SB83-122
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Bergstrom NITE Parked HVAC Performance Issues. Minor note: added an update of document previously submitted. The related VMRS codes are added
Vehicle report
2008 FREIGHTLINER CORONADO
Service bulletins
317 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
WI21-009
Service Bulletin/Repair Instructions
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Service Bulletin/Repair Instructions
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
SB35-036
Service Bulletin/Repair Instructions
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
SB54-278
Service Bulletin/Repair Instructions
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeterî is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
20TS-01
Service Bulletin/Repair Instructions
Technical Service Letter for DDC Series 60 engines concerning Series 60 Cylinder Head Resurfacing/Finish. Detroit Diesel does not recommend third party resurfacing of Series 60 cylinder heads (outside of Detroit and Detroit Reman).
SB32-054
Service Bulletin/Repair Instructions
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
SB47-027
Service Bulletin/Repair Instructions
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
19-008WI
Service Bulletin/Repair Instructions
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
fp46907
Service Bulletin/Repair Instructions
Steering Intermediate Shaft Replacement
DOC-1034220
Service Bulletin/Repair Instructions
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
sb54311
Service Bulletin/Repair Instructions
Service Bulletin- sb54311 ICU Odometer Programming
fp00024
Service Bulletin/Repair Instructions
fp00024 Cable-Tie Reference
sb00044
Service Bulletin/Repair Instructions
Reminder: Paper Service Bulletin Mailings Are Discontinued
sb54268
Service Bulletin/Repair Instructions
sb54268 122SD and Coronado Virtual Technician Retrofit
ICI12-016 FL614
Service Bulletin/Repair Instructions
Important Campaign Information on FL614 Recall
18TS4Rev DD
Service Bulletin/Repair Instructions
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
GHG17
Service Bulletin/Repair Instructions
Letter to customer on Coverage Extension GHG17 After Treatment
sb9817 Paint Sup
Service Bulletin/Repair Instructions
Service Bulletin 9817- Paint Supplier Change
HDEP PLV Return
Service Bulletin/Repair Instructions
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
Aftertreamtent F
Service Bulletin/Repair Instructions
Service Information Bulletin for Aftertreamtent Failure Guide
DD13, DD15, DD16
Service Bulletin/Repair Instructions
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
sb3125 AirLiner
Service Bulletin/Repair Instructions
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
sb0036
Service Bulletin/Repair Instructions
Operating Hours for the Customer Assistance Center
fp00020
Service Bulletin/Repair Instructions
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
sb31037
Service Bulletin/Repair Instructions
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed. The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
sb31038
Service Bulletin/Repair Instructions
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn. This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
ICI18-014
Service Bulletin/Repair Instructions
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
sb2043
Service Bulletin/Repair Instructions
sb2043 Radiator Fan Shroud Seal
sb2045
Service Bulletin/Repair Instructions
sb2045 New Surge Tank Cap
sb2046
Service Bulletin/Repair Instructions
sb2046 ABA Hose Clamp Torque Values
sb2052
Service Bulletin/Repair Instructions
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
sb2053
Service Bulletin/Repair Instructions
sb2053 New Stainless Steel Lower Radiator Tubes
sb2063
Service Bulletin/Repair Instructions
sb2063 Coolant Filter Inspection Procedure, DD13 DD15 DD16 Only
sb2068
Service Bulletin/Repair Instructions
sb2068 Conventional Fully-Formulated Coolant with SCA Color Change
sb2069
Service Bulletin/Repair Instructions
sb2069 Kysor Fan Clutch Sticking
sb2070
Service Bulletin/Repair Instructions
sb2070 EPA07 and Newer Gentech Coolant-Level Sensor Testing
sb2074
Service Bulletin/Repair Instructions
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2083
Service Bulletin/Repair Instructions
sb2083 FluidXchange Tool and FittingsB
sb31034
Service Bulletin/Repair Instructions
sb31034 Towing ProceduresB
sb4267
Service Bulletin/Repair Instructions
sb4267 Brake Shimmy?Meritor® SteeLite X30? Brake Drum with Excessive RunoutB
sb54122
Service Bulletin/Repair Instructions
sb54122 ICU3 Service Cluster AvailableB
sb54148
Service Bulletin/Repair Instructions
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb54194
Service Bulletin/Repair Instructions
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54202
Service Bulletin/Repair Instructions
sb54202 Rerouting the DDEC IV Relative-Humidity-Sensor Harness
sb54296
Service Bulletin/Repair Instructions
sb54296 Fuel Level Sending Unit RetrofitB
sb98020
Service Bulletin/Repair Instructions
sb98020 Axalta Paint Finish CareB
17-029
Service Bulletin/Repair Instructions
Computer Hook-Up Standard Diagnostic Time Update
17CSA25
Service Bulletin/Repair Instructions
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17TL26
Service Bulletin/Repair Instructions
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17TL27
Service Bulletin/Repair Instructions
17TL27 Injector Cup Tool DSN930E17001
17TL28
Service Bulletin/Repair Instructions
17TL28 Fuel Injector Removal Tool DSN930E17004
17CSA24
Service Bulletin/Repair Instructions
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17-028
Service Bulletin/Repair Instructions
OWL Enhancement Service Model Field
17CSA23r
Service Bulletin/Repair Instructions
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
17-026
Service Bulletin/Repair Instructions
17-026 Holiday Closure 2017
17-027
Service Bulletin/Repair Instructions
Warranty Classroom Training in 2018
17TL25
Service Bulletin/Repair Instructions
17TL25 TruckCam? Alignment System
14CSA23
Service Bulletin/Repair Instructions
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
17TS17Rev
Service Bulletin/Repair Instructions
Instructions for CSC Diagnostic Support
17-023
Service Bulletin/Repair Instructions
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
0903-17
Service Bulletin/Repair Instructions
Engine Manufacturer Diagnostics
sb4641
Service Bulletin/Repair Instructions
Adjusting Tilt Lock Force on TRW Steering Columns
SS1032974
Service Bulletin/Repair Instructions
SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
sb0002
Service Bulletin/Repair Instructions
Technical Publications Ordering
0609-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0608-17
Service Bulletin/Repair Instructions
Diagnostic tests - Two Filter System - FSIC Leak Test
0607-17
Service Bulletin/Repair Instructions
SPN 96 (MCM) (GHG17)
0606-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0604-17
Service Bulletin/Repair Instructions
SPN 712 (CPC) (GHG17)
0603-17
Service Bulletin/Repair Instructions
Fuel System Integrity Check Routine - Two-Filter Fuel System
0602-17
Service Bulletin/Repair Instructions
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
0601-17
Service Bulletin/Repair Instructions
SPN 3464 (MCM) (GHG14)
SS1033094
Service Bulletin/Repair Instructions
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
0409-17
Service Bulletin/Repair Instructions
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0202-17
Service Bulletin/Repair Instructions
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
sb3251
Service Bulletin/Repair Instructions
Replacing or Upgrading Airliner 40K Transverse Torque Rods
0120-17
Service Bulletin/Repair Instructions
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17
Service Bulletin/Repair Instructions
0118-17 Symptom Diagnostics - Oil Leaks
0114-17
Service Bulletin/Repair Instructions
0114-17 SPN 2791 (MCM) (EPA07;EPA10)
1213-16
Service Bulletin/Repair Instructions
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
18SP718
Service Bulletin/Repair Instructions
18SP718Rev EPA07 DD1516 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
16TL20
Service Bulletin/Repair Instructions
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
1021-16
Service Bulletin/Repair Instructions
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1020-16
Service Bulletin/Repair Instructions
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
1018-16
Service Bulletin/Repair Instructions
1018-16 SYMPTOM DIAGNOSTICS - NOISE
1017-16
Service Bulletin/Repair Instructions
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
SB0006
Service Bulletin/Repair Instructions
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
09 09-16
Service Bulletin/Repair Instructions
0909-16 EXCESSIVE OIL CONSUMPTION
08 10-16
Service Bulletin/Repair Instructions
0810-16 SYMPTOM DIAGNOSTIC NOISE
08 09-16
Service Bulletin/Repair Instructions
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
16 TS-15
Service Bulletin/Repair Instructions
16TS15 EPA07 AND LATER POWER TAKE-OFF (PTO) DOSING FEATURE
sb3233
Service Bulletin/Repair Instructions
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
Service Bulletin/Repair Instructions
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16TL4
Service Bulletin/Repair Instructions
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS9
Service Bulletin/Repair Instructions
16TS9 DD Platform High Pressure Fuel Lines
16TS8
Service Bulletin/Repair Instructions
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16TL5
Service Bulletin/Repair Instructions
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16-010
Service Bulletin/Repair Instructions
Warranty Recognition Program Suspension
16-011
Service Bulletin/Repair Instructions
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
Service Bulletin/Repair Instructions
16TS7 Reman Diesel Particulate Filter Serial Number
16TL3
Service Bulletin/Repair Instructions
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
16-008
Service Bulletin/Repair Instructions
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
Service Bulletin/Repair Instructions
16-009R_OWL Enhancements
16_TL-2
Service Bulletin/Repair Instructions
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0307-16 SPN 723
Service Bulletin/Repair Instructions
0307-16 SPN 723 (MCM) March
16-007
Service Bulletin/Repair Instructions
Canadian Warranty Parts Return Address Change
16TS5
Service Bulletin/Repair Instructions
16TS5 Release of the DD Platform Bearing Failure Guide
0302-16
Service Bulletin/Repair Instructions
Contaminated Fluids
0301-16 SPN 625
Service Bulletin/Repair Instructions
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
0303-16
Service Bulletin/Repair Instructions
Hydrocarbon Doser Coolant Lines
1210-14
Service Bulletin/Repair Instructions
1210-14 Cylinder Head
1207-15
Service Bulletin/Repair Instructions
1207-15 Updated procedures with adding EPA10 to the GHG14 title
1205-15
Service Bulletin/Repair Instructions
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
15TL24
Service Bulletin/Repair Instructions
15TL24 OTC 1750 Revolver Engine Stand
15TS4
Service Bulletin/Repair Instructions
15TS4_Rev2_ EPA07 DD15 Piston Kits
1202-15
Service Bulletin/Repair Instructions
1202-15 Symptom Diagnostics - ATD Checklist
15TS16
Service Bulletin/Repair Instructions
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1201-15
Service Bulletin/Repair Instructions
1201-15 Crankshaft and Bearings
18SP729
Service Bulletin/Repair Instructions
18SP729 ? EPA07 10 Three-Filter Fuel
18SP730
Service Bulletin/Repair Instructions
18SP730 ? EPA07 10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
15TL20
Service Bulletin/Repair Instructions
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
15-028
Service Bulletin/Repair Instructions
_NewDetroitCoolantLineSRTs
15-028A
Service Bulletin/Repair Instructions
15-028 New Detroit Coolant Line SRTs
15-029
Service Bulletin/Repair Instructions
_Warranty Recognition Program - Coming Soon
711-15
Service Bulletin/Repair Instructions
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
15TS14 GHG14
Service Bulletin/Repair Instructions
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15
Service Bulletin/Repair Instructions
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
706-15
Service Bulletin/Repair Instructions
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
sb54278
Service Bulletin/Repair Instructions
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sb54292
Service Bulletin/Repair Instructions
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
15-017
Service Bulletin/Repair Instructions
15-017 Detroit: Updated Fuel Injector SDTs
511-15
Service Bulletin/Repair Instructions
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
509-15
Service Bulletin/Repair Instructions
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
507-15
Service Bulletin/Repair Instructions
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
15-015
Service Bulletin/Repair Instructions
15-015 Warranty Exclusions Reminder
15-016
Service Bulletin/Repair Instructions
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15CSA10
Service Bulletin/Repair Instructions
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
Service Bulletin/Repair Instructions
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
Service Bulletin/Repair Instructions
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
Service Bulletin/Repair Instructions
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
Service Bulletin/Repair Instructions
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
15TL6
Service Bulletin/Repair Instructions
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
sb3133
Service Bulletin/Repair Instructions
sb3133 Step Clamps Are Not Reusable
15-010
Service Bulletin/Repair Instructions
15-010-DLR Transmission Cooler Line Photos
15TS9
Service Bulletin/Repair Instructions
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
15-009 - Detroit
Service Bulletin/Repair Instructions
15-009_Detroit_New_SDTs
15TL5
Service Bulletin/Repair Instructions
15TL5 DAVCO Shop Pro® FXP 95
307-15
Service Bulletin/Repair Instructions
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
15TL4
Service Bulletin/Repair Instructions
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
18SP712
Service Bulletin/Repair Instructions
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
sb01101
Service Bulletin/Repair Instructions
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
15TS8
Service Bulletin/Repair Instructions
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
15TS6
Service Bulletin/Repair Instructions
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
15TS5
Service Bulletin/Repair Instructions
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
0202-15
Service Bulletin/Repair Instructions
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
15TS2
Service Bulletin/Repair Instructions
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1
Service Bulletin/Repair Instructions
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder Misfire At Idle
0104-15
Service Bulletin/Repair Instructions
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
18SP687
Service Bulletin/Repair Instructions
18SP687 DD15 16 EGR Actuator Replacement
sb9815
Service Bulletin/Repair Instructions
sb9815 Paint Finish Standards
1108-14
Service Bulletin/Repair Instructions
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
1105-14
Service Bulletin/Repair Instructions
1105-14 Flywheel, Ring Gear and Flywheel Housing
1104-14
Service Bulletin/Repair Instructions
1104-14 Metal in the Fuel System
1102-14
Service Bulletin/Repair Instructions
1102-14 DD13 Cylinder Head R&R
18SP707
Service Bulletin/Repair Instructions
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
18SP708
Service Bulletin/Repair Instructions
18SP708Rev EPA07 10 Three-Filter Fuel
14TL8
Service Bulletin/Repair Instructions
14TL8 TorcUP? Non-Impacting Torque Tool.
14-036
Service Bulletin/Repair Instructions
14-036-DLR DTNA & JAD Highlights - Q3
14-038
Service Bulletin/Repair Instructions
14-038 Additional Detroit Standard Repair Times
14-038A
Service Bulletin/Repair Instructions
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
Service Bulletin/Repair Instructions
14-039 New Detroit Standard Diagnostic Times
14-039A
Service Bulletin/Repair Instructions
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
Service Bulletin/Repair Instructions
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
Service Bulletin/Repair Instructions
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
Service Bulletin/Repair Instructions
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
Service Bulletin/Repair Instructions
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
Service Bulletin/Repair Instructions
14TL9 Special Tool Warranty Program.
14TS30
Service Bulletin/Repair Instructions
14TS30 Aftertreatment Harness Diagnostics
14TL7
Service Bulletin/Repair Instructions
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
Service Bulletin/Repair Instructions
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
1010-14
Service Bulletin/Repair Instructions
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
Service Bulletin/Repair Instructions
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
Service Bulletin/Repair Instructions
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
Service Bulletin/Repair Instructions
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
14TS28
Service Bulletin/Repair Instructions
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1007-14
Service Bulletin/Repair Instructions
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
Service Bulletin/Repair Instructions
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
Service Bulletin/Repair Instructions
1005-14 Oil Coolant Module
1003-14
Service Bulletin/Repair Instructions
1003-14 Rough Running or Stalling.
18SP684REV4
Service Bulletin/Repair Instructions
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
Service Bulletin/Repair Instructions
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
Service Bulletin/Repair Instructions
sb2080 Australian CST M1400 Isolated Radiator Retrofit
920-14
Service Bulletin/Repair Instructions
920-14 Additional Cleaning and Preparing
14TS26
Service Bulletin/Repair Instructions
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
917-14
Service Bulletin/Repair Instructions
917-14 Installation and Removal of the Oil Filter Stand Pipe
916-14
Service Bulletin/Repair Instructions
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
913-14
Service Bulletin/Repair Instructions
913-14 Checking for Poor Engine Brake Performance
912-14
Service Bulletin/Repair Instructions
912-14 Coolant in Oil
910-14
Service Bulletin/Repair Instructions
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
909-14
Service Bulletin/Repair Instructions
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
905-14
Service Bulletin/Repair Instructions
905-14 Coolant Level Circuit Failed
18SP706
Service Bulletin/Repair Instructions
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
14TS21
Service Bulletin/Repair Instructions
14TS21 HDEP Camshaft Position Sensor Change
812-14
Service Bulletin/Repair Instructions
812-14 FMI 3, 4: Engine Aux. Shutdown Input Failed High and Low
14-017R
Service Bulletin/Repair Instructions
14-017R Revised: Detroit Addition of Admin Time
811-14
Service Bulletin/Repair Instructions
811-14 FMI 7: Internal Error with the DT12 Shift Stalk Lever
809-14
Service Bulletin/Repair Instructions
809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed
807-14
Service Bulletin/Repair Instructions
807-14 FMI 8 SCR Inlet Temperature Signal Spike
14-029
Service Bulletin/Repair Instructions
14-029 New Detroit Standard Diagnostic Times
804-14
Service Bulletin/Repair Instructions
804-14 FMI 16, 18 Intake Manifold Pressure Too high and low (Restricted Mode)
803-14
Service Bulletin/Repair Instructions
803-14 FMI 16,18: Intake Manifold Pressure Too High and Low
802-14
Service Bulletin/Repair Instructions
802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low
18SP703
Service Bulletin/Repair Instructions
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
54-268
Service Bulletin/Repair Instructions
54-268 - Coronado Virtual Technician Retrofit
801-14
Service Bulletin/Repair Instructions
801-14 FMI 19: RCM Message Not Received or Stopped Arriving
14TL2
Service Bulletin/Repair Instructions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
Service Bulletin/Repair Instructions
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
Service Bulletin/Repair Instructions
14-028 Remy Extended Coverage Direct File
14TS18
Service Bulletin/Repair Instructions
14TS18 GHG14 DD Engine EGR System Fault Code
14TS19
Service Bulletin/Repair Instructions
14TS19 DD Platform High Pressure Fuel Lines
14-027
Service Bulletin/Repair Instructions
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
Service Bulletin/Repair Instructions
14-026-DLR SelecTruck Warranty Enhancements
719-14
Service Bulletin/Repair Instructions
719-14 SPN 84 (CPC) (GHG14)
715-14
Service Bulletin/Repair Instructions
715-14 Symptom Diagnostics - Coolant Los
14-022
Service Bulletin/Repair Instructions
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
Service Bulletin/Repair Instructions
14-023 Detroit Axles Pre-Approval Changes
14-024
Service Bulletin/Repair Instructions
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
Service Bulletin/Repair Instructions
714-14 Symptom Diagnostics - Low Engine Compression
713-14
Service Bulletin/Repair Instructions
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
Service Bulletin/Repair Instructions
712-14 Engine Coolant Temperature
711-14
Service Bulletin/Repair Instructions
711-14 SPN 107 (CPC) (GHG14
710-14
Service Bulletin/Repair Instructions
710-14 SPN 96 (CPC) (GHG14)
709-14
Service Bulletin/Repair Instructions
709-14 SPN 3216 (MCM) (GHG14)
708-14
Service Bulletin/Repair Instructions
708-14 SPN 520219 (IPPC) (GHG14)
707-14
Service Bulletin/Repair Instructions
707-14 SPN 520229 FMI 3 (IPPC) (GHG14
706-14
Service Bulletin/Repair Instructions
706-14 SPN 171 FMI 3, 4 (CPC)(GHG14)
705-14
Service Bulletin/Repair Instructions
705-14 SPN 520203 FMI 6 (IPPC)(GHG14)
704-14
Service Bulletin/Repair Instructions
704-14 SPN 520200 FMI 6 (IPPC)(GHG14)
703-14
Service Bulletin/Repair Instructions
703-14 SPN 3556 (ACM) (EPA10)
702-14
Service Bulletin/Repair Instructions
702-14 SPN 520230FMI 5 (IPPC)(GHG14)
18SP701
Service Bulletin/Repair Instructions
18SP701Rev2 18SP701Rev2? GHG14 Two-Filter Fuel System
18SP709
Service Bulletin/Repair Instructions
18SP709Rev 18SP709Rev ? EPA10/GHG14 Two-Filter Fuel
18SP710
Service Bulletin/Repair Instructions
18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel
20-73
Service Bulletin/Repair Instructions
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75
Service Bulletin/Repair Instructions
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
54-215
Service Bulletin/Repair Instructions
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
54-285
Service Bulletin/Repair Instructions
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
701-14
Service Bulletin/Repair Instructions
701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14
512-14
Service Bulletin/Repair Instructions
512-14 FMI 0: DPF Outlet Temperature Very High
18SP684
Service Bulletin/Repair Instructions
18SP684Rev3 EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
sb4930
Service Bulletin/Repair Instructions
sb4930 49-30 - Gentech DEF Coolant-Flow Solenoid, Testing and Replacement
14TS5
Service Bulletin/Repair Instructions
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
0228-14
Service Bulletin/Repair Instructions
0228-14 Engine Oil Leaks - Oil Dye Method
14TS4
Service Bulletin/Repair Instructions
14TS4 Valve and Liner Installation Tool Issue
13wo3re
Service Bulletin/Repair Instructions
13wo3rev2_final Actual Labor Hours on Detroit Claims
0224-14
Service Bulletin/Repair Instructions
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0219-14
Service Bulletin/Repair Instructions
0219-14 Metal in Fuel
0215-14
Service Bulletin/Repair Instructions
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0210-14
Service Bulletin/Repair Instructions
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14
Service Bulletin/Repair Instructions
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0202-14
Service Bulletin/Repair Instructions
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0229-14
Service Bulletin/Repair Instructions
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14
Service Bulletin/Repair Instructions
0233-14 SPN 51 FMI 2 - All Years
0237-14
Service Bulletin/Repair Instructions
0237-14 Engine Brake Solenoid
0238-14
Service Bulletin/Repair Instructions
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
Service Bulletin/Repair Instructions
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
SB4934
Service Bulletin/Repair Instructions
DEF Tank Coolant Valve O-Ring Kit
FSB-20-72
Service Bulletin/Repair Instructions
FREIGHTLINER: A POSSIBLE RADIATOR FAILURE RESULTING IN COOLANT LEAKAGE DUE TO A CRACK LOCATED IN COOLANT TUBE AND WOULD NEED AN UPDATED ISOLATED ENGINE MOUNT, IF NECESSARY. *PE
13TS22
Service Bulletin/Repair Instructions
Rev DD Platform Fuel Injector Cup Seal
13M2
Service Bulletin/Repair Instructions
13m2 -Final-23-SEP-2013 Field Service Campaign 13M2
13M2-02
Service Bulletin/Repair Instructions
13m2- Equipment Owner Field Service Campaign - 13M2
33-28
Service Bulletin/Repair Instructions
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30
Service Bulletin/Repair Instructions
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
54-274
Service Bulletin/Repair Instructions
54-274 - Plastic Battery Box Cover Retainer Clip
54-277
Service Bulletin/Repair Instructions
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
54-278
Service Bulletin/Repair Instructions
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
13TS-24
Service Bulletin/Repair Instructions
13TS-24 DD Platform High Pressure Fuel Lines
18SP697
Service Bulletin/Repair Instructions
18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935
18SP698
Service Bulletin/Repair Instructions
18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932
603-13
Service Bulletin/Repair Instructions
603-13 SPN 84 -FMI 6 - EPA07-GHG14
18SP694
Service Bulletin/Repair Instructions
18SP694 EPA07 DD Platform High Pressure Fuel Flange Service Kit (P-N- A4720785844)
sb4932
Service Bulletin/Repair Instructions
sb4932 DEF Gauge Reading Incorrectly
sb54215
Service Bulletin/Repair Instructions
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
307-13
Service Bulletin/Repair Instructions
307-13 SPN 652-FMI 14 - EPA07
13TS6
Service Bulletin/Repair Instructions
13TS6 DD Platform Engine Oil Filter.pdf
13TS5
Service Bulletin/Repair Instructions
13TS5 DD Platform Fuel Filter Module
207-13
Service Bulletin/Repair Instructions
207-13 Removal and Installation of the Camshaft Housing
13WO-2
Service Bulletin/Repair Instructions
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
18SP693
Service Bulletin/Repair Instructions
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
12-039
Service Bulletin/Repair Instructions
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
Service Bulletin/Repair Instructions
12-040-DLR Roof Fairing Removal Program
12-041
Service Bulletin/Repair Instructions
12-041-DLR Over the Counter No Hassle Warranty (OTC)
12-038
Service Bulletin/Repair Instructions
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
PAB053
Service Bulletin/Repair Instructions
PAB053, USA-ONLY GM CHASSIS PRICE INCREASE
Body SRT
Service Bulletin/Repair Instructions
Body SRT Updates -2012.12.12
SB42-68
Service Bulletin/Repair Instructions
FREIGHTLINER: BRAKE S-CAM TUBE LUBRICATION INTERVAL CHANGE. TO ENSURE OPTIMUM SERVICE LIFE AND TROUBLE-FREE OPERATION, THE RECOMMENDED MAINTENANCE INTERVAL FOR LUBRICATING MERITOR S-CAM BRAKE TUBES ON CENTURY CLASS, COLUMBIA, CASCADIA AND CORONADO OVER-THE-ROAD VEHICLES IS CHANGED FROM M2 TO THE M1 MAINTENANCE INTERVAL. *JS
sb4268
Service Bulletin/Repair Instructions
sb4268 Brake S-Cam Tube Lubrication Interval Change
sb4724
Service Bulletin/Repair Instructions
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
sb3131
Service Bulletin/Repair Instructions
sb3131 Huck-Spin 2 Changeover
12-022
Service Bulletin/Repair Instructions
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
GI-46-41
Service Bulletin/Repair Instructions
FREIGHTLINER: ADJUSTING THE CORRECT TILT LOCK FORCE ON TRW STEERING COLUMNS. *PE UPDATED 7/18/12. *PE
FSB-49-33
Service Bulletin/Repair Instructions
FREIGHTLINER: EXCESSIVE WHITE CRYSTAL OR POWDER AROUND DEF FITTING, CAUSED BY EVAPORATION OF DEF WHEN EXPOSED TO AIR AND/OR DAMPNESS, INDICATES A LEAK IN DIESEL EXHAUST FLUID OR IMPROPER INSTALLATION OR DAMAGED CONNECTORS WOULD HAVE LEAKS IN COOLANT LINES. *PE
SB-49-28
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: THERE ARE NEW CGI BELLOWS, BECAUSE THE OLD ONES ARE PRONE TO FATIGUE AND MAY FAIL. *RM UPDATED 4/24/12. *PE
RC-FL-609A
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN TRUCKS, A DEFECT REGARDING THE RUBBER ISOLATOR, WITH A BOLT ATTACHMENT, THE SUPPORT BRACKET MAY LOOSEN AND BACK OUT, CAUSING SHORT CIRCUIT BETWEEN CHASSIS AND UN FUSED STARTED CABLE. *PE
SB-35-25
Service Bulletin/Repair Instructions
FREIGHTLINER: PROCEDURE OF REMOVING A LOWER PINION COVER IN THE REAR AXLES AND HOW TO RESEAL IT. *RM
SB-35-26
Service Bulletin/Repair Instructions
FREIGHTLINER: INFORMATION ON LUBRICATING THE WHEEL BEARINGS OF THE REAR DRIVE AXLES. *RM
SB-54-205
Service Bulletin/Repair Instructions
FREIGHTLINER: SOMETIMES THE IDLE INTERMITTENTLY FAILS TO START THE VEHICLE DUE TO A SENSITIVE VEHICLE SPEED SENSOR. *RM
SB-49-29
Service Bulletin/Repair Instructions
FREIGHTLINER LLC: ON VEHICLES WITH A FUEL TANK COVER INSTALLED THERE MAY BE COVER MOUNTING FASTENERS THAT ARE TOO LONG. THEY MAY DIG INTO THE TANK. *RM
SB-72-37
Service Bulletin/Repair Instructions
FREIGHTLINER LLC: THE EXTERIOR DOOR HANDLES MAY SHOW SIGNS OF BINDING AFTER TIME. *RM
F-SB-54-222
Service Bulletin/Repair Instructions
FREIGHTLINER: MEGA FUSE BREAKAGE. THE FUSES IN THE MEGA FUSE JUNCTION BLOCK MAY BREAK DUE TO PHYSICAL STRESS COUPLED WITH VEHICLE VIBRATIONS FROM ROAD AND DRIVETRAIN FORCES. WOULD RESULT IN SUDDEN OR INTERMITTENT ENGINE LOSS OR ELECTRICAL POWER. *PE UPDATED 5/13/11. *PE
ICI-10-025
Service Bulletin/Repair Instructions
DAIMLER TRUCKS: THE 294 BOLT IS DEEMED SERVICEABLE AND THERE IS A PROCEDURE FOR REPLACING IT. *RM
SB83133
Service Bulletin/Repair Instructions
New H02 and H03 A/C lines.
SB-46-48
Service Bulletin/Repair Instructions
FREIGHTLINER: TRW TAS85 STEERING GEAR INTERNAL LEAKAGE TEST. SOME TRW TAS85 STEERING GEARS HAVE BEEN EQUIPPED WITH AN INTERNAL RELIEF VALVE. THESE STEERING GEARS ARE TYPICALLY INSTALLED WITH POWER STEERING PUMPS THAT HAVE A PRESSURE RELIEF RATING GREATER THAN 2175 PSI (150 BAR). THE INTERNAL RELIEF VALVE LIMITS MAXIMUM SUPPLY PRESSURE TO PROTECT THE STEERING GEAR. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, COLUMBIA, CORONADO, BUSINESS CLASS M2 AND CASCADIA. NO MODEL YEARS LISTED. *PE
SF-398A-F
Service Bulletin/Repair Instructions
FREIGHTLINER: SOME VEHICLES MAY HAVE BEEN BUILT WITH CLAMPS USED TO CONNECT THE CLEAN GAS INDUCTION (CGI) PLUMBING THAT MAY NOT PROVIDE AN ADEQUATE SEAL, ALLOWING UNFILTER AIR INTO THE SYSTEM. THE CLAMPS WILL BE REPLACED. *PE
30-12
Service Bulletin/Repair Instructions
LACK OF ENGINE POWER AND THROTTLE PEDAL TRAVEL. *PE UPDATED 9/30/08. *PE
SF389A
Service Bulletin/Repair Instructions
FREIGHTLINER SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DETROIT DIESEL SERIES 60 EXHAUST BELLOWS - MODELS AFFECTED: SPECIFIC FREIGHTLINER CASCADIA, CENTURY CLASS S/T, COLUMBIA, AND CORONADO VEHICLES MANUFACTURED BETWEEN SEPT. 20, 2006 AND NOV. 14, 2007, WITH DETROIT DIESEL SERIES 60 ENGINES. CSC WAS RECEIVED. *NJ
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.