Vehicle report

2022 JEEP WRANGLER

Compare every JEEP WRANGLER yearNHTSA and EPA records

Service bulletins

495 bulletins

Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.

9100900

Service Bulletin/Repair Instructions

Passive Entry O/S Dr Handle Prior to replacing an inoperative passive entry door handle, perform Star Online S2623000040.

9100363 Rev 3

Service Bulletin/Repair Instructions

Turbocharger Kit Please note that many turbo components are serviceable separately and full turbo replacement may not be required. If the turbo is being inspected for: Noise/Rattle: Inspect heat shield fasteners for looseness and check the wastegate actuator/linkage for binding. The actuator kit is serviced separately. Oil Leak: Inspect the turbo oil feed O-ring area for leaks. O-ring is serviced separately.

114044

Warranty Program/Extension

D-25-15 Rev. C Aluminum Filiform Corrosion Warranty Policy and Vehicle Digital Imaging (VDI) Pre-Approval Process - ALL Vehicles

114045

Warranty Program/Extension

ID-25-11 Rev. C Aluminum Filiform Corrosion Warranty Policy and Vehicle Digital Imaging (VDI) Pre-Approval Process - ALL Vehicles

16C Combo Rev3

Warranty Program/Extension

EMISSION RECALL – NORTH AMERICA Check Engine/Malfunction Indicator Lamp 16C The instrument panel cluster on about 32,587 of the above vehicles may have an inoperable check engine/malfunction indicator lamp (CEL/MIL). (JT) vehicles: CEL/MIL and cargo lamp indicator function are swapped. (JL) vehicles: CEL/MIL will not turn on. The CEL/MIL in and of itself will not affect emissions. However, if there was an emission issue that would require illumination of the CEL/MIL, the customer would not be alerted. The vehicle would be non-compliant to the OBD II regulation.

113270

Service Bulletin/Repair Instructions

CORE – HEATER

113271

Service Bulletin/Repair Instructions

CORE – HEATER

9100833 REV1

Service Bulletin/Repair Instructions

Fuel Delivery Module Before replacing the fuel module for DTCs P0461 and P062A and other not start, long crank, fuel gauge accuracy and drivability issues, the technician should disconnect the electrical connector at the pump and perform a visual inspection of the connector for and bent, spread, or pushed out terminals. Repair any issues found. Reconnect the plug and perform a push pull push to ensure the connector is fully installed. Then perform 3 keys cycles and listen to hear if the fuel pump is operational. If the fuel pump is heard that indicates that everything is operating correctly. If the pump is heard replacement is not necessary, any replacement will function in the same way.

112639

Service Bulletin/Repair Instructions

THROTTLE BODY – NONE

112640

Service Bulletin/Repair Instructions

THROTTLE BODY – NONE

S2508000025 REV.A

Service Bulletin/Repair Instructions

Instrument Panel Cluster (IPC) and Radio Compass Display has Dashes (--)

112862

Service Bulletin/Repair Instructions

MOTOR - BLOWER WITH WHEEL

112863

Service Bulletin/Repair Instructions

MOTOR - BLOWER WITH WHEEL

112842

Service Bulletin/Repair Instructions

BOLT - HEX FLANGE HEAD

9100833

Service Bulletin/Repair Instructions

112856

Service Bulletin/Repair Instructions

HEATER - ELECTRIC COOLANT

112857

Service Bulletin/Repair Instructions

HEATER - ELECTRIC COOLANT

S2609000009

Service Bulletin/Repair Instructions

Check Engine Light (CEL) Illuminated with Diagnostic Trouble Code (DTC) P0106 Manifold Absolute Pressure Sensor Performance Setting In The Powertrain Control Module (PCM)

18-008-26 REV. B

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0300 - Multiple Cylinder Misfire (Active or Stored status set during cold start catalyst heating). ● P0301 - Cylinder 1 Misfire (Active or Stored status set during cold start catalyst heating). ● P0302 - Cylinder 2 Misfire (Active or Stored status set during cold start catalyst heating). ● P0303 - Cylinder 3 Misfire (Active or Stored status set during cold start catalyst heating). ● P0304 - Cylinder 4 Misfire (Active or Stored status set during cold start catalyst heating). ● P0305-00 - Cylinder 5 Misfire (Active or Stored status set during cold start catalyst heating). ● P0306-00 - Cylinder 6 Misfire (Active or Stored status set during cold start catalyst heating).** ● P08A6 – Gear Lever Position Sensor System – Multiple Sensor Correlation. (Manual Transmission Only) ● P152F – Engine Hood Switch 2 / Engine Hood Switch 1 Correlation. Customers may also comment on one or more of the following: ● **The vehicle has a rough idle. ● The engine has a miss. ● Noisy valvetrain.** ● "Service Transmission” message on in the Instrument Panel Cluster (IPC) due to clutch slip detection. (Manual Transmission Only) NOTE: Customers might experience wheel spin or slippage and the PCM could interpreted the wheel spin or slippage as slipping the clutch too much and to avoid clutch damage, the customer may see the message in the IPC. ● Vehicle is in limp home mode. Other software enhancements included: ● Engine oil pump in high pressure mode with cold engine oil to improve valvetrain component reliability. This bulletin involves reprogramming the PCM with the latest available software.

9100835

Service Bulletin/Repair Instructions

Prior to replacing an inoperative passive entry door handle, perform Star Online S2623000040.

S2623000040

Service Bulletin/Repair Instructions

Passive Entry Exterior Door Handle Inoperative When Touched To Lock And Or Unlock.

111760

Service Bulletin/Repair Instructions

MOTOR AND LINKAGE - WINDSHIELD WIPER

21-041-26

Service Bulletin/Repair Instructions

Transmission Auxiliary Oil Pump Failure Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P0B0D-00 - Electric/Auxiliary Transmission Fluid Pump Motor Control Module. Customers may also comment on the following: ● Vehicle is in limp mode This bulletin involves replacing the transmission oil pump.

08-208-26 REV. A

Service Bulletin/Repair Instructions

Radio Message "Power Surge On USB Detected" Customers may comment on the following: ● The radio displays the message: “Power surge on USB hub detected” Fig. 1. NOTE: After the message appears, no USB devices function in the hub (no charging, no data). NOTE: Hub operation does not return until the vehicle undergoes a full key cycle.

111833

Service Bulletin/Repair Instructions

SENSOR – KNOCK

111834

Service Bulletin/Repair Instructions

SENSOR – KNOCK

08-208-26

Service Bulletin/Repair Instructions

18-047-26

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0300 - Multiple Cylinder Misfire (Active or Stored status set during cold start catalyst heating). ● P0301 - Cylinder 1 Misfire (Active or Stored status set during cold start catalyst heating). ● P0302 - Cylinder 2 Misfire (Active or Stored status set during cold start catalyst heating). ● P0303 - Cylinder 3 Misfire (Active or Stored status set during cold start catalyst heating). ● P0304 - Cylinder 4 Misfire (Active or Stored status set during cold start catalyst heating). ● P0305-00 - Cylinder 5 Misfire (Active or Stored status set during cold start catalyst heating). ● P0306-00 - Cylinder 6 Misfire (Active or Stored status set during cold start catalyst heating). Customers may also comment on one or more of the following: ● The vehicle has a rough idle. ● The engine has a miss. ● Noisy valvetrain. This bulletin involves reprogramming the PCM with the latest available software.

S2623000018

Service Bulletin/Repair Instructions

Wind Noise From Hard Top Freedom Panels Near Rear View Mirror While Driving.

08-133-26

Service Bulletin/Repair Instructions

Rear Defroster Inoperative Customers may experience one or more of the following: SYMPTOM: ● Rear window is not defrosting. ● The rear window glass left or right side defrost solder terminal is detached from the defrost grid. This bulletin involves replacing the Electric Backlite (EBL) wire connector repair and re-securing the electrical connector(s) to the rear window.

18-044-26

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0111-00 - Intake Air Temperature Sensor 1 Circuit Range Performance Bank 1. (In Active or Stored status) ● P0071-00 - Ambient Air Temperature Sensor Performance. (In Active or Stored status) ● P0072-00 - Ambient Air Temperature Sensor Circuit "A" Low. (In Active or Stored status) ● P0073-00 - Ambient Air Temperature Sensor Circuit "A" High. (In Active or Stored status) ● P0011-00 - Bank 1 Camshaft 1 Position Timing Over Advanced Or. (In Active or Stored status) ● P25E4-00 - B Camshaft Position - Unable To Achieve Locked Position Bank 1. (In Active or Stored status) ● P05BD-00 - Stop-Start Mode Switch Range/Performance. (In Active or Stored status) ● P0116-00 - Engine Coolant Temperature Sensor 1 Performance. (In Active or Stored status) ● P062B-00 - Internal Control Module Fuel Injector Control Performance. (In Active or Stored status) ● P0604-00 - Internal Control Module Random Access Memory Ram Error. (In Active or Stored status) ● P060C-00 - Internal Control Module Main Processor Performance. (In Active or Stored status)** ● P018B-00 - Fuel Pressure Sensor "B" Circuit Range/performance. **(In Active or Stored status)** ● P1CEA-00 - Boost Side EVAP Purge System Performance. **(In Active or Stored status)** ● P06DD-00 - Engine Oil Pressure Control Circuit Performance/Stuck Off. **(In Active or Stored status)** ● P00C6-00 - Fuel Rail Pressure Too Low - Engine Cranking. **(In Active or Stored status)** ● P0300-00 - Multiple Cylinder Misfire. **(In Active or Stored status)** Customers may also experience one or more of the following: ● **Oil Level High Warning in the Instrument Panel Cluster (IPC).** ● Fully Autonomous Parking Assist (FAPA) is not deactivated when accelerator pedal is pressed. ● Vehicle is not heating up fast enough at freezi

16C Combo REV2

Warranty Program/Extension

Emissions Recall 16C - Check Engine/Malfunction Indicator Lamp - Dealer Notification (Revision 2)

S2621000003 REV.A

Service Bulletin/Repair Instructions

The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

S2608000010

Service Bulletin/Repair Instructions

Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00, B1A16-00, and B1A17-00 in The Radio Frequency Hub (RFH)

S1408000384 REV.J

Service Bulletin/Repair Instructions

Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On

110399

Service Bulletin/Repair Instructions

HANDLE - INSIDE RELEASE

110400

Service Bulletin/Repair Instructions

HANDLE - INSIDE RELEASE

S2603000001

Service Bulletin/Repair Instructions

A suspected leak may be noticed on the front or rear axle pinion seal.

S2621000003

Service Bulletin/Repair Instructions

Service transmission/check engine warning indicator for the 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV transmissions that have fault codes P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

31-001-26 REV.A

Service Bulletin/Repair Instructions

Door Hem Aluminum Body Panel Corrosion Repair Customers may experience the following: SYMPTOM: ● Filifom corrosion at the hem area of the door. This bulletin involves removing corrosion and refinishing the hem area on the vehicle door.

110462

Warranty Program/Extension

D-25-15 Rev. B Aluminum Filiform Corrosion Warranty Policy and Vehicle Digital Imaging (VDI) Pre-Approval Process - ALL Vehicles

110469

Warranty Program/Extension

ID-25-11 Rev. B Aluminum Filiform Corrosion Warranty Policy and Vehicle Digital Imaging (VDI) Pre-Approval Process - ALL Vehicles

110429

Warranty Program/Extension

Warranty Newsletter – Volume 12, Issue 2

110431

Warranty Program/Extension

FCA Caribbean Warranty Newsletter – Volume 12, Issue 2

18-008-26 REV.A

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P08A6 – Gear Lever Position Sensor System – Multiple Sensor Correlation. (Manual Transmission Only) ● P152F – Engine Hood Switch 2 / Engine Hood Switch 1 Correlation. Customers may also comment on one or more of the following: ● "Service Transmission” message on in the Instrument Panel Cluster (IPC) due to clutch slip detection. (Manual Transmission Only) NOTE: Customers might experience wheel spin or slippage and the PCM could interpreted the wheel spin or slippage as slipping the clutch too much and to avoid clutch damage, the customer may see the message in the IPC. ● Vehicle is in limp home mode. Other software enhancements included: ● Engine oil pump in high pressure mode with cold engine oil to improve valvetrain component reliability. This bulletin involves reprogramming the PCM with the latest available software.

31-001-26

Service Bulletin/Repair Instructions

16C Combo REV1

Warranty Program/Extension

EMISSION RECALL – NORTH AMERICA Check Engine/Malfunction Indicator Lamp Reference: 16C

S1408000384 REV.I

Service Bulletin/Repair Instructions

Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS Related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On

S2408000024 REV.B

Service Bulletin/Repair Instructions

Power Top Switch Unresponsive, Full Retractable Sky Roof Does Not Open or Close

S2623000006

Service Bulletin/Repair Instructions

Washer Fluid Warning Lamp Illuminated When Reservoir Is Full

9100756

Service Bulletin/Repair Instructions

DO NOT REPLACE MULTIPLE SHOCKS UNLESS ALL ARE VERIFIED TO BE DEFECTIVE. Reference Master Tech article released in January 2026 for updated diagnostic and testing procedures. Master Tech link: https: //mastertech.playerlync.net/app/player/p2tQVm

109607

Service Bulletin/Repair Instructions

CALIPER ASSEMBLY - DISC BRAKE

18-008-26

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P08A6 – Gear Lever Position Sensor System – Multiple Sensor Correlation. (Manual Transmission Only) ● P152F – Engine Hood Switch 2 / Engine Hood Switch 1 Correlation. Customers may also comment on one or more of the following: ● "Service Transmission” message on in the Instrument Panel Cluster (IPC) due to clutch slip detection. (Manual Transmission Only) NOTE: Customers might experience wheel spin or slippage and the PCM could interpreted the wheel spin or slippage as slipping the clutch too much and to avoid clutch damage, the customer may see the message in the IPC. ● Vehicle is in limp home mode. Other software enhancements included: ● Engine oil pump in high pressure mode with cold engine oil to improve valvetrain component reliability. This bulletin involves reprogramming the PCM with the latest available software.

109820

Service Bulletin/Repair Instructions

SEAL - ROOF RAIL

109822

Service Bulletin/Repair Instructions

SEAL - ROOF RAIL

109724

Service Bulletin/Repair Instructions

Water Pump & Chain Case Cover

109727

Service Bulletin/Repair Instructions

Water Pump & Chain Case Cover

109281

Service Bulletin/Repair Instructions

CENTER STACK – NONE

109223

Service Bulletin/Repair Instructions

BEZEL - INSTRUMENT PANEL

109224

Service Bulletin/Repair Instructions

DOOR - PASSENGER AIR BAG

08-394-25 REV. A

Service Bulletin/Repair Instructions

Telematics Box Module (TBM) Backup Battery Replacement When DTC B1E21 Is Present Technicians may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set the following Diagnostic Trouble Code (DTC): ● B1E21-96 - Backup Battery Component Internal Failure.

16C Combo

Emissions

Check Engine/Malfunction Indicator Lamp 16C

9100734

Service Bulletin/Repair Instructions

If the DTC B1E21-96: Backup Battery-Component Internal Failure is active and customer states Popup message will show at the radio: "Battery of Uconnect Box requires service. SOS call and related functions may be unavailable. Please visit an authorized dealer." PLEASE do not Replace the TBM module, only replace TBM Internal Battery (inside Telematics Box Module) and order PN68493347

9100736

Service Bulletin/Repair Instructions

Verify "Z" part number availability. Order a "Z" part number for all Exchange Orders: Warranty, Mopar, Customer pay and Service contract. Order"68" part number for New unsold units only

08-394-25

Service Bulletin/Repair Instructions

Telematics Box Module (TBM) Backup Battery Replacement When DTC B1E21 Is Present echnicians may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set the following Diagnostic Trouble Code (DTC): ● B1E21-96 - Backup Battery Component Internal Failure

S1819000004 REV.R

Service Bulletin/Repair Instructions

Shimmy Felt In Front End

108544

Service Bulletin/Repair Instructions

SWITCH - POWER WINDOW

108655

Warranty Program/Extension

D-25-15 Rev. A Aluminum Filiform Corrosion Warranty Policy and Vehicle Digital Imaging (VDI) Pre-Approval Process - ALL Vehicles

108657

Warranty Program/Extension

ID-25-11 Rev. A Aluminum Filiform Corrosion Warranty Policy and Vehicle Digital Imaging (VDI) Pre-Approval Process - ALL Vehicles

108463

Service Bulletin/Repair Instructions

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

108464

Service Bulletin/Repair Instructions

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

S2508000100

Service Bulletin/Repair Instructions

Intermittent Uconnect Box Requires Service Message. TBM Setting Stored Or Pending DTCs B22A9, B1560, B1561, B1562

S1805000006 REV.B

Service Bulletin/Repair Instructions

ESC Light Illuminated. DTC C1252-92 VACUUM PUMP CONTROL CIRCUIT And Or P258B ELECTRONIC VACUUM PUMP PERFORMANCE

S2509000009

Service Bulletin/Repair Instructions

Engine Oil Leak

9100684

Service Bulletin/Repair Instructions

When servicing/replacing 68415437A$ Transmission, take care to not damage the PIM to P2 harness. Also, when reinstalling the harness, route the harness properly and secure it at all the retention points.

105646

Service Bulletin/Repair Instructions

MODULE - STEERING CONTROL & COLUMN

9100325 Rev 1

Service Bulletin/Repair Instructions

Before replacing any parts please refer to SOL S2518000008 if it applies to the vehicle you are working on based on a VIN search in Service Library. Before replacing this part due to Engine Light On with P1CEA (Boost Side EVAP Purge System Performance), check for: 1) Improperly connected or kinked/pinched Purge Hoses at the Ejector Tees on the Air Box or Duct. 2) Improperly connected or kinked/pinched Purge Hose at the Purge Solenoid or OBD Valve. 3) Improperly connected or kinked/pinched Purge Hose at the Intake. 4) Check for the correct Purge Hoses installation.

23-034-25

Service Bulletin/Repair Instructions

Not applicable to vehicles built for US market. Parking Brake Will Not Release Customers may comment on the following: ● Park brake will not release. This bulletin involves using glue to repair the park brake handle positioning.

9100670

Service Bulletin/Repair Instructions

Data collection required for all 2020-2026MY vehicles with 3.6L PSU engines during any of their first 3 engine oil changes. This data collection is applicable to all vehicle with engines with sales codes: ERG, ERC, EH3 and ERF. To assist with monitoring and quality improvement of the 3.6L engine, every time a vehicle comes for any of the first 3 oil changes, please use wiTECH to record the total engine idle time and the total engine runtime. 1. Prior to perform the oil change connect wiTECH diagnostic tool. 2. Navigate to the topology screen on the action item section. 3. Once the topology screen loads, disconnect wiTECH and continue with oil change.

S2218000003 REV.B

Service Bulletin/Repair Instructions

Customer complaint may include a Mil On/Check Engine Lamp On and Electronic Throttle Control (ETC) Lamp On. There may also be associated driveability issues. Upon further investigation, the following fault codes may be found in the PCM:

107418

Service Bulletin/Repair Instructions

SWITCH - CLUTCH STARTER INTERLOCK & MASTER CYLINDER ASSEMBLY - CLUTCH

23-008-25 REV. A

Service Bulletin/Repair Instructions

Exterior Front Lamps Condensation Clearing Procedure *Some customers may report that on occasion vehicle exterior front lamps (headlamps, fog lamps, grille lamps, logo lamps or signature lamps) assemblies are fogged with a light layer of condensation on the inside of the lenses*

02-002-25 REV. A

Service Bulletin/Repair Instructions

Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts.

31-001-25 REV. B

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.

31-001-25 REV. A

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.

31-001-25

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates

08-230-25

Service Bulletin/Repair Instructions

Flash: Radio Frequency Hub Module (RFHM) Updates Customers must experience the following: ● Customers may be concerned about vehicle theft due to ability of key FOBs to be programmed through RFHM. Software enhancement includes: ● Update to the RFHM software to prevent unauthorized keyfob programming. ● This is intended to deter an unwanted drive off of the vehicle without the customer's knowledge. This bulletin involves updating the RFHM module with the latest available software.

S2509000001 REV.B

Service Bulletin/Repair Instructions

Engine Rattle Noise

S2422000001 REV.D

Service Bulletin/Repair Instructions

Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.

09-018-25

Service Bulletin/Repair Instructions

Engine Cylinder Block Porosity Inspection - Engine Cold Start Rough Idle Customers may experience the following: ● Rough engine idle when cold starting the engine. ● Low coolant level in coolant recovery bottle.

105648

Service Bulletin/Repair Instructions

MODULE - ENGINE CONTROLLER

9100627

Service Bulletin/Repair Instructions

To inform dealers about the 850RE valve body PN: R8348504A connector: the original 16-pin connector included six pins that were not used in this application. To simplify the design, the connector has been optimized and updated to a 10-pin configuration.

9100624

Service Bulletin/Repair Instructions

Verify Reman part number availability. Order the "R" part number for all orders:

21-009-25 REV. C

Service Bulletin/Repair Instructions

850RE D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must have at least 11,265 km (7,000 mi.) and exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ● Transmission slips when shifting. ● Vehicle will not move in reverse. ● Vehicle will not shift higher than third gear This bulletin involves replacing the D clutch.

S2208000138 REV.B

Service Bulletin/Repair Instructions

Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed

9100622

Service Bulletin/Repair Instructions

When replacing a camshaft and parts kit (P/N 68661146xx and/or 68661147xx), it is NOT necessary to order the roller-finger followers (rocker arms) separately, as these are included in the camshaft parts kit.

105647

Service Bulletin/Repair Instructions

RAIL - REAR

14-010-25 REV. C

Service Bulletin/Repair Instructions

Frequent Repairs Of Fuel System Components Such As Fuel Filters Numerous Stellantis vehicles having fuel line components replaced such as diesel fuel filters. Occasionally, components are replaced before their standard life expectancy or when not contaminated with debris.

9100614

Service Bulletin/Repair Instructions

ADJUSTER Valve Lash Customer's complaint may include a ticking noise coming from the engine. Technician's observations can refer to spongy or stuck hydraulic lash adjusters. Exhaust lash adjusters found with a "spongy" condition (compressible plunger) leading to the assumption of being defective/malfunctioning. EXHAUST lash adjusters are designed to be COMPRESSIBLE by hand. Intake lash adjusters found with a stiff or stuck condition (non-compressible plunger) leading to the assumption of being defective/malfunctioning. INTAKE lash adjusters are designed to be NON COMPRESSIBLE by hand. Do Not Replace EXHAUST lash adjusters when the following condition is present: should be compressible, but they will exert a reactionary spring force during compression and return to full expansion without a compression force. Do Not Replace INTAKE lash adjusters when the following condition is present: should feel very firm and difficult to compress. Once the correct functioning of the intake and exhaust lash adjusters is validated with the procedure above, refer to the Service Manual "HYDRAULIC LIFTER(S) NOISE DIAGNOSIS" procedure. After the corresponding service procedures from the Service Manual involving the Lash Adjusters have been conducted, refer to the detailed instructions in the Service Manual to diagnose and/or service any other component.

09-015-25

Service Bulletin/Repair Instructions

Spark Knock/Engine Symptoms Customers may experience the following: ● Knocking or pinging noise coming from the engine upon acceleration. This bulletin involves cleaning the piston heads and cylinder head combustion chambers to resolve a spark knock condition being caused by oil intrusion through the PCV system.

105590

Service Bulletin/Repair Instructions

Warranty Newsletter – Volume 11, Issue 6

105591

Warranty Program/Extension

FCA Caribbean Warranty Newsletter – Volume 11, Issue 6

14-010-25 REV. B

Service Bulletin/Repair Instructions

Frequent Repairs Of Fuel System Components Such As Fuel Filters Numerous Stellantis vehicles having fuel line components replaced such as fuel filter. Occasionally, components are replaced before their standard life expectancy or when not contaminated with debris

9100605

Service Bulletin/Repair Instructions

Shim - felt GIM # NUSENGCHR24018991: JL JT sun visor center support BSR. Add felt shim 68736674AA - 43MM OD x 10mm ID x 1mm thick.

18-027-25

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers may experience the following: ● Engine knocking or "pinging" during extreme hot and dry ambient temperatures if only using 91 Octane fuel This bulletin involves reprogramming the PCM with the latest available software.

14-010-25 REV. A

Service Bulletin/Repair Instructions

Frequent Repairs Of Fuel Line Components Such As Fuel Filters Numerous Stellantis vehicles having fuel line components replaced such as fuel filter. Occasionally, components are replaced before their standard life expectancy or when not contaminated with debri

S2408000024REVA

Service Bulletin/Repair Instructions

Power Top Switch Unresponsive, Full Retractable Sky Roof Does Not Open or Close Customer Complaint/Technician Observation: The owner complains the top system is inoperative and that by pressing the switches the Power Top does not make any movement. Technician may or may not have Diagnostic Trouble Codes (DTCs). Repair Procedure: Perform the power top calibration prior to any switch or parts replacement.

104966

Service Bulletin/Repair Instructions

BEZEL & INDICATOR- GEAR SHIFT INDICATOR

02-002-25

Service Bulletin/Repair Instructions

Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts.

9004003

Service Bulletin/Repair Instructions

Backlite Heated Liftgate Glass Assembly: For rear window defrost inoperative concerns where heated glass electrical tab has become detached, it is not necessary to replace the glass assembly. For loose or detached electrical tab, refer to TSB 23-007-25 for repair procedures on reattaching a loose tab. For burned or discolored gridlines on hard tops, DO NOT change the complete Flipper glass assembly. This discoloration is oxidation of the ceramic silver material and is normal. The Engineering standard call out the fact that this bus bar will change in color and is not a deterioration of the material or performance.

09-011-25

Service Bulletin/Repair Instructions

Misfire Diagnostic Trouble Codes (DTCs), Rough Idle, Valvetrain Noise Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0301 - Cylinder 1 Misfire. ● P0302 - Cylinder 2 Misfire. ● P0303 - Cylinder 3 Misfire. ● P0304 - Cylinder 4 Misfire. ● P0305 - Cylinder 5 Misfire. ● P0306 - Cylinder 6 Misfire. Customers may comment on one or more of the following: ● Rough idle. ● Valvetrain noise.

S2508000039

Service Bulletin/Repair Instructions

Universal Garage Door Opener (UGDO) Inoperative, LED Indicator Lamps Not Illuminating

S2323000002 REV.A

Service Bulletin/Repair Instructions

Washer Light On And Will Not Turn Off After Adding Washer Solvent.

105038

Service Bulletin/Repair Instructions

TUBE - FUEL INJECTOR SUPPLY & GASKET - NONE

105039

Service Bulletin/Repair Instructions

TUBE - FUEL INJECTOR SUPPLY & GASKET - NONE

9100498 Rev 3

Service Bulletin/Repair Instructions

3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. Refer to SOL # S2509000004. It is also important to confirm that the vehicle being repaired has the latest calibration/software update for oil pump operation mode (high pressure mode) during engine start up. RU, VF, WL & WD vehicles already include the latest oil pump mode in all 25MY and beyond. 24MY service releases are also available. JL & JT were updated as a running change in 24MY and beyond (08/15/24 & 08/19/24 respectively). 24MY service releases available. DT was updated starting 25MY and beyond. If the vehicle to be repaired is a 24MY vehicle with a service release available, please follow the released service procedures to update to the corresponding calibration/software.

9100534 Rev 1

Service Bulletin/Repair Instructions

Transmission "Transmission For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, visible ""glitter"" or debris in the pan and fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Complete unit replacements instead of repairs for these DTCs may be subject to chargeback."

9100570

Service Bulletin/Repair Instructions

Transmission Fluid Please note fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Visible "glitter" or debris in the pan does not justify complete unit replacements.

S2008000103 REV.B

Service Bulletin/Repair Instructions

No Start, Stop Start Inoperative, Battery or Check Engine Light (CEL) Illuminated

S258A000013

Service Bulletin/Repair Instructions

AM Radio Static, With No Active or Stored Radio Antenna Diagnostic Trouble Codes (DTC).

9100491 Rev 1

Service Bulletin/Repair Instructions

Drag Link Long Socket FOR STEERING SHIMMY DIAGNOSIS, PLEASE REFERENCE S1819000004 Rev. Q AND 19 - Steering / Diagnosis and Testing (IN SERVICE LIBRARY). PLEASE REFER 19 - Steering / Linkage / END, Tie Rod / Diagnosis and Testing IF YOU HAVE BALL JOINT LOOSENESS CONCERN. PLEASE DO NOT REPLACE DRAG LINK AND TIE ROD UNLESS PART HAS VISIABLE DAMAGE OR FREE PLAY EXCEEDS SPECS.

9100547

Service Bulletin/Repair Instructions

Telematics Box Module Verify Z part number availability. Order a Z part number for all Exchange Orders: warranty, Mopar, customer pay and service contract. Order regular part number for New unsold units only.

104558

Warranty Program/Extension

FCA Caribbean Warranty Newsletter – Volume 11, Issue 4

104557

Warranty Program/Extension

Warranty Newsletter – Volume 11, Issue 4

21-009-25 REV. B

Service Bulletin/Repair Instructions

850RE D Clutch Repair **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must have at least 11,265 km (7,000 mi.) and exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs):** ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ● Transmission slips when shifting. ● Vehicle will not move in reverse. ● Vehicle will not shift higher than third gear This bulletin involves replacing the D clutch.

08-099-25

Service Bulletin/Repair Instructions

Camshaft Sensor DTC Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P0341 - Camshaft Position Sensor - Performance Bank 1 - Sensor 1. This bulletin involves repairing the cam sensor harness and re-routing the generator wiring.

S2523000024

Service Bulletin/Repair Instructions

Rear Defogger Solder Terminals Detached.

S2408000015 REV.D

Service Bulletin/Repair Instructions

Remote Keyless Entry (RKE) Functions Do Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed, Adding Remote Start

S2509000004

Service Bulletin/Repair Instructions

Misfire DTCs, Rough Idle, Valvetrain Noise

S2523000010 REV.A

Service Bulletin/Repair Instructions

Exterior Rear View Mirror Stained And Will Not Clean.

S2523000015 REV.A

Service Bulletin/Repair Instructions

Replacement Exterior Mirror Glass Connector Does Not Match For Blind Spot.

S2509000001 REV.A

Service Bulletin/Repair Instructions

Engine Rattle Noise

21-022-25 REV. A

Service Bulletin/Repair Instructions

Flash: Transmission Control Module (TCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P1DB7-00 - Torque Converter Clutch Performance. ● P0701 Transmission Control System Range/Performance. Customers may also experience one or more of the following: ● The check engine light illuminates. ● Overheating of the transmission fluid. This bulletin involves reprogramming the TCM with the latest available software.

9100534

Service Bulletin/Repair Instructions

Transmission For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Complete unit replacements instead of repairs for these DTCs may be subject to chargeback.

103773

Service Bulletin/Repair Instructions

TOP KIT - SOFT

9100390 Rev 1

Service Bulletin/Repair Instructions

D Clutch Repair Kit For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Complete unit replacements instead of repairs for these DTCs may be subject to chargeback.

9100471

Service Bulletin/Repair Instructions

CANISTER Vapor -If an issue is detected with the Evaporative System Integrity Module (ESIM) Detector and not the Vapor Canister, only replace the ESIM Detector. -Before replacing the Vapor Canister due to Hard to Fill condition, replicate the condition at the Gas Station. If the condition is replicated, then check: 1) for kinked or pinched Clean Air Hose between the ESIM and the EVAP Air Filter; 2) for plugged EVAP Air Filter; 3) for kinked or pinched Vapor Hose between the Fuel Tank and the Vapor Canister. If the EVAP Filter is restricted, the replace the Filter. -Check if the Vapor Canister is flooded with fuel or the Recirculation Line has fuel. If fuel is found in the Vapor Canister or the Recirculation Line, then drop the Fuel Tank, remove the FDM Lock Ring to check if the internal Vapor Line is properly connected to the FDM Port. If the Vapor Line is not connected, then drain the fuel from the internal Vapor Line and properly connect to the FDM. Replace the Vapor Canister and the ESIM.

S2405000001 Rev B

Service Bulletin/Repair Instructions

Antilock Brake System (ABS) Module Will Not Initialize After Recent Service Replacement.

21-022-25

Service Bulletin/Repair Instructions

Flash: Transmission Control Module (TCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Codes (DTCs): ● **P1DB7-00- Torque Converter Clutch Performance.** ● P0701 Transmission Control System Range/Performance. **Customers may also experience one or more of the following: ● The check engine light illuminates. ● Overheating of the transmission fluid.** REPAIR SUMMARY: This bulletin involves reprogramming the TCM with the latest available software.

103986

Service Bulletin/Repair Instructions

D-23-04 Rev. H 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification

103987

Service Bulletin/Repair Instructions

ID-23-03 Rev. I 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification

08-060-25

Service Bulletin/Repair Instructions

Flash: Power Inverter Module(PIM) Flash Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician must find one or more of the following Diagnostic Trouble Code (DTC) has been set: ● P0C19-00 - Drive Motor A Torque Delivered Performance. ● P1B03-00 - Resolver Signal / MCPA Rationality. Customers may experience the following: ● Electric Vehicle (EV) system shuts down while transferring over to Internal Combustion Engine (ICE) motive power. Engine Stop Start (ESS) function will also not operate as a result of this condition This bulletin involves reprogramming the Auxiliary Hybrid Control Processor (AHCP) also known as PIM, with the latest available software.

103618

Service Bulletin/Repair Instructions

HOSE - COOLANT RECOVERY BOTTLE

S2509000002

Service Bulletin/Repair Instructions

Engine Noise

S258A000009

Service Bulletin/Repair Instructions

Apple CarPlay Does Not Complete The First Initial Wireless Connection.

S2523000015

Service Bulletin/Repair Instructions

Replacement Exterior Mirror Glass Connector Does Not Match For Blind Spot.

9100458

Service Bulletin/Repair Instructions

Engine Complete With scope to reduce cost per repair, Stellantis Engineering ask to use long block instead of engine complete replacement for GME T4 DOHC. Before to replace Long Block Engineering is asking to follow these checks for an overheating suspect diagnosis: 1) BLOC-CHECK-KIT (BLOCK TESTER or CO2 Tester) 2) CYLINDER LEAKAGE TEST 3) COOLING SYSTEM LEAKS -INTERNAL ENGINE LEAKAGE INSPECTION If no one of this checks (1-2-3) fails it does not need to replace long block ( even less full engine) but just the component causing the coolant leak.

9100498 REV 1

Service Bulletin/Repair Instructions

3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. These conditions may be related to worn intake camshaft high lift lobe(s), and intake rocker arm(s) high lift slider. High mileage failure (10,000-60,000 miles). 1. Remove the valve cover(s) per the released service procedures. The use of a stethoscope or DTC specific cylinder misfire codes can help to locate the condition to the left or right bank. 2. Once it has been visually confirmed that there is wear on the high lift intake lobe(s) & rocker arm(s) slider, there is a special service kit for this type of repair which should be used, instead of replacing the complete engine/long block. This kit contains the parts required for the repair (intake cam, rocker arms, sealer and gaskets). Once it is confirmed that the repair will be done using the camshaft/Rocker arms kit, it is also important to confirm that the vehicle being repaired has the latest calibration/software update for oil pump operation mode (high pressure mode) during engine start up. RU, VF, WL & WD vehicles already include the latest oil pump mode in all 25MY and beyond. 24MY service releases are also available. JL & JT were updated as a running change in 24MY and beyond (08/15/24 & 08/19/24 respectively). 24MY service releases available. DT was updated starting 25MY and beyond. If the vehicle to be repaired is a 24MY vehicle with a service release available, please follow the released service procedures to update to the corresponding calibration/software update.

S2108000015 REV.J

Service Bulletin/Repair Instructions

Uconnect Box Require Service Message

S2523000010

Service Bulletin/Repair Instructions

Exterior Rear View Mirror Stained And Will Not Clean.

103292

Service Bulletin/Repair Instructions

MODULE - BATTERY HEATER

S2509000001

Service Bulletin/Repair Instructions

Engine Rattle Noise

09-003-25

Service Bulletin/Repair Instructions

Oil Leaking From Oil Filter Area Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set the following Diagnostic Trouble Code (DTC): ● P06DD - Engine Oil Pressure Control Circuit Stuck Off. Customers may comment on the following: ● Oil found on the ground beneath the vehicle.

S1819000004 REV.Q

Service Bulletin/Repair Instructions

Shimmy Felt In Front End

23-008-25

Service Bulletin/Repair Instructions

Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses.

S2323000004 REV.A

Service Bulletin/Repair Instructions

Defogger Is Not Working. Terminal Detached From The Glass.

23-007-25

Service Bulletin/Repair Instructions

Rear Defroster Inoperative Customers may experience one or more of the following: ● Rear window is not defrosting. ● The rear window glass left or right side defrost solder terminal is detached from the defrost grid. This bulletin involves replacing the Electric Backlite (EBL) wire connector repair and re-securing the electrical connector(s) to the rear window

S2208000154 REV.A

Service Bulletin/Repair Instructions

Service Hybrid Electric Vehicle System Message Displayed In The IPC. Vehicle Shakes During A Cold Start And Noise Is Heard Near The P2 Motor. DTC’s U0287-00 And B273C-00

S2008000084 REV.C

Service Bulletin/Repair Instructions

Cluster Warning Lamp is on, Service 4WD Message

S228A000005 REV.E

Service Bulletin/Repair Instructions

Uconnect Box Error Message, With Active or Stored Cellular Antenna Open or Short Diagnostic Trouble Codes (DTCs)

9100498

Service Bulletin/Repair Instructions

103262

Service Bulletin/Repair Instructions

HINGE - DOOR

21-009-25 REV.A

Service Bulletin/Repair Instructions

D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ● Transmission slips when shifting. ● Vehicle will not move in reverse. ● Vehicle will not shift higher than third gear. This bulletin involves replacing the D clutch

102934

Service Bulletin/Repair Instructions

THROTTLE BODY

S1408000384 REV.H

Service Bulletin/Repair Instructions

102811

Service Bulletin/Repair Instructions

TRANSMISSION - 8 SPEED

102384

Service Bulletin/Repair Instructions

EVAPORATOR - AIR CONDITIONING

9100491

Service Bulletin/Repair Instructions

21-009-25

Service Bulletin/Repair Instructions

D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. **Customers may also comment on one or more of the following: ● Transmission slips when shifting. ● Vehicle will not move in reverse. ● Vehicle will not shift higher than third gear.** This bulletin involves replacing the D clutch."

S2405000001 REV.A

Service Bulletin/Repair Instructions

Antilock Brake System (ABS) Module Will Not Initialize After Recent Service Replacement.

S1408000384 REV.G

Service Bulletin/Repair Instructions

23-060-24

Service Bulletin/Repair Instructions

B-Pillar Water Leak When Vehicle Is Parked On A Hill Customers may experience one or more of the following: ● The vehicle will leak water from the top of the B-pillar when the vehicle is parked on a downward incline. ● Water on door trim or carpet. ● Water drips down the inside door and panel This bulletin includes performing a water test and possibly adding foam pads to both Freedom Panels.

9100468

Service Bulletin/Repair Instructions

FUEL VAPOR CANISTER FILTER EVAP Fuel Filters are to be checked for restriction / blockage on a regular schedule as indicated in the Owner s Manual. If the Filter is restricted or blocked then replace the part. For customers that drive light duty trucks in extreme dusty and dirty road conditions, please reference information only TSB 25-009-24 for an available MOPAR Dual EVAP Filter kit that is customer paid.

101792

Service Bulletin/Repair Instructions

FILTER - AIR

101816

Service Bulletin/Repair Instructions

FILTER - AIR

9100363 Rev1

Service Bulletin/Repair Instructions

Turbocharger Kit Please note many parts of the Turbo Assembly can be serviced separately and complete turbo replacement may not be necessary. If the Turbo is being replaced for a noise or a rattle, inspect the wastegate for binding. The actuator kit is serviced separately. If the turbo is being replaced for an oil leak concern, please inspect the area around the turbo oil feed oring for a leak. The o-ring is serviced separately

102365

Warranty Program/Extension

Warranty Newsletter – Volume 10, Issue 11

102366

Service Bulletin/Repair Instructions

FCA Caribbean Warranty Newsletter – Volume 10, Issue 11

21-039-24 REV. H

Service Bulletin/Repair Instructions

S248A000016

Service Bulletin/Repair Instructions

Customer complaints regarding rear view camera inoperative or flickering blue radio screen display while transmission is in reverse or blank screens when selecting the rear camera view following a recent service repair involving the removal and installation of the rear spare tire carrier

102300

Warranty Program/Extension

Warranty Bulletin D-23-04 Rev. G 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification

102315

Warranty Program/Extension

Warranty Bulletin ID-23-03 Rev. H 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification

S2323000074 REV.A

Service Bulletin/Repair Instructions

Buzz Squeak Rattle (BSR) From Sound Bar Or Sport Bar Area.

S2423000050

Service Bulletin/Repair Instructions

Buzz Squeak Rattle (BSR) From Speaker Sound Bar At High Volume Level.

101684

Service Bulletin/Repair Instructions

COVER KIT - HOOD

101285

Service Bulletin/Repair Instructions

DAMPER - NONE

S2422000001 REV.C

Service Bulletin/Repair Instructions

Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.

21-039-24 REV. G

Service Bulletin/Repair Instructions

S2423000045

Service Bulletin/Repair Instructions

Heated Steering Wheel Inoperative And Or Not Hot Enough.

101232

Service Bulletin/Repair Instructions

Plate - Planetary

101137

Warranty Program/Extension

Warranty Bulletin D-23-04 Rev. F 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification

101140

Service Bulletin/Repair Instructions

FCA Caribbean Warranty Bulletin ID-23-03 Rev. G 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification

21-039-24 REV. F

Service Bulletin/Repair Instructions

21-039-24 REV. E

Service Bulletin/Repair Instructions

100774

Service Bulletin/Repair Instructions

SWITCH - HEADLAMP

S2408000110

Service Bulletin/Repair Instructions

Vehicle Does Not Start. Electric Steering Column Lock (ESCL) Does Not Function, Steering Wheel Locked. DTCs U1433-62, U1412-62, U1517-62 In The ESCL

100875

Warranty Program/Extension

Warranty Bulletin D-23--04 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification

100876

Warranty Program/Extension

FCA Caribbean Warranty Bulletin ID-23-03 Rev. F 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification

97802

Service Bulletin/Repair Instructions

SWITCH - HEADLAMP

S2405000001

Service Bulletin/Repair Instructions

Antilock Brake System (ABS) Module Will Not Initialize After Recent Service Replacement.

100192

Service Bulletin/Repair Instructions

BOW - FOLDING TOP

21-039-24 REV. D

Service Bulletin/Repair Instructions

S2422000002

Service Bulletin/Repair Instructions

Low Tire Pressure. Tire Valve Stem And Tire Pressure Monitor (TPM) Sensor Service.

S228A000017 REV.A

Service Bulletin/Repair Instructions

Battery Drain Suspected or "Identified" From USB or Media Hub

21-039-24 REV. C

Service Bulletin/Repair Instructions

100164

Other

PUMP – WATER & CONNECTOR - OIL COOLER TUBE

S2123000046 REV.B

Service Bulletin/Repair Instructions

Click Noise From Front End While Driving And Or Turning.

S1819000004 REV.P

Service Bulletin/Repair Instructions

Shimmy Felt In Front End

99659

Other

WHEEL - STEEL

S2408000087

Service Bulletin/Repair Instructions

Shifter Binding Or "Service Shifter" Message On The Cluster. DTSs U11C3, U1069, U0074, U114C

21-039-24 REV. B

Service Bulletin/Repair Instructions

23-004-24 REV. A

Service Bulletin/Repair Instructions

Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses.

99885

Warranty Program/Extension

WARRANTY BULLETIN D-23-04 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification (Rev. D)

99887

Service Bulletin/Repair Instructions

FCA Caribbean Warranty Bulletin ID-23-03 Rev. E adds 2024 model year vehicles and updates the Collision Service Bulletin number

S2403000002

Service Bulletin/Repair Instructions

Griding/Gear Clash From Transfer Case When Going Into 4WD, Above 5 mph (8 kph).

S2403000003

Service Bulletin/Repair Instructions

Service 4WD Message Illuminated. Diagnostic Trouble Code (DTC) C2201-49 FDCM/FTCM Internal – Internal Electrical Failure, Set.

31-001-24

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.

99500

Other

CARRIER – PLANETARY & SHAFT KIT - OUTPUT

9100390 Rev1

Service Bulletin/Repair Instructions

D Clutch Repair Kit TSB 21-039-24 REV A - D-Clutch repair kit missing Carrier Output Shaft Seals It has been identified the Carrier Output Shaft is missing 2 seals for some of the kits delivered to dealers. These seals are not available individually. MOPAR is working to get the parts. Do not rebuild the transmission without these seals otherwise the vehicle will not have reverse. Please refer to STAR Online Publication S2421000001 for instructions for inspecting if the seals are present on the Output Shaft Carrier Shaft. If seals are missing, please return the D-Clutch Kit as defective and order another kit. Transmission replacement is not recommended as this issue should be solved with replacement kits

S2421000001

Service Bulletin/Repair Instructions

No Reverse And/Or Forward Gear After D-Clutch Repair.

9100390

Service Bulletin/Repair Instructions

08-160-24

Service Bulletin/Repair Instructions

Management Procedure for Customer Issues in Connected Services Customers may experience the following: ● Various Connected Services issues. The purpose of this informative Technical Service Bulletin (TSB) is to support the Network on the following topics: ● Discern the different kinds of connected service issues (onboard / offboard). ● Support the customer in his journey to open a request via Customer Care. ● Address on the correct actions to properly manage a customer complaining about the received assistance.

08-162-24

Service Bulletin/Repair Instructions

Flash: Drivetrain Control Module (DTCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● C140E-00 - Transfer Case Motor Blocked. This bulletin involves reprogramming the DTCM with the latest available software and possibly replacing the transfer case motor actuator.

S2408000015 REV.C

Service Bulletin/Repair Instructions

Remote Keyless Entry (RKE) Functions Do Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed, Adding Remote Start

S2423000033

Service Bulletin/Repair Instructions

Water Leak From Front Door. Water On Front Floor.

08-149-24

Service Bulletin/Repair Instructions

12V Battery Low Level Charge Notification On Customer’s Mobile Application Vehicle's 12V battery Low Level Charge notification on customer’s mobile application.

09-015-24

Service Bulletin/Repair Instructions

Engine Ticking Noise Customers may experience the following: ● Engine makes an abnormal ticking noise. There may be Diagnostic Trouble Codes (DTCs) present.

98931

Other

PUMP – WATER & CONNECTOR - OIL COOLER TUBE

98933

Other

PUMP – WATER & CONNECTOR - OIL COOLER TUBE

S1408000384 REV.F

Service Bulletin/Repair Instructions

9100360

Service Bulletin/Repair Instructions

SWITCH Power Window Before replacing the window switch, please follow these steps: 1.- Review the master window Switch for any physical issue (Button stuck, broke). If not, physical issue is found move to next step 2.- Make sure all the switches harness are properly connected, disconnect the switch and reconnect it, and reverify the issue. If after performing these steps the switch remains faulty, please replace the switch

94006

Other

WIPERUNIT - WINDSHIELD WIPER, BLADE - FRONT WIPER

98861

Other

WIPERUNIT - WINDSHIELD WIPER, BLADE - FRONT WIPER.

21-039-24 REV. A

Service Bulletin/Repair Instructions

D Clutch Repair Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch.

S2307000002 REV.B

Service Bulletin/Repair Instructions

Suspected Engine Coolant Leak

S1723000037 REV.A

Service Bulletin/Repair Instructions

Freedom Panel Underside Rough And Or White Coating Flaking

ZD8 Combo Rev3

Service Campaign

Customer Satisfaction Notification ZD8 Coolant Leak

S2423000029

Service Bulletin/Repair Instructions

Water Leaking Near Front Bulkhead Or Cowl Area On Driver’s Side.

21-039-24

Service Bulletin/Repair Instructions

9100338REV1

Service Bulletin/Repair Instructions

GENERATOR Engine Prior to alternator/generator removal: 1. Inspect & check all electrical connections to the alternator a. 2-way connector containing field control circuit & alternator sense voltage circuit. b. Unplug & plug-in the 2-way connector for field & sense circuit. Verify the connection is tight & check for any bent pins in alternator connector or damage to female terminals in connector. c. Check Alternator B+ Stud connection to be sure nut is securing positive cable terminal properly (i.e. nut is clamping terminal & connection is tight). d. Check fuse between the alternator B+ stud & PDC terminal to make sure it is not blown. e. Be sure to follow service manual sections on ALTERNATOR CONTROL CIRCUIT DIAGNOSTIC & ALTERNATOR SENSE CIRCUIT DIAGNOSTIC looking for any opens & shorts (to ground or battery voltage). 2. Check/verify all grounds in the charging system circuit a. Check tightness of mounting bolts securing alternator to engine block. Alternator is a case ground component. b. Check main ground from engine to chassis; connection must be tight. c. Check battery ground cable connections are tight. d. Potentially, loosen alternator mounting bolts, without removing alternator, and re-tighten to torque specifications in service manual. e. After all steps above are complete, re-start engine & check charging system operation. 3. Verify that the Smart Charging System is not the reason for alternator low voltage & current output (Amps). a. Alternator charging can be suspended during engine idle operation because of the Smart Charge strategy. b. Refer to service manual section "System Operation - Smart Charging System". c. Refer to Star Case S2008000031 Rev A for low charging voltage & Smart Charge Mode Voltage Range diagram & mode descriptions. d. The alternator has no internal regulator; thus, has no smart circuitry. All alternator control signals come from ECM. 4. If alternator is faulty, remove alternator & mounting bolts. Return alternator with bolts for analysis at QEC.

08-106-24 REV. C

Service Bulletin/Repair Instructions

Vehicle displays Performance Limited Fuel System Customers may experience the following: ● Vehicle displays "Performance Limited Fuel System" with no Diagnostic Trouble Codes (DTCs). This bulletin involves inspecting the N17 circuit of the High Pressure Fuel Pump Solenoid harness for contact with a cooling system hose clamp.

21-034-24

Service Bulletin/Repair Instructions

Flash: Transmission Control Module (TCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs): ● P0701 - Transmission Control System Range/Performance. This bulletin involves reprogramming the TCM with the latest available software.

9100010

Service Bulletin/Repair Instructions

Axle Assembly Do not replace the Axle for Axle Locker Sensor failure. The parts kit (SENSOR KIT, Axle: 68544629A$) must be used to repair the Axle Locker Sensor on JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). Internal axle components are serviceable. Complete axle assemblies should not be replaced unless necessary due to damaged housing. Over repairs may be subject to chargeback.

18-048-24

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs):** ● P02EE - Cylinder 1 Injector Circuit Performance (China Only). ● P02EF - Cylinder 2 Injector Circuit Performance (China Only). ● P02F0 - Cylinder 3 Injector Circuit Performance (China Only). ● P02F1 - Cylinder 4 Injector Circuit Performance (China Only). ● P2B95 - Cold Start Injection Pulse Performance. ● P152E - Engine Hood Switch Two Circuit High. ● P152F - Engine Hood Switch Two Engine Hood Switch One Correlation. Customers may also comment on the following: ● **"Performance Limited Service Fuel System" message appears and then disappears after a few seconds/ minutes in the Instrument Panel Cluster (IPC) (All Markets).** This bulletin involves reprogramming the PCM with the latest available software.

9100344

Service Bulletin/Repair Instructions

VALVE BODY & CONTROL UNIT Transmission Ensure clutch pressure check has been completed and documented prior to valve body replacement.

94519

Other

HEADLAMP

S2307000002 REV.A

Service Bulletin/Repair Instructions

Suspected Engine Coolant Leak

S2208000063 REV.A

Service Bulletin/Repair Instructions

Loss Of Power Steering Assist. U0131 Lost Communication With Electro Hydraulic Power Steering Control Module (EHPS).

S2408000015 REV.B

Service Bulletin/Repair Instructions

Remote Keyless Entry (RKE) Button Functions Does Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed

9100337

Service Bulletin/Repair Instructions

PUMP WATER For 2016-2024MY 3.6L Pentastar Upgrade with suspected coolant leak. PRIOR TO PERFORMING ANY WATER PUMP REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION S2307000002. Please submit pictures of the leak area thru the DIDI process outlined in the STAR Online document. NOTE: Some coolant residue may be found at the water pump weep hole plug area which may be normal, but coolant should not be dripping from this location. If unsure about, use the Pressurized Coolant System Inspection process as found in the Dealer Connect Cooling Diagnosis and Testing Procedures.

08-106-24 REV. B

Service Bulletin/Repair Instructions

S2208000020

Service Bulletin/Repair Instructions

Electric Mode Temporarily Unavailable, Cluster Message Displayed Vehicle in Fuel Oil Refresh Mode (FORM)

0802824

Service Bulletin/Repair Instructions

Radio Over The Air Update from QR39.82F to QR40.12 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.82F to QR40.12. NOTE: National launch for this FOTA update is expected to begin Feburary 19, 2024.

S238A000028

Service Bulletin/Repair Instructions

Radio Black Screen, Freezing, Reset, Cutting Out Or Inoperative Intermittently

0802624

Service Bulletin/Repair Instructions

Radio Over The Air Update from QR39.5 to QR40.11 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.5 to QR40.11. NOTE: National launch for this FOTA update is expected to begin Feburary 19, 2024.

0802524

Service Bulletin/Repair Instructions

Radio Over The Air Updating to QR40.12 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone, when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.2 to QR40.11. NOTE: National launch for this FOTA update is expected to begin February 19, 2023.

0300224

Service Bulletin/Repair Instructions

Front and Rear Axle Sensor Kit **Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: ? C1451-11 - Service Axle Locker System** Customers may also comment on a Service Axle Locker message displayed in the Electronic Vehicle Information Center (EVIC) for this condition.

Reference83A

Service Bulletin/Repair Instructions

Emission Recall 83A Sales Code Alignment

0700124

Service Bulletin/Repair Instructions

Thermostat Housing Manifold Coolant Leak Customers may experience the following: ? Coolant leak from the thermostat housing. This bulletin involves tightening the thermostat housing manifold fasteners and replacing the thermostat gasket.

9100287

Service Bulletin/Repair Instructions

Thermostat Assy For 2022-2024MY 3.6L Pentastar Upgrade with P0128 failure code. PRIOR TO PERFORMING ANY THERMOSTAT REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION S2309000014

0800624A

Service Bulletin/Repair Instructions

Navigation (NAV) Reboot When MOTA Fails The customer may describe one of more of the following: ? Radio navigation continues to reboot after a Map Update (MOTA). ? Navigation regularly cuts out and back on again. ? Radio switches to navigation without customer's input. This bulletin involves updating the Navigation maps via USB.

2300424

Service Bulletin/Repair Instructions

Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses.

S2408000002

Service Bulletin/Repair Instructions

Tire Pressure Warning Lamp is on Steady, or Flashing

0802024

Service Bulletin/Repair Instructions

Floor Console USB Inoperative Customers may comment on the following: ? Customer states the Apple Carplay/Android Auto? does not work or is intermittently working when their device is plugged into the center console bin USB port. This replacing the center console USB cable.

ReferenceY40

Service Bulletin/Repair Instructions

Customer Satisfaction Notification Y40 Control Module Software Updates

S1408000384

Service Bulletin/Repair Instructions

S2308000152

Service Bulletin/Repair Instructions

Vehicle in an Accident, Fuel Shut Off, Vehicle Does not Start

S2308000154

Service Bulletin/Repair Instructions

Rear Park Assist Warning Chime When Nothing is Behind the Vehicle

0824523

Service Bulletin/Repair Instructions

Radio Over The Air Update to Q339.3 to QR39.62 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from Q339.3 to QR39.62. NOTE: The National launch for this FOTA update campaign is expected to begin December 04, 2023.

0824823

Service Bulletin/Repair Instructions

Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? P0607-00 - ECU Internal Performance. ? P0C78-00 - Hybrid/EV Battery System Precharge Time Too Long. This bulletin involves updating the BPCM with the latest available software.

S2308000144

Service Bulletin/Repair Instructions

Multiple Cluster Warning Lamps Flash on While Driving

9100276

Service Bulletin/Repair Instructions

Spring Front Upr - Isolator Before replacing this part. Please contact FCA REDACTED CONTENT. ~ If no response in 15 minutes, proceed with repair.

S2309000013

Service Bulletin/Repair Instructions

Verifying Camshaft Diagnosis

S2309000012

Service Bulletin/Repair Instructions

Mil-On/Check Engine Lamp-On with DTC P06DD set in the powertrain control module (PCM).

9100264

Service Bulletin/Repair Instructions

PSU Oil Pump Assy

9100265

Service Bulletin/Repair Instructions

Hydraulic tensioner Before replacing any Front End Accessory Drive components, please check Accessory Drive belt routing as per engine sales code. Customer complaints may include a noise coming from under de hood described as a squeal, screech, squeak, chirp or "belt related" noise and/or noisy tensioner/pulley. Please check Service Library for any STAR Online publications that may apply. Note: If it is found that the pulleys and/or tensioners are to blame for the noise please use an stethoscope or similar tool to determine the origin of the noise and include it in the narrative.

S2308000121

Service Bulletin/Repair Instructions

Check Engine Lamp (CEL) On, Diagnostic Trouble Codes (DTCs) P0245, P2AB8

S2323000081

Service Bulletin/Repair Instructions

Buzz Squeak Rattle (BSR) From Rear Seat Area.

S2308000059

Service Bulletin/Repair Instructions

Check Charge Cable Message Appears on Cluster

S2318000011

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Code (DTC) P0341 ? Camshaft Position Sensor Performance ? Bank 1 Sensor 1, Set.

9100244

Service Bulletin/Repair Instructions

FRT DOOR HINGE - DOOR CHECK If the front door check strap physically breaks or cracks, please call FCA Redacted Content. If no response in 15 minutes, proceed with repair. Please take pictures of the broken part and email the pictures to FCA Redacted Content.

S238A000050

Service Bulletin/Repair Instructions

4.5 Inch Premium Bar Speaker Static, Rattles, Buzzing

S1808000057

Service Bulletin/Repair Instructions

Inspecting And Disconnecting Negative Battery Cables On ESS Vehicles

0823023

Service Bulletin/Repair Instructions

Radio Over The Air Updating From QR39.6 to QR40.12 Software Version Customers may experience one or more of the following symptoms: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.6 to QR40.12. NOTE: National launch for this FOTA update is expected to begin November 06, 2023.

S238A000048

Service Bulletin/Repair Instructions

Radio Reset After Clock Adjustment

9100220

Service Bulletin/Repair Instructions

Pan and Filter, Transmission Oil For WL & JL PHEV transmission leaks inspect for leaks through the transmission case prior to ordering a gasket. Leaks can be caused by possible porosity of transmission case or Oil Cooler Lines. Refer to the latest version of Star Online Publication S2321000005.

S2308000126

Service Bulletin/Repair Instructions

Check Engine Light (CEL) P257F, P152E, or P0073

9100247

Service Bulletin/Repair Instructions

ERG Hydraulic Tensioner Before replacing any FEAD components, please check FEAD belt layout as per the engine sales code. Customer complaint may include a noise from under the hood described as a squeal, screech, squeak, chirp or belt-related noise and/or noisy tensioner/pulley. Please refer to SOL# S2309000007.

S2318000010

Service Bulletin/Repair Instructions

Message in cluster for "Performance Limited Service Fuel System" with no DTC's

S2309000007

Service Bulletin/Repair Instructions

Customer complaint may include a noise from under the hood described as a ?belt-related? noise.

0812223

Service Bulletin/Repair Instructions

Restore Vehicle Configuration Customers may experience the following: ? Speed warning alert/Chime chimes continuously above a 80 KPH (50 MPH) speed - instead of one time chime alert. This bulletin involves performing a restore vehicle configuration procedure.

S2309000006

Service Bulletin/Repair Instructions

Engine oil leak

9100229

Service Bulletin/Repair Instructions

LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.

S2308000117

Service Bulletin/Repair Instructions

Check Engine Light On, P0CA6-00 Hybrid/EV Battery Charging Current High

S2323000075

Service Bulletin/Repair Instructions

2nd Row Center Seat Lazy Or Slow When Folding.

S2323000073

Service Bulletin/Repair Instructions

Exterior Mirror And Or Blind Spot Inoperative.

9100226

Service Bulletin/Repair Instructions

Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.

S2323000074

Service Bulletin/Repair Instructions

Buzz Squeak Rattle (BSR) From Sound Bar Or Sport Bar Area.

S2221000003

Service Bulletin/Repair Instructions

8-Speed Transmission, Additional Transmission Fluid Leak Inspection/Repair Guidelines.

S2321000005

Service Bulletin/Repair Instructions

Transmission Fluid Leak From Under The Vehicle.

S2323000072

Service Bulletin/Repair Instructions

Soft Top Windows Do Not Sit Flush To The Top.

S2319000007

Service Bulletin/Repair Instructions

Squeak Noise From Dash Area When Turning The Steering Wheel.

S2323000071

Service Bulletin/Repair Instructions

Front Door Window Will Not Roll Down All The Way. Window Stops Part Way Down.

9100212

Service Bulletin/Repair Instructions

PUMP Water For 2016-2024MY 3.6L Pentastar Upgrade with suspected coolant leak. PRIOR TO PERFORMING ANY WATER PUMP REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION S2307000002. Please submit pictures of the leak area thru the DIDI process outlined in the STAR Online document. NOTE: Some coolant residue may be found at the water pump weep hole plug area which may be normal, but coolant should not be dripping from this location. If unsure about, use the Pressurized Coolant System Inspection process as found in the Dealer Connect Cooling Diagnosis and Testing Procedures.

9100209

Service Bulletin/Repair Instructions

Switch-Mirror Before replacing this Switch, please follow the service procedures to properly diagnose it 1) Remove the switch 2) Please check the continuity on each pin of the switch based on the table found in the service Procedures. If after testing switch is still faulty, please call FCA Redacted Content. If no response after 15 minutes, proceeds with switch replacement.

S2208000027

Service Bulletin/Repair Instructions

Cluster Message ?Electric Mode Unavailable Cabin Heating or Cooling? or ?Electric Mode Temporarily Unavailable?, Vehicle Engine Runs All -the Time Does Not Enter Electric Vehicle (EV) Mode, Diagnostic Trouble Codes (DTCs) P0E15, U1008-00,U1124-00

S2307000002

Service Bulletin/Repair Instructions

Suspected engine coolant leak.

93023

Service Bulletin/Repair Instructions

Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)

93120

Service Bulletin/Repair Instructions

FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC

S238A000042

Service Bulletin/Repair Instructions

Media Hub USB Connection Drops, Or Apple CarPlay and Android Auto Inoperative.

2400623

Service Bulletin/Repair Instructions

A/C Diagnostic LOP Change

S1919000004

Service Bulletin/Repair Instructions

U0131-00-LOST COMMUNICATION WITH POWER STEERING CONTROL MODULE ?A?. Service Electric Power Steering Message On Cluster.

S2008000031

Service Bulletin/Repair Instructions

Low Charging Voltage Displayed On Cluster

2308923

Service Bulletin/Repair Instructions

Rear Defroster Inoperative Customer may experience the following: ? Rear window is not defrosting ? The rear window glass left or right side defrost solder terminal is detached from the defrost grid. This bulletin involves replacing the Electric Backlite (EBL) wire connector repair and re-securing the electrical connector(s) to the rear window.

S2108000093

Service Bulletin/Repair Instructions

Apple CarPlay Does Not Work Or Not Connecting

S2322000002A

Service Bulletin/Repair Instructions

Spare Tire Winch Operation. Winch Cable Binding.

9100196

Service Bulletin/Repair Instructions

Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used

9100185

Service Bulletin/Repair Instructions

ELECTRIC HYDRAULIC POWER STEERING PUMP Prior to replacing this component for damage at the pump electrical connection, please contact FCA redacted content. If no response in 15 minutes, proceed with repair.

9004433

Service Bulletin/Repair Instructions

PUMP, Vacuum For DTC Code P258B - ELECTRONIC VACUUM PUMP PERFORMANCE. Due to brake vacuum pumps returned with trouble not found, please follow the proper diagnostics outline in the service library this also includes checking all electrical and vacuum hose connections prior to replacement of the vacuum pump. This will avoid unnecessary repair and potential charge back on the vacuum pump.

9100186

Service Bulletin/Repair Instructions

Brake Vacuum Pump For DTC Code P258B. Due to brake vacuum pumps being returned with trouble not found, please follow the proper diagnostics outline in the service library this also includes checking all electrical and vacuum hose connections prior to replacement of the vacuum pump. This will avoid unnecessary repair and potential charge back on the vacuum pump.

S238A000034

Service Bulletin/Repair Instructions

USB Hub In-Operable

0816723

Service Bulletin/Repair Instructions

Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ?P0A80-00 - Replace Hybrid/EV Battery Pack. ? P0EDD-00 - Contactor Wear Counter Far Advanced. In addition, the customer may comment on the following condition: ? Battery light on in the Instrument Panel Cluster (IPC). This bulletin involves updating the BPCM with the latest available software.

0817023

Service Bulletin/Repair Instructions

Flash: Hybrid Control Processor (HCP) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ?P0563-00 - System Voltage High. ? P2B28-00 - Hybrid/EV Battery Pack Coolant Pump Performance. Customers may also comment on one or more of the following: ? Reduced engine restart performance. ? May observe battery lamp illumination or the technician observes the 12V system voltage high when diagnosing. This bulletin involves reprogramming the HCP also known as Power Inverter Module (PIM) with the latest available software.

2308323

Service Bulletin/Repair Instructions

Sunvisor Rocking or Loose One or both sunvisors rocking or are loose This bulletin involves adding foam pads to both sunvisor body mounts.

92177

Service Bulletin/Repair Instructions

Warranty Bulletin D-23-04 - 2018-2023 (Current) Jeep Wrangler (JL) and 2020-2023 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification (Rev. B)

92187

Service Bulletin/Repair Instructions

FCA Caribbean Warranty Bulletin ID-23-03 - 2018 - 2023 (Current) Jeep Wrangler (JL) and 2020 - 2023 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification (Rev. B)

1400423

Service Bulletin/Repair Instructions

Fuel Filler Cap Tether Too Long Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ?P04EC - EVAP System Large Leak Detected - Fuel Tank Side. ? P04EE - EVAP System Very Small Leak Detected - Fuel Tank Side. Customers may also comment the following: ? There is a "Check Gas Cap" message in the Instrument Panel Cluster (IPC). NOTE: The above condition is caused from an air leak through the fuel filler cap and fuel filler neck seal, because the fuel filler cap tether is caught between both. This bulletin involves removing the fuel filler cap tether and replacing it with a shorter tether.

0804923

Service Bulletin/Repair Instructions

Flash: Integrated Dual Charging Module (IDCM) Enhancements Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC) have been set: ? B22A9-64 - ECU Internal Performance-Signal Plausibility Failure. ? B22A9-16 - ECU Internal Performance-Circuit Voltage Below Threshold. ? B22A9-17 - ECU Internal Performance-Circuit Voltage Above Threshold. ? B22A9-19 - ECU Internal Performance-Overcurrent. Customer may also experience the following: ? Vehicle will not charge. This bulletin involves reprogramming the IDCM with the latest software available. NOTE: Additional module flashes are required for this update to be effective, the following modules are all to be updated along with this IDCM update: ? Powertrain Control Module (PCM). ? Integrated Dual Charging Module (IDCM). ? Transmission Control Module (TCM). ? Battery Pack Control Module (BPCM). ? Hybrid Control Processor (HCP), Auxiliary Hybrid Control Processor (AHCP) also known as the Power Inverter Module (PIM).

9100160

Service Bulletin/Repair Instructions

Power wndow switch passenger

S2325000006

Service Bulletin/Repair Instructions

Customer complaint may include a MIL-on or check engine lamp on condition.

1804923

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? **P02EE - Cylinder 1 Injector Circuit Performance. China only. ? P02EF - Cylinder 2 Injector Circuit Performance. China only. ? P02F0 - Cylinder 3 Injector Circuit Performance. China only. ? P02F1 - Cylinder 4 Injector Circuit Performance. China only.** ? P2B95 - Cold Start Injection Pulse Performance. ? P152E - Engine Hood Switch Two Circuit High. ? P152F - Engine Hood Switch Two Engine Hood Switch One Correlation. The customer may also comment on the following: ? ?Performance Limited Service Fuel System? message in the Instrument Panel Cluster (IPC). This bulletin involves reprogramming the PCM with the latest available software.

2306823

Service Bulletin/Repair Instructions

Water Leak (Drips) On Center Stack, Radio Or Shifter Lever From The Front Center LH Freedom Panel Customers may comment on the following: ? Water is leaking on the radio coming from the left freedom top panel (Fig. 1) . This bulletin includes performing a water test and replacing foam pads on left hand freedom panel.

Reference51A

Service Bulletin/Repair Instructions

Customer Satisfaction Notification 51A - Incorrect Grille Insert Color

S2323000043

Service Bulletin/Repair Instructions

Gate bumber falls.

S2309000002

Service Bulletin/Repair Instructions

MIL lamp-on. Engine noise, rattle. Misfire or rough running.

0900923b

Service Bulletin/Repair Instructions

Engine makes an abnormal ticking noise. There may be Diagnostic Trouble Codes (DTCs) present.

0700723

Service Bulletin/Repair Instructions

Water Quality When Mixed With Engine Coolant

S238A000024

Service Bulletin/Repair Instructions

SOS, Assistance Calls Not Successful After Radio Replacement or Radio Software Update

0900923

Service Bulletin/Repair Instructions

Engine Ticking Noise Engine makes an abnormal ticking noise. There may be Diagnostic Trouble Codes (DTC)s present. This bulletin involves inspecting and if needed, replacing the intake HLAs. NOTE: **ALL VEHICLES ON THE RSU VIN LIST REQUIRE ALL 12 INTAKE HYDRAULIC LASH ADJUSTERS TO BE REPLACED**.

0900923a

Service Bulletin/Repair Instructions

Engine makes an abnormal ticking noise. There may be Diagnostic Trouble Codes (DTC)s present.

0700623

Service Bulletin/Repair Instructions

Mis-Installed 3-way Coolant Valve The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC): ? P0E80-00 - Coolant Bypass Valve 9B9 Control Stuck Closed. Customer may also experience the following: ? Intermittent no heat. This bulletin involves possibly rerouting the three way valve hoses.

S2323000021

Service Bulletin/Repair Instructions

Clunk Noise From Front End Driving Between 15 And 35 MPH And When Decelerating. C0604- Active Air Dam Control Performance

S2309000001

Service Bulletin/Repair Instructions

Upon turning the vehicle on, vehicle propulsion system is inoperative.

S2308000055

Service Bulletin/Repair Instructions

Vehicle May Not Start, Service High Voltage System Warning Displayed, DTC P1D72-00 Open High Voltage Cable

S238A000021

Service Bulletin/Repair Instructions

Radio Display Screen Blank Or Screen Cuts In And Out

0700423

Service Bulletin/Repair Instructions

Coolant Overflow Bottle Leaking Coolant Leak. This bulletin involves inspection the overflow coolant bottle for leaks and replacing it if needed.

2304923

Service Bulletin/Repair Instructions

Water Leak - Liftgate Glass to Swing Gate Water leak into rear cargo area at the bottom of lift glass seal and top of swing gate. This bulletin involves installing two pieces of foam pads.

9100133

Service Bulletin/Repair Instructions

ROCKER ARM ASSY - ROLLER ROCKER Case 1.- Before replacing the intake or exhaust rocker arms due to an abnormal ticking noise, please check that the INTAKE Hydraulic Lash Adjusters are not "collapsed". If a collapsed INTAKE HLA is found, replace all INTAKE HLAs on the suspect cylinder head (no need to replace rocker arms). The noise can occur at low or high RPMs, and at low or high temperatures. There are no Diagnostic Trouble Codes (DTC)s present. Case 2.- If the INTAKE camshaft or INTAKE rocker arm has excessive wear on the high lift profile (Rocker arm: slider, Camshaft: central lobe), replace the intake camshaft (1) in that cylinder head and all intake rocker arms (6).

9100143

Service Bulletin/Repair Instructions

PSU right intake camshaft Case 1) If you are to flash the PSU (Pentastar Upgrade Engine) PCM due to P0300 code presence, only AB or previous LEVEL PSU right intake camshaft PN 05047913AA or AB (old version) should be replaced. If the engine is equipped with the AC/AD LEVEL PSU right intake camshaft PN 05047913AC or AD (new version), camshaft should NOT be replaced. Case 2) If the intake camshaft or intake rocker arm has excessive wear on the high lift profile (Rocker arm: slider, Camshaft: central lobe), replace the intake camshaft (1) in that cylinder head and all intake rocker arms (6).

NotificationZD8

Service Bulletin/Repair Instructions

Customer Satisfaction Notification ZD8 Coolant Leak

9100142

Service Bulletin/Repair Instructions

Mirror

0809923

Service Bulletin/Repair Instructions

Flash: Anti-Lock Brake System (ABS) Module Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTC has been set: ? C2206-00 - Vehicle Configuration Mismatch. Customer may also experience one or more of the following: ? Inconsistent or unexpected brake performance is perceived in slow speed situations. ? Feels like the brake pedal needs to be pressed harder just before the vehicle comes to a stop (actual braking distance is not affected and driver is able to step further into the pedal for more brake pressure). This bulletin involves reprogramming the ABS with the latest software available.

0810023

Service Bulletin/Repair Instructions

Battery Charge Indicator (BCI) Replacement Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTC has been set: ? B1271-00 - Charge Level Indicator Internal. Customer may also experience the following: ? BCI does not indicate charge status while the vehicle is charging. This bulletin involves replacing the BCIM.

1804823

Service Bulletin/Repair Instructions

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

Notification23A

Service Bulletin/Repair Instructions

Customer Satisfaction Notification 23A Electric Vehicle Mode

0808323

Service Bulletin/Repair Instructions

Re-Configure: Body Control Module (BCM) Customers may experience one or more of the following: ? Wi-Fi hotspot icon not shown in Uconnect. ? Wi-Fi functionality is missing from vehicle. This bulletin involves re-configuring the BCM.

Newsletter

Service Bulletin/Repair Instructions

FCA CARIBBEAN WARRANTY OPERATIONS NEWSLETTER

0806423

Service Bulletin/Repair Instructions

Radio Over The Air Updating to QR40.12 Software Version Mobile Wi-Fi inoperative upon start up. ? Hotspot gives 9No Internet9 connection message on phone, when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.7 to QR40.12. NOTE: National launch for this FOTA update is expected to begin March 10, 2023. DISCUSSION: Vehicles sold in the U.S. and Canada can now receive software updates ?over-the-air?. Updates to software will occur in a phased roll-out. The software is updated through the built-in cellular modem in the radio.

S2025000001

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant Level Sensor 1 Circuit Intermittent-Erratic Set.

9100139

Service Bulletin/Repair Instructions

Front Wheel Hub and Bearing Before replacing the front or rear wheel hub and bearing for moaning, grinding, or groaning type noise, verify the noise is not coming from the transfer case. Follow the diagnostic procedure outlined in SOL Publication S2303000001 prior to any repair.

0805823

Service Bulletin/Repair Instructions

Integrated Dual Charging Module (IDCM) Replacement Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs have been set: ? B22A9-87 - ECU Internal Performance-Missing Message. Customer may also experience the following: ? Unable to charge the vehicle. This bulletin involves replacing the IDCM.

2302923

Service Bulletin/Repair Instructions

Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses (Fig. 1) . This bulletin is to communicate the procedure for head lamp condensation clearing.

9003357A

Service Bulletin/Repair Instructions

ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.

9003357a

Service Bulletin/Repair Instructions

9100138

Service Bulletin/Repair Instructions

FILTER KIT, Transmission Oil For leak concerns that have been isolated to a transmission pan gasket, please replace ONLY the gasket. Pan/filter replacement are not required.

2300823

Service Bulletin/Repair Instructions

Tail Lamp Water Intrusion The customer may experience the following: ? Water in the left and/or right tail lamp. This bulletin involves water testing the rear tail lamps and replacing if needed.

S2108000015

Service Bulletin/Repair Instructions

Uconnect Box Require Service Message

89211

Service Bulletin/Repair Instructions

Warranty Bulletin D-23-04 2018 - 2023 (Current) Jeep Wrangler (JL) and 2020 - 2023 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification (Rev. A)

89216

Service Bulletin/Repair Instructions

International Warranty Bulletin ID-23-03 2018 - 2023 (Current) Jeep Wrangler (JL) and 2020 - 2023 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification (Rev. A)

S228A000028

Service Bulletin/Repair Instructions

Radio Remained On After Ignition Is Switched Off, Dead Battery From Excessive Radio Current Draw

9003357

Service Bulletin/Repair Instructions

ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.

0805023

Service Bulletin/Repair Instructions

Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. ? P0B3E-00 - Hybrid/EV Battery Voltage Sense 1 Circuit High. ? P0607-00 - ECU Internal Performance. ? P1E1B-00 - Hybrid/EV Battery Side Voltage System Isolation. ? P0AA4-00 - Hybrid Battery Negative Contactor Circuit Stuck Closed. This bulletin involves updating the BPCM with the latest available software. NOTE: Additional module flashes are required for this update to be effective, the following modules are all to be updated along with this BPCM update: ? Powertrain Control Module (PCM). ? Integrated Dual Charging Module (IDCM). ? Transmission Control Module (TCM). ? Battery Pack Control Module (BPCM). ? Hybrid Control Processor (HCP), Auxiliary Hybrid Control Processor (AHCP) also known as the Power Inverter Module (PIM).

9100132

Service Bulletin/Repair Instructions

ENGINE ASSY - 3.6L AUTO TRANS Before replacing the engine due to an abnormal ticking noise, please check that the INTAKE Hydraulic Lash Adjusters are not "collapsed". If a collapsed INTAKE HLA is found, replace all INTAKE HLAs on the suspect cylinder head. The noise can occur at low or high RPMs, and at low or high temperatures. There are no Diagnostic Trouble Codes (DTC)s present. CAUSE: INTAKE Hydraulic Lash Adjuster may have a manufacturing issue that can cause the plunger to stick, generating valvetrain noise.

2302023A

Service Bulletin/Repair Instructions

Corrosion on Door, Hood And/or Swing Gate Hinges Corrosion found on the door, hood and/or swing gate hinge(s). This bulletin involves inspecting and replacing any hinge exhibiting corrosion. The replacement hinge is equipped with a Zinc shim (Fig. 1) .Zinc Shim

2302023a

Service Bulletin/Repair Instructions

89079

Service Bulletin/Repair Instructions

Warranty Bulletin D-23-04 2018 - 2023 (Current) Jeep Wrangler (JL) and 2020 - 2023 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification

S2308000012

Service Bulletin/Repair Instructions

Rear Wiper Does Not Turn On

S2302000001

Service Bulletin/Repair Instructions

Service Air Suspension Message In Cluster. C15AD-92-Ride Height System- Performance In Below Freezing Temperatures.

3100123

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: **Verify current warranty policy to determine if digital imaging pre authorization is required or Pre Approval is required from Regional Office depending on market.** This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.

S1819000004

Service Bulletin/Repair Instructions

Shimmy Felt In Front End

2302023

Service Bulletin/Repair Instructions

Corrosion on Door hood Swing Gate Hinges Corrosion found on the door, hood and/or swing gate hinge(s). This bulletin involves inspecting and replacing any hinge exhibiting corrosion. The replacement hinge is equipped with a Zinc shim. (Fig. 1) .Zinc Shim

NotificationZD2

Service Bulletin/Repair Instructions

Customer Satisfaction Notification ZD2 Engine Misfire

18-011-23

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers may experience one or more of the following: Vehicle may not be able to enter electric mode driving while Fuel Oil Refresh Mode (FORM) is active. FORM staying on too long. This bulletin involves reprogramming the PCM with the latest available software. NOTE: Additional module flashes are required for this update to be effective, the following modules are all to be updated along with this PCM update: Hybrid Control Processor (HCP), Auxiliary Hybrid Control Processor (AHCP) also known as the Power Inverter Module (PIM). Transmission Control Module (TCM).

08-022-23

Service Bulletin/Repair Instructions

Radio Over The Air Updating to 40.12 Software Version Mobile Wi-Fi inoperative upon start up. Hotspot gives 9No Internet9 connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from 39.5 to 40.12.

23-008-23

Service Bulletin/Repair Instructions

Tail Lamp Water Intrusion The customer may experience the following: Water in the left and/or right tail lamp. This bulletin involves water testing the rear tail lamps and replacing if needed.

S2318000002

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illumination. Intake Manifold Runner Valve Diagnostic Trouble Codes (DTCs) Setting In Extreme Cold Ambient Temperatures.

S2308000003

Service Bulletin/Repair Instructions

When Performing The HCP/AHCP Combo Flash, The AHCP Portion May Fail

9100121

Service Bulletin/Repair Instructions

Battery Heater If you are looking for the Electronic Coolant Heater (ECH) for DTC P0E15 please order the latest level part number 68443445A$.

S2323000004

Service Bulletin/Repair Instructions

Defogger Is Not Working. Terminal Detached From The Glass.

9100116

Service Bulletin/Repair Instructions

Valve - Coolant JL PHEV Hoses to 3-Way valve coolant hoses misroute causes P0E80-00. Check hose routing as outlined in Star Online Publication S2208000205 or on a known good vehicle before replacing valve. Routing hoses correctly will likely fix the issue.

S2323000002

Service Bulletin/Repair Instructions

Washer Light On And Will Not Turn Off After Adding Washer Solvent.

18-162-22

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers may experience one or more of the following: ? Vehicle may not be able to enter electric mode driving while Fuel Oil Refresh Mode (FORM) is active. ? FORM staying on too long. This bulletin involves reprogramming the PCM with the latest available software. NOTE: Additional module flashes are required for this update to be effective, the following modules are all to be updated along with this PCM update: ? Hybrid Control Processor (HCP), Auxiliary Hybrid Control Processor (AHCP) also known as the Power Inverter Module (PIM). ? Transmission Control Module (TCM).

S2208000205

Service Bulletin/Repair Instructions

Three Way Coolant Valve Hoses Misrouted. P0E80-00-Coolant Bypass Valve "B" Control Stuck Closed

S2208000203

Service Bulletin/Repair Instructions

P0E15-00 Hybrid/Ev Battery Pack Coolant Heater "A" Control Performance Active After High Voltage (HV) Module Updates

S2208000199

Service Bulletin/Repair Instructions

Avoid Failure Of High Voltage Battery Pack When Performing Flashes

08-003-22 REV. A

Service Bulletin/Repair Instructions

UAQ and UCQ Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. ? Mobile Station Integrated Services Digital Network (MSISDN) missing from radio, no connected services working.** ? Intermittent, black radio display screen (Rear View Camera (RVC) not affected). ? Intermittent, radio freezes (RVC not affected). ? Wireless connectivity pairing and/or connection issues. ? Lost radio presets. ? Radio channels change by itself. ? SXMT icon inoperative. ? SXMT favorite song not displaying/playing. ? Incorrect navigation address/location/directions. ? Backup camera has black display screen or only displays Check Entire Surroundings with black screen (occurs when vehicle is shifted immediately to reverse upon key-on before RVC signal is received, recoverable with key cycle) . ? High pitch chime noise. ? Contact list not loading. ? Device not supported message. ? Remote app inoperative. ? Travel-Link fuel price incorrect. ? Backup camera gridlines missing. ? Unable to adjust volume. In addition, the following enhancement are included in this update: ? Enables map updates. ? Heavy Duty (HD) Truck USB HUB improvements. ? HD Truck heated steering wheel improvements This bulletin involves inspecting and if required, updating the radio software level to 40.1. Depending on the radio?s current software level the radio may need a one or two USB update.

9100115

Service Bulletin/Repair Instructions

Integrated Dual Charging Module Before replacing the IDCM part please follow the appropriate service procedure for DTC P0D27, ensure to clear the codes and perform a charging test. If the codes come back again, proceed with the replacement.

31-002-22

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Digital imaging pre authorization is required for Smart Warranty Base dealers or Pre Approval is required from Regional Office depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.

18-158-22

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation, a technician may find one or more of the following Diagnostic Trouble Codes (DTCs) have been set: P016F - Closed Loop Fuel Pressure Control At Limit - Pressure Too Low. P025C - Fuel Pump Module Control Circuit Low. P0300-00 - Multiple Cylinder Misfire. P0301-00 - Cylinder 1 Misfire. P0302-00 - Cylinder 2 Misfire. P0303-00 - Cylinder 3 Misfire. P0304-00 - Cylinder 4 Misfire. P0305-00 - Cylinder 5 Misfire. P0403-00 - EGR Control Circuit Open (Disabled Fault). P208B - Reductant Pump 1 Control Performance. Other Software enhancements:Low speed engine idle improvements. Improved engine restart performance and torque response during low fuel level and/or hot ambient conditions.

9100103

Service Bulletin/Repair Instructions

Engine Oil - 0W20,Fluid - ATF+4,Engine Oil - 10W30,Engine Oil - 5W20,Engine Oil - 5W30

9100104

Service Bulletin/Repair Instructions

SENSOR Intrusion Module

9100105

Service Bulletin/Repair Instructions

Seal, Sunroof

1815322

Service Bulletin/Repair Instructions

Powertrain Control Module (PCM) Updates

9100008

Service Bulletin/Repair Instructions

Telematic box module 2

9100096

Service Bulletin/Repair Instructions

Base Headlamp Bright, Base Headlamp Black

2304622

Service Bulletin/Repair Instructions

Sky One Power Top Rattle This bulletin involves checking the torque values on the Sky One-Touch power top screws andreplacing all 16 screws if one is found with an incorrect torque value. Customers may experience the following: A rattle noise over bumps and rough roads while driving coming from the roof area.

S2208000108RevD

Service Bulletin/Repair Instructions

PHEV Vehicle Does Not Charge with The Jeep Branded 32 Amp Charger or Other Level 2 Battery Chargers

S2208000138RevA

Service Bulletin/Repair Instructions

Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed

S2208000108RevC

Service Bulletin/Repair Instructions

PHEV Vehicle Does Not Charge with The Jeep Branded 32 Amp Charger or Other Level 2 Battery Chargers

0901222

Service Bulletin/Repair Instructions

Spark Knock/Engine Symptoms This bulletin involves cleaning the piston heads and cylinder head combustion chambersto resolve a spark knock condition being caused by oil intrusion through the PCV system. The customer may describe a knocking or pinging noise coming from the engine upon acceleration.

S2208000108

Service Bulletin/Repair Instructions

PHEV Vehicle Does Not Charge with The Jeep Branded 32 Amp Charger or Other Level 2 Battery Chargers

9100022

Service Bulletin/Repair Instructions

water pump For concern of leak at water pump, please check and re-torque water pump inlet tube fasteners as described in Service Bulletin 07-001-22 before replacing the water pump. Please also inspect the water pump to block gasket, this gasket can be service separately.

S2214000003

Service Bulletin/Repair Instructions

Guidelines For The Use Of Alternative Diesel Fuels.

S2208000159

Service Bulletin/Repair Instructions

Error 715 ? Not A Valid Market Message Received In wiTECH When Trying To Program An Immobilizer Component

S2208000154

Service Bulletin/Repair Instructions

Service Hybrid Electric Vehicle System Message Displayed In The IPC. Vehicle Shakes During A Cold Start And Noise Is Heard Near The P2 Motor. DTC?s U0287-00 And B273C-00

S2208000155

Service Bulletin/Repair Instructions

Battery Charge Indicator (BCI) Does Not Illuminate

S2223000066

Service Bulletin/Repair Instructions

Power Top Rattles Over Bumps And Rough Roads.

1814122

Service Bulletin/Repair Instructions

S2223000063

Service Bulletin/Repair Instructions

Ambient Temperature Sensor Servicing.

S228A000022

Service Bulletin/Repair Instructions

Connected Service Requires Service Message

S2003000001RevE

Service Bulletin/Repair Instructions

Noise From The Front Axle Area Over Bumps

S2008000103RevA

Service Bulletin/Repair Instructions

No Start, Stop Start Inoperative, Battery or Check Engine Light (CEL) Illuminated

S2108000056RevD

Service Bulletin/Repair Instructions

U0111-00 Lost Communication With Battery Energy Control Module Set In The HCP. BPCM Offline, Multiple Low Voltage DTC?s.

2102922

Service Bulletin/Repair Instructions

Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC). P0701 Transmission Control System Range/Performance.

3100122

Service Bulletin/Repair Instructions

Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.

S2208000150

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) On, ?Check Fuel Cap? Message

S2208000027RevA

Service Bulletin/Repair Instructions

Cluster Message ?Electric Mode Unavailable Cabin Heating or Cooling? or ?Electric Mode Temporarily Unavailable?, Vehicle Engine Runs All the Time Does Not Enter Electric Vehicle (EV) Mode

S2025000006RevA

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Code (DTC) P206D ? Reductant Quality Sensor Circuit High Set.

S2208000020RevA

Service Bulletin/Repair Instructions

Electric Mode Temporarily Unavailable, Cluster Message Displayed Vehicle in Fuel Oil Refresh Mode (FORM)

9100011

Service Bulletin/Repair Instructions

Battery Kit, Hybrid NOTE 1 of 2: Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Improper handling of damaged lithium ion batteries can causer property damage, serious injury or even death. Exemptions will not be made for any dealer who fails to follow the appropriate handling process. To read the DCMail communication, go to DealerCONNECT > DCMail (ID: 81758). For details on recyclers, please visit the Mopar Dealer Site Lithium Ion Battery Handling page: https://www.dealers-mopar.com/moparone/retail/programs/battery-program/lithium-ion.jsp NOTE 2 of 2: When replacing the HV battery, or any cooling component within any of the cooling systems, please ensure that the service procedure is followed by using a coolant vacuum fill tool to ensure all trapped air is removed from the coolant system. The battery cooling system is complex with small coolant passages used to cool electronics. It is fed by a small electronic pump that does not develop the pressure head to "burp" the cooling system in the same manner that an engine water pump often will. All electric pumps are designed to sense air in the cooling system. Proper service procedures and proper equipment must be used. Failure to do so may result in vehicle damage or customer return for MIL lights due to air in the cooling system.

S2218000017

Service Bulletin/Repair Instructions

Customer complaint may include a Mil-on condition and possible related driveability issues. Upon further inspection, a P0244-Turbo Wastegate Actuator "A" Range/Performance fault may be set in the PCM.

S2207000002

Service Bulletin/Repair Instructions

Coolant leak

85008

Service Bulletin/Repair Instructions

TOP KIT - SOFT

S2208000144

Service Bulletin/Repair Instructions

Front Park Sensors Not Providing Warning After a Recent Service Repair

0814622

Service Bulletin/Repair Instructions

Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: P1A21-00 - HV Battery Contactor Control Sequence Incorrect. P0B3E-00 - Hybrid/EV Battery Voltage Sense 1 Circuit High. P0607-00 - ECU Internal Performance. P1E1B-00 - Hybrid/EV Battery Side Voltage System Isolation. P0AA4-00 - Hybrid Battery Negative Contactor Circuit Stuck Closed.

S2208000054RevA

Service Bulletin/Repair Instructions

Left Headlight, Park Lamp Flickers Or Is Inoperative. B162A, B163A, B1632, B16CF

S2223000054

Service Bulletin/Repair Instructions

Washer Inoperative, Weak Or No Spray. Low Washer Indicator May Be Illuminated.

0300322

Service Bulletin/Repair Instructions

Front or Rear Axle Sensor Kit

S2208000138

Service Bulletin/Repair Instructions

Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed

S2214000001

Service Bulletin/Repair Instructions

The customer may experience a message in the instrument cluster that comes on briefly while driving, typically during a throttle tip-out/tip-in maneuver. The message states "Performance Limited Perform Fuel System Maintenance" and typically displays for only a few seconds. The message may or may not be accompanied by a Mil-On condition and there are usually no noticeable driveability symptoms.

S2223000053

Service Bulletin/Repair Instructions

Water Leak At Hard Top Front Corner Of Quarter Window

0813722

Service Bulletin/Repair Instructions

Flash: Integrated Dual Charging Module (IDCM) Enhancements This bulletin involves reprogramming the IDCM with the latest software available or replacing the IDCM if required. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC) have been set: B22A9-64 - ECU Internal Performance-Signal Plausibility Failure. Customer may also experience the following:Vehicle will not charge.

S228A000004RevB

Service Bulletin/Repair Instructions

Panasonic VP4R Wi-Fi New Enrollment Pause

S2108000270RevB

Service Bulletin/Repair Instructions

Sky Slider Power Top Does Not Operate. New Power Top Motors Inoperative

2302422

Service Bulletin/Repair Instructions

Headlamp Condensation Clearing Procedure This bulletin is to communicate the procedure for headlamp condensation clearing.

2302122

Service Bulletin/Repair Instructions

Front Seat Will Not Unfold and Lock Into Position This bulletin involves replacing the Easy Entry release cable and both front seattrack seat position returns. Customers may experience one or both of the following: This may be an intermittent condition the customer experiences.One or both of the front seats will not unlock from the Easy Entry position. One or both of the front seats will not unfold and lock back into the upright position. The vehicle cannot be driven due to this condition.

9004527

Service Bulletin/Repair Instructions

Valve Cover Gasket It is advised to replace the full valve cover assembly if you are experiencing a valve cover leak Engineering has updated the skirt height of the valve cover to address oil leaks. Replace the valve cover (part # 04893800AI (right side) or 04893799AH (left side)includes valve cover gasket) to ensure proper repair. Please call FCA Redacted Content to facilitate fast track shipment of failed part.

Z32

Service Bulletin/Repair Instructions

Customer Satisfaction Notification Z32 Mirror Side Marker Light

S228A000004RevA

Service Bulletin/Repair Instructions

Panasonic VP4R Wi-Fi New Enrollment Pause

S2108000270RevA

Service Bulletin/Repair Instructions

Sky Slider Power Top Does Not Operate. New Power Top Motors Inoperative

9003990

Service Bulletin/Repair Instructions

HVAC Blower Motor For concerns of intermittent or inoperative blower fan operation please contact FCA Redacted Content prior to replacement as returns have come back no trouble found. If no response in 15 minutes, proceed with repair.

S2213000001

Service Bulletin/Repair Instructions

Frame Bracket Attached To Right Front Frame Rail Behind Front Tire.

S2218000011

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illumination, Diagnostic Trouble Code (DTC) P00F3 ? Humidity Sensor Circuit Performance, Set.

83674

Service Bulletin/Repair Instructions

CONTROL - HVAC CONTROL

9004472

Service Bulletin/Repair Instructions

complete wiring harness Before replacing this harness, please check for an available connector repair kit at the following: http://connectors.dcctools.com/home.htm;jsessionid=C6A3F1B696B030953878BF34FE86A8FE If a connector repair kit is not available on the website contact FCA Redacted Content to see if an alternative repair kit is available for your application prior to ordering the harness. If no response in 15 minutes, proceed with repair. Please email pictures of harness defects to FCA Redacted Content

S228A000004

Service Bulletin/Repair Instructions

Panasonic VP4R Wi-Fi New Enrollment Pause

S2208000108 Rev.

Service Bulletin/Repair Instructions

PHEV Vehicle Does Not Charge With The Jeep Branded 32 Amp Charger Or Other Level 2 Battery Chargers

S1925000008

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes (DTCs) P208B ? Reductant Pump 1 Control Performance, and/or P20E8 ? Reductant Pressure Too Low, Set.

9004531

Service Bulletin/Repair Instructions

RECEIVER, Hub The final drop shipment of CSN Z23, P/N 68379519AL, has taken place. No further parts distribution will be taking place. All distributed parts would cover all sold and unsold needs. Please use all stock that your dealer has before asking for parts assistance. If part assistance is still required, please provide the following information to your Area Manager for review: 1. Dealer Code 2. Last eight digits of VIN 3. Appointment date/vehicle VOR at dealer Thank you, Mopar

9004533

Service Bulletin/Repair Instructions

PUMP, Auxiliary Coolant Customer experiences Check Engine Light with DTC/ P026 E, P023 A, or P023 B all related to Coolant Pump performance. Dealers are replacing Auxiliary Coolant Pump Part #68290300AA. Then draining and refilling coolant. If vehicle has DTC/ P026 E, P023 A, or P023 B present, drain and refill coolant before changing the pump making sure all air is out of the system, then clear codes. If any of these codes return, change Aux Coolant Pump Any questions or concerns, please contact FCA Redacted Content. If no response in 15 minutes, proceed with repair.

0700122REVB

Service Bulletin/Repair Instructions

Water Pump Inlet Tube Fastener Torque

82975

Service Bulletin/Repair Instructions

LATCH - FRONT DOOR

S2207000001

Service Bulletin/Repair Instructions

Coolant Color Looks Lighter Than Service Procedure Coolant

83020

Service Bulletin/Repair Instructions

DAMPER - STEERING

83052

Service Bulletin/Repair Instructions

RECEIVER - HUB

82973

Service Bulletin/Repair Instructions

LAMP - TAIL

82837

Service Bulletin/Repair Instructions

DAMPER - STEERING

S2209000004

Service Bulletin/Repair Instructions

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.

S1908000159

Service Bulletin/Repair Instructions

MIL Lamp On, DTC P0330 Knock Sensor 2 Circuit

S1908000159 RevA

Service Bulletin/Repair Instructions

MIL Lamp On, DTC P0330 Knock Sensor 2 Circuit

S2118000015

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Code (DTC) P0403 ? EGR Control Circuit Open, Set.

S2118000015 RevB

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Code (DTC) P0403 ? EGR Control Circuit Open, Set.

S2223000029

Service Bulletin/Repair Instructions

Rattle Noise From Door

9004505

Service Bulletin/Repair Instructions

Lithium Ion Batteries Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Improper handling of damaged lithium ion batteries can cause property damage, serious injury or even death. Exemptions will not be made for any dealer who fails to follow the appropriate handling process. To read the DCMail communication, go to DealerCONNECT > DCMail (ID: 81758) For details on recyclers, please visit the Mopar Dealer Site Lithium Ion Battery Handling page: https://www.dealers-mopar.com/moparone/retail/programs/battery-program/lithium-ion.jsp

9004501

Service Bulletin/Repair Instructions

PUMP, Washer, Windshield Windshield washer pump is inop or low pressure If customer comes in with the issue described above, please contact the following individuals prior to servicing the vehicle. FCA Redacted Content If no response in 15 minutes, proceed with repair.

S2208000073

Service Bulletin/Repair Instructions

No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting

S2208000063

Service Bulletin/Repair Instructions

Loss of power steering assist. U0131 Lost Communication With Electric Power Steering Control Module

S1708000118

Service Bulletin/Repair Instructions

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off

S1708000118 RevB

Service Bulletin/Repair Instructions

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off

S2208000067

Service Bulletin/Repair Instructions

No Start, Service Hybrid Electric Cluster Message, Turtle Warning Lamp On

9004487

Service Bulletin/Repair Instructions

Transmission Oil Pan and Gasket Assembly For Transmission oil leaks, need to identify exactly where the leak is coming from, please check the transmission case at the Trans Oil Heater (TOH) connection on the Grand Cherokee's. Also check the Trans Valve Body at the TCM harness connection. A black light can be used to identify trans fluid vs. other fluids. Contact FCA Redacted Content prior to replacing these components. If no response in 15 minutes, proceed with repair. Please email pictures of leak locations to FCA Redacted Content

0900322

Service Bulletin/Repair Instructions

Yellow Warning Labels on the 3.0L Diesel Engines Cylinder Head Covers This bulletin outlines the correct procedure for all the repairs that involve: Fuel Injector(s). Cylinder head(s). Cylinder head cover(s). The engine may have a yellow warning label applied to the plastic cylinder head cover to alert the technician special procedures required for Injector Removal/Install. Failure to follow the procedure can result in excessive engine soot. If specific yellow warning labelsFig. 1are applied on engine cylinder head cover(s), follow the procedures reported in this bulletin.During the following repairs:Fuel injector(s) replacement, removal and installation. Cylinder head replacement Cylinder head cover replacement.

9004465

Service Bulletin/Repair Instructions

AXLE, Service Rear A new parts kit (SENSOR KIT, Axle: 68544629AA) is available to repair the Axle Locker Sensor on the 2018 - 2022 JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). This new parts kit must be used when only the Axle Locker Sensor fails.

S2208000025

Service Bulletin/Repair Instructions

ABS Lamp On, U0121 Lost Communication With ABS Module, Stop Start Inoperative U0037-00 LIN BUS

S2223000001

Service Bulletin/Repair Instructions

Rattle Noise From Power Top Driving Over Bumps Or Rough Road

08-177-21

Service Bulletin/Repair Instructions

BEV/Hybrid - Showroom and Display Vehicle Battery Maintenance This information only bulletin discusses procedures that must be followed for BEV/Hybrid vehicles that are on display at dealership showrooms.

S2123000079

Service Bulletin/Repair Instructions

Wind Noise And Or Water Leak From Door Seal Area

S2108000270

Service Bulletin/Repair Instructions

Sky Slider Power Top Does Not Operate, New Power Top Motors Will Not Power Operate To Calibrate

S2108000269

Service Bulletin/Repair Instructions

Air Bag Lamp On, DTC B2761-11 B Pillar Side Impact Sensor Circuit Short

9004444

Service Bulletin/Repair Instructions

SPRING, Valve For conern of misfire or misfire related DTCs and diagnosis leads to a broken valve spring, please replace all valve springs and contact FCA Redacted Content to FasTrak all replaced parts to QEC for further analysis. If no response in 15 minutes, proceed with repair.

S2123000074

Service Bulletin/Repair Instructions

Front Wheel Well Splash Liner Contacting Tire

S2108000198

Service Bulletin/Repair Instructions

Media Device Connection Guidelines For Bluetooth, Apple CarPlay, Android Auto Or USB To The Radio Head Unit

S2109000004

Service Bulletin/Repair Instructions

Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.

9004009

Service Bulletin/Repair Instructions

Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.

S2025000005

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes P0407 ? EGR Sensor B Circuit Low, or P0408 ? EGR Sensor B Circuit High Set

Reading this report

Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.