Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SB83-137
Revised Freightliner Service Bulletin for ParkSmart Eberspaecher Auxiliary Heater Service. This bulletin replaces the version dated May 2015. The note in General Information has been revised to include New Cascadia. Espar information has been changed to reflect a company name change to Eberspaecher.
SB88-042
Revised Freightliner Service Bulletin for Hood-Mounted Splash Shield Rivet Replacement. Minor note: added an update of document previously submitted. The related VMRS codes are added
P3SALESCABEND
End of Production for the Freightliner P3 Cascadia Sales Cabs. Due to low production volumes, DTNA will be discontinuing the production of the Freightliner Cascadia P3 Sales Cabs.
TechTalk566564K
Tech Talk discussion on DD13 rail pressure woes.
WI21-009
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
SB54-308
Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
WI21-001
Warranty Information Letter for Detroit New Service Replacement Engine SRT Update. While validating Standard Repair Times (SRTs) for Detroit's new Gen 5 engine series, DTNA discovered an error in a pre-Gen 5 SRT for the New Service Replacement Engine Program. As a result, DTNA re-studied the SRT and concluded that time for removing/re-installing multiple components (e.g., exhaust manifold/turbo, engine sensor harness, rocker arm assemblies, etc.) should not be included.
SB35-036
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
WP20-018R
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
WP20-018
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
20TS-09
Technical Service Letter for SPN 3711 FMI 31 on GHG17 DD15 Trucks.
18SP744
Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines Service Kit.
18SP745
Special Publication Letter for EPA07 EPA10 Three-Filter Fuel System DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines Service Kit
SB54-278
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeterî is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
TechTalk4725
Tech Talk discussion about power steering fluid.
TechTalk7679
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
20CSA-15
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
SS1034761
Service Solution for P3 - CEL On and Engine de-rate due to ATD Chassis Harness Circuit 532M5+ at DEF Heater Supply location is shorted. Harness part number A66-03217-002 has been reported experiencing failures due to damages to 532M5+ circuit shorting /or corrosion in terminals at Connector (23-13053-200) harness location "ATD_CHAS_F_O_HTR_LINE_DEF_5B" .
SB42-078
Freightliner Service Bulletin for Meritor Steer Axle Drum Brake Squeal. Some Cascadia and New Cascadia vehicles equipped with Meritor steer axle drum brakes with a front axle rating less than 13,300 lb (6038 kg) have experienced brake squealing noise when the service brakes are applied at lower speeds. NOTE: This is a nuisance noise issue and not a failure. The solution given in this service bulletin may fix this issue.
SB31-043
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change. With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
20TS-05
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility. Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
SB31-044
Service Bulletin for Reflective Tape Installation. If a truck tractor is ordered without mudflaps and/or mudflap support brackets, the rear reflective tape applied to the mudflaps or mudflap brackets during production is delivered loose with the vehicle. FMVSS/CMVSS 108 S5.7.1.4.3 requires reflective tape on all truck tractors domiciled in the United States and Canada.
SB60-171
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
SB31-041
Service Bulletin for Chassis Side-Fairing Kickplate Magnet Replacement. On Freightliner Cascadia and New Cascadia vehicles manufactured before May 20, 2019, and equipped with side-fairings, the magnets that hold the kickplate closed may corrode and prevent the kickplate from staying in the closed position.
SB60-158
Service Bulletin for Marker Light Gasket Leaks, Cascadia. This bulletin replaces the version dated June 17, 2019. A procedure has been added for inspection, repair, and replacement of damaged or spun rivet nuts.
WI20-008
Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
WP20-006
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers. To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
WP20-007
Warranty Policy Letter for Chassis Progressive Damage Policy Change. Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
WP20-005
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program. DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
SB60-167
Service Bulletin for Draining Water Trapped in the Upper A-Pillar. A water leak in the seams between the cab roof and cab side wall or back wall can result in water becoming trapped in the upper A-pillar area in some Cascadia and New Cascadia vehicles. This water may migrate inside the cab and eventually spill through the marker light fastener clearance holes and drip on the dash.
WI20-004
Warranty Information Letter for Warranty Long Block Program Change. The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
SB54-327
Service Bulletin for Lengthening the Backup Light Harness. Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
SB60-169
Service Bulletin for Replacing Windshield Gasket. Different types of cab leaks can result in water dripping from the top of the windshield, onto the dash. Replacing a windshield gasket unnecessarily may create new leak issues. Do not replace a windshield gasket unless it has been confirmed to leak, using the cab pressure test.
02.2020 Campaign
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers
20TS-01
Technical Service Letter for DDC Series 60 engines concerning Series 60 Cylinder Head Resurfacing/Finish. Detroit Diesel does not recommend third party resurfacing of Series 60 cylinder heads (outside of Detroit and Detroit Reman).
SS1034068
Service Solution for Meritor Wabco OnGuard Radar Service Alignment. If the radar sensor needs to be aligned, the radar sensor mounting system has become damaged or has loosened, or new radar sensor software has been installed, a Radar Sensor Service Alignment will need to be performed.
SS1034598
Service Solution for Legacy Cascadia, where trailer turn signals or 4-way flashers used in applications with high duty cycles, the left and right turn signals may experience shortened relay life.
SB54-239
Service Bulletin for Cascadia Cabin CAN ECU Compatibility. Compatible software levels are required for the proper operation of the vehicle.
17TS9
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found on TechLit.
19TL-15
Tool Letter for ICC5 Programming Cable
SB47-027
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
82-018
Service Bulletin to fix wiper motor issue. On some Cascadia wiper park brush that rides against the brush plate may wear and may result in a diminished wiper park signal.
sb54299
Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer installed in production, and has been superseded by the ICU3S. When replacing an ICU3, the ICU3S must be installed in its place.
sb54312
Service Bulletin to replace the white drip shield and secondary SAM cover on the SAM Cabin, with a new one-piece drip shield.
sb82019
Service Bulletin to address wiper issue. On some Cascadia vehicles, when a request for wiper activation is made the wipers may not function. This can result from an overcurrent condition, which causes the wipers to stop functioning and immediately set fault code SPN 522215 FMI 6.
0609-19
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
18SP725Rev
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
19-008WI
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19TS-6
The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
19-009WI
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
sb60158
Marker Light Gasket Leaks, Cascadia
DOC-1034298
Service Solution: 1034298 - New Cascadia Engine Harness Chafe at A06-95037-000 Bracket
DOC-1034225
Accent / Park Light Function Disable Accent / Park Light Function Disable
DOC-1034231
SS 1034231 New Cascadia Fuel Gauge Not Indicating Full When Fuel Tank(s) Are Filled
DOC-1034234
SS1034234 Cascadia ICU4Me - Low Air Warning Light Not Coming On
sb72042
Installation of Vortex Generators
ICI19-016 SF560
Revised Bulletin
PTO Pump Support
Rear PTO Pump Support CA
DOC-1034220
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
sb54311
Service Bulletin- sb54311 ICU Odometer Programming
ICI19-009 FL799
Steer Axle Brake Chatter
sb42077
sb42077 Steer Axle Brake Chatter
sb54308
sb54308 Chassis ECU Programming
fp00024
fp00024 Cable-Tie Reference
sb60165
Service Bulletin-sb60165 Exhauster Splash Covers Do Not Fully Latch
sb83160
sb83160 HVAC Blend Door Retrofit
54302
ABS Light illuminating in the ICU.
sb00044
Reminder: Paper Service Bulletin Mailings Are Discontinued
sb2652 DT12 PTO
DT12 PTO Upfit
sb54302
Service Bulletin- ABS Light Illuminating in the ICU, ABS Solenoids Not Self Checking
DOC-1034171
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
8V491
ICUC Bulb check function.
0109-19
Service Information Bulletin- Input Shaft Pilot Bearing Measurement Specification
Detroit DT12
Detroit DT12 Split Rod Bushing Repair letter to customer
sb0039
Service Bulletin New "Natural Gas Vehicle Information" Webpage
1208-18
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
1212-18
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
1213-18
Service Information Bulletin
ICI12-016 FL614
Important Campaign Information on FL614 Recall
SS469068
SS 469068 Cascadia SAM Cab, SAM Chassis, MSF and CGW Hardware Compatibility
sb0006
Service Bulletin- sb0006 Freightliner Courtesy Engineering Policy
18TS4Rev DD
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
GHG17
Letter to customer on Coverage Extension GHG17 After Treatment
sb9818 Repaintin
Service Bulletin 9818- Repainting Plastic Bumper Components
HDEP PLV Return
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
SS1033121
SS 1033121 Adding a Fan Override Switch (Legacy Cascadia)
Aftertreamtent F
Service Information Bulletin for Aftertreamtent Failure Guide
DD13, DD15, DD16
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
Eaton 1800-Watt
Eaton 1800-Watt Inverter With Low Voltage communication
DOC-1033833
SS 1033833- Service Solution for Cascadia Parksmart 100 amp Durakool relay upgrade
18CSA16 Release
Release of DiagnosticLink® 8.08 Service Pack 2
TSN 32-06 Airlin
Technical Service Note: Airliner Rear Suspension Main Crossmember Fastener Replacement.
sb3125 AirLiner
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
sb60158 Marker L
Service Bulletin- Marker Light Leaks
sb0036
Operating Hours for the Customer Assistance Center
sb54301
Indel B Refrigerator Loose Circuit Board
SS1033638
SS 1033638 - Power Window Express Down Module Discontinued
0505-18
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
DOC-1033446
Vehicles with Meritor drivelines bene from a softer durometer center bearing support. Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
fp00020
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
sb31037
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed. The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
sb31038
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn. This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
ICI18-014
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
0405-18
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
0401-18
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
FL756
FL756 Brake Light Pressure Switches
0312-18
0312-18 Installation Output Shaft Seal
0311-18
0311-18 Installation of the Main Shaft Speed Sensor
DOC-1033334
SS 1033334 ICU3S Displays "Electrical System Problem Detected - Shutdown in Progress"
DOC-1033322
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
sb00042
sb00042 Flood Damage Repair GuidelinesB
sb2063
sb2063 Coolant Filter Inspection Procedure, DD13 DD15 DD16 Only
sb2066
sb2066 Gentech Low Coolant Level Sensor
sb2068
sb2068 Conventional Fully-Formulated Coolant with SCA Color Change
sb2069
sb2069 Kysor Fan Clutch Sticking
sb2070
sb2070 EPA07 and Newer Gentech Coolant-Level Sensor Testing
sb2074
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2077
sb2077 Tuned Mass Absorber Installation, Cascadia with 1625 sq in Radiator
sb2078
sb2078 Cascadia Radiator Strut Rod Rubbing on Upper RadiatorHose
sb2083
sb2083 FluidXchange Tool and FittingsB
sb2652
sb2652 DT12 PTO UpfitB
sb31034
sb31034 Towing ProceduresB
sb3250
sb3250 Incorrect ECAS Ride Height Sensor and Linkage InstallationB
sb3251
sb3251 Replacing or Upgrading Airliner 40K Transverse Torque RodsB
sb3329
sb3329 Caster Angle Specifications, Cascadia vs. New CascadiaB
sb4267
sb4267 Brake Shimmy?Meritor® SteeLite X30? Brake Drum with Excessive RunoutB
sb54148
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb54296
sb54296 Fuel Level Sending Unit RetrofitB
sb60159
sb60159 Shifter Adapter Plate for Replacement Cab or Cab FloorB
sb83158
sb83158 ParkSmart Control Module Cover Modification for a New Phase HarnessB
sb98020
sb98020 Axalta Paint Finish CareB
fp31028
fp31028 Cascadia 14.5-Inch Hendrickson Aero-Clad Stainless-Steel Bumpers
fp54031
fp54031 Ordering Service Wiring Harnesses for Cascadia
fsb4269
fsb4269 Humidité excessive dans le système d'air
17-029
Computer Hook-Up Standard Diagnostic Time Update
17CSA25
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17TL26
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17TL27
17TL27 Injector Cup Tool DSN930E17001
17TL28
17TL28 Fuel Injector Removal Tool DSN930E17004
17CSA24
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17-028
OWL Enhancement Service Model Field
17CSA23r
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
17-026
17-026 Holiday Closure 2017
17-027
Warranty Classroom Training in 2018
17TL25
17TL25 TruckCam? Alignment System
1110-17
Exhaust and Exhaust Gas Recirculation
14CSA23
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
17TS17Rev
Instructions for CSC Diagnostic Support
SS1023069
Cascadia - Engine Will Not Crank (No Starter Output from SAM Cab)
17-023
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
0904-17
Aftertreatment Systems - Diesel Exhaust Fluid Pump Module and Components
0903-17
Engine Manufacturer Diagnostics
sb4641
Adjusting Tilt Lock Force on TRW Steering Columns
SS3704
Cascadia Fault codes 6.0
SS1032974
SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
SS3672
SAM Cab & SAM Chassis Wall Charts
sb0002
Technical Publications Ordering
0609-17
SPN 3226 (ACM) (GHG17)
0608-17
Diagnostic tests - Two Filter System - FSIC Leak Test
0607-17
SPN 96 (MCM) (GHG17)
0606-17
SPN 3226 (ACM) (GHG17)
0604-17
SPN 712 (CPC) (GHG17)
0603-17
Fuel System Integrity Check Routine - Two-Filter Fuel System
0602-17
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
0601-17
SPN 3464 (MCM) (GHG14)
SS1033094
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
17-012
Cascadia Windshield Improvements
0409-17
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
SS1033047
Service Solution SS 1033047 M2 Battery Drain Problem â Mismatched I...
0315-17
GHG14 - Intake Manifold Pressure Too Low
0314-17
GHG14 Intake Manifold Pressure Too Low
TS1033014
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines. Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
0303-17
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0202-17
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
0141-17
0141-17 SPN 2659 (MCM) (EPA10)
0120-17
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17
0118-17 Symptom Diagnostics - Oil Leaks
0115-17
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
0114-17
0114-17 SPN 2791 (MCM) (EPA07;EPA10)
0113-17
0113-17 SPN 3361 (ACM) (EPA10)
SS469076
Odometer racks up mileage when the vehicle is stationary - Cascadia
1213-16
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
1207-16
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
16TS24
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
18SP714
18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
18SP718
18SP718Rev EPA07 DD1516 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
18SP719
18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
16TL20
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
1021-16
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1020-16
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
1018-16
1018-16 SYMPTOM DIAGNOSTICS - NOISE
1017-16
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL17
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
18SP713REV 18SP7
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP720REV 18SP7
18SP720REV 18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
SB0006
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
SB54291
SB54291 DETROIT ASSURANCE LANE DEPARTURE WARNING CAMERA INSTALLATION
SB54297
SB54297 LOOSE IGNITION SWITCH ON CASCADIA VEHICLES
16 TS-18
16TS18 EPA10 AND LATER DD AUTO-ELEVATE FEATURE
09 09-16
0909-16 EXCESSIVE OIL CONSUMPTION
09 06-16
0906-16 LOW PRESSURE FUEL PUMP
09 02-16
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
08 10-16
0810-16 SYMPTOM DIAGNOSTIC NOISE
08 09-16
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
16 TS-14
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
16 TS-15
16TS15 EPA07 AND LATER POWER TAKE-OFF (PTO) DOSING FEATURE
06 12-16
0612-16 SPN 175 (MCM) (GHG17) AND SPN 175 (MCM); ( EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 11-16
0611-16 SPN 110 (MCM) (GHG17) AND SPN 110 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 10-16
0610-16 SPN 111 (CPC) (GHG17) AND SPN 111 (CPC); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 09-16
0609-16 SPN 174 (MCM) (GHG17), SPN 174 (MCM) (EPA07), SPN 174; (MCM) (EPA10), AND SPN 174 DIAGNOSTIC PROCEDURE
06 05-16
0605-16 SPN 625 (CPC)(GHG17) AND SPN 625 (CPC) (EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 01-16
0601-16 SPN 103 (MCM) (GHG17) AND SPN 103 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
54-264
CASCADIA VIRTUAL TECHNICIAN RETROFIT
60-158
MARKER LIGHT LEAKS
0502-16
FMI 3 Engine Oil Pressure Sensor Circuit Failed High
0504-16
Inspection of the DD13 Turbocharger
0505-16
Metal in the Fuel - Three- Filter Fuel System
0507-16
FMI 5 Oil Pressure Sensor Stuck High
0510-16 SPN 2623
SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
0513-16
FMI 2, 3, 4 Remote Accelerator Pedal Supply Voltage
0514-16
Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
18SP726rev
18SP726 ? EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Fee
sb3233
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16TL4
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS9
16TS9 DD Platform High Pressure Fuel Lines
16TS8
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16TL5
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16-010
Warranty Recognition Program Suspension
16-011
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
16TS7 Reman Diesel Particulate Filter Serial Number
16TL3
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
16-008
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
16-009R_OWL Enhancements
16_TL-2
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
16TS6
16TS6 Variable-Speed Fan Operation on Cascadia Vehicles
0307-16 SPN 723
0307-16 SPN 723 (MCM) March
16-007
Canadian Warranty Parts Return Address Change
16TS5
16TS5 Release of the DD Platform Bearing Failure Guide
0304-16 SPN 2791
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0302-16
Contaminated Fluids
0301-16 SPN 625
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
0303-16
Hydrocarbon Doser Coolant Lines
ICI15-019
FL679 Revised Bulletin
1210-14
1210-14 Cylinder Head
1207-15
1207-15 Updated procedures with adding EPA10 to the GHG14 title
1205-15
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
15TL24
15TL24 OTC 1750 Revolver Engine Stand
15TS4
15TS4_Rev2_ EPA07 DD15 Piston Kits
1202-15
1202-15 Symptom Diagnostics - ATD Checklist
15TS16
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1201-15
1201-15 Crankshaft and Bearings
18SP729
18SP729 ? EPA07 10 Three-Filter Fuel
18SP730
18SP730 ? EPA07 10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
18SP720
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP722
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
18SP725
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
AEO15M1
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
15TL20
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
15-028
_NewDetroitCoolantLineSRTs
15-028A
15-028 New Detroit Coolant Line SRTs
15-029
_Warranty Recognition Program - Coming Soon
ICI15-012 FL679
Interim Recall Ending ? Final Recall to Begin
sb4012 40-12
- Tire Pressure Monitoring System (TPMS) Display Firmware Update
sb54291 54-291
- Detroit Assurance Lane Departure Warning Camera Installation
805-15
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
803-15
803-15 Removal of the Camshaft Housing
FSB-54-293
FREIGHTLINER: INFORMATION PROVIDED REGARDING WATER INTRUSION AND FOREIGN DEBRIS CAN ENTER SAM CHASSIS AND ELECTRICAL COMPONENT, WHEN COVER IS NOT SHUT SECURELY AND SWINGS OPEN. MODEL CASCADIA. NO MODEL YEARS LISTED. *PE
sb54293
sb54293 SAM Chassis Water Intrusion Prevention
sb9815
sb9815 Paint Finish Standards
711-15
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
15TS14 GHG14
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
706-15
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
703-15
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
702-15
702-15 DD15 and DD16 Delphi © Exhaust Gas Recirculation Valve Actuator
704-15
704-15 SPN 4364 (ACM)(EPA10)
sb3531
sb3531 Differential Lubrication, Detroit Model 6 Axles
sb54239
sb54239 Cascadia Cabin CAN ECU Compatibility
sb54278
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sb54291
sb54291 Detroit Assurance Lane Departure Warning Camera
sb54292
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
sb83114
sb83114 Approved Leak Detection Methods for Air Conditioning
15-017
15-017 Detroit: Updated Fuel Injector SDTs
512-15
512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod
511-15
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
509-15
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
508-15
508-15 SPN 625 (MCM)( EPA10;GHG14)
507-15
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
506-15
506-15 Air Compressor Coolant Lines
505-15
505-15 SPN 3361 (ACM) (EPA10)
15-015
15-015 Warranty Exclusions Reminder
15-016
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
504-15
504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod
503-15
503-15 DD13 Exhaust Gas Recirculation Valve Actuator
502-15
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
501-15
501-15 Engine Lifter Brackets
FL679
FL679 Freightliner Cascadia SAM Chassis
sb2084
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
sb4654
sb4654 Rack and Pinion Steering Gear Retrofit Guide
sb8217 82-17
sb8217 82-17 - Wiper Blade Replacement to Reduce Ice Accumulation On Passenger-Side Wiper, Cascadia Vehicles
sb83137
sb83137 ParkSmart?/Espar Auxiliary Heater Servic
15CSA10
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
406-15
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
405-15
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
404-15
404-15 SPN 4364 (ACM) (EPA10)
403-15
403-15 SPN 677 (MCM)(EPA07)
15TL6
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
402-15
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
18SP717
18SP717 DD13 EGR Actuator Replacement
401-15
401-15 Cylinder Block
sb3133
sb3133 Step Clamps Are Not Reusable
15-010
15-010-DLR Transmission Cooler Line Photos
15TS9
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
15-009 - Detroit
15-009_Detroit_New_SDTs
15TL5
15TL5 DAVCO Shop Pro® FXP 95
309-15
309-15 SPN 3251 (ACM)(EPA10)
307-15
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
306-15
306-15 SPN 3246 (ACM)(EPA10;GHG14)
305-15
305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor
15TL4
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
18SP706
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
18SP712
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
301-15
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
sb01101
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
sb54288
sb54288 Aftertreatment Harness Modification
15TS8
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0204-15
0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment
15TS6
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
0203-15
0203-15 Oil Filter Stand Pipe
15TS5
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
0202-15
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
60-156
60-156 - FE13 Roof Fairing Brace Cracking, Cascadia Daycab
83-144
83-144 - Optimized Idle and Auxiliary Cab Heater Concurrent Operation
15TS2
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder Misfire At Idle
ICI15-002
ICI15-002-DLR SF503 Revised Bulletin
0108-15
0108-15 SPN 1323 through 1328 (MCM) (GHG14)
0107-15
0107-15 Enhanced Steam Clean
0106-15
0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
0105-15
0105-15 SPN 102 (MCM) (GHG14)
0104-15
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
102-15
102-15 High Pressure Fuel Pump - Two-Filter System
0101-15
0101-15 SPN 4364 (ACM) (EPA10)
18SP687
18SP687 DD15 16 EGR Actuator Replacement
FSC-503-A
DAIMLER TRUCKS: RADIATOR RESONANCE RESULTS IN TUBE FRACTURES COOLING AND LEAKAGES AND OCCURS IN TRUCKS CONFIGURATIONS AT CERTAIN OPERATIONAL SPEEDS. *PE
SF503
SF503-DLR Cascadia 1625 Radiator Tuned Mass Absorbers
sb60156
sb60156 FE13 Roof Fairing Brace Cracking, Cascadia Daycab
sb83155
sb83155 Espar Service Information
1110-14
1110-14 EPA10 DOC Inlet Pressure Sensor
1108-14
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
1105-14
1105-14 Flywheel, Ring Gear and Flywheel Housing
1104-14
1104-14 Metal in the Fuel System
1102-14
1102-14 DD13 Cylinder Head R&R
1101-14
1101-14 DD15 and DD16 Cylinder Head
18SP707
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
18SP708
18SP708Rev EPA07 10 Three-Filter Fuel
18SP711
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
sb4271
sb4271 Rear Axle S-Cam Support Bracket Replacement
14TL8
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS19
14TS19Rev DD Platform High Pressure Fuel Lines
14-036
14-036-DLR DTNA & JAD Highlights - Q3
14-038
14-038 Additional Detroit Standard Repair Times
14-038A
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
14-039 New Detroit Standard Diagnostic Times
14-039A
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
14TL9 Special Tool Warranty Program.
14TL7
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-035
14-035 Detroit Standard Repair Time Updates for Cascadia Truck Models
14-035A
14-035_SRT_Update_for_Cascadia Detroit Standard Repair Time Updates for Cascadia Truck Models
1010-14
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
14TS28
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1007-14
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
1005-14 Oil Coolant Module
1003-14
1003-14 Rough Running or Stalling.
18SP684REV4
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
sb2080 Australian CST M1400 Isolated Radiator Retrofit
sb54287
sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
sb60155
sb60155 Water Leak at the Top of a Cab Door, Cascadia Day Cab
sbw5460
sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
920-14
920-14 Additional Cleaning and Preparing
919-14
919-14 Exhaust Gas Recirculation Flow Target Error Diagnostic - High Flow
14TS26
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
918-14
918-14 Removal and Installation and Inspection of the Fuel Cooler Delete Bypass Plate - Two Filter System
917-14
917-14 Installation and Removal of the Oil Filter Stand Pipe
916-14
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
915-14
915-14 Backwards Running Engine Detecte
913-14
913-14 Checking for Poor Engine Brake Performance
14TS25
14TS25 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
912-14
912-14 Coolant in Oil
911-14
911-14 5V Sensor Supply Bank 2 Circuit Failed High
910-14
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
909-14
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
908-14
908-14 908-14 EGR Differential Pressure Failed (High Box)
907-14
907-14 Installation and Removal of the Flywheel Housing
906-14
906-14 Installation of the Oil Pan
905-14
905-14 Coolant Level Circuit Failed
904-14
904-14 Selective Catalyst Reduction Outlet NOx Sensor Circuit Failed High and Low
903-14
903-14 Selective Catalyst Reduction Inlet NOx Sensor Circuit Failed High and Low
18SP701
18SP701Rev3 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
32-50
32-50 - Incorrect ECAS Ride Height Sensor and Linkage Installation
35-23
35-23 - Breather Oil Leak on Freightliner Tandem Rear Axles
14TS21
14TS21 HDEP Camshaft Position Sensor Change
14-017R
14-017R Revised: Detroit Addition of Admin Time
806-14
806-14 FMI 0, 8, 20: SCR Outlet Temperature Signal Spike
14-029
14-029 New Detroit Standard Diagnostic Times
49-35
49-35 - DEF Return Line Fitting Heater, 6-Gallon Tanks
54-239
54-239 - Cascadia Cabin CAN ECU Compatibility
60-144
60-144 - New Cascadia Windshield Seal, Adhesive, and Preparation
FL662
FL662.-DLR Meritor MSF12 Non-Conforming Front Axle Beams
14TL2
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
14-028 Remy Extended Coverage Direct File
14-027
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
14-026-DLR SelecTruck Warranty Enhancements
715-14
715-14 Symptom Diagnostics - Coolant Los
14-022
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
14-023 Detroit Axles Pre-Approval Changes
14-024
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
714-14 Symptom Diagnostics - Low Engine Compression
713-14
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
712-14 Engine Coolant Temperature
703-14
703-14 SPN 3556 (ACM) (EPA10)
ICI-14-012
DAIMLER (FREIGHTLINER): INFORMATION CONCERNING MASTER HEADLIGHT SWITCH IN MARKER LIGHTS POSITION CAUSING DAYTIME RUNNING LIGHTS TO FAIL, AND NOT TO USE MARKER LIGHTS POSITION WHEN DRIVING. MODEL 2007-2014 CASCADIA. *PE
18SP709
18SP709Rev 18SP709Rev ? EPA10/GHG14 Two-Filter Fuel
18SP710
18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel
20-73
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
54-215
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
54-218
54-218 - Adding Daytime Running Lights (DRL)Option to Business Class M2 Vehicles
54-285
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
FAB158
Freightliner Action Bulletin FAB158 Cummins Eaton SmartAdvantage
524-14
524-14 FMI 0: Engine Speed High
14TS13
14TS13Rev EPA10/GHG14 Diesel Exhaust Fluid (DEF) in Fuel System/Diesel Fuel in DEF System Contamination
519-14
519-14 FMI 1: SCR NOx Conversion Efficiency Very Low
518-14
518-14 FMI 1, 18: Regen Temperature- Out Of Range Low
516-14
516-14 FMI 3, 4: DEF pressure sensor circuit failed hig
513-14
513-14 FMI 0: Diesel Particulate Filter Outlet Temperature - Very High
507-14
507-14 Inspection of the DD15 and DD16 Axial Power Turbine
506-14
506-14 506-14 Removal and Installation and Inspection of the Exhaust Gas Recirculation Valve Actuator Pull Rod
505-14
505-14 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
504-14
504-14 Test-E - Three-Filter Fuel System
503-14
503-14 FMI 3, 4: High Side Digital Output 3 Circuit Failed High
502-14
502-14 FMI 4 SCR Inlet Temperature High
18SP684
18SP684Rev3 EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
sb5421
sb54215 54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
495
ELECTRONICALLY CONTROLLED AIR SUSPENSION IS BEING REPLACED. *LJ UPDATED 6/26/14. *PE UPDATED 7/3/14. *PE
14TS5
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
0228-14
0228-14 Engine Oil Leaks - Oil Dye Method
14TS4
14TS4 Valve and Liner Installation Tool Issue
0226-14
0226-14 SPN 3216 FMI 3, 4 (ACM2)(EPA10)
13wo3re
13wo3rev2_final Actual Labor Hours on Detroit Claims
0224-14
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0222-14
0222-14 SPN 4334 FMI 7 (ACM) (EPA10)
0219-14
0219-14 Metal in Fuel
0218-14
0218-14 GHG14 Diesel Exhaust Fluid Pump Module Filter
0217-14
0217-14 Installation of the Fuel Injector Cup
0216-14
0216-14 SPN 3363 FMI 1 - ACM - EPA10 - GHG14
0215-14
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0210-14
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0207-14
0207-14 SPN 3031 FMI 3, 4 (ACM) (EPA10 - GHG14)
0202-14
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0201-14
0201-14 SPN 1761 FMI 3, 4 (ACM2-EPA10) (ACM2.1-GHG14)
0227-14
0227-14 SPN 4335 FMI 7 - EPA10
0229-14
0229-14 Symptom Based Diagnostics - Oil Separator
0230-14
0230-14 SPN 4375 FMI 6 - EPA10
0233-14
0233-14 SPN 51 FMI 2 - All Years
0237-14
0237-14 Engine Brake Solenoid
0238-14
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
54-278
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
54-281
54-281 - Fuel Level Sender Guard Installation
FAB154
Freightliner Action Bulletin FAB154 New options for Cascadia
FAB153
Freightliner Action Bulletin FAB153 New Harness Highway for Cascadia
FSB-83-131
FREIGHTLINER: INFORMATION REGARDING THE REPLACEMENT LINE WITH A NEW ASSEMBLY CONNECTING THE MANIFOLD WITH A HOSE AND HOSE BARB, IN THE EVENT HEATER RETURN PIPE (HT2 LINE) FAILS ON THE ENGINE. MODEL CENTURY CLASS CONVENTIONAL, COLUMBIA, CASCADIA. NO YEARS LISTED. *PE
13TS30
GHG14 DD Engine EGR System Fault Codes
13TS28
GHG14 472906S Turbocharger Compressor Inlet
13TS15
13TS15Rev EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251/FMI 2 - DOC Inlet Pressure Sensor Not Plausible
13TS22
Rev DD Platform Fuel Injector Cup Seal
13TS25
Issues with PTO and Remote Throttle Combinations
13M2
13m2 -Final-23-SEP-2013 Field Service Campaign 13M2
13M2-02
13m2- Equipment Owner Field Service Campaign - 13M2
25-34
25-34 - Clutch-Related No-Start Diagnostics
33-28
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
54-274
54-274 - Plastic Battery Box Cover Retainer Clip
54-277
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
54-279
54-279 - Intermittent Communication Between the TrailerTRACS Transmitter and the Qualcomm Unit
54-280
54-280 - Video Available for Servicing APEX 150 Sealed 16-Pin Connectors
FSB-35-30
FREIGHTLINER: ON RECOMMENDATION OF CONMET, REPLACEMENT OF BEARING SPACER, WITH A NEW ONE, IS REQUIRED WHEN A HUB IS REMOVED. *PE
13TS-24
13TS-24 DD Platform High Pressure Fuel Lines
808-13
808-13 FMI 0 Under Pressurized DEF System
803-13
803-13 FMI 2: Intake Throttle Position Deviation Error
803-13 B
803-13 FMI 10,18: Intake Throttle Position Abnormal Rate of Change, Position Data Valid but Below Normal Operating Range - Moderately Severe Level
802-13
802-13 FMI 18 Coolant Level Low
18SP697
18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935
18SP698
18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932
18SP699
18SP699 EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Feed Lines PN A4710706035
18SP700
18SP700 EPA10,GHG14 Two-Filter Fuel System KM59 GEN1 DD15,16 High Pressure Fuel Feed Lines PN:A4720708032
54-275
54-275 - Chassis-Mounted Trailer PDM, Battery Power Cable Terminal Corrosion
FAB145
Freightliner Action Bulletin FAB145 New Cascadia Roof Fairing
FAB146
Freightliner Action Bulletin FAB146 Cascadia LED headlights
716-13
716-13 SPN 3226-FMI 13 - EPA10 - GHG14, SPN 3216-FMI 13 ? EPA10, SPN 3216-FMI 13 - GHG14
714-13
714-13 Fuel Filter Maintenance Intervals
713-13
713-13 SPN 4334-FMI 7 - EPA10
709-13
709-13 SPN 2798-FMI 4-EPA10-GHG14
708-13
708-13 Fuel System Diagram Update
706-13
706-13 SPN 157-FMI 10, 15, 17, 18 - GHG14
SB-09-35
FREIGHTLINER: REPLACEMENT OF THE ENGINE AIR FILTER ELEMENT. IF THE AIR FILTER IS INSTALLED IMPORPERLY IT COULD CAUSE ENGINE DAMAGE OR FAILURE. *KB
SB-42-69
FREIGHTLINER: BENDIX AIR DRYERS ARE EXPERIENCING EXCESSIVE MOISTURE IN THE AIR SYSTEM. THIS COULD POSSIBLY LEAD TO TRANSMISSION SOLENOID FAILURE. *KB
sb0935
sb0935 Replacing the Engine Air Filter Element, Donaldson Air Cleaner (03-33648-001-002)
sb4269
sb4269 Excessive Moisture in the Air System
611-13
611-13 Removal and Installation of the GHG14 Six-Gallon Diesel Exhaust Fluid Tank Header
607-13
607-13 SPN 3361-FMI 7- EPA10
604-13
604-13 Performing a Parked Regeneration
603-13
603-13 SPN 84 -FMI 6 - EPA07-GHG14
SF480
SF480-DLR Qualcomm TrailerTRACS Wiring
13TS17
13TS17 EPA10-GHG14 Diesel Exhaust Fluid (DEF) in Fuel System-Diesel Fuel in DEF System Contamination
531-13
531-13 GHG14 DD15 Asymmetrical Turbocharger
532-13
532-13 Description and Operation of the Two-Stage Valve - Two-Filter Systems
530-13
530-13 Low Pressure Fuel Pump ? Two-Filter Fuel System
529-13
529-13 Operation of the Fuel System - Two-Filter Fuel System
528-13
528-13 SPN 3246-FMI 0 - EPA10 - GHG14
527-13
527-13 SPN 190-FMI 15,17 GHG14
525-13
525-13 SPN 2791-FMI 7 ? ALL YEARS
520-13
520-13 Cylinder Block
518-13
518-13 SPN 4334-FMI 4 - GHG14
83-153
FREIGHTLINER: PARKSMART WITH DDC OPTIMIZED IDLE. DETROIT DIESEL OPTIMIZED IDLE AFFECTS THE WAY PARKSMART OPERATES. *JS
FSC-480-A
DAIMLER TRUCKS: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN TRUCKS, BETWEEN THE QUALCOMM UNIT AND TRAILER TRACS TRANSMITTER, COMMUNICATION IS INTERMITTENT, DUE TO LACK OF RELIABLE SIGNAL STRENGTH AND A MORE ROBUST WIRING WILL BE INSTALLED TO CORRECT ISSUE. MODELS 2010-2013 CASCADIA. *PE
SB-3132
FREIGHTLINER: THE CHASSIS SIDE FAIRING LOWER DEFLECTOR RETENTION. THE C-CLIPS THAT ARE ATTACHED TO THE CHASSIS SIDE FARING LOWER AIR DEFLECTORS MAY BECOME LOOSE. *JS
sb3529
sb3529 Axle Alignment Specifications
sb4932
sb4932 DEF Gauge Reading Incorrectly
418-13
418-13 SPN 2791-FMI 12 - GHG14
414-13
414-13 Removal and Installation of the GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank Header Unit
413-13
413-13 GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank
407-13
407-13 EGR Actuator Slow Learn
sb54215
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
sb60144
sb60144 New Cascadia Windshield Seal, Adhesive, and Preparation
sb83145
sb83145 ParkSmart Refrigerant Loop Service Kits
13TS10
13TS10 DD Platform Oil Coolant Module Plugs
311-13
311-13 SPN 651-FMI 3 - EPA10 - GHG14
310-13
310-13 Draining the Fuel System Using J-48710 Prior to Repairs
303-13
303-13 SPN 3242-FMI 4 -EPA10 - GHG14
301-13
301-13 SPN 5018- FMI 18 -GHG14
FL633
FL633-DLR Certification Door Labels - Tire Inflation
sb3132
sb3132 Cascadia Chassis Side Fairing Lower Air Deflector Retention
13TS6
13TS6 DD Platform Engine Oil Filter.pdf
13TS5
13TS5 DD Platform Fuel Filter Module
207-13
207-13 Removal and Installation of the Camshaft Housing
ICI13-001
ICI13-001-DLR FL631 - Revised Bulletin
13WO-2
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
18SP693
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
FL631
FL631-DLR Perpendicular Aluminum Air Tank Mounting Brackets
132-13
132-13 SPN 3597-FMI 4 - EPA10
133-13
133-13 SPN 4375-FMI 4 and 5 - GHG14
135-13
135-13 SPN 1243-FMI 14 - GHG14
137-13
137-13 SPN 2798-FMI 4 - EPA10 - GHG14
139-13
139-13 SPN 3251-FMI 0, 16, 20, 21 GHG14
13TL2
13TL2 GHG14 Test Electronic Control Units (ECUs).
13TS2
13TS2 Single-Speed Fan Operation on Cascadia Vehicles
143-13
143-13 Low Pressure Fuel System - Measuring Fuel Pressure Using Fuel System Integrity Check, Two-Filter Fuel System
144-13
144-13 Removal and Installation of the GHG14 Diesel Exhaust Fluid Lines
145-13
145-13 Description and Operation of Gear Train and Related Parts
146-13
146-13 SPN 4335-FMI 1 EPA10
148-13
148-13 GHG14 DD15 Asymmetrical Turbocharger Exhaust Manifold
129-13
129-13 DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE
128-13
128-13 SPN 511403-FMI 0,1,2,3,4,5,6,8,9,10,11,12,13,14
126-13
126-13 Description and Operation of the DD15 and DD16 Exhaust Gas Recirculaton Cooler
124-13
124-13 Installation of the DD Platform EGR Actuator Pull Rod
119-13
119-13 Exhaust Gas Recirculation System - Cleaning
112-13
112-13 SPN 4364-FMI 18 - GHG14
111-13
111-13 SPN 4374/FMI 0, 1, 3, 4 - GHG14
110-13
110-13 SPN 5435-FMI 7 - GHG14
109-13
109-13 SPN 3250-FMI 31 (ACM2.1) GHG14
108-13
108-13 SPN 3364-FMI 18 - GHG14
107-13
107-13 SPN 84-FMI 7 - GHG14
106-13
106-13 SPN 100-FMI 10 - GHG14
105-13
105-13 SPN 625-FMI 13 - GHG14
104-13
104-13 SPN 1592-FMI 13 and 19 - GHG14
103-13
103-13 SPN 520328-FMI 7 - GHG14
102-13
102-13 SPN 84-FMI 13, 19, 21 (MCM) EPA10-GHG14
101-13
101-13 SPN 3563 FMI 21 - GHG14
sb0934
sb0934 EPA10 Cummins ISX Air Intake Heat Shield Removal
sb8844
sb8844 Braces for Cascadia Cab-Mounted Splash Shields
12-039
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
12-040-DLR Roof Fairing Removal Program
12-041
12-041-DLR Over the Counter No Hassle Warranty (OTC)
ICI12-028
ICI12-028-DLR FL632 - Interim Notice
ICI12-027
ICI12-027-DLR Interim FL631 Ending - Final Recall to Begin
12-038
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
SB42-68
FREIGHTLINER: BRAKE S-CAM TUBE LUBRICATION INTERVAL CHANGE. TO ENSURE OPTIMUM SERVICE LIFE AND TROUBLE-FREE OPERATION, THE RECOMMENDED MAINTENANCE INTERVAL FOR LUBRICATING MERITOR S-CAM BRAKE TUBES ON CENTURY CLASS, COLUMBIA, CASCADIA AND CORONADO OVER-THE-ROAD VEHICLES IS CHANGED FROM M2 TO THE M1 MAINTENANCE INTERVAL. *JS
sb2073
sb2073 Cascadia Radiator Update - EPA10
sb2534
sb2534 Clutch-Related No-Start Diagnostics
sb4268
sb4268 Brake S-Cam Tube Lubrication Interval Change
sb4724
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
1118-12
1118-12 SPN 705-FMI 5 - GHG14
1113-12
1113-12 SPN 3226/FMI 20 - GHG14
1112-12
1112-12 Test C -Two-Filter Fuel System
1102-12
1102-12 Test A - Two-Filter Fuel System
1101-12
1101-12 Test B -Two-Filter Fuel System
SF-471-AB
DAIMLER TRUCK: THICKNESS AND EXCESS MATERIAL FROM DIE PUNCHING MAY PREVENT RETAINING SNAP RINGS FROM FULLY SEATING IN DIFFERENTIAL LOCK SHIFT FORK ASSEMBLIES, CAUSING DIFFERENTIAL LOCK TO REMAIN UNENGAGED OR ENGAGED. MODELS 2011-2012 BUSINESS CLASS M2, CASCADIA, COLUMBIA, CORONADO, WESTERN STAR 4900. *PE
sb3131
sb3131 Huck-Spin 2 Changeover
903-12
903-12 Installation of the Intake Throttle Valve and Adaptor.pdf
12CSA18
12CSA18 Update to Fix Internet Explorer - A Script on this Page is causing Internet Explorer to Run Slowly Issue
12-022
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
12C3
12C3 - Instructions-DocTrac -Final
12C3bul
12C3bul-DocTrac - Final
aeo12C3
aeo12C3-DocTrac -Final
sb3130
sb3130 Quarter Fender Reinforcement
FSB-42-67
FREIGHTLINER: ON SOME TRUCKS, WHENEVER BRAKES ARE APPLIED, THE TRUCK WOULD EXPERIENCE SEVERE SHIMMY OR SHAKING. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, ARGOSY COE, COLUMBIA, CORONADO, BUSINESS CLASS M2, CASCADIA, 108SD/114SD. NO MODEL YEARS LISTED. *PE UPDATED 11/1/12. *PE
FSB-49-33
FREIGHTLINER: EXCESSIVE WHITE CRYSTAL OR POWDER AROUND DEF FITTING, CAUSED BY EVAPORATION OF DEF WHEN EXPOSED TO AIR AND/OR DAMPNESS, INDICATES A LEAK IN DIESEL EXHAUST FLUID OR IMPROPER INSTALLATION OR DAMAGED CONNECTORS WOULD HAVE LEAKS IN COOLANT LINES. *PE
FSB-54-231
FREIGHTLINER: INFORMATION PROVIDED FOR REPLACEMENT HARDWARE PARTS FOR A SAM CHASSIS OR A SAM CAB. *PE
FSB-32-46
FREIGHTLINER: FOR SOME MODEL TRUCKS, RECOMMENDATION OF PREVENTIVE MAINTENANCE INTERVALS FOR REAR HEAVY DUTY SUSPENSION AND OFF HIGHWAY AND SEVERE SERVICE OPERATING CONDITIONS REQUIRES FREQUENT INSPECTIONS. *PE
FSC-455-A
DAIMLER TRUCK (FREIGHTLINER): THE LINE FOR A/C MAY BE REPLACED DUE TO POSSIBLE SPLIT IN THE BEND IN LINE, WHICH IS TIGHT, AND THE RECEIVER DRYER, IF NECESSARY, WILL ALSO BE REPLACED. *PE
SB-49-28
DAIMLER TRUCKS: THERE ARE NEW CGI BELLOWS, BECAUSE THE OLD ONES ARE PRONE TO FATIGUE AND MAY FAIL. *RM UPDATED 4/24/12. *PE
RC-FL-609A
DAIMLER TRUCKS: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN TRUCKS, A DEFECT REGARDING THE RUBBER ISOLATOR, WITH A BOLT ATTACHMENT, THE SUPPORT BRACKET MAY LOOSEN AND BACK OUT, CAUSING SHORT CIRCUIT BETWEEN CHASSIS AND UN FUSED STARTED CABLE. *PE
SB-54-262
DAIMLER TRUCKS: THERE MAY BE A RATTLE IN THE SWIVEL TYPE UTILITY LAMP. THE BOLT MAY ALSO LOOSEN OVER TIME. *RM
SB-88-42
DAIMLER TRUCKS: THERE ARE HOOD MOUNTED SPLASH SHIELDS THAT CAN FAIL ON SOME CASCADIA VEHICLES. RIVETS ON THE SHIELD MAY BREAK, LOOSEN, OR FALL OUT. *RM
SF-452A
DAIMLER TRUCKS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THERE MAY BE INCORRECT REAR DRIVE AXLE ALIGNMENTS. *RM
SB-32-48
FREIGHTLINER: THE REAR SUSPENSION AIR SPRING HAS BEEN REDESIGNED. *RM
TSB-65-255
FREIGHTLINER: ELECTRICAL SYSTEM UPDATE 2010.5 PRE SERIES VEHICLE INFORMATION. IN APRIL 23 PRE SERIES VEHICLES WERE BUILT WITH AN UPDATED ELECTRICAL SYSTEM. ANOTHER PRESERIES FOR APPROXIMATELY THE SAME NUMBER OF VEHICLES WAS RELEASED IN 6/10. NO MODEL YEARS ARE LISTED. *PE
SB-88-41
DAIMLER TRUCKS: THE HOOD RESTRAINT CABLE MAY INTERFERE WITH THE A/C LINES. *RM
ICI-10-028
DAIMLER TRUCKS: REVISIONS TO A PREVIOUS SERVICE CAMPAIGN. *RM
SB-32-40
DAIMLER TRUCKS: TROUBLESHOOTING FOR A MISALIGNMENT OF THE SUSPENSION AIR SPRINGS. *RM
SB-46-48
FREIGHTLINER: TRW TAS85 STEERING GEAR INTERNAL LEAKAGE TEST. SOME TRW TAS85 STEERING GEARS HAVE BEEN EQUIPPED WITH AN INTERNAL RELIEF VALVE. THESE STEERING GEARS ARE TYPICALLY INSTALLED WITH POWER STEERING PUMPS THAT HAVE A PRESSURE RELIEF RATING GREATER THAN 2175 PSI (150 BAR). THE INTERNAL RELIEF VALVE LIMITS MAXIMUM SUPPLY PRESSURE TO PROTECT THE STEERING GEAR. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, COLUMBIA, CORONADO, BUSINESS CLASS M2 AND CASCADIA. NO MODEL YEARS LISTED. *PE
SB-54-242
FREIGHTLINER: CASCADIA BATTERY BOX COVER. IN SOME CLIMATES, IT IS HELPFUL TO HAVE THE BATTERIES COVERED TO PREVENT ICE AND SNOW BUILD UP WHEN THE CASCADIA IS EQUIPPED WITH CHASSIS SIDE FAIRINGS. IF DESIRED, A BATTERY BOX INSTALLATION KIT IS AVAILABLE FROM FREIGHTLINER FOR THIS PURPOSE. NO MODEL YEARS LISTED. *PE
SB-54-223
FREIGHTLINER: WIRING HARNESSES ON CERTAIN TRUCKS ARE DOCUMENTED DIFFERENTLY THAN HARNESSES ON TRUCKS. WHEN SPECIFICATION IS RELEASED FOR PRODUCTION, ALL WIRING FOR STANDARD OPTIONS ARE BUNDLED INTO HARNESSES BASED ON THEIR LOCATION IN THE TRUCKS. NO MODEL YEARS LISTED. *PE
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.