D-20-02 Rev. A
Service Bulletin/Repair Instructions
DIPAP Requirements - Addition of Jeep Wrangler (JL/JK) and Jeep Gladiator (JT) Hard Top and Targa Top Panel Replacements - All Dealers (Rev. A)
Vehicle report
1989 JEEP WRANGLER
Service bulletins
11 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
0800600REV
Service Bulletin/Repair Instructions
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
080600
Service Bulletin/Repair Instructions
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
081698
Service Bulletin/Repair Instructions
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
070397
Service Bulletin/Repair Instructions
CONCERNS WITH ENGINE COOLANT USAGE. *NLM
230397
Service Bulletin/Repair Instructions
DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK. *TW
RCL647
Service Bulletin/Repair Instructions
APPLIES TO VEHICLES EQUIPPED WITH A 4.2L ENGINE AND FEDERAL HIGH ALTITUDE EMISSION CONTROL SYSTEM. FUEL VAPORS MAY CAUSE DETERIORATION OF THE PCV HARNESS ASSEMBLY. THE PCV HARNESS ASSEMBLY MUST BE REPLACED AND THE ENGINE IDLE SPEEDS MUST BE RESET.
RCL/617
Service Bulletin/Repair Instructions
UNKNOWN
011395
Service Bulletin/Repair Instructions
SUPPLEMENTAL INFORMATION TO MANUFACTURER'S RECALL #556. *TW
RCL/556
Service Bulletin/Repair Instructions
IT HAS BEEN DETERMINED THAT CERTAIN EMISSION RELATED COMPONENTS OF THE 1989 JEEP EQUIPPED WITH THE 2.5L ENGINE, MAY BE SUSCEPTIBLE TO FAILURE. FAILURE OF THESE COMPONENTS MAY CAUSE THE VEHICLE TO BE IN VIOLATION OF CALIFORNIA EMISSIONS STANDARDS. HYDROCARBONS, CARBON MONOXIDE AND OXIDES OF NITROGEN COULD BE ABOVE THE ALLOWABLE LIMITS, WHICH WERE ESTABLISHED TO PROTECT PUBLIC HEALTH FROM THE DANGERS OF AIR POLLUTION. TO CORRECT THIS PROBLEM, DEALERS WILL REPLACE THE OXYGEN SENSOR, CRANKCASE VENTILATION HOSE AND IF EQUIPPED, THE TRANSFER CASE VACUUM HOSE AND FUEL TANK VENT BOOT. IN ADDITION, THE THE EXHAUST MANIFOLD WILL BE CHECKED FOR AN EXHAUST LEAK NOISE AND REPLACED AS RQUIRED. *TW
RCL/616
Service Bulletin/Repair Instructions
IT HAS BEEN DETERMINED THAT THE OXYGEN SENSOR ON CERTAIN 1989 JEEP CHEROKEE, COMANCHE AND WRANGLER MODELS EQUIPPED WITH A 2.5L ENGINE MAY BE SUSCEPTIBLE TO FAILURE. FAILURE OF THE OXYGEN SENSOR MAY CAUSE YOUR VEHICLE TO BE IN VIOLATION OF FEDERAL EMISSIONS STANDARDS. TO CORRECT THIS PROBLEM, DEALERS WILL REPLACE THE OXYGEN SENSOR. *TW
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.