Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
R2118796A
Valve Body. These may cause over drive cycling.
23-014-15
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Vehicles in the following list that are marked **** for the model year are no longer supported with OEM retrofit kits. NOTE: Dealers are encouraged to honor any customers? request for the installation of the Child Seat Tether Anchors and Dealer reimbursement will be made by FCA US LLC regardless of vehicle age or mileage. See the Warranty Policy and Procedure Manual and/or Warranty Bulletin D-08-33 for reimbursement detail.
13-002-14
Towing Capacity For Vehicles Modified With N45 Or N46 Trailer-Hitch Assembly This bulletin specifies the approved tow rating for vehicles not equipped with trailer tow package that have received a trailer-hitch assembly as a result of the N45 or N46 Campaign.
1300214
Towing Capacity For Vehicles Modified With N45 Or N46 Trailer-Hitch Assembly This bulletin specifies the approved tow rating for vehicles not equipped with trailer tow package that have received a trailer-hitch assembly as a result of the N45 or N46 Campaign.
9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
N45062013
Chrysler will offer owners an upgrade to the rear structure of the subject vehicles by the addition of a trailer hitch to better manage the crash forces in low-speed impacts.
23-51-97
CUSTOMER MAY COMPLAI N OF DOOR TRIM PANEL VINYL OR PAINT PEELING. *NLM
22
REPROGRAM PCM AND INSPECT CATALYTIC CONVERTER. *KB
2100903
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
090500
EXPERIENCING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT
0006
INFORMATION REGARDING EXTENDED WARRANTY FOR REFRIGERANT LEAKS IN THE A/C EVAPORATOR COIL ON SUBJECT VEHICLES. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
090699
SUBJECT REGARDING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
021299
THIS BULLETIN PERTAINS TO FRONT END ALIGNMENT - ADJUSTABLE / OFFSET BALL JOINTS. *TT
210899
VEHICLES EXHIBITING BUZZ, WHINING, OR MOANING LIKE NOISE FROM COLD TRANSMISSION WHEN REVERSE GEAR IS SELECTED. *TT
080799
INFORMATION REGARDING POWER DISTRIBUTION CENTER (PDC) SERVICE. *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
184898
SUBJECT REGARDING IGNITION SYSTEM CROSS FIRE/ SECONDARY IGNITION WIRE INDUCTION. *AK
976498
CONDITION WITH ROLLING CODE GARAGE DOOR OPENER. *YC
084498
SUBJECT ON MEMORY POWER SEAT TRAVEL RANGE. *YC
085098
SOME CUSTOMERS MAY EXPERIENCE AN INTERMITTENT CONDITION WHERE THE RADIO STATION OR CD TRACK COULD CHANGE WHEN THE STEERING WHEEL MOUNTED VOLUME SWITCH IS ACTIVATED. *YC
210998
A THUMPING OR CREAKING NOISE MAY BE HEARD COMING FROM THE TRANSMISSION TUNNEL AREA ON ACCELERATION OR WHILE DRIVING OVER BUMPY ROADS. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
081798 REV B
SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES. *YC
182498
SOME VEHICLES MAY EXHIBIT LIGHT SPARK KNOCK WITH A WARM ENGINE UNDER LOAD. *YC
182298
INFORMATION ON THE OBD II MISFIRE MONTIOR. *YC
182198
SERVICE CAUTION ON POWERTRAIN CONTROL MODULE ( PCM ). *YC
140398
SUBJECT ON FUEL PRESSURE GAUGE ADAPTER USAGE. *YC
9821
SPECIFICATIONS AND SERVICE PROCEDURES USED IN THE CURRENT SERVICE MANUALS ARE BEING REVISED TO PROVIDE IMPROVED DIFFERENTIAL BEARING LIFE. *YC
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
181998
SOME VEHICLES MAY EXPERIENCE BUCKING DURING WIDE OPEN THROTTLE (WOT) ACCELERATION. *YC
240298
SERVICE MANUAL PROCEDURES TO SERVICE THE HEATER A/C HOUSING. *YC
180298
EXPERIENCING LONG CRANK TIME/SAGS/HESITATION OR SLOW RUN UP AFTER A COLD DIRVE-AWAY START WHICH IS CAUSED BY AN IGNITION SWITCH TRIGGERED RESET OF THE POWER TRAIN CONTROL MODULE (PCM) WHICH CAUSED ADOPTIVE MEMORY LOSS IN PCM. *AK
183197
CONDITIONS ON OBD II MISFIRE MONITOR. *NLM
980130183197
SUBJECT PERTAINING TO OBD II MISFIRE MONITOR. *YC
241797
A REVISED COWL PLENUM SCREEN HAS BEEN RELEASED WHICH CONTAINS A FINE MESH SCREEN TO MINIMIZE DEBRIS FROM ENTERING THE HEATER A/C HOUSING. *YC
210697A
THIS BULLETIN INVOLVES OVERDRIVE UNAVAILABLE IN EXTREME COLD TEMPERATURES, BYPASS KIT INSTALLATION, INHIBITOR PROGRAMMING. *NLM
140897
INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL. *NLM
083697
THIS BULLETIN INVOLVES SPEEDOMETER NEEDLE JUMP. *NLM
235397
CONCERNS WITH DOOR CHECK ROLLER REPAIR. *NLM
0832097
INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *NLM
235197
CONDITION WITH DOOR TRIM PANEL VINYL OR PAINT PEELING. *YC
970919083297
AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *YC
231497
ROOF/SUN ROOF LEAKS. *TW
231497A
SERVICE INFORMATION ON ROOF/SUN ROOF WATER LEAKS. *YC
082897
CONCERNS WITH LIFTGATE AJAR SWITCH TERMINAL CORROSION. *NLM
210297A
THIS BULLETIN INVOLVES TRANSFER CASE SHIFTER NOISE. *NLM
233597
COMPLAINTS MAY BE RECIEVED RELATED TO SPEAKER BUZZ AT REAR DOOR SPEAKERS. *YC
233597A
REAR DOOR SPEAKER BUZZ. *TW
241197
CONCERNS WITH A/C EVAPORATOR ODOR. *NLM
140697
INFORMATION ON FUEL PUMP DIAGNOSIS. *NLM
220197
INFORMATION ON TIRE AND WHEEL RUNOUT. *NLM
082097
INFORMATION REGARDING GARAGE DOOR OPENER. *NLM
070397
CONCERNS WITH ENGINE COOLANT USAGE. *NLM
231797
WIND NOISE AT THE SIDES OF THE WINDSHIELD. *TW
210697
OVERDRIVE UNAVAILABLE IN EXTREME COLD TEMPERATURES. *YC
210797
INFORMATION ON TRANSMISSION COOLER REVERSE FLUSHING WITH COOLER BYPASS KIT INSTALLED. *NLM
210297
A THUMPING OR BUMPING NOISE MAY BE HEARD COMING FROM THE TRANSMISSION TUNNEL AREA ON ACCELERATION OR WHILE DRIVING OVER BUMPY ROADS. *YC
230397
DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK. *TW
080197
JTEC POWERTRAIN CONTROL MODULE WIRING HARNESS CONNECTOR REPAIR PACKAGES. *JD
080297
WARNING CHIME SOUNDS WHENEVER VEHICLE MOVES AFTER BODY CONTROLLER MODULE SERVICE WITH THE DRB III. *JD
180397
ERRONEOUS MIL ILLUMINATION/DRIVEABILITY IMPROVEMENTS- DOWNSTREAM 02 SENSOR HEATER FAILURE- COLD ENGINE WARM UP SAG/HESITATION- DRIVEAWAY SAG/HESITATION- SURGE AT CONSTANT SPEEDS WITH CRUISE CONTROL- SPARK KNOCK DURING MODERATE TO HEAVY LOAD AND/OR DEEP THROTTLE ACCELERATION- COLD TRANSMISSION DELAYED- MAP SENSOR VOLTAGE TOO LOW. *JD
084995
WHENEVER AN OIL PRESSURE SENSOR IS REPLACED, BE SURE TO CHECK THE POLARITY OF THE TERMINALS IN THE HARNESS CONNECTOR. INCORRECT POLARITY CAN LEAD TO PREMATURE FAILURE OF THE SENSOR. DISASSEMBLE THE CONNECTOR AND REVERSE THE WIRES.
212295
TRANSMISSION SHIFTING REQUIRES EXCESSIVE EFFORT. INSPECT THE PRNDL SCROLL FOR ANY SIGNS OF DAMAGE OR CONTACT W/ OTHER COMPONENTS UNDER THE CONSOLE. IF DAMAGE IS PRESENT, REPLACE THE PRNDL BEZEL W/ A REDESIGNED ASSEMBLY.
081695REVA
BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-16-95, DATED APR. 14, 1995. IF THE VEHICLE OPERATOR **REPEATEDLY** PRESSES AND RELEASES THE SET BUTTON WITH THEIR FOOT OFF OF THE ACCELERATOR (A 'LIFT FOOT SET' TO BEGIN SPEED CONTROL OPERATION), THE VEHICLE MAY ACCELERATE AND EXCEED THE DESIRED SET SPEED BY UP TO 5 MPH (8 KM/H) AND THEN DECELERATE TO LESS THAN THE DESIRED SET SPEED BEFORE FINALLY ACHIEVING THE DESIRED SET SPEED.
084595
THE MEMORY SEAT FEATURE WHICH IS AVAILABLE AS AN OPTION FOR 1996, CONAINS A SOFT STOP PROTECTION FEATURE. THESE STOPS WILL BE SET WHEN THE SEAT COMES IN CONTACT WITH ANY OBJECT THAT INTERFERES WITH IT'S TRAVEL, STALLING THE MOTOR. THE STOPS WILL BE SET IN THE MEMORY OF THE MODULE, AND WILL LIMIT THE SEAT TRAVEL TO THE POINT THAT THE INTERFERENCE OCCURRED UNTIL THE STOP IS RESET. THERE ARE FIVE MOTORS WHICH OPERATE THE POWER SEATS. SOFT STOP CAN BE SET IN ANY DIRECTION FOR ALL FIVE MOTORS AND MORE THAN ONE STOP CAN BE SET IN SAME DIRECTION OF TRAVEL.
084795
THE HOOD SWITCH USED TO PROVIDE INPUT FOR THE HOOD AJAR WARNING INDICATOR IN THE VEHICLE INFORMATION CENTER AND FOR THE VEHICLE THEFT ALARM HAS BEEN DELETED FROM PRODUCTION FOR 1996 VEHICLES BUILT AFTER AUGUST 29, 1995 (MDH 08-29-XX). DO NOT ATTEMPT IO INSTALL SWITCHES ON VEHICLES BUILT AFTER THAT DATE.
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.