Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
25-BD-012H TSB
Service Bulletin/Repair Instructions
This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.
24-BD-001H
Service Bulletin/Repair Instructions
This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.
23-EM-005H
Service Bulletin/Repair Instructions
This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
23-BD-007H
Service Bulletin/Repair Instructions
Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
23-BD-002H
Service Bulletin/Repair Instructions
This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.
22-EM-010H
Service Bulletin/Repair Instructions
Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.
22-GI-006H
Service Bulletin/Repair Instructions
Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. This limit is the lesser of 1.5% of GVWR or 100 pounds. If the total added weight exceeds the lesser of the limit, a label must be added to the driver-side B-pillar within 25mm (1 inch) of the original tire placard.
21-AT-006H
Service Bulletin/Repair Instructions
Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicleâÂÂs ownerâÂÂs manual. ï· Use of other ATF may result in improper shift quality or other drivability conditions. ï· Use of other DCT and IVT gear oil may result in reduced durability. Hyundai does not approve the use of any aftermarket ATF or gear oil additives.
21-EM-004H
Service Bulletin/Repair Instructions
This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps.
21-BR-002H
Service Bulletin/Repair Instructions
This bulletin provides best practice recommendations when performing brake service procedures.
21-EM-003H
Service Bulletin/Repair Instructions
This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
20-BR-002H
Service Bulletin/Repair Instructions
This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.
20-SS-004H
Service Bulletin/Repair Instructions
This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the âTire Balance Data Sheetâ must be fully completed including imbalance and Road Force Variation (RFV) data. The Data Sheet can be found at the end of this bulletin.
20-BD-014H
Service Bulletin/Repair Instructions
This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes, or during normal driving operation.
20-SS-002H(1)
Service Bulletin/Repair Instructions
This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.
20-BD-007H-1
Service Bulletin/Repair Instructions
This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products.
20-EE-003H
Service Bulletin/Repair Instructions
This bulletin provides information on identifying dealer stock vehicles with either: ⢠A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. ⢠A 30 Day alert - vehicle has not started and reported an SOC in 30 days.
20-AT-016H
Service Bulletin/Repair Instructions
The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:
20-BD-007H
Service Bulletin/Repair Instructions
This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products.
20-SS-001H
Service Bulletin/Repair Instructions
This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years.
20-BE-001H
Service Bulletin/Repair Instructions
This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. This bulletin provides physical differences between the USB 2.0 port and USB 3.0 port.
19-BE-011H-1
Service Bulletin/Repair Instructions
The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects vehicles within the blind spot zone and gives off an alarm (visual and audible). The two magnetic radar sensors provide these functions for BSD/BCW: ? Senses other vehicles in the BSD/BCW zone and turns on the BSD/BCW warning lamp for the driver. The warning lamp starts blinking, along with an audible sound, when the driver turns on the turn signal lamp to enter the lane where another vehicle is driving.
19-GI-006H
Service Bulletin/Repair Instructions
This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and matched with a Techline Case number.
DOR-T5K8Y-01
Service Bulletin/Repair Instructions
This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causing loss of power steering assist and electrical system charging.
DOR-Y5Q6Z-01
Service Bulletin/Repair Instructions
This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causing loss of power steering assist and electrical system charging.
5NP-S9D9P-10
Service Bulletin/Repair Instructions
THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT).
TSB-11-BR-002
Service Bulletin/Repair Instructions
HYUNDAI: ALL SONATA HYBRIDS. BRAKE BLEEDING PROCEDURE. *RM
TSB-09-AT-018
Service Bulletin/Repair Instructions
HYUNDAI: ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0746, P0748, P0750, P0755, P0760, P0765, P0770. INCORRECT OPERATION OF THE TRANSAXLE SOLENOIDS MAY RESULT IN THE FOLLOWING SYMPTOMS-CHECK ENGINE LIGHT ILLUMINATED; TRANSAXLE HELD IN 3RD GEAR FAIL SAFE. *PE
TSB-09-AT-013
Service Bulletin/Repair Instructions
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OPERATING RANGE SWITCH MAY RESULT IN THE ABOVE MENTIONED CONDITIONS. MALFUNCTION INDICATOR LIGHT (MIL) ILLUMINATED; IMPOSSIBLE ENGINE START IN P OR N. *PE
0636006
Service Bulletin/Repair Instructions
EXHAUST GAS RECIRCULATION (EGR) SYSTEM DIAGNOSIS. *KB
0640018
Service Bulletin/Repair Instructions
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES (DTC) LIST. *KB
0650003
Service Bulletin/Repair Instructions
ABS PUMP SELF-CHECK NOISE. *TT
0540008
Service Bulletin/Repair Instructions
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *SC
01011901
Service Bulletin/Repair Instructions
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *NM
0550004
Service Bulletin/Repair Instructions
ABS PUMP SELF CHECK NOISE. ALSO INCLUDED: 2003-2005 MODEL XG AND 1999, 2000, 2001, 2003, 2004 AND 2005 MODEL SANTA FE. *SC
0497002
Service Bulletin/Repair Instructions
FD46XG PAG OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *TT
0804
Service Bulletin/Repair Instructions
FD46XG POLY ALKYLEN GLYCOL (PAG) OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *NM
0436006
Service Bulletin/Repair Instructions
UNSTABLE IDLE (SIMPLE DIAGNOSIS PROCEDURE FOR INTERMITTENTLY STUCK CLOSED EGR SOLENOID VALVE). *TT
0450006
Service Bulletin/Repair Instructions
ANTI-LOCK BRAKING SYSTEM (ABS)TCS ACTIVATION MAY RESULT FROM UNDERINFLATED COMPACT SPARE TIRE. *TT
03010112
Service Bulletin/Repair Instructions
2.5/2.7L V6 ENGINE TITANIUM O2 SENSORS (CAMPAIGN V01) - REVISED TSB VERSION 2. *TT
03010111
Service Bulletin/Repair Instructions
2.5/2.7L V6 ENGINE TITANIUM O2 SENSORS (CAMPAIGN V01) - REVISED TSB. *TT
0336024
Service Bulletin/Repair Instructions
RESISTANCE VALUES FOR IDLE SPEED CONTROL ACTUATOR (ISCA). VARIOUS MODELS INCLUDING THE 2004 SONATA. *TT
0336019
Service Bulletin/Repair Instructions
ECM (ENGINE CONTROL MODULE) REPROGRAMMING FOR ENGINE HESITATION IN THE MORNING AND DIAGNOSTIC TROUBLE CODE P0139. *TT
0340014
Service Bulletin/Repair Instructions
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODE (DTC) P1723 ACCOMPANIED WITH MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED; TRANSAXLE HELD IN 2RD GEAR FAIL-SAFE; HARSH SHIFTS INTO REVERSE OR DRIVE. *TT
0340006
Service Bulletin/Repair Instructions
ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0750, P0755, P0760, P0765, P0770. *TT
133
Service Bulletin/Repair Instructions
THIRD GEAR FAIL-SAFE INFORMATION. *TT
02360221
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE ENGINE RPM FLUCTUATION - CRUISE CONTROL CABLE ADJUSTMENT PROCEDURE. *TT
0236037
Service Bulletin/Repair Instructions
ECM (ENGINE CONTROL MODULE) REPROGRAMMING FOR ENGINE HESITATION IN THE MORNING AND DIAGNOSTIC TROUBLE CODE P0139. *TT
0240026
Service Bulletin/Repair Instructions
ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0743, P0750, P0755, P0760, P0765, P0770. *TT
0236027
Service Bulletin/Repair Instructions
VERY BRIEF, SLIGHT HEADLAMP DIMMING CONDITION. *TT
0240024
Service Bulletin/Repair Instructions
IMPROVED CLUTCH RELEASE SHAFT UPPER AND LOWER BUSHING. *TT
0280001
Service Bulletin/Repair Instructions
A CONDITION MAY EXIST WHERE THE FRONT DOOR GLASS DOES NOT RAISE PROPERLY OR WILL NOT STAY FULLY CLOSED AND / OR DOES NOT LOWER PROPERLY. *TT
0236022
Service Bulletin/Repair Instructions
SUBJECT REGARDING ENGINE RPM FLUCTUATION - CRUISE CONTROL CABLE ADJUSTMENT PROCEDURE. *JG
0240019
Service Bulletin/Repair Instructions
SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. *JG
0250012
Service Bulletin/Repair Instructions
THIS BULLETIN INVOLVES INFORMATION RELATING TO A CHANGE IN THE REAR DRUM BRAKES TO REDUCE BRAKE SQUEAL/SQUEAK NOISE. *JG
0290009
Service Bulletin/Repair Instructions
SUBJECT REGARDING DIAGNOSTIC GUIDE FOR CLIFFORD AND DEI SECURITY SYSTEM. *JG
200502
Service Bulletin/Repair Instructions
SUBJECT REGARDING SIDE IMPACT AIR BAG WIRE HARNESS ROUTING. *JG
0201005
Service Bulletin/Repair Instructions
SUBJECT REGARDING SIDE IMPACT AIR BAG WIRE HARNESS ROUTING CAMPAIGN. *JG
0250007
Service Bulletin/Repair Instructions
SUBJECT REGARDING REAR STABILIZER BAR BUSHING REPLACEMENT-NOISE REPAIR PROCEDURE. *JG
0236010
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE CHECK ENGINE LIGHT ILLUMINATION OR DIAGNOSTIC TROUBLE CODES P0133, P0134, P1134, P0153, P0154, OR P1154. *SLC
0240011
Service Bulletin/Repair Instructions
INFORMATION REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH
122
Service Bulletin/Repair Instructions
SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK-REVERSE OR PARK-DRIVE ENGAGEMENT. *SLC
0240008
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE A HARSH OR DELAYED PARK-REVERSE OR PARK-DRIVE ENGAGEMENT IN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. *SLC
0136026
Service Bulletin/Repair Instructions
SUBJECT REGARDING V6 NITROGEN OXIDE NOX DIAGNOSIS. *JG
01200021
Service Bulletin/Repair Instructions
SUBJECT REGARDING ENGINE RUNS ROUGH, IDLES ROUGH, DTC P0335. *YD
0140022
Service Bulletin/Repair Instructions
SUBJECT REGARDING SHIFTLOCK AND KEY LOCK CABLE ADJUSTMENT FOR VEHICLES WITH SPORT SHIFT. *SLC
117
Service Bulletin/Repair Instructions
INFORMATION ON EXHAUST GAS RECIRCULATION. *SLC
24092001
Service Bulletin/Repair Instructions
INFORMATION REGARDING NOISE FROM REAR WHEELSD ,PARKING BRAKE ADJUSTMENT. *YD
0136021
Service Bulletin/Repair Instructions
SUBJECT REGARDING EXHAUST GAS RECIRCULATION (EGR) SYSTEM DIAGNOSIS. *TT
0136009
Service Bulletin/Repair Instructions
INFORMATION REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH
01360091
Service Bulletin/Repair Instructions
SUBJECT REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH
0136016
Service Bulletin/Repair Instructions
SUBJECT REGARDING ECM NON-INTERCHANGEABILITY. *YH
061201
Service Bulletin/Repair Instructions
INFORMATION REGARDING SECURITY SYSTEM UPGRADE. *YH
061101
Service Bulletin/Repair Instructions
SUBJECT REGARDING FINAL DRIVE GEAR WHINE NOISE. *YH
01500041
Service Bulletin/Repair Instructions
SUBJECT REGARDING NOISE FROM REAR WHEELS. *YH
0190007
Service Bulletin/Repair Instructions
SUBJECT REGARDING SECURITY UPGRADE DOOR LOCK LEARN PROCEDURE. *YH
042501
Service Bulletin/Repair Instructions
INFORMATION REGARDING MISSING 5 AMP FUSE FROM SECURITY UPGRADE KITS. *YH
010101
Service Bulletin/Repair Instructions
INFORMATION ON THE ACUOSTIC WARNING SYSTEM. *TT
231000
Service Bulletin/Repair Instructions
HYUNDAI MOTOR AMERICA IS CONDUCTING A VOLUNTARY CUSTOMER NOTIFICATION (TRANSMISSION CONTROL MODULE (TCM) REPROGRAMMING) RECALL CAMPAIGN ON CERTAIN VEHICLES EQUIPPED WITH 2.4 LITER ENGINES AND AUTOMATIC TRANSMISSIONS WITH PRODUCTION DATES BETWEEN JUNE 22, 2000 AND AUGUST 29, 2000 INCLUSIVE. *TT
201000
Service Bulletin/Repair Instructions
HYUNDAI MOTOR AMERICA IS CONDUCTING A VOLUNTARY CUSTOMER NOTIFICATION (RECALL CAMPAIGN) WHICH INVOLVES REPROGRAMMING THE TRANSMISSION CONTROL MODULE (TCM). *TT
0002007
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 2.4L DOHC ENGINES AND AUTOMATIC TRANSAXLES WERE PRODUCED WITH TRANSAXLE CONTROL MODULES (TCM) THAT DO NOT PROPERLY DIAGNOSE AND DISPLAY DIAGNOSTIC TROUBLE CODES (DTC) FOR SOME FUNCTIONS. *TT
0040014
Service Bulletin/Repair Instructions
INFORMATION ON DIAGNOSING TRANSAXLE DIAGNOSTIC TROUBLE CODES. *TT
0140023
Service Bulletin/Repair Instructions
SUBJECT REGARDING AUTOMATIC TRANSAXLE OIL DRAIN PLUG. *YD