Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
WI21-009
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
SB35-036
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
SB54-278
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeterî is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
TechTalk2039
Tech Talk Discussion for DD15 GHG14 EGR linkage hex nuts.
SB54-327
Service Bulletin for Lengthening the Backup Light Harness. Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
SB54-290
Service Bulletin on guidelines for repairing or replacing an electrical harness.
SB83-119
Service Bulletin for A/C system receiver-drier replacement guidelines.
SB72-043
Service Bulletin revision for window regular refit. Argosy is now included as an applicable vehicle. This version replaces the previous version dated 9/27/19.
19-012WP
Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
19-013WI
Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized Demonstrator Program
19-010WI
Warranty Information Letter updated to communicate warranty system updates.
19-008WI
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19-009WI
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
DOC-1034452
Training Solution created by DTNA to provide guidance to customers when searching for service information for components and systems not owned by Daimler Trucks North America (DTNA).
sb54311
Service Bulletin- sb54311 ICU Odometer Programming
fp00024
fp00024 Cable-Tie Reference
sb00044
Reminder: Paper Service Bulletin Mailings Are Discontinued
DOC-1034171
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
1208-18
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
1212-18
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
1213-18
Service Information Bulletin
18-032-NoDefectF
Warranty Bulletin for charge back exemtions
sb9817 Paint Sup
Service Bulletin 9817- Paint Supplier Change
sb9818 Repaintin
Service Bulletin 9818- Repainting Plastic Bumper Components
sb0036
Operating Hours for the Customer Assistance Center
fp00020
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
sb00042
sb00042 Flood Damage Repair GuidelinesB
sb1512
sb1512 Accessories On When Key is OffB
sb2046
sb2046 ABA Hose Clamp Torque Values
sb2052
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
sb2053
sb2053 New Stainless Steel Lower Radiator Tubes
sb2074
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2084
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
sb31034
sb31034 Towing ProceduresB
sb54107
sb54107 Changing Odometer Units
sb54109
sb54109 RAMI Antenna
sb54122
sb54122 ICU3 Service Cluster AvailableB
sb54148
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb54194
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54202
sb54202 Rerouting the DDEC IV Relative-Humidity-Sensor Harness
sb54296
sb54296 Fuel Level Sending Unit RetrofitB
sb98020
sb98020 Axalta Paint Finish CareB
sb9815
sb9815 Paint Finish StandardsB
fp47019
fp47019 25-Inch Diameter Fuel Tanks
17-029
Computer Hook-Up Standard Diagnostic Time Update
17CSA25
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17-028
OWL Enhancement Service Model Field
17CSA23r
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
17-026
17-026 Holiday Closure 2017
17-027
Warranty Classroom Training in 2018
17TL25
17TL25 TruckCam? Alignment System
14CSA23
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
SS1032974
SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
sb0002
Technical Publications Ordering
sb54289
ICU2M to ICU4M Conversion
SB54289
SB54289 ICU2M TO ICU4M CONVERSION
0525-16
FMI 3,4,5 Digital Output 2 10 Circuit
sb2535
Clutch Release Bearing Grease Hose
sb3233
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16-010
Warranty Recognition Program Suspension
16-011
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
16TS7 Reman Diesel Particulate Filter Serial Number
16-008
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
16-009R_OWL Enhancements
ICI16-006
FL676 Second Revised Bulletin
16-007
Canadian Warranty Parts Return Address Change
FL676
Haldex Life Seal Brake Chambers
SF516A
Freightliner Argosy and Coronado Axle Tower Brackets. Certain vehicles may have an incorrect transverse torque rod tower bracket installed on the rearmost drive axle. An incorrect axle tower bracket results in poor alignment of the transverse torque rod and premature failures of the transverse rod tapered pin and/or bushing. The axle tower bracket on the rearmost drive axle and the transverse torque rod will be replaced.
15TL20
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
15-028
_NewDetroitCoolantLineSRTs
15-028A
15-028 New Detroit Coolant Line SRTs
15-029
_Warranty Recognition Program - Coming Soon
15-017
15-017 Detroit: Updated Fuel Injector SDTs
15-015
15-015 Warranty Exclusions Reminder
15-016
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15CSA10
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
15TL6
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
sb3133
sb3133 Step Clamps Are Not Reusable
15-010
15-010-DLR Transmission Cooler Line Photos
REF-15-010
DAIMLER TRUCKS: ON CERTAIN TRUCKS, A POTENTIAL TO A SERIOUS TRANSMISSION COOLER LEAKAGE IN CERTAIN AREAS AS JUMPER TO MAIN LINE, REAR CRIMP MAIN LINE, FITTING ON COOLER, JUMPER TO COOLER, FITTING ON TRANSMISSION, FORWARD CRIMP LINE, FITTING TO TRANSMISSION FITTING. NO YEARS LISTED. *PE
15-009 - Detroit
15-009_Detroit_New_SDTs
15TL5
15TL5 DAVCO Shop Pro® FXP 95
15TL4
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
sb01101
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
sb54290
sb54290 Guidelines for Repairing or Replacing an Electrical Harness
ICI15-003
ICI15-003-DLR FL676 - Interim Recall Notice
FL673-A
DAIMLER TRUCKS: INFORMATION ON RECALL CAMPAIGN REGARDING DEFECT OF THE RELEASE PARK BRAKE VALVE. MKODELS AFFECTED ARE : SPECIFIC FREIGHTLINER CASCADIA 122SD, ARGOSY VEHICLES MANUFACTURED JULY2013- OCT 2014. *LJ
14TL8
14TL8 TorcUP? Non-Impacting Torque Tool.
14-036
14-036-DLR DTNA & JAD Highlights - Q3
14-038
14-038 Additional Detroit Standard Repair Times
14-038A
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
14-039 New Detroit Standard Diagnostic Times
14-039A
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
14TL9 Special Tool Warranty Program.
14TL7
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
1010-14
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1007-14
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
1005-14 Oil Coolant Module
1003-14
1003-14 Rough Running or Stalling.
18SP684REV4
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
sb2080 Australian CST M1400 Isolated Radiator Retrofit
sb54287
sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
sbw5460
sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
14-017R
14-017R Revised: Detroit Addition of Admin Time
14-029
14-029 New Detroit Standard Diagnostic Times
14TL2
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
14-028 Remy Extended Coverage Direct File
14TS19
14TS19 DD Platform High Pressure Fuel Lines
14-027
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
14-026-DLR SelecTruck Warranty Enhancements
715-14
715-14 Symptom Diagnostics - Coolant Los
14-022
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
14-023 Detroit Axles Pre-Approval Changes
14-024
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
714-14 Symptom Diagnostics - Low Engine Compression
713-14
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
712-14 Engine Coolant Temperature
20-73
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
54-215
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
14TS5
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
0228-14
0228-14 Engine Oil Leaks - Oil Dye Method
14TS4
14TS4 Valve and Liner Installation Tool Issue
13wo3re
13wo3rev2_final Actual Labor Hours on Detroit Claims
0224-14
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0219-14
0219-14 Metal in Fuel
0215-14
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0210-14
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0202-14
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0229-14
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14
0233-14 SPN 51 FMI 2 - All Years
0237-14
0237-14 Engine Brake Solenoid
0238-14
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
33-28
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
sb54215
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
sb60152
sb60152 Argosy Cab Water-Leak Detection and Repair
12-039
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
12-040-DLR Roof Fairing Removal Program
12-041
12-041-DLR Over the Counter No Hassle Warranty (OTC)
12-038
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
sb4724
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
sb3131
sb3131 Huck-Spin 2 Changeover
12-022
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
sb4267
sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.