Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB_ENG263
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MISFIRE CONCERN DUE TO OVERRUNNING ALTERNATOR DECOUPLER - This bulletin provides information to address unresolved misfire events on some 2020–2024MY Forte (BDm) produced from January 1, 2019 through September 30, 2024, and 2020–2022MY Soul (SK3) vehicles produced from November 1, 2018 through May 31, 2022 equipped with a Gamma 1.6L T‑GDI engine. In certain cases, misfire symptoms may persist after completing normal diagnostic procedures and replacing ignition‑related components (spark plugs, ignition coils, and fuel injectors). If misfire concerns remain after these repairs are performed, excessive torsional oscillation of the Overrunning Alternator Decoupler (OAD) pulley may be the contributing factor. This bulletin provides the procedure to replace the OAD pulley with the updated Overrunning Alternator Pulley (OAP) kit and associated damper components.
CS2311_TSB_R4
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION: CYLINDER PROTECTOR & DECAL INSTALLATION (CS2311) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 20, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) are not able to receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles that are not equipped with an immobilizer, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
CS2312_TSB_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR AND DECAL INSTALLATION (CS2312) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 20, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) did receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
TSB_BOD336
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: KEY AND CYLINDER SET REPLACEMENT - This bulletin provides information to replace the driver’s door lock and trunk lid key cylinders on some 2019-2024MY Kia vehicles listed below. On affected vehicles, the stored key code may not correspond to the mechanical key profile, which can result in incorrect key cutting when the original key is lost or damaged.
SC199_OWNR_SK3_3
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER RENOTIFICATION (SC199 FL301) - This document is the owner renotification advising that Kia is conducting Voluntary Service Campaign to update the software programming on the Transmission Control Module (TCM) and, if necessary, replace the Intelligent Variable Transmission (IVT) on certain 2020-2021 MY Soul vehicles.
TSB_CS2312_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR AND DECAL INSTALLATION (CS2312) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 20, which may not have been equipped with an immobilizer and whole Integrated Body control Unit (IBU) / Body Control Module (BCM) did receive the Ant-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
CS2311_OWNR_PC201
Other
CUSTOMER SATISFACTION CAMPAIGN: POSTCARD OWNER RENOTIFICATION (CS2311) - This document is the owner renotification advising that Kia is conducting Customer Satisfaction Campaign. Kia has developed a new zinc-reinforced ignition cylinder protector hardware upgrade and can be installed at the ignition cylinder location to provide additional protection against the social media theft method. Prior notifications stated that this modification had to be performed by July 1, 2025, but the subject vehicles are now eligible until March 31, 2027, to have the ignition cylinder protector installed—if requested—at no cost through an authorized Kia dealership. (Mailing of these notifications to vehicle owners will be completed from December 19, 2025 through December 31, 2025)
TSB_CS2312
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR AND DECAL INSTALLATION (CS2312) - This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 19, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) did receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
CS2312_OWNR
Other
CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION (CS2312) - This document is the owner notification advising that Kia is conducting Customer Satisfaction Campaign. A software upgrade that addresses the social media theft method has been made available to owners of eligible Kia model vehicles free of charge at authorized Kia dealers since 2023. In addition to the anti-theft software, a new zinc-reinforced ignition cylinder protector hardware upgrade has been developed and can be installed at the ignition cylinder location to provide additional protection against the social media theft method. Because the subject Kia vehicles were not factory-equipped with an engine immobilizer and were previously eligible for the software upgrade, these vehicles are eligible until March 31, 2027, to have the ignition cylinder protector installed—if requested—at no cost through an authorized Kia dealership. (Mailing of these notifications to vehicle owners will be completed from December 17, 2025 through February 27, 2026)
PS797
Other
PITSTOP: TECHNICAL OPERATIONS: EXTERNAL DAMAGE TO ULTRASONIC SENSOR: This Pitstop provides information related to Parking Distance Warning (PDW) alerts and repairs involving ultrasonic sensors. The PDW system alerts the driver while parking, by calculating distance based on the difference in signal transmission and reception times between the vehicle (ultrasonic sensor) and an object. The membrane film of the ultrasonic sensor is used for object detention and can be damaged by stone chips or foreign substances while driving. Damage to the cover of the ultrasonic sensor can also lead to damage to the internal circuit. As a result of this external damage, the PDW system may not receive the proper signal from the ultrasonic sensor. In some cases, the system may cause a false alarm, no alert, or phantom warnings by a “Warning Lamp’ to be displayed on the cluster. The ultrasonic sensor membrane film should be always inspected for external damage and if any part replacement should be treated as a general repair, not as a warranty claim repair for this concern. (Please note that this Pitstop only applies to models/trims that are equipped with the ultrasonic sensors.)
WTY041_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: HORN ASSEMBLY INSPECTION/REPLACEMENT (WTY041) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY041) to inspect and, if necessary, replace the horn assembly on certain 2020-2025MY Soul (SK3) vehicles produced from November 15, 2018 through August 13, 2024, The affected vehicles may experience a distorted or an inoperative horn sound caused by to corrosion and dust inside the horn assembly. The warranty coverage for repairs related to the horn assembly have been extended from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
SST082_R1
Service Bulletin/Repair Instructions
This bulletin provides instructions to perform an engine vibration inspection using the Kia Diagnostic System (KDS) tablet on certain Kia engine/model vehicles. The piston oil ring(s) in certain Kia engines may, over time, damage the surface of the engine cylinder wall. This may lead to increased oil consumption which will eventually result in abnormal noise from the engine and/or illumination of the oil pressure warning light. The applicable vehicle may or may not have the Piston Noise Sensing System (PNSS) software installed at the time of an engine vibration inspection. The PNSS software may detect engine noise triggering a DTC P132700.
TSB_TRA046_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission.
TSB_SST082
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PISTON NOISE SENSING SYSTEM (PNSS) INSPECTION - This bulletin provides instructions to perform an engine vibration inspection using the Kia Diagnostic System (KDS) tablet on certain 2020 - 2023 MY Kia Soul (SK3) 2021 - 2023 MY Seltos (SP2) Kia vehicles equipped with 2.0L Nu MPI Engines. The piston oil ring(s) in certain Kia engines may, over time, damage the surface of the engine cylinder wall. This may lead to increased oil consumption which will eventually result in abnormal noise from the engine and/or illumination of the oil pressure warning light. The applicable vehicle may or may not have the Piston Noise Sensing System (PNSS) software installed at the time of an engine vibration inspection. The PNSS software may detect engine noise triggering a DTC P132700.
TSB_ENG222_R8
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2024MY vehicles (refer to the table on pages 9 and 10 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
TSB_ELE378
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: KIA CONNECT MODEM RESET (SA611) - This bulletin outlines the procedure for resetting the modem in certain 2016-2025MY Kia vehicles listed on page 3 that are equipped with Kia Connect Services. The affected vehicles may encounter the following issues: remote Start/Climate Control function not working, vehicle Status on the Kia Access App not updating, connected routing not functioning properly.
WTY041_OWNR
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: OWNER NOTIFICATION (WTY041) - This document is the owner notification advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for repairs related to the horn assembly in certain 2020-2025 MY Soul vehicles from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address a horn sound malfunction condition.
WTY041_Reimb
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: REIMBURSEMENT FORM (WTY041) - This document is a Reimbursement Request form that was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extension campaign program launch.
WTY041_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN: HORN ASSEMBLY INSPECTION/REPLACEMENT (WTY041) - This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY041) to inspect and, if necessary, replace the horn assembly on certain 2020-2025MY Soul (SK3) vehicles produced from November 15, 2018 through August 13, 2024, The affected vehicles may experience a distorted or an inoperative horn sound caused by to corrosion and dust inside the horn assembly. The warranty coverage for repairs related to the horn assembly have been extended from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY041_DP
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: DEALER PRINCIPAL MEMO (WTY041) - This document is the announcement to the dealer principals advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for repairs related to the horn assembly in certain 2020-2025 MY Soul vehicles, manufactured from November 15, 2018 through August 13, 2024, from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address a horn sound malfunction condition.
WTY041_DPSM
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (WTY041) - This document is the announcement to the dealer principals advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for repairs related to the horn assembly in certain 2020-2025 MY Soul vehicles, manufactured from November 15, 2018 through August 13, 2024, from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address a horn sound malfunction condition.
WTY041_QA
Warranty Program/Extension
WARRANTY EXTENSION CAMPAIGN: QUESTION AND ANSWER (WTY041) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Warranty Extension Campaign WTY041.
TSB_ENG222_R7
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2024MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
TSB_ELE361
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE DEALER MODE FACTORY RESET - This bulletin provides the procedure to perform the ‘Dealer Mode Factory Reset’ on multiple 2020-2021MY vehicles (listed on page 5) equipped with AVN 5.0 Wide head units. The affected vehicles may exhibit inoperable and/or interrupted Kia Connect services due to a logic error with the current software version. This logic error may affect the Kia Connect services: calendar, weather, sports, vehicle diagnostics, maintenance and/or Kia Connect services rendering these features inoperable.
TSB_ELE303_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 8) to remedy a ‘non-responsive’ or ‘inoperative’ radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the ‘RADIO’ hard key/button on the AVN unit or when selecting the ‘RADIO’ icon on the AVN menu screen.
CS2311_TSB_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR & DECAL INSTALLATION (CS2311) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 15, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) are not able to receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles that are not equipped with an immobilizer, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
TSB_CHA121_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: FRONT STRUT BEARING & SPRING PAD REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to replace the front strut bearing and upper spring pad on both front (LH and RH) strut assemblies on certain 2019-2024MY Forte (BDm) vehicles produced from July 09, 2018 through present, 2020-2024MY Soul (SK3) vehicles produced from November 15, 2018 through present, and 2021-2024 Seltos (SP2) vehicles produced from November 20, 2019 through present. The affected vehicles may exhibit an intermittent noise when turning the steering wheel both when driving and when the vehicle is not in motion.
TSB_CHA121_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: FRONT STRUT BEARING & SPRING PAD REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to replace the front strut bearing and upper spring pad on both front (LH and RH) strut assemblies on certain 2019-2024MY Forte (BDm) vehicles produced from July 09, 2018 through present, 2020-2024MY Soul (SK3) vehicles produced from November 15, 2018 through present, and 2021-2024 Seltos (SP2) vehicles produced from November 20, 2019 through present. The affected vehicles may exhibit an intermittent noise when turning the steering wheel both when driving and when the vehicle is not in motion.
TSB_TRA109
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: IVT OIL PRESSURE SENSOR REPLACEMENT: This bulletin provides information to replace the Intelligent Variable Transmission (IVT) Oil Pressure Sensor (OPS) on some 2018-2024MY vehicles listed on page 3 equipped with IVT. The affected vehicles may exhibit a malfunction indicator lamp (MIL) illuminated on the instrument cluster with DTCs P084500, P084600, and/or P0867XX present with no drivability concerns due to a failed IVT oil pressure sensor.
SC209Y_TSB_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SUBSEQUENT REPAIR ACTION: ENGINE REPLACEMENT INSTRUCTIONS FOR PISTON RING NOISE DTC 1327 (SC209Y) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published in (SC209A) titled “ECM Logic Improvement for Piston Ring Noise Sensing System”. If DTC P1327 is present after the ECM Logic Improvement is performed per SC209A, follow the instructions in this bulletin to replace the engine long block.
CS2306_TSB_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2306) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on certain 2020-2022MY Soul (SK3) vehicles produced from November 24, 2018 through December 11, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked with the use of the key fob.
TSB_TRA046_R4
Service Bulletin/Repair Instructions
This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.
CS2311_TSB_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR & DECAL INSTALLATION (CS2311) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 15, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) are not able to receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles that are not equipped with an immobilizer, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
TSB_ELE303_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
TSB_CHA121
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: FRONT STRUT BEARING & SPRING PAD REPLACEMENT - This bulletin provides information to replace the front strut bearing and upper spring pad on both front (LH and RH) strut assemblies on certain 2019-2024MY Forte (BDm) vehicles produced from July 09, 2018 through present, 2020-2024MY Soul (SK3) vehicles produced from November 15, 2018 through present, and 2021-2024 Seltos (SP2) vehicles produced from November 20, 2019 through present. The affected vehicles may exhibit an intermittent noise when turning the steering wheel both when driving and when the vehicle is not in motion.
CS2311A_OWNRSK3
Service Bulletin/Repair Instructions
CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia now has an additional vehicle modification available for installation to help deter or thwart attempted thefts. This modification consists of a theft deterrent ignition cylinder protector and will be available to you free of charge for eighteen (18) months from the date of this letter.
CS2311_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR & DECAL INSTALLATION (CS2311) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 15, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) are not able to receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles that are not equipped with an immobilizer, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
CS2311_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR & DECAL INSTALLATION (CS2311) - This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 13, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) are not able to receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles that are not equipped with an immobilizer, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
TSB_ELE320
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE SCREEN FREEZING OR MAP DELAY WITH WIRED APPLE CARPLAY - This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles to remedy an inaccurate map location, freezing AVN screen, or experiencing a delay when using Google Maps or Waze through wired Apple CarPlay.
TSB_ELE314
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: UNEVEN/SLIPPERY ROAD WARNING DISPLAYED ON INSTRUMENT CLUSTER - This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles (refer to model list on page 3) to remedy a warning sound accompanied by a 'Slippery road ahead. Drive carefully' or 'Uneven road ahead. Drive carefully' warning which is displayed on the instrument cluster. The current AVN software causes the warning sound and message to repeat approximately every ten (10) seconds, if the vehicle is not in motion, in 'PARK' or driving on even surfaces.
TSB_ELE303_R1
Service Bulletin/Repair Instructions
This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
TSB_ELE303
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen. Follow the procedure outlined in this publication to update the software on 5th Generation AVN wide units using the applicable USB Flash Drive A or B for the applicable vehicle.
CS2306_OWNR2
Service Bulletin/Repair Instructions
CUSTOMER SATISFACTION CAMPAIGN: OWNER RE-NOTIFICATION - This document is the owner re-notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of the original letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to the vehicle to discourage a break-in.
CS2306L_OWNRSK32
Service Bulletin/Repair Instructions
CUSTOMER SATISFACTION CAMPAIGN: OWNER RE-NOTIFICATION - This document is the owner re-notification advising that Kia is now making steering wheel lock devices available directly to certain Kia vehicle owners. These devices can help deter a theft attempt. We are making this device available to customers free of charge and will ship it directly to customers who place orders within eighteen (18) months from the date of this letter.
TSB_ELE209_R4
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the service reminder setting, which may have been auto-set by the Kia Vehicle Inspection and Delivery application (KVID) at time of Pre-Delivery Inspection (PDI). Beginning with the 2023MY, Oil Life Monitoring (OLM) has been applied to all models, except Forte (BDm), Stinger (CK), Telluride (ON) and Soul (SK3). Refer to TSB ENG241 for additional information. As of 08/11/2023, the service reminder auto-set feature by KVID has been disabled for ALL models NOT equipped with OLM.
CS2310_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: KIA GENUINE REMOTE START CONTROL MODULE UPGRADE FOR ANTI-THEFT LOGIC COMPATIBILITY (CS2310) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software logic in the Kia Genuine Remote Start Control Module on certain 2012-2022MY model vehicles listed on page 7. Vehicles equipped with a Kia Genuine Remote Start feature and have had the Anti-Theft software logic (CS230*) applied to the Integrated Body Control Unit (IBU) or Body Control Module (BCM) may experience five (5) inadvertent honks after starting the vehicle with the remote start feature.
CS2306_TSB_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2306) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on certain 2020-2022MY Soul (SK3) vehicles produced from November 24, 2018 through December 11, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
TSB_CHA104_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: BRAKE AIR BLEEDING PROCEDURE FOR ESC HONKING NOISE AND SOFT/SPONGY BRAKE PEDAL - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the brake air bleeding procedure for 2020MY~ Soul (SK3) vehicles equipped with Electronic Stability Control (ESC) module which may exhibit a "honk" noise when using Idle Stop and Go (ISG) and/or Hill Start Assist Control (HAC).
CS2310_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN CUSTOMER SATISFACTION: KIA GENUINE REMOTE START CONTROL MODULE UPGRADE FOR ANTI-THEFT LOGIC COMPATIBILITY (CS2310) - This bulletin provides information to update the software logic in the Kia Genuine Remote Start Control Module on certain 2012-2022MY model vehicles listed on page 6. Vehicles equipped with a Kia Genuine Remote Start feature and have had the Anti-Theft software logic (CS230*) applied to the Integrated Body Control Unit (IBU) or Body Control Module (BCM) may experience five (5) inadvertent honks after starting the vehicle with the remote start feature.
SC199_TSB_R4
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT (SC199) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. (This bulletin was previously referred as âÂÂSA424â or âÂÂELE 200âÂÂ.) This bulletin provides the procedure to update the Transmission Control Module (TCM) software logic and, if necessary, replace the Intelligent Variable Transmission (IVT) on certain 2019-2021MY vehicles listed in the chart below. The affected vehicles may exhibit the illumination of MIL with the DTC(s) listed below in addition to a lack of acceleration or delay in accelerating due to transmission slippage.
TSB_TRA102_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT - This bulletin provides the procedure to update the Transmission Control Module (TCM) software logic and, if necessary, replace the Intelligent Variable Transmission (IVT) assembly on certain 2019-2021MY model vehicles listed in the chart below, which may exhibit an MIL ON with the DTC(s) listed below and a lack/delay in acceleration due to transmission slippage.
TSB_BOD314
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: OVERHEAD CONSOLE SUNGLASS DOOR-LATCH REPAIR - This bulletin provides information to repair the overhead console lamp assembly and sunglass door latch on some 2012-2023MY model vehicles listed in the table below, which may encounter the sunglass case of the overhead console lamp not closing properly.
CS2306_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2306) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on certain 2020-2022MY Soul (SK3) vehicles produced from November 24, 2018 through December 11, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
CS2306_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2306) - This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on certain 2020-2022MY Soul (SK3) vehicles produced from November 24, 2018 through December 11, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation.
PS677_R2
Service Bulletin/Repair Instructions
PIT STOP: LOG FILE COLLECTION FOR AVN 5.0/W AND DISPLAY AUDIO 2.0 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop contains information regarding the log file collection procedure for 2020MY~ models equipped with AVN 5.0/W or Display Audio 2.0 head units.
CS2306L_OWNRSK3
Service Bulletin/Repair Instructions
CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia is now making steering wheel lock devices available directly to certain Kia vehicle owners. These devices can help deter a theft attempt. We are making this device available to customers free of charge and will ship it directly to customers who place orders within eighteen (18) months from the date of this letter.
TSB_CHA104_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: BRAKE AIR BLEEDING PROCEDURE FOR ESC HONKING NOISE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the brake air bleeding procedure for 2020MY~ Soul (SK3) vehicles equipped with Electronic Stability Control (ESC) module which may exhibit a "honk" noise when using Idle Stop and Go (ISG) and/or Hill Start Assist Control (HAC).
TSB_TRA046_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.
TSB_ENG219_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides information on setting the "Service Interval Reminder" feature available on most 2014-2023MY Kia vehicles (refer to model list on page 2). If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance. Refer to TSB ENG241 for 2023MY~ vehicles equipped with the Oil Life Management System (OLMS) feature not included in table on page 2.
SC199_TSB_R3
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT (SC199) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. (This bulletin was previously referred as 'SA424' or 'ELE 200'.) This bulletin provides the procedure to update the Transmission Control Module (TCM) software logic and, if necessary, replace the Intelligent Variable Transmission (IVT) on certain 2019-2021MY vehicles listed in the chart below. The affected vehicles may exhibit the illumination of MIL with the DTC(s) listed below in addition to a lack of acceleration or delay in accelerating due to transmission slippage.
TSB_ELE209_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin provides the procedure to turn OFF the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster. The KDS is required to change the setting from "Workshop" to "Customer Mode."
SC199_TSB_R2
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT (SC199) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. (This bulletin was previously referred as 'SA424' or 'ELE 200'.) This bulletin provides the procedure to update the Transmission Control Module (TCM) software logic and, if necessary, replace the Intelligent Variable Transmission (IVT) on certain 2019-2021MY vehicles listed in the chart below. The affected vehicles may exhibit the illumination of MIL with the DTC(s) listed below in addition to a lack of acceleration or delay in accelerating due to transmission slippage.
TSB_ENG227_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: MIL ON DTC P0605 AND/OR P2181 ECM LOGIC IMPROVEMENT (SA463) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to improve the logic of the Engine Control Module (ECM) on some 2020-2021MY Soul (SK3) vehicles and 2021MY Seltos (SP2) vehicles produced in the date ranges shown below, equipped with NU 2.0L ATK engines, which may exhibit engine starting related DTC P0605 and/or thermostat related DTC P2181.
PS731
Service Bulletin/Repair Instructions
PITSTOP: DTC P0011/ P0014/ P0016/ P0017 DUE TO INCORRECT CAMSHAFT RELUCTOR WHEEL CONFIGURATION - This Pitstop provides information on some 2010-2013MY Soul (AM), 2014-2019MY Soul (PS), and 2020~MY Soul (SK3) vehicles equipped with the engines listed below, which may set DTC P0011, P0014, P0016, or P0017 after an engine replacement. If these DTCs were not present prior to engine replacement, the camshaft reluctor wheel (also called pulse wheel) may not be in the correct position when engine is at Top Dead Center and may be sending an erroneous signal to the PCM, causing the DTC. Follow the procedure outlined in this publication, with engine set to Top Dead Center (TDC), to inspect and identify whether the reluctor wheel is correctly clocked on the camshaft, and if not, how to correctly position it.
SC209Y_TSB_R1
Service Bulletin/Repair Instructions
SUBSEQUENT REPAIR ACTION: ENGINE REPLACEMENT INSTRUCTIONS FOR PISTON RING NOISE DTC P1327 (SC209Y) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published in (SC209A) titled "ECM Logic Improvement for Piston Ring Noise Sensing System". If DTC P1327 is present after the ECM Logic Improvement is performed per SC209A, follow the instructions in this bulletin to replace the engine long block.
TSB_TRA102
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT - This bulletin provides the procedure to update the Transmission Control Module (TCM) software logic and, if necessary, replace the Intelligent Variable Transmission (IVT) assembly on certain 2019-2021MY model vehicles listed in the chart below, which may exhibit an MIL ON with the DTC(s) listed below and a lack/delay in acceleration due to transmission slippage. To correct this concern, if necessary, apply the improved software logic to the CVT system using the KDS ECU Upgrade function as described in this bulletin and replace the IVT assembly.
PS613_R1
Service Bulletin/Repair Instructions
PITSTOP: INSTRUMENT CLUSTER REPLACEMENT AND MILEAGE SETTING WITH KDS - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This pitstop provides the KDS service procedure for mileage setting on the models listed below with newly replaced instrument clusters. Certain models allow for mileage setting with the KDS, which prevents the need to send out the instrument cluster to a 3rd party for mileage adjustment (refer to PS264). After a new cluster is installed, cluster (variant) coding may also need to be conducted using the KDS. Make sure the KDS software is also updated to the latest version. Mileage setting should be performed by using the KDS only, as described in this bulletin.
SC209Y_TSB
Service Bulletin/Repair Instructions
SUBSEQUENT REPAIR ACTION: ENGINE REPLACEMENT INSTRUCTIONS FOR PISTON RING NOISE DTC P1327(SC209Y) - This bulletin provides information related to the Technical Service Bulletin previously published in (SC209A) titled "ECM Logic Improvement for Piston Ring Noise Sensing System". If DTC P1327 is present after the ECM Logic Improvement is performed per SC209A, follow the instructions in this bulletin to replace the engine long block.
TSB_ENG222_R6
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
PS576_R2
Service Bulletin/Repair Instructions
PITSTOP: BATTERY DEALER (SHIPPING)/CUSTOMER MODE SWITCH - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop provides information regarding a new interface related to the electronic Dealer (Shipping) / Customer Mode Switch setting on all applicable models.
TSB_ENG227_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN - SERVICE ACTION: MIL ON DTC P0605 AND/OR P2181 ECM LOGIC IMPROVEMENT (SA463) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to improve the logic of the Engine Control Module (ECM) on some 2020-2021MY Soul (SK3) vehicles produced from November 24, 2018 through January 4, 2021 and 2021MY Seltos (SP2) vehicles produced from November 20, 2019 through January 12, 2021, equipped with NU 2.0L ATK engines, which may exhibit engine poor starting related DTC P0605 and/or thermostat related DTC P2181.
TSB_ENG222_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
TSB_ENG222_R4
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
TSB_ELE231_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: FRONT VIEW CAMERA REPLACEMENT FOR DTC C160449 & C160649 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on the inspection and replacement of the front camera on some vehicles. Due to an internal control chip concern inside the camera, the vehicle may exhibit a Forward Collision Avoidance Assist Warning Lamp (A) and/or Master Warning Lamp (B) with C160449 and/or C160649 codes. Certain systems may become temporarily disabled during occurrences: Smart Cruise Control (SCC), Lane Keep Assistance (LKA), Lane Departure Warning (LDW), Forward Collision-Avoidance Assist (FCA), Forward Collision Warning (FCW) and/or Driver Attention Warning (DAW).
SC199_TSB_R1
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT (SC199) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. (This bulletin was previously referred to as SA424 or ELE 200.) This bulletin provides the procedure to update the Transmission Control Module (TCM) software logic and, if necessary, replace the Intelligent Variable Transmission (IVT) on certain 2019-2021MY vehicles listed in the chart below. The affected vehicles may exhibit the illumination of MIL with the DTC(s) listed below in addition to a lack of acceleration or delay in accelerating due to transmission slippage.
TSB_ELE239_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: ECM OBD CODE DISPLAY LOGIC IMPROVEMENT (SA474) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to update the software logic of the Engine Control Module (ECM) system on some 2019MY Stinger (CK) vehicles equipped with the 2.0L T-GDI engine and 8AT transmission, 2020MY Soul (SK3) vehicles with 2.0L MPI engine and 6MT transmission, and 2020MY Sportage (QL) vehicles with 2.4L GDI engine and 6AT transmission, in order to improve OBD authentication code display logic.
TSB_CHA084_R8
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit. On some vehicles when the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly and does not affect the steering effort.
TSB_BOD055_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
TSB_ELE246_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: FRONT VIEW CAMERA REPLACEMENT AND SOFTWARE UPGRADE INSTALLATION - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to update the software logic of the front view camera system (FR_CMR) on the vehicles listed below, when a new replacement Front View Camera installed with a part number ending in "SW0". NEW parts with a part number ending in "SW0" do not have the operating software upgrade installed. If the software upgrade is not installed, units will exhibit a warning light ON with Diagnostic Trouble Codes (DTCs) related to the front view camera. Some vehicles require recovery and recording the prior variant coding value before replacement.
TSB_ENG222_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2019MY vehicles (refer to table below for applicable model and engine), which may exhibit a symptom of excessive oil consumption.
TSB_ELE231_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: FRONT VIEW CAMERA REPLACEMENT FOR DTC C160449 & C160649 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on the inspection and replacement of the front camera on some vehicles. Due to an internal control chip concern inside the camera, the vehicle may exhibit a Forward Collision Avoidance Assist Warning Lamp (A) and/or Master Warning Lamp (B) with C160449 and/or C160649 codes. Certain systems may become temporarily disabled during occurrences: Smart Cruise Control (SCC), Lane Keep Assistance (LKA), Lane Departure Warning (LDW), Forward Collision-Avoidance Assist (FCA), Forward Collision Warning (FCW) and/or Driver Attention Warning (DAW).
TSB_TRA083_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: 7-SPEED DCT JUDDER INSPECTION AND DUAL CLUTCH ASSEMBLY REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to replace Dual Clutch Assembly and upgrade the TCU on some 2016-2020MY Kia vehicles listed in the table below, equipped with the 7 Speed Dual Clutch Transmission (DCT), which might exhibit clutch judder when accelerating from a stop.
TSB_ELE246
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: FRONT VIEW CAMERA REPLACEMENT AND SOFTWARE UPGRADE INSTALLATION - This bulletin provides the procedure to update the software logic of the Front Camera (FR_CMR) system on the vehicles listed below, which have had a new replacement Front View Camera installed without software upgrade. If the S/W is not upgraded, units will exhibit a warning light ON with Diagnostic Trouble Codes (DTCs) related to the Front Camera (FR_CMR).
PS704
Service Bulletin/Repair Instructions
PITSTOP: FRONT RADAR SENSOR MOUNTING INSPECTION (PS704) - This pitstop provides information regarding front radar sensor alignment on 2014MY and later vehicles that may exhibit a warning light ON related to radar sensor alignment errors in the Forward Collision-Avoidance Assist (FCA)/Smart Cruise Control (SCC) system.
PS703
Service Bulletin/Repair Instructions
PITSTOP: BLUETOOTH MEMORY AND VOICE RECOGNITION CONCERN WITH AVN 5.0/W - This Pitstop provides information for resolving a memory concern with the AVN 5.0 Wide head unit while downloading the contact list from a paired phone. The concern also affects Voice Recognition (VR) functionality.
TSB_ELE239
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: ECM OBD CODE DISPLAY LOGIC IMPROVEMENT (SA474) - This bulletin provides the procedure to update the software logic of the Engine Control Module (ECM) system on some 2019MY Stinger (CK) vehicles equipped with the 2.0L T-GDI engine and 8AT transmission, 2020MY Soul (SK3) vehicles with 2.0L MPI engine and 6MT transmission, and 2020MY Sportage (QL) vehicles with 2.4L GDI engine and 6AT transmission, in order to improve OBD authentication code display logic.
SC199_OWNR_SK3_2
Service Bulletin/Repair Instructions
SC199 - Owner Letter - Soul: Second notification to Soul vehicle owners advising them of a Voluntary Emissions Service Campaign to improve the Transmission Control Module (TCM) logic and, if necessary, replace the Intelligent Variable Transmission (IVT) on some 2020-2021 Soul vehicles.
PS677_R1
Service Bulletin/Repair Instructions
PIT STOP: LOG FILE COLLECTION FOR AVN 5.0/W AND DISPLAY AUDIO 2.0 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop contains information regarding the log file collection procedure for 2020MY~ models equipped with AVN 5.0/W or Display Audio 2.0 head units.
TSB_ELE209_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to turn OFF the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster.
TSB_CHA084_R7
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
PS576_R1
Service Bulletin/Repair Instructions
PITSTOP: BATTERY DEALER / CUSTOMER MODE SWITCH - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop provides information regarding a new interface related to the electronic Dealer / Customer Mode Switch setting on multiple models.
PS677
Service Bulletin/Repair Instructions
PITSTOP: LOG FILE COLLECTION FOR AVN 5.0/W & DISPLAY AUDIO 2.0 - This Pitstop contains information regarding the log file collection procedure for 2020MY~ models equipped with AVN 5.0/W or Display Audio 2.0 head units.
TSB_ELE209_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to turn OFF the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster.
TSB_ENG227
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN - SERVICE ACTION: MIL ON DTC P0605 AND/OR P2181 ECM LOGIC IMPROVEMENT (SA463) - This bulletin provides the procedure to improve the logic of the Engine Control Module (ECM) on some 2020-2021MY Soul (SK3) vehicles produced from November 24, 2018 through January 4, 2021 and 2021MY Seltos (SP2) vehicles produced from November 20, 2019 through January 12, 2021, equipped with NU 2.0L ATK engines, which may exhibit engine poor starting related DTC P0605 and/or thermostat related DTC P2181.
TSB_ENG213_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC20). This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. - This bulletin provides information related to extracting âÂÂin use performance trackingâ emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
TSB_TRA083
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: 7-SPEED DCT JUDDER INSPECTION AND DUAL CLUTCH ASSEMBLY REPLACEMENT - This bulletin provides the procedure to replace Dual Clutch Assembly and upgrade the TCU on some 2016-2020MY Kia vehicles listed on the table below, equipped with the 7 Speed Dual Clutch Transmission (DCT), which might exhibit clutch judder when accelerating from a stop. If the vehicle body vibrates without the steering wheel shuddering when performing creep driving test (driving the vehicle up to 3mph), the vehicle is exhibiting clutch judder. The creep test can be conducted by driving at a speed slower than 5 mph after releasing the brake.
SC199_OWNR_SK3
Service Bulletin/Repair Instructions
SC199 - Owner Letter to Soul vehicle owners advising them of a Voluntary Emissions Service Campaign to improve the Transmission Control Module (TCM) logic and, if necessary, replace the Intelligent Variable Transmission (IVT) on some 2020-2021 Soul vehicles.
SC199_DP
Service Bulletin/Repair Instructions
SC199 - Dealer Principal Notice: Notification to Dealer Principals advising them of a Voluntary Emissions Service Campaign to improve the Transmission Control Module (TCM) logic and, if necessary, replace the Intelligent Variable Transmission (IVT) on some 2019-2020 Forte; 2020-2021 Soul, and 2021 Seltos vehicles.
SC199_DPSM
Service Bulletin/Repair Instructions
SC199 - Dealer Parts and Service Manager Notice: Notification to Dealer Parts and Service Managers advising them of a Voluntary Emissions Service Campaign to improve the Transmission Control Module (TCM) logic and, if necessary, replace the Intelligent Variable Transmission (IVT) on some 2019-2020 Forte; 2020-2021 Soul, and 2021 Seltos vehicles.
SC199_POC
Service Bulletin/Repair Instructions
SC199_POC - Proof of Completion Card
SC199_QA
Service Bulletin/Repair Instructions
SC199 - Questions and Answers: Frequently Asked Questions regarding the Voluntary Emissions Service Campaign to improve the Transmission Control Module (TCM) logic and, if necessary, replace the Intelligent Variable Transmission (IVT) on some 2019-2020 Forte; 2020-2021 Soul, and 2021 Seltos vehicles.
SC199_STCKR
Service Bulletin/Repair Instructions
SC199_STCKR - Completion Sticker
SC199_TSB
Service Bulletin/Repair Instructions
SC199_TSB: VOLUNTARY EMMISSIONS SERVICE CAMPAIGN - IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT (SC199) - (This bulletin was previously referred as 'SA424' or 'ELE 200'.) This bulletin provides the procedure to update the Transmission Control Module (TCM) software logic and, if necessary, replace the Intelligent Variable Transmission (IVT) on certain 2019-2021MY vehicles listed in the chart below. The affected vehicles may exhibit the illumination of MIL with the DTC(s) listed below in addition to a lack of acceleration or delay in accelerating due to transmission slippage.
TSB_CHA084_R6
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Worm Gear Assembly or Steering Column Housing on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
TSB_CHA084_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Worm Gear Assembly or Steering Column Housing on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
PS663
Service Bulletin/Repair Instructions
PITSTOP: MFC, CONCERNS FOR DISABLED OPERATION - This Pitstop provides information regarding concerns with disabled operation of Multi-Function Camera (MFC) on some Kia vehicles. When normal operation is not possible due to certain outside environment conditions (such as sunlight glare, heavy rain, sunlight, snow, fog and/or substance/debris) causing a temporary concern. This stops operation causing Warning Lamp ON and/or Pop-up Message displayed on the cluster. This is a normal operation of the ADAS and once environment conditions improve and/or substance/debris are removed, the system will clear itself and operate normally.
TSB_ELE209
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin provides the procedure to turn OFF the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster.
PS675
Service Bulletin/Repair Instructions
PITSTOP - BRAKE CALIPER LEAK INSPECTION - This PITSTOP provides information related to a brake caliper fluid/oil substance found on some Kia vehicles, due to possible excess assembly oil applied during assembly.
TSB_ELE200_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT (SA424) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to improve the Transmission Control Module (TCM) logic and if necessary, replace the Intelligent Variable Transmission (IVT) on 2019-2021MY vehicleswhich may exhibit a MIL with certain DTC(s).
TSB_CHA098_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: IBAU SYSTEM REPAIR FOR NOISE AND AIR BLEEDING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the repair procedure for the Integrated Brake Actuation Unit (iBAU) system on some 2014-2019MY EV/Hybrid/Plug-In Hybrid vehicles listed (see table), which may exhibit a "honking" (Hissing) noise due to air remaining in the brake fluid system.
TSB_ENG219
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin provides information on setting the "Service Interval Reminder" feature available on most Kia vehicles. If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance.
TSB_ELE200_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT (SA424) - This bulletin has been revised to include additional information. This bulletin provides the procedure to improve the Transmission Control Module (TCM) logic and if necessary, replace the Intelligent Variable Transmission (IVT) on 2019-2021MY vehicles which may exhibit a MIL with the DTC(s) listed below.
TSB_ENG217
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE
TSB_ELE200_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT (SA424) - This bulletin has been revised to include additional information. This bulletin provides the procedure to improve the Transmission Control Module (TCM) logic and if necessary, replace the Intelligent Variable Transmission (IVT) on 2019-2021MY vehicles which may exhibit a MIL with the DTC(s) listed below. To correct this concern, apply the improved logic to the CVT system using the KDS ECU Upgrade function as described in this bulletin and/or replace the IVT assembly.
TSB_ELE200
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: IVT SOFTWARE LOGIC IMPROVEMENT AND/OR IVT REPLACEMENT (SA424) - This bulletin provides the procedure to improve the Transmission Control Module (TCM) logic and if necessary, replace the Intelligent Variable Transmission (IVT) on 2019-2021MY vehicles which may exhibit a MIL with the DTC(s) listed below. To correct this concern, apply the improved logic to the CVT system using the KDS ECU Upgrade function as described in this bulletin and/or replace the IVT assembly.
TSB_CHA104
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: BRAKE AIR BLEEDING PROCEDURE FOR ESC HONKING NOISE - This bulletin provides information regarding the brake air bleeding procedure for 2020MY~ Soul (SK3) vehicles equipped with Electronic Stability Control (ESC) module which may exhibit a "honk" noise when using Idle Stop and Go (ISG) and/or Hill Start Assist Control (HAC).
PS661
Service Bulletin/Repair Instructions
PITSTOP: BLIND-SPOT COLLISION WARNING (BCW) VARIANT CODING - POSSIBLE C166A87 - This Pitstop provides information regarding the Blind-Spot Collision Warning (BCW) system setting a DTC C166A87 after replacing a BCW module on 2020-2021 Soul (SK3) vehicles. After replacement, the BCW (BSD) variant coding needs to be performed using the KDS under S/W Management for the options equipped for that vehicle.
TSB_TRA046_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: - TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles on page 2. Refer to the shop manual on KGIS for the specific Kia model for the correct transmission fluid check/fill procedures.
TSB_CHA101
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CREAKING OR POPPING NOISE FROM STEERING WHEEL COLUMN TILT LEVER - This bulletin provides the procedure to repair a creaking/popping noise from the steering column area on some 2020MY Soul (SK3) vehicles, which may be heard when turning the steering wheel at low speeds or while stopped. To repair this concern, follow the procedure outlined in this bulletin to replace and install the improved fixed cam kit to the steering column.
TSB_BOD203
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: RE-TIGHTENING WIPER ARM NUTS (SA412) - This bulletin provides the procedure to re-tighten the wiper arm nuts to the torque specification on some 2020MY Soul (SK3) vehicles produced from November 4, 2019 through December 12, 2019, which may not have been properly torqued during assembly.
TSB_ENG214
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: SK3 1.6T GDI ECU LOGIC IMPROVEMENT (SA413) - This bulletin provides the procedure to improve the logic of the Engine Control Unit (ECU) on some 2020MY Soul (SK3) vehicles equipped with 1.6T GDI and 7-Speed Dual Clutch Transmission (DCT), produced from November 15, 2018 through December 26, 2019, which may exhibit check engine lamp with misfire and/or coolant DTCs.
TSB_ENG213
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC20) - This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
TSB_CHA102
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: EPS DTC JUDGEMENT LOGIC IMPROVEMENT SOFTWARE UPGRADE (SA409) - This bulletin provides the procedure to apply improved Diagnostic Trouble Code (DTC) judgement logic for the Electronic Power Steering (EPS) on some 2020MY Soul (SK3) vehicles, produced from November 15, 2018 through October 8, 2019, which requires a software upgrade. Install the improved logic of the EPS using the KDS ECU Upgrade function as described in this bulletin.
TSBCHA084_R4
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information.This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU) or Steering Column Housing on some 2010MY~ Kia models listed on page 5 equipped with a Column Motor Driven Power Steering (C-MDPS) unit. Follow the MDPS Flowchart (page 2) along with the MDPS DTC Table (page 3) procedure outlined in this bulletin before replacing the C-MDPS Motor, ECU or Steering Column Housing.
TSBTRA084
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: REPLACEMENT OF 7-SPEED DUAL CLUTCH TRANSMISSION ASSEMBLY (SA396) - This bulletin provides the procedure to replace the 7-Speed Dual Clutch Transmission (DCT) assembly on some 2019-2020MY Soul (PS, SK3) vehicles, which may exhibit harsh shifting and/or Malfunction Indicator Lamp (MIL) with transmission related DTCs due to crack(s) on the 3rd and 7th gear synchronizer hub.
TSBELE190
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN TSBELE190: SERVICE ACTION: AVN 5 WIDE SOFTWARE UPDATE VOICE RECOGNITION ISSUE (SA405) - This bulletin provides the procedure for updating the AVN 5 WIDE software on some 2020MY Telluride (ON) produced from January 9, 2019 through September 16, 2019 and Soul (SK3) vehicles produced from November 22, 2018 through September 19, 2019, which may experience inoperative voice recognition when setting a destination
TSBCHA084_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN TSB084_R3: PARTIAL REPAIR OF C-MDPS MOTOR, ECU AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information.This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU) or Steering Column Housing on some 2010MY~ Kia models listed on page 5 equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
PS617
Service Bulletin/Repair Instructions
PITSTOP: DCT OIL LEVEL INSPECTION PROCEDURE - This Pitstop provides information regarding the procedural change made when inspecting the oil level on a Dual Clutch Transmission (DCT) for 2020MY~ Soul (SK3) vehicles. The DCT assembly now sits at a 5 degree difference from the previous Soul (PS). This change requires an updated oil level inspection procedure.
PS611
Service Bulletin/Repair Instructions
PITSTOP: CUSTOMER TIP: MOOD LAMP SK3 - This Pitstop provides information regarding the Sound Mood Lamp logic available only on the 2020MY Soul GT-Line 1.6T (SK3) with the Comfort and Convenience Package.
PS613
Service Bulletin/Repair Instructions
PITSTOP: INSTRUMENT CLUSTER REPLACEMENT, MILEAGE SETTING WITH KDS - This publication provides the KDS service procedure for mileage setting on the listed vehicles with newly replaced instrument clusters.
TSBELE180_R1
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: AVN 5 WIDE SOFTWARE UPDATE BLUETOOTH MEMORY ISSUE (SA386) - This bulletin provides the procedure for updating the AVN 5 WIDE software on some 2020MY Telluride (ON) produced from March 23, 2019 through April 30, 2019 and Soul (SK3) vehicles produced from February 18, 2019 to May 2, 2019, which may experience Bluetooth and navigation connection and/or memory issues.
TSBELE180
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: AVN 5 WIDE BLUETOOTH MEMORY ISSUE (SA386) - This bulletin provides the procedure for updating the AVN 5 WIDE software on some 2020MY Telluride (ON) produced from March 23, 2019 through April 30, 2019 and Soul (SK3) vehicles produced from February 18, 2019 to May 2, 2019, which may experience Bluetooth and navigation connection and/or memory issues.
TSBBOD190
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: INOPERATIVE HORN REPLACEMENT (SA384) - This bulletin provides the procedure to replace the horn assembly on some 2020MY Soul (SK3) vehicles produced from December 10, 2018 through January 11, 2019 which may exhibit a weak intermittent or non-operational "sound" due to moisture inflow into the horn.
PS609
Service Bulletin/Repair Instructions
PITSTOP: SOUL (SK3) ALIGNMENT SPECIFICATIONS - This Pitstop provides information regarding alignment specifications for 2020MY Soul (SK3) vehicles. In the event a wheel alignment is needed, ensure your alignment equipment has the correct specifications programmed into the PC database.
PS605
Service Bulletin/Repair Instructions
PITSTOP: DIFFICULT TO SHIFT INTO 1ST GEAR - This Pitstop provides information regarding a possible difficult to shift into 1st gear concern on 2020MY Soul (SK3) vehicles equipped with manual transmissions. The possible root cause could be that the shift/control cable is out of adjustment.
TSBENG203
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: ECU LOGIC IMPROVEMENT FOR DTC P0606 (SA377) - This bulletin provides the procedure to improve the logic of the Engine Control Unit (ECU) on some 2020MY Soul (SK3) 1.6T vehicles, produced from November 15, 2018 through February 28, 2019, which may exhibit a malfunction indicator lamp (MIL) illumination with DTC P0606.
PS601
Service Bulletin/Repair Instructions
PITSTOP: EXTEND REAR CAMERA USE FEATURE - This Pitstop provides information regarding the "Extend Rear Camera Use" feature available on the AVN 5.0 Wide and Display Audio head units.