Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB_CLI049_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR – ELECTRICAL A/C COMPRESSOR - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Air Conditioning (A/C) compressor assembly on some 2011MY~ Optima Hybrid (TF HEV, JF HEV/PHEV), 2015MY~ Soul EV (PS EV), 2017MY~ Niro (DE HEV/PHEV/EV), 2022MY~ EV6 (CV), 2021MY~ Sorento (MQ4 HEV/PHEV), 2023MY~ Sportage (NQ5 HEV/PHEV), and 2023MY~ Niro (SG2 EV/HEV/PHEV) vehicles.
TSB_BOD336
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: KEY AND CYLINDER SET REPLACEMENT - This bulletin provides information to replace the driver’s door lock and trunk lid key cylinders on some 2019-2024MY Kia vehicles listed below. On affected vehicles, the stored key code may not correspond to the mechanical key profile, which can result in incorrect key cutting when the original key is lost or damaged.
WTY043_TSB
Warranty Program/Extension
TECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN: REAR RH DOOR CURTAIN INSPECTION / REPLACEMENT (WTY043) - This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY043) inspect and, if necessary replace the rear RH door curtain on certain 2023 - 2026MY Sorento Hybrid (MQ4 HEV) SX Prestige vehicles produced from June 27, 2022 through December 05, 2025 and certain 2023 – 2026MY Sorento Plug-In Hybrid (MQ4 PHEV) SX-Prestige vehicles produced from June 27, 2022 through November 22, 2025. The affected vehicle’s rear RH door curtain may not return to the fully retracted position. Under this program, the New Vehicle Warranty coverage for this condition is extended from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
TSB_ELE422
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: INFOTAINMENT SYSTEM SOFTWARE UPDATE USING UPDATE.KIA.COM - This bulletin provides information and service procedures for updating the infotainment systems on applicable Kia vehicles using the Kia Navigation Updater available at update.kia.com. The software update may improve system performance, enhance existing features, and apply the latest operating software for supported vehicles (2021-2026MY All Models).
WTY043_OWNR
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: OWNER NOTIFICATION (WTY043) - This document is the owner notification advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for certain repairs related to the rear right-hand (RH) door curtain in certain 2023-2026 MY Sorento Hybrid (HEV) SX-Prestige and Sorento Plug-in Hybrid (PHEV) SX-Prestige vehicles from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY043_REIMB
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: REIMBURSEMENT FORM (WTY043) - This document is a Reimbursement Request form that was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extension campaign program launch.
WTY043_DP
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: DEALER PRINCIPAL MEMO (WTY043) - This document is the announcement to the dealer principals advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for certain repairs related to the rear right-hand (RH) door curtain in certain 2023-2026 MY Sorento Hybrid (HEV) SX-Prestige vehicles manufactured from June 27, 2022 through December 5, 2025 and certain 2023-2026 MY Sorento Plug-in Hybrid (PHEV) SX-Prestige vehicles, manufactured from June 27, 2022 through November 22, 2025.
WTY043_DPSM
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (WTY043) - This document is the announcement to the dealer Parts and Service managers advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for certain repairs related to the rear right-hand (RH) door curtain in certain 2023-2026 MY Sorento Hybrid (HEV) SX-Prestige vehicles manufactured from June 27, 2022 through December 5, 2025 and certain 2023-2026 MY Sorento Plug-in Hybrid (PHEV) SX-Prestige vehicles, manufactured from June 27, 2022 through November 22, 2025.
WTY043_QA
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: QUESTION AND ANSWER (WTY043) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Warranty Extension Campaign WTY043.
TSB_ELE417
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: INFOTAINMENT SOFTWARE UPDATE PROCEDURE - This bulletin provides information on the process for downloading infotainment software updates and preparing USB for installation on applicable Kia vehicles. The software downloads and USB preparation process is similar across all supported platforms; however, in‑vehicle installation procedures vary by head unit type.
TSB_ELE394
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN5.0W DTC P17A000 DAIGNOSTIC PROCEDURE - This bulletin provides information regarding a potential illuminated Malfunction Indicator Lamp (MIL) accompanied by DTC P17A000 on some 2022-2025MY Hybrid Electric Vehicles (HEV) and Plug-In Hybrid Electric Vehicles (PHEV) equipped with AVN5.0Wide head units listed below. This condition occurs when the Global Positioning System (GPS) module within the Audio Video Navigation (AVN) head unit, sends an inaccurate signal to the Hybrid Power Control Unit (HPCU), causing the DTC to set. There are no drivability symptoms associated with this condition.
WTY042_OWNR
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: OWNER NOTIFICATION (WTY042) - This document is the owner notification advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for repairs related to the horn assembly in certain 2021-2025 MY Sorento, 2021-2025 MY Sorento Hybrid (HEV), and 2022-2025 MY Sorento Plug-in Hybrid (PHEV) vehicles from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address a horn sound malfunction condition free of charge at no cost to the customer.
WTY042_DP
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: DEALER PRINCIPAL MEMO (WTY042) - This document is the announcement to the dealer principals advising that Kia is is extending the New Vehicle Limited Warranty coverage, to all owners, for repairs related to the horn assembly for eligible vehicles, from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, from the date the vehicle was first put into service. This warranty extension is to address a horn sound malfunction condition on 2021-2025 MY Sorento vehicles manufactured from September 10, 2020, through June 3, 2025, 2021-2025 MY Sorento Hybrid (HEV) vehicles manufactured from September 2, 2020, through January 24, 2025, and 2022-2025 MY Sorento Plug-In Hybrid (PHEV) vehicles manufactured from June 29, 2021, through January 20, 2025.
WTY042_DPSM
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: DEALER PARTS & SERVICE MANAGER MEMO (WTY042) - This document is the announcement to the dealer Parts and Service managers advising that Kia is is extending the New Vehicle Limited Warranty coverage, to all owners, for repairs related to the horn assembly for eligible vehicles, from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, from the date the vehicle was first put into service. This warranty extension is to address a horn sound malfunction condition on 2021-2025 MY Sorento vehicles manufactured from September 10, 2020, through June 3, 2025, 2021-2025 MY Sorento Hybrid (HEV) vehicles manufactured from September 2, 2020, through January 24, 2025, and 2022-2025 MY Sorento Plug-In Hybrid (PHEV) vehicles manufactured from June 29, 2021, through January 20, 2025.
WTY042_QA
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: QUESTION AND ANSWER (WTY042) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Warranty Extension Campaign WTY042.
WTY042_REIMB
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: REIMBURSEMENT FORM (WTY042) - This document is a Reimbursement Request form that was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extension campaign program launch.
WTY042_TSB
Service Bulletin/Repair Instructions
WARRANTY EXTENSION CAMPAIGN: TECHNICAL SERVICE BULLETIN: HORN ASSEMBLY INSPECTION AND REPLACEMENT (WTY042) - This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY042) to inspect and, if necessary, replace the horn assembly on certain vehicles listed in the table below. The affected vehicles may experience an unusual or different horn sound than normal, or an inoperative horn, caused by corrosion inside the electric horn and/or carbonization of the contact point. The warranty coverage for repairs related to the horn assembly has been extended from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
SC325_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: AEWP INSPECTION AND REPLACEMENT (SC325) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect and, if necessary, replace the Auxiliary Electric Water Pump (AEWP), control harness wiring, and/or engine room junction box for coolant intrusion and/or corrosion on certain 2022-2023MY Kia Hybrid and Plug-in Hybrid vehicles listed in the table below. The AEWP in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine Light (CEL) may be illuminated with one or more DTCs listed on page 2. If the vehicle continues to be driven in this condition, the Active Air Flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of motive power and may cause the vehicle to release air pollutants which exceeds Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
PS797
Other
PITSTOP: TECHNICAL OPERATIONS: EXTERNAL DAMAGE TO ULTRASONIC SENSOR: This Pitstop provides information related to Parking Distance Warning (PDW) alerts and repairs involving ultrasonic sensors. The PDW system alerts the driver while parking, by calculating distance based on the difference in signal transmission and reception times between the vehicle (ultrasonic sensor) and an object. The membrane film of the ultrasonic sensor is used for object detention and can be damaged by stone chips or foreign substances while driving. Damage to the cover of the ultrasonic sensor can also lead to damage to the internal circuit. As a result of this external damage, the PDW system may not receive the proper signal from the ultrasonic sensor. In some cases, the system may cause a false alarm, no alert, or phantom warnings by a “Warning Lamp’ to be displayed on the cluster. The ultrasonic sensor membrane film should be always inspected for external damage and if any part replacement should be treated as a general repair, not as a warranty claim repair for this concern. (Please note that this Pitstop only applies to models/trims that are equipped with the ultrasonic sensors.)
TSB_TRA112
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSAXLE ASSEMBLY REPLACEMENT & HCU LOGIC IMPROVEMENT - This bulletin provides information to replace the transaxle assembly and upgrade the Hybrid Control Unit Low-Voltage DC Converter (HCULDC) software on some 2022-2024MY Sorento Plug-In Hybrid (MQ4 PHEV) vehicles equipped with a 1.6L T-GDI engine and All-Wheel Drive (AWD), produced from June 29, 2021 through January 10, 2024. Some vehicles may experience an illuminated Malfunction Indicator Lamp (MIL) with DTC P0C4E00 stored, accompanied by a rough transition when the vehicle switches between EV and HEV motive power.
TSB_TRA046_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission.
TSB_ELE378
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: KIA CONNECT MODEM RESET (SA611) - This bulletin outlines the procedure for resetting the modem in certain 2016-2025MY Kia vehicles listed on page 3 that are equipped with Kia Connect Services. The affected vehicles may encounter the following issues: remote Start/Climate Control function not working, vehicle Status on the Kia Access App not updating, connected routing not functioning properly.
SC325_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY SERVICE CAMPAIGN: AEWP INSPECTION AND REPLACEMENT (SC325) - This bulletin provides information to inspect and, if necessary, replace the Auxiliary Electric Water Pump (AEWP), control harness wiring, and/or engine room junction box for coolant intrusion and/or corrosion on certain 2023MY Niro Hybrid (HEV) and Plug-in Hybrid (PHEV), 2023MY Sportage HEV/PHEV, and 2022-2023MY Sorento HEV/PHEV Kia vehicles listed in this bulletin. The AEWP in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine Light (CEL) may be illuminated with one or more DTCs listed on page 2. If the vehicle continues to be driven in this condition, the Active Air Flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of motive power and may cause the vehicle to release air pollutants which exceeds Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
SC325_OWNR_MQ4
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC325) - This document is the owner notification advising that Kia conducting Voluntary Emissions Service Campaign regarding the Auxiliary Electric Water Pump (AEWP) on certain 2022-2023 MY Sorento P/HEV vehicles. Kia has become aware that the Auxiliary Electric Water Pump (AEWP) in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine light (CEL) may be illuminated. If the vehicle continues to be driven in this condition, the active air flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of drive power and may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
SC325_POC
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: SC325_POC: PROOF OF CORRECTION CARD
SC325_STKR
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: SC325_STKR: COMPLETION LABEL/STICKER
SC325_DP
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO (SC325) - This document is the announcement to the dealer principals advising that Kia is conducting a Voluntary Emissions Service Campaign regarding the Auxiliary Electric Water Pump (AEWP) on certain 2023 MY Niro P/HEV, 2023 MY Sportage P/HEV, and 2022-2023 MY Sorento P/HEV vehicles. Kia has become aware that the Auxiliary Electric Water Pump (AEWP) in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine light (CEL) may be illuminated. If the vehicle continues to be driven in this condition, the active air flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of drive power and may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
SC325_DPSM
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (SC325) - This document is the announcement to the dealer Parts and Service managers advising that Kia is conducting a Voluntary Emissions Service Campaign regarding the Auxiliary Electric Water Pump (AEWP) on certain 2023 MY Niro P/HEV, 2023 MY Sportage P/HEV, and 2022-2023 MY Sorento P/HEV vehicles. Kia has become aware that the Auxiliary Electric Water Pump (AEWP) in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine light (CEL) may be illuminated. If the vehicle continues to be driven in this condition, the active air flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of drive power and may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
SC325_QA
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: QUESTION AND ANSWER (SC325) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Emissions Service Campaign SC325.
TSB_ELE352_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) (SA582) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2023-2024MYKia vehicles (refer to model list on page 8) to remedy a ‘non-responsive’ or ‘inoperative’ radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the ‘RADIO’ hard key/button on the AVN unit or when selecting the ‘RADIO’ icon on the AVN menu screen.
TSB_ELE303_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 8) to remedy a ‘non-responsive’ or ‘inoperative’ radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the ‘RADIO’ hard key/button on the AVN unit or when selecting the ‘RADIO’ icon on the AVN menu screen.
TSB_ELE352_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) (SA582) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2023-2024MYKia vehicles (refer to model list on page 8) to remedy a ‘non-responsive’ or ‘inoperative’ radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the ‘RADIO’ hard key/button on the AVN unit or when selecting the ‘RADIO’ icon on the AVN menu screen.
TSB_ELE352
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) (SA582) - This bulletin provides information to update the software on 5th Generation AVN wide on certain 2023-2024MY Kia vehicles (refer to model list on page 3) to remedy a ‘non-responsive’ or ‘inoperative’ radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the ‘RADIO’ hard key/button on the AVN unit or when selecting the ‘RADIO’ icon on the AVN menu screen. Also, a warning sound accompanied by a ‘Slippery road ahead. Drive carefully’ or ‘Uneven road ahead. Drive carefully’ warning can be displayed on the instrument cluster. The current AVN software causes the warning sound and message to repeat approximately every ten (10) seconds, if the vehicle is not in motion, in ‘PARK’ or driving on even surfaces.
TSB_ELE343
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: ICU LOGIC UPGRADE FOR OIL CHANGE REMINDER DISPLAY (SA573) - This bulletin provides information to improve the Integrated Central Control Unit (ICU) operation logic on certain 2023MY Sorento PHEV (MQ4 PHEV) vehicles produced from June 27, 2022 through August 16, 2023. The affected vehicles may be unable to reset the ‘Oil Change Reminder’ notice on the instrument cluster. The updated software will allow access to reset the ‘Oil Change Reminder’ notice on the instrument cluster via the AVN menu.
TSB_TRA046_R4
Service Bulletin/Repair Instructions
This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.
TSB_TRA108_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: 4WD COUPLING ACTUATOR ASSEMBLY REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to replace the AWD coupling actuator assembly on some 2021-2024MY Kia AWD models listed on page 4. The affected vehicles may exhibit an inoperative AWD system (also referred to as 4WD) capability concern which may be caused by abnormal wear of the motor brushes inside the actuator assembly. This condition will cause the warning lamps on the instrument cluster to illuminate with stored DTC(s) P195800 and/or P19600.
TSB_ELE303_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
TSB_ELE320
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE SCREEN FREEZING OR MAP DELAY WITH WIRED APPLE CARPLAY - This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles to remedy an inaccurate map location, freezing AVN screen, or experiencing a delay when using Google Maps or Waze through wired Apple CarPlay.
TSB_ELE314
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: UNEVEN/SLIPPERY ROAD WARNING DISPLAYED ON INSTRUMENT CLUSTER - This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles (refer to model list on page 3) to remedy a warning sound accompanied by a 'Slippery road ahead. Drive carefully' or 'Uneven road ahead. Drive carefully' warning which is displayed on the instrument cluster. The current AVN software causes the warning sound and message to repeat approximately every ten (10) seconds, if the vehicle is not in motion, in 'PARK' or driving on even surfaces.
TSB_TRA108
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: 4WD COUPLING ACTUATOR ASSEMBLY REPLACEMENT - This bulletin provides information to replace the AWD coupling actuator assembly on some 2021-2023MY Kia AWD models listed on page 4. The affected vehicles may exhibit an inoperative AWD system (also referred to as 4WD) capability concern which may be caused by abnormal wear of the motor brushes inside the actuator assembly. This condition will cause the warning lamps on the instrument cluster to illuminate with stored DTC(s) P195800 and/or P19600.
TSB_ELE303
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen. Follow the procedure outlined in this publication to update the software on 5th Generation AVN wide units using the applicable USB Flash Drive A or B for the applicable vehicle.
TSB_CLI049_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR - ELECTRICAL A/C COMPRESSOR - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding partial repair of the Air Conditioning (A/C) compressor assembly on some 2011MY~ Optima Hybrid (TF HEV, JF HEV/PHEV), 2015MY~ Soul EV (PS EV), 2017MY~ Niro (DE HEV/PHEV/EV), 2022MY~ EV6 (CV), 2021MY~ Sorento (MQ4 HEV/PHEV), 2023MY~ Sportage (NQ5 HEV/PHEV), and 2023MY~ Niro (SG2 EV/HEV/PHEV) vehicles.
TSB_ENG239_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC23) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate collection of this data at the dealer level, KDS screenshots will allow the capture of relevant parameters.
TSB_ELE285
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MQ4 P/HEV GAMMA 1.6L T-GDI ECM & HCULDC LOGIC IMPROVEMENT FOR OIL DILUTION: This bulletin provides the procedure to update the software logic of the 'Engine' and Hybrid Control Unit Low DC-DC Converter 'HCULDC' systems on certain 2021-2023MY Sorento HEV, PHEV (MQ4 P/HEV) w/ Gamma 1.6L T-GDI vehicles produced from July 1, 2021 through November 3, 2022. The affected vehicles may exhibit a MIL 'ON' with DTCs stored (P144100, P1A7795, P00B700, P211800, P040100, P023600, P029900, P2B6000) due to the engine oil becoming diluted with fuel and/or moisture caused by repeated short drive trips, in low outdoor temperature (32 degree F-) environments.
TSB_ELE272_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: CLUSTER LOGIC IMPROVEMENT FOR ADAS ALERT VOLUME CHANGE (SA517) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to update the software logic of the Cluster (CLU) system on some 2023MY vehicles to allow the Advanced Driver Assistance System (ADAS) default alert volume to be changed. Kia is requesting the completion of this Service Action on all affected vehicles in dealer stock, prior to delivery.
TSB_ELE272
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: CLUSTER LOGIC IMPROVEMENT FOR ADAS ALERT VOLUME CHANGE (SA517) - This bulletin provides the procedure to update the software logic of the Cluster (CLU) system on some 2023MY vehicles to allow the Advanced Driver Assistance System (ADAS) default alert volume to be changed. Kia is requesting the completion of this Service Action on all affected vehicles in dealer stock, prior to delivery.
TSB_TRA046_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.
TSB_ELE209_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin provides the procedure to turn OFF the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster. The KDS is required to change the setting from "Workshop" to "Customer Mode."
PS672_R1
Service Bulletin/Repair Instructions
PITSTOP: REAR OCCUPANT ALERT (ROA) W/REAR DOOR LOGIC - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop provides information regarding the Rear Occupant Alert (ROA) with Rear Door Logic system on all 21MY~ models equipped with this feature. This system is designed to help prevent a rear passenger from being left inside the vehicle when exiting. The "Check Rear Seats" message will display on the cluster when driver opens the front door, if during vehicle operation the rear doors (one or both) were opened and closed.
TSB_ENG239
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC23) - This bulletin provides information related to extracting in use performance tracking emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate collection of this data at the dealer level, KDS screenshots will allow the capture of relevant parameters.