Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
WI21-009
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
SB35-036
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
SB60-171
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
SB54-327
Service Bulletin for Lengthening the Backup Light Harness. Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
SB72-043
Service Bulletin revision that adds Century Class and Columbia models to the affected list for a Door Window and Regulator Retrofit.
19-008WI
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19-009WI
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
fp46907
Steering Intermediate Shaft Replacement
sb54311
Service Bulletin- sb54311 ICU Odometer Programming
fp00024
fp00024 Cable-Tie Reference
sb00044
Reminder: Paper Service Bulletin Mailings Are Discontinued
DOC-1034171
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
ICI12-016 FL614
Important Campaign Information on FL614 Recall
sb9813 Side Fair
Service Bulletin 9813- Side Fairing Primer Repair
sb9814 Bumper Pa
Service Bulletin 9814- Bumper Paint
sb9816 DuPont Im
Service Bulletin 9816- DuPont? Imron® Elite
sb9817 Paint Sup
Service Bulletin 9817- Paint Supplier Change
sb9818 Repaintin
Service Bulletin 9818- Repainting Plastic Bumper Components
Aftertreamtent F
Service Information Bulletin for Aftertreamtent Failure Guide
DD13, DD15, DD16
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
18CSA16 Release
Release of DiagnosticLink® 8.08 Service Pack 2
sb3125 AirLiner
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
sb0036
Operating Hours for the Customer Assistance Center
SS1033638
SS 1033638 - Power Window Express Down Module Discontinued
fp00020
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
ICI18-014
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
FL705
FL705 Bendix Rear Brake Calipers
sb00042
sb00042 Flood Damage Repair GuidelinesB
sb0164
sb0164 MBE Engine Support Information
sb0175
sb0175 Replacing Drive Belts on MBE4000 EnginesB
sb1512
sb1512 Accessories On When Key is OffB
sb2046
sb2046 ABA Hose Clamp Torque Values
sb2052
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
sb2053
sb2053 New Stainless Steel Lower Radiator Tubes
sb2080
sb2080 Australian CST M1400 Isolated Radiator RetrofitB
sb31034
sb31034 Towing ProceduresB
sb54122
sb54122 ICU3 Service Cluster AvailableB
sb54148
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb54194
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54202
sb54202 Rerouting the DDEC IV Relative-Humidity-Sensor Harness
sb54296
sb54296 Fuel Level Sending Unit RetrofitB
sb98020
sb98020 Axalta Paint Finish CareB
fp47019
fp47019 25-Inch Diameter Fuel Tanks
17-029
Computer Hook-Up Standard Diagnostic Time Update
17CSA25
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17-028
OWL Enhancement Service Model Field
17CSA23r
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
17-026
17-026 Holiday Closure 2017
17-027
Warranty Classroom Training in 2018
17TL25
17TL25 TruckCam? Alignment System
14CSA23
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
sb4641
Adjusting Tilt Lock Force on TRW Steering Columns
SS1032974
SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
sb0002
Technical Publications Ordering
0609-17
SPN 3226 (ACM) (GHG17)
0608-17
Diagnostic tests - Two Filter System - FSIC Leak Test
0607-17
SPN 96 (MCM) (GHG17)
0606-17
SPN 3226 (ACM) (GHG17)
0604-17
SPN 712 (CPC) (GHG17)
0603-17
Fuel System Integrity Check Routine - Two-Filter Fuel System
0602-17
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
0601-17
SPN 3464 (MCM) (GHG14)
17TS11
Detroit? DT12? Transmission Proper Moving Procedure
17TS10
Detroit? DT12? Split Rod Bushing Repair
17TS9
DD Heavy Duty Platform Belt and Belt Tensioner
0409-17
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0408-17 SPN 5242
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
0406-17
SPN 521221 (TCM)
0405-17
SPN 521222 (TCM)
0401-17
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
0315-17
GHG14 - Intake Manifold Pressure Too Low
0314-17
GHG14 Intake Manifold Pressure Too Low
0303-17
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0202-17
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
0141-17
0141-17 SPN 2659 (MCM) (EPA10)
0120-17
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17
0118-17 Symptom Diagnostics - Oil Leaks
0115-17
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
0114-17
0114-17 SPN 2791 (MCM) (EPA07;EPA10)
0113-17
0113-17 SPN 3361 (ACM) (EPA10)
1213-16
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
1207-16
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
16TS24
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
18SP714
18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
18SP719
18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
16TL20
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
1021-16
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1020-16
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
1018-16
1018-16 SYMPTOM DIAGNOSTICS - NOISE
1017-16
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
18SP713REV 18SP7
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
SB0006
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
09 09-16
0909-16 EXCESSIVE OIL CONSUMPTION
08 10-16
0810-16 SYMPTOM DIAGNOSTIC NOISE
08 09-16
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
16 TS-14
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
sb3233
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16TL4
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS9
16TS9 DD Platform High Pressure Fuel Lines
16TS8
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16TL5
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16-010
Warranty Recognition Program Suspension
16-011
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
16TS7 Reman Diesel Particulate Filter Serial Number
16TL3
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
16-008
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
16-009R_OWL Enhancements
16_TL-2
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0307-16 SPN 723
0307-16 SPN 723 (MCM) March
16-007
Canadian Warranty Parts Return Address Change
16TS5
16TS5 Release of the DD Platform Bearing Failure Guide
0302-16
Contaminated Fluids
0301-16 SPN 625
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
0303-16
Hydrocarbon Doser Coolant Lines
1210-14
1210-14 Cylinder Head
1207-15
1207-15 Updated procedures with adding EPA10 to the GHG14 title
15TL24
15TL24 OTC 1750 Revolver Engine Stand
15TS4
15TS4_Rev2_ EPA07 DD15 Piston Kits
15TS16
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1201-15
1201-15 Crankshaft and Bearings
18SP718
18SP718 EPA07 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP720
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP722
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
18SP725
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
AEO15M1
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
15TL20
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
15-028
_NewDetroitCoolantLineSRTs
15-028A
15-028 New Detroit Coolant Line SRTs
15-029
_Warranty Recognition Program - Coming Soon
805-15
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
803-15
803-15 Removal of the Camshaft Housing
802-15
802-15 SPN 520970 FMI 7 (TCM)
801-15
801-15 SPN 520999 FMI 7 (TCM)
15TS15
15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
711-15
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
15TS14 GHG14
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
706-15
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
703-15
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
702-15
702-15 DD15 and DD16 Delphi © Exhaust Gas Recirculation Valve Actuator
704-15
704-15 SPN 4364 (ACM)(EPA10)
sb54278
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sb54292
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
15-017
15-017 Detroit: Updated Fuel Injector SDTs
512-15
512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod
511-15
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
509-15
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
508-15
508-15 SPN 625 (MCM)( EPA10;GHG14)
507-15
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
506-15
506-15 Air Compressor Coolant Lines
505-15
505-15 SPN 3361 (ACM) (EPA10)
15-015
15-015 Warranty Exclusions Reminder
15-016
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
504-15
504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod
503-15
503-15 DD13 Exhaust Gas Recirculation Valve Actuator
502-15
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
501-15
501-15 Engine Lifter Brackets
sb2084
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
sb4654
sb4654 Rack and Pinion Steering Gear Retrofit Guide
15CSA10
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
406-15
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
405-15
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
404-15
404-15 SPN 4364 (ACM) (EPA10)
403-15
403-15 SPN 677 (MCM)(EPA07)
15TL6
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
402-15
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
18SP717
18SP717 DD13 EGR Actuator Replacement
401-15
401-15 Cylinder Block
sb3133
sb3133 Step Clamps Are Not Reusable
15-010
15-010-DLR Transmission Cooler Line Photos
15TS9
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15
326-15 Main Shaft Speed Sensor
324-15
324-15 External Component Repair
323-15
323-15 Symptom Diagnostics ? Noise
15-009 - Detroit
15-009_Detroit_New_SDTs
15TL5
15TL5 DAVCO Shop Pro® FXP 95
309-15
309-15 SPN 3251 (ACM)(EPA10)
308-15
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
307-15
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
306-15
306-15 SPN 3246 (ACM)(EPA10;GHG14)
305-15
305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor
15TL4
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
304-15
304-15 Diagnostic Tests
303-15
303-15 Contaminated Fluids
302-15
302-15 Crankshaft Oil Seals
18SP706
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
18SP712
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
301-15
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
sb01101
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
sb54290
sb54290 Guidelines for Repairing or Replacing an Electrical Harness
15TS8
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0204-15
0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment
15TS6
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
0203-15
0203-15 Oil Filter Stand Pipe
15TS5
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
0202-15
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
15TS2
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder Misfire At Idle
0108-15
0108-15 SPN 1323 through 1328 (MCM) (GHG14)
0107-15
0107-15 Enhanced Steam Clean
0106-15
0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
0105-15
0105-15 SPN 102 (MCM) (GHG14)
0104-15
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
102-15
102-15 High Pressure Fuel Pump - Two-Filter System
0101-15
0101-15 SPN 4364 (ACM) (EPA10)
18SP687
18SP687 DD15 16 EGR Actuator Replacement
sb9815
sb9815 Paint Finish Standards
1110-14
1110-14 EPA10 DOC Inlet Pressure Sensor
1108-14
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
1105-14
1105-14 Flywheel, Ring Gear and Flywheel Housing
1104-14
1104-14 Metal in the Fuel System
1102-14
1102-14 DD13 Cylinder Head R&R
1101-14
1101-14 DD15 and DD16 Cylinder Head
18SP707
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
18SP708
18SP708Rev EPA07 10 Three-Filter Fuel
18SP711
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
SF501
SF501-DLR Perpendicular Steel Air Tank Mounting Brackets
14TL8
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS19
14TS19Rev DD Platform High Pressure Fuel Lines
14-036
14-036-DLR DTNA & JAD Highlights - Q3
14-038
14-038 Additional Detroit Standard Repair Times
14-038A
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
14-039 New Detroit Standard Diagnostic Times
14-039A
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
14TL9 Special Tool Warranty Program.
14TL7
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
1010-14
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
14TS28
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1007-14
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
1005-14 Oil Coolant Module
1003-14
1003-14 Rough Running or Stalling.
18SP684REV4
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb54287
sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
sbw5460
sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
920-14
920-14 Additional Cleaning and Preparing
919-14
919-14 Exhaust Gas Recirculation Flow Target Error Diagnostic - High Flow
14TS26
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
918-14
918-14 Removal and Installation and Inspection of the Fuel Cooler Delete Bypass Plate - Two Filter System
917-14
917-14 Installation and Removal of the Oil Filter Stand Pipe
916-14
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
915-14
915-14 Backwards Running Engine Detecte
14TS25
14TS25 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
912-14
912-14 Coolant in Oil
911-14
911-14 5V Sensor Supply Bank 2 Circuit Failed High
910-14
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
909-14
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
908-14
908-14 908-14 EGR Differential Pressure Failed (High Box)
907-14
907-14 Installation and Removal of the Flywheel Housing
906-14
906-14 Installation of the Oil Pan
905-14
905-14 Coolant Level Circuit Failed
904-14
904-14 Selective Catalyst Reduction Outlet NOx Sensor Circuit Failed High and Low
903-14
903-14 Selective Catalyst Reduction Inlet NOx Sensor Circuit Failed High and Low
18SP701
18SP701Rev3 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
35-23
35-23 - Breather Oil Leak on Freightliner Tandem Rear Axles
813-14
813-14 Installation of the One & Two-Piece Fuel Injector Wiring Harness - Two & Three-Filter System
14TS21
14TS21 HDEP Camshaft Position Sensor Change
812-14
812-14 FMI 3, 4: Engine Aux. Shutdown Input Failed High and Low
14-017R
14-017R Revised: Detroit Addition of Admin Time
811-14
811-14 FMI 7: Internal Error with the DT12 Shift Stalk Lever
809-14
809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed
807-14
807-14 FMI 8 SCR Inlet Temperature Signal Spike
14-029
14-029 New Detroit Standard Diagnostic Times
804-14
804-14 FMI 16, 18 Intake Manifold Pressure Too high and low (Restricted Mode)
803-14
803-14 FMI 16,18: Intake Manifold Pressure Too High and Low
802-14
802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low
18SP703
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
801-14
801-14 FMI 19: RCM Message Not Received or Stopped Arriving
14TL2
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
14-028 Remy Extended Coverage Direct File
14TS18
14TS18 GHG14 DD Engine EGR System Fault Code
14-027
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
14-026-DLR SelecTruck Warranty Enhancements
719-14
719-14 SPN 84 (CPC) (GHG14)
716-14
716-14 SPN 4077 (MCM)(EPA07 EPA10;GHG14
715-14
715-14 Symptom Diagnostics - Coolant Los
14-022
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
14-023 Detroit Axles Pre-Approval Changes
14-024
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
714-14 Symptom Diagnostics - Low Engine Compression
713-14
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
712-14 Engine Coolant Temperature
711-14
711-14 SPN 107 (CPC) (GHG14
710-14
710-14 SPN 96 (CPC) (GHG14)
709-14
709-14 SPN 3216 (MCM) (GHG14)
708-14
708-14 SPN 520219 (IPPC) (GHG14)
707-14
707-14 SPN 520229 FMI 3 (IPPC) (GHG14
706-14
706-14 SPN 171 FMI 3, 4 (CPC)(GHG14)
705-14
705-14 SPN 520203 FMI 6 (IPPC)(GHG14)
704-14
704-14 SPN 520200 FMI 6 (IPPC)(GHG14)
703-14
703-14 SPN 3556 (ACM) (EPA10)
702-14
702-14 SPN 520230FMI 5 (IPPC)(GHG14)
18SP709
18SP709Rev 18SP709Rev ? EPA10/GHG14 Two-Filter Fuel
18SP710
18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel
20-73
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
54-215
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
701-14
701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14
524-14
524-14 FMI 0: Engine Speed High
522-14
522-14 Removal and Installation of the Oil Pump Cover
14TS13
14TS13Rev EPA10/GHG14 Diesel Exhaust Fluid (DEF) in Fuel System/Diesel Fuel in DEF System Contamination
519-14
519-14 FMI 1: SCR NOx Conversion Efficiency Very Low
518-14
518-14 FMI 1, 18: Regen Temperature- Out Of Range Low
516-14
516-14 FMI 3, 4: DEF pressure sensor circuit failed hig
513-14
513-14 FMI 0: Diesel Particulate Filter Outlet Temperature - Very High
507-14
507-14 Inspection of the DD15 and DD16 Axial Power Turbine
506-14
506-14 506-14 Removal and Installation and Inspection of the Exhaust Gas Recirculation Valve Actuator Pull Rod
505-14
505-14 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
504-14
504-14 Test-E - Three-Filter Fuel System
503-14
503-14 FMI 3, 4: High Side Digital Output 3 Circuit Failed High
502-14
502-14 FMI 4 SCR Inlet Temperature High
18SP684
18SP684Rev3 EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
14TS5
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
0228-14
0228-14 Engine Oil Leaks - Oil Dye Method
14TS4
14TS4 Valve and Liner Installation Tool Issue
0226-14
0226-14 SPN 3216 FMI 3, 4 (ACM2)(EPA10)
13wo3re
13wo3rev2_final Actual Labor Hours on Detroit Claims
0224-14
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0222-14
0222-14 SPN 4334 FMI 7 (ACM) (EPA10)
0219-14
0219-14 Metal in Fuel
0218-14
0218-14 GHG14 Diesel Exhaust Fluid Pump Module Filter
0217-14
0217-14 Installation of the Fuel Injector Cup
0216-14
0216-14 SPN 3363 FMI 1 - ACM - EPA10 - GHG14
0215-14
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0210-14
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0207-14
0207-14 SPN 3031 FMI 3, 4 (ACM) (EPA10 - GHG14)
0202-14
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0201-14
0201-14 SPN 1761 FMI 3, 4 (ACM2-EPA10) (ACM2.1-GHG14)
0227-14
0227-14 SPN 4335 FMI 7 - EPA10
0229-14
0229-14 Symptom Based Diagnostics - Oil Separator
0230-14
0230-14 SPN 4375 FMI 6 - EPA10
0233-14
0233-14 SPN 51 FMI 2 - All Years
0237-14
0237-14 Engine Brake Solenoid
0238-14
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
54-278
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
FSB-83-131
FREIGHTLINER: INFORMATION REGARDING THE REPLACEMENT LINE WITH A NEW ASSEMBLY CONNECTING THE MANIFOLD WITH A HOSE AND HOSE BARB, IN THE EVENT HEATER RETURN PIPE (HT2 LINE) FAILS ON THE ENGINE. MODEL CENTURY CLASS CONVENTIONAL, COLUMBIA, CASCADIA. NO YEARS LISTED. *PE
13TS30
GHG14 DD Engine EGR System Fault Codes
13TS28
GHG14 472906S Turbocharger Compressor Inlet
13TS15
13TS15Rev EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251/FMI 2 - DOC Inlet Pressure Sensor Not Plausible
13TS22
Rev DD Platform Fuel Injector Cup Seal
13TS25
Issues with PTO and Remote Throttle Combinations
13M2
13m2 -Final-23-SEP-2013 Field Service Campaign 13M2
13M2-02
13m2- Equipment Owner Field Service Campaign - 13M2
33-28
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
54-274
54-274 - Plastic Battery Box Cover Retainer Clip
54-277
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
FSB-35-30
FREIGHTLINER: ON RECOMMENDATION OF CONMET, REPLACEMENT OF BEARING SPACER, WITH A NEW ONE, IS REQUIRED WHEN A HUB IS REMOVED. *PE
13TS-24
13TS-24 DD Platform High Pressure Fuel Lines
808-13
808-13 FMI 0 Under Pressurized DEF System
803-13
803-13 FMI 2: Intake Throttle Position Deviation Error
803-13 B
803-13 FMI 10,18: Intake Throttle Position Abnormal Rate of Change, Position Data Valid but Below Normal Operating Range - Moderately Severe Level
802-13
802-13 FMI 18 Coolant Level Low
18SP697
18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935
18SP698
18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932
18SP699
18SP699 EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Feed Lines PN A4710706035
18SP700
18SP700 EPA10,GHG14 Two-Filter Fuel System KM59 GEN1 DD15,16 High Pressure Fuel Feed Lines PN:A4720708032
716-13
716-13 SPN 3226-FMI 13 - EPA10 - GHG14, SPN 3216-FMI 13 ? EPA10, SPN 3216-FMI 13 - GHG14
714-13
714-13 Fuel Filter Maintenance Intervals
713-13
713-13 SPN 4334-FMI 7 - EPA10
709-13
709-13 SPN 2798-FMI 4-EPA10-GHG14
708-13
708-13 Fuel System Diagram Update
706-13
706-13 SPN 157-FMI 10, 15, 17, 18 - GHG14
SB-09-35
FREIGHTLINER: REPLACEMENT OF THE ENGINE AIR FILTER ELEMENT. IF THE AIR FILTER IS INSTALLED IMPORPERLY IT COULD CAUSE ENGINE DAMAGE OR FAILURE. *KB
sb0935
sb0935 Replacing the Engine Air Filter Element, Donaldson Air Cleaner (03-33648-001-002)
611-13
611-13 Removal and Installation of the GHG14 Six-Gallon Diesel Exhaust Fluid Tank Header
607-13
607-13 SPN 3361-FMI 7- EPA10
604-13
604-13 Performing a Parked Regeneration
603-13
603-13 SPN 84 -FMI 6 - EPA07-GHG14
13TS17
13TS17 EPA10-GHG14 Diesel Exhaust Fluid (DEF) in Fuel System-Diesel Fuel in DEF System Contamination
531-13
531-13 GHG14 DD15 Asymmetrical Turbocharger
528-13
528-13 SPN 3246-FMI 0 - EPA10 - GHG14
527-13
527-13 SPN 190-FMI 15,17 GHG14
525-13
525-13 SPN 2791-FMI 7 ? ALL YEARS
520-13
520-13 Cylinder Block
518-13
518-13 SPN 4334-FMI 4 - GHG14
418-13
418-13 SPN 2791-FMI 12 - GHG14
414-13
414-13 Removal and Installation of the GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank Header Unit
413-13
413-13 GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank
407-13
407-13 EGR Actuator Slow Learn
sb54215
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
13TS12
13TS12 HDEP Wastegate Solenoid Air Leaks
13TS10
13TS10 DD Platform Oil Coolant Module Plugs
311-13
311-13 SPN 651-FMI 3 - EPA10 - GHG14
310-13
310-13 Draining the Fuel System Using J-48710 Prior to Repairs
305-13
305-13 GHG14 DD15 Asymmetrical Turbocharger Flanged Exhaust Manifold
303-13
303-13 SPN 3242-FMI 4 -EPA10 - GHG14
13TS7
13TS7 GHG14 CPC4 Vehicle Speed Sensor Code SPN 84-FMI 6
13TS8
13TS8 GHG14 Throttle Codes SPN 91-FMI 7 and SPN 91-FMI 10
301-13
301-13 SPN 5018- FMI 18 -GHG14
13TS6
13TS6 DD Platform Engine Oil Filter.pdf
13TS5
13TS5 DD Platform Fuel Filter Module
207-13
207-13 Removal and Installation of the Camshaft Housing
13WO-2
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
18SP693
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
SF471
SF471-DLR Detroit Axles Driver-Controlled Differential Locks
132-13
132-13 SPN 3597-FMI 4 - EPA10
133-13
133-13 SPN 4375-FMI 4 and 5 - GHG14
135-13
135-13 SPN 1243-FMI 14 - GHG14
137-13
137-13 SPN 2798-FMI 4 - EPA10 - GHG14
139-13
139-13 SPN 3251-FMI 0, 16, 20, 21 GHG14
13TL2
13TL2 GHG14 Test Electronic Control Units (ECUs).
143-13
143-13 Low Pressure Fuel System - Measuring Fuel Pressure Using Fuel System Integrity Check, Two-Filter Fuel System
144-13
144-13 Removal and Installation of the GHG14 Diesel Exhaust Fluid Lines
145-13
145-13 Description and Operation of Gear Train and Related Parts
146-13
146-13 SPN 4335-FMI 1 EPA10
148-13
148-13 GHG14 DD15 Asymmetrical Turbocharger Exhaust Manifold
129-13
129-13 DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE
128-13
128-13 SPN 511403-FMI 0,1,2,3,4,5,6,8,9,10,11,12,13,14
126-13
126-13 Description and Operation of the DD15 and DD16 Exhaust Gas Recirculaton Cooler
124-13
124-13 Installation of the DD Platform EGR Actuator Pull Rod
119-13
119-13 Exhaust Gas Recirculation System - Cleaning
112-13
112-13 SPN 4364-FMI 18 - GHG14
111-13
111-13 SPN 4374/FMI 0, 1, 3, 4 - GHG14
110-13
110-13 SPN 5435-FMI 7 - GHG14
109-13
109-13 SPN 3250-FMI 31 (ACM2.1) GHG14
108-13
108-13 SPN 3364-FMI 18 - GHG14
107-13
107-13 SPN 84-FMI 7 - GHG14
106-13
106-13 SPN 100-FMI 10 - GHG14
105-13
105-13 SPN 625-FMI 13 - GHG14
104-13
104-13 SPN 1592-FMI 13 and 19 - GHG14
103-13
103-13 SPN 520328-FMI 7 - GHG14
102-13
102-13 SPN 84-FMI 13, 19, 21 (MCM) EPA10-GHG14
101-13
101-13 SPN 3563 FMI 21 - GHG14
12-039
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
12-040-DLR Roof Fairing Removal Program
12-041
12-041-DLR Over the Counter No Hassle Warranty (OTC)
ICI12-028
ICI12-028-DLR FL632 - Interim Notice
12-038
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
Body SRT
Body SRT Updates -2012.12.12
sb4268
sb4268 Brake S-Cam Tube Lubrication Interval Change
sb4724
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
ICI12-026
ICI12-026-DLR SF471 - Second Revised Bulletin
1118-12
1118-12 SPN 705-FMI 5 - GHG14
ICI12-025
ICI12-025-DLR SF471 - Revised Bulletin
1113-12
1113-12 SPN 3226/FMI 20 - GHG14
1112-12
1112-12 Test C -Two-Filter Fuel System
1102-12
1102-12 Test A - Two-Filter Fuel System
12-033
12-033-DLR Over the Counter No Hassle Warranty (OTC)
1101-12
1101-12 Test B -Two-Filter Fuel System
SF-471-AB
DAIMLER TRUCK: THICKNESS AND EXCESS MATERIAL FROM DIE PUNCHING MAY PREVENT RETAINING SNAP RINGS FROM FULLY SEATING IN DIFFERENTIAL LOCK SHIFT FORK ASSEMBLIES, CAUSING DIFFERENTIAL LOCK TO REMAIN UNENGAGED OR ENGAGED. MODELS 2011-2012 BUSINESS CLASS M2, CASCADIA, COLUMBIA, CORONADO, WESTERN STAR 4900. *PE
sb3131
sb3131 Huck-Spin 2 Changeover
914-12
914-12 GHG14 Two-Box Diesel Oxidation Catalyst.pdf
903-12
903-12 Installation of the Intake Throttle Valve and Adaptor.pdf
830-12
830-12 SPN 520326-FMI 4 - GHG14
12CSA19
12CSA19 GHG14 Rapid Warranty Parts Return.
818-12
818-12 SPN 520296-FMI 19 and 31 - GHG14
815-12
815-12 Installation of the Oil Cooler
811-12
811-12 SPN 411-FMI 3
810-12
810-12 SPN 3842-FMI 3, 4, and 5 (CPC4)
809-12
809-12 Removal and Installation of the GHG14 1-BOX From the Vehicle
12TS14
12TS14 Repair Facility Input on GHG14 Engine and Aftertreatment System Issues
807-12
807-12 Removal and Installation of the GHG14 Diesel Exhaust Fluid Dosing Unit Inlet Screen
805-12
805-12 SPN 4354-FMI 5, 4356-FMI 5, 4355-FMI 5, 4357-FMI 5
804-12
804-12 SPNs 4354-FMI 5, 4355-FMI 5, 4356-FMI 5, 4357-FMI 5
803-12
803-12 SPN 4360-FMI 10, 15 (ACM2.1)
802-12
802-12 SPN 520328-FMI 7 - GHG14
12-022
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
801-12
801-12 SPN 1761-FMI 9 - GHG14
842-12
842-12 SPN 3864-FMI 3 and 4 - GHG14
843-12
843-12 SPN 3866-FMI 3 and 4
844-12
844-12 SPN 3867-FMI 3 and 4
845-12
845-12 SPN 3868-FMI 3 and 4
846-12
846-12 SPN 3869-FMI 3 and 4
847-12
847-12 SPN 3870-FMI 3 and 4
848-12
848-12 SPN 3872-FMI 3 and 4
849-12
849-12 SPN 3873-FMI 3 and 4
sb4267
sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
FSB-42-67
FREIGHTLINER: ON SOME TRUCKS, WHENEVER BRAKES ARE APPLIED, THE TRUCK WOULD EXPERIENCE SEVERE SHIMMY OR SHAKING. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, ARGOSY COE, COLUMBIA, CORONADO, BUSINESS CLASS M2, CASCADIA, 108SD/114SD. NO MODEL YEARS LISTED. *PE UPDATED 11/1/12. *PE
GI-46-41
FREIGHTLINER: ADJUSTING THE CORRECT TILT LOCK FORCE ON TRW STEERING COLUMNS. *PE UPDATED 7/18/12. *PE
FSB-32-46
FREIGHTLINER: FOR SOME MODEL TRUCKS, RECOMMENDATION OF PREVENTIVE MAINTENANCE INTERVALS FOR REAR HEAVY DUTY SUSPENSION AND OFF HIGHWAY AND SEVERE SERVICE OPERATING CONDITIONS REQUIRES FREQUENT INSPECTIONS. *PE
SB-32-48
FREIGHTLINER: THE REAR SUSPENSION AIR SPRING HAS BEEN REDESIGNED. *RM
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.