Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
WTY026_TSB_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN: OIL PRESSURE SWITCH (OPS) REPLACEMENT (WTY026 REVISION 2) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the replacement of the Oil Pressure Switch associated with the ‘Warranty Extension Program’ (WTY026) on some 2014-2018MY vehicles listed in the table below, for repairs that may be necessary to address an Oil Pressure Switch leak in the eligible vehicles listed below from 10 years/100,000 miles to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address the Oil Pressure Switch leaking condition at no cost to the customers during this extended warranty period.
WTY039_TSB_R7
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: ENGINE SUB ASSEMBLY INSPECTION/REPLACEMENT (WTY039 - REVISION 7) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY039) to diagnose a coolant leak from the cylinder head gasket area and, if necessary, replace the engine sub assembly on 2014-2015 MY Sorento, 2014-2017 MY Cadenza, and 2015-2016 MY Sedona vehicles, equipped with 3.3L GDI engines. The warranty coverage for repairs related to the cylinder head gasket will be extended from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
PS797
Other
PITSTOP: TECHNICAL OPERATIONS: EXTERNAL DAMAGE TO ULTRASONIC SENSOR: This Pitstop provides information related to Parking Distance Warning (PDW) alerts and repairs involving ultrasonic sensors. The PDW system alerts the driver while parking, by calculating distance based on the difference in signal transmission and reception times between the vehicle (ultrasonic sensor) and an object. The membrane film of the ultrasonic sensor is used for object detention and can be damaged by stone chips or foreign substances while driving. Damage to the cover of the ultrasonic sensor can also lead to damage to the internal circuit. As a result of this external damage, the PDW system may not receive the proper signal from the ultrasonic sensor. In some cases, the system may cause a false alarm, no alert, or phantom warnings by a “Warning Lamp’ to be displayed on the cluster. The ultrasonic sensor membrane film should be always inspected for external damage and if any part replacement should be treated as a general repair, not as a warranty claim repair for this concern. (Please note that this Pitstop only applies to models/trims that are equipped with the ultrasonic sensors.)
WTY039_TSB_R6
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: ENGINE SUB ASSEMBLY INSPECTION/REPLACEMENT (WTY039 REVISION 6) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY039) to diagnose a coolant leak from the cylinder head gasket area and, if necessary, replace the engine sub assembly on 2014-2015 MY Sorento, 2014-2017 MY Cadenza, and 2015-2016 MY Sedona vehicles, equipped with 3.3L GDI engines. The warranty coverage for repairs related to the cylinder head gasket will be extended from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY039_TSB_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN (WTY039) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY039) to diagnose a coolant leak from the cylinder head gasket area and, if necessary, replace the engine sub assembly on 2014-2015 MY Sorento, 2014-2017 MY Cadenza, and 2015-2016 MY Sedona vehicles, equipped with 3.3L GDI engines. The warranty coverage for repairs related to the cylinder head gasket will be extended from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY039_TSB_R4
Warranty Program/Extension
TECHNICAL SERVICE BULLETIN: ENGINE SUB ASSEMBLY: INSPECTION/REPLACEMENT (WTY039) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY039) to diagnose a coolant leak from the cylinder head gasket area and, if necessary, replace the engine sub assembly on 2014-2015 MY Sorento, 2014-2017 MY Cadenza, and 2015-2016 MY Sedona vehicles, equipped with 3.3L GDI engines. The warranty coverage for repairs related to the cylinder head gasket will be extended from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
TSB_TRA046_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission.
WTY039_TSB_R3
Warranty Program/Extension
TECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN: ENGINE SUB ASSEMBLY INSPECTION/REPLACEMENT (WTY039) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY039) to diagnose a coolant leak from the cylinder head gasket area and, if necessary, replace the engine sub assembly on 2014-2015 MY Sorento, 2014-2017 MY Cadenza, and 2015-2016 MY Sedona vehicles, equipped with 3.3L GDI engines. The warranty coverage for repairs related to the cylinder head gasket will be extended from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY039_TSB_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: ENGINE SUB ASSEMBLY INSPECTION/REPLACEMENT (WTY039) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY039) to diagnose a coolant leak from the cylinder head gasket area and, if necessary, replace the engine sub assembly on 2014-2015 MY Sorento, 2014-2017 MY Cadenza, and 2015-2016 MY Sedona vehicles, equipped with 3.3L GDI engines. The warranty coverage for repairs related to the cylinder head gasket will be extended from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY039_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN: ENGINE SUB ASSEMBLY INSPECTION/REPLACEMENT (WTY039) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY039) to diagnose a coolant leak from the cylinder head gasket area and, if necessary, replace the engine sub assembly on 2014-2015 MY Sorento, 2014-2017 MY Cadenza, and 2015-2016 MY Sedona vehicles, equipped with 3.3L GDI engines. The warranty coverage for repairs related to the cylinder head gasket will be extended from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY039_TSB
Warranty Program/Extension
TECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN: ENGINE SUB ASSEMBLY INSPECTION/REPLACEMENT (WTY039) - This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY039) to diagnose a coolant leak from the cylinder head gasket area and, if necessary, replace the engine sub-assembly on 2014-2015 MY Sorento (3.3L GDI Lambda), 2014-2017 MY Cadenza (3.3L GDI Lambda), 2015-2016 MY Sedona (3.3L GDI Lambda) vehicles.
WTY039_OWNR_VG
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: OWNER NOTIFICATION (WTY039) - This document is the owner notification advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for certain repairs related to the vehicle’s engine in 2014-2017 MY Cadenza vehicles from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service. Under certain severe operating conditions and over time, the engine in the vehicle may develop a coolant leak from the cylinder head gasket area.
WTY039_DP
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: DEALER PRINCIPAL MEMO (WTY039) - This document is the announcement to the dealer principals that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for certain repairs related to the vehicle’s engine in the following vehicles equipped with 3.3L V6 engines: 2014-2015 MY Sorento vehicles, manufactured from December 17, 2012 through December 11, 2014, 2014-2017 MY Cadenza vehicles, manufactured from February 1, 2013 through July 12, 2017, and 2015-2016 MY Sedona vehicles, manufactured from July 21, 2014 through March 17, 2016. This will extend the warranty from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service
WTY039_DPSM
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (WTY039) - This document is the announcement to the dealer Parts and Service Managers that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for certain repairs related to the vehicle’s engine in the following vehicles equipped with 3.3L V6 engines: 2014-2015 MY Sorento vehicles, manufactured from December 17, 2012 through December 11, 2014, 2014-2017 MY Cadenza vehicles, manufactured from February 1, 2013 through July 12, 2017, and 2015-2016 MY Sedona vehicles, manufactured from July 21, 2014 through March 17, 2016. This will extend the warranty from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service. Under certain severe operating conditions and over time, the engine in the vehicle may develop a coolant leak from the cylinder head gasket area.
WTY039_QA
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: QUESTION AND ANSWER - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Warranty Extension Campaign WTY039.
WTY039_REIMB
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: REQUEST FOR REIMBURSEMENT FORM (WTY039) - This document is a Reimbursement Request form that was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extension program launch.
TSB_TRA046_R4
Service Bulletin/Repair Instructions
This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.
TSB_TRA046_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.
TSB_ENG219_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides information on setting the "Service Interval Reminder" feature available on most 2014-2023MY Kia vehicles (refer to model list on page 2). If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance. Refer to TSB ENG241 for 2023MY~ vehicles equipped with the Oil Life Management System (OLMS) feature not included in table on page 2.
WTY026_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: OIL PRESSURE SWITCH (OPS) REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the replacement of the Oil Pressure Switch associated with the 'Warranty Extension Program' (WTY026) on some 2014-2018MY vehicles listed in the table below, for repairs that may be necessary to address an Oil Pressure Switch leak in the eligible vehicles listed below from 10 years/100,000 miles to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address the Oil Pressure Switch leaking condition at no cost to the customers during this extended warranty period. Follow the procedure outlined in this publication to replace the OPS.
WTY026_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN OIL PRESSURE SWITCH (OPS) REPLACEMENT - This bulletin provides information regarding the replacement of the Oil Pressure Switch associated with the 'Warranty Extension Program' (WTY026) on some 2014-2018MY vehicles listed in the table below, for repairs that may be necessary to address an Oil Pressure Switch leak in the eligible vehicles listed below from 10 years/100,000 miles to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address the Oil Pressure Switch leaking condition at no cost to the customers during this extended warranty period.
WTY026_OWNR_VG
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: OWNER NOTIFICATION - This document is the owner notification advising that Kia is extending the New Vehicle Limited Warranty coverage for repairs that may be necessary to address an Oil Pressure Switch leak in 2014-2016 MY Cadenza vehicles equipped with 3.3L GDI Engine from 5 years/60,000 miles to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY026_REIMB_VG
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: REIMBURSEMENT FORM - This document is a Reimbursement Request form for 14-16 MY Cadenza customers which was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extension program launch.
WTY026_DP
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: DEALER PRINCIPAL MEMO - This document is the announcement to the dealer principals of the warranty extension program for WTY026. Kia is extending the New Vehicle Limited Warranty coverage for the repairs related to the Oil Pressure Switch leaking for eligible vehicles from 5 years/60,000 miles to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY026_DPSM
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: DEALER PARTS AND SERVICE MANAGER MEMO - This document is the announcement to the dealer Parts and Service Managers of the warranty extension program for WTY026. Kia is extending the New Vehicle Limited Warranty coverage for the repairs related to the Oil Pressure Switch leaking for eligible vehicles from 5 years/60,000 miles to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY026_QA
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: QUESTION AND ANSWER - This document is the Question and Answer Guide containing the most frequently asked questions regarding the warranty extension (WTY026).
TSB_CHA084_R8
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit. On some vehicles when the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly and does not affect the steering effort.
TSB_BOD055_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
PS704
Service Bulletin/Repair Instructions
PITSTOP: FRONT RADAR SENSOR MOUNTING INSPECTION (PS704) - This pitstop provides information regarding front radar sensor alignment on 2014MY and later vehicles that may exhibit a warning light ON related to radar sensor alignment errors in the Forward Collision-Avoidance Assist (FCA)/Smart Cruise Control (SCC) system.
TSB_CHA084_R7
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
TSB_CHA084_R6
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Worm Gear Assembly or Steering Column Housing on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
TSB_CHA084_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Worm Gear Assembly or Steering Column Housing on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
PS663
Service Bulletin/Repair Instructions
PITSTOP: MFC, CONCERNS FOR DISABLED OPERATION - This Pitstop provides information regarding concerns with disabled operation of Multi-Function Camera (MFC) on some Kia vehicles. When normal operation is not possible due to certain outside environment conditions (such as sunlight glare, heavy rain, sunlight, snow, fog and/or substance/debris) causing a temporary concern. This stops operation causing Warning Lamp ON and/or Pop-up Message displayed on the cluster. This is a normal operation of the ADAS and once environment conditions improve and/or substance/debris are removed, the system will clear itself and operate normally.
PS675
Service Bulletin/Repair Instructions
PITSTOP - BRAKE CALIPER LEAK INSPECTION - This PITSTOP provides information related to a brake caliper fluid/oil substance found on some Kia vehicles, due to possible excess assembly oil applied during assembly.
TSB_ENG219
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin provides information on setting the "Service Interval Reminder" feature available on most Kia vehicles. If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance.
TSB_CHA091_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: STEERING GEAR YOKE PLUG AND ASSEMBLY REPLACEMENT - This bulletin has been revised to include additional information. This bulletin provides the procedure to replace the steering gear box yoke plug and assembly on some models listed below, which may exhibit a ticking noise while turning the steering wheel with the vehicle stopped. This condition is caused by a worn lining on the steering gear box yoke assembly.
TSB_TRA046_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: - TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles on page 2. Refer to the shop manual on KGIS for the specific Kia model for the correct transmission fluid check/fill procedures.
TSB_ELE148
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: HALOGEN HEAD LAMP LOW BEAM BULB CONNECTOR REPLACEMENT - This bulletin provides information regarding the procedure to repair the bulb connector on some 2010MY~ vehicles listed on the table below, which may exhibit a bulb connector concern. To correct this concern, replace the connector with a new and improved part.
TSB_CHA091_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: STEERING GEAR YOKE PLUG AND ASSEMBLY REPLACEMENT - This bulletin has been revised to include additional information. This bulletin provides the procedure to replace the steering gear box yoke plug and assembly on some models listed below, which may exhibit a ticking noise while turning the steering wheel with the vehicle stopped. This condition is caused by a worn lining on the steering gear box yoke assembly. Follow the procedure outlined in this bulletin to replace the steering gear box yoke plug and assembly with updated parts.
TSBCHA084_R4
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information.This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU) or Steering Column Housing on some 2010MY~ Kia models listed on page 5 equipped with a Column Motor Driven Power Steering (C-MDPS) unit. Follow the MDPS Flowchart (page 2) along with the MDPS DTC Table (page 3) procedure outlined in this bulletin before replacing the C-MDPS Motor, ECU or Steering Column Housing.
TSBCHA084_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN TSB084_R3: PARTIAL REPAIR OF C-MDPS MOTOR, ECU AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information.This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU) or Steering Column Housing on some 2010MY~ Kia models listed on page 5 equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
WTY013_OWNR_VG
Service Bulletin/Repair Instructions
OWNER LETTER: Dear Kia Cadenza Owner: Kia Motors America, Inc. takes pride in providing you with high quality and dependable vehicles. In order to maintain these standards, Kia is extending the New Vehicle Limited Warranty coverage, to all owners of the 2014 MY Cadenza, for the Motor Driven Power Steering (MDPS) flexible coupling from 5-years/60,000-miles to 10-years/unlimited-miles, starting from the date of first service. The MDPS unit may experience noise when turning the steering left or right, especially while the vehicle is stopped.
WTY013_REIMB_VG
Service Bulletin/Repair Instructions
REQUEST FOR REIMBURSEMENT FORM 2014 MY Cadenza Vehicles Motor Driven Power Steering (MDPS) Flexible Coupling Warranty Extension Program (WTY013) - If you have incurred expense to remedy this issue prior to the date of this notice, you may have the opportunity to obtain reimbursement for that expense. You may submit your receipts online to Kia via the Owners section of www.kia.com or mail your receipts with a cover letter directly to Kia for review and consideration.
WTY013_DP
Service Bulletin/Repair Instructions
Attention: All Dealer Principals - Kia Motors America, Inc. is extending the New Vehicle Limited Warranty coverage to all owners of vehicles listed below for the Motor Driven Power Steering (MDPS) Flexible Coupling from 5-years/60,000-miles to 10-years/unlimited-miles, starting from the date of first service. The MDPS unit may experience noise when turning the steering left or right, especially while the vehicle is stopped. ⢠2012-2013 MY Kia Soul vehicles produced from July 8, 2011 through October 2, 2013 and ⢠2014 MY Kia Cadenza vehicles produced from February 1, 2013 through April 19, 2014.
WTY013_DPSM
Service Bulletin/Repair Instructions
Attention: All Kia Parts & Service Managers - Kia Motors America, Inc. is extending the New Vehicle Limited Warranty coverage to all owners of vehicles listed below for the Motor Driven Power Steering (MDPS) Flexible Coupling from 5-years/60,000-miles to 10-years/unlimited-miles, starting from the date of first service. The MDPS unit may experience noise when turning the steering left or right, especially while the vehicle is stopped. ⢠2012-2013 MY Kia Soul vehicles produced from July 8, 2011 through October 2, 2013 and ⢠2014 MY Kia Cadenza vehicles produced from February 1, 2013 through April 19, 2014.
WTY013_QA
Service Bulletin/Repair Instructions
Q & A: 2012-2013 MY SOUL AND 2014 MY CADENZA VEHICLES MOTOR DRIVEN POWER STEERING (MDPS) FLEXIBLE COUPLING KIA NEW VEHICLE LIMITED WARRANTY EXTENSION PROGRAM
TSBCHA074_R2
Service Bulletin/Repair Instructions
TSB: MDPS FLEXIBLE COUPLING REPLACEMENT - This bulletin is issued to provide information about the replacement of the flexible coupling in the MDPS motor of some vehicles which might experience a âÂÂknockâ noise originating from the MDPS, when moving the steering wheel to right or left when the vehicle is stopped. This is caused by premature wear of the flexible coupling in the MDPS motor. If any âÂÂknockâ noise from the MDPS occurs, replace the affected flexible coupling only with an improved one, following the Replacement Procedure below.
TSBENG083_R1
Service Bulletin/Repair Instructions
TSB: SPECIAL SERVICE INFORMATION & SPECIFICATIONS FOR GDI HIGH PRESSURE FUEL SYSTEM - This bulletin has been revised to include additional information. This bulletin provides information relating to all Kia vehicles equipped with Gasoline Direct Injection (GDI) engines. In these engines highly pressurized gasoline is injected via a common fuel rail and injectors that deliver fuel directly into the combustion chamber of each cylinder. In comparison, in a conventional Multi-Point Fuel Injection (MPI) engine, the gasoline is injected into the intake port of each cylinder at a relatively low pressure. Due to high fuel pressure in a GDI system, servicing the GDI system requires special attention and handling procedures. This bulletin provides special service information and specifications for the GDI fuel system components.
TSBCHA091
Service Bulletin/Repair Instructions
TSB: STEERING GEAR YOKE PLUG AND ASSEMBLY REPLACEMENT - This bulletin provides the procedure to replace the steering gear box yoke plug and assembly on some models listed below, which may exhibit a ticking noise while turning the steering wheel with the vehicle stopped. This condition is caused by a worn lining on the steering gear box yoke assembly. Follow the procedure outlined in this bulletin to replace the steering gear box yoke plug and assembly with updated parts.
PS320_R1
Service Bulletin/Repair Instructions
PITSTOP: ROUGH IDLE AFTER COLD START ON 3.3L GDI ENGINE - When addressing a customer complaint of rough idle, which occurs only on the first start of the day and lasts for 30-45 seconds, check for the possibility of poor injector performance in a particular cylinder. This concern may feel like a misfire, however, it is not an emissions or catalyst damaging misfire and it does not typically trigger any DTC(s). To diagnose this concern, go to KDS ? Data Analysis ? Engine and monitor for Current Misfire Counts on all 6 cylinders, during the first cold start in the morning, to assist in determining which cylinder is responsible for the rough idle condition. Replace only the injector for the affected cylinder. To verify the repair, recheck again after an overnight cold soak to make sure the rough idle condition is no longer present.
PS464_R2
Service Bulletin/Repair Instructions
PITSTOP - NO COMMUNICATION WITH BLIND SPOT DETECTION AFTER COLLISION REPAIRS - This Pitstop provides information relating to the vehicles listed below with Blind Spot Detection (BSD), which may exhibit a ?Check BSD System? message and no communication with the BSD system after collision repairs.
PS539
Service Bulletin/Repair Instructions
PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine.
TSBELE091R3
Service Bulletin/Repair Instructions
TSB - IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - This bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations.
PS474
Service Bulletin/Repair Instructions
PITSTOP: TPMS SENSOR POSITION - When diagnosing TPMS-related DTCs, make sure you are investigating the correct sensor. The TPMS positioning from the manufacturer may be different from the positioning shown on a KDS.
PS496
Service Bulletin/Repair Instructions
PITSTOP: CUSTOMER TIP: ACCELERATOR PEDAL FUNCTION/DESCRIPTION - On all K900 (KH), Cadenza (VG, YG), and Optima (JF, JFa, JF-HEV, JF-PHEV) vehicles, the accelerator pedal features a small detent with a spring to provide increased resistance to help avoid unnecessary fuel consumption when applying full throttle. When the driver depresses the pedal beyond the resistance where the detent is felt (above 85% WOT), the pedal will easily reach WOT and kickdown shift will occur accordingly. For additional information, refer to the individual vehicle?s Owner?s Manual under section ?Driving Your Vehicle? ? Automatic Transmission (Drive).
PS493
Service Bulletin/Repair Instructions
TSB: DEFOGGING LOGIC ? NORMAL OPERATION, DISABLING, AND ENABLING - Starting with 2010MY, all Kia vehicles, except Rio (JB), incorporate a defogging logic to prevent the interior windows from becoming excessively fogged. Depending on the specific model, the HVAC control head monitors ambient temperature and/or cabin humidity to determine which settings will best prevent the windows from fogging. If the system detects lower ambient temperature or higher cabin humidity, the defogging logic may automatically switch ON the A/C, and/or set the air intake mode to Fresh Air. If the user changes these settings, the defogging logic will take control again after 3 to 5 minutes, depending on the procedure in this publication.
PS469
Service Bulletin/Repair Instructions
PITSTOP: MANUAL EVAPORATIVE EMISSIONS TEST FOR HARD TO FIND/SMALL LEAKS - If the malfunction indicator lamp (MIL) is illuminated with DTC(s) P0442, P0455, P0456, or P0457 (Evaporative Emissions System-Leak detected) and the evaporative (EVAP) leak self-test resulted in NTF, a manual EVAP test is recommended.
TSB-GEN085R1
Service Bulletin/Repair Instructions
TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.? It is critical for technicians to be aware that ALL such locking fasteners, regardless of type, are for ?one time use? only.
TSB-GEN085
Service Bulletin/Repair Instructions
TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?
TSB-TRA055
Service Bulletin/Repair Instructions
TSB: INHIBITOR SWITCH DIAGNOSIS INFORMATION - This bulletin gives information regarding the steps to take regarding the diagnosis of the Inhibitor Switch.
TSB-ELE117
Service Bulletin/Repair Instructions
TSB: NAVIGATION SOFTWARE UPDATE - NO SIRIUS TRAFFIC DISPLAY - This bulletin provides the procedure for updating the Navigation software on some Sportage (SL), Cadenza (VG), Optima (QF/TF), and Optima (TF HEV) vehicles, which may experience an inactive (grayed out) Sirius Traffic icon, no traffic flow shown, or a ?There is no traffic on route.? message.
PS266R1
Service Bulletin/Repair Instructions
PITSTOP: HVAC RECEIVER/DRYER - DESICCANT REPLACEMENT - IN THE EVENT OF A HVAC SYSTEM CONCERN IN WHICH METAL PARTICLES OR SHARDS HAVE CONTAMINATED THE SYSTEM, THE DESICCANT OR THE ENTIRE A/C RECEIVER/DRYER ASSEMBLY MAY NEED TO BE REPLACED. THIS IS DUE TO THE FACT THAT IT MAY BE IMPOSSIBLE TO REMOVE ALL METAL CONTAMINANTS FROM THE RECEIVER/DRYER DURING THE A/C FLUSHING PROCEDURE. REFER TO THE INCLUDED TABLE FOR DETAILED INFORMATION ON COMPONENT REPLACEMENT BY MODEL. IF YOU SUSPECT A PLUGGED EXPANSION VALVE, THE INLET SCREENS CAN BE CLEANED. IF THE VALVE IS NOT EQUIPPED WITH AN INLET SCREEN AND IS RESTRICTED, THE EXPANSION VALVE MAY ALSO NEED TO BE REPLACED.
TSBENG148R4
Service Bulletin/Repair Instructions
TSB REV4: CHATTER/RATTLE NOISE FROM ENGINE AFTER COLD SOAK - THIS BULLETIN PROVIDES INFORMATION ABOUT THE TIMING CHAIN TENSIONER REPLACEMENT ON SOME 2014~16MY CADENZA (VG), PRODUCED FROM FEBRUARY 1, 2013 THROUGH JANUARY 7, 2016, AND SOME 2014~2015MY SORENTO (XMA) VEHICLES, PRODUCED FROM DECEMBER 17, 2012 THROUGH DECEMBER 11, 2014, WHICH MAY EXPERIENCE A BRIEF CHATTERING OR RATTLING NOISE CONCERN FROM THE ENGINE ON START-UP, AFTER A COLD SOAK. AFTER CONFIRMING THE NOISE CONCERN, FOLLOW THE PROCEDURES OUTLINED IN THIS TSB TO RESOLVE THE CONCERN.
TSBCHA074R1
Service Bulletin/Repair Instructions
TSB REV1: MDPS FLEXIBLE COUPLING REPLACEMENT - THIS BULLETIN IS ISSUED TO PROVIDE INFORMATION ABOUT THE REPLACEMENT OF THE FLEXIBLE COUPLING IN THE MDPS MOTOR OF SOME VEHICLES WHICH MIGHT EXPERIENCE A KNOCK NOISE ORIGINATING FROM THE MDPS, WHEN MOVING THE STEERING WHEEL TO RIGHT OR LEFT WHEN THE VEHICLE IS STOPPED. THIS IS CAUSED BY PREMATURE WEAR OF THE FLEXIBLE COUPLING IN THE MDPS MOTOR. IF ANY KNOCK NOISE FROM THE MDPS OCCURS, REPLACE THE AFFECTED FLEXIBLE COUPLING ONLY WITH AN IMPROVED ONE, FOLLOWING THE REPLACEMENT PROCEDURE BELOW.
PS465
Service Bulletin/Repair Instructions
PITSTOP: RECALIBRATION OF BLIND SPOT DETECTION AFTER COLLISION REPAIRS - THIS PITSTOP PROVIDES INFORMATION RELATING TO SOME VEHICLES EQUIPPED WITH BLIND SPOT DETECTION (BSD), WHICH MAY EXHIBIT A CHECK BSD SYSTEM MESSAGE WITH DTCS: C270254 AND C270354: C270254: CONTROL MODULE MASTER MISSING CALIBRATION / C270354: CONTROL MODULE SLAVE MISSING CALIBRATION
TSBENG148R3
Service Bulletin/Repair Instructions
TSB: CHATTER/RATTLE NOISE FROM ENGINE AFTER COLD SOAK - THIS BULLETIN PROVIDES INFORMATION ABOUT THE TIMING CHAIN TENSIONER REPLACEMENT ON SOME 2014~16MY CADENZA (VG), PRODUCED FROM FEBRUARY 1, 2013 THROUGH JANUARY 7, 2016, AND SOME 2014~2015MY SORENTO (XMA) VEHICLES, PRODUCED FROM DECEMBER 17, 2012 THROUGH DECEMBER 11, 2014, WHICH MAY EXPERIENCE A BRIEF CHATTERING OR RATTLING NOISE CONCERN FROM THE ENGINE ON START-UP, AFTER A COLD SOAK. AFTER CONFIRMING THE NOISE CONCERN, FOLLOW THE PROCEDURES OUTLINED IN THIS TSB TO RESOLVE THE CONCERN.
TSBCHA074
Service Bulletin/Repair Instructions
TSB: MDPS FLEXIBLE COUPLING REPLACEMENT - THIS BULLETIN IS ISSUED TO PROVIDE INFORMATION ABOUT THE REPLACEMENT OF THE FLEXIBLE COUPLING IN THE MDPS MOTOR OF SOME VEHICLES WHICH MIGHT EXPERIENCE A KNOCK NOISE ORIGINATING FROM THE MDPS, WHEN MOVING THE STEERING WHEEL TO RIGHT OR LEFT WHEN THE VEHICLE IS STOPPED. THIS IS CAUSED BY PREMATURE WEAR OF THE FLEXIBLE COUPLING IN THE MDPS MOTOR. IF ANY KNOCK NOISE FROM THE MDPS OCCURS, REPLACE THE AFFECTED FLEXIBLE COUPLING ONLY WITH AN IMPROVED ONE, FOLLOWING THE REPLACEMENT PROCEDURE BELOW.
PS-282-R1
Service Bulletin/Repair Instructions
PITSTOP: RATTLING, SQUEAKING OR CREAKING NOISES FROM ROOF AREA - THIS BULLETIN DESCRIBES THE SERVICE PROCEDURES TO FOLLOW WHEN ADDRESSING A RATTLING, SQUEAKING AND/OR CREAKING NOISE CONCERN COMING FROM THE PANORAMA SUNROOF AREA.
PS282R1
Service Bulletin/Repair Instructions
PITSTOP - RATTLING, SQUEAKING OR CREAKING NOISES FROM ROOF AREA - This bulletin describes the Service Procedures to follow when addressing a rattling, squeaking and/or creaking noise concern coming from the Panorama Sunroof area.
PS443
Service Bulletin/Repair Instructions
TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones. Customers may experience issues with their head units that may be related to the use of aftermarket USB charging cables, including; * Electrical interference and limited or no functionality when attempting to play music, or when charging a device through the USB port * Excessive static or noise when listening to the audio source * Malfunctions and screen freeze of the head unit screen * Slow down of the system response while device is plugged in * Music will not play from iPhone 5 or 6 with Kia iPod cable and aftermarket adapter * No or limited functionality when trying to play music from an Apple device
TSB ENG148_REV1
Service Bulletin/Repair Instructions
THIS BULLETIN PROVIDES INFORMATION ABOUT THE TIMING CHAIN TENSIONER REPLACEMENT ON SOME 2014-2016 MY CADENZA VEHICLES PRODUCED FROM SOP THROUGH JANUARY 7, 2016, WHICH MAY EXPERIENCE A BRIEF CHATTERING OR RATTLING NOISE CONCERN FROM THE ENGINE AT START-UP AFTER A COLD SOAK. AFTER CONFIRMING THE NOISE CONCERN, FOLLOW THE PROCEDURES OUTLINED IN THE TSB TO RESOLVE THE CONCERN.
TSBENG148R1
Service Bulletin/Repair Instructions
TSB: CHATTER/RATTLE NOISE FROM ENGINE AFTER COLD SOAK - THIS BULLETIN PROVIDES INFORMATION ABOUT THE TIMING CHAIN TENSIONER REPLACEMENT ON SOME 2014~16MY CADENZA (VG) VEHICLES, PRODUCED FROM SOP THROUGH JANUARY 7, 2016, WHICH MAY EXPERIENCE A BRIEF CHATTERING OR RATTLING NOISE CONCERN FROM THE ENGINE ON START-UP, AFTER A COLD SOAK. AFTER CONFIRMING THE NOISE CONCERN, FOLLOW THE PROCEDURES OUTLINED IN THIS TSB TO RESOLVE THE CONCERN.
TSB-ELE-077-R1
Service Bulletin/Repair Instructions
TSB: REAR VIEW CAMERA DIAGNOSIS/REPLACEMENT - THIS BULLETIN PROVIDES INFORMATION TO DIAGNOSE AND/OR REPLACE THE REAR VIEW CAMERA OF SOME KIA VEHICLES (SEE TABLE ON PG. 6 FOR SPECIFIC MODELS AND PRODUCTION DATES) WHICH MAY EXHIBIT INADEQUATE IMAGE QUALITY FROM THE REAR VIEW CAMERA. DIAGNOSE THE CONCERNS USING THE INFORMATION IN THIS BULLETIN AND, IF NECESSARY, REPLACE THE REAR VIEW CAMERA WITH AN IMPROVED PART BY FOLLOWING THE APPLICABLE SERVICE PROCEDURE ON KGIS.
TSBSST041
Service Bulletin/Repair Instructions
TSB: KDS - AUDIO UPDATE MODULE (AUM) - THE GDS AUDIO UPDATE MODULE (AUM) WAS INTRODUCED IN FOURTH QUARTER OF 2013. THIS SPECIAL SERVICE TOOL (SST) WAS DEVELOPED TO IMPROVE THE EFFICIENCY AND EFFECTIVENESS OF UPDATING 2010MY, AND LATER, KIA AUDIO HEAD UNITS USING A GDS, AND NOW, THE SAME FUNCTIONALITY IS AVAILABLE ON KDS. SOME TECHNICIANS MAY NOT BE AWARE OF THE BENEFITS THE AUM TOOL HAS TO OFFER. THE AUM ELIMINATES THE NEED FOR MULTIPLE USB FLASH DRIVES FOR SPECIFIC VEHICLE MODELS AND APPLICATIONS WHICH, IF MISAPPLIED, MAY RESULT IN AN IMPROPER AUDIO SYSTEM SOFTWARE UPDATE AND/OR LOCKED UP HEAD UNIT. ADDITIONALLY, FIELD REPORTS HAVE INDICATED THAT USB DRIVES FOR AUDIO UPDATES ARE EASILY LOST OR MISPLACED.
148
Service Bulletin/Repair Instructions
Chatter/Rattle Noise from engine after cold soak
TSB-148
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
TSB-ELE091R1
Service Bulletin/Repair Instructions
TSB: IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - Identifying Head Unit Software Version For Direct Exchange (ELE091) (Rev 1) - This bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations. This procedure will now be required when ordering head units through the Direct Exchange Program (see Parts Bulletin 91-961-0005).
TSBELE091
Service Bulletin/Repair Instructions
TSB: IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - THIS BULLETIN PROVIDES THE PROCEDURE ON HOW TO IDENTIFY AND RECORD THE HEAD UNIT SOFTWARE LEVEL ON VARIOUS HEAD UNIT PLATFORMS AND GENERATIONS. THIS PROCEDURE WILL NOW BE REQUIRED WHEN ORDERING HEAD UNITS THROUGH THE DIRECT EXCHANGE PROGRAM.
TSBTRA049R1
Service Bulletin/Repair Instructions
TSB: 6-SPD. A/T ADAPTIVE VALUE RESET /RELEARN - THIS BULLETIN PROVIDES THE PROCEDURES NECESSARY TO RESET AND RELEARN THE ADAPTIVE VALUES AFTER TRANSMISSION REPLACEMENT OR REPROGRAMMING/REPLACEMENT OF THE PCM/TCM. AFTER THE ADAPTIVE VALUES ARE RESET, THE TRANSMISSION COMPUTER ADAPTIVE VALUES MUST BE RELEARNED BY DRIVING IN A PRECISE MANNER TO TEACH THE COMPUTER THE PROPER SOLENOID DUTY AND LINE PRESSURE FOR THE NEW TRANSMISSION/COMPUTER COMBINATION.
TSBTRA056
Service Bulletin/Repair Instructions
TSB: TCM UPGRADE SHIFT LOGIC IMPROVEMENT - THIS BULLETIN PROVIDES INFORMATION RELATED TO A TCM (TRANSMISSION CONTROL MODULE) SOFTWARE UPGRADE FOR SOME 2014~2015MY CADENZA (VG) VEHICLES, PRODUCED FROM FEBRUARY 11, 2013 THROUGH JULY 11, 2014 AND FROM JULY 14, 2014 THROUGH DECEMBER 12, 2014, TO IMPROVE A TRANSMISSION SHIFT CONCERN THAT MAY BE DESCRIBED AS HUNTING AND/OR BUSY SHIFT. TO RESOLVE THE CONCERN, REPROGRAM THE TCM/PCM USING THE GDS/KDS DOWNLOAD AS DESCRIBED IN THIS BULLETIN. FOR CONFIRMATION THAT THE LATEST REFLASH HAS BEEN PERFORMED, VERIFY ROM ID USING THE TABLES IN THIS TSB.
PS056
Service Bulletin/Repair Instructions
TCM Upgrade - Shift Logic Improvement
PS391
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
TSBELE090
Service Bulletin/Repair Instructions
TSB: C STATE ERROR MESSAGE ON VERSION 8.5 MAP UPDATE - THIS BULLETIN DESCRIBES AN SD CARD REPLACEMENT PROCEDURE FOR CUSTOMERS THAT HAVE A SPECIFIC ERROR DISPLAYED ON THE NAVIGATION HEAD UNIT (SHOWN BELOW) AFTER PURCHASING AND INSTALLING A VERSION 8.5 MAP UPDATE SD CARD. A TOTAL OF 129 AFFECTED SD CARDS WERE PURCHASED BY CUSTOMERS THROUGH KIA DEALERS, FROM JANUARY 1ST TO MAY 11TH, 2015.
PS417
Service Bulletin/Repair Instructions
PITSTOP: DTC P0315 - CRANKSHAFT POSITION (CKP) SENSOR VARIATION NOT LEARNED - WHEN ENCOUNTERING A CUSTOMER COMPLAINT OF ENGINE MISFIRE WITH A MALFUNCTION INDICATOR LIGHT (MIL) ON IN THE DASH, CHECK FOR THE PRESENCE OF DTC P0315 CRANKSHAFT POSITION SENSOR (CKP) VARIATION NOT LEARNED. USE THE VMI TO VIEW THE SCOPE PATTERN OF THE CRANKSHAFT POSITION SENSOR SIGNAL. VERIFY A GOOD EQUAL CRANKSHAFT SENSOR PATTERN IS PRESENT WITH NO DIPS OR VARIATION, AS SHOWN IN FIGURE A, IN THE SIGN WAVE PATTERN. IF THE PATTERN IS IDENTICAL TO FIGURE A, USE GDS/KDS TO PERFORM A CRANK SENSOR RELEARN PROCEDURE. IF THE PATTERN SHOWS A DIP OR VARIATION, AS SHOWN IN FIGURE B, REPLACE THE FLEX PLATE TO RESOLVE THE CONCERN.
PS-417
Service Bulletin/Repair Instructions
KIA: CRANKSHAFT POSITION SENSOR (CKP) VARIATION HAS NOT LEARNED CAUSING MISFIRE OF ENGINE AND MALFUNCTION INDICATOR LIGHT (MIL) TO COME IN DASH. MODEL ALL. NO YEARS LISTED. *PE
TSBELE089
Service Bulletin/Repair Instructions
TSB: NAVIGATION HEAD UNIT SD CARD REPLACEMENT - THIS BULLETIN DESCRIBES THE SD CARD EXCHANGE/REPLACEMENT PROCEDURE RELATED TO ERROR MESSAGES THAT MAY BE DISPLAYED ON THE NAVIGATION SCREEN WHEN THE INCORRECT SD CARD IS INSERTED. NOTE: ONLY NEW MODELS (DURING PDI INSPECTION OR AT THE POINT OF PURCHASE) OR COMPATIBILITY MISMATCHES THAT OCCUR AFTER HEAD UNIT REPLACEMENT WILL BE CONSIDERED FOR THIS PROGRAM.
TSBTRA051R1
Service Bulletin/Repair Instructions
TSB: 6 SPD A/T SOLENOID REPLACEMENT MULTIPLE DTCS - THIS BULLETIN PROVIDES INFORMATION RELATING TO THE REPLACEMENT OF VARIOUS SHIFT SOLENOIDS ON 6-SPEED AUTOMATIC TRANSAXLES WITH DTCS P0741, P0743, P0748, P0753, P0758, P0763, P0768, P0773, P1778 AND P2709. REPLACE THE SOLENOIDS IF CURRENT OR HISTORY CODES ARE PRESENT; DO NOT REPLACE THE TRANSAXLE. TO REDUCE VEHICLE REPAIR TIME, THIS PROCEDURE CAN BE PERFORMED WITH THE TRANSAXLE INSTALLED IN THE VEHICLE. REFER TO KGIS FOR SOLENOID PACK REMOVAL AND REINSTALLATION PROCEDURES FOR THE SPECIFIC YEAR AND MODEL OF THE VEHICLE.
PS400
Service Bulletin/Repair Instructions
PITSTOP: SMART PEDAL FEATURE - THE SMART PEDAL IS AN INTEGRAL PART OF THE ENGINE MANAGEMENT SYSTEM (EMS) FUNCTIONALITY WHICH MONITORS AND PREVENTS THE SIMULTANEOUS ACTIVATION OF ACCELERATOR AND BRAKE PEDALS. WHEN ENGAGED, THE FEATURE REDUCES ENGINE POWER TO IDLE. MOST CUSTOMERS WILL NEVER NOTICE THE SMART PEDAL FEATURE WHEN ACTIVE, HOWEVER, CUSTOMERS WHO TEND TO REST THEIR FOOT ON THE BRAKE PEDAL WHILE DRIVING MIGHT DESCRIBE A HESITATION OR DELAY SYMPTOM AND NOT REALIZE THAT THE EMS ELECTRONIC CONTROL MODULE IS INTERVENING, AS DESIGNED.
TSB-ELE062R2
Service Bulletin/Repair Instructions
TSB: NAVIGATION UNIT SOFTWARE UPGRADE - This bulletin provides the procedure for upgrading the navigation system software on some 2014MY Cadenza (VG) Sorento (XMa) and Optima (TF/QF) vehicles, produced from March 11, 2013 through January 24, 2014.
TSB-GEN057
Service Bulletin/Repair Instructions
TSB: GENERAL INFORMATION AND DIAGNOSIS FOR SMART KEY FOB SYSTEMS AND START/STOP BUTTONS - This bulletin provides information related to the Smart Key Systems on vehicles equipped with A/T (automatic transaxle) and Start/Stop Buttons (SSB).
TSB-ELE062R1
Service Bulletin/Repair Instructions
TSB: NAVIGATION UNIT SOFTWARE UPGRADE - This bulletin provides the procedure for upgrading the navigation system software on some 2014MY Cadenza (VG) and Optima (TF/QF) vehicles, produced from March 11, 2013 through January 24, 2014.
TSB-GEN065
Service Bulletin/Repair Instructions
TSB: NAVIGATION UNIT PART NUMBER AND SD CARD COMPATIBILITY - This bulletin provides information regarding navigation unit part numbers, and compatible SD Card part numbers, for some Cadenza (VG), Sorento (XMa) and Forte (YD) vehicles.
TSB-CHA044R2
Service Bulletin/Repair Instructions
TSB: MDPS FLEXIBLE COUPLING REPLACEMENT - Rev 2 - This bulletin provides information related to the replacement of the flexible coupling in the MDPS motor of some of vehicles, which may experience a ?clicking? noise emanating from the MDPS when turning the steering wheel left or right, while stopped. This condition may be caused by premature wear of the flexible coupling in the MDPS.
TSB-CLI024
Service Bulletin/Repair Instructions
TSB: TESTING A/C COMPRESSOR FUNCTION USING GDS - This bulletin provides information on a new procedure to test A/C compressor function using the GDS.
TSB-CHA044R1
Service Bulletin/Repair Instructions
TSB: MDPS FLEXIBLE COUPLING REPLACEMENT - This bulletin provides information related to the replacement of the flexible coupling in the MDPS motor of some of vehicles, which may experience a ?clicking? noise emanating from the MDPS when turning the steering wheel left or right, while stopped.
PS320
Service Bulletin/Repair Instructions
PIT STOP: ROUGH IDLE AFTER COLD START ON 3.3L GDI ENGINE - When addressing a customer complaint of rough idle, which occurs only on the first start of the day and lasts for 30-45 seconds, check for the possibility of poor injector performance in a particular cylinder.
TSB-CHA044
Service Bulletin/Repair Instructions
TSB: MDPS FLEXIBLE COUPLING REPLACEMENT - This bulletin provides information related to the replacement of the flexible coupling in the MDPS motor of some of vehicles, which may experience a ?clicking? noise emanating from the MDPS when turning the steering wheel left or right, while stopped. This condition may be caused by premature wear of the flexible coupling in the MDPS.
TSB-TRA051
Service Bulletin/Repair Instructions
TSB: 6 SPD A/T SOLENOID REPLACEMENT ? DTC P0741 - This bulletin provides information relating to the replacement of the Damper Clutch (D/C) Solenoid on 6-speed automatic transaxles with DTC P0741 (active or history), instead of replacing the transaxle. To reduce vehicle repair time, this procedure can be performed with the transaxle installed in the vehicle.
PS315
Service Bulletin/Repair Instructions
PIT STOP: GDI INJECTOR SPRAY TIP DEPOSITS - A design feature of vehicles equipped with a Gasoline Direct Injection (GDI) system is the placement of each fuel injector directly into the engine cylinder head assembly. Therefore, it is completely normal for the combustion process to create deposits on the injector spray tip surfaces.
PS307
Service Bulletin/Repair Instructions
PIT STOP: PROGRAMMING A THIRD SMART KEY ON CERTAIN 2014-15MY VEHICLES - In past Smart Key systems, the maximum amount of keys that could be programmed to a vehicle was 2. On certain 2014-15MY Kia vehicles, the amount of keys that can be programmed to a vehicle has increased to 3. For information on the current number of keys ?learned? by the system, access SMK > Current Data in GDS, as shown below. To program any additional keys, follow the applicable service procedure on KGIS.
TSB-SST033
Service Bulletin/Repair Instructions
TSB: SPECIAL SERVICE TOOL FOR HOOD RELEASE LEVER REMOVAL - This bulletin provides information related to the introduction of a new Special Service Tool (SST) (A) developed to prevent the hood release lever pivot point (B) from being damaged when removing the hood release lever. Follow the instructions included in this bulletin to properly remove the hood release lever using the new SST.
TT057
Service Bulletin/Repair Instructions
TECH TIP: Navigation System Displaying the Wrong Location - Customer complains that the location displayed on the map is different than the actual location (i.e. system shows location in a river, lake, etc.). This tech tip gives the procedure to resolve.
TSB-ELE062
Service Bulletin/Repair Instructions
TSB: NAVIGATION UNIT SOFTWARE UPGRADE - This bulletin provides the procedure for upgrading the navigation system software on some 2014MY Cadenza (VG) vehicles, produced from March 11, 2013 through January 24, 2014. The software upgrade addresses the following concerns: 1. Error Messages displayed in Korean (Navi.exe and mmMedia.exe) which are sometimes followed by system lock-ups. 2. Speed Dependent Volume staying active. 3. Sirius Traffic being inoperative or intermittently inoperative.
062
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
062-REV1A
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
PS282
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
TT009
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
TSB-ENG137R1
Service Bulletin/Repair Instructions
TSB: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC005) - This bulletin provides information related to extracting ?in use performance tracking? emissions data from the engine control unit (ECU) in certain vehicles sold in California.
TSB-FUE026
Service Bulletin/Repair Instructions
TSB: MIL ON WITH DTC P0087 - DIAGNOSIS AND REPAIR - This bulletin provides information related to some Optima (TF/QF), Sportage (SL), Sorento (XM) and Cadenza (VG) vehicles, which may experience a malfunction indicator lamp (MIL) illuminated with the ECM (Electronic Control Module) system-related DTC P0087.
PS272R1
Service Bulletin/Repair Instructions
PITSTOP: LOCATING THE DRIVER'S DOOR LOCK CYLINDER, TRUNK LOCK CYLINDER AND THE TRUNK LID CONTROL BUTTON - This article provides information about the location of the driver's door lock and trunk lock cylinders on all Cadenza vehicles.
137
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
PS273
Service Bulletin/Repair Instructions
PITSTOP: AVN HEAD-UNIT AND/OR MONITOR REPLACEMENT - WHEN PERFORMING A REPLACEMENT OF THE AVN HEAD UNIT OR MONITOR ON CADENZA VEHICLES, MAKE SURE TO DISCONNECT THE NEGATIVE (-) TERMINAL FROM THE BATTERY BEFORE CONDUCTING ANY REPAIRS. ALL POWER SHOULD BE DISCONTINUED TO THE AVN MONITOR WHEN UNPLUGGED FROM THE AVN HEAD UNIT.