9100645
Service Bulletin/Repair Instructions
Verify Reman part number availability. Order the "R" part number for all orders: Warranty, Mopar, customer pay and service contract. Order "68" part number for New unsold units only.
Vehicle report
2007 JEEP GRAND CHEROKEE
Service bulletins
52 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
101232
Service Bulletin/Repair Instructions
Plate - Planetary
9100226
Service Bulletin/Repair Instructions
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
9004009
Service Bulletin/Repair Instructions
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.
9004361
Service Bulletin/Repair Instructions
NAG1 Transmission Before installing the transmission with the engine, check for dowel pins (2) for alignment. If the pins are missing request to add the dowel pin first and then install the transmission
9001784
Service Bulletin/Repair Instructions
Mechanical rocker arm, intake, 1.7 ratio.
23-015-20
Service Bulletin/Repair Instructions
Disinfectant Solution Recommended for COVID-19
08-049-20
Service Bulletin/Repair Instructions
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
9004178
Service Bulletin/Repair Instructions
DAMPER, Transfer Case Reman Transfer Case will arrive equipped with the Transfer Case Damper. Please return core with original damper intact.
31-003-19
Service Bulletin/Repair Instructions
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Service Bulletin/Repair Instructions
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Service Bulletin/Repair Instructions
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Service Bulletin/Repair Instructions
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Service Bulletin/Repair Instructions
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Service Bulletin/Repair Instructions
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
9003483
Service Bulletin/Repair Instructions
Exterior Mirror The latest version of these exterior mirrors have had their glass removed to be serviced separatly. To install, connect the electrial connector (if equipped) and snap the glass onto the mirror housing.
9003687
Service Bulletin/Repair Instructions
Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
R2118796A
Service Bulletin/Repair Instructions
Valve Body. These may cause over drive cycling.
RL108213A$
Service Bulletin/Repair Instructions
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
CSN-P-73
Service Bulletin/Repair Instructions
FIAT CHRYSLER: TSB HAS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. WHEN SHIFTING OUT OF CURRENT SELECTED MODE, FINAL DRIVE CONTROL MODULE (FDCM) SOFTWARE CAUSES SERVICE 4WD LIGHT TO ILLUMINATE AND SWITCHING OUT OF 4WD FAILS AND NEEDS REPROGRAMMING. MODEL 2005-2010 JEEP GRAND CHEROKEE, JEEP COMMANDER. *PE
P73
Service Bulletin/Repair Instructions
Customer Satisfaction Notification P73 Reprogram Final Drive Control Module The Final Drive Control Module (FDCM) software on about 295,600 of the above vehicles may cause the ?Service 4WD? light to come on and an inability to switch 4WD mode when trying to shift out of the current selected mode. The Final Drive Control Module (FDCM) must be reprogrammed with new software.
9003215
Service Bulletin/Repair Instructions
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
9002887
Service Bulletin/Repair Instructions
Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
08-002-15
Service Bulletin/Repair Instructions
P41 Interim Repair Procedure Brazil ONLY Some Jeep Commander and Jeep Grand Cherokee vehicles may experience an unintended change in ignition switch position while driving which may result in loss of engine power, power steering, and braking assist increasing the risk of a crash and disabling one or more of the vehicle?s safety features including the frontal airbags. Chrysler intends to repair the vehicle free of charge (parts and labor). However, the part required to provide a permanent remedy for this condition is currently not available.
21-022-14 REV. A
Service Bulletin/Repair Instructions
4WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indicate that the ?Service 4WD? indicator in the instrument cluster is illuminated. They may also indicate that the transfer case will not shift from 4WD High, 4WD Low, and/or Neutral once the lamp is illuminated. Further investigation identifies that a Diagnostic Trouble Code C140F is stored or active in the Final Drive Control Modules (FDCM) Memory
21-022-14REV.A
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
21-022-14
Service Bulletin/Repair Instructions
4WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indicate that the ?Service 4WD? indicator in the instrument cluster is illuminated. They may also indicate that the transfer case will not shift from 4WD High, 4WD Low, and/or Neutral once the lamp is illuminated. Further investigation identifies that a Diagnostic Trouble Code C140F is stored or active in the Final Drive Control Modules (FDCM) Memory
9001199
Service Bulletin/Repair Instructions
Part Description: Actuator Motor
SB-18-009-09REVA
Service Bulletin/Repair Instructions
JEEP/CHRYSLER/DODGE: FLASH; DRIVEABILITY IMPROVEMENTS. THIS BULLETIN INVOLVES SELECTIVELY ERASING AND REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH NEW SOFTWARE. *PE UPDATED 11/15/13. *PE
N23050813
Service Bulletin/Repair Instructions
New Safety Recall Advanced Communication ? N23050813 Chrysler Group LLC (Chrysler) announced a safety recall on certain 2005 - 2010 model year (WK) Jeep Grand Cherokee and (XK) Jeep Commander vehicles equipped with a Quadra-Drive II or Quadra-Trac II four wheel drive system. Some of the above vehicles may experience a transfer case actuator encoder electrical failure that results in unintentional transfer case shifting into or through the neutral position. NOTE: These vehicles are equipped with a NV245 transfer case that is part of the automatic four wheel drive system. The transfer case shifts into and out of four wheel drive modes and ranges automatically or based on driver inputs. Chrysler will conduct a voluntary safety recall on all affected vehicles to reprogram the Final Drive Controller Module (FDCM) with new software. The four wheel drive system will then be function tested. Vehicles found with an inoperative transfer case actuator will also have the actuator replaced. Dealers will be notified of the launch of this safety recall by way of established methods used in the past. We ask that you please take the time to ensure that your personnel are aware of this communication and are prepared to execute a customer friendly process for inquiries on involved vehicles.
9002519
Service Bulletin/Repair Instructions
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
09-001-13
Service Bulletin/Repair Instructions
Gasoline Engine Diagnostic Inspection Procedure This bulletin provides a procedure to determine repair versus replacement of a gasoline long block engine assembly. This procedure is to be used prior to conducting any engine related repairs or removal of engine components.
SB-18-013-09
Service Bulletin/Repair Instructions
JEEP: IN COLD CLIMATES A MIL ILLUMINATION P0123 OR P0222 OR STORED DIAGNOSTIC TROUBLE CODE P0123 OR 00222 AND THE ETC LIGHT ILLUMINATED. THIS INVOLVES REPLACING THE ELECTRONIC THROTTLE BODY AND CLEAN AIR DUCT. *PE
SB-09-001-09
Service Bulletin/Repair Instructions
JEEP: DIESEL ALTERNATOR INOPERATIVE. OIL MARKS ON THE ALTERNATOR. THIS CONDITION CAN ONLY HAPPEN WHILE POURING THE OIL INTO THE ENGINE AND CARE IS NOT TAKEN TO ENSURE NONE IS SPILLED. *PE
0800807
Service Bulletin/Repair Instructions
THIS BULLETIN INVOLVES SELECTIVELY ERASING AND REPROGRAMMING THE WIRELESS CONTROL MODULE(WCM) WITH NEW SOFTWARE. *KB UPDATED 1/23/08. *NJ
0900507
Service Bulletin/Repair Instructions
3.0L DIESEL OIL FILTER CAP SERVICE. *NJ
0900407
Service Bulletin/Repair Instructions
ENGINE CRANKS BUT WILL NOT START AND APPLIES TO VEHICLES EQUIPPED WITH A 3.0L DIESEL ENGINE. *NJ
2304106
Service Bulletin/Repair Instructions
EXTERIOR LAMP - LENS FOGGING. *NJ
2303207
Service Bulletin/Repair Instructions
FRONT DOOR WINDOW GLASS - LOOSE, STICKS, BINDS, OR EXPRESS - UP REVERSAL. *KB
1804007
Service Bulletin/Repair Instructions
MIL ILLUMINATION DUE TO DTC P1128, P1129 WHEN VEHICLE IS OPERATED WITH A 38% TO 40% ETHANOL FUEL BLEND. *KB
2101207
Service Bulletin/Repair Instructions
MIL ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE P0741- TORQUE CONVERTER CLUTCH CIRCUIT PERFORMANCE. *KB
1803807
Service Bulletin/Repair Instructions
CHARGING SYSTEM VOLTAGE. ERASING AND REPROGRAMMING OF THE POWER TRAIN CONTROL MODULE (PCM). *KB
1802707
Service Bulletin/Repair Instructions
MIL ILLUMINATION DUE TO EGR POSITION SENSOR DTC - P0404, P0405, P0406. *KB
13
Service Bulletin/Repair Instructions
INCORRECT VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL WAS INADVERTENTLY INSTALLED. *KB
0900107
Service Bulletin/Repair Instructions
INTAKE - TO - THROTTLE BODY JOINT MAY CAUSE A WHISTLE - LIKE SOUND ON 3.7L ENGINES. *KB
0800107
Service Bulletin/Repair Instructions
PASSENGER AIR BAG DEACTIVATION. *KB
2304706
Service Bulletin/Repair Instructions
CRACKED WINDSHIELD DUE TO BEING HIT BY A FOREIGN OBJECT LIKE A STONE. *KB
2200406
Service Bulletin/Repair Instructions
TIRE PRESSURE MONITOR SYSTEM INFORMATION. *KB
0803006
Service Bulletin/Repair Instructions
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
1800106
Service Bulletin/Repair Instructions
STARSCAN@/STARMOBILE ABORT RECOVERY PROCEDURES. *TT
2200206
Service Bulletin/Repair Instructions
TIRE PRESSURE MONITOR DTC'S DUE TO THE IOD FUSE NOT BEING INSTALLED. *KB
0803205
Service Bulletin/Repair Instructions
DAIMLERCHRYSLER CORPORATION IS NOW OFFERING A PASSENGER AIRBAG DEACTIVATION WIRING PACKAGE. TO INCLUDE 2006 CHRYSLER TOWN AND COUNTRY AND 300/TOURING. *TT
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.