Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
21-042-26 REV. A
Not applicable to vehicles built for US market. 1.5L Transmission Diagnosis Service Solution Customers may experience one or more of the following: SYMPTOM: ● Transmission warning light on and/or vehicle jerking. ● Vehicle is not shifting correctly or has no traction. This service bulletin is to provide a diagnostic guide for a transmission warning light on, vehicle jerking, not shifting correctly or no traction symptoms.
9100852
When long block is received, inspection needs to be performed per SOL S2609000010 before the repair begins. If the block machining is not complete according to information in SOL, a new long block will need to be ordered.
S2609000010
Mis-Machined Engine Block
09-011-26
Not applicable to vehicles built for US market. ENGINE – 1.5 GSE T4 MHEV - Malfunction Indication Light (MIL) P0016 Customers must experience a MIL illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P0016 - Crankshaft/camshaft Timing Misalignment - Bank 1 Sensor 1. Check the trouble codes in the Engine Control Unit (ECU). Apply this document if the trouble code as mentioned is set (P0016). Fix Engine Timing and replace the cam-to-cam guide rail (“snubber”)
21-042-26
Not applicable to vehicles built for US market. 1.5L Transmission Diagnosis Service Solution Customers may experience one or more of the following: ● Transmission warning light on and/or vehicle jerking. ● Vehicle is not shifting correctly or has no traction This service bulletin is to provide a diagnostic guide for a transmission warning light on, vehicle jerking, not shifting correctly or no traction symptoms.
21-040-26
Not applicable to vehicles built for US market. Clutch Actuator Cylinder Motor Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P2787-00 Clutch 1 Temperature Too High. ● P28C7-00 Clutch A Motor Phase U-V-W Performance. ● P27F3-00 Clutch 2 Temperature Too High. ● P28D5-00 Clutch B Motor Phase U-V-W Circuit Performance. Customers may experience the following: ● Transmission warning light on or odd gears unavailable or even gears unavailable or reverse gear unavailable In case of a reported and ascertained fault, check and replace the worn/damaged components, if necessary, according to the Operating Cycle below.
08-204-26
Not applicable to vehicles built for US market. Vehicle Does Not Operate In Electric Mode And/Or Reverse Gear Is Unavailable Customers may experience one or more of the following: ● The vehicle does not operate in electric mode. ● Reverse gear is not available.
08-176-26
Not applicable to vehicles built for US market. Flash: Instrument Panel Cluster (IPC) Updates Customer may comment on the following: ● Incorrect speed limiter indication on the IPC when the system is set to imperial (mph) This bulletin involves reprogramming the IPC with the latest available software
9100752 Rev 1
Warning light on after replacing: Airbag (ORC) Lane control feedback (HALF) Customer will experience a warning light after replacing ORC DTCs: B12C7, B12C8 The security gateway module software requires updating with the ORC/Half replacement.
14-009-25 REV. D
Not applicable to vehicles built for US market. Fuel Injector Leak Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0087-00 - Fuel Line Pressure Sensor - Bank 1 - Pressure Below Limit. ● P0300-00 - Multiple Cylinder Misfire. ● P0301-00 - Cylinder 1 Misfire. ● P0302-00 - Cylinder 2 Misfire. ● P0303-00 - Cylinder 3 Misfire. ● P0304-00 - Cylinder 4 Misfire. ● P006C-00 - Air Pressure and Temperature Sensor - Correlation. Customers may also comment on one or more of the following: ● Unstable idle. ● Abnormal engine noise This bulletin involves diagnosing and possibly replacing the fuel injectors and the high pressure tube.
14-009-25 REV. C
Not applicable to vehicles built for US market. Fuel Injector Leak Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0087-00 - Fuel Line Pressure Sensor - Bank 1 - Pressure Below Limit. ● P0300-00 - Multiple Cylinder Misfire. ● P0301-00 - Cylinder 1 Misfire. ● P0302-00 - Cylinder 2 Misfire. ● P0303-00 - Cylinder 3 Misfire. ● P0304-00 - Cylinder 4 Misfire. ● P006C-00 - Air Pressure and Temperature Sensor - Correlation. Customers may also comment on one or more of the following: ● Unstable idle. ● Abnormal engine noise This bulletin involves diagnosing and possibly replacing the fuel injectors and the high pressure tube.
08-405-25
Not applicable to vehicles built for US market. Turn Signal Lever End Cap Detached Customers may comment on the following: ● The end cap on the turn signal lever has detached or is loose This bulletin involves replacing the turn signal lever.
08-394-25 REV. A
Telematics Box Module (TBM) Backup Battery Replacement When DTC B1E21 Is Present Technicians may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set the following Diagnostic Trouble Code (DTC): ● B1E21-96 - Backup Battery Component Internal Failure.
23-045-25
Not applicable to vehicles built for US market. Rear Doors Misaligned Customers may comment on the following: ● Rear doors misaligned with the fixed windows. This bulletin involves adjusting the rear door strikers.
05-004-25
Not applicable to vehicles built for US market. Brake Booster Noise While Braking Customers may comment on the following: ● Hissing or air leak type noise heard when braking. This bulletin involves replacing the brake booster.Brake Booster Noise While Braking Customers may comment on the following: ● Hissing or air leak type noise heard when braking. This bulletin involves replacing the brake booster.Brake Booster Noise While Braking Customers may comment on the following: ● Hissing or air leak type noise heard when braking. This bulletin involves replacing the brake booster.
9100734
If the DTC B1E21-96: Backup Battery-Component Internal Failure is active and customer states Popup message will show at the radio: "Battery of Uconnect Box requires service. SOS call and related functions may be unavailable. Please visit an authorized dealer." PLEASE do not Replace the TBM module, only replace TBM Internal Battery (inside Telematics Box Module) and order PN68493347
08-394-25
Telematics Box Module (TBM) Backup Battery Replacement When DTC B1E21 Is Present echnicians may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set the following Diagnostic Trouble Code (DTC): ● B1E21-96 - Backup Battery Component Internal Failure
108458
DETECTOR - EVAPORATIVE SYSTEM INTEGRITY MODULE
108461
DETECTOR - EVAPORATIVE SYSTEM INTEGRITY MODULE
14-009-25 REV. B
Not applicable to vehicles built for US market. Fuel Injector Leak Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0087-00 - Fuel Line Pressure Sensor - Bank 1 - Pressure Below Limit. ● P0300-00 - Multiple Cylinder Misfire. ● P0301-00 - Cylinder 1 Misfire. ● P0302-00 - Cylinder 2 Misfire. ● P0303-00 - Cylinder 3 Misfire. ● P0304-00 - Cylinder 4 Misfire. ● P006C-00 - Air Pressure and Temperature Sensor - Correlation. Customers may also comment on one or more of the following: ● Unstable idle. ● Abnormal engine noise This bulletin involves diagnosing and possibly replacing the fuel injectors and the high pressure tube.
23-041-25
Not applicable to vehicles built for US market. Glove Box Door Difficult To Close Customers may experience the following: ● The glove compartment door is difficult to close. This bulletin involves installing a washer spacer stack to correct glove compartment door alignment.
08-218-25 REV. D
Not applicable to vehicles built for US market. Turn Signal Lever Does Not Cancel Customers may comment on the following: ● Turn signal lever does not return or cancel. This bulletin involves inspecting the turn signal lever and possibly replacing it.
09-028-25
Not applicable to vehicles built for US market. Drivers Monitoring Module Manifold Absolute Pressure (MAP) Sensor Not Installed Properly Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P006D-00 - Barometric Pressure - Inlet Air Pressure Correlation. ● P012C-00 - Turbocharger/Supercharger Inlet Air Pressure Sensor 1 Circuit Low. ● P012D-00 - Turbocharger/Supercharger Inlet Air Pressure Sensor 1 Circuit High. ● P1189-00 - Inlet Air Pressure Sensor Circuit Low. ● P1190-00 - Inlet Air Pressure Sensor Circuit High. This bulletin involves measuring the distance between the lower base of the MAP sensor and the surface of the intake air line and, if required, replacing the MAP sensor.
08-218-25 REV. C
Not applicable to vehicles built for US market. Turn Signal Lever Does Not Cancel Customers may comment on the following: ● Turn signal lever does not return or cancel This bulletin involves inspecting the turn signal lever and possibly replacing it.
08-218-25 REV. B
Not applicable to vehicles built for US market. Turn Signal Lever Does Not Cancel Customers may comment on the following: ● Turn signal lever does not return or cancel. This bulletin involves inspecting the turn signal lever and possibly replacing it.
14-015-25
Not applicable to vehicles built for US market. Fuel Tank Leaking Customers may experience the following: ● A fuel leak (leakage at the fuel tank inlet).
23-008-25 REV. A
Exterior Front Lamps Condensation Clearing Procedure *Some customers may report that on occasion vehicle exterior front lamps (headlamps, fog lamps, grille lamps, logo lamps or signature lamps) assemblies are fogged with a light layer of condensation on the inside of the lenses*
09-026-25
Not applicable to vehicles built for US market. Spark Plug Melting Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0300 -00 - Random/Multiple Cylinder - Misfire Detected. ● P0301 -00 - Cylinder 1 - Misfire Detected. ● P0302 -00 - Cylinder 2 - Misfire Detected. ● P0303 -00 - Cylinder 3 - Misfire Detected. ● P0304 -00 - Cylinder 4 - Misfire Detected. ● P1336 -00 - Combustion misfiring (impact on catalytic converter) : Cylinder undetermined. ● P1337 - Combustion misfiring (impact on catalytic converter) : Cylinder 1. ● P1338 - Combustion misfiring (impact on catalytic converter) : Cylinder 2. ● P1339 - Combustion misfiring (impact on catalytic converter) : Cylinder 3. ● P1340 - Combustion misfiring (impact on catalytic converter) : Cylinder 4. Customers may also experience one or more of the following: ● Engine makes a loud metallic knocking noise at idle. ● Difficulty starting. ● Rough and noisy idle This bulletin involves inspecting for DTCs, inspecting for engine leaks and/or damage, and replacing the spark plugs.
S2308000041 REV.B
Replacement Key Fobs Will Not Program On Vehicles Equipped With An iBCM
09-024-25
Not applicable to vehicles built for US market. Rear Main Crankshaft Oil Seal Leak Customers may comment on the following: ● **Oil Pressure warning light illuminates.** ● Engine oil leak. This bulletin involves inspecting for oil leaks and if necessary replacing the rear main crankshaft oil seal.
31-001-25 REV. B
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.
31-001-25 REV. A
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.
09-023-25
Not applicable to vehicles built for US market. Low Oil Pressure Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: ● P06DD - Engine Oil Pressure Control Circuit Stuck Off. Customers may also comment on the following: ● Vehicle will not be able to exceed 3,300 RPM (when DTC P06DD is active) This bulletin involves inspecting and if necessary replacing the timing chain cover (oil pump).
31-001-25
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates
S2508000067
Key Fobs Only Work When Depressing the Key Fob Into the Keyless Ignition Node (KIN)
S2509000008
Customer Indicates Reduced Power And Malfunction Indication Light (MIL) on. Possible DTC’s P2453, P2455, P2461.
08-239-25
NOTE: Not applicable to vehicles built for US Market. Rear View Camera Inoperable Customers may experience the following: ● Rearview camera is inoperable, or shows a blue screen. This bulletin involves replacing the rearview camera main harness.
23-029-25
NOTE: Not applicable to vehicles built for US Market. Center High Mounted Stop Lamp (CHMSL) - Water infiltration Customers may experience the following: ● Water infiltration in the CHMSL. This bulletin involves inspecting and possibly replacing the CHMSL.
08-218-25 REV. A
Not applicable to vehicles built for US market. Turn Signal Lever Does Not Cancel Customers may comment on the following: ● Turn signal lever does not return or cancel. This bulletin involves inspecting the turn signal lever and possibly replacing it.
08-218-25
Not applicable to vehicles built for US market. Turn Signal Lever Does Not Cancel Customers may comment on the following: ● Turn signal lever does not return or cancel. This bulletin involves inspecting the turn signal lever and possibly replacing it.
9100624
Verify Reman part number availability. Order the "R" part number for all orders:
08-208-25
NOTE: Not applicable to vehicles built for US Market. R1L Radio Over The Air Update From 62.00.23 To 62.00.29 Software Version Customers will not experience any symptoms. ● New software has been created to support a new radio model This bulletin provides information regarding the latest FOTA update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software for will be updated from 62.00.23 to 62.00.29.
09-016-25
Fuel Injector Leakage NOTE: Does not apply to vehicles built for US Market. Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0087 - Fuel Rail Pressure Too Low - Bank 1. ● P0300 - Multiple Cylinder Misfire. ● P0301 - Cylinder 1 Misfire. ● P0302 - Cylinder 2 Misfire. ● P0303 - Cylinder 3 Misfire. ● P0304 - Cylinder 4 Misfire. ● P006C - MAP - Turbocharger Inlet Pressure Correlation. Customers may also experience one or more of the following: ● The injector light is illuminated on the Instrument Panel Cluster (IPC). ● Engine idle is unstable. ● Abnormal noise from the engine. This bulletin involves inspecting for a fuel injector leak and possibly replacing the fuel injectors and the fuel pipe
23-025-25
NOTE: Only applicable to vehicles built for South America Market. Fuel Tank Hatch Stuck Closed Customers may experience the following: ● The fuel tank cap hatch does not open. This bulletin involves replacing the fuel tank hatch.
07-002-25 REV. B
Engine Coolant Leak From Thermostatic Valve Gasket Customers may experience the following: ● Coolant is leaking at the thermostatic valve This bulletin involves inspecting and, if necessary, replacing the thermostatic valve gasket
08-181-25
Alternator Wiring Harness Low Torque Customers may comment on one or more of the following: ● Battery light is illuminated on the Instrument Panel Cluster (IPC). ● Vehicle does not start due to a depleted battery. This bulletin involves tightening the alternator B+ cable nut to the proper torque specification.
18-028-25
Check Engine Light Illuminated - Erroneous Fault Codes Set Customers must experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician must find one or more of the following Diagnostic Trouble Codes (DTC)s have been set: ● P012C - Turbocharger/Supercharger Inlet Air Pressure Sensor 1 Circuit Low. ● P012D - Turbocharger/Supercharger Inlet Air Pressure Sensor 1 Circuit High. ● P006C-MAP - Turbocharger Inlet Air Pressure Correlation.
17-003-25
Rear Shock Absorber Noise Customers may experience the following: ● A metallic knocking noise in the rear suspension when driving on uneven surfaces. This bulletin involves replacing one or both of the rear shock absorbers.
07-002-25 REV. A
Engine Coolant Leak From Thermostatic Valve Gasket Customers may experience the following: ● Coolant is leaking at the thermostatic valve. This bulletin involves inspecting and, if necessary, replacing the thermostatic valve gasket.
14-009-25 REV. A
Fuel Injector Leak Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0087-00 - Fuel Line Pressure Sensor - Bank 1 - Pressure Below Limit. ● P0300-00 - Multiple Cylinder Misfire. ● P0301 - Cylinder 1 Misfire. ● P0302 - Cylinder 2 Misfire. ● P0303 - Cylinder 3 Misfire. ● P0304 - Cylinder 4 Misfire. ● P006C-00 - Air Pressure and Temperature Sensor - Correlation. Customers may also comment on one or more of the following: ● Unstable idle. ● Abnormal engine noise. This bulletin involves diagnosing and possibly replacing the fuel injectors and the high pressure tube.
09-009-25
Engine Mount Noise Customers may experience the following: ● The customer notices the problem through a noise in the front right part in the engine area during parking maneuvers when changing gear from R to D, as well as when reversing from D to R. This bulletin involves inspecting the right hand side engine mount and replacing it as needed.
23-017-25
Rear Door Belt Molding Loose Customers may experience the following: ● The weather stripping (belt molding) on the rear doors is loose or detaching This bulletin involves possibly replacing one or both of the rear door sill moldings (belt moldings).
07-002-25
Engine Coolant Leak From Thermostatic valve Gasket Customers may experience the following: ● Coolant is leaking at the thermostatic valve. This bulletin involves inspecting and, if necessary, replacing the thermostatic valve gasket.
07-001-25
Various Models - Auxiliary Water Pump Blocked - MIL Li Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P2601-00 - Electric Coolant Pump Control Circuit Performance/Stuck Off. his bulletin involves replacing the auxiliary coolant pump and the pump inlet pipe
08-110-25
Guidelines For Correct Coordinated Reflash Management here are no Customer Symptoms for this Information Only TSB
23-016-25
Rear Spoiler Loosening Customers may experience one or more of the following: ● Squeaking noise coming from the rear spoiler. ● Rear spoiler is loose. This bulletin involves installing a new spoiler
14-009-25
Fuel Injector Leak Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0087-00 - Fuel Line Pressure Sensor - Bank 1 - Pressure Below Limit. ● P0300-00 - Multiple Cylinder Misfire. ● P0301 - Cylinder 1 Misfire. ● P0302 - Cylinder 2 Misfire. ● P0303 - Cylinder 3 Misfire. ● P0304 - Cylinder 4 Misfire. ● P006C-00 - Air Pressure and Temperature Sensor - Correlation. Customers may also comment on one or more of the following: ● Unstable idle. ● Abnormal engine noise. This bulletin involves diagnosing and possibly replacing the fuel injectors and the high pressure tube.
08-068-25
Plant Mode Activated Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● C170C-00 - PBC (Event PBC Factory Mode). ● C1436-86 - Electric Parking Brake System Fail. ● C10D0 - Electronic Park Brake System Failure. Customers may experience one or more of the following: ● Vehicle does not accelerate properly. ● Anti-Lock Brakes System (ABS) warning light on. This bulletin involves replacing the ABS Modul 11015872 20250324 08-068-25 20250324 Service Bulletin/Repair Instructions JEEP RENEGADE 2025 SERVICE BRAKES Park Brake Plant Mode Activated Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● C170C-00 - PBC (Event PBC Factory Mode). ● C1436-86 - Electric Parking Brake System Fail. ● C10D0 - Electronic Park Brake System Failure. Customers may experience one or more of the following: ● Vehicle does not accelerate properly. ● Anti-Lock Brakes System (ABS) warning light on. This bulletin involves replacing the ABS Modul
09-005-25
Various Models - Engine Valley Cap (Flywheel Side) - Oil Leakage - Service Solution Customers may experience the following: ● Oil leaks from the engine compartment, engine/transmission coupling. This bulletin supersedes Technical Service Bulletin (TSB) 09-021-24, date of issue November 23, 2024, which should be removed from your files. All revisions are highlighted with **asterisks** and include new Labor Times.
S258A000009
Apple CarPlay Does Not Complete The First Initial Wireless Connection.
103290
VALVE - FUEL VAPOR
S2108000015 REV.J
Uconnect Box Require Service Message
23-008-25
Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses.
14-002-25 REV. A
Fuel Tank Breather Tube Loose Customers may comment on the following: ● Difficult to refuel the vehicle This bulletin involves inspecting, and if necessary, properly connecting the fuel hose quick connects
14-002-25
Fuel Tank Breather Tube Loose Customers may comment on the following: ● Difficult to refuel the vehicle This bulletin involves inspecting, and if necessary, properly connecting the fuel hose quick connects
14-001-25
High pressure Fuel Pump Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0087 - Sensor De Pressão Da Linha De Combustível - Banco 1 - Pressão Abaixo Do Limite ● P0088 - Sensor De Pressão Da Linha De Combustível - Banco 1 - Pressão Acima Do Limite ● P0089 - Sensor De Pressão Da Linha De Combustível 1 - Desempenho Customers may also comment on one or more of the following: ● The engine is running rough. ● Partial loss of engine power. This bulletin involves replacing the high pressure fuel pump.
9100752
Warning light on after replacing : Airbag (ORC) Lane control feedback (HALF) DTC: B12C7, B12C8 Customer will experience a warning light after replacing ORC Secure gateway software update needed in case Of ORC/Half replacement.
08-258-24
Body Control Module (BCM) Replacement Guidelines Guidelines in case of BCM replacement on exFCA vehicles in the Enlarged Europe region.
23-058-24 REV. A
Seatback Not Torqued Properly Customers may experience the following: ● Loose seatback on the passenger front seat. This bulletin involves removing the passenger seat and tightening the fasteners that join the seatback to the seat
08-251-24 REV. A
Noise From Steering Wheel While Turning Customers may comment on the following: ● Noise when turning the steering wheel. This bulletin involves inspecting the steering wheel operation for a noise while turning and, if noisy, repositioning the steering wheel wire harness.
08-251-24
Noise From Steering Wheel While Turning Customers may comment on the following: ● Noise when turning the steering wheel. This bulletin involves inspecting the steering wheel operation for a noise while turning and, if noisy, repositioning the steering wheel wire harness.
09-021-24
Various Models - Engine Valley Cap (Flywheel Side) - Oil Leakage - Service Solution Customers may experience the following: ● Oil leaks from the engine compartment, engine/transmission coupling. When the claimed fault is confirmed, replace the engine valley cap, according to the Repair Procedure
S2408000117
Turtle Icon Warning Lamp is Displayed on Cluster, No Electric Vehicle Operation or Reverse
23-055-24
Sahara Badge Detaching Customers may comment on the following: ● Liftgate Sahara badge Fig. 1 is loose, detaching or deforming. This bulletin involves replacing the liftgate Sahara Badge.
S2418000015
Unexpected Operation of the ICE (Internal Combustion Engine) Instead of Electric Operation
17-003-24
Rear Damper Noise Customers may experience the following: ● Noise from rear while driving. This bulletin involves replacing both rear dampers.
S2423000042
Snap Noise From Manual Front Seat While Adjusting Or Moving Seat Track.
S2308000160 REV.B
Passive Entry And Start/Stop Button Are Inoperative After iBCM And/Or Fob Replacement
14-006-24
Fuel Tank Leaking Customers may experience the following: ● A fuel leak (leakage at the fuel tank inlet).
08-194-24 REV. A
Engine Starter Malfunction Customers may comment on the following: ● Vehicle no start. This bulletin involves inspecting and possibly replacing the engine starter.
23-049-24 REV. A
Bubbles On Rear Door Panel Customers may experience the following: ● Appearance of bubbles on the rear door panel located in the armrest Fig. 1. This bulletin involves replacing the left rear door panel.
08-193-24
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P0C74 - Motor Electronics Coolant Pump "B" Control Performance. This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software.
08-194-24
Engine Starter Malfunction Customers may comment on the following: ● Vehicle no start. This bulletin involves inspecting and possibly replacing the engine starter.
09-019-24
Rear Main Crankshaft Oil Seal Leak Customers may comment on the following: ● Engine oil leak. This bulletin involves inspecting for oil leaks and if necessary replacing the rear main crankshaft oil seal.
100209
Warranty Newsletter Volume 10 Issue 8_ID
100203
WARRANTY OPERATIONS NEWSLETTER VOLUME 10, ISSUE 8
23-049-24
Bubbles On Rear Door Panel Customers may experience the following: ● Appearance of bubbles on the rear door panels located in the armrest Fig. 1. This bulletin involves replacing the left rear door panel.
08-183-24
Third Stop Lamp Water Ingress Customers may comment on the following: ● Center High Mounted Stop Lamp (CHMSL) holding water. This bulletin involves testing and possibly replacing the CHMSL if water is present inside.
23-004-24 REV. A
Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses.
08-176-24
Plant Mode Activated Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● C170C-00 - PBC (Event PBC Factory Mode). ● C1436-86 - Electric Parking Brake System Fail. ● C10D0 - Electronic Park Brake System Failure. Customers may experience one or more of the following: ● Vehicle does not accelerate properly. ● Anti-Lock Brakes System (ABS) warning light on. This bulletin involves replacing the ABS Module.
31-001-24
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.
08-160-24
Management Procedure for Customer Issues in Connected Services Customers may experience the following: ● Various Connected Services issues. The purpose of this informative Technical Service Bulletin (TSB) is to support the Network on the following topics: ● Discern the different kinds of connected service issues (onboard / offboard). ● Support the customer in his journey to open a request via Customer Care. ● Address on the correct actions to properly manage a customer complaining about the received assistance.
08-149-24
12V Battery Low Level Charge Notification On Customer’s Mobile Application Vehicle's 12V battery Low Level Charge notification on customer’s mobile application.
14-004-24
Fuel Odor or Difficult to Refuel Customers may experience one or more of the following: ● Difficult to refuel the vehicle. ● Fuel odor detected. This bulletin involves inspecting, and if necessary, properly connecting the fuel hose quick connects.
08-129-24 REV A
Nenhum Mapa Disponível Message on the Multimedia Screen Customers may comment on the following: ● "Nenhum mapa disponível" message displayed on the multimedia screen.
08-143-24
Global Telematics Box Module (TBM) Firmware Over The Air (FOTA) Software Update from 4.34 to 4.36 Customers will not experience any symptoms.
08-121-24 REV. B
Rear View Camera (RVC) Error Customers may experience the following: ● RVC display has a blurry image, a blue screen and/or grid line that is not working Fig. 1. This bulletin involves inspecting the RVC for errors and possibly replacing the RVC.
24-002-24
Air Conditioning Not Blowing Cold or is Inoperative The customer or technician may describe or find one or more of the following: ● A/C system provides insufficient cabin cooling. ● Low A/C system pressure. ● Lack or loss of refrigerant in the A/C system. This bulletin involves performing an inspection and possibly replacing A/C lines.
08-121-24 REV. A
Rear View Camera (RVC) Error Customers may experience the following: ● RVC display has a blurry image, a blue screen and/or grid line that is not working Fig. 1. This bulletin involves inspecting the RVC for errors and possibly replacing the RVC.
08-121-24
Rear View Camera (RVC) Error Customers may experience the following: ● RVC display has a blurry image, a blue screen and/or grid line that is not working Fig. 1. This bulletin involves inspecting the RVC for errors and possibly replacing the RVC.
2300424
Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses.
S1408000384
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
1700124
Rear Wheel Bearing Noise The customer may notice the following: ? Rear wheel bearing noise on the right side while driving the vehicle. This bulletin involves replacing the right rear wheel bearing.
2401323
Air Conditioning Not Blowing Cold or is Inoperative Customers may comment on one or more of the following: ? A/C will not function. ? A/C is not blowing cold. This bulletin involves performing an inspection on and possibly replacing the evaporator.
1810623
Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) has been set: ? P0087 - Fuel Rail Pressure Too Low - Bank 1. ? P0088 - Fuel Rail Pressure Too High - Bank 1. This bulletin involves reprogramming the PCM with the latest available software.
0900822
Low Oil Pressure Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: ? P06DD - Engine Oil Pressure Control Circuit Stuck Off. Customers may also comment on the following: ? Vehicle will not be able to exceed 3,300 RPM (when DTC P06DD is active). This bulletin involves inspecting and if necessary replacing the timing chain cover (oil pump).
0902023
Right Engine Insulator Noise Customers may experience the following: ? Metallic clicking noises when when moving the vehicle forward and reverse This bulletin involves inspecting and if needed replacing the right engine insulator.
2310523
Windshield Wiper Rattle Noise Customers may experience the following: ? Rattle noise when the windshield wipers are active. This bulletin involves inspecting and, if necessary, replacing one or both the front wiper arms and wiper blades.
0822423
Carrier Motor Malfunction Customers may experience a grinding noise during driver window down/up operation. This bulletin involves inspecting and possibly replacing the driver side window motor / carrier assembly.
9100229
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
S2323000075
2nd Row Center Seat Lazy Or Slow When Folding.
9100226
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
93023
Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)
93120
FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC
1900323
Steering Wheel Off-Center Customers may experience the steering wheel is off-center. This bulletin involves re-centering the steering wheel.
2400623
A/C Diagnostic LOP Change
0900623
Low Oil Pressure Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: ? P06DD - Engine Oil Pressure Control Circuit Stuck Off. Customers may also comment on the following: ? Vehicle will not be able to exceed 3,300 RPM (when DTC P06DD is active). This bulletin involves inspecting and if necessary replacing the timing chain cover (oil pump).
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.