Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SC369_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: THETA III 2.5L T-GDI ECM SOFTWARE LOGIC IMPROVEMENT (SC369) - This bulletin provides information to upgrade the engine control module (ECM) software to improve combustion stability by optimizing injector fuel injection control during the initial driving period on certain 2022-2023MY Stinger (CK) vehicles equipped with the Theta III 2.5L T-GDI ULEV engine, manufactured from February 1, 2021 through April 11, 2023. The subject vehicles may have been produced with engine calibrations that can cause the vehicle to release air pollutants that exceed Federal and California standards. These standards were established to protect the public’s health and welfare from the dangers of air pollution.
SC369__OWNR
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC369) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) for 2022-2023 MY Stinger vehicles equipped with the 2.5L Turbocharged Gas Direct Injection (T-GDI) engine to ensure compliance with emissions regulations.
SC369_POC
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: SC369_POC: PROOF OF CORRECTION CARD
SC369_QA
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: QUESTION AND ANSWER (SC369) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Emissions Service Campaign SC369.
SC369_STKR
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: SC369_STKR: VOLUNTARY EMISSIONS SERVICE CAMPAIGN COMPLETION LABEL/STICKER
SC369_DP
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO (SC369) - This document is the announcement to the dealer principals advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations for 2022-2023 MY Stinger vehicles equipped with the 2.5L T-GDI engine and manufactured from February 1, 2021 through April 11, 2023.
SC369_DPSM
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (SC369) - This document is the announcement to the dealer Parts and Service managers advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations for 2022-2023 MY Stinger vehicles equipped with the 2.5L T-GDI engine and manufactured from February 1, 2021 through April 11, 2023.
TSB_ELE422
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: INFOTAINMENT SYSTEM SOFTWARE UPDATE USING UPDATE.KIA.COM - This bulletin provides information and service procedures for updating the infotainment systems on applicable Kia vehicles using the Kia Navigation Updater available at update.kia.com. The software update may improve system performance, enhance existing features, and apply the latest operating software for supported vehicles (2021-2026MY All Models).
TSB_ELE417
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: INFOTAINMENT SOFTWARE UPDATE PROCEDURE - This bulletin provides information on the process for downloading infotainment software updates and preparing USB for installation on applicable Kia vehicles. The software downloads and USB preparation process is similar across all supported platforms; however, in‑vehicle installation procedures vary by head unit type.
PS797
Other
PITSTOP: TECHNICAL OPERATIONS: EXTERNAL DAMAGE TO ULTRASONIC SENSOR: This Pitstop provides information related to Parking Distance Warning (PDW) alerts and repairs involving ultrasonic sensors. The PDW system alerts the driver while parking, by calculating distance based on the difference in signal transmission and reception times between the vehicle (ultrasonic sensor) and an object. The membrane film of the ultrasonic sensor is used for object detention and can be damaged by stone chips or foreign substances while driving. Damage to the cover of the ultrasonic sensor can also lead to damage to the internal circuit. As a result of this external damage, the PDW system may not receive the proper signal from the ultrasonic sensor. In some cases, the system may cause a false alarm, no alert, or phantom warnings by a “Warning Lamp’ to be displayed on the cluster. The ultrasonic sensor membrane film should be always inspected for external damage and if any part replacement should be treated as a general repair, not as a warranty claim repair for this concern. (Please note that this Pitstop only applies to models/trims that are equipped with the ultrasonic sensors.)
TSB_TRA046_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission.
TSB_ELE378
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: KIA CONNECT MODEM RESET (SA611) - This bulletin outlines the procedure for resetting the modem in certain 2016-2025MY Kia vehicles listed on page 3 that are equipped with Kia Connect Services. The affected vehicles may encounter the following issues: remote Start/Climate Control function not working, vehicle Status on the Kia Access App not updating, connected routing not functioning properly.
TSB_ELE303_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 8) to remedy a ‘non-responsive’ or ‘inoperative’ radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the ‘RADIO’ hard key/button on the AVN unit or when selecting the ‘RADIO’ icon on the AVN menu screen.
TSB_TRA046_R4
Service Bulletin/Repair Instructions
This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.
TSB_ELE303_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
TSB_ELE320
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE SCREEN FREEZING OR MAP DELAY WITH WIRED APPLE CARPLAY - This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles to remedy an inaccurate map location, freezing AVN screen, or experiencing a delay when using Google Maps or Waze through wired Apple CarPlay.
TSB_ELE314
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: UNEVEN/SLIPPERY ROAD WARNING DISPLAYED ON INSTRUMENT CLUSTER - This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles (refer to model list on page 3) to remedy a warning sound accompanied by a 'Slippery road ahead. Drive carefully' or 'Uneven road ahead. Drive carefully' warning which is displayed on the instrument cluster. The current AVN software causes the warning sound and message to repeat approximately every ten (10) seconds, if the vehicle is not in motion, in 'PARK' or driving on even surfaces.
TSB_ELE303_R1
Service Bulletin/Repair Instructions
This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
PS750
Service Bulletin/Repair Instructions
PITSTOP: AWD SYSTEM CONCERN DUE TO TIRE CIRCUMFERENCE - This Pitstop provides information regarding potential concerns with the All-Wheel-Drive (AWD) system due to tire sizes of differing circumference. Some customers may complain of a chatter sensation felt in the drivetrain of the vehicle and/or the failure of drivetrain component(s). A difference in tire size (width, aspect ratio, construction, rim diameter etc.) may be the cause.
TSB_ELE303
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen. Follow the procedure outlined in this publication to update the software on 5th Generation AVN wide units using the applicable USB Flash Drive A or B for the applicable vehicle.
TSB_BOD317
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: HEADLINER NOSIE REDUCTION - This bulletin provides information to apply anti-noise tape to the headliner and assist handle brackets on some 2022MY Stinger (CK) vehicles produced from September 9, 2021 through present, equipped with a sunroof. The affected vehicles may exhibit an intermittent noise due to normal body flexing while driving on uneven roads.
TSB_ELE294
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SHIFT LEVER POSITION INSPECTION & DETENT DAMPER REPLACEMENT FOR REMOTE START FAILURE - This bulletin provides information to inspect the shift lever position and, if necessary, replace the shift lever detent damper on some 2022-2023MY Stinger H-MATIC (CK) vehicles produced from December 23, 2020 through October 30, 2022. The shift lever detent damperâÂÂs angled design may cause interference between the detent damper and the shift lever Park 'P' switch resulting in the Integrated Body Control Unit (IBU) not registering 'P'. This can render the Remote Start function inoperative when either using the key fob or Kia Access App.
TSB_BOD314
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: OVERHEAD CONSOLE SUNGLASS DOOR-LATCH REPAIR - This bulletin provides information to repair the overhead console lamp assembly and sunglass door latch on some 2012-2023MY model vehicles listed in the table below, which may encounter the sunglass case of the overhead console lamp not closing properly.
PS677_R2
Service Bulletin/Repair Instructions
PIT STOP: LOG FILE COLLECTION FOR AVN 5.0/W AND DISPLAY AUDIO 2.0 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop contains information regarding the log file collection procedure for 2020MY~ models equipped with AVN 5.0/W or Display Audio 2.0 head units.
PS738
Service Bulletin/Repair Instructions
PITSTOP: VARIANT CODING AFTER MDPS/EPS REPLACEMENT - This Pitstop provides information to perform variant coding on some 2018-2023MY Stinger (CK) vehicles, after replacement of an MDPS and/or EPS unit. The selections on KGIS do not match those on the KDS. Follow the procedure below to perform variant coding on a newly replaced MDPS and/or EPS unit.
TSB_TRA046_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.
TSB_BOD309
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR FOR SUNROOF OPERATION - This bulletin provides information to replace the rear sled assembly in the sunroof (left and right side) on some 2018-2023MY Stinger (CK) vehicles produced from September 21, 2017 through January 28, 2022, which may exhibit separation of the rear sled assembly in the sunroof mechanism, resulting in an inoperative sunroof.
TSB_ENG219_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides information on setting the "Service Interval Reminder" feature available on most 2014-2023MY Kia vehicles (refer to model list on page 2). If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance. Refer to TSB ENG241 for 2023MY~ vehicles equipped with the Oil Life Management System (OLMS) feature not included in table on page 2.
TSB_ELE209_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin provides the procedure to turn OFF the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster. The KDS is required to change the setting from "Workshop" to "Customer Mode."
PS672_R1
Service Bulletin/Repair Instructions
PITSTOP: REAR OCCUPANT ALERT (ROA) W/REAR DOOR LOGIC - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop provides information regarding the Rear Occupant Alert (ROA) with Rear Door Logic system on all 21MY~ models equipped with this feature. This system is designed to help prevent a rear passenger from being left inside the vehicle when exiting. The "Check Rear Seats" message will display on the cluster when driver opens the front door, if during vehicle operation the rear doors (one or both) were opened and closed.
TSB_ELE255
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DYNAMIC BENDING LIGHT DTC B232509/B232609 - MOISTURE ABSORBENT & BRACKET REPLACEMENT - This bulletin provides information to repair an inoperative Dynamic Bending Light (DBL) by replacing the moisture absorbent and bracket on some 2018-2022MY Stinger (CK) vehicles produced from October 11, 2017 through April 27, 2022, which may exhibit a MIL 'ON' with DTC B232509 or B232609 (active or pending). This may be due to an expanded moisture absorbent causing the bracket to interfere with the DBL module. New parts are available to address this condition (see chart below for details).
TSB_BOD302_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN SERVICE ACTION: FRONT DOOR TRIM GRIP HANDLE REPAIR (SA483) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to repair the two (2) (LHS & RHS) front door trim grip handles on some 2022MY Stinger (CK) vehicles produced from February 25, 2021 through June 17, 2021, which may have the grip handle detached from the inside door trim.
TSB_ENG231_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC22) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
TSB_ENG231
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC22) - This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
TSB_BOD055_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
TSB_BOD302
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: FRONT DOOR TRIM GRIP HANDLE INSPECTION AND REPAIR (SA483) - This bulletin provides information to inspect the two (2) (LHS & RHS) front door trim grip handles on some 2022MY Stinger (CK) vehicles produced from February 25, 2021 through June 17, 2021, which may have the grip handle detached from the inside door trim.
PS704
Service Bulletin/Repair Instructions
PITSTOP: FRONT RADAR SENSOR MOUNTING INSPECTION (PS704) - This pitstop provides information regarding front radar sensor alignment on 2014MY and later vehicles that may exhibit a warning light ON related to radar sensor alignment errors in the Forward Collision-Avoidance Assist (FCA)/Smart Cruise Control (SCC) system.
PS677_R1
Service Bulletin/Repair Instructions
PIT STOP: LOG FILE COLLECTION FOR AVN 5.0/W AND DISPLAY AUDIO 2.0 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop contains information regarding the log file collection procedure for 2020MY~ models equipped with AVN 5.0/W or Display Audio 2.0 head units.
TSB_CLI050
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: HEATER HOSE CLAMP INSPECTION AND REPLACEMENT (SA479) - This bulletin provides the procedure to inspect and if necessary, replace the heater hose clamp on some 2022MY Stinger (CK) vehicles equipped with 3.3L T-GDI LAMBDA II engine, which may have had the incorrect diameter hose camp installed in one of the hose ends during assembly.
TSB_FUE051
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: VARIABLE MUFFLER OPERATION LOGIC IMPROVEMENT (SA468) - This bulletin provides the procedure to update the software logic of the Engine Control Module (ECM) system on some 2022MY Stinger (CK) vehicles equipped with the 3.3L GDI engine and 8AT transmission, produced from January 15, 2021 through February 5, 2021, to improve the variable sound of the muffler in "sport mode."