Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
PS797
Other
PITSTOP: TECHNICAL OPERATIONS: EXTERNAL DAMAGE TO ULTRASONIC SENSOR: This Pitstop provides information related to Parking Distance Warning (PDW) alerts and repairs involving ultrasonic sensors. The PDW system alerts the driver while parking, by calculating distance based on the difference in signal transmission and reception times between the vehicle (ultrasonic sensor) and an object. The membrane film of the ultrasonic sensor is used for object detention and can be damaged by stone chips or foreign substances while driving. Damage to the cover of the ultrasonic sensor can also lead to damage to the internal circuit. As a result of this external damage, the PDW system may not receive the proper signal from the ultrasonic sensor. In some cases, the system may cause a false alarm, no alert, or phantom warnings by a “Warning Lamp’ to be displayed on the cluster. The ultrasonic sensor membrane film should be always inspected for external damage and if any part replacement should be treated as a general repair, not as a warranty claim repair for this concern. (Please note that this Pitstop only applies to models/trims that are equipped with the ultrasonic sensors.)
TSB_TRA046_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission.
TSB_TRA046_R4
Service Bulletin/Repair Instructions
This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.
TSB_TRA046_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.
TSB_ENG219_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides information on setting the "Service Interval Reminder" feature available on most 2014-2023MY Kia vehicles (refer to model list on page 2). If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance. Refer to TSB ENG241 for 2023MY~ vehicles equipped with the Oil Life Management System (OLMS) feature not included in table on page 2.
TSB_BOD055_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
TSB_TRA096
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: 8AT (A8LR1-SBW) SOLENOID VALVE REPLACEMENT AND TCU LOGIC IMPROVEMENT - This bulletin provides the procedure to replace two (2) solenoid valves (35R and 4&OD) and improve the gear shift logic of the Transmission Control Unit (TCU) on some 2015-2016MY K900 (KH) vehicles, equipped with Tau 5.0L engine and 8-speed automatic transmission w/Shift-By-Wire (A8LR1-SBW), which may exhibit symptoms of abnormal shift shock during an upshift (2nd-->3rd, 3rd-->4th, 4th-->5th). This condition occurs on vehicles with mileage over 12,000 miles and may be due to possible premature wear of the solenoid valve. To correct this concern, replace the 35R and 4&O/D solenoid valves with added âHâ ventilation port, perform TCU relearn, and, if applicable, apply the improved logic to the Transmission system using the KDS ECU Upgrade function as described in this bulletin.
PS704
Service Bulletin/Repair Instructions
PITSTOP: FRONT RADAR SENSOR MOUNTING INSPECTION (PS704) - This pitstop provides information regarding front radar sensor alignment on 2014MY and later vehicles that may exhibit a warning light ON related to radar sensor alignment errors in the Forward Collision-Avoidance Assist (FCA)/Smart Cruise Control (SCC) system.
PS299_R4
Service Bulletin/Repair Instructions
PITSTOP: CORRECT PROCEDURE FOR RAISING WINDSHIELD WIPERS - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. When servicing windshield wipers on the below listed vehicles, including during PDI, ensure to raise the wiper arms to a vertical position to avoid damaging the paint on the rear edge of the hood.
PS675
Service Bulletin/Repair Instructions
PITSTOP - BRAKE CALIPER LEAK INSPECTION - This PITSTOP provides information related to a brake caliper fluid/oil substance found on some Kia vehicles, due to possible excess assembly oil applied during assembly.
TSB_ENG219
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin provides information on setting the "Service Interval Reminder" feature available on most Kia vehicles. If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance.
TSB_TRA046_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: - TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles on page 2. Refer to the shop manual on KGIS for the specific Kia model for the correct transmission fluid check/fill procedures.
TSBENG083_R1
Service Bulletin/Repair Instructions
TSB: SPECIAL SERVICE INFORMATION & SPECIFICATIONS FOR GDI HIGH PRESSURE FUEL SYSTEM - This bulletin has been revised to include additional information. This bulletin provides information relating to all Kia vehicles equipped with Gasoline Direct Injection (GDI) engines. In these engines highly pressurized gasoline is injected via a common fuel rail and injectors that deliver fuel directly into the combustion chamber of each cylinder. In comparison, in a conventional Multi-Point Fuel Injection (MPI) engine, the gasoline is injected into the intake port of each cylinder at a relatively low pressure. Due to high fuel pressure in a GDI system, servicing the GDI system requires special attention and handling procedures. This bulletin provides special service information and specifications for the GDI fuel system components.
PS299_R3
Service Bulletin/Repair Instructions
PITSTOP - CORRECT PROCEDURE FOR RAISING WINDSHIELD WIPERS - When servicing the windshield wipers on the listed vehicles below during PDI, make sure to use the procedure outlined below to raise the wiper arms to the fully vertical position in order to avoid damaging the paint on the rear edge of the hood. It is important to note that the wipers on these vehicles are recessed under the hood to provide better appearance and reduced wind noise characteristics. This procedure applies to both key start and SMK type ignition systems.
PS578
Service Bulletin/Repair Instructions
PITSTOP: IDENTIFYING A SEIZED COMPRESSOR - This Pitstop provides information regarding the diagnosis of an A/C related concern on 2017-2019MY Sportage (QL) and 2015-2018MY K900 (KH) vehicles that may have a seized compressor. To confirm the diagnosis of a seized A/C compressor, visually inspect for a paint mark (A) against the limiter in the center of the compressor. If the mark is no longer aligned (B), an internal disconnection of the limiter has occurred and the compressor assembly needs to be replaced.
PS299_R2
Service Bulletin/Repair Instructions
PITSTOP - CORRECT PROCEDURE FOR RAISING WINDSHIELD WIPERS - When servicing the windshield wipers on 2015MY~ K900 (KH), 2016MY~ Optima (JFa/JF), and 2018MY~ Stinger (CK) vehicles during PDI, make sure to use the procedure outlined below to raise the wiper arms to the fully vertical position in order to avoid damaging the paint on the rear edge of the hood. It is important to note that the wipers on these vehicles are recessed under the hood to provide better appearance and reduced wind noise characteristics.
PS539
Service Bulletin/Repair Instructions
PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine.
PS430_CLOSED
Service Bulletin/Repair Instructions
PS430 CLOSED. REFER TO TSB TRA067.
TSBTRA067
Service Bulletin/Repair Instructions
TSB - AUTOMATIC TRANSMISSION OIL PRESSURE CHARACTERISTIC VALUES DATA TRANSFER - This bulletin provides information regarding data transfer of automatic transmission (A/T) characteristic values on 2015MY-2018MY K900 (KH) vehicles equipped with A8TR1 8-speed A/T and 2017MY~ Sportage (QL), Forte (YDm), and Cadenza (YG) vehicles equipped with the GEN2 Type (A6MF2-2 6-speed / A8LF1 8-speed) A/T. The type of solenoid valve used to control gear shifts changed from indirect to direct control type to reduce oil capacity and improve fuel efficiency.
TSBELE091R3
Service Bulletin/Repair Instructions
TSB - IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - This bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations.
VSC156TSB
Service Bulletin/Repair Instructions
SC156 - TSB - Technical Service Bulletin regarding the K900 Seatbelt Anchor Pretensioner Sticker.
VSC156
Service Bulletin/Repair Instructions
SC156 - OWNER LETTER - Notification of new safety recall campaign for the seatbelt anchor pretensioner sticker.
VSC156DP
Service Bulletin/Repair Instructions
SC156 - DEALER PRINCIPAL LETTER - Notification of new safety recall campaign for the seatbelt anchor pretensioner sticker.
VSC156DSM
Service Bulletin/Repair Instructions
SC156 - DEALER SERVICE MANAGER LETTER - Notification of new safety recall campaign for the seatbelt anchor pretensioner sticker.
VSC156QA
Service Bulletin/Repair Instructions
SC156 - QUESTION AND ANSWER GUIDE - Notification of new safety recall campaign for the seatbelt anchor pretensioner sticker FAQs.
PS474
Service Bulletin/Repair Instructions
PITSTOP: TPMS SENSOR POSITION - When diagnosing TPMS-related DTCs, make sure you are investigating the correct sensor. The TPMS positioning from the manufacturer may be different from the positioning shown on a KDS.
PS496
Service Bulletin/Repair Instructions
PITSTOP: CUSTOMER TIP: ACCELERATOR PEDAL FUNCTION/DESCRIPTION - On all K900 (KH), Cadenza (VG, YG), and Optima (JF, JFa, JF-HEV, JF-PHEV) vehicles, the accelerator pedal features a small detent with a spring to provide increased resistance to help avoid unnecessary fuel consumption when applying full throttle. When the driver depresses the pedal beyond the resistance where the detent is felt (above 85% WOT), the pedal will easily reach WOT and kickdown shift will occur accordingly. For additional information, refer to the individual vehicle?s Owner?s Manual under section ?Driving Your Vehicle? ? Automatic Transmission (Drive).
PS493
Service Bulletin/Repair Instructions
TSB: DEFOGGING LOGIC ? NORMAL OPERATION, DISABLING, AND ENABLING - Starting with 2010MY, all Kia vehicles, except Rio (JB), incorporate a defogging logic to prevent the interior windows from becoming excessively fogged. Depending on the specific model, the HVAC control head monitors ambient temperature and/or cabin humidity to determine which settings will best prevent the windows from fogging. If the system detects lower ambient temperature or higher cabin humidity, the defogging logic may automatically switch ON the A/C, and/or set the air intake mode to Fresh Air. If the user changes these settings, the defogging logic will take control again after 3 to 5 minutes, depending on the procedure in this publication.
TSB-ELE122
Service Bulletin/Repair Instructions
TSB: PREMIUM NAVIGATION UNIT SOFTWARE UPGRADE - This bulletin provides the procedure for upgrading the navigation system software of some 2015MY K900 (KH) vehicles, produced from January 2, 2014 through March 17, 2015, to resolve concerns related to ?Application Error? messages on the navigation screen and system reboots or blank screen concerns
PS469
Service Bulletin/Repair Instructions
PITSTOP: MANUAL EVAPORATIVE EMISSIONS TEST FOR HARD TO FIND/SMALL LEAKS - If the malfunction indicator lamp (MIL) is illuminated with DTC(s) P0442, P0455, P0456, or P0457 (Evaporative Emissions System-Leak detected) and the evaporative (EVAP) leak self-test resulted in NTF, a manual EVAP test is recommended.
TSB-GEN085R1
Service Bulletin/Repair Instructions
TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.? It is critical for technicians to be aware that ALL such locking fasteners, regardless of type, are for ?one time use? only.
PS472R1
Service Bulletin/Repair Instructions
PITSTOP: HVAC VENTILATION LOGIC OPERATION - Starting with 14MY Soul (PS) (with the exception of PSEV) and complete new models such as K900 (KH), Sedona (YP), Sorento (UMa), Optima (JFa), Sportage (QL), and 17MY Forte (YD, YDm), etc., equipped with a sunroof, a ventilation logic has been applied in order to prevent exhaust gases flowing into the vehicle due to the pressure difference (inside vs outside) that is generated when driving with the sunroof open. This logic allows the system to automatically switch from RECIRCULATION to FRESH mode when the sunroof is open.
TSB-GEN085
Service Bulletin/Repair Instructions
TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?
TSB-TRA055
Service Bulletin/Repair Instructions
TSB: INHIBITOR SWITCH DIAGNOSIS INFORMATION - This bulletin gives information regarding the steps to take regarding the diagnosis of the Inhibitor Switch.
PS266R1
Service Bulletin/Repair Instructions
PITSTOP: HVAC RECEIVER/DRYER - DESICCANT REPLACEMENT - IN THE EVENT OF A HVAC SYSTEM CONCERN IN WHICH METAL PARTICLES OR SHARDS HAVE CONTAMINATED THE SYSTEM, THE DESICCANT OR THE ENTIRE A/C RECEIVER/DRYER ASSEMBLY MAY NEED TO BE REPLACED. THIS IS DUE TO THE FACT THAT IT MAY BE IMPOSSIBLE TO REMOVE ALL METAL CONTAMINANTS FROM THE RECEIVER/DRYER DURING THE A/C FLUSHING PROCEDURE. REFER TO THE INCLUDED TABLE FOR DETAILED INFORMATION ON COMPONENT REPLACEMENT BY MODEL. IF YOU SUSPECT A PLUGGED EXPANSION VALVE, THE INLET SCREENS CAN BE CLEANED. IF THE VALVE IS NOT EQUIPPED WITH AN INLET SCREEN AND IS RESTRICTED, THE EXPANSION VALVE MAY ALSO NEED TO BE REPLACED.
PS465
Service Bulletin/Repair Instructions
PITSTOP: RECALIBRATION OF BLIND SPOT DETECTION AFTER COLLISION REPAIRS - THIS PITSTOP PROVIDES INFORMATION RELATING TO SOME VEHICLES EQUIPPED WITH BLIND SPOT DETECTION (BSD), WHICH MAY EXHIBIT A CHECK BSD SYSTEM MESSAGE WITH DTCS: C270254 AND C270354: C270254: CONTROL MODULE MASTER MISSING CALIBRATION / C270354: CONTROL MODULE SLAVE MISSING CALIBRATION
TSBELE103
Service Bulletin/Repair Instructions
SERVICE ACTION: START STOP BUTTON (SSB) INSPECTION AND REPLACEMENT (SA228) - THIS BULLETIN PROVIDES THE PROCEDURE TO INSPECT THE START BUTTON SWITCH CAP AND REPLACE THE START BUTTON SWITCH ASSEMBLY, IF NECESSARY, ON CERTAIN 2015 MY K900 (KH) VEHICLES, PRODUCED FROM DECEMBER 18, 2013 THROUGH MAY 12, 2014. THE SSB IN CERTAIN VEHICLES MAY CAUSE DIFFICULTY STARTING AND/OR SHUTTING OFF THE VEHICLE DUE TO A BROKEN START BUTTON SWITCH CAP.
TSB_ELE103
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: START STOP BUTTON (SSB) INSPECTION AND REPLACEMENT (SA228) - This bulletin provides the procedure to inspect the start button switch cap and replace the start button switch assembly, if necessary, on certain 2015 MY K900 (KH) vehicles, produced from December 18, 2013 through May 12, 2014. The SSB in certain vehicles may cause difficulty starting and/or shutting off the vehicle due to a broken start button switch cap.
TSBSC130
Service Bulletin/Repair Instructions
MULTI-FUNCTION SWITCH REPLACEMENT (SC130) - THIS BULLETIN PROVIDES THE PROCEDURE TO REPLACE THE MULTI-FUNCTION SWITCH (SEE BELOW) IN CERTAIN 2015~2016MY K900 (KH) LUXURY V8 VEHICLES,EQUIPPED WITH LED HEADLIGHTS, AND PRODUCED FROM DECEMBER 18, 2013 THROUGH JANUARY 11, 2016. USE OF THE HEADLIGHTS IN AUTO MODE OVER TIME MAY RESULT IN INCREASED ELECTRICAL RESISTANCE OF THE CONTACT POINTS, WHICH IN TURN MAY AFFECT THE OPERATION OF THE ELECTRONIC CONTROL UNIT LOCATED INSIDE THE MULTI-FUNCTION SWITCH. IF THIS OCCURS, THE HEADLIGHTS MAY FLICKER AND/OR INTERMITTENTLY TURN OFF WHILE DRIVING. TO CORRECT THIS CONDITION, FOLLOW THE PROCEDURE OUTLINED IN THIS BULLETIN. BEFORE CONDUCTING THE PROCEDURE, VERIFY THE VEHICLE IS INCLUDED IN THE LIST OF AFFECTED VINS.
TSB_SC130
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MULTI-FUNCTION SWITCH REPLACEMENT (SC130) - This bulletin provides the procedure to replace the Multi-Function Switch (see below) in certain 2015~2016MY K900 (KH) Luxury V8 vehicles, equipped with LED Headlights, and produced from December 18, 2013 through January 11, 2016. Use of the headlights in AUTO mode over time may result in increased electrical resistance of the contact points, which in turn may affect the operation of the Electronic Control Unit located inside the Multi-Function Switch. If this occurs, the headlights may flicker and/or intermittently turn off while driving. To correct this condition, follow the procedure outlined in this bulletin. Before conducting the procedure, verify the vehicle is included in the list of affected VINs.
PS443
Service Bulletin/Repair Instructions
TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones. Customers may experience issues with their head units that may be related to the use of aftermarket USB charging cables, including; * Electrical interference and limited or no functionality when attempting to play music, or when charging a device through the USB port * Excessive static or noise when listening to the audio source * Malfunctions and screen freeze of the head unit screen * Slow down of the system response while device is plugged in * Music will not play from iPhone 5 or 6 with Kia iPod cable and aftermarket adapter * No or limited functionality when trying to play music from an Apple device
PS430
Service Bulletin/Repair Instructions
8-SPEED TRANSMISSION REPLACEMENT REQUIREMENTS - ON K900 (KH) VEHICLES, THE 8-SPEED TRANSMISSION (A8TR1) HAS PRECISE DIRECT SOLENOID CONTROL FOR THE CLUTCH AND BRAKE SYSTEM INSIDE THE TRANSMISSION. DUE TO HYDRAULIC PRESSURE VARIANCE AT THE TIME OF TRANSMISSION AND SOLENOID PRODUCTION, SHOCK OR SHIFT DELAY MAY OCCUR DURING GEAR SHIFT AFTER REPLACEMENT. IN RESPONSE TO THIS PRESSURE VARIANCE, THE HYDRAULIC PRESSURE IS RECORDED IN A BAR CODE FORMAT AND AFFIXED IN THE FORM OF TWO LABELS (A) ON THE LEFT SIDE OF THE TRANSMISSION. WHENEVER THE TCM AND/OR 8-SPEED TRANSMISSION IS REPLACED, THE BAR CODE VALUE MUST BE ENTERED (B) INTO GDS/KDS BY FOLLOWING THE PROCEDURE OUTLINED ON KGIS.
PS299R1
Service Bulletin/Repair Instructions
CORRECT PROCEDURE FOR RAISING WINDSHIELD WIPERS - THIS ARTICLE OUTLINES THE PROCEDURE TO BE USED TO RAISE THE WIPER ARMS TO THE FULLY VERTICAL POSITION.
TSBSST041
Service Bulletin/Repair Instructions
TSB: KDS - AUDIO UPDATE MODULE (AUM) - THE GDS AUDIO UPDATE MODULE (AUM) WAS INTRODUCED IN FOURTH QUARTER OF 2013. THIS SPECIAL SERVICE TOOL (SST) WAS DEVELOPED TO IMPROVE THE EFFICIENCY AND EFFECTIVENESS OF UPDATING 2010MY, AND LATER, KIA AUDIO HEAD UNITS USING A GDS, AND NOW, THE SAME FUNCTIONALITY IS AVAILABLE ON KDS. SOME TECHNICIANS MAY NOT BE AWARE OF THE BENEFITS THE AUM TOOL HAS TO OFFER. THE AUM ELIMINATES THE NEED FOR MULTIPLE USB FLASH DRIVES FOR SPECIFIC VEHICLE MODELS AND APPLICATIONS WHICH, IF MISAPPLIED, MAY RESULT IN AN IMPROPER AUDIO SYSTEM SOFTWARE UPDATE AND/OR LOCKED UP HEAD UNIT. ADDITIONALLY, FIELD REPORTS HAVE INDICATED THAT USB DRIVES FOR AUDIO UPDATES ARE EASILY LOST OR MISPLACED.
TSBFUE029
Service Bulletin/Repair Instructions
SERVICE ACTION - REAR OXYGEN (02) SENSOR LOGIC IMPROVEMENT (SA199) - THIS BULLETIN PROVIDES INFORMATION RELATED TO THE ECM SOFTWARE UPGRADE OF SOME 2015MY K900 (KH) VEHICLES, PRODUCED FROM DECEMBER 13, 2013 THROUGH DECEMBER 15, 2014, TO IMPROVE REAR OXYGEN (02) SENSOR LOGIC.
TSB-ELE091R1
Service Bulletin/Repair Instructions
TSB: IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - Identifying Head Unit Software Version For Direct Exchange (ELE091) (Rev 1) - This bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations. This procedure will now be required when ordering head units through the Direct Exchange Program (see Parts Bulletin 91-961-0005).
TSBELE091
Service Bulletin/Repair Instructions
TSB: IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - THIS BULLETIN PROVIDES THE PROCEDURE ON HOW TO IDENTIFY AND RECORD THE HEAD UNIT SOFTWARE LEVEL ON VARIOUS HEAD UNIT PLATFORMS AND GENERATIONS. THIS PROCEDURE WILL NOW BE REQUIRED WHEN ORDERING HEAD UNITS THROUGH THE DIRECT EXCHANGE PROGRAM.
PS-417
Service Bulletin/Repair Instructions
KIA: CRANKSHAFT POSITION SENSOR (CKP) VARIATION HAS NOT LEARNED CAUSING MISFIRE OF ENGINE AND MALFUNCTION INDICATOR LIGHT (MIL) TO COME IN DASH. MODEL ALL. NO YEARS LISTED. *PE
TSBENG147
Service Bulletin/Repair Instructions
TSB: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC1501) - THIS BULLETIN PROVIDES INFORMATION RELATED TO EXTRACTING IN USE PERFORMANCE TRACKING EMISSIONS DATA FROM THE ENGINE CONTROL UNIT (ECU) OF CERTAIN VEHICLES SOLD IN CALIFORNIA. THE CALIFORNIA AIR RESOURCES BOARD (CARB) REQUIRES THE EMISSIONS DATA FROM VEHICLES WITH A MINIMUM OF 3,000 ACCUMULATED MILES WITHOUT REPROGRAMMING OR RESETTING. TO FACILITATE COLLECTION OF THIS DATA AT THE DEALER LEVEL, GDS/KDS SCREENSHOTS WILL ALLOW THE CAPTURE OF RELEVANT PARAMETERS.
TSBELE089
Service Bulletin/Repair Instructions
TSB: NAVIGATION HEAD UNIT SD CARD REPLACEMENT - THIS BULLETIN DESCRIBES THE SD CARD EXCHANGE/REPLACEMENT PROCEDURE RELATED TO ERROR MESSAGES THAT MAY BE DISPLAYED ON THE NAVIGATION SCREEN WHEN THE INCORRECT SD CARD IS INSERTED. NOTE: ONLY NEW MODELS (DURING PDI INSPECTION OR AT THE POINT OF PURCHASE) OR COMPATIBILITY MISMATCHES THAT OCCUR AFTER HEAD UNIT REPLACEMENT WILL BE CONSIDERED FOR THIS PROGRAM.
TSBCLI025
Service Bulletin/Repair Instructions
TSB: A/C COMPRESSOR REPLACEMENT - THIS BULLETIN PROVIDES THE PROCEDURE FOR REPLACING THE A/C COMPRESSOR ON SOME 2015MY K900 (KH) VEHICLES, PRODUCED FROM JOB #1 THROUGH OCTOBER 13, 2014, WHICH MAY EXPERIENCE DIMINISHED COOLING PERFORMANCE OR AN INOPERATIVE A/C SYSTEM. TECHNICIANS CAN VALIDATE THIS CONDITION BY OPERATING THE A/C SYSTEM AND BY CHECKING SYSTEM LINE PRESSURE. IF SYSTEM PRESSURES (HIGH/LOW) ARE EQUAL; CHECK FOR COMPRESSOR SEIZURE OR FOR A CRACKED COMPRESSOR CASING (COMPLETE LOSS OF REFRIGERANT). TO CORRECT THIS CONCERN, REPLACE THE A/C COMPRESSOR, INCLUDING REQUIRED ASSOCIATED PARTS PER THE TABLE ON PAGE 3, BY REFERRING TO THE APPLICABLE WORKSHOP MANUAL ON KGIS.
PS360
Service Bulletin/Repair Instructions
PITSTOP: AIR INTAKE MODE CHANGES WHEN OPENING SUNROOF - WHEN ADDRESSING CUSTOMER COMPLAINTS REGARDING THE AIR INTAKE MODE SWITCHING FROM RECIRCULATION TO FRESH AIR MODE WITHOUT CUSTOMER INPUT; ON THE APPLICABLE VEHICLES IN THIS PITSTOP, THE HVAC LOGIC HAS BEEN MODIFIED TO SWITCH THE AIR INTAKE MODE TO FRESH AIR, AUTOMATICALLY, WHEN OPENING THE SUNROOF. THIS IS DONE TO PREVENT EXHAUST GASES FROM ENTERING THE CABIN WHEN THE SUNROOF IS OPEN. THIS CONDITION SHOULD BE CONSIDERED NORMAL OPERATION AND NOT A MALFUNCTION.
PS400
Service Bulletin/Repair Instructions
PITSTOP: SMART PEDAL FEATURE - THE SMART PEDAL IS AN INTEGRAL PART OF THE ENGINE MANAGEMENT SYSTEM (EMS) FUNCTIONALITY WHICH MONITORS AND PREVENTS THE SIMULTANEOUS ACTIVATION OF ACCELERATOR AND BRAKE PEDALS. WHEN ENGAGED, THE FEATURE REDUCES ENGINE POWER TO IDLE. MOST CUSTOMERS WILL NEVER NOTICE THE SMART PEDAL FEATURE WHEN ACTIVE, HOWEVER, CUSTOMERS WHO TEND TO REST THEIR FOOT ON THE BRAKE PEDAL WHILE DRIVING MIGHT DESCRIBE A HESITATION OR DELAY SYMPTOM AND NOT REALIZE THAT THE EMS ELECTRONIC CONTROL MODULE IS INTERVENING, AS DESIGNED.
PS365R1
Service Bulletin/Repair Instructions
PITSTOP: BLUETOOTH® ISSUES AFTER IPHONE® IOS 8 SOFTWARE UPDATE - THIS ARTICLE PROVIDES INFORMATION RELATED TO POSSIBLE BLUETOOTH CONCERNS WHEN USING AN IPHONE® WITH IOS 8.X (IOS 8, 8.0.1, 8.0.2, 8.1, 8.1.2, 8.1.3, ETC.) WHILE PAIRED TO A HEAD UNIT.
TSBBOD108
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: FRONT SEAT HEADREST ELEVATOR MODULE REPLACEMENT (SA177) - THIS BULLETIN PROVIDES THE PROCEDURE TO REPLACE THE HEADREST ELEVATOR MODULE OF SOME K900 (KH) VEHICLES, PRODUCED FROM MARCH 20, 2014 THROUGH SEPTEMBER 19, 2014 AND EQUIPPED WITH MANUALLY ADJUSTABLE HEADRESTS, WHICH MAY EXHIBIT DIFFICULTIES WHEN ADJUSTING THE HEADREST HEIGHT. TO PREVENT AND/OR CORRECT THIS CONDITION, REPLACE THE HEADREST ELEVATOR MODULE WITH A NEW ONE BY FOLLOWING THE SERVICE PROCEDURE OUTLINED BELOW. KIA IS REQUESTING THE COMPLETION OF THIS SERVICE ACTION ON ALL AFFECTED VEHICLES, INCLUDING DEALER STOCK, PRIOR TO DELIVERY.
TSB-ELE071
Service Bulletin/Repair Instructions
TSB: COMBINED TSB/SERVICE ACTION: K900 (KH) NAVIGATION UNIT SOFTWARE UPGRADE (SA 173) - This bulletin provides the procedure for upgrading the navigation system software of some 2015MY K900 (KH) vehicles, produced from January 2, 2014 through October 15, 2014, to resolve concerns related to ?Application Error? messages on the navigation screen and system reboots after the expiration of Sirius XM® trial period.
TSB-TRA054R1
Service Bulletin/Repair Instructions
TSB: COMBINED TSB/SERVICE ACTION: K900 (KH) SHIFT LOGIC IMPROVEMENT - TCM UPGRADE (SA174) - This bulletin provides information related to an upgrade of the TCM software for 2015MY K900 vehicles, produced prior to April 30, 2014, which may exhibit a ?rough shift feeling? concern, particularly when downshifting from third to second gear.
071
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
PS347
Service Bulletin/Repair Instructions
PITSTOP: BATTERY REPLACEMENT ? VENT HOSE MODIFICATION - When replacing a battery for K900 utilizing P/N 37110 H9000U; a slight modification to the vent elbow/hose will be needed in order to properly secure the vent hose assembly to the replacement battery.
054
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
TSB-ELE063
Service Bulletin/Repair Instructions
TSB: VARIANT CODING AFTER HEAD UNIT REPLACEMENT - This bulletin provides the procedure to follow after replacement of the head unit on all K900 (KH) vehicles.
063
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
ELE 063
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
TSB-CLI024
Service Bulletin/Repair Instructions
TSB: TESTING A/C COMPRESSOR FUNCTION USING GDS - This bulletin provides information on a new procedure to test A/C compressor function using the GDS.
TSB-ENG141R1
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: 5.0L (TAU V8) GDI RPM STABILITY IMPROVEMENT - ECM UPGRADE (SA165) - This bulletin provides information related to an inspection of the current ECM ROM ID and, if necessary, an upgrade of the ECM software on some 2015MY K900 vehicles, produced from January 24, 2014 through April 10, 2014, which may not have the latest version ROM ID installed.
PS307
Service Bulletin/Repair Instructions
PIT STOP: PROGRAMMING A THIRD SMART KEY ON CERTAIN 2014-15MY VEHICLES - In past Smart Key systems, the maximum amount of keys that could be programmed to a vehicle was 2. On certain 2014-15MY Kia vehicles, the amount of keys that can be programmed to a vehicle has increased to 3. For information on the current number of keys ?learned? by the system, access SMK > Current Data in GDS, as shown below. To program any additional keys, follow the applicable service procedure on KGIS.
PS299
Service Bulletin/Repair Instructions
PIT STOP: CORRECT PROCEDURE FOR RAISING WINDSHIELD WIPERS - When servicing the windshield wipers on K900 (KH) vehicles during PDI, always use the procedure outlined below to raise the wiper arms to the fully vertical position in order to avoid damaging the paint on the rear edge of the hood.
066
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.