SB83-122
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Bergstrom NITE Parked HVAC Performance Issues. Minor note: added an update of document previously submitted. The related VMRS codes are added
Vehicle report
2007 FREIGHTLINER CENTURY CLASS
Service bulletins
222 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
WI21-008
Service Bulletin/Repair Instructions
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
04TS-43REV4
Service Bulletin/Repair Instructions
Revised Technical Service Letter for Series 60 and Series 50 Camshaft Timing Specifications. Camshaft timing, valve lash, injector height, and Jake Brake lash are all very important specifications that must be followed closely in order to optimize the performance and service life of any Detroit Diesel engine.
SB35-036
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
SB54-278
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeterî is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
20TS-01
Service Bulletin/Repair Instructions
Technical Service Letter for DDC Series 60 engines concerning Series 60 Cylinder Head Resurfacing/Finish. Detroit Diesel does not recommend third party resurfacing of Series 60 cylinder heads (outside of Detroit and Detroit Reman).
0609-19
Service Bulletin/Repair Instructions
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
19-008WI
Service Bulletin/Repair Instructions
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19-009WI
Service Bulletin/Repair Instructions
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
fp46907
Service Bulletin/Repair Instructions
Steering Intermediate Shaft Replacement
fp00024
Service Bulletin/Repair Instructions
fp00024 Cable-Tie Reference
sb9810 Chassis P
Service Bulletin/Repair Instructions
Service Bulletin 9810- Chassis Paint Usage
sb9812 Cab Surfa
Service Bulletin/Repair Instructions
Service Bulletin 9812- Cab Surface Repair
sb9816 DuPont Im
Service Bulletin/Repair Instructions
Service Bulletin 9816- DuPont? Imron® Elite
sb9817 Paint Sup
Service Bulletin/Repair Instructions
Service Bulletin 9817- Paint Supplier Change
sb9818 Repaintin
Service Bulletin/Repair Instructions
Service Bulletin 9818- Repainting Plastic Bumper Components
sb0036
Service Bulletin/Repair Instructions
Operating Hours for the Customer Assistance Center
SS1033638
Service Bulletin/Repair Instructions
SS 1033638 - Power Window Express Down Module Discontinued
fp00020
Service Bulletin/Repair Instructions
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
sb2028
Service Bulletin/Repair Instructions
sb2028 Engine Coolant Changes
sb2031
Service Bulletin/Repair Instructions
sb2031 Horton Fan Clutches with 32-Inch Fans
sb2032
Service Bulletin/Repair Instructions
sb2032 Gates PowerGrip Hose Clamps, Replacement
sb2045
Service Bulletin/Repair Instructions
sb2045 New Surge Tank Cap
sb2049
Service Bulletin/Repair Instructions
sb2049 Fan Shroud Modification
sb2050
Service Bulletin/Repair Instructions
sb2050 Surge-Tank Cap Replacement
sb2052
Service Bulletin/Repair Instructions
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
sb2053
Service Bulletin/Repair Instructions
sb2053 New Stainless Steel Lower Radiator Tubes
sb2056
Service Bulletin/Repair Instructions
sb2056 Transmission Oil Line Removal and Installation
sb2057
Service Bulletin/Repair Instructions
sb2057 New Surge Tank Design
sb2058
Service Bulletin/Repair Instructions
sb2058 Early EPA07 QLD Radiator Replacement
sb2059
Service Bulletin/Repair Instructions
sb2059 Replacing Push-to-Connect Air Line Fittings with Brass Compression Fittings
sb2063
Service Bulletin/Repair Instructions
sb2063 Coolant Filter Inspection Procedure, DD13 DD15 DD16 Only
sb2068
Service Bulletin/Repair Instructions
sb2068 Conventional Fully-Formulated Coolant with SCA Color Change
sb2069
Service Bulletin/Repair Instructions
sb2069 Kysor Fan Clutch Sticking
sb31034
Service Bulletin/Repair Instructions
sb31034 Towing ProceduresB
sb4267
Service Bulletin/Repair Instructions
sb4267 Brake Shimmy?Meritor® SteeLite X30? Brake Drum with Excessive RunoutB
sb54105
Service Bulletin/Repair Instructions
sb54105 Fresh Air Warning Buzzer Disable
sb54109
Service Bulletin/Repair Instructions
sb54109 RAMI Antenna
sb54122
Service Bulletin/Repair Instructions
sb54122 ICU3 Service Cluster AvailableB
sb54148
Service Bulletin/Repair Instructions
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb54194
Service Bulletin/Repair Instructions
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54202
Service Bulletin/Repair Instructions
sb54202 Rerouting the DDEC IV Relative-Humidity-Sensor Harness
sb54296
Service Bulletin/Repair Instructions
sb54296 Fuel Level Sending Unit RetrofitB
sb5471
Service Bulletin/Repair Instructions
sb5471 Vehicle Speed Sensor Optimized Idle FeatureB
sb6083
Service Bulletin/Repair Instructions
sb6083 Roof Seam Seal Repair
sb98020
Service Bulletin/Repair Instructions
sb98020 Axalta Paint Finish CareB
ssb3312
Service Bulletin/Repair Instructions
ssb3312 Tapacubos flojos en ejes Rockwell® FF?981
fp47019
Service Bulletin/Repair Instructions
fp47019 25-Inch Diameter Fuel Tanks
17-029
Service Bulletin/Repair Instructions
Computer Hook-Up Standard Diagnostic Time Update
17CSA25
Service Bulletin/Repair Instructions
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24
Service Bulletin/Repair Instructions
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17-028
Service Bulletin/Repair Instructions
OWL Enhancement Service Model Field
17CSA23r
Service Bulletin/Repair Instructions
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
17-026
Service Bulletin/Repair Instructions
17-026 Holiday Closure 2017
17-027
Service Bulletin/Repair Instructions
Warranty Classroom Training in 2018
17TL25
Service Bulletin/Repair Instructions
17TL25 TruckCam? Alignment System
14CSA23
Service Bulletin/Repair Instructions
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
sb4641
Service Bulletin/Repair Instructions
Adjusting Tilt Lock Force on TRW Steering Columns
SS1032974
Service Bulletin/Repair Instructions
SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
sb0002
Service Bulletin/Repair Instructions
Technical Publications Ordering
sb54289
Service Bulletin/Repair Instructions
ICU2M to ICU4M Conversion
sb3233
Service Bulletin/Repair Instructions
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
Service Bulletin/Repair Instructions
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16TL4
Service Bulletin/Repair Instructions
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS9
Service Bulletin/Repair Instructions
16TS9 DD Platform High Pressure Fuel Lines
16TS8
Service Bulletin/Repair Instructions
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16TL5
Service Bulletin/Repair Instructions
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16-010
Service Bulletin/Repair Instructions
Warranty Recognition Program Suspension
16-011
Service Bulletin/Repair Instructions
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
Service Bulletin/Repair Instructions
16TS7 Reman Diesel Particulate Filter Serial Number
16TL3
Service Bulletin/Repair Instructions
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
16-008
Service Bulletin/Repair Instructions
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
Service Bulletin/Repair Instructions
16-009R_OWL Enhancements
16_TL-2
Service Bulletin/Repair Instructions
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0307-16 SPN 723
Service Bulletin/Repair Instructions
0307-16 SPN 723 (MCM) March
16-007
Service Bulletin/Repair Instructions
Canadian Warranty Parts Return Address Change
16TS5
Service Bulletin/Repair Instructions
16TS5 Release of the DD Platform Bearing Failure Guide
0302-16
Service Bulletin/Repair Instructions
Contaminated Fluids
0301-16 SPN 625
Service Bulletin/Repair Instructions
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
0303-16
Service Bulletin/Repair Instructions
Hydrocarbon Doser Coolant Lines
1210-14
Service Bulletin/Repair Instructions
1210-14 Cylinder Head
1207-15
Service Bulletin/Repair Instructions
1207-15 Updated procedures with adding EPA10 to the GHG14 title
15TL24
Service Bulletin/Repair Instructions
15TL24 OTC 1750 Revolver Engine Stand
15TS4
Service Bulletin/Repair Instructions
15TS4_Rev2_ EPA07 DD15 Piston Kits
15TS16
Service Bulletin/Repair Instructions
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1201-15
Service Bulletin/Repair Instructions
1201-15 Crankshaft and Bearings
18SP729
Service Bulletin/Repair Instructions
18SP729 ? EPA07 10 Three-Filter Fuel
18SP730
Service Bulletin/Repair Instructions
18SP730 ? EPA07 10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
15TL20
Service Bulletin/Repair Instructions
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
15-028
Service Bulletin/Repair Instructions
_NewDetroitCoolantLineSRTs
15-028A
Service Bulletin/Repair Instructions
15-028 New Detroit Coolant Line SRTs
15-029
Service Bulletin/Repair Instructions
_Warranty Recognition Program - Coming Soon
sb54278
Service Bulletin/Repair Instructions
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sb54292
Service Bulletin/Repair Instructions
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
15-017
Service Bulletin/Repair Instructions
15-017 Detroit: Updated Fuel Injector SDTs
511-15
Service Bulletin/Repair Instructions
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
509-15
Service Bulletin/Repair Instructions
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
507-15
Service Bulletin/Repair Instructions
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
15-015
Service Bulletin/Repair Instructions
15-015 Warranty Exclusions Reminder
15-016
Service Bulletin/Repair Instructions
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15CSA10
Service Bulletin/Repair Instructions
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
Service Bulletin/Repair Instructions
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
Service Bulletin/Repair Instructions
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
Service Bulletin/Repair Instructions
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
Service Bulletin/Repair Instructions
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
15TL6
Service Bulletin/Repair Instructions
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
sb3133
Service Bulletin/Repair Instructions
sb3133 Step Clamps Are Not Reusable
15-010
Service Bulletin/Repair Instructions
15-010-DLR Transmission Cooler Line Photos
15TS9
Service Bulletin/Repair Instructions
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
15-009 - Detroit
Service Bulletin/Repair Instructions
15-009_Detroit_New_SDTs
15TL5
Service Bulletin/Repair Instructions
15TL5 DAVCO Shop Pro® FXP 95
307-15
Service Bulletin/Repair Instructions
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
15TL4
Service Bulletin/Repair Instructions
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
18SP712
Service Bulletin/Repair Instructions
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
sb01101
Service Bulletin/Repair Instructions
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
sb54290
Service Bulletin/Repair Instructions
sb54290 Guidelines for Repairing or Replacing an Electrical Harness
15TS6
Service Bulletin/Repair Instructions
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
15TS5
Service Bulletin/Repair Instructions
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
0202-15
Service Bulletin/Repair Instructions
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
15TS2
Service Bulletin/Repair Instructions
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1
Service Bulletin/Repair Instructions
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder Misfire At Idle
0104-15
Service Bulletin/Repair Instructions
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
18SP687
Service Bulletin/Repair Instructions
18SP687 DD15 16 EGR Actuator Replacement
sb9815
Service Bulletin/Repair Instructions
sb9815 Paint Finish Standards
14TL8
Service Bulletin/Repair Instructions
14TL8 TorcUP? Non-Impacting Torque Tool.
14-036
Service Bulletin/Repair Instructions
14-036-DLR DTNA & JAD Highlights - Q3
14-038
Service Bulletin/Repair Instructions
14-038 Additional Detroit Standard Repair Times
14-038A
Service Bulletin/Repair Instructions
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
Service Bulletin/Repair Instructions
14-039 New Detroit Standard Diagnostic Times
14-039A
Service Bulletin/Repair Instructions
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
Service Bulletin/Repair Instructions
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
Service Bulletin/Repair Instructions
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
Service Bulletin/Repair Instructions
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
Service Bulletin/Repair Instructions
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
Service Bulletin/Repair Instructions
14TL9 Special Tool Warranty Program.
14TL7
Service Bulletin/Repair Instructions
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
Service Bulletin/Repair Instructions
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
1010-14
Service Bulletin/Repair Instructions
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
Service Bulletin/Repair Instructions
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
Service Bulletin/Repair Instructions
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
Service Bulletin/Repair Instructions
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
14TS28
Service Bulletin/Repair Instructions
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1007-14
Service Bulletin/Repair Instructions
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
Service Bulletin/Repair Instructions
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
Service Bulletin/Repair Instructions
1005-14 Oil Coolant Module
1003-14
Service Bulletin/Repair Instructions
1003-14 Rough Running or Stalling.
18SP684REV4
Service Bulletin/Repair Instructions
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
Service Bulletin/Repair Instructions
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
Service Bulletin/Repair Instructions
sb2080 Australian CST M1400 Isolated Radiator Retrofit
35-23
Service Bulletin/Repair Instructions
35-23 - Breather Oil Leak on Freightliner Tandem Rear Axles
14-017R
Service Bulletin/Repair Instructions
14-017R Revised: Detroit Addition of Admin Time
14-029
Service Bulletin/Repair Instructions
14-029 New Detroit Standard Diagnostic Times
14TL2
Service Bulletin/Repair Instructions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
Service Bulletin/Repair Instructions
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
Service Bulletin/Repair Instructions
14-028 Remy Extended Coverage Direct File
14TS19
Service Bulletin/Repair Instructions
14TS19 DD Platform High Pressure Fuel Lines
14-027
Service Bulletin/Repair Instructions
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
Service Bulletin/Repair Instructions
14-026-DLR SelecTruck Warranty Enhancements
716-14
Service Bulletin/Repair Instructions
716-14 SPN 4077 (MCM)(EPA07 EPA10;GHG14
715-14
Service Bulletin/Repair Instructions
715-14 Symptom Diagnostics - Coolant Los
14-022
Service Bulletin/Repair Instructions
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
Service Bulletin/Repair Instructions
14-023 Detroit Axles Pre-Approval Changes
14-024
Service Bulletin/Repair Instructions
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
Service Bulletin/Repair Instructions
714-14 Symptom Diagnostics - Low Engine Compression
713-14
Service Bulletin/Repair Instructions
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
Service Bulletin/Repair Instructions
712-14 Engine Coolant Temperature
703-14
Service Bulletin/Repair Instructions
703-14 SPN 3556 (ACM) (EPA10)
18SP710
Service Bulletin/Repair Instructions
18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel
20-73
Service Bulletin/Repair Instructions
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75
Service Bulletin/Repair Instructions
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
54-215
Service Bulletin/Repair Instructions
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
54-285
Service Bulletin/Repair Instructions
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
SB-54-260
Service Bulletin/Repair Instructions
FREIGHTLINER: INFORMATION ON REPLACING THE MEGA FUSE JUNCTION BLOCK WITH A SERVICE VERSION POWER NET DISTRIBUTION BOX. *RM UPDATED 7/3/14. *PE
14TS5
Service Bulletin/Repair Instructions
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
0228-14
Service Bulletin/Repair Instructions
0228-14 Engine Oil Leaks - Oil Dye Method
14TS4
Service Bulletin/Repair Instructions
14TS4 Valve and Liner Installation Tool Issue
13wo3re
Service Bulletin/Repair Instructions
13wo3rev2_final Actual Labor Hours on Detroit Claims
0224-14
Service Bulletin/Repair Instructions
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0219-14
Service Bulletin/Repair Instructions
0219-14 Metal in Fuel
0215-14
Service Bulletin/Repair Instructions
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0210-14
Service Bulletin/Repair Instructions
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14
Service Bulletin/Repair Instructions
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0202-14
Service Bulletin/Repair Instructions
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0229-14
Service Bulletin/Repair Instructions
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14
Service Bulletin/Repair Instructions
0233-14 SPN 51 FMI 2 - All Years
0237-14
Service Bulletin/Repair Instructions
0237-14 Engine Brake Solenoid
0238-14
Service Bulletin/Repair Instructions
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
Service Bulletin/Repair Instructions
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
13TS22
Service Bulletin/Repair Instructions
Rev DD Platform Fuel Injector Cup Seal
13M2
Service Bulletin/Repair Instructions
13m2 -Final-23-SEP-2013 Field Service Campaign 13M2
13M2-02
Service Bulletin/Repair Instructions
13m2- Equipment Owner Field Service Campaign - 13M2
54-274
Service Bulletin/Repair Instructions
54-274 - Plastic Battery Box Cover Retainer Clip
54-277
Service Bulletin/Repair Instructions
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
54-278
Service Bulletin/Repair Instructions
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
13TS-24
Service Bulletin/Repair Instructions
13TS-24 DD Platform High Pressure Fuel Lines
18SP697
Service Bulletin/Repair Instructions
18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935
18SP698
Service Bulletin/Repair Instructions
18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932
sb0935
Service Bulletin/Repair Instructions
sb0935 Replacing the Engine Air Filter Element, Donaldson Air Cleaner (03-33648-001-002)
sb54215
Service Bulletin/Repair Instructions
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
307-13
Service Bulletin/Repair Instructions
307-13 SPN 652-FMI 14 - EPA07
13TS5
Service Bulletin/Repair Instructions
13TS5 DD Platform Fuel Filter Module
207-13
Service Bulletin/Repair Instructions
207-13 Removal and Installation of the Camshaft Housing
13WO-2
Service Bulletin/Repair Instructions
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
18SP693
Service Bulletin/Repair Instructions
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
12-039
Service Bulletin/Repair Instructions
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
Service Bulletin/Repair Instructions
12-040-DLR Roof Fairing Removal Program
12-041
Service Bulletin/Repair Instructions
12-041-DLR Over the Counter No Hassle Warranty (OTC)
12-038
Service Bulletin/Repair Instructions
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
SB42-68
Service Bulletin/Repair Instructions
FREIGHTLINER: BRAKE S-CAM TUBE LUBRICATION INTERVAL CHANGE. TO ENSURE OPTIMUM SERVICE LIFE AND TROUBLE-FREE OPERATION, THE RECOMMENDED MAINTENANCE INTERVAL FOR LUBRICATING MERITOR S-CAM BRAKE TUBES ON CENTURY CLASS, COLUMBIA, CASCADIA AND CORONADO OVER-THE-ROAD VEHICLES IS CHANGED FROM M2 TO THE M1 MAINTENANCE INTERVAL. *JS
sb4268
Service Bulletin/Repair Instructions
sb4268 Brake S-Cam Tube Lubrication Interval Change
sb4724
Service Bulletin/Repair Instructions
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
sb3131
Service Bulletin/Repair Instructions
sb3131 Huck-Spin 2 Changeover
12-022
Service Bulletin/Repair Instructions
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
SB-49-28
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: THERE ARE NEW CGI BELLOWS, BECAUSE THE OLD ONES ARE PRONE TO FATIGUE AND MAY FAIL. *RM UPDATED 4/24/12. *PE
SB-35-25
Service Bulletin/Repair Instructions
FREIGHTLINER: PROCEDURE OF REMOVING A LOWER PINION COVER IN THE REAR AXLES AND HOW TO RESEAL IT. *RM
SB-35-26
Service Bulletin/Repair Instructions
FREIGHTLINER: INFORMATION ON LUBRICATING THE WHEEL BEARINGS OF THE REAR DRIVE AXLES. *RM
SB-46-51
Service Bulletin/Repair Instructions
FREIGHTLINER: THERE IS A PROCEDURE TO REPLACE THE POWER STEERING PUMP. *RM
SB-54-205
Service Bulletin/Repair Instructions
FREIGHTLINER: SOMETIMES THE IDLE INTERMITTENTLY FAILS TO START THE VEHICLE DUE TO A SENSITIVE VEHICLE SPEED SENSOR. *RM
ICI-10-025
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: THE 294 BOLT IS DEEMED SERVICEABLE AND THERE IS A PROCEDURE FOR REPLACING IT. *RM
SB-46-48
Service Bulletin/Repair Instructions
FREIGHTLINER: TRW TAS85 STEERING GEAR INTERNAL LEAKAGE TEST. SOME TRW TAS85 STEERING GEARS HAVE BEEN EQUIPPED WITH AN INTERNAL RELIEF VALVE. THESE STEERING GEARS ARE TYPICALLY INSTALLED WITH POWER STEERING PUMPS THAT HAVE A PRESSURE RELIEF RATING GREATER THAN 2175 PSI (150 BAR). THE INTERNAL RELIEF VALVE LIMITS MAXIMUM SUPPLY PRESSURE TO PROTECT THE STEERING GEAR. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, COLUMBIA, CORONADO, BUSINESS CLASS M2 AND CASCADIA. NO MODEL YEARS LISTED. *PE
SB-46-47
Service Bulletin/Repair Instructions
FREIGHTLINER TRUCK: INNER TIE ROD INSPECTION AND REPAIR, RACK AND PINION GEAR. INCREASED LENGTH OF THE DRIVER SIDE INNER TIE ROD (IF THE INNER TIE ROD UNTHREADS FROM THE RACK) MAY CAUSE ABNORMAL STEER TIRE WEAR DUE TO HIGH TOE IN OR AN INABILITY TO MAINTAIN CORRECT TOE IN ADJUSTMENT. NO MODEL YEARS LISTED. *PE
SB-54-247
Service Bulletin/Repair Instructions
FREIGHTLINER TRUCK: INTERMITTENT ELECTRICAL ISSUES. INTERMITTENT ELECTRICAL ISSUES HAVE BEEN REPORTED ON CENTURY CLASS AND COLUMBIA TRUCKS. ISSUES WITH ENGINE PERFORMANCE, AUTOMATED TRANSMISSION SHIFTING, AND CHASSIS LIGHTING. IF ISSUES ARE REPORTED, PERFORM THE FOLLOWING WIRING HARNESS INSPECTION PROCEDURE. NO MODEL YEARS LISTED. *PE
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.