Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB_CLI049_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR – ELECTRICAL A/C COMPRESSOR - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Air Conditioning (A/C) compressor assembly on some 2011MY~ Optima Hybrid (TF HEV, JF HEV/PHEV), 2015MY~ Soul EV (PS EV), 2017MY~ Niro (DE HEV/PHEV/EV), 2022MY~ EV6 (CV), 2021MY~ Sorento (MQ4 HEV/PHEV), 2023MY~ Sportage (NQ5 HEV/PHEV), and 2023MY~ Niro (SG2 EV/HEV/PHEV) vehicles.
TSB_ELE426
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN GEN 5.0 WIDE SOFTWARE UPDATE - This bulletin provides information on the Audio Video Navigation (AVN) system software update for certain vehicles equipped with AVN5W and Navigation System listed in the table below. Affected vehicles may overestimate travel times during route calculation.
TSB_ELE422
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: INFOTAINMENT SYSTEM SOFTWARE UPDATE USING UPDATE.KIA.COM - This bulletin provides information and service procedures for updating the infotainment systems on applicable Kia vehicles using the Kia Navigation Updater available at update.kia.com. The software update may improve system performance, enhance existing features, and apply the latest operating software for supported vehicles (2021-2026MY All Models).
TSB_ELE394
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN5.0W DTC P17A000 DAIGNOSTIC PROCEDURE - This bulletin provides information regarding a potential illuminated Malfunction Indicator Lamp (MIL) accompanied by DTC P17A000 on some 2022-2025MY Hybrid Electric Vehicles (HEV) and Plug-In Hybrid Electric Vehicles (PHEV) equipped with AVN5.0Wide head units listed below. This condition occurs when the Global Positioning System (GPS) module within the Audio Video Navigation (AVN) head unit, sends an inaccurate signal to the Hybrid Power Control Unit (HPCU), causing the DTC to set. There are no drivability symptoms associated with this condition.
SC325_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: AEWP INSPECTION AND REPLACEMENT (SC325) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect and, if necessary, replace the Auxiliary Electric Water Pump (AEWP), control harness wiring, and/or engine room junction box for coolant intrusion and/or corrosion on certain 2022-2023MY Kia Hybrid and Plug-in Hybrid vehicles listed in the table below. The AEWP in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine Light (CEL) may be illuminated with one or more DTCs listed on page 2. If the vehicle continues to be driven in this condition, the Active Air Flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of motive power and may cause the vehicle to release air pollutants which exceeds Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
TSB_GEN099_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: TIRE MOBILITY KIT INSPECTION & REPLACEMENT/ REPAIR (SA556) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect, and if necessary, replace the Tire Mobility Kit (TMK) sealant can or sealant can cap on certain 2023-2024MY Kia vehicles listed on page 5. Lower ambient temperatures can create a vacuum effect inside the TMK sealant can, causing the sealant can cap to open, resulting in the tire sealant leaking.
SC338_OWNR_SG2_102
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION: EXPANSION (SC338 Flight 102) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to update the battery management system (BMS) to prevent overcharging of the 12V Lithium battery in certain 2023 MY Niro Hybrid (HEV) vehicles to ensure compliance with emissions regulations.
TSB_SC338_R1
Emissions
TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: BMS S/W LOGIC IMPROVEMENT FOR DTC P1BB2 (SC338) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to upgrade the Battery Management System ‘BMS’ software logic on certain 2023-2024MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022 to December 15, 2023, and 2023MY Niro HEV (SG2 HEV) vehicles produced from June 21, 2022 through April 25, 2023. Due to a software issue, the Battery Management System (BMS) may inadvertently overcharge the 12V Lithium battery. If the 12V Lithium battery becomes overcharged, the subject vehicles may experience a reduction in motive power accompanied by the ‘Check Hybrid System, Stop Safely’ warning message, Hybrid system warning lamp, Service warning lamp, Charging system warning lamp, and a rapid beeping sound for approximately ten (10) seconds. (Note: This Voluntary Emissions Service Campaign supersedes SC335).
SC338_OWNR_SG2
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC338) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to update the battery management system (BMS) to prevent overcharging of the 12V Lithium battery in certain 2023 MY Niro Hybrid (HEV) vehicles to ensure compliance with emissions regulations.
SC335_TSB_CLSD
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY SERVICE CAMPAIGN: BMS S/W LOGIC IMPROVEMENT FOR DTC P1BB2 (SC335) CLOSED AND SUPERSEDED TO SC338 (TSB) - This bulletin is now closed. "This bulletin provided information to upgrade the Battery Management System ‘BMS’ software logic on certain 2023-2024MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022 to October 28, 2023, and2023-2024MY Niro HEV (SG2 HEV) vehicles produced from June 21, 2022 through February 6, 2023. Due to a software issue, the Battery Management System (BMS) may inadvertently overcharge the 12V Lithium battery.
SC338_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: BMS S/W LOGIC IMPROVEMENT FOR DTC P1BB2 (SC338) - This bulletin provides information to upgrade the Battery Management System ‘BMS’ software logic on certain 2023MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022 to October 28, 2023, and 2023-2024MY Niro HEV (SG2 HEV) vehicles produced from June 21, 2022 through February 6, 2023. Due to a software issue, the Battery Management System (BMS) may inadvertently overcharge the 12V Lithium battery.
SC338_DP
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO (SC338) - This document is the announcement to the dealer principals advising that Kia is conducting a Voluntary Emissions Service Campaign to update the battery management system (BMS) to prevent overcharging of the 12V Lithium battery in certain 2023-2024 MY Sportage Hybrid (HEV) vehicles manufactured from February 15, 2022 through October 28, 2023 and 2023 MY Niro Hybrid (HEV) vehicles manufactured from June 21, 2022 through February 6, 2023. These vehicles have not had SA553 completed yet.
SC338_DPSM
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (SC338) - This document is the announcement to the dealer Parts and Service managers advising that Kia is conducting a Voluntary Emissions Service Campaign to update the battery management system (BMS) to prevent overcharging of the 12V Lithium battery in certain 2023-2024 MY Sportage Hybrid (HEV) vehicles manufactured from February 15, 2022 through October 28, 2023 and 2023 MY Niro Hybrid (HEV) vehicles manufactured from June 21, 2022 through February 6, 2023. These vehicles have not had SA553 completed yet.
SC338_POC
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: SC338_POC: PROOF OF CORRECTION CARD
SC338_QA
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: QUESTION AND ANSWER (SC338) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Emissions Service Campaign SC338.
SC338_STKR
Emissions
SC338_STKR: VOLUNTARY EMISSIONS SERVICE CAMPAIGN COMPLETION LABEL/STICKER
TSB_TRA046_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission.
TSB_ELE378
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: KIA CONNECT MODEM RESET (SA611) - This bulletin outlines the procedure for resetting the modem in certain 2016-2025MY Kia vehicles listed on page 3 that are equipped with Kia Connect Services. The affected vehicles may encounter the following issues: remote Start/Climate Control function not working, vehicle Status on the Kia Access App not updating, connected routing not functioning properly.
SC335_DP
Service Campaign
VOLUNTARY SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO (SC335) - This document is the announcement to the dealer principals advising that Kia is conducting a Voluntary Service Campaign to update the battery management system (BMS) to prevent overcharging of the 12V Lithium battery in certain 2023-2024 MY Sportage Hybrid (HEV) vehicles manufactured from February 15, 2022 through October 28, 2023 and certain 2023-2024 MY Niro Hybrid (HEV) vehicles manufactured from June 21, 2022 through February 6, 2023, that have not had SA553 completed yet. This Voluntary Service Campaign supersedes SA553.
SC335_DPSM
Service Campaign
VOLUNTARY SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (SC335) - This document is the announcement to the dealer Parts and Service managers advising that Kia is conducting a Voluntary Service Campaign to update the battery management system (BMS) to prevent overcharging of the 12V Lithium battery in certain 2023-2024 MY Sportage Hybrid (HEV) vehicles manufactured from February 15, 2022 through October 28, 2023 and certain 2023-2024 MY Niro Hybrid (HEV) vehicles manufactured from June 21, 2022 through February 6, 2023, that have not had SA553 completed yet. This Voluntary Service Campaign supersedes SA553.
SC335_QA
Service Campaign
VOLUNTARY SERVICE CAMPAIGN: QUESTION AND ANSWER (SC335) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Service Campaign SC335.
SC335_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY SERVICE CAMPAIGN: BMS S/W LOGIC IMPROVEMENT FOR DTC P1BB2 (SC335) - This bulletin provides information to upgrade the Battery Management System ‘BMS’ software logic on certain 2023-2024MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022 to October 28, 2023, and 2023-2024MY Niro HEV (SG2 HEV) vehicles produced from June 21, 2022 through February 6, 2023. Due to a software issue, the Battery Management System (BMS) may inadvertently overcharge the 12V Lithium battery. If the 12V Lithium battery becomes overcharged, the subject vehicles may experience a reduction in motive power accompanied by the ‘Check Hybrid System, Stop Safely’ warning message, Hybrid system warning lamp, Service warning lamp, Charging system warning lamp, and a rapid beeping sound for approximately ten (10) seconds. (Note: This Voluntary Service Campaign supersedes ELE318/SA553).
SC325_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY SERVICE CAMPAIGN: AEWP INSPECTION AND REPLACEMENT (SC325) - This bulletin provides information to inspect and, if necessary, replace the Auxiliary Electric Water Pump (AEWP), control harness wiring, and/or engine room junction box for coolant intrusion and/or corrosion on certain 2023MY Niro Hybrid (HEV) and Plug-in Hybrid (PHEV), 2023MY Sportage HEV/PHEV, and 2022-2023MY Sorento HEV/PHEV Kia vehicles listed in this bulletin. The AEWP in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine Light (CEL) may be illuminated with one or more DTCs listed on page 2. If the vehicle continues to be driven in this condition, the Active Air Flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of motive power and may cause the vehicle to release air pollutants which exceeds Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
SC325_OWNR_SG2
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC325) - This document is the owner notification advising that Kia conducting Voluntary Emissions Service Campaign regarding the Auxiliary Electric Water Pump (AEWP) on certain 2023 MY Niro P/HEV vehicles. Kia has become aware that the Auxiliary Electric Water Pump (AEWP) in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine light (CEL) may be illuminated. If the vehicle continues to be driven in this condition, the active air flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of drive power and may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
SC325_POC
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: SC325_POC: PROOF OF CORRECTION CARD
SC325_STKR
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: SC325_STKR: COMPLETION LABEL/STICKER
SC325_DP
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO (SC325) - This document is the announcement to the dealer principals advising that Kia is conducting a Voluntary Emissions Service Campaign regarding the Auxiliary Electric Water Pump (AEWP) on certain 2023 MY Niro P/HEV, 2023 MY Sportage P/HEV, and 2022-2023 MY Sorento P/HEV vehicles. Kia has become aware that the Auxiliary Electric Water Pump (AEWP) in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine light (CEL) may be illuminated. If the vehicle continues to be driven in this condition, the active air flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of drive power and may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
SC325_DPSM
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (SC325) - This document is the announcement to the dealer Parts and Service managers advising that Kia is conducting a Voluntary Emissions Service Campaign regarding the Auxiliary Electric Water Pump (AEWP) on certain 2023 MY Niro P/HEV, 2023 MY Sportage P/HEV, and 2022-2023 MY Sorento P/HEV vehicles. Kia has become aware that the Auxiliary Electric Water Pump (AEWP) in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine light (CEL) may be illuminated. If the vehicle continues to be driven in this condition, the active air flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of drive power and may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
SC325_QA
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: QUESTION AND ANSWER (SC325) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Emissions Service Campaign SC325.
TSB_ELE347_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DISPLAY AUDIO 2.0V/AVN5W SOFTWARE UPDATE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on Display Audio 2.0 (D2V) and AVN 5.0 Wide (AVN5W) head units on certain 2021-2023MY Kia vehicles (refer to pages 5 and 16). The affected vehicles may experience Apple CarPlay®/Android Auto™ phone projection connectivity-related concerns.
TSB_ELE303_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 8) to remedy a ‘non-responsive’ or ‘inoperative’ radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the ‘RADIO’ hard key/button on the AVN unit or when selecting the ‘RADIO’ icon on the AVN menu screen.
PS771
Service Bulletin/Repair Instructions
PITSTOP: TECHNICAL OPERATION: ACTIVE AIRFLAP SYSTEM INSPECTION/CLEANING - This Pitstop provides information regarding the Active Air Flap (AAF) system on some 2023-2025MY Niro PHEV/HEV (SG2 P/HEV) vehicles which may exhibit a “Check Active Air Flap System” message in the instrument cluster and possible MIL ‘ON’ with one or more of the DTCs described below.
TSB_GEN099_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: TIRE MOBILITY KIT INSPECTION & REPLACEMENT/REPAIR (SA556) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect, and if necessary, replace the Tire Mobility Kit (TMK) sealant can or sealant can cap on certain 2023-2024MY Kia vehicles listed on page 7. Lower ambient temperatures can create a vacuum effect inside the TMK sealant can, causing the sealant can cap to open, resulting in the tire sealant leaking.
SC305_OWNR
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC305) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign on certain 2023 MY Niro Hybrid (HEV) vehicles manufactured from June 21, 2022 through March 20, 2023 and certain 2023 Niro Plug-in Hybrid (PHEV) vehicles manufactured from July 11, 2022 through March 17, 2023 to replace the EGR control valve pipe and hose with a new one.
SC305_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: EGR CONTROL VALVE PIPE AND HOSE REPLACEMENT (SC305) - This bulletin provides information to replace the Exhaust Gas Recirculation (EGR) control valve pipe and hose on certain 2023MY Niro HEV (SG2 HEV) vehicles produced from June 21, 2022 through March 20, 2023 and 2023MY Niro PHEV (SG2 PHEV) vehicles produced from July 11, 2022 through March 17, 2023. The subject vehicles may experience illumination of the Check Engine Light (CEL) due to excessive intake manifold pressure fluctuation. This condition may cause the vehicle to release air pollutants that exceeds Federal and California standards.
SC305_DP
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO (SC305) - This document is the announcement to the dealer principals advising that Kia is conducting a Voluntary Emissions Service Campaign on certain 2023 MY Niro Hybrid (HEV) vehicles manufactured from June 21, 2022 through March 20, 2023 and certain 2023 Niro Plug-in Hybrid (PHEV) vehicles manufactured from July 11, 2022 through March 17, 2023 to replace the EGR control valve pipe and hose with a new one.
SC305_DPSM
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (SC305) - This document is the announcement to the dealer Parts and Service Managers advising that Kia is conducting a Voluntary Emissions Service Campaign on certain 2023 MY Niro Hybrid (HEV) vehicles manufactured from June 21, 2022 through March 20, 2023 and certain 2023 Niro Plug-in Hybrid (PHEV) vehicles manufactured from July 11, 2022 through March 17, 2023 to replace the EGR control valve pipe and hose with a new one.
SC305_POC
Emissions
SC305_POC: PROOF OF CORRECTION CARD
SC305_QA
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: QUESTIONS AND ANSWER (SC305) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Emissions Service Campaign SC305.
SC305_STKR
Emissions
SC305_STKR: VOLUNTARY EMISSIONS SERVICE CAMPAIGN COMPLETION LABEL/STICKER
TSB_ELE347
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DISPLAY AUDIO 2.0V/AVN5W SOFTWARE UPDATE - This bulletin provides information to update the software on Display Audio 2.0 (D2V) and 5th Generation AVN Wide (AVN5W) head units on certain 2021-2023MY Kia vehicles. The affected vehicles may experience Apple CarPlay®/Android Auto™ phone projection connectivity-related concerns.
TSB_TRA046_R4
Service Bulletin/Repair Instructions
This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.
TSB_ELE303_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
TSB_ELE318
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: BMS SOFTWARE LOGIC IMPROVEMENT FOR DTC P1BB2 (SA553) - This bulletin provides information to upgrade the Battery Management System (BMS) software logic on certain 2023-2024MY Niro HEV (SG2 HEV) vehicles produced from June 21, 2022 through February 6, 2023, and 2023-2024MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022 to October 28, 2023, which may exhibit a âÂÂCheck Hybrid Systemâ message displayed on the instrument cluster with DTC P1BB2 stored. This condition may occur when the vehicle is exposed to high heat/hot weather environments.
TSB_ELE303_R1
Service Bulletin/Repair Instructions
This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
TSB_ELE300
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: MOOD LAMP OPERATION LOGIC IMPROVEMENT (SA536) - This bulletin provides the procedure to upgrade the software logic of the interior Mood Lamp Module (MLM) system on some 2023MY Niro EV, P/HEV (SG2 P/HEV, EV) vehicles produced from April 14, 2023 through May 15, 2023 and 2023MY EV6 (CV) vehicles produced from April 18, 2023 through May 13, 2023, which may exhibit an inoperative mood lamp.
TSB_CLI049_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR - ELECTRICAL A/C COMPRESSOR - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding partial repair of the Air Conditioning (A/C) compressor assembly on some 2011MY~ Optima Hybrid (TF HEV, JF HEV/PHEV), 2015MY~ Soul EV (PS EV), 2017MY~ Niro (DE HEV/PHEV/EV), 2022MY~ EV6 (CV), 2021MY~ Sorento (MQ4 HEV/PHEV), 2023MY~ Sportage (NQ5 HEV/PHEV), and 2023MY~ Niro (SG2 EV/HEV/PHEV) vehicles.
TSB_BOD316
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: ICU FUSE LABEL REPLACEMENT (SA530) - This bulletin provides information to replace the Integrated Central Control Unit (ICU) fuse label on some 2023MY Niro PHEV, EV (SG2 PHEV, EV) vehicles produced from July 11, 2022 through February 3, 2023. The incorrect ICU fuse label on the affected vehicles was installed.
TSB_ENG239_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC23) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate collection of this data at the dealer level, KDS screenshots will allow the capture of relevant parameters.
TSB_TRA106
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: 6-SPEED DCT JUDGEMENT LOGIC IMPROVEMENT / GROUND BOLT TIGHTENING (P074A73) - This bulletin provides information to tighten both the clutch actuator and transmission control unit (TCU) grounding bolts then, upgrade the software logic of the 6-speed dual clutch transmission (DCT) on some 2023MY Niro P/HEV vehicles produced from June 14, 2022 through December 12, 2022, which may exhibit a poor shift quality concern and MIL "ON" with DTC P074A73 stored.
TSB_ELE272_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: CLUSTER LOGIC IMPROVEMENT FOR ADAS ALERT VOLUME CHANGE (SA517) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to update the software logic of the Cluster (CLU) system on some 2023MY vehicles to allow the Advanced Driver Assistance System (ADAS) default alert volume to be changed. Kia is requesting the completion of this Service Action on all affected vehicles in dealer stock, prior to delivery.
TSB_TRA046_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.