Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
IB13-R-001G
This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). The Exchange Program must be used when any Alpine radio or other component covered by this bulletin is repaired under warranty and may also be used for radio and component repairs not covered under warranty. Contact Alpine directly for pricing and payment methods applicable to radio and component repairs not covered under warranty.
WB13-X-001B
Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback. This bulletin was revised to add a Parts Warranty Form
WB13-X-001A
Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback.
IB09-X-002B
The following is a list of the Isuzu-recommended Threebond product part numbers identified in the various Isuzu Workshop Manuals and bulletins. If a Threebond product is unavailable, we recommend that you utilize the chart below to find equivalent of similar products (when available) from Loctite and Permatex.
IB09-X-004C
The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic support to Isuzu dealer technicians repairing Isuzu vehicles in and out of vehicle warranty. A TAC case number will be issued solely for information tracking purposes and future contact reference.
05-06-04-035D
This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.
0709002
REAR BRAKE ROTORS. *KB
0505004
SHIFT LOCK SOLENOID REMOVAL AND REPLACEMENT PROCEDURES. *TT 2002-2004 ISUZU AXIOM (UP), 198-2004 RODEO (UE) AND 1998-2004 RODEO SPORT. UPDATE *SC
0304S003
IGNITION SWITCH DOES NOT TURN TO THE LOCK POSITION AND THE IGNITION KEY CANNOT BE REMOVED. *TT
0311S004
POOR AND/OR LOOSE DOOR WEATHERSTRIP POSITION. *TT
0309S001C
ABS (ANTI-LOCKING BRAKE) SYSTEM, COIL INTEGRATED MODULE REPLACEMENT PHASE 3 ANNOUNCEMENT. *TT
0301S002
THROTTLE BODY MOUNTING BOLT TORQUE SPECIFICATIONS. *TT
0305S001
TRANSMISSION INDICATOR LIGHT MAY BE ON AND DIAGNOSTIC TROUBLE CODE P1870 IS SET IN THE POWERTRAIN CONTROL MODULE (PCM). *TT
0309S001B
ABS (ANTI-LOCK BRAKE SYSTEM), COIL INTEGRATED MODULE REPLACEMENT SAFETY IMPROVEMENT CAMPAIGN. *TT
0309S001A
ABS (ANTI-LOCK BRAKE SYSTEM), COIL INTEGRATED MODULE REPLACEMENT SAFETY IMPROVEMENT CAMPAIGN 02I-002. *TT
0205S003
TRANSMISSION INDICATOR LIGHT MAY BE ON AND DIAGNOSTIC TROUBLE CODE P1870 IS SET IN THE PCM (POWERTRAIN CONTROL MODULE). *TT
0204S003
REPLACEMENT ODOMETER PROGRAMING. *JG
0211S002
REAR STORAGE COMPARTMENT LID LOCK KNOB BROKEN. *JG
0201S003
V-6 FAN CLUTCH REPLACEMENT PROCEDURES. *TT
0208S001
TERMINATION OF TIRE REPLACEMENT PROGRAM. *TT
IB0101S003
SUBJECT REGARDING THE AVAILABILITY OF HEC LONG BLOCK/PARTIAL ENGINE ASSEMBLIES. *SLC
SB0111S006
SOME VEHICLES BUILT PRIOR TO VIN BREAKPOINT 14327313 MAY EXPERIENCE MUD FLAP INTERFERENCE CAUSING A RUBBING SOUND WHEN MAKING A TURN. *TT
IB0101S002
SUBJECT REGARDING HEC ENGINE TIMING BELT SCRAPPING. *TT
IB0109S001
SUBJECT REGARDING DRUM BRAKE ADJUSTMENT PROCEDURE. *TT
SB0105S001
SOME V6 MODELS WITH TRANSMISSION SERIAL NUMBERS 4754596 - 5831756 MAY EXPERIENCE LEAKAGE IN THE AREA OF OVERFILL PLUG AND OIL DRAIN PLUG. *TT
0201S001
MOUNTING POSITION OF SPEEDOMETER DRIVEN GEAR BUSHING WORK SHOP MANUAL REVISION. *JG
SB0108S001
SOME VEHICLES BUILT PRIOR TO VIN BREAKPOINT 14330722 EQUIPPED WITH OEM P215 / 235 15 INCH AND P225 / 245 16 INCH TIRES MAY EXHIBIT A STEERING WHEEL VIBRATION / SHIMMY (NIBBLE) OR BODY VIBRATION THROUGH THE STEERING WHEEL OR FLOORBOARD RESPECTIVELY ON SMOOTH ROAD SURFACE. *TT
IB0104S002
SUBJECT REGARDING P0337 CRANKSHAFT POSITION SENSOR CIRCUIT LOW INPUT CORRECTION. *TT
IB0110S001
INFORMATION REGARDING SECTOR SHAFT ALIGNMENT ON THE STEERING RACK ASSEMBLY. *TT
IB0004S005
THIS BULLETIN PROVIDES INFORMATION ON THE P1640 AND P1650 OUTPUT DRIVE CODES WHICH REFER TO OUTPUT DRIVER CIRCUIT CONDITIONS RELATED TO THE PCM. *TT
IB0004S008
SOME VEHICLES MAY RANDOMLY SET A PCM CODE P0502 IN A DECELERATION MODE USUALLY WITH 0% THROTTLE. THE MALFUNCTION INDICATOR LIGHT WILL ONLY SET AFTER THE FAULT HAS BEEN DETECTED FOR TWO CONSECUTIVE KEY CYCLES. *TT
IB0004S009
SOME VEHICLES THAT HAVE RECENTLY HAD THE ENGINE REPLACED WITH A LONG BLOCK WILL SET CODE P1336 FOR TOOTH ERROR CORRECTION. *TT
SB0008S003
SOME VEHICLES BUILT PRIOR TO VIN BREAKPIONT Y4329627 MAY DEMONSTRATE A REAR WHEEL VIBRATION AT HIGHWAY SPEEDS. *TT
SB0001S005
EXPERIENCING INTERMITTENT ROUGH IDLE AND / OR THE MALFUNCTION INDICATOR LAMP IS ON WITH DIAGNOSTIC TROUBLE CODES P0171, P0174, OR P1171. *TT
SB0004S002
SOME OWNERS MAY COMMENT ON WINDSHIELD WASHER FLUID LEAK. *TT
SB0005S002
CERTAIN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION (SERIAL NUMBER 5504006 - 5570892) MAY EXHIBIT THE MALFUNCTION INDICATOR LAMP ON AND TECH-II INDICATES THE PRESENCE OF TORQUE CONVERTER (DIAGNOSTIC TROUBLE CODE 1870) ON. *TT
IB0004S001
INFORMATION REGARDING ANTI-THEFT CONTROLLER REPLACEMENT. *TT
IB0006S001
SUBJECT REGARDING ALIGNMENT SPECIFICATION CHANGE. *TT
SB0001S003
ON SOME VEHICLES WITHIN VIN Y4300787 / 74400051, THE ENGINE MOUNTS MAY NOT ISOLAT ENGINE VIBRATION. *TT
SB0002S002
SERVICE INFORMATION REGARDING ALL AFFECTED VEHICLES WITH THE P1441 EVAPORATIVE EMISSION CODE THAT HAS BEEN DIAGNOSED WITH NO FAULT FOUND FROM THE APPROPRIATE FLOW CHART IN THE DRIVEABILITY AND EMISSIONS MANUAL. *TT
SB0010S001
SOME OWNERS OF VEHICLES WITHIN VIN 8X4351792 MAY EXHIBIT STEERING WHEEL VIBRATION OR SHIMMY DURING VEHICLE OPERATION AT MEDIUM TO HIGH SPEED. A STEERING NIBBLE MAY BE FELT IN THE STEERING WHEEL WHEN DRIVING ON SMOOTH ROADS AT HIGHWAY SPEEDS. A NIBBLE MAY BE DEFINED AS SLIGHT ROTATIONAL MOVEMENT IN THE STEERING WHEEL. *TT
IB00S005
THIS INFORMATION BULLETIN OUTLINES THE PROPER STEPS TO INDEX THE CAMSHAFTS WITH THE CRANKSHAFT FOR VEHICLES EQUIPPED WITH DIRECT ATTACK DOHC 3.2L / 3.5L V6 ENGINE. IN THE EVENT THAT CAMSHAFT TIMING HAS BEEN DISRUPTED, DUE TO TIMING BELT BREAKAGE OR CAMSHAFTS / CRANKSHAFT BEING ROTATED WITHOUT A TIMING BELT, THIS IS IMPORTANT PRIOR TO TIMING BELT INSTALLATION. *TT
IB00S007
ON SUV VEHICLES WITH AUTOMATIC TRANSMISSIONS, SOME REMOTE STARTER INSTALLATIONS MAY CAUSE THE MALFUNCTION INDICATOR LIGHT TO SET AND STORE P0705. AMERICAN ISUZU MOTORS DOES NOT SELL REMOTE STARTER KITS AND DOES NOT RECOMMEND ANY PARTICULAR INSTALLATION. *TT
IB00S009
SOME AFTERMARKET TINT INSTALLERS MAY SCRATCH THE HEATING ELEMENT (DEFROSTER LINES) OR ETCH THE GLASS (START OF THE BREAK AREA) DURING INSTALLATION, FROM AFFIXING AFTERMARKET FILM TINT MATERIAL TO THE TAILGATE GLASS. *TT
SB0008S002
SOME VEHICLES MAY DEMONSTRATE A BODY VIBRATION AT HIGHWAY SPEEDS. *TT
SB0014S001
AMERICAN ISUZU MOTORS INC. IS PLEASED TO ANNOUNCE THE AVAILABILITY OF TOP TETHER CHILD RESTRAINT SEAT ANCHOR BRACKET KITS FOR CERTAIN ISUZU SPORT UTILITY VEHICLES. THE USE OF THIS ANCHOR BRACKET MAY BE NECESSARY WHEN INSTALLING CERTAIN CHILD SEATS, WHICH REQUIRE ANCHORING TO THE VEHICLE WITH A TOP TETHER STRAP. *TT
SB0002S001
A CONDITION MAY EXIST WHERE THE P1441 EVAPORATIVE EMISSION CODE. *TT
SB0004S001
SOME VEHICLES MAY EXHIBIT ONE OR MORE ABS DIAGNOSTIC TROUBLE CODES SUCH AS: REAR SPEED SENSOR OPEN OR SHORTED; SPEED SENSOR MISSING; WHEEL SPEED INPUT ABNORMALITY. *TT
SB0008S001
SOME VEHICLES MAY DEMONSTRATE A BODY VIBRATION AT HIGHWAY SPEEDS. *TT
SB9912S004
A CONDITION WITH THE AIR CONDITIONING COMPRESSOR EMITTING A MEDIUM PITCH SOUND (MOAN) DURING ENGINE OPERATION AT UP TO 2000 RPM. *TT
SB9909S002
SUBJECT REGARDING 2WD REAR DRUM BRAKE ADJUSTMENT PROCEDURE. *TT
SB9901S002
MAINTENANCE SCHEDULE INFORMATION: TIMING BELT REPLACEMENT INTERVAL AND DOHC V6 VALVE ADJUSTMENT SCHEDULE. *TT
9913S003
INFORMATION ON REAR CUP HOLDER REPLACEMENT. *TT
SB9910S001
SOME CUSTOMERS MAY COMMENT ON THE PRESENCE OF STEERING WHEEL VIBRATION, SHIMMY, OR NIBBLE. *TT
SB9908S001
INFORMATION ON TIRE PRESSURE - WORKSHOP MANUAL REVISIONS. *TT
SB9914S007
INFORMATION REGARDING THE AVAILABILITY OF THE CHILD SEAT TETHER ANCHOR KIT. *TT
SB9907S001
A CONDITION MAY EXIST WHERE EVIDENCE OF LEAKING DIFFERENTIAL LUBRICANT ON THE EXTERIOR SURFACE OF THE REAR AXLE HOUSING, AND REAR BRAKE DUST SHIELD. *TT
SB9914S003
AVAILABILITY OF SUPPLEMENTAL INFORMATION BOOKLET FOR INSTALLING CHILD SAFETY SEATS. *TT
9802L003
INFORMATION ON THE ACCELERATOR PEDAL PAD REPLACEMENT SERVICE CAMPAIGN. *YC
SB9802L002
SOME AFFECTED VEHICLES MAY EXPERIENCE A CONDITION IN WHICH THE INSTRUMENT PANEL FUEL GAUGE READS INACCURATELY. *TT
SB9811L005
A CONDITION MAY EXIST WERE THE DOOR MIRROR(S) HAVE CRACKED AFTER THE REAR WINDOW / DOOR MIRROR DEFOGGER SWITCH WAS TURNED ON. *TT
SB9813L006
A CONDITION MAY EXIST WHERE THE TRAILER LIGHTS WILL ONLY WORK WITH THE KEY EITHER IN THE ON OR ACC POSITION. A SERVICE CAMPAIGN TO INSTALL TRAILER HITCH WIRING SUB HARNESS KIT. *TT
SB9813L007
ON SOME AFFECTED VEHICLES, THE AUDIO SYSTEM MAY BECOME INOPERATIVE OR NOT FULLY FUNCTIONAL, ASSOCIATED WITH NOISES COMING FROM THE SPEAKER(S). *TT
9804L005
ELECTRICAL SYSTEM FAILURE REPORT PROGRAM DISCONTINUED. *YC
9810L002
EXPERIENCING A RUBBING NOISE FROM SRS COIL ASSEMBLY. *YC
SB9813L005
SBJECT REGARDING REAR CUP HOLDER LATCH REPLACEMENT. *TT
9813L004
SERVICE INFORMATION ON REMOTE KEYLESS ENTRY / SECURITY SYSTEM REPROGRAMMING. *YC
SB9804L006
SUBJECT REGARDING ENGINE GROUND WIRE HARNESS REPLACEMENT SAFETY CAMPAIGN. *TT
9801L003
WORKSHOP MANUAL REVISIONS ON FAN BELT INFORMATION. *YC
9801L005
WORKSHP MANUAL REVISIONS ON THE COOLING FAN ASSEMBLY TORQUE SPECIFICATIONS. *YC
9802L001
WORKSHOP MANUAL CORRECTIONS ON FUEL SYSTEM ELECTRICAL TEST DRIVEABILITY AND EMISSIONS. *YC
9803L006
WORKSHOP MANUAL CORRECTIONS REGARDING DRIVEABILITY AND EMISSIONS. *YC
9805L002
WORKSHOP MANUAL REVISIONS ON AUTOMATIC TRANSMISSION (4L30-E). *YC
9809L004
A DESIGN CHANGE TO THE REAR BRAKE SHOES. *YC
9813L001
CONDITION WITH TOP PORTION OF THE RADIATOR GRILLE IS NOT PROTECTED FROM POSSIBLE CONTACT WITH THE ACCESSORY HOOD PROTECTOR. *YC
9813L002
CONDITION WITH THE ACCESSORY HOOD PROTECTOR RATTLES DURING VEHICLE OPERATION. *YC
9811L001
WORKSHOP MANUAL CORRECTIONS. *YC
98040101L001
CONCERNS WITH ENGINE OIL CONTAMINATION. *YC
9804L002
CONDITION WITH BATTERY DISCHARGE. *YC
9809L002
REPLACEMENT OF THE COIL-INTEGRATED MODULE. *YC
9804L004
REMOVAL OF 10 AMP DOME LIGHT FUSE DURING VEHICLE TRANSPORT/DEALER STORAGE. *YC
9711L011
VEHICLE MAY EXPERIENCE STAINING ON THE REAR BUMPER ASSEMBLY PAINT. *YC
9704L007
SERVICE INFORMATION ON ELECTRICAL SYSTEM FAILURE REPORT. *YC
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.