TSB-54-384-FTL
Service Bulletin/Repair Instructions
Technical Service Bulletin for Grote OEM and Alliance Aftermarket Headlamp Replacement
Vehicle report
2018 FREIGHTLINER BUSINESS CLASS M2
Service bulletins
388 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
FleetCom_Oil Plug Loc
Other
Fleet Communications for NFD Lower Oil Plug Location - SP Axles
SF671-Bulletin
Service Campaign
Revised Field Service Campaign for Beverage Body Frame Rail 50 KSI
SF671-DLR LTR
Service Campaign
Revised Field Service Campaign for Beverage Body Frame Rail 50 KSI
TSB88-048-FTL
Service Bulletin/Repair Instructions
Technical Service Bulletin for New Grill Design
SS3124-FTL
Other
Service Solution for Legacy M2 Bulkhead Module (BHM) Replacement and Diagnosticlink Issue
CXA 3_25_NOx
Other
CX Advocate for NOx conversion low faults
CXA 2_25_NOx
Other
CX Advocate for NOx conversion low faults
CXA 2_25_Turbo Oil Drain
Other
CX Advocate for turbo oil drain cracking
ICI25-004
Other
Important Campaign Information letter for SF695 – Campaign Replaced by F1012
CXA 1_16_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
CXA 1_16_DD13 Altitude
Other
CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
CXA 1_16_NOx
Other
CX Advocate for NOx conversion low faults
CXA 1_16_Seat Occupancy
Other
CX Advocate for repairing seat occupancy sensor (TSB 91-016-FTL)
CXA 1_16_Turbo Oil Drain
Other
CX Advocate for turbo oil drain cracking
TSB35-039-FTL
Service Bulletin/Repair Instructions
Technical Service Bulletin for Detroit New Final Drive Standard Performance Forward Carrier Change to Top Performance Passive Lube Management
CXA 11_21_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
CXA 11_21_M2, SD Transfer
Other
CX Advocate for M2 and SD Vehicles Transfer Case Failures Due to Excessive Vehicle Speed (SS 3155-FTL)
TSB91-016-FTL
Service Bulletin/Repair Instructions
Technical Service Bulletin for Repairing Seat Occupancy Sensor for ISRI, SEARS and National Truck Seats
WI24-019
Warranty Program/Extension
Warranty Information letter for Detroit Line or Line Seal, High Pressure Fuel Injector Standard Repair Time Updates
PB01-009
Other
Parts Bulletin for Powertrain Power Distribution Module (PTPDM) Kit Replacement
SS3155-FTL
Other
Service Solution for M2 and SD Vehicles Transfer Case Failures Due to Excessive Vehicle Speed
CXA 10_17_Misrated engine
Other
CX Advocate for Legacy M2 – Misrated Engines in Emergency Vehicles (SF695)
CXA_10_17_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
SS1023366-Detroit
Other
Service Solution for Detroit Successful Regen Reference for GHG17 DD Engines
CXA 9_24_MDEG Updates
Other
CX Advocate for MDEG Updates
CXA 8_24_MDEG Updates
Other
CX Advocate for MDEG Updates
CXA 7_24_MDEG Updates
Other
CX Advocate for MDEG Updates
CXA 7_24_NOx
Other
CX Advocate for NOx conversion low faults. Update to CXA 6_24_NOx submission.
CALFTL13-002
Service Bulletin/Repair Instructions
Customer Advisory Letter for Proactive Air Compressor, Resonator, and Suction Line Replacement
ICI24-029
Other
Important Campaign Information Letter for SF695 – Cummins Engine Emergency Vehicle Calibration
CXA 06_24_NOx
Other
CX Advocate communication for NOx conversion low faults
ICI24-025
Service Campaign
Revised Important Campaign Inofrmation letter for SF671 - Bulletin Revision. REVISION: 3 new SRTs and repair procedures have been created to address specific issues that arise during the repair.
SF671_V2-Bulletin
Service Campaign
Revised Field Service Campaign for Beverage Body Frame Rail 50 KSI. REVISION: 3 new SRTs and repair procedures have been created to address specific issues that arise during the repair.
SF671_V2-DLR LTR
Service Campaign
Revised Field Service Campaign for Beverage Body Frame Rail 50 KSI. REVISION: 3 new SRTs and repair procedures have been created to address specific issues that arise during the repair.
TSB35-042-FTL
Service Bulletin/Repair Instructions
Technical Service Bulletin for New Final Drive Over Heat Diagnostic
SS734-WST
Other
Service Solution for Thread Spring Pin Suspension Alignment & Installation
SF672 POSTCARD LARGE
Service Campaign
Field Service Campaign Owner Reminder Postcard large population
SF672 POSTCARD SMALL
Service Campaign
Field Service Campaign Owner Reminder Postcard small population
VSWP Customer Letter
Other
Customer letter regarding variable speed water pump.
MYCOM_05142024-1
Other
My Communications for SSI DEF Header Warranty Policy Extension for B6 7 Engines Model Years 2017-2021
CumminsB6.7SSI
Service Bulletin/Repair Instructions
Extended Warranty Policy for certain Cummins B6.7 engines with SSI DEF headers for EPA and CARB Emissions Reporting
ICI24-013
Service Bulletin/Repair Instructions
Important Campaign Information letter for SF671 Campaign Suspended
ICI24-009
Service Bulletin/Repair Instructions
Important Campaign Information letter for SF671 - Bulletin Revision. REVISION: If you find modifications to the chassis, please submit a WSC Inquiry before beginning any additional work.
SF671
Service Bulletin/Repair Instructions
Revised Field Service Campaign for Beverage Body Frame Rail 50 KSI. REVISION: If you find modifications to the chassis, please submit a WSC Inquiry before beginning any additional work.
FL974
Service Bulletin/Repair Instructions
Revised Emissions Recall: Cummins DEF Sensor Shortage. REVISION: Some vehicles formerly in Group F have been moved to Group G and have been assigned a new part number as specified in Table 1. An SRT for 'Calibration Code Only: Update or Confirm' has been added, as shown in Table 2, to be used when a new DEF header is not required. There have been some other minor changes to the work instructions and SRT times.
ICI24-006
Service Bulletin/Repair Instructions
Important Campaign Information letter for FL974 - Revised Bulletin & Population
SF672_V4
Service Bulletin/Repair Instructions
Revised Field Service Campaign for Common Telematics Platform Software Update
SF672
Service Bulletin/Repair Instructions
Field Service Campaign for Common Telematics Platform Software Update
SB54-295
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Replacing an Auto Baud Rate Detecting Bulkhead Module with a Fixed Baud Rate BHM. Description of Revisions: This bulletin replaces the version dated 02/01/2016. Information about auto baud rate connections has been included.
SB83-161
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Heater Hose Reduced Clearance May Cause Early Horn Failures
SB49-042
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for DEF Connector Reinforcement Caps.
SS3090-FTL2021
Service Bulletin/Repair Instructions
Service Solution for DD8 Engine Harness Chafing Air Compressor Suction Line.
CSR 520
Service Bulletin/Repair Instructions
Daimler Trucks North America LLC (DTNA), on behalf of its Freightliner Trucks Division, has decided that a defect that relates to motor vehicle safety exists on specific model year 2014 through 2019 Freightliner Business Class M2 vehicles manufactured October 17, 2013, through September 25, 2018 and equipped with a Mahle-Bahr radiator. Contact your DTNA dealer to schedule a service date to perform the recall. Refer to the included communication from DTNA for additional information.
CALDDE01-001
Service Bulletin/Repair Instructions
Vibration Damper Replacement. DD5 Engines built from 4/04/2017 through 3/30/2018.
CALFTL32-011
Service Bulletin/Repair Instructions
Customer Advisory Letter for 80KSI Frame Reinforcement Installation on specific Business Class M2 equipped with 80KSI frame rails and an Airliner 20,000 lb or 21,000 lb rear suspension.
SB54-320
Service Bulletin/Repair Instructions
Updated Service Bulletin for upgrading BHM software for switch expansion module fault SPN 698 FMI 7. This bulletin replaces the version dated 11/11/2019. Figure 3 has been updated with a new hardware part number. A procedure was added to the data download process.
16TS-08REV
Service Bulletin/Repair Instructions
Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
WI21-009
Service Bulletin/Repair Instructions
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
TechTalk566197K
Service Bulletin/Repair Instructions
Tech Talk discussion on M2 ESC UNABLE TO INITIALIZED.
WI21-008
Service Bulletin/Repair Instructions
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
SB54-328
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Rerouting Wiring Harness to Reduce Chafing. This bulletin replaces the version dated 06/29/2020. Two new illustrations have been added to demonstrate proper application of butterfly tie straps on the transmission. ---Allison transmission wiring harness chafing causes disruption to gear engagement and fault code generation. To reduce chafing, the wiring is routed using stand off brackets and tie straps to minimize contact with the transmission parts. This bulletin applies to vehicles equipped with on-board diagnostics (OBDs) manufactured after 2016.
SB83-155
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Espar Service Information. This bulletin replaces the version dated January 1, 2015. New Cascadia has been added to the model list.
WP21-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for battery tags. DTNA determined that since adopting the AutoMeter BCT-460DTNA Powernet Assessment Tool (AutoMeter) as the required powernet system tester, not all battery tags have to be retained support Warranty-related claims.
SS3073FTL2021
Service Bulletin/Repair Instructions
Service Solution for M2 Rear Suspension Knock. This document applies to Freightliner M2 Business Class used in a âFire/Emergencyâ application and equipped with FTL flat leaf spring rear suspensions. The FTL flat leaf spring rear suspension permits the spring pack to shift laterally within the spring hanger brackets. Under heavy cornering load applications, the spring pack can shift laterally and contact the sidewall of the spring hanger bracket. Driver of the vehicle will detect an audible popping or knocking noise from the rear suspension when turning the vehicle.
SB49-038
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for netized Fill Neck for Six-Gallon DEF Tanks. A design change removed the magnets from the fill necks for some 6-gallon diesel exhaust fluid (DEF) tanks. If the vehicle is equipped with a non-magnetic fill neck 04-32529-000, it can be updated to a magnetic neck 04-32529-001. This bulletin replaces the version dated 04/18/2017. Updated availability of magnetic fill neck option for other diesel exhaust fluid (DEF) tank part numbers.
D21R5
Service Bulletin/Repair Instructions
Detroit Emission Recall for Certain Detroit DD5 quick launch engines that are registered in the state of California will require reprogramming to a minimum of the MCM and ACM software versions.
TechTalk12259K
Service Bulletin/Repair Instructions
Tech Talk discussion on DD5 engine and ACM harness pigtail info.
SB54-308
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
20TS-08REV
Service Bulletin/Repair Instructions
Revised Technical Service Letter for Fault Code SPN 2629 FMI 10 on GHG21 936.917 DD8 Dual Stage Turbo with MCM Software Version 14.
21OEM-06
Service Bulletin/Repair Instructions
Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available. Current subscribers of DiagnosticLink 8.11 or 8.12 may upgrade to DiagnosticLink 8.13 at no cost. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
WI21-006
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes - Claim Guidelines.
TechTalk8099
Service Bulletin/Repair Instructions
Tech Talk discussion on a 2018 M2 intermittently burning Fuse 15.
WI20-014R
Service Bulletin/Repair Instructions
Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes. Revisions are in blue font.
TechTalk7041
Service Bulletin/Repair Instructions
Tech Talk discussion on head light fog up.
TechTalk8104
Service Bulletin/Repair Instructions
Tech Talk discussion on jz6410 freightliner m2 with dd13.
WI21-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit Resources: Exploded View DD Platform and DT12 Posters. Detroit's TechComm team created visual aids for the network and released exploded view posters for DD platform engines. In early 2021, Detroit added multiple DT12 posters.
21TS-01
Service Bulletin/Repair Instructions
Technical Service Letter for Detroit Bearing Failures - Standard Diagnostic Times. DTNA is increasing repair strategies for determining the root cause of Detroit DD heavy duty lower end bearing failures. To support this strategy change, Detroit now has two (2) Standard Diagnostic Times (SDTs), easy and difficult, which can be applied to repair orders.
21TS-03
Service Bulletin/Repair Instructions
Technical Service Letter for GHG17 1-Box Inlet and Outlet Exhaust Clamps. There is a short supply of exhaust clamps, part number DDE A6809950502, used as inlet and outlet exhaust clamps on GHG17 heavy duty engines (DD13, DD15 and DD16) with a 1-Box aftertreatment configuration. Exhaust clamp part number TCX T130158342AC2 may be used as a substitute for DDE A6809950502, but be aware of the different torque specs between the two parts.
WI21-003
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit Bearing Failures - Standard Diagnostic Times. DTNA is increasing repair strategies for determining the root cause of Detroit DD heavy duty lower end bearing failures. To support this strategy change, Detroit now has two (2) Standard Diagnostic Times (SDTs), easy and difficult, which can be applied to repair orders.
CALFTL88-001
Service Bulletin/Repair Instructions
Customer Advisory Letter for Freightliner M2 Forward-Frame Extension Hood Mount Bracket Gusset Installation.
TechTalk7394
Service Bulletin/Repair Instructions
Tech Talk discussion on 2019 Western Start Door Speakers INOP. Also discusses Speaker interrupts for 2018 M2.
TechTalk7999
Service Bulletin/Repair Instructions
Tech Talk discussion on 2018 m2 PNDB f2 125 amp fuse blown.
Techtalk7999
Service Bulletin/Repair Instructions
Tech Talk discussion on M2 PNDB F2 125 amp fuse blown.
SB35-036
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
WP20-018R
Service Bulletin/Repair Instructions
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
WP20-018
Service Bulletin/Repair Instructions
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
20TS-08
Service Bulletin/Repair Instructions
Technical Service Letter for Fault Code SPN 2629 FMI 10 on GHG21 936.917 DD8 Dual Stage Turbo with MCM Software Version 14
CALFTL32-006R
Service Bulletin/Repair Instructions
Revised Customer Advisory Letter for Hendrickson Primaax EX 69,000 lb Tri-Axle Rear Air Suspension Height-Control Valve Relocation. Revision is Step 8 drilling instructions expanded. The attached document provides work instructions for relocating the height-control valve downward 1.62 inches (41.3 mm) to prevent the linkage from protruding above the top flange of the frame when the suspension air is dumped.
Techtalk7915
Service Bulletin/Repair Instructions
Tech Talk discussion on M2 ICU with the markers down.
SS1034797
Service Bulletin/Repair Instructions
Service Solution for M2,108SD, 114SD Coolant Level Sensor P/N 06-93316-002. The Call Center has received several calls pertaining to this LCL sensor introduced to in 2018. The purpose of this solution is to bring better awareness to the sensor functions, fault codes generated, along with providing testing procedures used to validate the sensors condition.
SB54-278
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeterî is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
17TS-05REV2
Service Bulletin/Repair Instructions
Revised Technical Service Letter for Detroit DT12 TCM GHG17 Only; Bootloader Update. On Detroit DT12 equipped vehicles, it may be necessary to complete an additional step in the programming process when updating the TCM software.
20TS-06
Service Bulletin/Repair Instructions
DDC Technical Service Letter for GHG17 DD Platform Heavy Duty Oil Pan Drain Plug Inserts. Some GHG17 DD Platform Heavy Duty oil pans may experience an issue with the oil pan drain plug insert spinning during removal or installation while completing an oil change. Leaking may also be observed at the drain plug and/or other plugs in the oil pan.
18SP736
Service Bulletin/Repair Instructions
Detroit Diesel Special Publication informing about Heavy Duty Friction Style Belt Tensioner Kit. This heavy duty friction style belt tensioner kit contains the belt tensioner and two M10 bolts to correctly pin the friction style belt tensioner. The M10x80mm bolt is used to pin the engine cooling fan drive arm. The M10x50mm bolt is used to pin the engine accessory drive arm.
20TS-03REV2
Service Bulletin/Repair Instructions
Revised Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform. The revision includes additional information on retrofit and service kits.
CALFTL20-003REV
Service Bulletin/Repair Instructions
Revised Customer Advisory Letter for Fan Hub Fastener Inspection in Business Class M2 Vehicles with DD5 Engines. The revision has updated inspection procedures. DTNA has determined that some GHG17 Detroit DD5 engines will need to have the fan hub bolts inspected for correct torque.
TechTalk4725
Service Bulletin/Repair Instructions
Tech Talk discussion about power steering fluid.
TechTalk7658
Service Bulletin/Repair Instructions
Tech Talk discussion on M-2 gauges inoperative at times.
TechTalk7679
Service Bulletin/Repair Instructions
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
TechTalk3401
Service Bulletin/Repair Instructions
Tech Talk discussion for needing parameter for PTO to remain engaged when park brake is set.
TechTalk4374
Service Bulletin/Repair Instructions
Tech Talk Discussion for M2 mirror shake. Vehicle has excessive mirror shake going down the road.
D20M9
Service Bulletin/Repair Instructions
Detroit Diesel Field Service Campaign for Engine Emission Label Replacement. Certain DETROIT heavy-duty engines installed in various applications will require reprogramming and engine emission label replacement.
20CSA-15
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
CALFTL32-006
Service Bulletin/Repair Instructions
Customer Advisory Letter for Hendrickson Primaax EX 69,000 lb Tri-Axle Rear Air Suspension Height-Control Valve Relocation. The attached document provides work instructions for relocating the height-control valve downward 1.62 inches (41.3 mm) to prevent the linkage from protruding above the top flange of the frame when the suspension air is dumped.
ICI20-022R
Service Bulletin/Repair Instructions
Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately.
SB54-315
Service Bulletin/Repair Instructions
Service Bulletin for Powertrain PDM and Main PDM Bracket Modiï¬Âcation. This bulletin replaces the version dated 10/31/2019. The build date section has been added.
ICI20-022
Service Bulletin/Repair Instructions
Important Campaign Information letter announcing Dealer Travel for Campaign Performance. This letter is to announce a reimbursement available to dealers for travel to a customerÃÂÃÂÃÂâÃÂÃÂÃÂÃÂÃÂÃÂÃÂÃÂs location to perform a recall or field service campaign.
WI20-012
Service Bulletin/Repair Instructions
Warranty Information Letter informing that to ensure that DTNA policies and service network practices align, the Warranty Department will be revising the Warranty Manual.
WI20-014
Service Bulletin/Repair Instructions
Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes.
SB31-043
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change. With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
20CSA-10
Service Bulletin/Repair Instructions
Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkÃÂÃÂÃÂÃÂÃÂÃÂÃÂî 8.12 Standard and Professional is available to download from the Detroit Diesel server.
20OEM-05
Service Bulletin/Repair Instructions
OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
20TS-05
Service Bulletin/Repair Instructions
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility. Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
SB54-334
Service Bulletin/Repair Instructions
Service Bulletin for Front Lighting Ground Splice Pack Failure. The left and right hood lighting of these vehicles have separate ground paths to the frame and use the same splice pack parts. The splice packs are part of the hood commodity and located near the headlight assemblies. These splice packs can fail, resulting in either the left or right lighting becoming intermittent or inoperative.
20CSA-09
Service Bulletin/Repair Instructions
Customer Service Announcement for DiagnosticLink Software Update Reminder. Due to various software changes and fixes, vehicles will require DiagnosticLink 8.12 to perform functional programming. Failure to use this version may cause errors, incomplete programming, and poor vehicle performance. Because of this, all DiagnosticLink 8.09 installed versions will be disabled as of Thursday, July 23, 2020.
SB60-171
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
20TS-03REV
Service Bulletin/Repair Instructions
Revised Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform.
20CSA-08
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020, DiagnosticLink 8.12 will be made available for download from the ordering system. Current subscribers of DiagnosticLink 8.xx can upgrade to DiagnosticLink 8.12 at no cost. All DTNA service shops are required to maintain the latest version of software on each of their stations.
20TS-03
Service Bulletin/Repair Instructions
Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform.
WI20-008
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
WP20-006
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers. To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
WP20-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for Chassis Progressive Damage Policy Change. Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
WP20-005
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program. DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
WI20-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Long Block Program Change. The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
CAL80KSIFRAMEREV
Service Bulletin/Repair Instructions
Customer Advisory Letter revision for 80KSI Frame Reinforcement Installation for certain vehicles equipped with 80KSI frame rails and Airliner 21,000LB rear suspensions. This version adds Model Year 2020.
SB54-327
Service Bulletin/Repair Instructions
Service Bulletin for Lengthening the Backup Light Harness. Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
SB32-033
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for Front Axle Spacer Replacement. This service bulletin replaces the version dated 05/01/2016. This bulletin is updated to include the parts list. Some vehicles may exhibit a lean (right or left) due to weight difference on the front suspension. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers. To correct this condition, replace the existing front axle spacer on the low side of the vehicle with a thicker one.
SIB0201-20
Service Bulletin/Repair Instructions
Service Information Bulletin for Cylinder Block Porosity Repair for DD5 and DD8 egnines. Use this procedure to repair oil leaks caused by cylinder block porosity. The low oil pressure, cast areas of the cylinder block can be repaired using this method. J-B Weld is the recommended two-part epoxy for this repair.
20CSA-04
Service Bulletin/Repair Instructions
Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLinkî 8.11 Standard and Professional will be available for download from the Detroit Diesel server.
D19M4-REV3
Service Bulletin/Repair Instructions
Field Service Campaign revision for Detroit Axle M2 Chassis Stabilizer Bracket Inspection. Additional information added to Parts Information.
SS1034679
Service Bulletin/Repair Instructions
Service Solution for M2 ABS Wiring Harness Rubs On Forward Cab Mount. ABS chassis harness is rubbing on the rear of the driver side forward cab mounting bracket on M2 106 trucks with a 160 MM Cab Hgt. This may cause open or shorted circuits in multiple wires in the harness transitioning from the chassis to the cab. Noticeable symptoms include illumination of the ABS and ATC indictor lamps.
03.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers.
SB00-038
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for vibration troubleshooting - finding the cause. This version replaces the version dated 5/1/14 and adds New Cascadia.
SB41-013
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for Midship Bearing Replacement for built vehicles with driveshafts SPL140, SPL170 or SPL250 with first order driveline vibration.
WP20-002
Service Bulletin/Repair Instructions
Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy, published in DTNA Workshop Manuals, which states that there are very few cases in which welding a heat-treated frame rail is allowed. Therefore, before welding anything on a frame rail, contact the applicable regional service representative for approval.
ICI20-008 D19M2
Service Bulletin/Repair Instructions
Important Campaign Information Letter announcing the extension of the Campaign Termination Date for D19M2 which was for the inspection of DD5 fan hub bolts.. The termination date has been extended to August 28, 2020.
02.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers
SS1034558
Service Bulletin/Repair Instructions
Service Solution for OBD16 M2, C2, 108SD & 114SD Allison transmission not shifting due to harness chafing.
SB54-290
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness. Use the guidelines in this bulletin to determine if a damaged electrical harness should be repaired or replaced.
20CSA-01
Service Bulletin/Repair Instructions
Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs) will now have a 60-day expiration, starting on the release day of the bulletin. The intent of a SIB is to notify the service network of a major change to one or more service procedures. Do not save SIBs nor reference them for repairs, as they are uncontrolled and never updated.
ICI20-004
Service Bulletin/Repair Instructions
Important Campaign Information announcing that a revised bulletin for SF588 Medium Duty DD8 Engine Updates is available on DTNAConnect.
D19R2REV1
Service Bulletin/Repair Instructions
DDC Emission Recall for GHG17 MDEG Platform DD8 âÃÂàSoftware Reprogramming For California Inspection and Maintenance. Adding clarification to the Corrective Procedure.
ICI20-002
Service Bulletin/Repair Instructions
Important Campaign Information Letter announcing that revisions to DDC bulletins D19M5 and D19R2 are available.
SB83-119
Service Bulletin/Repair Instructions
Service Bulletin for A/C system receiver-drier replacement guidelines.
SF588
Service Bulletin/Repair Instructions
Field Service Campaign for Medium Duty DD8 Engine Updates. Certain vehicles with Detroit Diesel MDEG DD8 engines need updates to the air compressor suction line, powertrain control module, oil fill cap, 10-pin connector wiring harness, and fuel filter/engine labels.
D19M4-REV2
Service Bulletin/Repair Instructions
Field Service Campaign revision for Detroit Axle M2 Chassis Stabilizer Bracket Inspection.
ICI19-064
Service Bulletin/Repair Instructions
Important Campaign Information Letter announcing that a revision for D19M4 as a REV2 exists and is available on DTNAConnect.
WI19-022
Service Bulletin/Repair Instructions
Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment Systems
SB20-087
Service Bulletin/Repair Instructions
Service Bulletin for M2 Surge Tank Shunt Line Clamp Replacement. On some vehicles, the shunt line coolant hose is disconnecting from the surge tank and replacing the constant tension clamp with a Breezeî brand clamp resolves the issue.
19TS-12
Service Bulletin/Repair Instructions
Camshaft Position (CMP) sensor terminal fretting due to vibration for DD5 and DD8 engines.
SB54-319
Service Bulletin/Repair Instructions
Service Bulletin for severe duty main PDM installation for vehicles operating in severe moisture and/or corrosive environments.
ICI19-059
Service Bulletin/Repair Instructions
Important Campaign Information letter announcing a revision to D19M4 exists and can be found on DTNAConnect and updates the section on Warranty Information.
D19M4-REV1
Service Bulletin/Repair Instructions
Service Campaign to inspect and fix stabilizer brackets for damage.
SB54-314
Service Bulletin/Repair Instructions
Service Bulletin describing changes made to the Powernet Distribution Box (PNDB) for better fuse retention.
17TS9
Service Bulletin/Repair Instructions
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found on TechLit.
D19R2
Service Bulletin/Repair Instructions
DDC Emission Recall for GHG17 MDEG Platform DD8ÂÂ Software Reprogramming For California Inspection and Maintenance
09-037
Service Bulletin/Repair Instructions
Service Bulletin for Air Cleaner Modifications for Dusty Environments
19TL-15
Service Bulletin/Repair Instructions
Tool Letter for ICC5 Programming Cable
D19M4
Service Bulletin/Repair Instructions
Field Service Campaign Bulletin for DetroitTM Axle M2 Chassis Stabilizer Bracket Inspection
SB32-054
Service Bulletin/Repair Instructions
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
SB47-027
Service Bulletin/Repair Instructions
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
15CSA-3REV
Service Bulletin/Repair Instructions
Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
19CSA-12 BCT
Service Bulletin/Repair Instructions
PowerNet Assessment Tool Repair Procedure
19TL-10 NVH
Service Bulletin/Repair Instructions
Communication to assist the field with service vibration issues on DTNA vehicles
19TL-12
Service Bulletin/Repair Instructions
Tool Letter for New Final Drive Pinion Cover Install Tool
19TL-14
Service Bulletin/Repair Instructions
Tool Letter for New Final Drive Driver Controlled Differential Lock Spring Compressor. These new axles require a new tool to compress the Driver Controlled Differential Lock (DCDL) spring. To remove and install the DCDL spring, the tool DSN0FDA17001 is needed.
D19M2
Service Bulletin/Repair Instructions
Field Service Campaign to inspect DD5 Fan Hub Bolts
D19M3
Service Bulletin/Repair Instructions
Field Service Campaign for DD5 Software Reprogramming
19CSA-13
Service Bulletin/Repair Instructions
Service Systems Development provided document to service locations on price list reflects current charges to engine horsepower ratings for HDEP and MDEG engine platforms.
19-011WP
Service Bulletin/Repair Instructions
Warranty Policy Letter to communicate Detroit Return Changes
19-012WP
Service Bulletin/Repair Instructions
Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
19-013WI
Service Bulletin/Repair Instructions
Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized Demonstrator Program
sb32-054
Service Bulletin/Repair Instructions
Service Bulletin to fix vehicles which may have an incorrect transverse torque rod tower bracket installed on the rear drive axles at the factory. This can result in cracking at the transverse rod tower where it is welded to the axle housing, premature wearing of the transverse torque rod tapered pin and bushings, and damage to the transverse torque rod frame bracket.
sb54299
Service Bulletin/Repair Instructions
Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer installed in production, and has been superseded by the ICU3S. When replacing an ICU3, the ICU3S must be installed in its place.
19-010WI
Service Bulletin/Repair Instructions
Warranty Information Letter updated to communicate warranty system updates.
0107-19 GHG17
Service Bulletin/Repair Instructions
Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
0202-19
Service Bulletin/Repair Instructions
Service Information Bulletin for DD5 Aftertreatment Systems - DPF End Cap
0305-19 SPN 2000
Service Bulletin/Repair Instructions
Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC Heartbeat Message is no Longer Arriving)
0419-19SPN521030
Service Bulletin/Repair Instructions
Updates to troubleshooting guides in Diagnostic Link with newest version
0607-19
Service Bulletin/Repair Instructions
Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine Electrical section.
0609-19
Service Bulletin/Repair Instructions
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
18SP725Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
19-008WI
Service Bulletin/Repair Instructions
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19TL-9
Service Bulletin/Repair Instructions
DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on DTNA products at DTNA service locations. The Axis4000 system uses the reference points required by DTNA for precise, accurate, and repeatable measurements. Axis4000 is a sophisticated, user-friendly system that utilizes computer based camera-radio technology and references the center line of the frame for measuring and providing alignment results to DTNA specifications.
19TS-6
Service Bulletin/Repair Instructions
The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
SPN 3563 / FMI 2
Service Bulletin/Repair Instructions
HDEP GHG17 engines are not equipped with turbo wastegates. Steps in this troubleshooting involving wastegates were removed.
19-009WI
Service Bulletin/Repair Instructions
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
DOC-1034452
Service Bulletin/Repair Instructions
Training Solution created by DTNA to provide guidance to customers when searching for service information for components and systems not owned by Daimler Trucks North America (DTNA).
sb46056
Service Bulletin/Repair Instructions
Forward Chassis Wiring Harness
fp46907
Service Bulletin/Repair Instructions
Steering Intermediate Shaft Replacement
sb54308
Service Bulletin/Repair Instructions
DiagnosticLink support programming of both chassis and powertrain ECUs
SF579 DD5
Service Bulletin/Repair Instructions
Engine Low Coolant Sensor
DOC-1034220
Service Bulletin/Repair Instructions
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
sb54311
Service Bulletin/Repair Instructions
Service Bulletin- sb54311 ICU Odometer Programming
fp00024
Service Bulletin/Repair Instructions
fp00024 Cable-Tie Reference
CALFTL26-001
Service Bulletin/Repair Instructions
Customer Advisory Letter on Missing Transmission Cooler Line Bracket and Clamp
DOC-1034171
Service Bulletin/Repair Instructions
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
FL783
Service Bulletin/Repair Instructions
Brake Caliper Mounting Bolts
sbw00018
Service Bulletin/Repair Instructions
Service Bulletin M2 Heated Windshield Modification
sb0039
Service Bulletin/Repair Instructions
Service Bulletin New "Natural Gas Vehicle Information" Webpage
FL783-REV
Service Bulletin/Repair Instructions
FL783 Dealer Bulletin Brake Caliper Mounting Bolts
ICI19-002 D18M7-
Service Bulletin/Repair Instructions
D18M7 ? Replaced by Recall D18R7 (FL802)
ICI19-004 FL783
Service Bulletin/Repair Instructions
FL783 - Revised Bulletin
FL794 REV
Service Bulletin/Repair Instructions
FL794 Recall Campaign- Brake Caliper Mounting Bolts
ICI19-003 FL794
Service Bulletin/Repair Instructions
FL794 - Revised Bulletin Brake Caliper Mounting Bolts
1208-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
1212-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
1213-18
Service Bulletin/Repair Instructions
Service Information Bulletin
18TL18
Service Bulletin/Repair Instructions
30mm Air Disc Brake Caliper Bolt Torque Adapter DSNCHA018005
FL794
Service Bulletin/Repair Instructions
FL794 Brake Caliper Mounting Bolts Dealer Bulletin
GHG17
Service Bulletin/Repair Instructions
Letter to customer on Coverage Extension GHG17 After Treatment
aeoD18M2
Service Bulletin/Repair Instructions
Field Service Campaign D18M2 GHG17 GHG17 Detroit DD13® Software Reprogramming and Emission Label Replacement for Motor Coach Industries, Inc. (MCI®)
DOC-1033988
Service Bulletin/Repair Instructions
Service Solution: 1033988, SPN 879 or 881 FMI 6 Fault Codes
sb9810 Chassis P
Service Bulletin/Repair Instructions
Service Bulletin 9810- Chassis Paint Usage
sb9815 Paint Fin
Service Bulletin/Repair Instructions
Service Bulletin 9815- Paint Finish Standards
sb9819 Body Pain
Service Bulletin/Repair Instructions
Service Bulletin 9819- Body Paint Repair Process
DOC-1033890
Service Bulletin/Repair Instructions
SS1033890 DD5 Coolant Sensor Fault 111/1
FL783 Brake Cali
Service Bulletin/Repair Instructions
Recall FL783- Brake Caliper Mounting Bolts
sb20086 Allison
Service Bulletin/Repair Instructions
Service Bulletin- Allison Transmission Cooler Quick-Connect Fittings
DOC-1033889
Service Bulletin/Repair Instructions
Service Solution 1033889- Hydromax Hydraulic Brake Booster Pump Function Logic
Rocker Arm Housi
Service Bulletin/Repair Instructions
Service information Bulletin for Rocker Arm Housing and Camshaft
18-029 Auto Mete
Service Bulletin/Repair Instructions
Important Warranty Information on AutoMeter BCT-460DTNA Powernet Assessment Tool: Warranty Requirement and Claim Filing
FL772 Brake Cali
Service Bulletin/Repair Instructions
FL772-Dealer bulletin for Brake Caliper Mounting Bolts recall
18CSA16 Release
Service Bulletin/Repair Instructions
Release of DiagnosticLink® 8.08 Service Pack 2
18TL11 DD5 DD8 I
Service Bulletin/Repair Instructions
DD5/DD8 Injector Breakout Box Overlay DPI930E18001
M2 Roof Repair
Service Bulletin/Repair Instructions
Freightliner M2 Roof Repair
M2 AWD Passenger
Service Bulletin/Repair Instructions
Customer / Dealer Advisory: M2 All-Wheel Drive Passenger Side Step Modification
Telematics conne
Service Bulletin/Repair Instructions
Customer Advisory Letter- Telematics Connections
sb3125 AirLiner
Service Bulletin/Repair Instructions
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
sb0036
Service Bulletin/Repair Instructions
Operating Hours for the Customer Assistance Center
0508-18
Service Bulletin/Repair Instructions
0508-18 Aftertreatment
0505-18
Service Bulletin/Repair Instructions
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
0504-18
Service Bulletin/Repair Instructions
0504-18 Fuel System - Fuel Injectors
0503-18
Service Bulletin/Repair Instructions
0503-18 Relative Cylinder Compression Test
0502-18
Service Bulletin/Repair Instructions
0502-18 Symptom Diagnostics - Low Engine Coolant Temperature
0501-18
Service Bulletin/Repair Instructions
0501-18 Aftertreatment Control Module (ACM)
18SP734
Service Bulletin/Repair Instructions
18SP734 18SP734?GHG14 DD15AT Turbocharger
DOC-1033446
Service Bulletin/Repair Instructions
Vehicles with Meritor drivelines bene from a softer durometer center bearing support. Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
MY18M4
Service Bulletin/Repair Instructions
MY18M4_Bulletin_02-MAY-2018 Field Service Campaign D18M4
SF559
Service Bulletin/Repair Instructions
SF559 Freightliner Business Class M2 Power Steering Hoses
aeo18M4
Service Bulletin/Repair Instructions
aeo18M4 Field Service Campaign D18M4
fp00020
Service Bulletin/Repair Instructions
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
sb31037
Service Bulletin/Repair Instructions
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed. The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
sb31038
Service Bulletin/Repair Instructions
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn. This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
sb88048
Service Bulletin/Repair Instructions
A new design for the M2 grille went into prduction on February 5, 2018. The hood design has also changed slightly to accommodate a different grille fastening strategy. The old grille and hood part part numbers will no longer be produced, and will supersede to the new design with new part numbers.
DOC-1033425
Service Bulletin/Repair Instructions
SS 1033425 Cruise Control Not Working When Replacing ICU3 With ICU3S M2 Vehicles With Caterpillar Engine Only
0405-18
Service Bulletin/Repair Instructions
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
0404-18
Service Bulletin/Repair Instructions
0404-18 GHG17 DD8 - Aftertreatment Systems - Diesel Particulate Filter End Cap
0402-18
Service Bulletin/Repair Instructions
0402-18 SPN 625 (CPC) (GHG14)
ICI18-008
Service Bulletin/Repair Instructions
ICI18-008 SF552 Revised Bulletin
ICI18-008 SF552
Service Bulletin/Repair Instructions
ICI18-008 SF552 Revised Bulletin
0401-18
Service Bulletin/Repair Instructions
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
SF552
Service Bulletin/Repair Instructions
SF552 Medium Duty DD5 AC Dryer Hardware Updates
0312-18
Service Bulletin/Repair Instructions
0312-18 Installation Output Shaft Seal
0311-18
Service Bulletin/Repair Instructions
0311-18 Installation of the Main Shaft Speed Sensor
DOC-1033322
Service Bulletin/Repair Instructions
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
MY18M1
Service Bulletin/Repair Instructions
MY18M1a 05-MAR-2018 Vocational
aeo18M1
Service Bulletin/Repair Instructions
aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
sb00042
Service Bulletin/Repair Instructions
sb00042 Flood Damage Repair GuidelinesB
sb0164
Service Bulletin/Repair Instructions
sb0164 MBE Engine Support Information
sb0175
Service Bulletin/Repair Instructions
sb0175 Replacing Drive Belts on MBE4000 EnginesB
sb15020
Service Bulletin/Repair Instructions
sb15020 Alternator Remote Sense WiringB
sb2042
Service Bulletin/Repair Instructions
sb2042 Coolant Overflow Hose
sb2046
Service Bulletin/Repair Instructions
sb2046 ABA Hose Clamp Torque Values
sb2052
Service Bulletin/Repair Instructions
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
sb2053
Service Bulletin/Repair Instructions
sb2053 New Stainless Steel Lower Radiator Tubes
sb2067
Service Bulletin/Repair Instructions
sb2067 Surge Tank Leaks
sb2074
Service Bulletin/Repair Instructions
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2084
Service Bulletin/Repair Instructions
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
sb31034
Service Bulletin/Repair Instructions
sb31034 Towing ProceduresB
sb42072
Service Bulletin/Repair Instructions
sb42072 Air Leak DiagnosticsB
sb42073
Service Bulletin/Repair Instructions
sb42073 Transport Dealer Air Leak InspectionB
sb4256
Service Bulletin/Repair Instructions
sb4256 Enabling M2 Exhaust Brake Lights
sb4725
Service Bulletin/Repair Instructions
sb4725 DAVCO Preheater Fault Code SA 33 SPN 6897 FMI 6B
sb49038
Service Bulletin/Repair Instructions
sb49038 Magnetized Fill Neck for Six-Gallon DEF TanksB
sb49039
Service Bulletin/Repair Instructions
sb49039 Cleaning DEF Line ConnectorsB
sb49040
Service Bulletin/Repair Instructions
sb49040 Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser ConnectionB
sb4937
Service Bulletin/Repair Instructions
sb4937 2013 OBD GHG14, 6-Gallon DEF Header Suction Line Connection Broken by Ice PressureB
sb54122
Service Bulletin/Repair Instructions
sb54122 ICU3 Service Cluster AvailableB
sb54148
Service Bulletin/Repair Instructions
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb54194
Service Bulletin/Repair Instructions
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54278
Service Bulletin/Repair Instructions
sb54278 Powernet Troubleshooting Guide Batteries, Path, Alternator, and Starter
sb54296
Service Bulletin/Repair Instructions
sb54296 Fuel Level Sending Unit RetrofitB
sb54298
Service Bulletin/Repair Instructions
sb54298 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil Pressure GaugeB
sb60157
Service Bulletin/Repair Instructions
sb60157 Roof Noise, M2 and 108SD 114SD Day CabsB
sb98020
Service Bulletin/Repair Instructions
sb98020 Axalta Paint Finish CareB
sb9815
Service Bulletin/Repair Instructions
sb9815 Paint Finish StandardsB
ssb42072
Service Bulletin/Repair Instructions
ssb42072 Diagnóstico de fugas de aire
ssb42073
Service Bulletin/Repair Instructions
ssb42073 Inspección de fugas de aire del transportista concesionario
fsb42072
Service Bulletin/Repair Instructions
fsb42072 Diagnostic de fuite d'air
fsb42073
Service Bulletin/Repair Instructions
fsb42073 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
fsb49040
Service Bulletin/Repair Instructions
fsb49040 Conduite sous pression de fluide pour échappement diesel (DEF) débranchée au niveau du raccordement du doseur
sb0006
Service Bulletin/Repair Instructions
sb0006 Freightliner Courtesy Engineering PolicyB
SS1033289
Service Bulletin/Repair Instructions
Service Solution SS 1033289 BHM Fault Code SPN 524249 / FMI 7
SS1032728
Service Bulletin/Repair Instructions
SS 1032728 Bulkhead Module Fault Codes 524280 thru 524286 with FMI 7 Clarification
42-073
Service Bulletin/Repair Instructions
Transport Dealer Air Leak Inspection
49-040
Service Bulletin/Repair Instructions
Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
1110-17
Service Bulletin/Repair Instructions
Exhaust and Exhaust Gas Recirculation
FL740
Service Bulletin/Repair Instructions
Brake Check Valve
1105-17
Service Bulletin/Repair Instructions
EPA10, GHG14 and GHG17 Diesel Particulate Filters
1102-17
Service Bulletin/Repair Instructions
SPN 157 (MCM) (GHG17)
1101-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Noisy One-Box Aftertreatment
FL742
Service Bulletin/Repair Instructions
FL742 Freightliner and Western Star Tow Hooks
17CSA16
Service Bulletin/Repair Instructions
17CSA16 Release of DiagnosticLink® 8.06 Service Pack 1
17TS12Rev1
Service Bulletin/Repair Instructions
17TS12Rev1 GHG17 Heavy Duty Engine Platform 1-BOX? Aftertreatment System ATS Wire Harness
0806-17
Service Bulletin/Repair Instructions
0806-17 SPN 101 (MCM)(GHG17)
0803-17
Service Bulletin/Repair Instructions
0803-17 SPN 411 (MCM) (GHG17)
SS1033180
Service Bulletin/Repair Instructions
Service Solution SS 1033180 BHM Fault Code SPN 524251 FMI 7 - Extr...
SS1032974
Service Bulletin/Repair Instructions
SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
0701-17
Service Bulletin/Repair Instructions
SPN 168 (CPC3) (GHG17)
sb0002
Service Bulletin/Repair Instructions
Technical Publications Ordering
SS1033094
Service Bulletin/Repair Instructions
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
17TL7Rev
Service Bulletin/Repair Instructions
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
17TS11
Service Bulletin/Repair Instructions
Detroit? DT12? Transmission Proper Moving Procedure
17TL8Rev1
Service Bulletin/Repair Instructions
Vehicle Interface Module
0412-17
Service Bulletin/Repair Instructions
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
0411-17
Service Bulletin/Repair Instructions
SPN 5741 (ACM) (GHG17)
0410-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Hard Start No Start
17TS10
Service Bulletin/Repair Instructions
Detroit? DT12? Split Rod Bushing Repair
0409-17
Service Bulletin/Repair Instructions
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0408-17 SPN 5242
Service Bulletin/Repair Instructions
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
0407-17
Service Bulletin/Repair Instructions
GHG17 Heavy Duty- Exhaust & EGR - EGR Actuator Coolant Lines
0406-17
Service Bulletin/Repair Instructions
SPN 521221 (TCM)
0405-17
Service Bulletin/Repair Instructions
SPN 521222 (TCM)
0403-17
Service Bulletin/Repair Instructions
SPN 677 FMI 2 Starter Switch Inconsistent Diagnostics
0402-17
Service Bulletin/Repair Instructions
SPN 1322 (MCM) (GHG17)
0401-17
Service Bulletin/Repair Instructions
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
0329-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Oil Leaks
0328-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0327-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0326-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0325-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0324-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0323-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0322-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0321-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0320-17
Service Bulletin/Repair Instructions
(MCM)(GHG17)
0319-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0318-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0317-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0316-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0314-17
Service Bulletin/Repair Instructions
GHG14 Intake Manifold Pressure Too Low
0313-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0312-17
Service Bulletin/Repair Instructions
(MCM) GHG17
0311-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0310-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0309-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
TS1033014
Service Bulletin/Repair Instructions
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines. Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
0308-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0307-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0307-17 SPN
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0306-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0305-17
Service Bulletin/Repair Instructions
Diagnostic Tests
0304-17
Service Bulletin/Repair Instructions
Contaminated Fluids Diagnostic Tests
0303-17
Service Bulletin/Repair Instructions
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17
Service Bulletin/Repair Instructions
0301-17 Contaminated Fluids
0302-17
Service Bulletin/Repair Instructions
(CPC)(GHG17)
0346-17
Service Bulletin/Repair Instructions
(CPC) (GHG17)
0356-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0356-17 SPN
Service Bulletin/Repair Instructions
(MCM) (GHG17)
SS1032998
Service Bulletin/Repair Instructions
Service Solution SS 1032998 M2 mirror wind noise
SS1032989
Service Bulletin/Repair Instructions
Service Solution SS 1032989 â BHM Fault Code Changes
0208-17 SPN 412
Service Bulletin/Repair Instructions
0208-17 SPN 412 (MCM) (GHG17)
0206-17 SPN 5210
Service Bulletin/Repair Instructions
0206-17_ SPN 521049 (MCM) (GHG17)
0205-17 SPN 5210
Service Bulletin/Repair Instructions
0205-17 SPN 521052 (MCM) (GHG17)
0204-17 SPN 5210
Service Bulletin/Repair Instructions
0204-17 SPN 521050 (MCM) (GHG17)
0203-17 SPN 5741
Service Bulletin/Repair Instructions
0203-17 SPN 5741 FMI 13 (GHG17) (MCM)
18SP733
Service Bulletin/Repair Instructions
18SP733 GHG17 Medium Duty DD8 Oil Filter Kit
sb3251
Service Bulletin/Repair Instructions
Replacing or Upgrading Airliner 40K Transverse Torque Rods
0137-17
Service Bulletin/Repair Instructions
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0130-17
Service Bulletin/Repair Instructions
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0127-17
Service Bulletin/Repair Instructions
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0120-17
Service Bulletin/Repair Instructions
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
FL688
Service Bulletin/Repair Instructions
Rear Brake Calipers and Anchor Plates.
sb01101
Service Bulletin/Repair Instructions
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
sb83155
Service Bulletin/Repair Instructions
sb83155 Espar Service Information
sb2079
Service Bulletin/Repair Instructions
sb2079 20-79 - Premature Belt Wear on Cummins ISCISL with FEPTO
26-50
Service Bulletin/Repair Instructions
26-50 - M2 Shift Cable Noise, Allison Transmissions
33-28
Service Bulletin/Repair Instructions
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30
Service Bulletin/Repair Instructions
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
54-280
Service Bulletin/Repair Instructions
54-280 - Video Available for Servicing APEX 150 Sealed 16-Pin Connectors
54-275
Service Bulletin/Repair Instructions
54-275 - Chassis-Mounted Trailer PDM, Battery Power Cable Terminal Corrosion
sb2650
Service Bulletin/Repair Instructions
sb2650 M2 Shift Cable Noise, Allison Transmissions
601-13
Service Bulletin/Repair Instructions
601-13 Engine Oil Capacities
sb4930
Service Bulletin/Repair Instructions
sb4930 Gentech DEF Coolant-Flow Solenoid, Testing and Replacement
sb4932
Service Bulletin/Repair Instructions
sb4932 DEF Gauge Reading Incorrectly
sb3131
Service Bulletin/Repair Instructions
sb3131 Huck-Spin 2 Changeover
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.