use a bulkhead module (BHM) with a 500k auto baud rate. If a BHM needs replacement, it must be replaced with the new BHM (A66-03086-000) with a 500k auto baud rate.
SB09-37
Service Bulletin/Repair Instructions
Air Cleaner Modifications for Dusty Environments, 108SD/ 114SD and Business Class M2.
1210-14
Service Bulletin/Repair Instructions
1210-14 Cylinder Head
1207-15
Service Bulletin/Repair Instructions
1207-15 Updated procedures with adding EPA10 to the GHG14 title
1205-15
Service Bulletin/Repair Instructions
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
15TL24
Service Bulletin/Repair Instructions
15TL24 OTC 1750 Revolver Engine Stand
15TS4
Service Bulletin/Repair Instructions
15TS4_Rev2_ EPA07 DD15 Piston Kits
1202-15
Service Bulletin/Repair Instructions
1202-15 Symptom Diagnostics - ATD Checklist
15TS16
Service Bulletin/Repair Instructions
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
14TS16REV
Service Bulletin/Repair Instructions
14TS16REV EXCESSIVE OVERHEAD ENGINE NOISE ON GHG14 DD PLATFORM ENGINES
15M1
Service Bulletin/Repair Instructions
FINAL_15M1_BULLETIN GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
15R2
Service Bulletin/Repair Instructions
15R2 DETROIT AXLE STEERING ARM CAPSCREW INSPECTION
15R3
Service Bulletin/Repair Instructions
15R3 DETROIT AXLE STEERING ARM CAPSCREW REPLACEMENT
18SP722
Service Bulletin/Repair Instructions
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
18SP725
Service Bulletin/Repair Instructions
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
AEO15M1
Service Bulletin/Repair Instructions
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
FL688
Service Bulletin/Repair Instructions
Rear Brake Calipers and Anchor Plates.
15TL21
Service Bulletin/Repair Instructions
15TL21 GHG17 Diagnostic Connector Update
15TL20
Service Bulletin/Repair Instructions
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
15-028
Service Bulletin/Repair Instructions
_NewDetroitCoolantLineSRTs
15-028A
Service Bulletin/Repair Instructions
15-028 New Detroit Coolant Line SRTs
15-029
Service Bulletin/Repair Instructions
_Warranty Recognition Program - Coming Soon
901-15
Service Bulletin/Repair Instructions
901-15 Oil Breather Vent
SB-40-11
Service Bulletin/Repair Instructions
FREIGHTLINER: INFORMATION REGARDING THE PREVENTION OF TIRE FAILURES ON AUTO HAULERS DUE TO OVERLOADED OR INCORRECTLY INFLATED AND/OR EXCESSIVE SPEEDS AND TEMPERATURE. MODEL COLUMBIA, 108SD/114SD, 122SD AND CORONADO, BUSINESS CLASS M2. *PE
805-15
Service Bulletin/Repair Instructions
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
803-15
Service Bulletin/Repair Instructions
803-15 Removal of the Camshaft Housing
802-15
Service Bulletin/Repair Instructions
802-15 SPN 520970 FMI 7 (TCM)
801-15
Service Bulletin/Repair Instructions
801-15 SPN 520999 FMI 7 (TCM)
sb54290
Service Bulletin/Repair Instructions
sb54290 Guidelines for Repairing or Replacing an Electrical Harness
15TS15
Service Bulletin/Repair Instructions
15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
711-15
Service Bulletin/Repair Instructions
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
15TS14 GHG14
Service Bulletin/Repair Instructions
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15
Service Bulletin/Repair Instructions
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
706-15
Service Bulletin/Repair Instructions
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
703-15
Service Bulletin/Repair Instructions
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
702-15
Service Bulletin/Repair Instructions
702-15 DD15 and DD16 Delphi © Exhaust Gas Recirculation Valve Actuator
704-15
Service Bulletin/Repair Instructions
704-15 SPN 4364 (ACM)(EPA10)
sb54292
Service Bulletin/Repair Instructions
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
sb83114
Service Bulletin/Repair Instructions
sb83114 Approved Leak Detection Methods for Air Conditioning
15-017
Service Bulletin/Repair Instructions
15-017 Detroit: Updated Fuel Injector SDTs
15TS12
Service Bulletin/Repair Instructions
15TS12 DD Platform Cylinder Block Oil Gallery Cup Plug Replacement
15TS13
Service Bulletin/Repair Instructions
15TS13 DD Platform Oil Filter Bypass Valve
512-15
Service Bulletin/Repair Instructions
512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod
511-15
Service Bulletin/Repair Instructions
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
509-15
Service Bulletin/Repair Instructions
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
508-15
Service Bulletin/Repair Instructions
508-15 SPN 625 (MCM)( EPA10;GHG14)
507-15
Service Bulletin/Repair Instructions
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
506-15
Service Bulletin/Repair Instructions
506-15 Air Compressor Coolant Lines
505-15
Service Bulletin/Repair Instructions
505-15 SPN 3361 (ACM) (EPA10)
15-015
Service Bulletin/Repair Instructions
15-015 Warranty Exclusions Reminder
15-016
Service Bulletin/Repair Instructions
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
504-15
Service Bulletin/Repair Instructions
504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod
503-15
Service Bulletin/Repair Instructions
503-15 DD13 Exhaust Gas Recirculation Valve Actuator
502-15
Service Bulletin/Repair Instructions
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716
Service Bulletin/Repair Instructions
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
501-15
Service Bulletin/Repair Instructions
501-15 Engine Lifter Brackets
15CSA10
Service Bulletin/Repair Instructions
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
Service Bulletin/Repair Instructions
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
Service Bulletin/Repair Instructions
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
Service Bulletin/Repair Instructions
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
Service Bulletin/Repair Instructions
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
406-15
Service Bulletin/Repair Instructions
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
405-15
Service Bulletin/Repair Instructions
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
404-15
Service Bulletin/Repair Instructions
404-15 SPN 4364 (ACM) (EPA10)
403-15
Service Bulletin/Repair Instructions
403-15 SPN 677 (MCM)(EPA07)
15TL6
Service Bulletin/Repair Instructions
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
402-15
Service Bulletin/Repair Instructions
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
18SP717
Service Bulletin/Repair Instructions
18SP717 DD13 EGR Actuator Replacement
401-15
Service Bulletin/Repair Instructions
401-15 Cylinder Block
sb3133
Service Bulletin/Repair Instructions
sb3133 Step Clamps Are Not Reusable
15-010
Service Bulletin/Repair Instructions
15-010-DLR Transmission Cooler Line Photos
15TS9
Service Bulletin/Repair Instructions
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15
Service Bulletin/Repair Instructions
326-15 Main Shaft Speed Sensor
325-15
Service Bulletin/Repair Instructions
325-15 Symptom Diagnosis - ATD Checklist
324-15
Service Bulletin/Repair Instructions
324-15 External Component Repair
323-15
Service Bulletin/Repair Instructions
323-15 Symptom Diagnostics ? Noise
321-15
Service Bulletin/Repair Instructions
321-15 SPN 4364 (ACM) (GHG14)
320-15
Service Bulletin/Repair Instructions
320-15 SPN 4374 (ACM) (GHG14)
15-009 - Detroit
Service Bulletin/Repair Instructions
15-009_Detroit_New_SDTs
15TL5
Service Bulletin/Repair Instructions
15TL5 DAVCO Shop Pro® FXP 95
308-15
Service Bulletin/Repair Instructions
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
307-15
Service Bulletin/Repair Instructions
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
306-15
Service Bulletin/Repair Instructions
306-15 SPN 3246 (ACM)(EPA10;GHG14)
15TL4
Service Bulletin/Repair Instructions
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
304-15
Service Bulletin/Repair Instructions
304-15 Diagnostic Tests
303-15
Service Bulletin/Repair Instructions
303-15 Contaminated Fluids
302-15
Service Bulletin/Repair Instructions
302-15 Crankshaft Oil Seals
18SP706
Service Bulletin/Repair Instructions
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
18SP712
Service Bulletin/Repair Instructions
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713
Service Bulletin/Repair Instructions
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
301-15
Service Bulletin/Repair Instructions
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
sb01101
Service Bulletin/Repair Instructions
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
15TS8
Service Bulletin/Repair Instructions
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0204-15
Service Bulletin/Repair Instructions
0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment
15TS6
Service Bulletin/Repair Instructions
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
0203-15
Service Bulletin/Repair Instructions
0203-15 Oil Filter Stand Pipe
15TS5
Service Bulletin/Repair Instructions
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
0202-15
Service Bulletin/Repair Instructions
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
0201-15
Service Bulletin/Repair Instructions
0201-15 SPN 3250 FMI 31 - GHG14
15TS2
Service Bulletin/Repair Instructions
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1
Service Bulletin/Repair Instructions
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder Misfire At Idle
0108-15
Service Bulletin/Repair Instructions
0108-15 SPN 1323 through 1328 (MCM) (GHG14)
0107-15
Service Bulletin/Repair Instructions
0107-15 Enhanced Steam Clean
0106-15
Service Bulletin/Repair Instructions
0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
0105-15
Service Bulletin/Repair Instructions
0105-15 SPN 102 (MCM) (GHG14)
0104-15
Service Bulletin/Repair Instructions
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
102-15
Service Bulletin/Repair Instructions
102-15 High Pressure Fuel Pump - Two-Filter System
0101-15
Service Bulletin/Repair Instructions
0101-15 SPN 4364 (ACM) (EPA10)
18SP687
Service Bulletin/Repair Instructions
18SP687 DD15 16 EGR Actuator Replacement
sb83155
Service Bulletin/Repair Instructions
sb83155 Espar Service Information
1110-14
Service Bulletin/Repair Instructions
1110-14 EPA10 DOC Inlet Pressure Sensor
1108-14
Service Bulletin/Repair Instructions
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
1105-14
Service Bulletin/Repair Instructions
1105-14 Flywheel, Ring Gear and Flywheel Housing
1104-14
Service Bulletin/Repair Instructions
1104-14 Metal in the Fuel System
1102-14
Service Bulletin/Repair Instructions
1102-14 DD13 Cylinder Head R&R
1101-14
Service Bulletin/Repair Instructions
1101-14 DD15 and DD16 Cylinder Head
18SP707
Service Bulletin/Repair Instructions
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
18SP708
Service Bulletin/Repair Instructions
18SP708Rev EPA07 10 Three-Filter Fuel
18SP711
Service Bulletin/Repair Instructions
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
14TL8
Service Bulletin/Repair Instructions
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS19
Service Bulletin/Repair Instructions
14TS19Rev DD Platform High Pressure Fuel Lines
14-036
Service Bulletin/Repair Instructions
14-036-DLR DTNA & JAD Highlights - Q3
14-038
Service Bulletin/Repair Instructions
14-038 Additional Detroit Standard Repair Times
14-038A
Service Bulletin/Repair Instructions
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
Service Bulletin/Repair Instructions
14-039 New Detroit Standard Diagnostic Times
14-039A
Service Bulletin/Repair Instructions
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
Service Bulletin/Repair Instructions
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
Service Bulletin/Repair Instructions
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
Service Bulletin/Repair Instructions
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
Service Bulletin/Repair Instructions
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
Service Bulletin/Repair Instructions
14TL9 Special Tool Warranty Program.
14TS30
Service Bulletin/Repair Instructions
14TS30 Aftertreatment Harness Diagnostics
14TL7
Service Bulletin/Repair Instructions
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
Service Bulletin/Repair Instructions
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
1010-14
Service Bulletin/Repair Instructions
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
Service Bulletin/Repair Instructions
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
Service Bulletin/Repair Instructions
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
Service Bulletin/Repair Instructions
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
14TS28
Service Bulletin/Repair Instructions
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1007-14
Service Bulletin/Repair Instructions
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
Service Bulletin/Repair Instructions
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
Service Bulletin/Repair Instructions
1005-14 Oil Coolant Module
1003-14
Service Bulletin/Repair Instructions
1003-14 Rough Running or Stalling.
18SP684REV4
Service Bulletin/Repair Instructions
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
Service Bulletin/Repair Instructions
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
Service Bulletin/Repair Instructions
sb2080 Australian CST M1400 Isolated Radiator Retrofit
sb54287
Service Bulletin/Repair Instructions
sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
sbw5460
Service Bulletin/Repair Instructions
sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
14TS21
Service Bulletin/Repair Instructions
14TS21 HDEP Camshaft Position Sensor Change
14-017R
Service Bulletin/Repair Instructions
14-017R Revised: Detroit Addition of Admin Time
FAB160
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB160 Rock Guard
FAB161
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB161 Watson and Chalin Suspension
FAB162
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB162 Remote Stop Start
14TL2
Service Bulletin/Repair Instructions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
Service Bulletin/Repair Instructions
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
Service Bulletin/Repair Instructions
14-028 Remy Extended Coverage Direct File
14-027
Service Bulletin/Repair Instructions
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
Service Bulletin/Repair Instructions
14-026-DLR SelecTruck Warranty Enhancements
715-14
Service Bulletin/Repair Instructions
715-14 Symptom Diagnostics - Coolant Los
14-022
Service Bulletin/Repair Instructions
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
Service Bulletin/Repair Instructions
14-023 Detroit Axles Pre-Approval Changes
14-024
Service Bulletin/Repair Instructions
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
Service Bulletin/Repair Instructions
714-14 Symptom Diagnostics - Low Engine Compression
713-14
Service Bulletin/Repair Instructions
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
Service Bulletin/Repair Instructions
712-14 Engine Coolant Temperature
20-73
Service Bulletin/Repair Instructions
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75
Service Bulletin/Repair Instructions
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
54-218
Service Bulletin/Repair Instructions
54-218 - Adding Daytime Running Lights (DRL)Option to Business Class M2 Vehicles
54-285
Service Bulletin/Repair Instructions
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
16 TS-12
Service Bulletin/Repair Instructions
DETROIT APPROVED PRIMING TOOLS FOR THE KM63 GEN2 FUEL SYSTEMDETROIT APPROVED PRIMING
sb0038
Service Bulletin/Repair Instructions
sb0038 00-38 - Vibration Troubleshooting: Finding the Cause
14TS5
Service Bulletin/Repair Instructions
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
0228-14
Service Bulletin/Repair Instructions
0228-14 Engine Oil Leaks - Oil Dye Method
14TS4
Service Bulletin/Repair Instructions
14TS4 Valve and Liner Installation Tool Issue
13wo3re
Service Bulletin/Repair Instructions
13wo3rev2_final Actual Labor Hours on Detroit Claims
0224-14
Service Bulletin/Repair Instructions
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0219-14
Service Bulletin/Repair Instructions
0219-14 Metal in Fuel
0215-14
Service Bulletin/Repair Instructions
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0210-14
Service Bulletin/Repair Instructions
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14
Service Bulletin/Repair Instructions
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0202-14
Service Bulletin/Repair Instructions
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0229-14
Service Bulletin/Repair Instructions
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14
Service Bulletin/Repair Instructions
0233-14 SPN 51 FMI 2 - All Years
0237-14
Service Bulletin/Repair Instructions
0237-14 Engine Brake Solenoid
0238-14
Service Bulletin/Repair Instructions
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
Service Bulletin/Repair Instructions
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
54-281
Service Bulletin/Repair Instructions
54-281 - Fuel Level Sender Guard Installation
FAB155
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB155 Polished stainless steel steps
SB4934
Service Bulletin/Repair Instructions
DEF Tank Coolant Valve O-Ring Kit
FAB152
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB152 Chassis Module Relocation
FAB147
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB147 Vehicle Data Recorder and Seat Belt Display
FAB149
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB149 heated seats
FAB150
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB150 Bumper guide lights
33-28
Service Bulletin/Repair Instructions
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30
Service Bulletin/Repair Instructions
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
54-280
Service Bulletin/Repair Instructions
54-280 - Video Available for Servicing APEX 150 Sealed 16-Pin Connectors
532-13
Service Bulletin/Repair Instructions
532-13 Description and Operation of the Two-Stage Valve - Two-Filter Systems
530-13
Service Bulletin/Repair Instructions
530-13 Low Pressure Fuel Pump ? Two-Filter Fuel System
529-13
Service Bulletin/Repair Instructions
529-13 Operation of the Fuel System - Two-Filter Fuel System
525-13
Service Bulletin/Repair Instructions
525-13 SPN 2791-FMI 7 ? ALL YEARS
sb3529
Service Bulletin/Repair Instructions
sb3529 Axle Alignment Specifications
sb4932
Service Bulletin/Repair Instructions
sb4932 DEF Gauge Reading Incorrectly
12-039
Service Bulletin/Repair Instructions
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
Service Bulletin/Repair Instructions
12-040-DLR Roof Fairing Removal Program
12-041
Service Bulletin/Repair Instructions
12-041-DLR Over the Counter No Hassle Warranty (OTC)
12-038
Service Bulletin/Repair Instructions
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
sb4724
Service Bulletin/Repair Instructions
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
sb3131
Service Bulletin/Repair Instructions
sb3131 Huck-Spin 2 Changeover
12-022
Service Bulletin/Repair Instructions
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
sb4267
Service Bulletin/Repair Instructions
sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.