24KWL/PBL
Service Bulletin/Repair Instructions
The verbiage in the Introduction section has been updated.
Vehicle report
2021 KENWORTH T280
Service bulletins
22 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
43-080
Service Bulletin/Repair Instructions
KW: A new recommended repair has been added to verify the software level and close the campaign in SIR.The repair procedure has been updated with additional note boxes for clear instructions. PB: The repair procedure has been updated with additional note boxes for clear instructions.
02-177
Service Bulletin/Repair Instructions
Troubleshooting procedures for 2.1m cab power windows are now available.
14-034
Service Bulletin/Repair Instructions
Bogie Crossmember Torque Value Update - Procedure has been updated to correct torque values.
24PBE_KWE
Service Bulletin/Repair Instructions
The Parts section has been updated to clarify that freight charges for safety recall orders should not be passed on to the end customer.
45-069
Service Bulletin/Repair Instructions
Cummins TSB 210203 has been updated to remove the PACCAR suction side fuel filter part number from Table 1 as the filter is no longer compatible.
24KWE / 24PBE
Service Bulletin/Repair Instructions
The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle.
24PBE_24KWE
Warranty Program/Extension
24PBE_24KWE RH Shift Stalk Update Warranty section has been updated with revised verbiage for picture requirements.
43-076
Service Bulletin/Repair Instructions
Certain vehicle model years 2020-2025 K270, K370, T270, T280, T370, T380, T480, T680, T880, W900 chassis have updated Greenhouse Gas (GHG) labels available for installation.
24KWE/24PBE
Emissions
The parts section has been updated for clarity. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle.
24PBE/KWE
Warranty Program/Extension
The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle.
24KWE
Service Campaign
The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle.
98-026
Service Bulletin/Repair Instructions
New tools are required to support PACCAR TX-8 / ZF transmissions. Part numbers E0l-1012 (Adapter, Jack TX-8), E0l-1014 (Front Seal Installer), and E0l-1015 (Rear Seal Installer) are currently available to order
23KWJ
Service Bulletin/Repair Instructions
Safety Recall 23KWJ: T280/T380/T480 Delayed Trailer Brake Release T280/T380/T480 Delayed Trailer Brake Release. Safety Recall Certain T280/T380/T480 chassis built with 2.1m Medium Duty End of Frame Trailer Connections and Tractor Protection Valves may not meet the standard trailer brake release timing requirements by 0.5 seconds. A delay in the trailer brake release may create momentary instability to the trailer and increase the risk of a crash.
43-072
Service Bulletin/Repair Instructions
Certain chassis with Engine Model Year 2016-2021 PACCAR MX-11/MX-13, or EPA13 and EPA21 Cummins ISX12/ISX15/X15 engines that had a previously failed DEF sensor and with DEF sensor software disabled due to industry DEF sensor shortages will now be able to receive a replacement DEF sensor, DEF tank heater coolant control valve, and re-enabled DEF diagnostic software. Please note that chassis equipped with PACCAR PX engines will be eligible for this repair at a future date when software is available.
23KWB
Service Bulletin/Repair Instructions
Parts and repair procedures are now available. Kenworth has determined that a safety defect exists in certain Model Year 2021-2024 T280, T380, and T480 chassis with air brakes. The brake pedal plunger which connects the brake pedal to the brake valve may dislodge after the pedal is fully depressed, and rapidly released (side slip foot brake release). If the plunger in the brake pedal assembly dislodges, the driver may be unable to apply the service brakes, which may increase the risk of a crash.
45-064
Service Bulletin/Repair Instructions
Info Only - PACCAR is introducing Over-the-Air (OTA) software updates for engine MY17 and newer chassis equipped with Cummins X15, X12, ISX12, ISX12N, L9N, PX-7, and PX-9 engines The technology will leverage the existing Remote Diagnostic cs hardware to deliver secure software updates remotely. This will reduce downtime and save on maintenance costs for eligible vehicles.
T013
Service Bulletin/Repair Instructions
chassis with a PACCAR TX-8 transmission without cruise control may have active transmission faults 86-2 and 595-2. These faults do not affect the operation of the transmission and can be ignored.
E282
Service Bulletin/Repair Instructions
Information Only: Due to differences between the PACCAR MX-11 or MX-13 2021A and 2021B engines, technicians must be able to identify which of these engines are in a chassis.
43-071
Service Bulletin/Repair Instructions
Fix-As-Fail â Due to undersupply issues, only a limited supply of Diesel Exhaust Fluid (DEF) sensors are available. As a temporary solution, after PACCAR confirms a DEF sensor is not available, a temporary software update will allow a vehicle to continue operation with a failed DEF sensor by disabling the DEF sensor diagnostics.
43-069
Service Bulletin/Repair Instructions
A DPF regeneration two-position switch parameter is causing inhibited DPF regeneration. A parameter update, via Cummins Insite, restores proper DPF regeneration function.
21 KWF
Service Bulletin/Repair Instructions
âSafety Recall - Model year 2021 Cummins PX9 fuel hose assemblies may leak from the hoses between the fuel pump and the remote filter head. A fuel leak in the presence of an ignition source may increase the risk of a fire. A repair is now available.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.