SB83-124
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Large Temperature Swings at A/C Outlet. Minor note: added an update of document previously submitted. The related VMRS codes are added
Vehicle report
2009 FREIGHTLINER BUSINESS CLASS M2
Service bulletins
405 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB-54-259-FTL
Service Bulletin/Repair Instructions
Revised Technical Service Bulletin for chassis module replacement
WI21-009
Service Bulletin/Repair Instructions
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Service Bulletin/Repair Instructions
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
SB35-036
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
SB54-278
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeterî is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
SB54-319
Service Bulletin/Repair Instructions
Service Bulletin for severe duty main PDM installation for vehicles operating in severe moisture and/or corrosive environments.
17TS9
Service Bulletin/Repair Instructions
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found on TechLit.
19TL-15
Service Bulletin/Repair Instructions
Tool Letter for ICC5 Programming Cable
SB32-054
Service Bulletin/Repair Instructions
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
SB47-027
Service Bulletin/Repair Instructions
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
18SP725Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
19-008WI
Service Bulletin/Repair Instructions
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19-009WI
Service Bulletin/Repair Instructions
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
fp46907
Service Bulletin/Repair Instructions
Steering Intermediate Shaft Replacement
sb54308
Service Bulletin/Repair Instructions
DiagnosticLink support programming of both chassis and powertrain ECUs
DOC-1034220
Service Bulletin/Repair Instructions
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
sb54311
Service Bulletin/Repair Instructions
Service Bulletin- sb54311 ICU Odometer Programming
fp00024
Service Bulletin/Repair Instructions
fp00024 Cable-Tie Reference
sbw00018
Service Bulletin/Repair Instructions
Service Bulletin M2 Heated Windshield Modification
sb0039
Service Bulletin/Repair Instructions
Service Bulletin New "Natural Gas Vehicle Information" Webpage
1208-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
1212-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
1213-18
Service Bulletin/Repair Instructions
Service Information Bulletin
sb0006
Service Bulletin/Repair Instructions
Service Bulletin- sb0006 Freightliner Courtesy Engineering Policy
GHG17
Service Bulletin/Repair Instructions
Letter to customer on Coverage Extension GHG17 After Treatment
sb9810 Chassis P
Service Bulletin/Repair Instructions
Service Bulletin 9810- Chassis Paint Usage
sb9816 DuPont Im
Service Bulletin/Repair Instructions
Service Bulletin 9816- DuPont? Imron® Elite
sb9819 Body Pain
Service Bulletin/Repair Instructions
Service Bulletin 9819- Body Paint Repair Process
SPN 2631 0904-18
Service Bulletin/Repair Instructions
Service information Bulletin
M2 Roof Repair
Service Bulletin/Repair Instructions
Freightliner M2 Roof Repair
sb3125 AirLiner
Service Bulletin/Repair Instructions
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
sb0036
Service Bulletin/Repair Instructions
Operating Hours for the Customer Assistance Center
0505-18
Service Bulletin/Repair Instructions
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
fp00020
Service Bulletin/Repair Instructions
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
sb31037
Service Bulletin/Repair Instructions
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed. The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
sb31038
Service Bulletin/Repair Instructions
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn. This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
sb54299
Service Bulletin/Repair Instructions
sb54299 ICU3 to ICU3S Replacement Guidelines
sb88048
Service Bulletin/Repair Instructions
A new design for the M2 grille went into prduction on February 5, 2018. The hood design has also changed slightly to accommodate a different grille fastening strategy. The old grille and hood part part numbers will no longer be produced, and will supersede to the new design with new part numbers.
0405-18
Service Bulletin/Repair Instructions
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
0312-18
Service Bulletin/Repair Instructions
0312-18 Installation Output Shaft Seal
0311-18
Service Bulletin/Repair Instructions
0311-18 Installation of the Main Shaft Speed Sensor
DOC-1033322
Service Bulletin/Repair Instructions
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
sb15020
Service Bulletin/Repair Instructions
sb15020 Alternator Remote Sense WiringB
sb2042
Service Bulletin/Repair Instructions
sb2042 Coolant Overflow Hose
sb2046
Service Bulletin/Repair Instructions
sb2046 ABA Hose Clamp Torque Values
sb2052
Service Bulletin/Repair Instructions
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
sb2053
Service Bulletin/Repair Instructions
sb2053 New Stainless Steel Lower Radiator Tubes
sb2062
Service Bulletin/Repair Instructions
sb2062 Removing the Shipping Plate from the Fan Hub on ISB Engines
sb2068
Service Bulletin/Repair Instructions
sb2068 Conventional Fully-Formulated Coolant with SCA Color Change
sb2069
Service Bulletin/Repair Instructions
sb2069 Kysor Fan Clutch Sticking
sb2070
Service Bulletin/Repair Instructions
sb2070 EPA07 and Newer Gentech Coolant-Level Sensor Testing
sb2071
Service Bulletin/Repair Instructions
sb2071 FEPTO Snowplow, Isolated Radiator Retrofit, EPA07, DD-13B
sb2074
Service Bulletin/Repair Instructions
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2079
Service Bulletin/Repair Instructions
sb2079 Premature Belt Wear on Cummins ISC ISL
sb2083
Service Bulletin/Repair Instructions
sb2083 FluidXchange Tool and FittingsB
sb31034
Service Bulletin/Repair Instructions
sb31034 Towing ProceduresB
sb3251
Service Bulletin/Repair Instructions
sb3251 Replacing or Upgrading Airliner 40K Transverse Torque RodsB
sb4256
Service Bulletin/Repair Instructions
sb4256 Enabling M2 Exhaust Brake Lights
sb4267
Service Bulletin/Repair Instructions
sb4267 Brake Shimmy?Meritor® SteeLite X30? Brake Drum with Excessive RunoutB
sb54122
Service Bulletin/Repair Instructions
sb54122 ICU3 Service Cluster AvailableB
sb54148
Service Bulletin/Repair Instructions
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb54194
Service Bulletin/Repair Instructions
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54224
Service Bulletin/Repair Instructions
sb54224 New Severe-Duty Taillight and Trailer PDMs (Power Distribution Modules)
sb54251
Service Bulletin/Repair Instructions
sb54251 Condensation and Possible Water Entry Points in Headlamp Assemblies
sb54296
Service Bulletin/Repair Instructions
sb54296 Fuel Level Sending Unit RetrofitB
sb98020
Service Bulletin/Repair Instructions
sb98020 Axalta Paint Finish CareB
17-029
Service Bulletin/Repair Instructions
Computer Hook-Up Standard Diagnostic Time Update
17CSA25
Service Bulletin/Repair Instructions
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17TL26
Service Bulletin/Repair Instructions
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17TL27
Service Bulletin/Repair Instructions
17TL27 Injector Cup Tool DSN930E17001
17TL28
Service Bulletin/Repair Instructions
17TL28 Fuel Injector Removal Tool DSN930E17004
17CSA24
Service Bulletin/Repair Instructions
17CSA24 Holiday Schedule for the Detroit Customer Support Center
SS1033289
Service Bulletin/Repair Instructions
Service Solution SS 1033289 BHM Fault Code SPN 524249 / FMI 7
17-028
Service Bulletin/Repair Instructions
OWL Enhancement Service Model Field
17CSA23r
Service Bulletin/Repair Instructions
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
17-026
Service Bulletin/Repair Instructions
17-026 Holiday Closure 2017
17-027
Service Bulletin/Repair Instructions
Warranty Classroom Training in 2018
17TL25
Service Bulletin/Repair Instructions
17TL25 TruckCam? Alignment System
SS1032728
Service Bulletin/Repair Instructions
SS 1032728 Bulkhead Module Fault Codes 524280 thru 524286 with FMI 7 Clarification
1110-17
Service Bulletin/Repair Instructions
Exhaust and Exhaust Gas Recirculation
1105-17
Service Bulletin/Repair Instructions
EPA10, GHG14 and GHG17 Diesel Particulate Filters
14CSA23
Service Bulletin/Repair Instructions
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
17TS17Rev
Service Bulletin/Repair Instructions
Instructions for CSC Diagnostic Support
17-023
Service Bulletin/Repair Instructions
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
0903-17
Service Bulletin/Repair Instructions
Engine Manufacturer Diagnostics
SS1033180
Service Bulletin/Repair Instructions
Service Solution SS 1033180 BHM Fault Code SPN 524251 FMI 7 - Extr...
SS1032974
Service Bulletin/Repair Instructions
SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
sb0002
Service Bulletin/Repair Instructions
Technical Publications Ordering
SS1033094
Service Bulletin/Repair Instructions
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
0409-17
Service Bulletin/Repair Instructions
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
SS1032998
Service Bulletin/Repair Instructions
Service Solution SS 1032998 M2 mirror wind noise
SS1032989
Service Bulletin/Repair Instructions
Service Solution SS 1032989 â BHM Fault Code Changes
0202-17
Service Bulletin/Repair Instructions
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
0141-17
Service Bulletin/Repair Instructions
0141-17 SPN 2659 (MCM) (EPA10)
0120-17
Service Bulletin/Repair Instructions
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17
Service Bulletin/Repair Instructions
0118-17 Symptom Diagnostics - Oil Leaks
0114-17
Service Bulletin/Repair Instructions
0114-17 SPN 2791 (MCM) (EPA07;EPA10)
1213-16
Service Bulletin/Repair Instructions
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
16TS24
Service Bulletin/Repair Instructions
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
18SP718
Service Bulletin/Repair Instructions
18SP718Rev EPA07 DD1516 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
16TL20
Service Bulletin/Repair Instructions
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
1021-16
Service Bulletin/Repair Instructions
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1020-16
Service Bulletin/Repair Instructions
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
1018-16
Service Bulletin/Repair Instructions
1018-16 SYMPTOM DIAGNOSTICS - NOISE
1017-16
Service Bulletin/Repair Instructions
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL17
Service Bulletin/Repair Instructions
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
18SP720REV 18SP7
Service Bulletin/Repair Instructions
18SP720REV 18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
SB0006
Service Bulletin/Repair Instructions
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
09 09-16
Service Bulletin/Repair Instructions
0909-16 EXCESSIVE OIL CONSUMPTION
09 06-16
Service Bulletin/Repair Instructions
0906-16 LOW PRESSURE FUEL PUMP
09 02-16
Service Bulletin/Repair Instructions
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
08 10-16
Service Bulletin/Repair Instructions
0810-16 SYMPTOM DIAGNOSTIC NOISE
08 09-16
Service Bulletin/Repair Instructions
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
16 TS-15
Service Bulletin/Repair Instructions
16TS15 EPA07 AND LATER POWER TAKE-OFF (PTO) DOSING FEATURE
sb3233
Service Bulletin/Repair Instructions
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
Service Bulletin/Repair Instructions
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16TL4
Service Bulletin/Repair Instructions
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS9
Service Bulletin/Repair Instructions
16TS9 DD Platform High Pressure Fuel Lines
16TS8
Service Bulletin/Repair Instructions
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16TL5
Service Bulletin/Repair Instructions
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16-010
Service Bulletin/Repair Instructions
Warranty Recognition Program Suspension
16-011
Service Bulletin/Repair Instructions
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
Service Bulletin/Repair Instructions
16TS7 Reman Diesel Particulate Filter Serial Number
16TL3
Service Bulletin/Repair Instructions
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
16-008
Service Bulletin/Repair Instructions
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
Service Bulletin/Repair Instructions
16-009R_OWL Enhancements
16_TL-2
Service Bulletin/Repair Instructions
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0307-16 SPN 723
Service Bulletin/Repair Instructions
0307-16 SPN 723 (MCM) March
16-007
Service Bulletin/Repair Instructions
Canadian Warranty Parts Return Address Change
16TS5
Service Bulletin/Repair Instructions
16TS5 Release of the DD Platform Bearing Failure Guide
0304-16 SPN 2791
Service Bulletin/Repair Instructions
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0302-16
Service Bulletin/Repair Instructions
Contaminated Fluids
0301-16 SPN 625
Service Bulletin/Repair Instructions
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
0303-16
Service Bulletin/Repair Instructions
Hydrocarbon Doser Coolant Lines
1210-14
Service Bulletin/Repair Instructions
1210-14 Cylinder Head
1207-15
Service Bulletin/Repair Instructions
1207-15 Updated procedures with adding EPA10 to the GHG14 title
1205-15
Service Bulletin/Repair Instructions
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
15TL24
Service Bulletin/Repair Instructions
15TL24 OTC 1750 Revolver Engine Stand
15TS4
Service Bulletin/Repair Instructions
15TS4_Rev2_ EPA07 DD15 Piston Kits
1202-15
Service Bulletin/Repair Instructions
1202-15 Symptom Diagnostics - ATD Checklist
15TS16
Service Bulletin/Repair Instructions
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1201-15
Service Bulletin/Repair Instructions
1201-15 Crankshaft and Bearings
18SP729
Service Bulletin/Repair Instructions
18SP729 ? EPA07 10 Three-Filter Fuel
18SP730
Service Bulletin/Repair Instructions
18SP730 ? EPA07 10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
18SP722
Service Bulletin/Repair Instructions
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
18SP725
Service Bulletin/Repair Instructions
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
AEO15M1
Service Bulletin/Repair Instructions
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
FL688
Service Bulletin/Repair Instructions
Rear Brake Calipers and Anchor Plates.
15TL20
Service Bulletin/Repair Instructions
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
15-028
Service Bulletin/Repair Instructions
_NewDetroitCoolantLineSRTs
15-028A
Service Bulletin/Repair Instructions
15-028 New Detroit Coolant Line SRTs
15-029
Service Bulletin/Repair Instructions
_Warranty Recognition Program - Coming Soon
805-15
Service Bulletin/Repair Instructions
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
803-15
Service Bulletin/Repair Instructions
803-15 Removal of the Camshaft Housing
711-15
Service Bulletin/Repair Instructions
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
15TS14 GHG14
Service Bulletin/Repair Instructions
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15
Service Bulletin/Repair Instructions
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
706-15
Service Bulletin/Repair Instructions
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
703-15
Service Bulletin/Repair Instructions
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
702-15
Service Bulletin/Repair Instructions
702-15 DD15 and DD16 Delphi © Exhaust Gas Recirculation Valve Actuator
704-15
Service Bulletin/Repair Instructions
704-15 SPN 4364 (ACM)(EPA10)
sb54278
Service Bulletin/Repair Instructions
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sb54292
Service Bulletin/Repair Instructions
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
15-017
Service Bulletin/Repair Instructions
15-017 Detroit: Updated Fuel Injector SDTs
511-15
Service Bulletin/Repair Instructions
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
510-15
Service Bulletin/Repair Instructions
510-15 SID 057 04 - PWM Driver #1 Shorted to Ground
509-15
Service Bulletin/Repair Instructions
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
507-15
Service Bulletin/Repair Instructions
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
506-15
Service Bulletin/Repair Instructions
506-15 Air Compressor Coolant Lines
505-15
Service Bulletin/Repair Instructions
505-15 SPN 3361 (ACM) (EPA10)
15-015
Service Bulletin/Repair Instructions
15-015 Warranty Exclusions Reminder
15-016
Service Bulletin/Repair Instructions
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
502-15
Service Bulletin/Repair Instructions
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716
Service Bulletin/Repair Instructions
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
501-15
Service Bulletin/Repair Instructions
501-15 Engine Lifter Brackets
sb2084
Service Bulletin/Repair Instructions
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
15CSA10
Service Bulletin/Repair Instructions
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
Service Bulletin/Repair Instructions
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
Service Bulletin/Repair Instructions
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
Service Bulletin/Repair Instructions
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
Service Bulletin/Repair Instructions
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
406-15
Service Bulletin/Repair Instructions
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
405-15
Service Bulletin/Repair Instructions
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
404-15
Service Bulletin/Repair Instructions
404-15 SPN 4364 (ACM) (EPA10)
403-15
Service Bulletin/Repair Instructions
403-15 SPN 677 (MCM)(EPA07)
15TL6
Service Bulletin/Repair Instructions
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
402-15
Service Bulletin/Repair Instructions
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
401-15
Service Bulletin/Repair Instructions
401-15 Cylinder Block
sb3133
Service Bulletin/Repair Instructions
sb3133 Step Clamps Are Not Reusable
15-010
Service Bulletin/Repair Instructions
15-010-DLR Transmission Cooler Line Photos
15TS9
Service Bulletin/Repair Instructions
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
15-009 - Detroit
Service Bulletin/Repair Instructions
15-009_Detroit_New_SDTs
15TL5
Service Bulletin/Repair Instructions
15TL5 DAVCO Shop Pro® FXP 95
307-15
Service Bulletin/Repair Instructions
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
15TL4
Service Bulletin/Repair Instructions
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
18SP712
Service Bulletin/Repair Instructions
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
sb01101
Service Bulletin/Repair Instructions
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
15TS8
Service Bulletin/Repair Instructions
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
15TS6
Service Bulletin/Repair Instructions
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
15TS5
Service Bulletin/Repair Instructions
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
0202-15
Service Bulletin/Repair Instructions
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
15TS2
Service Bulletin/Repair Instructions
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1
Service Bulletin/Repair Instructions
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder Misfire At Idle
0104-15
Service Bulletin/Repair Instructions
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
18SP687
Service Bulletin/Repair Instructions
18SP687 DD15 16 EGR Actuator Replacement
sb83155
Service Bulletin/Repair Instructions
sb83155 Espar Service Information
sb9815
Service Bulletin/Repair Instructions
sb9815 Paint Finish Standards
1110-14
Service Bulletin/Repair Instructions
1110-14 EPA10 DOC Inlet Pressure Sensor
1108-14
Service Bulletin/Repair Instructions
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
1105-14
Service Bulletin/Repair Instructions
1105-14 Flywheel, Ring Gear and Flywheel Housing
1104-14
Service Bulletin/Repair Instructions
1104-14 Metal in the Fuel System
1102-14
Service Bulletin/Repair Instructions
1102-14 DD13 Cylinder Head R&R
18SP707
Service Bulletin/Repair Instructions
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
18SP708
Service Bulletin/Repair Instructions
18SP708Rev EPA07 10 Three-Filter Fuel
18SP711
Service Bulletin/Repair Instructions
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
14TL8
Service Bulletin/Repair Instructions
14TL8 TorcUP? Non-Impacting Torque Tool.
14-036
Service Bulletin/Repair Instructions
14-036-DLR DTNA & JAD Highlights - Q3
14-038
Service Bulletin/Repair Instructions
14-038 Additional Detroit Standard Repair Times
14-038A
Service Bulletin/Repair Instructions
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
Service Bulletin/Repair Instructions
14-039 New Detroit Standard Diagnostic Times
14-039A
Service Bulletin/Repair Instructions
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
Service Bulletin/Repair Instructions
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
Service Bulletin/Repair Instructions
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
Service Bulletin/Repair Instructions
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
Service Bulletin/Repair Instructions
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
Service Bulletin/Repair Instructions
14TL9 Special Tool Warranty Program.
14TL7
Service Bulletin/Repair Instructions
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
Service Bulletin/Repair Instructions
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
1010-14
Service Bulletin/Repair Instructions
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
Service Bulletin/Repair Instructions
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
Service Bulletin/Repair Instructions
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
Service Bulletin/Repair Instructions
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
14TS28
Service Bulletin/Repair Instructions
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1007-14
Service Bulletin/Repair Instructions
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
Service Bulletin/Repair Instructions
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
Service Bulletin/Repair Instructions
1005-14 Oil Coolant Module
1003-14
Service Bulletin/Repair Instructions
1003-14 Rough Running or Stalling.
18SP684REV4
Service Bulletin/Repair Instructions
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
Service Bulletin/Repair Instructions
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
Service Bulletin/Repair Instructions
sb2080 Australian CST M1400 Isolated Radiator Retrofit
920-14
Service Bulletin/Repair Instructions
920-14 Additional Cleaning and Preparing
14TS26
Service Bulletin/Repair Instructions
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
917-14
Service Bulletin/Repair Instructions
917-14 Installation and Removal of the Oil Filter Stand Pipe
916-14
Service Bulletin/Repair Instructions
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
915-14
Service Bulletin/Repair Instructions
915-14 Backwards Running Engine Detecte
913-14
Service Bulletin/Repair Instructions
913-14 Checking for Poor Engine Brake Performance
912-14
Service Bulletin/Repair Instructions
912-14 Coolant in Oil
910-14
Service Bulletin/Repair Instructions
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
909-14
Service Bulletin/Repair Instructions
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
905-14
Service Bulletin/Repair Instructions
905-14 Coolant Level Circuit Failed
18SP706
Service Bulletin/Repair Instructions
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
35-23
Service Bulletin/Repair Instructions
35-23 - Breather Oil Leak on Freightliner Tandem Rear Axles
42-64
Service Bulletin/Repair Instructions
42-64 - Accessing a Service Brake Light Signal on M2 Vehicles
14TS21
Service Bulletin/Repair Instructions
14TS21 HDEP Camshaft Position Sensor Change
14-017R
Service Bulletin/Repair Instructions
14-017R Revised: Detroit Addition of Admin Time
810-14
Service Bulletin/Repair Instructions
810-14 Clutch Position Sensor
809-14
Service Bulletin/Repair Instructions
809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed
14TS20
Service Bulletin/Repair Instructions
14TS20 GHG14 Auto-Elevate Feature
14-029
Service Bulletin/Repair Instructions
14-029 New Detroit Standard Diagnostic Times
802-14
Service Bulletin/Repair Instructions
802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low
FL662
Service Bulletin/Repair Instructions
FL662.-DLR Meritor MSF12 Non-Conforming Front Axle Beams
14TL2
Service Bulletin/Repair Instructions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
Service Bulletin/Repair Instructions
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
Service Bulletin/Repair Instructions
14-028 Remy Extended Coverage Direct File
14TS19
Service Bulletin/Repair Instructions
14TS19 DD Platform High Pressure Fuel Lines
14-027
Service Bulletin/Repair Instructions
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
Service Bulletin/Repair Instructions
14-026-DLR SelecTruck Warranty Enhancements
715-14
Service Bulletin/Repair Instructions
715-14 Symptom Diagnostics - Coolant Los
14-022
Service Bulletin/Repair Instructions
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
Service Bulletin/Repair Instructions
14-023 Detroit Axles Pre-Approval Changes
14-024
Service Bulletin/Repair Instructions
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
Service Bulletin/Repair Instructions
714-14 Symptom Diagnostics - Low Engine Compression
713-14
Service Bulletin/Repair Instructions
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
Service Bulletin/Repair Instructions
712-14 Engine Coolant Temperature
20-73
Service Bulletin/Repair Instructions
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75
Service Bulletin/Repair Instructions
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
54-285
Service Bulletin/Repair Instructions
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
FSB-54-218
Service Bulletin/Repair Instructions
FREIGHTLINER: INFORMATION ON THE OPTION OF ADDING, TO BUSINESS CLASS M2 TRUCKS, THE DAYTIME RUNNING LIGHTS (DRL), DEPENDING ON TYPE OF TRUCK. *PE
512-14
Service Bulletin/Repair Instructions
512-14 FMI 0: DPF Outlet Temperature Very High
18SP684
Service Bulletin/Repair Instructions
18SP684Rev3 EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
sb4930
Service Bulletin/Repair Instructions
sb4930 49-30 - Gentech DEF Coolant-Flow Solenoid, Testing and Replacement
14TS5
Service Bulletin/Repair Instructions
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
0228-14
Service Bulletin/Repair Instructions
0228-14 Engine Oil Leaks - Oil Dye Method
14TS4
Service Bulletin/Repair Instructions
14TS4 Valve and Liner Installation Tool Issue
13wo3re
Service Bulletin/Repair Instructions
13wo3rev2_final Actual Labor Hours on Detroit Claims
0224-14
Service Bulletin/Repair Instructions
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0219-14
Service Bulletin/Repair Instructions
0219-14 Metal in Fuel
0215-14
Service Bulletin/Repair Instructions
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0210-14
Service Bulletin/Repair Instructions
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14
Service Bulletin/Repair Instructions
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0202-14
Service Bulletin/Repair Instructions
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0229-14
Service Bulletin/Repair Instructions
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14
Service Bulletin/Repair Instructions
0233-14 SPN 51 FMI 2 - All Years
0237-14
Service Bulletin/Repair Instructions
0237-14 Engine Brake Solenoid
0238-14
Service Bulletin/Repair Instructions
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
Service Bulletin/Repair Instructions
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
49-31
Service Bulletin/Repair Instructions
49-31 - New DEF Injector Guard
54-281
Service Bulletin/Repair Instructions
54-281 - Fuel Level Sender Guard Installation
13TS22
Service Bulletin/Repair Instructions
Rev DD Platform Fuel Injector Cup Seal
13M2
Service Bulletin/Repair Instructions
13m2 -Final-23-SEP-2013 Field Service Campaign 13M2
13M2-02
Service Bulletin/Repair Instructions
13m2- Equipment Owner Field Service Campaign - 13M2
26-50
Service Bulletin/Repair Instructions
26-50 - M2 Shift Cable Noise, Allison Transmissions
33-28
Service Bulletin/Repair Instructions
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30
Service Bulletin/Repair Instructions
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
54-280
Service Bulletin/Repair Instructions
54-280 - Video Available for Servicing APEX 150 Sealed 16-Pin Connectors
13TS-24
Service Bulletin/Repair Instructions
13TS-24 DD Platform High Pressure Fuel Lines
18SP697
Service Bulletin/Repair Instructions
18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935
18SP698
Service Bulletin/Repair Instructions
18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932
54-275
Service Bulletin/Repair Instructions
54-275 - Chassis-Mounted Trailer PDM, Battery Power Cable Terminal Corrosion
sb2650
Service Bulletin/Repair Instructions
sb2650 M2 Shift Cable Noise, Allison Transmissions
611-13
Service Bulletin/Repair Instructions
611-13 Removal and Installation of the GHG14 Six-Gallon Diesel Exhaust Fluid Tank Header
607-13
Service Bulletin/Repair Instructions
607-13 SPN 3361-FMI 7- EPA10
604-13
Service Bulletin/Repair Instructions
604-13 Performing a Parked Regeneration
603-13
Service Bulletin/Repair Instructions
603-13 SPN 84 -FMI 6 - EPA07-GHG14
13TS17
Service Bulletin/Repair Instructions
13TS17 EPA10-GHG14 Diesel Exhaust Fluid (DEF) in Fuel System-Diesel Fuel in DEF System Contamination
531-13
Service Bulletin/Repair Instructions
531-13 GHG14 DD15 Asymmetrical Turbocharger
528-13
Service Bulletin/Repair Instructions
528-13 SPN 3246-FMI 0 - EPA10 - GHG14
527-13
Service Bulletin/Repair Instructions
527-13 SPN 190-FMI 15,17 GHG14
525-13
Service Bulletin/Repair Instructions
525-13 SPN 2791-FMI 7 ? ALL YEARS
520-13
Service Bulletin/Repair Instructions
520-13 Cylinder Block
518-13
Service Bulletin/Repair Instructions
518-13 SPN 4334-FMI 4 - GHG14
13TS15
Service Bulletin/Repair Instructions
13TS15 EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251-FMI2 - DOC Inlet Pressure Sensor Not Plausible
18SP694
Service Bulletin/Repair Instructions
18SP694 EPA07 DD Platform High Pressure Fuel Flange Service Kit (P-N- A4720785844)
sb4932
Service Bulletin/Repair Instructions
sb4932 DEF Gauge Reading Incorrectly
418-13
Service Bulletin/Repair Instructions
418-13 SPN 2791-FMI 12 - GHG14
414-13
Service Bulletin/Repair Instructions
414-13 Removal and Installation of the GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank Header Unit
413-13
Service Bulletin/Repair Instructions
413-13 GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank
407-13
Service Bulletin/Repair Instructions
407-13 EGR Actuator Slow Learn
13TS10
Service Bulletin/Repair Instructions
13TS10 DD Platform Oil Coolant Module Plugs
311-13
Service Bulletin/Repair Instructions
311-13 SPN 651-FMI 3 - EPA10 - GHG14
310-13
Service Bulletin/Repair Instructions
310-13 Draining the Fuel System Using J-48710 Prior to Repairs
307-13
Service Bulletin/Repair Instructions
307-13 SPN 652-FMI 14 - EPA07
303-13
Service Bulletin/Repair Instructions
303-13 SPN 3242-FMI 4 -EPA10 - GHG14
301-13
Service Bulletin/Repair Instructions
301-13 SPN 5018- FMI 18 -GHG14
13TS6
Service Bulletin/Repair Instructions
13TS6 DD Platform Engine Oil Filter.pdf
13TS5
Service Bulletin/Repair Instructions
13TS5 DD Platform Fuel Filter Module
207-13
Service Bulletin/Repair Instructions
207-13 Removal and Installation of the Camshaft Housing
ICI13-001
Service Bulletin/Repair Instructions
ICI13-001-DLR FL631 - Revised Bulletin
13WO-2
Service Bulletin/Repair Instructions
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
18SP693
Service Bulletin/Repair Instructions
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
FL631
Service Bulletin/Repair Instructions
FL631-DLR Perpendicular Aluminum Air Tank Mounting Brackets
132-13
Service Bulletin/Repair Instructions
132-13 SPN 3597-FMI 4 - EPA10
133-13
Service Bulletin/Repair Instructions
133-13 SPN 4375-FMI 4 and 5 - GHG14
135-13
Service Bulletin/Repair Instructions
135-13 SPN 1243-FMI 14 - GHG14
137-13
Service Bulletin/Repair Instructions
137-13 SPN 2798-FMI 4 - EPA10 - GHG14
139-13
Service Bulletin/Repair Instructions
139-13 SPN 3251-FMI 0, 16, 20, 21 GHG14
13TL2
Service Bulletin/Repair Instructions
13TL2 GHG14 Test Electronic Control Units (ECUs).
143-13
Service Bulletin/Repair Instructions
143-13 Low Pressure Fuel System - Measuring Fuel Pressure Using Fuel System Integrity Check, Two-Filter Fuel System
144-13
Service Bulletin/Repair Instructions
144-13 Removal and Installation of the GHG14 Diesel Exhaust Fluid Lines
145-13
Service Bulletin/Repair Instructions
145-13 Description and Operation of Gear Train and Related Parts
146-13
Service Bulletin/Repair Instructions
146-13 SPN 4335-FMI 1 EPA10
148-13
Service Bulletin/Repair Instructions
148-13 GHG14 DD15 Asymmetrical Turbocharger Exhaust Manifold
129-13
Service Bulletin/Repair Instructions
129-13 DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE
128-13
Service Bulletin/Repair Instructions
128-13 SPN 511403-FMI 0,1,2,3,4,5,6,8,9,10,11,12,13,14
126-13
Service Bulletin/Repair Instructions
126-13 Description and Operation of the DD15 and DD16 Exhaust Gas Recirculaton Cooler
124-13
Service Bulletin/Repair Instructions
124-13 Installation of the DD Platform EGR Actuator Pull Rod
119-13
Service Bulletin/Repair Instructions
119-13 Exhaust Gas Recirculation System - Cleaning
112-13
Service Bulletin/Repair Instructions
112-13 SPN 4364-FMI 18 - GHG14
111-13
Service Bulletin/Repair Instructions
111-13 SPN 4374/FMI 0, 1, 3, 4 - GHG14
110-13
Service Bulletin/Repair Instructions
110-13 SPN 5435-FMI 7 - GHG14
109-13
Service Bulletin/Repair Instructions
109-13 SPN 3250-FMI 31 (ACM2.1) GHG14
108-13
Service Bulletin/Repair Instructions
108-13 SPN 3364-FMI 18 - GHG14
107-13
Service Bulletin/Repair Instructions
107-13 SPN 84-FMI 7 - GHG14
106-13
Service Bulletin/Repair Instructions
106-13 SPN 100-FMI 10 - GHG14
105-13
Service Bulletin/Repair Instructions
105-13 SPN 625-FMI 13 - GHG14
104-13
Service Bulletin/Repair Instructions
104-13 SPN 1592-FMI 13 and 19 - GHG14
103-13
Service Bulletin/Repair Instructions
103-13 SPN 520328-FMI 7 - GHG14
102-13
Service Bulletin/Repair Instructions
102-13 SPN 84-FMI 13, 19, 21 (MCM) EPA10-GHG14
101-13
Service Bulletin/Repair Instructions
101-13 SPN 3563 FMI 21 - GHG14
12-039
Service Bulletin/Repair Instructions
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
Service Bulletin/Repair Instructions
12-040-DLR Roof Fairing Removal Program
12-041
Service Bulletin/Repair Instructions
12-041-DLR Over the Counter No Hassle Warranty (OTC)
ICI12-028
Service Bulletin/Repair Instructions
ICI12-028-DLR FL632 - Interim Notice
12-038
Service Bulletin/Repair Instructions
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
sb4724
Service Bulletin/Repair Instructions
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
1118-12
Service Bulletin/Repair Instructions
1118-12 SPN 705-FMI 5 - GHG14
1113-12
Service Bulletin/Repair Instructions
1113-12 SPN 3226/FMI 20 - GHG14
1112-12
Service Bulletin/Repair Instructions
1112-12 Test C -Two-Filter Fuel System
1102-12
Service Bulletin/Repair Instructions
1102-12 Test A - Two-Filter Fuel System
1101-12
Service Bulletin/Repair Instructions
1101-12 Test B -Two-Filter Fuel System
sb3131
Service Bulletin/Repair Instructions
sb3131 Huck-Spin 2 Changeover
903-12
Service Bulletin/Repair Instructions
903-12 Installation of the Intake Throttle Valve and Adaptor.pdf
12-022
Service Bulletin/Repair Instructions
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
54-265
Service Bulletin/Repair Instructions
FREIGHTLINER: THE TREE-WIRE LOW COOLANT LEVEL SENSOR (CAS 700685 001) ON SOME M2 VEHICLES BUILT FROM 2007 TO OCTOBER 8, 2009, WITH CUMMINS ISB AND ISC ENGINES, MAY DEVELOP AN INTERNAL LEAK CAUSING THE ENGINE LIGHT TO ILLUMINATE AND THE ENGINE TO SHUT DOWN. *JS
GI-01-100
Service Bulletin/Repair Instructions
FREIGHTLINER: CONTAMINATION OF AIR INTAKE. *PE UPDATED 2/28/12. *PE
SF-447A
Service Bulletin/Repair Instructions
DAIMLER TRUCK (FREIGHTLINER): ON RIGHT HAND STEERING ASSIST RAM, WHEN SUSPENSION IS EXTENDED, FULLY, IT MAY CONTACT FRONT SPRING HANGER CASTING, WHICH MAY FRACTURE RAM BALL STUD. WILL REPLACE RIGHT HAND FRONT SPRING HANGER. *PE
SF-437-A
Service Bulletin/Repair Instructions
FREIGHTLINER (DAIMLER): AN INCORRECT DIESEL EXHAUST FLUID (DEF) COOLANT LINE MAY INTERFERE WITH NEARBY ENGINE MOUNT WAS ASSEMBLED ON CERTAIN VEHICLES AND NEED TO BE MODIFIED AND REPLACED. *PE
SF-453A-D
Service Bulletin/Repair Instructions
DAIMLER TRUCKS (FREIGHTLINER): THE INSTRUMENT DISPLAY PANEL, THE COOLANT PUMP, AND RADIATOR ON CERTAIN HYBRID ELECTRIC VEHICLES MAY REQUIRE UPDATES AFTER INSPECTION. *PE
FSB-20-67
Service Bulletin/Repair Instructions
FREIGHTLINER: TANK SEAMS ARE SPLIT/CRACKED WHICH CAUSES FUEL TO LEAK. THE VALVE MIGHT BE PLUGGED WITH CONTAMINATE. *PE
SB-35-25
Service Bulletin/Repair Instructions
FREIGHTLINER: PROCEDURE OF REMOVING A LOWER PINION COVER IN THE REAR AXLES AND HOW TO RESEAL IT. *RM
SB-35-26
Service Bulletin/Repair Instructions
FREIGHTLINER: INFORMATION ON LUBRICATING THE WHEEL BEARINGS OF THE REAR DRIVE AXLES. *RM
SB-46-51
Service Bulletin/Repair Instructions
FREIGHTLINER: THERE IS A PROCEDURE TO REPLACE THE POWER STEERING PUMP. *RM
SB-54-261
Service Bulletin/Repair Instructions
FREIGHTLINER: INSTRUCTIONS TO INSTALL THE NEW RUBBER DRAW LATCH ON THE BATTERY BOX. *RM
SF-436A
Service Bulletin/Repair Instructions
FREIGHTLINER: WARNING LABELS. WARNING LABELS HAVE BEEN SENT DIRECTLY TO CUSTOMERS. *PE
SF-427-A-G
Service Bulletin/Repair Instructions
DAIMLER TRUCK SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE EXHAUST TEMPERATURES DO NOT MEET SPECIFICATIONS. *RM
TSB-54-237
Service Bulletin/Repair Instructions
FREIGHTLINER: A NEW BULB SOCKET IS AVAILABLE FOR TURN/PARK LIGHTS THAT IS METALIZED TO WITHSTAND HIGH HEAT WITHOUT OUT GASSING. MODEL YEARS UNKNOWN. MODELS COLUMBIA, BUSINESS CLASS M2 AND CASCADIA. *PE UPDATED ON 6/14/2011. *KB
SB-49-29
Service Bulletin/Repair Instructions
FREIGHTLINER LLC: ON VEHICLES WITH A FUEL TANK COVER INSTALLED THERE MAY BE COVER MOUNTING FASTENERS THAT ARE TOO LONG. THEY MAY DIG INTO THE TANK. *RM
SF-430A
Service Bulletin/Repair Instructions
FREIGHTLINER LLC SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SOME VEHICLES HAVE SEATS THAT WERE INSTALLED WITH MOUNTING SCREWS THAT COULD CRACK UNDER TORQUE. *RM
SF-431A
Service Bulletin/Repair Instructions
DAIMLER TRUCKS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE PLASTIC ENGINE COOLANT LINE MAY NOT BE SUFFICIENT UNDER CERTAIN TEMPERATURES RESULTING IN CRACKING AND LOSS OF COOLANT. *RM
ICI-10-025
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: THE 294 BOLT IS DEEMED SERVICEABLE AND THERE IS A PROCEDURE FOR REPLACING IT. *RM
SB-46-48
Service Bulletin/Repair Instructions
FREIGHTLINER: TRW TAS85 STEERING GEAR INTERNAL LEAKAGE TEST. SOME TRW TAS85 STEERING GEARS HAVE BEEN EQUIPPED WITH AN INTERNAL RELIEF VALVE. THESE STEERING GEARS ARE TYPICALLY INSTALLED WITH POWER STEERING PUMPS THAT HAVE A PRESSURE RELIEF RATING GREATER THAN 2175 PSI (150 BAR). THE INTERNAL RELIEF VALVE LIMITS MAXIMUM SUPPLY PRESSURE TO PROTECT THE STEERING GEAR. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, COLUMBIA, CORONADO, BUSINESS CLASS M2 AND CASCADIA. NO MODEL YEARS LISTED. *PE
SB-09-31
Service Bulletin/Repair Instructions
FREIGHTLINER: SOME TRUCKS HAVE BEEN FOUND WITH INCORRECT SEALING OF AIR INTAKE DUCT ASSEMBLIES, ALLOWING UNFILTERED AIR TO BYPASS THE AIR CLEANER. LOOSE DUCT CONNECTIONS OR DIRT FOUND IN THE DUCTING DURING A FILTER SERVICE INDICATE THAT DUCT CLAMPS SHOULD BE CHECKED, AND RUBBER SEALS ADDED WHERE NOT PRESENT. LOOSE DUCTING SHOULD BE THOROUGHLY INSPECTED FOR DAMAGE AND REPLACED IF NECESSARY. NO MODEL YEARS LISTED. *PE
SB-33-24
Service Bulletin/Repair Instructions
FREIGHTLINER TRUCK: STEER AXLE MAINTENANCE, AAC AND MERITOR 6000LB AND 8000LB AXLES: THIS BULLETIN IS TO PROVIDE INFORMATION ON THE RECOMMENDED MAINTENANCE PROCEDURE TO BE ADDED TO DTNA MAINTENANCE MANUALS FOR ALL MODELS WITH THESE AXLE RATINGS. IT IS RECOMMENDED THAT THESE PROCEDURES BE ADOPTED AS SOON AS POSSIBLE. NO MODEL YEARS LISTED. *PE
SB-42-63
Service Bulletin/Repair Instructions
FREIGHTLINER: ABS FAULT CODES DUE TO CONNECTOR WATER INTRUSION. ON SOME TRUCKS, THE ABS MODULE WAS MOVED INTO THE CAB. THIS REQUIRED A CONNECTOR TO BE PLACED UNDER THE CAB, BEHIND THE FRONT STEERING AXLE, ON THE FRAME RAIL. IF THIS CONNECTOR IS LOOSE, OR IMPROPERLY INSTALLED, MOISTURE CAN ENTER THE CONNECTOR AND CAUSE CORROSION ON THE TERMINALS, WHICH WILL LEAD TO CONNECTIVITY ISSUES, CAUSING VARIOUS ABS FAULT CODES, AND THE ABS DASH LIGHT TO COME ON. *PE
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.