TSB54-276-FTL
Service Bulletin/Repair Instructions
Technical Service Bulletin for Load Dump Switch Inspection and Installation on Dometic Refrigerators
Vehicle report
2013 FREIGHTLINER CASCADIA
Service bulletins
766 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
ICI22-017
Service Bulletin/Repair Instructions
Important Campaign Information Letter for DDC D21M1 Termination Date Extended. This letter is to inform you that a revised bulletin for Detroit Diesel Field Service Campaign D21M1, DT12 Transmission Drive Shaft Cover Plug Reseal has been EXTENDED for an additional three months. Please use the extended termination date for all work under D21M1 from this point forward. REVISION: D21M1 termination date extended to July 1, 2022.
SB83-137
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for ParkSmart Eberspaecher Auxiliary Heater Service. This bulletin replaces the version dated May 2015. The note in General Information has been revised to include New Cascadia. Espar information has been changed to reflect a company name change to Eberspaecher.
SB88-044
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Braces for Cascadia Cab-Mounted Splash Shields. Minor note: added an update of document previously submitted. The related VMRS codes are added
P3SALESCABEND
Service Bulletin/Repair Instructions
End of Production for the Freightliner P3 Cascadia Sales Cabs. Due to low production volumes, DTNA will be discontinuing the production of the Freightliner Cascadia P3 Sales Cabs.
TechTalk566641
Service Bulletin/Repair Instructions
Tech Talk Discussion Valve Stem Seal Installer Sleeve
TechTalk566602K
Service Bulletin/Repair Instructions
Tech Talk discussion on a Valve Stem Installer Sleeve.
SS3075-FTL2021
Service Bulletin/Repair Instructions
Service Solution for FTL DT12 Trans Control Harness Chaffing - PT Can faults. Transmission will not shift into Gear while driving or will not start and trigger multiple PT CAN Fault Codes.
16TS-08REV
Service Bulletin/Repair Instructions
Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
D21M1
Service Bulletin/Repair Instructions
Detroit Field Service Campaign for DT12 Transmission Drive Shaft Cover Plug Reseal. Daimler Trucks North America LLC, on behalf of its DETROIT Powertrain Division, is initiating Field Service Campaign D21M1 on certain DT12 transmissions in order to reseal the bypass plugs of the drive shaft cover located in front housing.
WI21-009
Service Bulletin/Repair Instructions
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Service Bulletin/Repair Instructions
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
SB83-155
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Espar Service Information. This bulletin replaces the version dated January 1, 2015. New Cascadia has been added to the model list.
TechTalk12345K
Service Bulletin/Repair Instructions
Tech Talk discussion on engine fan running all the time.
TechTalk12318K
Service Bulletin/Repair Instructions
Tech Talk discussion on an engine fan running all the time.
TechTalk2414K
Service Bulletin/Repair Instructions
Tech Talk discussion on 1845_9 for 1939 TCFG2 message missing ON 2013 CASCADIA.
SB54-308
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
D21M2
Service Bulletin/Repair Instructions
DDC Field Service Campaign for GHG14 DETROIT DD13 with One-Box Aftertreatment Software Reprogramming. Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in California will require reprogramming to a minimum of the MCM software version and fuel map version listed below: MCM Software Version 4.7.0.0 ZGS 005.
WI21-001
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit New Service Replacement Engine SRT Update. While validating Standard Repair Times (SRTs) for Detroit's new Gen 5 engine series, DTNA discovered an error in a pre-Gen 5 SRT for the New Service Replacement Engine Program. As a result, DTNA re-studied the SRT and concluded that time for removing/re-installing multiple components (e.g., exhaust manifold/turbo, engine sensor harness, rocker arm assemblies, etc.) should not be included.
SB35-036
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
WP20-018R
Service Bulletin/Repair Instructions
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
WP20-018
Service Bulletin/Repair Instructions
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
20TS-09
Service Bulletin/Repair Instructions
Technical Service Letter for SPN 3711 FMI 31 on GHG17 DD15 Trucks.
18SP744
Service Bulletin/Repair Instructions
Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines Service Kit.
SB26-052
Service Bulletin/Repair Instructions
Revised Service Bulletin for DT12 PTO Upfit. This bulletin replaces the version dated 09/13/2019. DDCSN and Power Service Literature references have been removed.
TechTalk2822
Service Bulletin/Repair Instructions
Tech Talk discussion on 1845/9 for 1939 TCFG2 message missing ON 2013 CASCADIA VIN#FH8156.
SB54-278
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeterî is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
TechTalk4100
Service Bulletin/Repair Instructions
Tech Talk discussion on 2013 dd13 camshft sensor issues.
TechTalk2039
Service Bulletin/Repair Instructions
Tech Talk Discussion for DD15 GHG14 EGR linkage hex nuts.
TechTalk4725
Service Bulletin/Repair Instructions
Tech Talk discussion about power steering fluid.
TechTalk 7713
Service Bulletin/Repair Instructions
Tech Talk discussion on no power when turning key in 2013 Cascadia
TechTalk7696
Service Bulletin/Repair Instructions
Tech Talk discussion on DD15 Rear Jakes stuck on not activated.
TechTalk7679
Service Bulletin/Repair Instructions
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
D20M9
Service Bulletin/Repair Instructions
Detroit Diesel Field Service Campaign for Engine Emission Label Replacement. Certain DETROIT heavy-duty engines installed in various applications will require reprogramming and engine emission label replacement.
20CSA-15
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
SS1034761
Service Bulletin/Repair Instructions
Service Solution for P3 - CEL On and Engine de-rate due to ATD Chassis Harness Circuit 532M5+ at DEF Heater Supply location is shorted. Harness part number A66-03217-002 has been reported experiencing failures due to damages to 532M5+ circuit shorting /or corrosion in terminals at Connector (23-13053-200) harness location "ATD_CHAS_F_O_HTR_LINE_DEF_5B" .
SB26-051
Service Bulletin/Repair Instructions
Updated Service Bulletin for DT12 Transmission Cooler Retrofit. This bulletin replaces the version dated 09/18/2019. The part number for the oil control valve has been updated in the parts table.
SB42-078
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for Meritor Steer Axle Drum Brake Squeal. Some Cascadia and New Cascadia vehicles equipped with Meritor steer axle drum brakes with a front axle rating less than 13,300 lb (6038 kg) have experienced brake squealing noise when the service brakes are applied at lower speeds. NOTE: This is a nuisance noise issue and not a failure. The solution given in this service bulletin may fix this issue.
SB31-043
Service Bulletin/Repair Instructions
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change. With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
20TS-05
Service Bulletin/Repair Instructions
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility. Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
SB31-044
Service Bulletin/Repair Instructions
Service Bulletin for Reflective Tape Installation. If a truck tractor is ordered without mudflaps and/or mudflap support brackets, the rear reflective tape applied to the mudflaps or mudflap brackets during production is delivered loose with the vehicle. FMVSS/CMVSS 108 S5.7.1.4.3 requires reflective tape on all truck tractors domiciled in the United States and Canada.
SB60-171
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
SB31-041
Service Bulletin/Repair Instructions
Service Bulletin for Chassis Side-Fairing Kickplate Magnet Replacement. On Freightliner Cascadia and New Cascadia vehicles manufactured before May 20, 2019, and equipped with side-fairings, the magnets that hold the kickplate closed may corrode and prevent the kickplate from staying in the closed position.
SB60-158
Service Bulletin/Repair Instructions
Service Bulletin for Marker Light Gasket Leaks, Cascadia. This bulletin replaces the version dated June 17, 2019. A procedure has been added for inspection, repair, and replacement of damaged or spun rivet nuts.
WI20-008
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
D20M1
Service Bulletin/Repair Instructions
Updated DDC Field Service Campaign for GHG14 DETROIT DD13 with Two-Box Aftertreatment Software Reprogramming. Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in California will require reprogramming to a minimum of the MCM software version and fuel map version listed below: MCM Software Version 4.7.0.0 ZGS 005. Certain sections have been updated for clarity.
WP20-006
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers. To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
WP20-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for Chassis Progressive Damage Policy Change. Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
WP20-005
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program. DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
SB60-167
Service Bulletin/Repair Instructions
Service Bulletin for Draining Water Trapped in the Upper A-Pillar. A water leak in the seams between the cab roof and cab side wall or back wall can result in water becoming trapped in the upper A-pillar area in some Cascadia and New Cascadia vehicles. This water may migrate inside the cab and eventually spill through the marker light fastener clearance holes and drip on the dash.
WI20-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Long Block Program Change. The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
SB54-327
Service Bulletin/Repair Instructions
Service Bulletin for Lengthening the Backup Light Harness. Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
SB60-169
Service Bulletin/Repair Instructions
Service Bulletin for Replacing Windshield Gasket. Different types of cab leaks can result in water dripping from the top of the windshield, onto the dash. Replacing a windshield gasket unnecessarily may create new leak issues. Do not replace a windshield gasket unless it has been confirmed to leak, using the cab pressure test.
02.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers
CALHIGHCURRENT
Service Bulletin/Repair Instructions
Customer Advisory Letter that an inspection to determine if the high current breaker has been bypassed.
SS1034068
Service Bulletin/Repair Instructions
Service Solution for Meritor Wabco OnGuard Radar Service Alignment. If the radar sensor needs to be aligned, the radar sensor mounting system has become damaged or has loosened, or new radar sensor software has been installed, a Radar Sensor Service Alignment will need to be performed.
SS1034598
Service Bulletin/Repair Instructions
Service Solution for Legacy Cascadia, where trailer turn signals or 4-way flashers used in applications with high duty cycles, the left and right turn signals may experience shortened relay life.
SB54-239
Service Bulletin/Repair Instructions
Service Bulletin for Cascadia Cabin CAN ECU Compatibility. Compatible software levels are required for the proper operation of the vehicle.
17TS9
Service Bulletin/Repair Instructions
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found on TechLit.
19TL-18
Service Bulletin/Repair Instructions
Tool Letter for updating Cascadia and Western Star 5700 oil-to-air coolers. To be used with service bulletins SB26-051 and SB26004 respectively.
19TL-15
Service Bulletin/Repair Instructions
Tool Letter for ICC5 Programming Cable
SB47-027
Service Bulletin/Repair Instructions
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
19TL-11
Service Bulletin/Repair Instructions
Tool Letter for New Tool Kit Replacement Components DDE DKICHA018006 Components 1, 2 and 3
19TL-13
Service Bulletin/Repair Instructions
Tool Letter for DT12 Seal Protector Sleeve
D18M4
Service Bulletin/Repair Instructions
Field Service Campaign for Remanufactured Detroit DT12 Transmissions
82-018
Service Bulletin/Repair Instructions
Service Bulletin to fix wiper motor issue. On some Cascadia wiper park brush that rides against the brush plate may wear and may result in a diminished wiper park signal.
sb54299
Service Bulletin/Repair Instructions
Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer installed in production, and has been superseded by the ICU3S. When replacing an ICU3, the ICU3S must be installed in its place.
sb54312
Service Bulletin/Repair Instructions
Service Bulletin to replace the white drip shield and secondary SAM cover on the SAM Cabin, with a new one-piece drip shield.
sb82019
Service Bulletin/Repair Instructions
Service Bulletin to address wiper issue. On some Cascadia vehicles, when a request for wiper activation is made the wipers may not function. This can result from an overcurrent condition, which causes the wipers to stop functioning and immediately set fault code SPN 522215 FMI 6.
0609-19
Service Bulletin/Repair Instructions
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
18SP725Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
19-008WI
Service Bulletin/Repair Instructions
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19TS-6
Service Bulletin/Repair Instructions
The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
19-009WI
Service Bulletin/Repair Instructions
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
sb60158
Service Bulletin/Repair Instructions
Marker Light Gasket Leaks, Cascadia
DOC-1034298
Service Bulletin/Repair Instructions
Service Solution: 1034298 - New Cascadia Engine Harness Chafe at A06-95037-000 Bracket
FL807 Axle Tie R
Service Bulletin/Repair Instructions
Hendrickson 5 Inch Drop Axle Tie Rods Recall Bulletin
ICI19-025 FL807
Service Bulletin/Repair Instructions
Hendrickson 5 Inch Drop Axle Tie Rods Recall ICI letter
DOC-1034225
Service Bulletin/Repair Instructions
Accent / Park Light Function Disable Accent / Park Light Function Disable
DOC-1034231
Service Bulletin/Repair Instructions
SS 1034231 New Cascadia Fuel Gauge Not Indicating Full When Fuel Tank(s) Are Filled
DOC-1034234
Service Bulletin/Repair Instructions
SS1034234 Cascadia ICU4Me - Low Air Warning Light Not Coming On
sb72042
Service Bulletin/Repair Instructions
Installation of Vortex Generators
FL807
Service Bulletin/Repair Instructions
Hendrickson 5 Inch Drop Axle Tie Rods
ICI19-016 SF560
Service Bulletin/Repair Instructions
Revised Bulletin
PTO Pump Support
Service Bulletin/Repair Instructions
Rear PTO Pump Support CA
DOC-1034220
Service Bulletin/Repair Instructions
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
sb54311
Service Bulletin/Repair Instructions
Service Bulletin- sb54311 ICU Odometer Programming
FL782
Service Bulletin/Repair Instructions
FL782 Detroit Steer Axle Tie Rods
ICI19-009 FL799
Service Bulletin/Repair Instructions
Steer Axle Brake Chatter
ICI19-011 FL782
Service Bulletin/Repair Instructions
ICI19-011 FL782 - Revised Bulletin
sb42077
Service Bulletin/Repair Instructions
sb42077 Steer Axle Brake Chatter
sb54308
Service Bulletin/Repair Instructions
sb54308 Chassis ECU Programming
fp00024
Service Bulletin/Repair Instructions
fp00024 Cable-Tie Reference
sb60165
Service Bulletin/Repair Instructions
Service Bulletin-sb60165 Exhauster Splash Covers Do Not Fully Latch
sb83160
Service Bulletin/Repair Instructions
sb83160 HVAC Blend Door Retrofit
54302
Service Bulletin/Repair Instructions
ABS Light illuminating in the ICU.
sb00044
Service Bulletin/Repair Instructions
Reminder: Paper Service Bulletin Mailings Are Discontinued
sb2652 DT12 PTO
Service Bulletin/Repair Instructions
DT12 PTO Upfit
sb54302
Service Bulletin/Repair Instructions
Service Bulletin- ABS Light Illuminating in the ICU, ABS Solenoids Not Self Checking
DOC-1034171
Service Bulletin/Repair Instructions
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
8V491
Service Bulletin/Repair Instructions
ICUC Bulb check function.
0109-19
Service Bulletin/Repair Instructions
Service Information Bulletin- Input Shaft Pilot Bearing Measurement Specification
Detroit DT12
Service Bulletin/Repair Instructions
Detroit DT12 Split Rod Bushing Repair letter to customer
sb0039
Service Bulletin/Repair Instructions
Service Bulletin New "Natural Gas Vehicle Information" Webpage
ICI19-005 FL782
Service Bulletin/Repair Instructions
FL782 Interim Recall Ending - Final Recall Beginning
1208-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
1212-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
1213-18
Service Bulletin/Repair Instructions
Service Information Bulletin
ICI12-016 FL614
Service Bulletin/Repair Instructions
Important Campaign Information on FL614 Recall
SS469068
Service Bulletin/Repair Instructions
SS 469068 Cascadia SAM Cab, SAM Chassis, MSF and CGW Hardware Compatibility
18TS4Rev DD
Service Bulletin/Repair Instructions
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
DOC-1033628
Service Bulletin/Repair Instructions
SS 1033628 New Cascadia Ground Strategy -Steering Wheel Clockspring Failures
GHG17
Service Bulletin/Repair Instructions
Letter to customer on Coverage Extension GHG17 After Treatment
New Cascadia Cab
Service Bulletin/Repair Instructions
Field Service-New Cascadia Cab Air Shocks
DOC-1033951
Service Bulletin/Repair Instructions
SS 1033951 New Cascadia - Low Air Warning Audible Alert (Buzzer) Operation
sb9818 Repaintin
Service Bulletin/Repair Instructions
Service Bulletin 9818- Repainting Plastic Bumper Components
HDEP PLV Return
Service Bulletin/Repair Instructions
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
SS1033121
Service Bulletin/Repair Instructions
SS 1033121 Adding a Fan Override Switch (Legacy Cascadia)
FL782 Detroit St
Service Bulletin/Repair Instructions
Dealer Bulletin- FL782 Detroit Steer Axle Tie Rods
Aftertreamtent F
Service Bulletin/Repair Instructions
Service Information Bulletin for Aftertreamtent Failure Guide
DD13, DD15, DD16
Service Bulletin/Repair Instructions
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
Eaton 1800-Watt
Service Bulletin/Repair Instructions
Eaton 1800-Watt Inverter With Low Voltage communication
SPN 191 13 and 8
Service Bulletin/Repair Instructions
D12 Transmission issue communication on Cascadia
DOC-1033833
Service Bulletin/Repair Instructions
SS 1033833- Service Solution for Cascadia Parksmart 100 amp Durakool relay upgrade
0805-18 SPN 5210
Service Bulletin/Repair Instructions
Service Information Bulletin
18CSA16 Release
Service Bulletin/Repair Instructions
Release of DiagnosticLink® 8.08 Service Pack 2
TSN 32-06 Airlin
Service Bulletin/Repair Instructions
Technical Service Note: Airliner Rear Suspension Main Crossmember Fastener Replacement.
DOC-1033699
Service Bulletin/Repair Instructions
TS 1033699: DT12 Transmission Driver Interview: Shifting Complaint Questionnaire
sb3125 AirLiner
Service Bulletin/Repair Instructions
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
D18M1 GHG14 Heav
Service Bulletin/Repair Instructions
Field Service Campaign: GHG14 Heavy Duty Engine Platform Vocational Application Programming
sb60158 Marker L
Service Bulletin/Repair Instructions
Service Bulletin- Marker Light Leaks
sb0036
Service Bulletin/Repair Instructions
Operating Hours for the Customer Assistance Center
sb54301
Service Bulletin/Repair Instructions
Indel B Refrigerator Loose Circuit Board
SS1033638
Service Bulletin/Repair Instructions
SS 1033638 - Power Window Express Down Module Discontinued
0505-18
Service Bulletin/Repair Instructions
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
DOC-1033446
Service Bulletin/Repair Instructions
Vehicles with Meritor drivelines bene from a softer durometer center bearing support. Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
GHG14 18R3
Service Bulletin/Repair Instructions
GHG14_18R3_bulletin_07-MAY-2018a Emission Recall D18R3
GHG14-18R3
Service Bulletin/Repair Instructions
GHG14-18R3 bulletin-07-MAY-2018a-Emission Recall D18R3
fp00020
Service Bulletin/Repair Instructions
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
owner18R3
Service Bulletin/Repair Instructions
owner18R3 Emission Recall D18R3
sb31037
Service Bulletin/Repair Instructions
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed. The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
sb31038
Service Bulletin/Repair Instructions
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn. This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
ICI18-014
Service Bulletin/Repair Instructions
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
0405-18
Service Bulletin/Repair Instructions
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
0401-18
Service Bulletin/Repair Instructions
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
FL756
Service Bulletin/Repair Instructions
FL756 Brake Light Pressure Switches
0312-18
Service Bulletin/Repair Instructions
0312-18 Installation Output Shaft Seal
0311-18
Service Bulletin/Repair Instructions
0311-18 Installation of the Main Shaft Speed Sensor
DOC-1033334
Service Bulletin/Repair Instructions
SS 1033334 ICU3S Displays "Electrical System Problem Detected - Shutdown in Progress"
DOC-1033322
Service Bulletin/Repair Instructions
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
sb00042
Service Bulletin/Repair Instructions
sb00042 Flood Damage Repair GuidelinesB
sb2066
Service Bulletin/Repair Instructions
sb2066 Gentech Low Coolant Level Sensor
sb2074
Service Bulletin/Repair Instructions
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2077
Service Bulletin/Repair Instructions
sb2077 Tuned Mass Absorber Installation, Cascadia with 1625 sq in Radiator
sb2078
Service Bulletin/Repair Instructions
sb2078 Cascadia Radiator Strut Rod Rubbing on Upper RadiatorHose
sb2083
Service Bulletin/Repair Instructions
sb2083 FluidXchange Tool and FittingsB
sb2652
Service Bulletin/Repair Instructions
sb2652 DT12 PTO UpfitB
sb31034
Service Bulletin/Repair Instructions
sb31034 Towing ProceduresB
sb3250
Service Bulletin/Repair Instructions
sb3250 Incorrect ECAS Ride Height Sensor and Linkage InstallationB
sb3251
Service Bulletin/Repair Instructions
sb3251 Replacing or Upgrading Airliner 40K Transverse Torque RodsB
sb3329
Service Bulletin/Repair Instructions
sb3329 Caster Angle Specifications, Cascadia vs. New CascadiaB
sb4641
Service Bulletin/Repair Instructions
sb4641 Adjusting Tilt Lock Force on TRW Steering ColumnsB
sb54148
Service Bulletin/Repair Instructions
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb54296
Service Bulletin/Repair Instructions
sb54296 Fuel Level Sending Unit RetrofitB
sb60159
Service Bulletin/Repair Instructions
sb60159 Shifter Adapter Plate for Replacement Cab or Cab FloorB
sb83158
Service Bulletin/Repair Instructions
sb83158 ParkSmart Control Module Cover Modification for a New Phase HarnessB
sb98020
Service Bulletin/Repair Instructions
sb98020 Axalta Paint Finish CareB
fp31028
Service Bulletin/Repair Instructions
fp31028 Cascadia 14.5-Inch Hendrickson Aero-Clad Stainless-Steel Bumpers
fp54031
Service Bulletin/Repair Instructions
fp54031 Ordering Service Wiring Harnesses for Cascadia
fsb4269
Service Bulletin/Repair Instructions
fsb4269 Humidité excessive dans le système d'air
sb0006
Service Bulletin/Repair Instructions
sb0006 Freightliner Courtesy Engineering PolicyB
17-029
Service Bulletin/Repair Instructions
Computer Hook-Up Standard Diagnostic Time Update
17CSA25
Service Bulletin/Repair Instructions
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17TL26
Service Bulletin/Repair Instructions
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17TL27
Service Bulletin/Repair Instructions
17TL27 Injector Cup Tool DSN930E17001
17TL28
Service Bulletin/Repair Instructions
17TL28 Fuel Injector Removal Tool DSN930E17004
SB72-40
Service Bulletin/Repair Instructions
On Cascadia vehicles built from November 25, 2013, the drain holes at the bottom of the cab doors were enlarged to improve drainage during the e-coat process in the manufacturing plant. The larger holes allow more cold air to flow through the doors, most noticeably in extreme cold conditions.
17CSA24
Service Bulletin/Repair Instructions
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17-028
Service Bulletin/Repair Instructions
OWL Enhancement Service Model Field
ICI17-038
Service Bulletin/Repair Instructions
SF551 ? Revised Bulletin
17CSA23r
Service Bulletin/Repair Instructions
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
17-026
Service Bulletin/Repair Instructions
17-026 Holiday Closure 2017
17-027
Service Bulletin/Repair Instructions
Warranty Classroom Training in 2018
17TL25
Service Bulletin/Repair Instructions
17TL25 TruckCam? Alignment System
SF551
Service Bulletin/Repair Instructions
Cascadia 2020 DRM Air Tank Mounting Brackets
1112-17
Service Bulletin/Repair Instructions
Installation of the Transmission
1111-17
Service Bulletin/Repair Instructions
Removal of the Transmission
1110-17
Service Bulletin/Repair Instructions
Exhaust and Exhaust Gas Recirculation
1109-17
Service Bulletin/Repair Instructions
Power Take-Off
1108-17
Service Bulletin/Repair Instructions
Power Take-Off
1105-17
Service Bulletin/Repair Instructions
EPA10, GHG14 and GHG17 Diesel Particulate Filters
1104-17
Service Bulletin/Repair Instructions
SPN 520960 (TCM)
1102-17
Service Bulletin/Repair Instructions
SPN 157 (MCM) (GHG17)
14CSA23
Service Bulletin/Repair Instructions
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
17TS17Rev
Service Bulletin/Repair Instructions
Instructions for CSC Diagnostic Support
SS1023069
Service Bulletin/Repair Instructions
Cascadia - Engine Will Not Crank (No Starter Output from SAM Cab)
17-023
Service Bulletin/Repair Instructions
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
sb54300
Service Bulletin/Repair Instructions
ICU4Me Low Air Pressure Warning Change
0904-17
Service Bulletin/Repair Instructions
Aftertreatment Systems - Diesel Exhaust Fluid Pump Module and Components
0903-17
Service Bulletin/Repair Instructions
Engine Manufacturer Diagnostics
FL721A-E
Service Bulletin/Repair Instructions
FL721 CNG Fuel Tank and CPDM Mounting Location
ICI17-018
Service Bulletin/Repair Instructions
FL721 Fifth Revised Bulletin
SS3704
Service Bulletin/Repair Instructions
Cascadia Fault codes 6.0
SS1032974
Service Bulletin/Repair Instructions
SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
SS3672
Service Bulletin/Repair Instructions
SAM Cab & SAM Chassis Wall Charts
sb0002
Service Bulletin/Repair Instructions
Technical Publications Ordering
0609-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0608-17
Service Bulletin/Repair Instructions
Diagnostic tests - Two Filter System - FSIC Leak Test
0607-17
Service Bulletin/Repair Instructions
SPN 96 (MCM) (GHG17)
0606-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0604-17
Service Bulletin/Repair Instructions
SPN 712 (CPC) (GHG17)
0603-17
Service Bulletin/Repair Instructions
Fuel System Integrity Check Routine - Two-Filter Fuel System
0602-17
Service Bulletin/Repair Instructions
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
0601-17
Service Bulletin/Repair Instructions
SPN 3464 (MCM) (GHG14)
SS1033094
Service Bulletin/Repair Instructions
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
17TL7Rev
Service Bulletin/Repair Instructions
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
17TS11
Service Bulletin/Repair Instructions
Detroit? DT12? Transmission Proper Moving Procedure
0412-17
Service Bulletin/Repair Instructions
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
FL721
Service Bulletin/Repair Instructions
CNG Fuel Tank and CPDM Mounting Location
ICI17-009
Service Bulletin/Repair Instructions
FL721 Second Revised Bulletin
17-012
Service Bulletin/Repair Instructions
Cascadia Windshield Improvements
17TS10
Service Bulletin/Repair Instructions
Detroit? DT12? Split Rod Bushing Repair
0409-17
Service Bulletin/Repair Instructions
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0408-17 SPN 5242
Service Bulletin/Repair Instructions
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
0406-17
Service Bulletin/Repair Instructions
SPN 521221 (TCM)
0405-17
Service Bulletin/Repair Instructions
SPN 521222 (TCM)
0401-17
Service Bulletin/Repair Instructions
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
SS1033047
Service Bulletin/Repair Instructions
Service Solution SS 1033047 M2 Battery Drain Problem â Mismatched I...
0315-17
Service Bulletin/Repair Instructions
GHG14 - Intake Manifold Pressure Too Low
0314-17
Service Bulletin/Repair Instructions
GHG14 Intake Manifold Pressure Too Low
TS1033014
Service Bulletin/Repair Instructions
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines. Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
0303-17
Service Bulletin/Repair Instructions
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17
Service Bulletin/Repair Instructions
0301-17 Contaminated Fluids
ICI17-002
Service Bulletin/Repair Instructions
FL721 Interim Recall Ending ? Final Recall to Begin
0202-17
Service Bulletin/Repair Instructions
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
0137-17
Service Bulletin/Repair Instructions
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0141-17
Service Bulletin/Repair Instructions
0141-17 SPN 2659 (MCM) (EPA10)
0130-17
Service Bulletin/Repair Instructions
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0127-17
Service Bulletin/Repair Instructions
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0120-17
Service Bulletin/Repair Instructions
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17
Service Bulletin/Repair Instructions
0118-17 Symptom Diagnostics - Oil Leaks
0115-17
Service Bulletin/Repair Instructions
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
SS469076
Service Bulletin/Repair Instructions
Odometer racks up mileage when the vehicle is stationary - Cascadia
1213-16
Service Bulletin/Repair Instructions
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
1207-16
Service Bulletin/Repair Instructions
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
16TS24
Service Bulletin/Repair Instructions
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
18SP714
Service Bulletin/Repair Instructions
18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
18SP719
Service Bulletin/Repair Instructions
18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
16TL20
Service Bulletin/Repair Instructions
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
1021-16
Service Bulletin/Repair Instructions
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1020-16
Service Bulletin/Repair Instructions
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
1018-16
Service Bulletin/Repair Instructions
1018-16 SYMPTOM DIAGNOSTICS - NOISE
1017-16
Service Bulletin/Repair Instructions
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL17
Service Bulletin/Repair Instructions
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
18SP713REV 18SP7
Service Bulletin/Repair Instructions
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP720REV 18SP7
Service Bulletin/Repair Instructions
18SP720REV 18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
SB0006
Service Bulletin/Repair Instructions
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
SB54291
Service Bulletin/Repair Instructions
SB54291 DETROIT ASSURANCE LANE DEPARTURE WARNING CAMERA INSTALLATION
SB54297
Service Bulletin/Repair Instructions
SB54297 LOOSE IGNITION SWITCH ON CASCADIA VEHICLES
16 TS-18
Service Bulletin/Repair Instructions
16TS18 EPA10 AND LATER DD AUTO-ELEVATE FEATURE
09 09-16
Service Bulletin/Repair Instructions
0909-16 EXCESSIVE OIL CONSUMPTION
09 06-16
Service Bulletin/Repair Instructions
0906-16 LOW PRESSURE FUEL PUMP
09 02-16
Service Bulletin/Repair Instructions
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
08 10-16
Service Bulletin/Repair Instructions
0810-16 SYMPTOM DIAGNOSTIC NOISE
08 09-16
Service Bulletin/Repair Instructions
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
16 TS-14
Service Bulletin/Repair Instructions
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
06 12-16
Service Bulletin/Repair Instructions
0612-16 SPN 175 (MCM) (GHG17) AND SPN 175 (MCM); ( EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 11-16
Service Bulletin/Repair Instructions
0611-16 SPN 110 (MCM) (GHG17) AND SPN 110 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 10-16
Service Bulletin/Repair Instructions
0610-16 SPN 111 (CPC) (GHG17) AND SPN 111 (CPC); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 09-16
Service Bulletin/Repair Instructions
0609-16 SPN 174 (MCM) (GHG17), SPN 174 (MCM) (EPA07), SPN 174; (MCM) (EPA10), AND SPN 174 DIAGNOSTIC PROCEDURE
06 05-16
Service Bulletin/Repair Instructions
0605-16 SPN 625 (CPC)(GHG17) AND SPN 625 (CPC) (EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 01-16
Service Bulletin/Repair Instructions
0601-16 SPN 103 (MCM) (GHG17) AND SPN 103 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
54-264
Service Bulletin/Repair Instructions
CASCADIA VIRTUAL TECHNICIAN RETROFIT
60-158
Service Bulletin/Repair Instructions
MARKER LIGHT LEAKS
0502-16
Service Bulletin/Repair Instructions
FMI 3 Engine Oil Pressure Sensor Circuit Failed High
0504-16
Service Bulletin/Repair Instructions
Inspection of the DD13 Turbocharger
0505-16
Service Bulletin/Repair Instructions
Metal in the Fuel - Three- Filter Fuel System
0507-16
Service Bulletin/Repair Instructions
FMI 5 Oil Pressure Sensor Stuck High
0510-16 SPN 2623
Service Bulletin/Repair Instructions
SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
0513-16
Service Bulletin/Repair Instructions
FMI 2, 3, 4 Remote Accelerator Pedal Supply Voltage
0514-16
Service Bulletin/Repair Instructions
Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
18SP726rev
Service Bulletin/Repair Instructions
18SP726 ? EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Fee
sb3233
Service Bulletin/Repair Instructions
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
Service Bulletin/Repair Instructions
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16TL4
Service Bulletin/Repair Instructions
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS9
Service Bulletin/Repair Instructions
16TS9 DD Platform High Pressure Fuel Lines
16TS8
Service Bulletin/Repair Instructions
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16TL5
Service Bulletin/Repair Instructions
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16-010
Service Bulletin/Repair Instructions
Warranty Recognition Program Suspension
16-011
Service Bulletin/Repair Instructions
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
Service Bulletin/Repair Instructions
16TS7 Reman Diesel Particulate Filter Serial Number
16TL3
Service Bulletin/Repair Instructions
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
16-008
Service Bulletin/Repair Instructions
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
Service Bulletin/Repair Instructions
16-009R_OWL Enhancements
16_TL-2
Service Bulletin/Repair Instructions
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
16TS6
Service Bulletin/Repair Instructions
16TS6 Variable-Speed Fan Operation on Cascadia Vehicles
0308-16
Service Bulletin/Repair Instructions
0308-16 TCM Programming Instruction
0307-16 SPN 723
Service Bulletin/Repair Instructions
0307-16 SPN 723 (MCM) March
16-007
Service Bulletin/Repair Instructions
Canadian Warranty Parts Return Address Change
16TS5
Service Bulletin/Repair Instructions
16TS5 Release of the DD Platform Bearing Failure Guide
0306-16
Service Bulletin/Repair Instructions
0306-16 TCM SPN 520970 FMI 7
0305-16
Service Bulletin/Repair Instructions
0305-16 TCM SPN 520999 FMI 7 March
0304-16 SPN 2791
Service Bulletin/Repair Instructions
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0302-16
Service Bulletin/Repair Instructions
Contaminated Fluids
0301-16 SPN 625
Service Bulletin/Repair Instructions
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
0303-16
Service Bulletin/Repair Instructions
Hydrocarbon Doser Coolant Lines
1210-14
Service Bulletin/Repair Instructions
1210-14 Cylinder Head
1207-15
Service Bulletin/Repair Instructions
1207-15 Updated procedures with adding EPA10 to the GHG14 title
1205-15
Service Bulletin/Repair Instructions
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
15TL24
Service Bulletin/Repair Instructions
15TL24 OTC 1750 Revolver Engine Stand
15TS4
Service Bulletin/Repair Instructions
15TS4_Rev2_ EPA07 DD15 Piston Kits
1202-15
Service Bulletin/Repair Instructions
1202-15 Symptom Diagnostics - ATD Checklist
15TS16
Service Bulletin/Repair Instructions
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1201-15
Service Bulletin/Repair Instructions
1201-15 Crankshaft and Bearings
18SP718
Service Bulletin/Repair Instructions
18SP718 EPA07 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP720
Service Bulletin/Repair Instructions
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP722
Service Bulletin/Repair Instructions
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
18SP725
Service Bulletin/Repair Instructions
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
AEO15M1
Service Bulletin/Repair Instructions
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
15TL20
Service Bulletin/Repair Instructions
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
15-028
Service Bulletin/Repair Instructions
_NewDetroitCoolantLineSRTs
15-028A
Service Bulletin/Repair Instructions
15-028 New Detroit Coolant Line SRTs
15-029
Service Bulletin/Repair Instructions
_Warranty Recognition Program - Coming Soon
sb4012 40-12
Service Bulletin/Repair Instructions
- Tire Pressure Monitoring System (TPMS) Display Firmware Update
sb54291 54-291
Service Bulletin/Repair Instructions
- Detroit Assurance Lane Departure Warning Camera Installation
805-15
Service Bulletin/Repair Instructions
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
803-15
Service Bulletin/Repair Instructions
803-15 Removal of the Camshaft Housing
802-15
Service Bulletin/Repair Instructions
802-15 SPN 520970 FMI 7 (TCM)
801-15
Service Bulletin/Repair Instructions
801-15 SPN 520999 FMI 7 (TCM)
FSB-54-293
Service Bulletin/Repair Instructions
FREIGHTLINER: INFORMATION PROVIDED REGARDING WATER INTRUSION AND FOREIGN DEBRIS CAN ENTER SAM CHASSIS AND ELECTRICAL COMPONENT, WHEN COVER IS NOT SHUT SECURELY AND SWINGS OPEN. MODEL CASCADIA. NO MODEL YEARS LISTED. *PE
sb54293
Service Bulletin/Repair Instructions
sb54293 SAM Chassis Water Intrusion Prevention
sb9815
Service Bulletin/Repair Instructions
sb9815 Paint Finish Standards
ICI15-008R SF499
Service Bulletin/Repair Instructions
ICI15-008R SF499 Termination Date Extended
15TS15
Service Bulletin/Repair Instructions
15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
711-15
Service Bulletin/Repair Instructions
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
15TS14 GHG14
Service Bulletin/Repair Instructions
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15
Service Bulletin/Repair Instructions
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
706-15
Service Bulletin/Repair Instructions
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
703-15
Service Bulletin/Repair Instructions
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
702-15
Service Bulletin/Repair Instructions
702-15 DD15 and DD16 Delphi © Exhaust Gas Recirculation Valve Actuator
704-15
Service Bulletin/Repair Instructions
704-15 SPN 4364 (ACM)(EPA10)
sb3531
Service Bulletin/Repair Instructions
sb3531 Differential Lubrication, Detroit Model 6 Axles
sb54239
Service Bulletin/Repair Instructions
sb54239 Cascadia Cabin CAN ECU Compatibility
sb54278
Service Bulletin/Repair Instructions
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sb54291
Service Bulletin/Repair Instructions
sb54291 Detroit Assurance Lane Departure Warning Camera
sb54292
Service Bulletin/Repair Instructions
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
sb83114
Service Bulletin/Repair Instructions
sb83114 Approved Leak Detection Methods for Air Conditioning
15-017
Service Bulletin/Repair Instructions
15-017 Detroit: Updated Fuel Injector SDTs
512-15
Service Bulletin/Repair Instructions
512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod
511-15
Service Bulletin/Repair Instructions
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
509-15
Service Bulletin/Repair Instructions
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
508-15
Service Bulletin/Repair Instructions
508-15 SPN 625 (MCM)( EPA10;GHG14)
507-15
Service Bulletin/Repair Instructions
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
506-15
Service Bulletin/Repair Instructions
506-15 Air Compressor Coolant Lines
505-15
Service Bulletin/Repair Instructions
505-15 SPN 3361 (ACM) (EPA10)
15-015
Service Bulletin/Repair Instructions
15-015 Warranty Exclusions Reminder
15-016
Service Bulletin/Repair Instructions
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
504-15
Service Bulletin/Repair Instructions
504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod
503-15
Service Bulletin/Repair Instructions
503-15 DD13 Exhaust Gas Recirculation Valve Actuator
502-15
Service Bulletin/Repair Instructions
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716
Service Bulletin/Repair Instructions
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
501-15
Service Bulletin/Repair Instructions
501-15 Engine Lifter Brackets
sb2084
Service Bulletin/Repair Instructions
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
sb4654
Service Bulletin/Repair Instructions
sb4654 Rack and Pinion Steering Gear Retrofit Guide
sb8217 82-17
Service Bulletin/Repair Instructions
sb8217 82-17 - Wiper Blade Replacement to Reduce Ice Accumulation On Passenger-Side Wiper, Cascadia Vehicles
sb83137
Service Bulletin/Repair Instructions
sb83137 ParkSmart?/Espar Auxiliary Heater Servic
15CSA10
Service Bulletin/Repair Instructions
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
Service Bulletin/Repair Instructions
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
Service Bulletin/Repair Instructions
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
Service Bulletin/Repair Instructions
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
Service Bulletin/Repair Instructions
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
406-15
Service Bulletin/Repair Instructions
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
405-15
Service Bulletin/Repair Instructions
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
404-15
Service Bulletin/Repair Instructions
404-15 SPN 4364 (ACM) (EPA10)
403-15
Service Bulletin/Repair Instructions
403-15 SPN 677 (MCM)(EPA07)
15TL6
Service Bulletin/Repair Instructions
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
402-15
Service Bulletin/Repair Instructions
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
18SP717
Service Bulletin/Repair Instructions
18SP717 DD13 EGR Actuator Replacement
401-15
Service Bulletin/Repair Instructions
401-15 Cylinder Block
FL641-DLR
Service Bulletin/Repair Instructions
FL641-DLR Freightliner Cascadia Daytime Running Lights
sb3133
Service Bulletin/Repair Instructions
sb3133 Step Clamps Are Not Reusable
15-010
Service Bulletin/Repair Instructions
15-010-DLR Transmission Cooler Line Photos
15TS9
Service Bulletin/Repair Instructions
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15
Service Bulletin/Repair Instructions
326-15 Main Shaft Speed Sensor
325-15
Service Bulletin/Repair Instructions
325-15 Symptom Diagnosis - ATD Checklist
324-15
Service Bulletin/Repair Instructions
324-15 External Component Repair
323-15
Service Bulletin/Repair Instructions
323-15 Symptom Diagnostics ? Noise
321-15
Service Bulletin/Repair Instructions
321-15 SPN 4364 (ACM) (GHG14)
320-15
Service Bulletin/Repair Instructions
320-15 SPN 4374 (ACM) (GHG14)
15-009 - Detroit
Service Bulletin/Repair Instructions
15-009_Detroit_New_SDTs
15TL5
Service Bulletin/Repair Instructions
15TL5 DAVCO Shop Pro® FXP 95
309-15
Service Bulletin/Repair Instructions
309-15 SPN 3251 (ACM)(EPA10)
308-15
Service Bulletin/Repair Instructions
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
307-15
Service Bulletin/Repair Instructions
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
306-15
Service Bulletin/Repair Instructions
306-15 SPN 3246 (ACM)(EPA10;GHG14)
305-15
Service Bulletin/Repair Instructions
305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor
15TL4
Service Bulletin/Repair Instructions
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
304-15
Service Bulletin/Repair Instructions
304-15 Diagnostic Tests
303-15
Service Bulletin/Repair Instructions
303-15 Contaminated Fluids
302-15
Service Bulletin/Repair Instructions
302-15 Crankshaft Oil Seals
FSB-54-285
Service Bulletin/Repair Instructions
FREIGHTLINER: DUE TO VIBRATION, ON HORIZONTALLY MOUNTED POWERTRAIN POWER DISTRIBUTION MODULES (PDM), THE FUSES WILL CRACK AND INSTRUCTIONS ARE PROVIDED TO HELP REDUCE VIBRATION LEVEL. *PE UPDATED 03/02/15*LJ
18SP706
Service Bulletin/Repair Instructions
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
18SP712
Service Bulletin/Repair Instructions
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713
Service Bulletin/Repair Instructions
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
301-15
Service Bulletin/Repair Instructions
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
FSC-SF 504A-C
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: EXHAUST TAILPIPE TERMINATING NEAR CNG TANK PROTECTOR RELIEF VALVE AND CONTINUAL HEATING OF EXHAUST DISCHARGE RESULTS IN CNG VENTING AND HAVING TAILPIPE EXTENSION INSTALLED, AND AWAY FROM CNG TANK PROTECTION RELIEF VALVE. MODEL 2012-14 CASCADIA.
SF504
Service Bulletin/Repair Instructions
SF504-DLR Cascadia CNG Exhaust Mitigation
sb01101
Service Bulletin/Repair Instructions
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
15TS8
Service Bulletin/Repair Instructions
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0204-15
Service Bulletin/Repair Instructions
0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment
15TS6
Service Bulletin/Repair Instructions
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
0203-15
Service Bulletin/Repair Instructions
0203-15 Oil Filter Stand Pipe
15TS5
Service Bulletin/Repair Instructions
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
0202-15
Service Bulletin/Repair Instructions
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
60-156
Service Bulletin/Repair Instructions
60-156 - FE13 Roof Fairing Brace Cracking, Cascadia Daycab
83-144
Service Bulletin/Repair Instructions
83-144 - Optimized Idle and Auxiliary Cab Heater Concurrent Operation
FL671
Service Bulletin/Repair Instructions
FL671-DLR Exhaust Discharge Location
15TS2
Service Bulletin/Repair Instructions
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1
Service Bulletin/Repair Instructions
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder Misfire At Idle
ICI15-002
Service Bulletin/Repair Instructions
ICI15-002-DLR SF503 Revised Bulletin
0108-15
Service Bulletin/Repair Instructions
0108-15 SPN 1323 through 1328 (MCM) (GHG14)
0107-15
Service Bulletin/Repair Instructions
0107-15 Enhanced Steam Clean
0106-15
Service Bulletin/Repair Instructions
0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
0105-15
Service Bulletin/Repair Instructions
0105-15 SPN 102 (MCM) (GHG14)
0104-15
Service Bulletin/Repair Instructions
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
102-15
Service Bulletin/Repair Instructions
102-15 High Pressure Fuel Pump - Two-Filter System
0101-15
Service Bulletin/Repair Instructions
0101-15 SPN 4364 (ACM) (EPA10)
18SP687
Service Bulletin/Repair Instructions
18SP687 DD15 16 EGR Actuator Replacement
FSC-503-A
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: RADIATOR RESONANCE RESULTS IN TUBE FRACTURES COOLING AND LEAKAGES AND OCCURS IN TRUCKS CONFIGURATIONS AT CERTAIN OPERATIONAL SPEEDS. *PE
SF503
Service Bulletin/Repair Instructions
SF503-DLR Cascadia 1625 Radiator Tuned Mass Absorbers
sb60156
Service Bulletin/Repair Instructions
sb60156 FE13 Roof Fairing Brace Cracking, Cascadia Daycab
sb83155
Service Bulletin/Repair Instructions
sb83155 Espar Service Information
1110-14
Service Bulletin/Repair Instructions
1110-14 EPA10 DOC Inlet Pressure Sensor
1108-14
Service Bulletin/Repair Instructions
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
1105-14
Service Bulletin/Repair Instructions
1105-14 Flywheel, Ring Gear and Flywheel Housing
1104-14
Service Bulletin/Repair Instructions
1104-14 Metal in the Fuel System
1102-14
Service Bulletin/Repair Instructions
1102-14 DD13 Cylinder Head R&R
1101-14
Service Bulletin/Repair Instructions
1101-14 DD15 and DD16 Cylinder Head
18SP707
Service Bulletin/Repair Instructions
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
18SP708
Service Bulletin/Repair Instructions
18SP708Rev EPA07 10 Three-Filter Fuel
18SP711
Service Bulletin/Repair Instructions
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
SF501
Service Bulletin/Repair Instructions
SF501-DLR Perpendicular Steel Air Tank Mounting Brackets
sb4271
Service Bulletin/Repair Instructions
sb4271 Rear Axle S-Cam Support Bracket Replacement
sb54288
Service Bulletin/Repair Instructions
sb54288 Aftertreatment Harness Modification
14TL8
Service Bulletin/Repair Instructions
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS19
Service Bulletin/Repair Instructions
14TS19Rev DD Platform High Pressure Fuel Lines
14-036
Service Bulletin/Repair Instructions
14-036-DLR DTNA & JAD Highlights - Q3
14-038
Service Bulletin/Repair Instructions
14-038 Additional Detroit Standard Repair Times
14-038A
Service Bulletin/Repair Instructions
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
Service Bulletin/Repair Instructions
14-039 New Detroit Standard Diagnostic Times
14-039A
Service Bulletin/Repair Instructions
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
Service Bulletin/Repair Instructions
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
Service Bulletin/Repair Instructions
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
Service Bulletin/Repair Instructions
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
Service Bulletin/Repair Instructions
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
Service Bulletin/Repair Instructions
14TL9 Special Tool Warranty Program.
14TL7
Service Bulletin/Repair Instructions
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
Service Bulletin/Repair Instructions
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-035
Service Bulletin/Repair Instructions
14-035 Detroit Standard Repair Time Updates for Cascadia Truck Models
14-035A
Service Bulletin/Repair Instructions
14-035_SRT_Update_for_Cascadia Detroit Standard Repair Time Updates for Cascadia Truck Models
1010-14
Service Bulletin/Repair Instructions
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
Service Bulletin/Repair Instructions
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
Service Bulletin/Repair Instructions
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
Service Bulletin/Repair Instructions
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
14TS28
Service Bulletin/Repair Instructions
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1007-14
Service Bulletin/Repair Instructions
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
Service Bulletin/Repair Instructions
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
Service Bulletin/Repair Instructions
1005-14 Oil Coolant Module
1003-14
Service Bulletin/Repair Instructions
1003-14 Rough Running or Stalling.
18SP684REV4
Service Bulletin/Repair Instructions
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
Service Bulletin/Repair Instructions
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
Service Bulletin/Repair Instructions
sb2080 Australian CST M1400 Isolated Radiator Retrofit
sb54287
Service Bulletin/Repair Instructions
sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
sb60155
Service Bulletin/Repair Instructions
sb60155 Water Leak at the Top of a Cab Door, Cascadia Day Cab
sbw5460
Service Bulletin/Repair Instructions
sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
920-14
Service Bulletin/Repair Instructions
920-14 Additional Cleaning and Preparing
919-14
Service Bulletin/Repair Instructions
919-14 Exhaust Gas Recirculation Flow Target Error Diagnostic - High Flow
SF499
Service Bulletin/Repair Instructions
SF499-DLR Meritor WABCO OnGuard System
14TS26
Service Bulletin/Repair Instructions
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
918-14
Service Bulletin/Repair Instructions
918-14 Removal and Installation and Inspection of the Fuel Cooler Delete Bypass Plate - Two Filter System
917-14
Service Bulletin/Repair Instructions
917-14 Installation and Removal of the Oil Filter Stand Pipe
916-14
Service Bulletin/Repair Instructions
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
915-14
Service Bulletin/Repair Instructions
915-14 Backwards Running Engine Detecte
913-14
Service Bulletin/Repair Instructions
913-14 Checking for Poor Engine Brake Performance
14TS25
Service Bulletin/Repair Instructions
14TS25 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
912-14
Service Bulletin/Repair Instructions
912-14 Coolant in Oil
911-14
Service Bulletin/Repair Instructions
911-14 5V Sensor Supply Bank 2 Circuit Failed High
910-14
Service Bulletin/Repair Instructions
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
909-14
Service Bulletin/Repair Instructions
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
908-14
Service Bulletin/Repair Instructions
908-14 908-14 EGR Differential Pressure Failed (High Box)
907-14
Service Bulletin/Repair Instructions
907-14 Installation and Removal of the Flywheel Housing
906-14
Service Bulletin/Repair Instructions
906-14 Installation of the Oil Pan
FSC-SF-499-A-H
Service Bulletin/Repair Instructions
DAIMLER TRUCK: CERTAIN TRUCKS, UNDER ALL CONDITIONS, HAVE ONGUARD SYSTEM THAT FAILS TO PERFORM OPTIMALLY AND SPECIFIC UPDATES WILL BE MADE ON UNIT TO ENHANCE PERFORMANCE, AS NECESSARY AND WORK INSTRUCTIONS ARE PROVIDED. MODEL CASCADIA 2012-14. *PE UPDATED 2/26/15. *PE
ICI14-014
Service Bulletin/Repair Instructions
ICI14-014-DLR SF499 Revised Bulletin
905-14
Service Bulletin/Repair Instructions
905-14 Coolant Level Circuit Failed
904-14
Service Bulletin/Repair Instructions
904-14 Selective Catalyst Reduction Outlet NOx Sensor Circuit Failed High and Low
903-14
Service Bulletin/Repair Instructions
903-14 Selective Catalyst Reduction Inlet NOx Sensor Circuit Failed High and Low
18SP701
Service Bulletin/Repair Instructions
18SP701Rev3 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
32-50
Service Bulletin/Repair Instructions
32-50 - Incorrect ECAS Ride Height Sensor and Linkage Installation
35-23
Service Bulletin/Repair Instructions
35-23 - Breather Oil Leak on Freightliner Tandem Rear Axles
14TS21
Service Bulletin/Repair Instructions
14TS21 HDEP Camshaft Position Sensor Change
14-017R
Service Bulletin/Repair Instructions
14-017R Revised: Detroit Addition of Admin Time
14-029
Service Bulletin/Repair Instructions
14-029 New Detroit Standard Diagnostic Times
49-35
Service Bulletin/Repair Instructions
49-35 - DEF Return Line Fitting Heater, 6-Gallon Tanks
60-144
Service Bulletin/Repair Instructions
60-144 - New Cascadia Windshield Seal, Adhesive, and Preparation
FL662
Service Bulletin/Repair Instructions
FL662.-DLR Meritor MSF12 Non-Conforming Front Axle Beams
14TL2
Service Bulletin/Repair Instructions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
Service Bulletin/Repair Instructions
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
Service Bulletin/Repair Instructions
14-028 Remy Extended Coverage Direct File
14-027
Service Bulletin/Repair Instructions
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
Service Bulletin/Repair Instructions
14-026-DLR SelecTruck Warranty Enhancements
715-14
Service Bulletin/Repair Instructions
715-14 Symptom Diagnostics - Coolant Los
14-022
Service Bulletin/Repair Instructions
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
Service Bulletin/Repair Instructions
14-023 Detroit Axles Pre-Approval Changes
14-024
Service Bulletin/Repair Instructions
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
Service Bulletin/Repair Instructions
714-14 Symptom Diagnostics - Low Engine Compression
713-14
Service Bulletin/Repair Instructions
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
Service Bulletin/Repair Instructions
712-14 Engine Coolant Temperature
ICI-14-012
Service Bulletin/Repair Instructions
DAIMLER (FREIGHTLINER): INFORMATION CONCERNING MASTER HEADLIGHT SWITCH IN MARKER LIGHTS POSITION CAUSING DAYTIME RUNNING LIGHTS TO FAIL, AND NOT TO USE MARKER LIGHTS POSITION WHEN DRIVING. MODEL 2007-2014 CASCADIA. *PE
20-73
Service Bulletin/Repair Instructions
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75
Service Bulletin/Repair Instructions
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
54-215
Service Bulletin/Repair Instructions
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
54-218
Service Bulletin/Repair Instructions
54-218 - Adding Daytime Running Lights (DRL)Option to Business Class M2 Vehicles
54-285
Service Bulletin/Repair Instructions
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
FAB158
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB158 Cummins Eaton SmartAdvantage
524-14
Service Bulletin/Repair Instructions
524-14 FMI 0: Engine Speed High
522-14
Service Bulletin/Repair Instructions
522-14 Removal and Installation of the Oil Pump Cover
14TS13
Service Bulletin/Repair Instructions
14TS13Rev EPA10/GHG14 Diesel Exhaust Fluid (DEF) in Fuel System/Diesel Fuel in DEF System Contamination
519-14
Service Bulletin/Repair Instructions
519-14 FMI 1: SCR NOx Conversion Efficiency Very Low
518-14
Service Bulletin/Repair Instructions
518-14 FMI 1, 18: Regen Temperature- Out Of Range Low
516-14
Service Bulletin/Repair Instructions
516-14 FMI 3, 4: DEF pressure sensor circuit failed hig
513-14
Service Bulletin/Repair Instructions
513-14 FMI 0: Diesel Particulate Filter Outlet Temperature - Very High
507-14
Service Bulletin/Repair Instructions
507-14 Inspection of the DD15 and DD16 Axial Power Turbine
506-14
Service Bulletin/Repair Instructions
506-14 506-14 Removal and Installation and Inspection of the Exhaust Gas Recirculation Valve Actuator Pull Rod
505-14
Service Bulletin/Repair Instructions
505-14 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
504-14
Service Bulletin/Repair Instructions
504-14 Test-E - Three-Filter Fuel System
503-14
Service Bulletin/Repair Instructions
503-14 FMI 3, 4: High Side Digital Output 3 Circuit Failed High
502-14
Service Bulletin/Repair Instructions
502-14 FMI 4 SCR Inlet Temperature High
18SP684
Service Bulletin/Repair Instructions
18SP684Rev3 EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
sb5421
Service Bulletin/Repair Instructions
sb54215 54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
495
Service Bulletin/Repair Instructions
ELECTRONICALLY CONTROLLED AIR SUSPENSION IS BEING REPLACED. *LJ UPDATED 6/26/14. *PE UPDATED 7/3/14. *PE
TT-7400-EN
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: ON BEHALF OF WESTERN STAR AND FREIGHTLINER TRUCKS, A REPROGRAMMING WILL BE PERFORMED FOR ACCELERATION CONTROL (VAC), ON SOME TRUCKS, BY ALLISON TRANSMISSION DISTRIBUTORS. *PE
14TS5
Service Bulletin/Repair Instructions
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
GI-20-78
Service Bulletin/Repair Instructions
FREIGHTLINER: ON THE UPPER RADIATOR HOSE, THE RADIATOR STRUT ROD IS RUBBING AND IF EVIDENCE OF RUBBING IS PRESENT, HOSE IS REPLACED, WITH ORIGINAL PART, AND REPLACEMENT STRUT ROD INSTALLED. MODEL CASCADIA. *PE
0228-14
Service Bulletin/Repair Instructions
0228-14 Engine Oil Leaks - Oil Dye Method
14TS4
Service Bulletin/Repair Instructions
14TS4 Valve and Liner Installation Tool Issue
0226-14
Service Bulletin/Repair Instructions
0226-14 SPN 3216 FMI 3, 4 (ACM2)(EPA10)
13wo3re
Service Bulletin/Repair Instructions
13wo3rev2_final Actual Labor Hours on Detroit Claims
0224-14
Service Bulletin/Repair Instructions
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0223-14
Service Bulletin/Repair Instructions
0223-14 MCM SPN 2791 FMI 2 - GHG14
0222-14
Service Bulletin/Repair Instructions
0222-14 SPN 4334 FMI 7 (ACM) (EPA10)
0221-14
Service Bulletin/Repair Instructions
0221-14 Description and Operation of the GHG14 Airless Dosing System
0220-14
Service Bulletin/Repair Instructions
0220-14 CPC4 SPN 524279 FMI 11, 18 - GHG14
0219-14
Service Bulletin/Repair Instructions
0219-14 Metal in Fuel
0218-14
Service Bulletin/Repair Instructions
0218-14 GHG14 Diesel Exhaust Fluid Pump Module Filter
0217-14
Service Bulletin/Repair Instructions
0217-14 Installation of the Fuel Injector Cup
0216-14
Service Bulletin/Repair Instructions
0216-14 SPN 3363 FMI 1 - ACM - EPA10 - GHG14
0215-14
Service Bulletin/Repair Instructions
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0214-14
Service Bulletin/Repair Instructions
0214-14 CPC4 SPN 524276 FMI 13 - GHG14 - MCM fuelmap to GVC
0213-14
Service Bulletin/Repair Instructions
0213-14 CPC4 SPN 524278 FMI 13, 14, 15 - GHG14
212-14
Service Bulletin/Repair Instructions
212-14 CPC4 SPN 3719 FMI 0, 16 - GHG14
0211-14
Service Bulletin/Repair Instructions
0211-14 CPC4 SPN 524277 FMI 13, 14, 19 - GHG14
0210-14
Service Bulletin/Repair Instructions
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14
Service Bulletin/Repair Instructions
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0207-14
Service Bulletin/Repair Instructions
0207-14 SPN 3031 FMI 3, 4 (ACM) (EPA10 - GHG14)
0206-14
Service Bulletin/Repair Instructions
0206-14 SPN 524280 FMI 2, 3, 4, 5, 6 (CPC4) (GHG14)
0205-14
Service Bulletin/Repair Instructions
0205-14 SPN 1623 FMI 9, 13 (CPC4)(GHG14)
0204-14
Service Bulletin/Repair Instructions
0204-14 SPN 1484 FMI 9, 13 (CPC4) (GHG14)
0203-14
Service Bulletin/Repair Instructions
0203-14 SPN 65226 FMI 2, 3, 4 (CPC4)(GHG14)
0202-14
Service Bulletin/Repair Instructions
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0201-14
Service Bulletin/Repair Instructions
0201-14 SPN 1761 FMI 3, 4 (ACM2-EPA10) (ACM2.1-GHG14)
0227-14
Service Bulletin/Repair Instructions
0227-14 SPN 4335 FMI 7 - EPA10
0229-14
Service Bulletin/Repair Instructions
0229-14 Symptom Based Diagnostics - Oil Separator
0230-14
Service Bulletin/Repair Instructions
0230-14 SPN 4375 FMI 6 - EPA10
0233-14
Service Bulletin/Repair Instructions
0233-14 SPN 51 FMI 2 - All Years
0237-14
Service Bulletin/Repair Instructions
0237-14 Engine Brake Solenoid
0238-14
Service Bulletin/Repair Instructions
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
Service Bulletin/Repair Instructions
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
0240-14
Service Bulletin/Repair Instructions
0240-14 SPN 4374 FMI 0 (ACM2.1)(GHG14)
54-278
Service Bulletin/Repair Instructions
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
54-281
Service Bulletin/Repair Instructions
54-281 - Fuel Level Sender Guard Installation
FAB154
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB154 New options for Cascadia
FSB-54-278
Service Bulletin/Repair Instructions
FREIGHTLINER: TROUBLESHOOTING GUIDE INFORMATION REGARDING SOME TRUCKS WITH SEPARATE CABLE VOLTAGE DROP CHECKS, CHARGING, STARTER ISSUES, BATTERY, AND ALTERNATOR ROUTES . *PE
SF488
Service Bulletin/Repair Instructions
SF488-DLR Airliner 69K Axle Stops
FSB-20-75
Service Bulletin/Repair Instructions
FREIGHTLINER: SOME TRUCKS WERE MANUFACTURED WITH RADIATOR FAILURES RESULTING IN COOLANT LEAKAGE DUE TO CRACK IN COOLANT TUBE AND RADIATOR WILL BE UPDATED TO AN ISOLATED ENGINE MOUNTED 1400 SQ IN RADIATOR. MODEL CASCADIA. NO YEARS LISTED. *PE UPDATED 4/8/14. *PE
FSC-SF-489-A-D
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SOME TRUCKS RECEIVED THE STANDARD INSULATION, NOT PREMIUM INSULATION, ON XT OR RAISED ROOF ASSEMBLY AND WILL BE INSPECTED AND, IF STANDARD INSULATION IS FOUND, WILL BE REPLACED WITH PREMIUM INSULATION. MODEL CASCADIA. *PE
FAB153
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB153 New Harness Highway for Cascadia
FSB-83-131
Service Bulletin/Repair Instructions
FREIGHTLINER: INFORMATION REGARDING THE REPLACEMENT LINE WITH A NEW ASSEMBLY CONNECTING THE MANIFOLD WITH A HOSE AND HOSE BARB, IN THE EVENT HEATER RETURN PIPE (HT2 LINE) FAILS ON THE ENGINE. MODEL CENTURY CLASS CONVENTIONAL, COLUMBIA, CASCADIA. NO YEARS LISTED. *PE
FSB-SF-486-A
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: THE FREIGHTLINER IN CAB TRAINING SYSTEM (FIT) ANCHORS WERE NOT INSTALLED, ON CERTAIN TRUCKS, BUT WILL BE INSTALLED AT SEAT BELT TETHER BRACKET AND BUNK RESTRAINT LOCATIONS. MODEL 2013 CASCADIA. *PE
13TS30
Service Bulletin/Repair Instructions
GHG14 DD Engine EGR System Fault Codes
13TS28
Service Bulletin/Repair Instructions
GHG14 472906S Turbocharger Compressor Inlet
13TS15
Service Bulletin/Repair Instructions
13TS15Rev EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251/FMI 2 - DOC Inlet Pressure Sensor Not Plausible
13TS22
Service Bulletin/Repair Instructions
Rev DD Platform Fuel Injector Cup Seal
13TS25
Service Bulletin/Repair Instructions
Issues with PTO and Remote Throttle Combinations
13M2
Service Bulletin/Repair Instructions
13m2 -Final-23-SEP-2013 Field Service Campaign 13M2
13M2-02
Service Bulletin/Repair Instructions
13m2- Equipment Owner Field Service Campaign - 13M2
25-34
Service Bulletin/Repair Instructions
25-34 - Clutch-Related No-Start Diagnostics
33-28
Service Bulletin/Repair Instructions
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30
Service Bulletin/Repair Instructions
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
54-274
Service Bulletin/Repair Instructions
54-274 - Plastic Battery Box Cover Retainer Clip
54-277
Service Bulletin/Repair Instructions
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
54-279
Service Bulletin/Repair Instructions
54-279 - Intermittent Communication Between the TrailerTRACS Transmitter and the Qualcomm Unit
54-280
Service Bulletin/Repair Instructions
54-280 - Video Available for Servicing APEX 150 Sealed 16-Pin Connectors
FSB-25-34
Service Bulletin/Repair Instructions
FREIGHTLINER: THERE MAY BE A NO START FAULT ASSOCIATED WITH CLUTCH POSITION COMBINATION SWITCH ON MANUAL TRANSMISSION AND INVESTIGATION WILL DETERMINE CAUSE OF PROBLEM. MODEL CASCADIA. NO YEARS LISTED. *PE
FSB-35-30
Service Bulletin/Repair Instructions
FREIGHTLINER: ON RECOMMENDATION OF CONMET, REPLACEMENT OF BEARING SPACER, WITH A NEW ONE, IS REQUIRED WHEN A HUB IS REMOVED. *PE
SB-54-274
Service Bulletin/Repair Instructions
FREIGHTLINER: THE PLASTIC BATTERY BOX COVER CAN BECOME LOOSE OR LOST DUE TO AN INADEQUATE RETENTION CLIP. NO YEARS LISTED. *PE
ICI13-009
Service Bulletin/Repair Instructions
ICI13-009-DLR Campaign Claims for Detroit Axle
13TS-24
Service Bulletin/Repair Instructions
13TS-24 DD Platform High Pressure Fuel Lines
808-13
Service Bulletin/Repair Instructions
808-13 FMI 0 Under Pressurized DEF System
803-13
Service Bulletin/Repair Instructions
803-13 FMI 2: Intake Throttle Position Deviation Error
803-13 B
Service Bulletin/Repair Instructions
803-13 FMI 10,18: Intake Throttle Position Abnormal Rate of Change, Position Data Valid but Below Normal Operating Range - Moderately Severe Level
802-13
Service Bulletin/Repair Instructions
802-13 FMI 18 Coolant Level Low
18SP697
Service Bulletin/Repair Instructions
18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935
18SP698
Service Bulletin/Repair Instructions
18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932
18SP699
Service Bulletin/Repair Instructions
18SP699 EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Feed Lines PN A4710706035
18SP700
Service Bulletin/Repair Instructions
18SP700 EPA10,GHG14 Two-Filter Fuel System KM59 GEN1 DD15,16 High Pressure Fuel Feed Lines PN:A4720708032
54-275
Service Bulletin/Repair Instructions
54-275 - Chassis-Mounted Trailer PDM, Battery Power Cable Terminal Corrosion
FAB143
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB143 Load Transfer Suspension
FAB145
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB145 New Cascadia Roof Fairing
FAB146
Service Bulletin/Repair Instructions
Freightliner Action Bulletin FAB146 Cascadia LED headlights
716-13
Service Bulletin/Repair Instructions
716-13 SPN 3226-FMI 13 - EPA10 - GHG14, SPN 3216-FMI 13 ? EPA10, SPN 3216-FMI 13 - GHG14
714-13
Service Bulletin/Repair Instructions
714-13 Fuel Filter Maintenance Intervals
713-13
Service Bulletin/Repair Instructions
713-13 SPN 4334-FMI 7 - EPA10
709-13
Service Bulletin/Repair Instructions
709-13 SPN 2798-FMI 4-EPA10-GHG14
708-13
Service Bulletin/Repair Instructions
708-13 Fuel System Diagram Update
706-13
Service Bulletin/Repair Instructions
706-13 SPN 157-FMI 10, 15, 17, 18 - GHG14
SB-09-35
Service Bulletin/Repair Instructions
FREIGHTLINER: REPLACEMENT OF THE ENGINE AIR FILTER ELEMENT. IF THE AIR FILTER IS INSTALLED IMPORPERLY IT COULD CAUSE ENGINE DAMAGE OR FAILURE. *KB
SB-42-69
Service Bulletin/Repair Instructions
FREIGHTLINER: BENDIX AIR DRYERS ARE EXPERIENCING EXCESSIVE MOISTURE IN THE AIR SYSTEM. THIS COULD POSSIBLY LEAD TO TRANSMISSION SOLENOID FAILURE. *KB
sb0935
Service Bulletin/Repair Instructions
sb0935 Replacing the Engine Air Filter Element, Donaldson Air Cleaner (03-33648-001-002)
sb4269
Service Bulletin/Repair Instructions
sb4269 Excessive Moisture in the Air System
611-13
Service Bulletin/Repair Instructions
611-13 Removal and Installation of the GHG14 Six-Gallon Diesel Exhaust Fluid Tank Header
607-13
Service Bulletin/Repair Instructions
607-13 SPN 3361-FMI 7- EPA10
604-13
Service Bulletin/Repair Instructions
604-13 Performing a Parked Regeneration
603-13
Service Bulletin/Repair Instructions
603-13 SPN 84 -FMI 6 - EPA07-GHG14
FL642
Service Bulletin/Repair Instructions
FL642-DLR ICU4Me Park Brake Warning Message
SF480
Service Bulletin/Repair Instructions
SF480-DLR Qualcomm TrailerTRACS Wiring
13TS17
Service Bulletin/Repair Instructions
13TS17 EPA10-GHG14 Diesel Exhaust Fluid (DEF) in Fuel System-Diesel Fuel in DEF System Contamination
531-13
Service Bulletin/Repair Instructions
531-13 GHG14 DD15 Asymmetrical Turbocharger
532-13
Service Bulletin/Repair Instructions
532-13 Description and Operation of the Two-Stage Valve - Two-Filter Systems
530-13
Service Bulletin/Repair Instructions
530-13 Low Pressure Fuel Pump ? Two-Filter Fuel System
529-13
Service Bulletin/Repair Instructions
529-13 Operation of the Fuel System - Two-Filter Fuel System
528-13
Service Bulletin/Repair Instructions
528-13 SPN 3246-FMI 0 - EPA10 - GHG14
527-13
Service Bulletin/Repair Instructions
527-13 SPN 190-FMI 15,17 GHG14
525-13
Service Bulletin/Repair Instructions
525-13 SPN 2791-FMI 7 ? ALL YEARS
520-13
Service Bulletin/Repair Instructions
520-13 Cylinder Block
518-13
Service Bulletin/Repair Instructions
518-13 SPN 4334-FMI 4 - GHG14
ICI13-007
Service Bulletin/Repair Instructions
ICI13-007-DLR FL641 ? Interim Recall Notice
83-153
Service Bulletin/Repair Instructions
FREIGHTLINER: PARKSMART WITH DDC OPTIMIZED IDLE. DETROIT DIESEL OPTIMIZED IDLE AFFECTS THE WAY PARKSMART OPERATES. *JS
FSC-480-A
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN TRUCKS, BETWEEN THE QUALCOMM UNIT AND TRAILER TRACS TRANSMITTER, COMMUNICATION IS INTERMITTENT, DUE TO LACK OF RELIABLE SIGNAL STRENGTH AND A MORE ROBUST WIRING WILL BE INSTALLED TO CORRECT ISSUE. MODELS 2010-2013 CASCADIA. *PE
SB-3132
Service Bulletin/Repair Instructions
FREIGHTLINER: THE CHASSIS SIDE FAIRING LOWER DEFLECTOR RETENTION. THE C-CLIPS THAT ARE ATTACHED TO THE CHASSIS SIDE FARING LOWER AIR DEFLECTORS MAY BECOME LOOSE. *JS
sb3529
Service Bulletin/Repair Instructions
sb3529 Axle Alignment Specifications
sb4932
Service Bulletin/Repair Instructions
sb4932 DEF Gauge Reading Incorrectly
418-13
Service Bulletin/Repair Instructions
418-13 SPN 2791-FMI 12 - GHG14
414-13
Service Bulletin/Repair Instructions
414-13 Removal and Installation of the GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank Header Unit
413-13
Service Bulletin/Repair Instructions
413-13 GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank
407-13
Service Bulletin/Repair Instructions
407-13 EGR Actuator Slow Learn
sb54215
Service Bulletin/Repair Instructions
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
sb60144
Service Bulletin/Repair Instructions
sb60144 New Cascadia Windshield Seal, Adhesive, and Preparation
sb83145
Service Bulletin/Repair Instructions
sb83145 ParkSmart Refrigerant Loop Service Kits
13TS12
Service Bulletin/Repair Instructions
13TS12 HDEP Wastegate Solenoid Air Leaks
13TS10
Service Bulletin/Repair Instructions
13TS10 DD Platform Oil Coolant Module Plugs
311-13
Service Bulletin/Repair Instructions
311-13 SPN 651-FMI 3 - EPA10 - GHG14
310-13
Service Bulletin/Repair Instructions
310-13 Draining the Fuel System Using J-48710 Prior to Repairs
305-13
Service Bulletin/Repair Instructions
305-13 GHG14 DD15 Asymmetrical Turbocharger Flanged Exhaust Manifold
303-13
Service Bulletin/Repair Instructions
303-13 SPN 3242-FMI 4 -EPA10 - GHG14
13TS7
Service Bulletin/Repair Instructions
13TS7 GHG14 CPC4 Vehicle Speed Sensor Code SPN 84-FMI 6
13TS8
Service Bulletin/Repair Instructions
13TS8 GHG14 Throttle Codes SPN 91-FMI 7 and SPN 91-FMI 10
301-13
Service Bulletin/Repair Instructions
301-13 SPN 5018- FMI 18 -GHG14
sb3132
Service Bulletin/Repair Instructions
sb3132 Cascadia Chassis Side Fairing Lower Air Deflector Retention
13TS6
Service Bulletin/Repair Instructions
13TS6 DD Platform Engine Oil Filter.pdf
13TS5
Service Bulletin/Repair Instructions
13TS5 DD Platform Fuel Filter Module
207-13
Service Bulletin/Repair Instructions
207-13 Removal and Installation of the Camshaft Housing
13WO-2
Service Bulletin/Repair Instructions
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
18SP693
Service Bulletin/Repair Instructions
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
SF-477-AB
Service Bulletin/Repair Instructions
FREIGHTLINER: ISRINGHAUSEN SEAT SLIDE STOPS. THIS IS CAUSING THE SEAT TO RIDE UP OVER THE STOP. THIS COULD CAUSE THE SEAT TO GET STUCK IN THE AFT POSITION AND CANNOT BE ADJUSTED FORWARD. *KB
SF477
Service Bulletin/Repair Instructions
SF477-DLR Isringhausen Seat Slide Stops
132-13
Service Bulletin/Repair Instructions
132-13 SPN 3597-FMI 4 - EPA10
133-13
Service Bulletin/Repair Instructions
133-13 SPN 4375-FMI 4 and 5 - GHG14
135-13
Service Bulletin/Repair Instructions
135-13 SPN 1243-FMI 14 - GHG14
137-13
Service Bulletin/Repair Instructions
137-13 SPN 2798-FMI 4 - EPA10 - GHG14
139-13
Service Bulletin/Repair Instructions
139-13 SPN 3251-FMI 0, 16, 20, 21 GHG14
13TL2
Service Bulletin/Repair Instructions
13TL2 GHG14 Test Electronic Control Units (ECUs).
13TS2
Service Bulletin/Repair Instructions
13TS2 Single-Speed Fan Operation on Cascadia Vehicles
143-13
Service Bulletin/Repair Instructions
143-13 Low Pressure Fuel System - Measuring Fuel Pressure Using Fuel System Integrity Check, Two-Filter Fuel System
144-13
Service Bulletin/Repair Instructions
144-13 Removal and Installation of the GHG14 Diesel Exhaust Fluid Lines
145-13
Service Bulletin/Repair Instructions
145-13 Description and Operation of Gear Train and Related Parts
146-13
Service Bulletin/Repair Instructions
146-13 SPN 4335-FMI 1 EPA10
148-13
Service Bulletin/Repair Instructions
148-13 GHG14 DD15 Asymmetrical Turbocharger Exhaust Manifold
129-13
Service Bulletin/Repair Instructions
129-13 DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE
128-13
Service Bulletin/Repair Instructions
128-13 SPN 511403-FMI 0,1,2,3,4,5,6,8,9,10,11,12,13,14
126-13
Service Bulletin/Repair Instructions
126-13 Description and Operation of the DD15 and DD16 Exhaust Gas Recirculaton Cooler
124-13
Service Bulletin/Repair Instructions
124-13 Installation of the DD Platform EGR Actuator Pull Rod
119-13
Service Bulletin/Repair Instructions
119-13 Exhaust Gas Recirculation System - Cleaning
112-13
Service Bulletin/Repair Instructions
112-13 SPN 4364-FMI 18 - GHG14
111-13
Service Bulletin/Repair Instructions
111-13 SPN 4374/FMI 0, 1, 3, 4 - GHG14
110-13
Service Bulletin/Repair Instructions
110-13 SPN 5435-FMI 7 - GHG14
109-13
Service Bulletin/Repair Instructions
109-13 SPN 3250-FMI 31 (ACM2.1) GHG14
108-13
Service Bulletin/Repair Instructions
108-13 SPN 3364-FMI 18 - GHG14
107-13
Service Bulletin/Repair Instructions
107-13 SPN 84-FMI 7 - GHG14
106-13
Service Bulletin/Repair Instructions
106-13 SPN 100-FMI 10 - GHG14
105-13
Service Bulletin/Repair Instructions
105-13 SPN 625-FMI 13 - GHG14
104-13
Service Bulletin/Repair Instructions
104-13 SPN 1592-FMI 13 and 19 - GHG14
103-13
Service Bulletin/Repair Instructions
103-13 SPN 520328-FMI 7 - GHG14
102-13
Service Bulletin/Repair Instructions
102-13 SPN 84-FMI 13, 19, 21 (MCM) EPA10-GHG14
101-13
Service Bulletin/Repair Instructions
101-13 SPN 3563 FMI 21 - GHG14
sb0934
Service Bulletin/Repair Instructions
sb0934 EPA10 Cummins ISX Air Intake Heat Shield Removal
sb8844
Service Bulletin/Repair Instructions
sb8844 Braces for Cascadia Cab-Mounted Splash Shields
12-039
Service Bulletin/Repair Instructions
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
Service Bulletin/Repair Instructions
12-040-DLR Roof Fairing Removal Program
12-041
Service Bulletin/Repair Instructions
12-041-DLR Over the Counter No Hassle Warranty (OTC)
ICI12-028
Service Bulletin/Repair Instructions
ICI12-028-DLR FL632 - Interim Notice
12-038
Service Bulletin/Repair Instructions
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
SB-83150
Service Bulletin/Repair Instructions
FREIGHTLINER: PARKSMART, SPLIT UNIT, CONTROLLER AND HARNESS CHANGES. A DESIGN CHANGE HAS BEEN MADE TO THE PARKSMART INTERNAL CONTROLLER CIRCUIT BOARD TO PROTECT AGAINST HIGH VOLTAGE DAMAGE. *JS
SB42-68
Service Bulletin/Repair Instructions
FREIGHTLINER: BRAKE S-CAM TUBE LUBRICATION INTERVAL CHANGE. TO ENSURE OPTIMUM SERVICE LIFE AND TROUBLE-FREE OPERATION, THE RECOMMENDED MAINTENANCE INTERVAL FOR LUBRICATING MERITOR S-CAM BRAKE TUBES ON CENTURY CLASS, COLUMBIA, CASCADIA AND CORONADO OVER-THE-ROAD VEHICLES IS CHANGED FROM M2 TO THE M1 MAINTENANCE INTERVAL. *JS
sb2073
Service Bulletin/Repair Instructions
sb2073 Cascadia Radiator Update - EPA10
sb2534
Service Bulletin/Repair Instructions
sb2534 Clutch-Related No-Start Diagnostics
sb4268
Service Bulletin/Repair Instructions
sb4268 Brake S-Cam Tube Lubrication Interval Change
sb4724
Service Bulletin/Repair Instructions
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
sb83150
Service Bulletin/Repair Instructions
sb83150 ParkSmart, Split Unit, Controller and Harness Changes
ICI12-026
Service Bulletin/Repair Instructions
ICI12-026-DLR SF471 - Second Revised Bulletin
1118-12
Service Bulletin/Repair Instructions
1118-12 SPN 705-FMI 5 - GHG14
ICI12-025
Service Bulletin/Repair Instructions
ICI12-025-DLR SF471 - Revised Bulletin
1113-12
Service Bulletin/Repair Instructions
1113-12 SPN 3226/FMI 20 - GHG14
1112-12
Service Bulletin/Repair Instructions
1112-12 Test C -Two-Filter Fuel System
1102-12
Service Bulletin/Repair Instructions
1102-12 Test A - Two-Filter Fuel System
1101-12
Service Bulletin/Repair Instructions
1101-12 Test B -Two-Filter Fuel System
SF471
Service Bulletin/Repair Instructions
SF471-DLR Detroit Axles Driver-Controlled Differential Locks
sb3131
Service Bulletin/Repair Instructions
sb3131 Huck-Spin 2 Changeover
sb54271
Service Bulletin/Repair Instructions
sb54271 Early Failure of 8A31 AGM Primary Batteries
914-12
Service Bulletin/Repair Instructions
914-12 GHG14 Two-Box Diesel Oxidation Catalyst.pdf
903-12
Service Bulletin/Repair Instructions
903-12 Installation of the Intake Throttle Valve and Adaptor.pdf
sb83149
Service Bulletin/Repair Instructions
sb83149 ParkSmart Interconnect Controller Logic Loss
830-12
Service Bulletin/Repair Instructions
830-12 SPN 520326-FMI 4 - GHG14
12CSA19
Service Bulletin/Repair Instructions
12CSA19 GHG14 Rapid Warranty Parts Return.
818-12
Service Bulletin/Repair Instructions
818-12 SPN 520296-FMI 19 and 31 - GHG14
815-12
Service Bulletin/Repair Instructions
815-12 Installation of the Oil Cooler
12CSA18
Service Bulletin/Repair Instructions
12CSA18 Update to Fix Internet Explorer - A Script on this Page is causing Internet Explorer to Run Slowly Issue
811-12
Service Bulletin/Repair Instructions
811-12 SPN 411-FMI 3
810-12
Service Bulletin/Repair Instructions
810-12 SPN 3842-FMI 3, 4, and 5 (CPC4)
809-12
Service Bulletin/Repair Instructions
809-12 Removal and Installation of the GHG14 1-BOX From the Vehicle
12TS14
Service Bulletin/Repair Instructions
12TS14 Repair Facility Input on GHG14 Engine and Aftertreatment System Issues
807-12
Service Bulletin/Repair Instructions
807-12 Removal and Installation of the GHG14 Diesel Exhaust Fluid Dosing Unit Inlet Screen
805-12
Service Bulletin/Repair Instructions
805-12 SPN 4354-FMI 5, 4356-FMI 5, 4355-FMI 5, 4357-FMI 5
804-12
Service Bulletin/Repair Instructions
804-12 SPNs 4354-FMI 5, 4355-FMI 5, 4356-FMI 5, 4357-FMI 5
803-12
Service Bulletin/Repair Instructions
803-12 SPN 4360-FMI 10, 15 (ACM2.1)
802-12
Service Bulletin/Repair Instructions
802-12 SPN 520328-FMI 7 - GHG14
12-022
Service Bulletin/Repair Instructions
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
12C3
Service Bulletin/Repair Instructions
12C3 - Instructions-DocTrac -Final
12C3bul
Service Bulletin/Repair Instructions
12C3bul-DocTrac - Final
801-12
Service Bulletin/Repair Instructions
801-12 SPN 1761-FMI 9 - GHG14
842-12
Service Bulletin/Repair Instructions
842-12 SPN 3864-FMI 3 and 4 - GHG14
843-12
Service Bulletin/Repair Instructions
843-12 SPN 3866-FMI 3 and 4
844-12
Service Bulletin/Repair Instructions
844-12 SPN 3867-FMI 3 and 4
845-12
Service Bulletin/Repair Instructions
845-12 SPN 3868-FMI 3 and 4
846-12
Service Bulletin/Repair Instructions
846-12 SPN 3869-FMI 3 and 4
847-12
Service Bulletin/Repair Instructions
847-12 SPN 3870-FMI 3 and 4
848-12
Service Bulletin/Repair Instructions
848-12 SPN 3872-FMI 3 and 4
849-12
Service Bulletin/Repair Instructions
849-12 SPN 3873-FMI 3 and 4
aeo12C3
Service Bulletin/Repair Instructions
aeo12C3-DocTrac -Final
sb3130
Service Bulletin/Repair Instructions
sb3130 Quarter Fender Reinforcement
sb4267
Service Bulletin/Repair Instructions
sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
FSB-42-67
Service Bulletin/Repair Instructions
FREIGHTLINER: ON SOME TRUCKS, WHENEVER BRAKES ARE APPLIED, THE TRUCK WOULD EXPERIENCE SEVERE SHIMMY OR SHAKING. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, ARGOSY COE, COLUMBIA, CORONADO, BUSINESS CLASS M2, CASCADIA, 108SD/114SD. NO MODEL YEARS LISTED. *PE UPDATED 11/1/12. *PE
FSB-46-53
Service Bulletin/Repair Instructions
FREIGHTLINER: THERE ARE INCONSISTENCIES RELATING TO THE STEERING RACK AND PINION GEARS, PITTING CAUSED BY CORROSION, POWER STEERING FLUID LEAKAGE, AND INNER TIE ROD LOOSENESS LEADING TO POOR GEAR PERFORMANCE, LEADING TO INSPECTION PROCEDURES. *PE
FSB-54-271
Service Bulletin/Repair Instructions
FREIGHTLINER: BATTERY BOXES, 8A31 AGM, IN SLEEPER CABS, ARE FAILING TO START WITH LOSS OF ELECTROLYTE ACCELERATING, DUE TO HIGH TEMPERATURES UNDER CAB. NO MODEL YEARS LISTED. *PE
FSB-49-33
Service Bulletin/Repair Instructions
FREIGHTLINER: EXCESSIVE WHITE CRYSTAL OR POWDER AROUND DEF FITTING, CAUSED BY EVAPORATION OF DEF WHEN EXPOSED TO AIR AND/OR DAMPNESS, INDICATES A LEAK IN DIESEL EXHAUST FLUID OR IMPROPER INSTALLATION OR DAMAGED CONNECTORS WOULD HAVE LEAKS IN COOLANT LINES. *PE
FSB-54-231
Service Bulletin/Repair Instructions
FREIGHTLINER: INFORMATION PROVIDED FOR REPLACEMENT HARDWARE PARTS FOR A SAM CHASSIS OR A SAM CAB. *PE
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.