Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
D-20-02 Rev. A
DIPAP Requirements - Addition of Jeep Wrangler (JL/JK) and Jeep Gladiator (JT) Hard Top and Targa Top Panel Replacements - All Dealers (Rev. A)
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
R2118796A
Valve Body. These may cause over drive cycling.
9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
1900306
STEERING SHIMMY. *TT
22
REPROGRAM PCM AND INSPECT CATALYTIC CONVERTER. *KB
2301006
PRIMARY DOOR WEATHERSTRIP WATER LEAK AT A-PILLAR BELT LINE. *TT
2100903
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
0901004
DIRT AND DEBRIS ACCUMULATION AT REAR MAIN SEAL. *TT
2300504
SOFT TOP ZIPPER CLEANER AND LUBRICANT - FOR DIFFICULT TO OPERATE WINDOW ZIPPERS. *TT
2400703
HVAC DRIVE WATER LEAKS UNDER PASSENGER SIDE FRONT CARPET. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2302501
SOFT TOP ZIPPER CLEANER AND LUBRICANT - FOR DIFFICULT TO OPERATE WINDOW ZIPPERS. *TT
2401201
CUSTOMERS MAY COMPLAIN THAT THE HVAC DRAIN WATER LEAKS UNDER PASSENGER SIDE CARPET. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2500401
SUBJECT REGARDING ADDITIONAL DIAGNOSTIC FOR DIAGNOSTIC TROUBLE CODES CAUSED BY AN EVAPORATIVE SYSTEM LEAK. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
234199
INFORMATION REGARDING THE IMPROVED DOOR WEATHER STRIP. *MJS
242199
VEHICLES MAY EXPERIENCE WATER DRIPPING FROM THE BOTTOM OF THE EVAPORATOR DRAIN TUBE AND ENTER THE PASSENGER COMPARTMENT CAUSING WET CARPET OR WATER ON THE PASSENGER COMPARTMENT FLOOR. *MJS
021299
THIS BULLETIN PERTAINS TO FRONT END ALIGNMENT - ADJUSTABLE / OFFSET BALL JOINTS. *TT
181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
081499
CONDITIONS WITH VEHICLE START AND STALL OR VEHICLE NO-START. *TT
081599
SOME VEHICLES MAY EXHIBIT AN ERRATIC, INTERMITTENT CLUSTER OPERATION / INTERMITTENT AIR BAG WARNING LIGHT. *TT
180799
EXHIBITING ERRONEOUS MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE $A8 (P1763) GOVERNOR PRESSURE SENSOR VOLTS TOO HIGH. *TT
210899
VEHICLES EXHIBITING BUZZ, WHINING, OR MOANING LIKE NOISE FROM COLD TRANSMISSION WHEN REVERSE GEAR IS SELECTED. *TT
230999
SUBJECT ON WATER LEAK DIAGNOSTIC / REPAIR PROCEDURES. *TT
080799
INFORMATION REGARDING POWER DISTRIBUTION CENTER (PDC) SERVICE. *TT
180399
SUBJECT REGARDING ERRONEOUS MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE $24 (PO107). *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
110798
OUTER EXHAUST MANIFOLD STUDS MAY FATIGUE/BREAK. *AK
210998
A THUMPING OR CREAKING NOISE MAY BE HEARD COMING FROM THE TRANSMISSION TUNNEL AREA ON ACCELERATION OR WHILE DRIVING OVER BUMPY ROADS. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
050398
EXHIBITING MINOR BRAKE PEDAL PULSTION WHICH MAY BE CAUSED BY ROUGH DISC ROTORS. *AK
182898
ERRONEOUS MIL WITH DTC $71(PO441) -EVAP PURGE FLOW MONITOR FAILURE DUE TO INAPPROPRIATE FUEL LEVEL READINGS DURING THE TEST SEQUENCE. *AK
233698
INFORMATION TO ASSIST IN IDENTIFYING WATER LEAK ENTRY POINTS BY HIGHLIGHTING AREAS WHERE LEAKS ARE LIKELY TO OCCUR BASED ON THE EXPERIENCE GAINED DURING THE DEVELOPMENT OF THE VEHICLE. *YC
030598
A CLICKING NOISE MAY BE PRESENT WHEN CHANGING FROM A FORWARD GEAR TO REVERSE DUE TO POOR FITTING UNIVERSAL JOINT RETAINING STRAPS. *AK
233198
A SQUEAK OR BUZZ COMING FROM THE HOOD OF THE VEHICLE. *YC
083398
INFORMATION ON PASSENGER'S AIR BAG ON/OFF SWITCH WHICH IS LOCATED ON FORWARD END OF FLOOR CONSOLE, AND ALLOWS PASSENGER'S SIDE AIR BAG ON/OFF SWITCH TO BE DISABLED WHEN CERTAIN CHILD RESTRAINT DEVICES ARE USED IN THE PASSENGER'S SEATING POSITION. *AK
190498
A SQUAWKING OR SCRAPPING NOISE COMING FROM THE STEERING COLUMN WHICH MAY BE CONFUSED WITH CLOCK SPRING OR STEERING COLUMN BEARING NOISE. *YC
182298
INFORMATION ON THE OBD II MISFIRE MONTIOR. *YC
980320240398
A SQUEAKING NOISE MAY BE HEARD WHEN THE SYSTEM MODE IS CHANGED FROM FLOOR TO PANEL OR DEFROST. *YC
182198
SERVICE CAUTION ON POWERTRAIN CONTROL MODULE ( PCM ). *YC
08298
ERRATIC INSTRUMENT PANEL CLUSTER OPERATION / INTERMITTENT AIR BAG WARNING LIGHT. *YC
232198
A SQUEAKING NOISE HEARD IN THE FRONT SEAT. *YC
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
240398
A SQUEAKING NOISE MAY BE PRESENT WHEN THE SYSTEM MODE IS CHANGED FROM FLOOR TO PANEL HEATING.*AK
230998
A RATTLING OR KNOCKING NOISE MAY BE PRESENT WHEN DRIVING OVER ROUGH ROADS, NOISE WAS COMING FROM REAR OF VEHICLE. *AK
9807
SOME VEHICLES HAVE INCORRECT DIPSTICK INSTALLATION. *YC
183197
CONDITIONS ON OBD II MISFIRE MONITOR. *NLM
980130183197
SUBJECT PERTAINING TO OBD II MISFIRE MONITOR. *YC
183697
CONCERNS ON INCORRECT FAULT MATURE TIME - DTC $B7 LEAK DETECTION PUMP SOLENOID CIRCUIT. *NLM
140897
INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL. *NLM
241397
INFORMATION ON A/C REFRIGERANT LEAKS. *NLM
0832097
INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *NLM
970919083297
AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *YC
241197
CONCERNS WITH A/C EVAPORATOR ODOR. *NLM
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.