Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
23LE01
Service Bulletin/Repair Instructions
DL: On December 20, 2022, a settlement of claims for certain low pressure fuel pumps was approved by the federal court. The settlement includes Lexus?s agreement to provide a Customer Support Program for certain 2013-2020 model year (MY) vehicles originally equipped with low pressure fuel pumps repaired under Safety Recall 20LA01 or Special Service Campaign 21LC01. The purpose of this Customer Support Program letter is to help clarify how to administer this coverage in accordance with the settlement.
LSB000523
Service Bulletin/Repair Instructions
TSB: Some 2013 ? 2020 model year Lexus vehicles may exhibit a hard start and/or MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): ?DTC P0171 and/or P0174 (System Too Lean Bank 1/Bank 2) ?DTC P0087 Fuel Rail / System Pressure ? Too Low Techstream data list analysis may reveal positive fuel trims including a no pressure condition verified by a manual fuel pressure gauge. Follow the Repair Procedure in this bulletin to address these conditions.
19LE05 Dealer Pa
Service Bulletin/Repair Instructions
DP: Customer Support Program 19LE05 expired December 1, 2022.
19LE05 Technical
Service Bulletin/Repair Instructions
TI: 19LE05 Expired December 1, 2022
KLG Dealer Packa
Service Bulletin/Repair Instructions
DP: Limited Service Campaign KLG expired December 01, 2022
KLG Technical In
Service Bulletin/Repair Instructions
TI: 19LE05 Expired December 1, 2022
L-SB-0015-21 Rev
Service Bulletin/Repair Instructions
TSB: Some 2010 ? 2023 model year GX 460 (KDSS-equipped) vehicles may exhibit a condition where the vehicle leans more than 20 mm (0.79 in.) from left to right when viewed from the rear of the vehicle. Follow the Repair Procedure in this bulletin to address this condition
22LE02 - Takata
Service Bulletin/Repair Instructions
CSP: On July 30, 2018, a settlement of claims for Economic Loss related to Takata airbag inflators was approved for full implementation. The settlement includes Lexus?s agreement to provide a Customer Support Program (?CSP?) for 2002-2019 model year (MY) vehicles originally equipped with certain Takata airbag inflators or repaired under a recall with Takata airbag inflators to provide coverage for repairs of the airbag inflator contained in the airbag module. This CSP letter is to help clarify how to administer this coverage in accordance with the settlement. This is NOT a recall or a campaign, but is provided to reassure owners that Lexus stands behind the reliability of our vehicles
Takata CSP Cover
Service Bulletin/Repair Instructions
CSP: Takata CSP Coverage Job Aid - published 7.28.2022
Safety Recall 22
Service Bulletin/Repair Instructions
Lexus Safety Recall and Service Campaign - Technician Certification Requirements 4.13.2022
L-SB-0006-22
Service Bulletin/Repair Instructions
TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Follow the Repair Procedure in this bulletin to replace the loose or damaged carpet floor retainer(s).
L-SB-0004-22
Service Bulletin/Repair Instructions
TSB: Some 2005 ? 2022 model year Lexus vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this service bulletin is to provide general guidelines and procedures for odor remediation. This service bulletin provides a guide on how to prepare the interior of the vehicle prior to an odor remediation being performed, as well as contact information for an approved vendor who will arrange the remediation, and instructions on how to prepare the interior of the vehicle for reassembly once the remediation has been completed. Refer to all model and model year specific Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This service bulletin is to provide a general overview and direction for the odor remediation process.
L-SB-0046-21
Service Bulletin/Repair Instructions
TSB: For proper calibration of the millimeter wave radar sensor, the vehicle and radar target must be on a level surface with a consistent plane. If a level surface with a consistent plane is not available, use the Floor Slope Compensation Procedure in this service bulletin in conjunction with the appropriate model and model year Repair Manual instructions when adjusting the millimeter wave radar sensor.
L-SB-0018-14 Obs
Service Bulletin/Repair Instructions
OBSOLETE NOTICE July 26, 2021: This bulletin is now obsolete. Please see L-SB-0024-21.
L-SB-0024-21
Service Bulletin/Repair Instructions
TSB: Some 2007 ? 2022 model year Lexus vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX® Tip) is available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the ARINIX® Tip. Follow the procedures in this bulletin for proper handling and installation of this optional service part.
L-SB-0041-14 Obs
Service Bulletin/Repair Instructions
OBSOLETE NOTICE July 2, 2021: This bulletin is now obsolete. Please see L-SB-0015-21.
L-SB-0015-21
Service Bulletin/Repair Instructions
TSB: Some 2010 ? 2021 model year GX 460 (KDSS-equipped) vehicles may exhibit a condition where the vehicle leans more than 20 mm (0.79 in.) from left to right when viewed from the rear of the vehicle. Follow the Repair Procedure in this bulletin to address this condition.
Lexus PRO21-UFRM
Service Bulletin/Repair Instructions
POL: UPDATES TO THE 2014-2021 LEXUS UNIVERSAL FLAT RATE MANUAL
Lexus Safety Re
Service Bulletin/Repair Instructions
Lexus Safety Recall and Service Campaign - Technician Certification Requirements
L-TT-0281-20 Rev
Service Bulletin/Repair Instructions
TT: Some customers may encounter Bluetooth® connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth® failure to connect to the vehicle when first turning on the vehicle. ?Various Bluetooth® Audio functions are no longer functioning with customer?s phone such as ability to change the track using the steering wheel controls. These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or if they have restored their phone data/settings recently.
L-TT-0294-20
Service Bulletin/Repair Instructions
TT: HVAC drain tube is found to blocked/clogged.
L-SB-0039-20
Service Bulletin/Repair Instructions
TSB: This Service Bulletin provides updated non-electric water pump leak inspection and diagnostic tips for some 2008 ? 2021 model year Lexus vehicles.
L-SB-0023-20
Service Bulletin/Repair Instructions
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST004-01, SU001-08, and L-SB-0174-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before proceeding. This Service Bulletin provides best practice procedures for vehicle pulling complaint, diagnosis, and repair for 2002 ? 2021 model year Lexus vehicles. This information supplements Repair Manual procedures when the symptoms are: ?Vehicle Pulling: The vehicle moves to the right or left when the driver holds the steering wheel while driving straight ahead without exerting steering effort. ?Steering Wheel Off Center: The vehicle travels straight, but the steering wheel is not pointed straight ahead. The vehicle is not pulling. Before repairing a vehicle pulling to one side, it is necessary to clearly identify the cause of the pulling condition. Frequently, pulling to one side is diagnosed as a wheel alignment concern. However, the actual cause may be related to the lateral force generated by the tires, vehicle damage, road crown or worn components. Performing a wheel alignment when tire force is the cause could result in the wheel alignment being set at a value outside of specifications. This could then cause other problems such as uneven tire wear, etc. A customer may notice a pull to the left when in the left lanes of travel and notice a pull to the right or no pull when traveling in the right lanes of travel on the very same section of roadway. This road crown effect is environmental and cannot be corrected with suspension adjustments or any other wheel or tire modification discussed in this bulletin.
L-SB-0041-14_Rev
Service Bulletin/Repair Instructions
TSB: Some 2010 ? 2020 model year GX 460 (KDSS-equipped) vehicles may exhibit a condition where the vehicle leans more than 20 mm (0.79 in.) from left to right when viewed from the rear of the vehicle. Follow the Repair Procedure in this bulletin to address this condition.
L-SB-0008-20
Service Bulletin/Repair Instructions
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. L-SB-0048-08, PG007-07, PG016-01, PG015-01, PG004-97, PG003-97, PG003-93, PG002-90, L-SB-0048-08, PG007-07, PG016-01, PG015-01, PG004-97, PG003-97, PG003 93, and PG002-90. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1990 ? 2020 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin.
L-SB-0179-17 Obs
Service Bulletin/Repair Instructions
TSB: OBSOLETE NOTICE April 06, 2020: This bulletin is now obsolete. Please see L-SB-0008-20. Replacement Certification Labels and VIN Plates
L-TT-0284-20
Service Bulletin/Repair Instructions
TT: For proper calibration of the millimeter wave radar sensor, the vehicle must be on a level surface. If a level surface is not available, this tech tip should be used in conjunction with the repair manual to set the angle of the front millimeter wave radar sensor and reflector height before performing beam axis adjustment.
L-TT-0281-20
Service Bulletin/Repair Instructions
TT: Some customers may encounter Bluetooth® connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth® failure to connect to the vehicle when first turning on the vehicle. ?Various Bluetooth® Audio functions are no longer functioning with customer?s phone such as ability to change the track using the steering wheel controls. These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or if they have restored their phone data/settings recently.
L-SB-0003-20
Service Bulletin/Repair Instructions
TSB: Some 2006 ? 2020 model year Lexus vehicles may exhibit odors that naturally occur from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
L-SB-0060-13 Obs
Service Bulletin/Repair Instructions
TSB: February 06, 2020: This bulletin is now obsolete. Please see L-SB-0003-20.
19LE05 - Dealer
Service Bulletin/Repair Instructions
Dealer Package: December 10, 2019 Vehicle total has decreased by approximately 6,260 vehicles. Vehicles were moved from Customer Support Program 19LE05 and added to Limited Service Campaign KLG.
KLG_Dealer Packa
Service Bulletin/Repair Instructions
Dealer Package: 12/10/2019 Vehicle total has increased by approximately 6,260 vehicles. Vehicles were moved from Customer Support Program 19LE05 and added to Limited Service Campaign KLG. The Data Communication Module (DCM) in the subject vehicles are equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use incorrect vehicle coordinates if one of the system?s features is activated.
L-SB-0170-17_Rev
Service Bulletin/Repair Instructions
TSB: REVISION NOTICE December 10, 2019 Rev2: ? The Parts Information and Required Tools & Equipment sections have been updated. November 14, 2018 Rev1: ? The Parts Information and Required Tools & Equipment sections have been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. L-SB-0074-14. ? The Part Information and Required Tools & Equipment, and On-Vehicle Data Navigation Update sections have been updated. Service Bulletin No. L-SB-0074-14 is obsolete and any printed versions should be discarded. Lexus models equipped with the HDD Navigation (EMV-N) system require a Special Service Tool (SST) USB drive to update the map, points of interest, Gracenote®, and system software. The SST is used with all vehicles to deliver the update; however, a unique activation number is required for each vehicle. Activation numbers are provided in an Activation Card Number pamphlet available through the normal parts ordering system. Use the process described in this bulletin to perform the update.
L-SB-0045-19
Service Bulletin/Repair Instructions
TSB: Some 2014 ? 2020 model year GX460 vehicles may exhibit a leak from the front shock absorbers that has been identified by the customer. Improved front shock absorbers have been made available. Please follow the Repair Procedure in this bulletin to address this condition. NOTE The improved shock absorbers may change the ride characteristics of the vehicle and make suspension stiffness more noticeable. Ensure the customer is made aware of this change prior to replacement. If the customer wishes to retain the current ride characteristics, this bulletin does NOT apply.
L-TT-0235-17_Rev
Service Bulletin/Repair Instructions
TT: HVAC drain tube is found to blocked/clogged.
19LE05_Dealer Pa
Service Bulletin/Repair Instructions
Dealer Package: The Data Communication Module (DCM) in the subject vehicles is equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use incorrect vehicle coordinates if one of the system?s features is activated. Note: Lexus has initiated a Limited Service Campaign and a Customer Support Program to resolve this issue related to the Safety Connect system. Both of these programs provide the same free remedy to correct this issue with Safety Connect. Lexus recommends that customers have the free remedy performed before reactivating Safety Connect. Vehicles that had an active Safety Connect subscription on or after 10/1/2017 were included in Limited Service Campaign LSC KLG. Vehicles that did not have an active Safety Connect subscription on or after 10/1/2017 but are affected by this condition are included in this Customer Support Program (19LE05).
19LE05 - Area Le
Service Bulletin/Repair Instructions
Area Letter: The Data Communication Module (DCM) in the subject vehicles is equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use incorrect vehicle coordinates if one of the system?s features is activated. Note: Lexus has initiated a Limited Service Campaign and a Customer Support Program to resolve this issue related to the Safety Connect system. Both of these programs provide the same free remedy to correct this issue with Safety Connect. Lexus recommends that customers have the free remedy performed before reactivating Safety Connect. Vehicles that had an active Safety Connect subscription on or after 10/1/2017 were included in Limited Service Campaign LSC KLG. Vehicles that did not have an active Safety Connect subscription on or after 10/1/2017 but are affected by this condition are included in this Customer Support Program (19LE05).
19LE05 - Region
Service Bulletin/Repair Instructions
Region Email: The Data Communication Module (DCM) in the subject vehicles is equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use incorrect vehicle coordinates if one of the system?s features is activated. Note: Lexus has initiated a Limited Service Campaign and a Customer Support Program to resolve this issue related to the Safety Connect system. Both of these programs provide the same free remedy to correct this issue with Safety Connect. Lexus recommends that customers have the free remedy performed before reactivating Safety Connect. Vehicles that had an active Safety Connect subscription on or after 10/1/2017 were included in Limited Service Campaign LSC KLG. Vehicles that did not have an active Safety Connect subscription on or after 10/1/2017 but are affected by this condition are included in this Customer Support Program (19LE05).
19LE05-KLG - TI-
Service Bulletin/Repair Instructions
Technical Instructions: TECHNICAL INSTRUCTIONS FOR LIMITED SERVICE CAMPAIGN KLG CUSTOMER SUPPORT PROGRAM 19LE05 SAFETY CONNECT SYSTEM ? VEHICLE LOCATION INACCURATE CERTAIN 2011 ? 2017 MODEL YEAR LS, 2013 ? 2016 MODEL YEAR LS Hybrid, 2011 ? 2017 MODEL YEAR GS, 2016 ? 2017 MODEL YEAR GS-F, 2013 ? 2017 MODEL YEAR GS Hybrid, 2010 ? 2017 MODEL YEAR IS, 2011 ? 2015 MODEL YEAR IS-C, 2013 ? 2014 MODEL YEAR IS-F, 2015 ? 2017 MODEL YEAR RC, 2015 ? 2017 MODEL YEAR RC-F, 2011 ? 2017 MODEL YEAR CT, 2010 ? 2017 MODEL YEAR RX, 2010 ? 2017 MODEL YEAR RX Hybrid, 2015 ? 2017 MODEL YEAR NX, 2015 ? 2017 MODEL YEAR NX Hybrid, 2010 ? 2017 MODEL YEAR LX, 2010 ? 2018 MODEL YEAR GX, 2010 ? 2017 MODEL YEAR ES, 2013 ? 2017 MODEL YEAR ES Hybrid Updated 10/17/2019
L-TT-0221-17_Rev
Service Bulletin/Repair Instructions
TT: Some customers may encounter Bluetooth® connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth® failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth® Audio functions are no longer functioning with customer?s phone such as ability to change the track using the steering wheel controls. These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or if they have restored their phone data/settings recently.
KLG - Dealer Pac
Service Bulletin/Repair Instructions
Dealer Package: 10/02/19 KLG: Vehicle applicability for remedy in relation to Safety Connect Subscription. The Data Communication Module (DCM) in the subject vehicles are equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use incorrect vehicle coordinates if one of the system?s features is activated.
KLG_Area Letter_
Service Bulletin/Repair Instructions
Area Letter: The Data Communication Module (DCM) in the subject vehicles are equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use incorrect vehicle coordinates if one of the system?s features is activated.
KLG_Dealer Email
Service Bulletin/Repair Instructions
Dealer Email: The Data Communication Module (DCM) in the subject vehicles are equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use incorrect vehicle coordinates if one of the system?s features is activated.
KLG_Region Email
Service Bulletin/Repair Instructions
Region Email: The Data Communication Module (DCM) in the subject vehicles are equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use incorrect vehicle coordinates if one of the system?s features is activated.
L-SB-0018-14_Rev
Service Bulletin/Repair Instructions
TSB: REVISION NOTICE June 13, 2019 Rev2: ? Applicability has been updated to include 2018 ? 2019 model year Lexus vehicles. March 13, 2017 Rev1: ? Applicability has been updated to include 2015 ? 2017 model year Lexus vehicles. ? The Parts Information section has been updated. Any previous printed versions of this bulletin should be discarded. Some 2007 ? 2019 model year Lexus vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX® Tip) is available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the ARINIX® Tip. Follow the procedures in this bulletin for proper handling and installation of this optional service part. NOTE The ARINIX® Tip is NOT registered or labeled for sale or use outside the United States or Puerto Rico.
L-SB-0084-15_Obs
Service Bulletin/Repair Instructions
TSB: OBSOLETE NOTICE November 30, 2018: This bulletin is no longer applicable and is now obsolete.
L-SB-0041-14-Rev
Service Bulletin/Repair Instructions
TSB: REVISION NOTICE September 5, 2018 Rev1: ? Applicability has been updated to include 2015 ? 2018 model year GX460 vehicles. ? The Production Change Information section has been removed. Any previous printed versions of this bulletin should be discarded. Some 2010 ? 2018 model year GX460 (KDSS-equipped) vehicles may exhibit a condition where the vehicle leans more than 20 mm from left to right when viewed from the rear of the vehicle. Follow the Repair Procedure in this bulletin to address this condition.
L-TT-0221-17Rev1
Service Bulletin/Repair Instructions
Diagnosis of bluetooth connectivity complaints.
L-TT-0218-17_Rev
Service Bulletin/Repair Instructions
TT: This bulletin is regarding best practices when handling navigation systems that use Hard Disc Drive or Micro SD Card memory. 1. First type is generation 6 or 7 which utilizes HDD (Hard Disc Drive). Pioneer models that begin with NXH, have Map Data, Operating System and other Information in the Hard Disc Drive. With this system if a radio is being sent back for an exchange. The original Hard Disc Drive needs to be removed and installed into the newly serviced radio. 2. The Second type is Generation 8 Navigation system which utilizes the Micro SD Card. Pioneer models that begin with NXF, have map data in the Micro SD card. This is a customer accessible Micro SD card which can be found behind the front flip cover. The original Micro SD card should be removed and installed into the newly serviced radio.
L-SB-0021-14_Obs
Service Bulletin/Repair Instructions
TSB: OBSOLETE NOTICE January 22, 2018: This bulletin is now obsolete. Please see L-SB-0001-18.
L-SB-0001-18
Service Bulletin/Repair Instructions
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. L-SB-0021-14. * Applicability has been updated to include applicable 2018 models and 2016 * 2018 model year RC 300 and 2015 * 2018 model year RC 350 vehicles. * Applicability has been updated to exclude 2001 - 2003 model year ES 300 vehicles. Service Bulletin No. L-SB-0021-14 is obsolete and any printed versions should be discarded. Be sure to review the entire content of this bulletin before proceeding. Flash reprogramming allows the Electronic Control Unit (ECU) software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines the use of TIS and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information. NOTE ECU is a Lexus term used to describe integrated computerized devices responsible for managing the operation of a system or subsystem. For the purposes of this bulletin, the term ECU is used as a generic label for the following SAE J1930 standard references: * Powertrain Control Module (PCM) * Engine Control Module (ECM) * Transmission Control Module (TCM) * Any other Lexus-specific control unit
L-SB-0014-16_Rev
Service Bulletin/Repair Instructions
TSB: REVISION NOTICE January 19, 2018 Rev1: ? Applicability has been updated to include 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. The purpose of this Service Bulletin is to elevate awareness and provide best practices for leather care in Lexus vehicles. As an additional resource, if the vehicle is equipped with factory leather seats, the vehicle Owner?s Manual will highlight the importance of proper maintenance and provide guidance for care. NOTE Leather seat covers that are replaced for dye transfer or soiling are NOT eligible for replacement under warranty. Likewise, damage caused by unapproved cleaning methods are NOT eligible for replacement under warranty.
L-TT-0235-17
Service Bulletin/Repair Instructions
TT: HVAC drain tube is found to blocked/clogged.
L-TT-0182-15
Service Bulletin/Repair Instructions
TT: Rev1 iPhone text messages do not appear on multimedia display.
L-TT-0221-17
Service Bulletin/Repair Instructions
This bulletin is regarding the Diagnosis of Bluetooth Connectivity Complaints: Some customers may encounter Bluetooth® connectivity concerns such as: Difficulty to pair the phone. Intermittent Bluetooth® failure to connect to the vehicle when first turning on the vehicle. Various Bluetooth® Audio functions are no longer functioning with customer?s phone such as ability to change the track using the steering wheel controls. These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or if they have restored their phone data/settings recently.
L-SB-0014-08_Rev
Service Bulletin/Repair Instructions
TSB: REVISION NOTICE March 22, 2017 Rev2: ? Applicability has been updated to include 2016-2017 model year Lexus vehicles. ? February 11, 2015 Rev1: Applicability has been updated to include 2006 ? 2015 model year Lexus vehicles. On some vehicles, when Rapgard? is removed, the paint may have a stained appearance. These stains appear to be under the clear coat. The stain patterns are usually under wrinkles in the Rapgard?. These wrinkles sometimes trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces, such as the hood, roof and trunk. Stains can be removed by heating the stained surface to remove the trapped moisture. Use the following procedure to address this condition.
L-SB-0016-15_Rev
Service Bulletin/Repair Instructions
TSB: REVISION NOTICE March 08, 2017 Rev2: ? Applicability has been updated to include 2016-2017 model year GX 460 vehicles, and the Production Change Information and Repair Procedure sections have been updated. Some 2014 - 2017 model year GX 460 vehicles equipped with the 1UR-FE engine may exhibit a MIL ?ON? condition with Diagnostic Trouble Code (DTC) P006A (MAP ? Mass or Volume Air Flow Correlation Bank 1). Some vehicles may also exhibit a rough running engine and light hesitation under acceleration. The condition may be caused by debris in the EGR assembly. Follow the procedures in this bulletin to address this condition.
L-TT-0218-17
Service Bulletin/Repair Instructions
TT: This bulletin is regarding best practices when handling navigation systems that use Hard Disc Drive or Micro SD Card memory.
L-SB-0079-14 Rev
Service Bulletin/Repair Instructions
TSB: REVISION NOTICE November 11, 2016 Rev2: ? The Introduction and the Firmware Update Information sections have been updated.
L-SB-0060-13 Rev
Service Bulletin/Repair Instructions
TSB: REVISION NOTICE November 10, 2016 Rev1: ? Applicability has been updated to include 2015 ? 2017 model year applicable Lexus vehicles. ? The Parts Information section has been updated. Any previous printed versions of this bulletin should be discarded. Some 2006 ? 2017 model year Lexus vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
L-TT-0162-14 Rev
Service Bulletin/Repair Instructions
TT: Some customers may experience Bluetooth disconnections or loss of SMS Text Message Functionality on the navigation/audio system with Android phones OS 4.4 or later. This condition tends to occur to customers who have many previous text messages on their phones.
L-TT-0212-16
Service Bulletin/Repair Instructions
TT: Front Brake Vibration Key Points: * Issue can occur at any time if improper torque is applied on lug nuts * Over time, even one lug nut over or under torqued, can cause a vibration issue * When lug nuts are over torqued, this causes the rotor to have a runout out condition which can lead to brake vibration concerns * Brake vibration issues can occur at parking lot to highway speeds * Brake vibration issues can occur at light to moderate braking * Tightening lug nuts in a star pattern method during the torqueing process will assure that even/equal pressure is applied across the rotor hub surface * Torque sticks/wrenches should be used to apply accurate torque values when tightening * Do Not use impact guns/ratchets to completely run lug nuts up to the wheel surface
L-SB-0084-16
Service Bulletin/Repair Instructions
TSB: Some 2010 - 2015 model year Lexus vehicles with the RES+ accessory may exhibit a condition of not being able to remote start the vehicle through their smart phone application in some areas. The user will receive a mobile device message "Waiting the answer from VIN", indicating the network was unable to connect to their vehicle. The cause of this may be related to the provider's 3G and 4G wireless infrastructure upgrades, resulting in the elimination of 2G network capabilities. Follow the procedures in this bulletin to address this condition.
L-SB-0021-14 Rev
Service Bulletin/Repair Instructions
TSB: Revision Notice: Applicability section has been updated to include 2016-2017 applicable model year Lexus vehicles. The Repair Procedure section, Required Tools & Equipment section, and the Repair Procedure section has been updated. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information.
L-SB-0038-16
Service Bulletin/Repair Instructions
TSB: Some 2014 ? 2016 model year GX 460 vehicles may exhibit a MIL ?ON? condition with Diagnostic Trouble Code (DTC) P2440 (Secondary Air Injection System Switching Valve Stuck Open, Bank 1) or P2442 (Secondary Air Injection System Switching Valve Stuck Open, Bank 2) and under some conditions may enter limp mode (limited throttle input ~ 25mph). This condition can be triggered by sub-freezing ambient temperatures. Follow the Repair Procedure below to address this condition.
L-SB-0032-16
Service Bulletin/Repair Instructions
TSB: Some 2014 ? 2016 Lexus vehicles may exhibit a navigation system rebooting condition. (This condition may be due to an errant data broadcast by Toyota's traffic and weather data service provider.) Follow the process in this bulletin to reset the navigation system.
L-SB-0026-16
Service Bulletin/Repair Instructions
TSB: Some 2014 ? 2016 model year GX460 vehicles may exhibit a MIL "ON" condition with Diagnostic Trouble Code (DTC) P2610 present, indicating an ECM/PCM Engine OFF Timer Performance concern. The Engine Control Module (ECM) logic has been modified to reduce the possibility of this condition. Please follow the Repair Procedure below to address this condition.
L-TT-0204-16
Service Bulletin/Repair Instructions
TT: Multimedia systems reset procedure should be performed when the multimedia system no longer responds or reboots itself.
L-TT-0202-16
Service Bulletin/Repair Instructions
TT: Some customers may experience difficulty programming HomeLink.
L-TT-0198-16
Service Bulletin/Repair Instructions
TT: Certain vehicles may exhibit a leak from the input shaft seal on the transfer case assembly. This leak is typically first identified by gear oil colored fluid collecting at the bottom of the seam between the transmission output and transfer case input mating surfaces.
L-SB-0014-16
Service Bulletin/Repair Instructions
LSB: The purpose of this Technical Service Bulletin is to elevate awareness and provide best practices for leather care in Lexus vehicles. As an additional resource, if the vehicle is equipped with factory leather seats, the vehicle Owner's Manual will highlight the importance of proper maintenance and provide guidance for care.
LSB001416
Service Bulletin/Repair Instructions
Leather Care Best Practices.
L-SB-0020-15 REV
Service Bulletin/Repair Instructions
LSB: WHILE A VEHICLE IS IN INVENTORY, THE BATTERY IS SUBJECT TO CONDITIONS THAT CAN REDUCE ITS PERFORMANCE AND LIFE. BATTERIES CAN BECOME DISCHARGED DUE TO AN EXTENDED STORAGE PERIOD, TEMPERATURE, PARISTIC DRAIN, OR WHILE DEMONSTRATING VEHICLE FEATURES AND BNEFITS IN THE SALES PROCESS. BATTERY INSPECTION AND MAINTENANCE ARE REQUIRED IN ORDER TO ENSURE PROPER OPERATION AND OPTIMAL BATTERY LIFE.
LSB-0020-15 Rev1
Service Bulletin/Repair Instructions
LSB: While a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. Batteries can become discharged due to an extended storage period, temperature, paristic drain, or while demonstrating vehicle features and bnefits in the sales process. Battery inspection and maintenance are required in order to ensure proper operation and optimal battery life.
L-TT-0127-13 REV
Service Bulletin/Repair Instructions
TT: NAVIGATION MICROSD CARD READS AN ERROR WHEN MISSING OR SWAPPED FROM ANOTHER VEHICLE.
L-TT-0127-13 Rev
Service Bulletin/Repair Instructions
TT: Navigation microSD card reads an error when missing or swapped from another vehicle.
L-TT-0121-13 REV
Service Bulletin/Repair Instructions
TT: REFER TO THE CHART BELOW FOR A COMPREHENSIVE LIST OF THE CURRENT AND PREVIOUSLY ISSUED USB SSTS AND THEIR APPLICABILITY. THIS IS ONLY A REFERENCE LIST OF TOOLS THAT MIGHT BE IN DEALERSHIP INVENTORY AND NOT MEANT TO BE A DIAGNOSTIC OR REPAIR PROCEDURE. GENERATION 7 NAVIGATION SYSTEMS USE A USB SST TO UPDATE FIRMWARE AND MAP. GENERATION 8 NAVIGATION SYSTEMS USE A USB STICK TO UPDATE THE FIRMWARE ONLY.
L-TT-0121-13 Rev
Service Bulletin/Repair Instructions
TT: Refer to the chart below for a comprehensive list of the current and previously issued USB SSTs and their applicability. This is only a reference list of tools that might be in dealership inventory and not meant to be a diagnostic or repair procedure. Generation 7 navigation systems use a USB SST to update firmware and map. Generation 8 navigation systems use a USB stick to update the firmware only.
L-TT-0144-13 REV
Service Bulletin/Repair Instructions
TT: SOME CUSTOMERS MAY ENCOUNTER BLUETOOTH CONNECTIVITY CONCERNS SUCH AS: DIFFICULTY TO PAIR THE PHONE. INTERMITTENT BLUETOOTH FAILURE TO CONNECT TO THE VEHICLE WHEN FIRST TURNING ON THE VEHICLE. VARIOUS BLUETOOTH AUDIO FUNCTIONS ARE NO LONGER FUNCTIONING WITH THE CUSTOMER'S PHONE SUCH AS ABILITY TO CHANGE THE TRACK USING THE STEERING WHEEL CONTROLS. THESE CONCERNS CAN BE CAUSED BY CHANGES MADE ON THE CUSTOMER'S PHONE. MAKE SURE TO INQUIRE WITH THE CUSTOMER IF THE CONNECTIVITY CONCERNS OCCURRED AFTER RECEIVING AN OPERATING SYSTEM UPDATE ON THEIR PHONE OR THEY HAVE RESTORED THEIR PHONE DATA/SETTINGS RECENTLY.
L-TT-0144-13 Rev
Service Bulletin/Repair Instructions
TT: Some customers may encounter Bluetooth connectivity concerns such as: Difficulty to pair the phone. Intermittent Bluetooth failure to connect to the vehicle when first turning on the vehicle. Various Bluetooth Audio functions are no longer functioning with the customer's phone such as ability to change the track using the steering wheel controls. These concerns can be caused by changes made on the customer's phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone data/settings recently.
L-TT-0162-14 REV
Service Bulletin/Repair Instructions
TT: SOME CUSTOMERS MAY EXPERIENCE BLUETOOTH DISCONNECTIONS OR LOSS OF SMS TEXT MESSAGE FUNCTIONALITY ON THE NAVIGATION/AUDIO SYSTEM WITH ANDROID PHONES OS 4.4 OR LATER. THIS CONDITION TENDS TO OCCUR TO CUSTOMERS WHO HAVE MANY PREVIOUS TEXT MESSAGES ON THEIR PHONES.
L-SB-0001-14 REV
Service Bulletin/Repair Instructions
LSB: OBSOLETE NOTICE NOVEMBER 9, 2015: THIS BULLETIN IS NOW OBSOLETE. PLEASE SEE L-SB-0079-14
L-SB-0001-14 Rev
Service Bulletin/Repair Instructions
LSB: OBSOLETE NOTICE November 9, 2015: This bulletin is now obsolete. Please see L-SB-0079-14
L-TT-0162-14
Service Bulletin/Repair Instructions
Tech Tip: Some customers may experience Bluetooth disconnections or loss of SMS Text Message Functionality on the navigation/audio system with Android phones running Kitkat 4.4 or later. This condition tends to occur to customers who have many previous text messages on their phones.
L-TT-0100-12 Rev
Service Bulletin/Repair Instructions
TSB: Condition - (A) Some Customers/Technicians may experience a condition where the mirrors adjust to an unexpected position when the transmission is shifted into reverse. (B) Some Customers may experience a condition where the mirrors do not change to the exact previous position in which the customer had set the memory to when the transmission is shifted into reverse.
L-TT-0172-15
Service Bulletin/Repair Instructions
TT: Techstream Health Check Results screen shows "Yes" for a Telematics ECU (DCM) Calibration update regardless of whether a calibration update is available or not. The issue is related to the Techstream software and will be corrected in a future Techstream software release.
L-SB-0022-15
Service Bulletin/Repair Instructions
LSB: Some 2014 ? 2015 model year GX 460 vehicles equipped with the 1UR-FE engine may exhibit a MIL ?ON? condition with Diagnostic Trouble Code (DTC) P006A (MAP ? Mass or Volume Air Flow Correlation Bank 1). Some vehicles may also exhibit the engine running rough and light hesitation under acceleration. The condition may be caused by debris in the EGR assembly. Follow the procedures in this bulletin to address this condition.
L-TT-0184-15
Service Bulletin/Repair Instructions
TT: Some vehicles may experience an intermittenly "tick" or "rattle" noise when over uneven terrain. The noise is typically present when the front passenger seat is empty and will go away when the front passenger seat is removed from the vehicle. Closer investigation may find the noise emanating from the Passenger Side floor sheet metal near one of the spot welds in the floor underneath the front passenger seat.
L-SB-0016-15 Rev
Service Bulletin/Repair Instructions
Some 2014 2015 model year GX 460 vehicles equipped with the 1UR-FE engine may exhibit a MIL ON condition with Diagnostic Trouble Code (DTC) P006A (MAP Mass or Volume Air Flow Correlation Bank 1). Some vehicles may also exhibit the engine running rough and light hesitation under acceleration. The condition may be caused by debris in the EGR assembly. Follow the procedures in this bulletin to address this condition.
L-SB-0025-14
Service Bulletin/Repair Instructions
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.
L-SB-0020-15
Service Bulletin/Repair Instructions
LSB: While a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. Batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating vehicle features and benefits in the sales process. Battery inspection and maintenance are required in order to ensure proper operation and optimal battery life. As described in this bulletin, operating the engine for 30 minutes after 60 days in storage and every 30 days thereafter will help to maintain battery State of Charge (SOC). This process supplements other movements of the vehicle as it is staged, and has specific restrictions on how maintenance is to be done. Also described in this bulletin are 2 other approved methods for maintaining battery State of Charge.
LSB002015
Service Bulletin/Repair Instructions
Battery Maintenance for In-Stock Vehicles.
L-SB-0016-15
Service Bulletin/Repair Instructions
LSB: Some 2014 - 2015 model year GX 460 vehicles equipped with the 1UR-FE engine may exhibit a MIL "ON" condition with Diagnostic Trouble Code (DTC) P006A (MAP - Mass or Volume Air Flow Correlation Bank 1). Some vehicles may also exhibit the engine running rough and light hesitation under acceleration. The condition may be caused by debris in the EGR assembly. Follow the procedures in this bulletin to address this condition.
L-SB-0015-15
Service Bulletin/Repair Instructions
LSB: Some 2010 - 2015 applicable Lexus vehicles equipped with a Remote Engine Starter (RES+) includes CarFinder, a feature which utilizes GPS technology to help locate a customer's vehicle on a map. If a customer has a Carfinder that is inoperative, follow the procedure in this bulletin to address the condition.
L-SB-0015-14 Rev
Service Bulletin/Repair Instructions
LSB: Some 2010 - 2015 model year GX 460 vehicles may exhibit a squeak noise coming from the second row seats when driving over uneven terrain. The bracket for the inside hinge of the 60% second row seat may rub the seat frame. Follow the procedure outlined below to address this condition.
L-TT-0176-15
Service Bulletin/Repair Instructions
TT: Certain vehicles ay exhibit a leak from the input shaft seal on the transfer case assembly. This leak is typically first identified by fluid collecting at the bottom of the seam between the transmission output and transfer case input mating surfaces.
L-SB-0066-11 Rev
Service Bulletin/Repair Instructions
LSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or other compounds that may contaminate electrical contacts, and therefore increase electrical resistance and decrease switch performance. The use of any cleaners or fluids may increase the risk of further damage to electrical components.
L-SB-0014-08 Rev
Service Bulletin/Repair Instructions
LSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat. The stain patterns are usually under wrinkles in the Rapgard. These wrinkles sometimes trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces, such as the hood, roof, and trunk. Stains can be removed by heating the stained surface to remove the trapped moisture. Use the following procedure to address this concern.
L-TT-0164-14 Rev
Service Bulletin/Repair Instructions
TT: Customer complains of various Bluetooth connectivity concerns after upgrading to iOS 8.0X. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed through the audio/navigation system, and the inability to place a hands free phone call using the audio/navigation system.
L-TT-0127-13
Service Bulletin/Repair Instructions
TechTip: Navigation microSD card reads an error when missing or swapped from another vehicle.
LTT012713
Service Bulletin/Repair Instructions
Navigation Micro SD Card Error
L-SB-0025-14 Rev
Service Bulletin/Repair Instructions
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.
L-TT-0121-13
Service Bulletin/Repair Instructions
TT: Refer to the chart below for a comprehensive list of the current and previously issued USB SSTs and their applicability. This is only a reference list of tools that might be in a dealership inventory and not meant to be a diagnostic or repair procedure. Generation 7 navigation systems use a USB SST to update the firmware and map. Generation 8 navigation system models use a USB stick to update the firmware ONLY.
L-TT-0168-14
Service Bulletin/Repair Instructions
Tech Tip: Head unit does not recognize a Multimedia software update file that has been downloaded to a USB flash drive from a Technical Service Bulletin.
L-SB-0007-11 Rev
Service Bulletin/Repair Instructions
TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing washers can cause damage to the torque converter assembly. Use the information in this bulletin when installing an automatic transmission/transaxle assembly.
L-SB-0030-11 Rev
Service Bulletin/Repair Instructions
TSB: The purpose of this bulletin is to provide information regarding transmission and/or park neutral position switch installation. If the manual shift lever is rotated prior to installing the park neutral position switch, the detent spring may become detached from the manual shift lever. Use the information in this bulletin when installing an automatic transmission and/or park neutral position switch assembly.
L-SB-0041-11 Rev
Service Bulletin/Repair Instructions
TSB: OBSOLETE NOTICE-October 16, 2014: This bulletin is now obsolete. Please see L-SB-0082-14.
L-SB-0082-14
Service Bulletin/Repair Instructions
TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL "ON" shifting issues and/or transmission damage. Use the information in this bulletin when installing an automatic transmission/transaxle assembly.
LSB008214
Service Bulletin/Repair Instructions
Auto matic Transmission Replacement kPrecautions
L-TT-0164-14
Service Bulletin/Repair Instructions
Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed through the audio/navigation system, and the inability to place a hands free phone call using the audio/navigation system.
LTT016414
Service Bulletin/Repair Instructions
Bluetooth Connectivity for Apple Devices Upgraded to iOS 8.0.X
L-SB-0079-14
Service Bulletin/Repair Instructions
Navigation System Firmware Update
L-SB-0001-11 Rev
Service Bulletin/Repair Instructions
TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Lexus vehicles requiring its use.
L-SB-0084-08 Rev
Service Bulletin/Repair Instructions
TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
L-SB-0041-14
Service Bulletin/Repair Instructions
TSB: Some 2010 - 2014 model year GX 460 (KDSS equipped) vehicles may exhibit a condition where the vehicle is leaning to the right when being viewed from the rear. The following Repair Procedure has been developed to improve this condition.
L-TT-0142-13
Service Bulletin/Repair Instructions
Tech Tip: Starting with the 2010 Model Year, Lexus began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil, including: Reduced friction and wear on engine surfaces, improved fuel economy, Reduction in waste oil stream (in vehicles approved for 10,000 mile oil change intervals), Reduced maintenance cost (in vehicles approved for 10,000 mile oil change intervals). Due to the improved performance and durability of 0w20 synthetic oil, Lexus has extended the oil change intervals to 10,000 miles for vehicles that require this oil. With this change, the following should be noted: Only Lexus vehicles in which 0w20 oil is mandatory have been approved for the extended oil intervals. Vehicles in which 0w20 is an option to 5w20 (or 5w30) will continue to require 5,000 mile change intervals, even if 0w20 oil is used. In the case of vehicles with 10,000 mile oil change intervals, the 5,000 mile service interval has not been eliminated. The traditional 5,000 maintenance procedures (such as tire rotation) will continue to be required, and the fluid levels (including engine oil) will need to be checked and adjusted at this time. If the vehicle operation meets the standard criteria for "Special Operating Conditions" such as: driving off road, on dirt roads, towing a trailer, making repeated short trips under 32°F, or extensive idling; the engine oil must be replaced at 5,000 mile intervals, regardless of oil specified.
L-TT-0129-13
Service Bulletin/Repair Instructions
Tech Tip: Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields.
LTT012913
Service Bulletin/Repair Instructions
Window and Windshield kProduct Report Tips - Multiple Vehicles
L-TT-0160-14
Service Bulletin/Repair Instructions
Tech Tip: Safety Connect/Lexus Enform is a vehicle feature which requires a subscription fee for the system to be active. The first year of service is provided in a the vehicle purchase price. Once the subscription has lapsed the DCM will be an inactive state. In some instances, a DCM may need to be replaced even though the customer is not using the service.
LTT016014
Service Bulletin/Repair Instructions
DCM Activation is not Applicable when Safety Connect/Lexus enform service has expired
LSB002514A
Service Bulletin/Repair Instructions
Immobilizer and Smart Key Reset
LSB002514B
Service Bulletin/Repair Instructions
Immobilizer and Smart Key Reset
LSB002514
Service Bulletin/Repair Instructions
Immobilizer and Smart Key Reset.
L-SB-0015-10 Rev
Service Bulletin/Repair Instructions
TSB: OBSOLETE NOTICE-June 12, 2014: This bulletin is now obsolete.
L-SB-0021-14
Service Bulletin/Repair Instructions
TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information.
LSB002114
Service Bulletin/Repair Instructions
Techstream ECU Flash Reprogramming Procedure.
L-TT-0158-14
Service Bulletin/Repair Instructions
Tech Tip: Greenhouse Gas Logic (GHG) has been implemented on Toyota A/C Systems to reduce tailpipe emissions. The Federal government issues CAFÉ (Corporate Average Fuel Economy) credits to vehicle manufacturers that implement new technologies that reduce the carbon footprint of the vehicles they produce. GHG Logic technology works by automatically operating the HVAC system in REC mode when certain conditions are met, improving the A/C system cooling efficiency and reducing the vehicle's CO2 tailpipe emissions.
L-SB-0018-14
Service Bulletin/Repair Instructions
TSB: Some vehicles in particular geographic areas may exhibit a condition where the HVAC Evaporator Drain Hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX®Tip) is now available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the ARINIX® Tip. Follow the procedures in this bulletin for proper handling and installation of this optional service part.
L-TT-0122-13
Service Bulletin/Repair Instructions
The front seatback cover may have a loose fit due to damage of the retention clips following removal of the seatback for service.
L-TT-0144-13
Service Bulletin/Repair Instructions
Customers complain of Bluetooth connectivity concerns such as: difficulty to pair the phone. Intermittent Bluetooth failure to connect to the vehicle when first turning on the vehicle. These concerns can be caused by changes made on the customer's phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restore their phone data/settings recently.
L-TT-0111-13
Service Bulletin/Repair Instructions
Lexus vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pre-tensioner devices did not perform as expected (including an unintended deployment event), please follow the steps in the recommendations section below.
L-SB-0001-14
Service Bulletin/Repair Instructions
Some 2014 model year GX 460 vehicles equipped with navigation may exhibit one or more of the following conditions:
L-SB-001-14
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
LSB000114A
Service Bulletin/Repair Instructions
Navigation System Firmware Update.
L-BO-004-05 Obso
Service Bulletin/Repair Instructions
This bulletin is now obsolete. Please see L-SB-0092-13.
L-SB-0092-13
Service Bulletin/Repair Instructions
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
LSB009213B
Service Bulletin/Repair Instructions
Windshield Wiper Blade Maintenance and cleaning
L-SB-0143-11 Rev
Service Bulletin/Repair Instructions
Beginning in 1998, Lexus introduced side airbags as optional equipment. Lexus does NOT recommend replacement of original seat covers with non-Lexus leather or other seat cover materials on vehicles due to the following: Seat covers NOT recommended by Lexus may affect side airbag performance, in general or in part, during an accident. Modifications that negatively affect side airbag performance can result in severe occupant injuries. Seat covers are an integral part of this safety system. Replacing fabric seat covers with non-Lexus leather or other seat cover materials may compromise the effectiveness of this safety system. The design of the seat is complex, integrating safety and strength with comfort and luxury. Lexus strongly discourages modifying original equipment seats that have optional side airbags. Additionally, Lexus strongly advises against the installation or use of aftermarket seat covers, which could impair the performance of the side airbags in the event of an accident.
L-TT-0031-10
Service Bulletin/Repair Instructions
Adhesive & sealant cross reference Information
L-TT-0145-13
Service Bulletin/Repair Instructions
Spots in Window glass
LTT014513
Service Bulletin/Repair Instructions
Spots in Window Glass - vehicle exterior
L-TT-0095-12
Service Bulletin/Repair Instructions
If a customer states there is an unpleasant odor in the vehicle from the HVAC system, there are various factors that may be involved.
L-TT-0141-13
Service Bulletin/Repair Instructions
Some customers may report the following conditions with the Podcast application on iPhones running iOS 7.0 and later: While playing a podcast the system will jump to the next podcast Podcast will intermittently restart at the beginning of the current podcast
LTT014113A
Service Bulletin/Repair Instructions
Intermittent Audio from Podcasts on iPhones Running iOS 7.0
L-TT-0139-13
Service Bulletin/Repair Instructions
Customers using iPhone 4, 4S, 5, 5S, or 5C running iOS 7.0 or later now have the ability to make Facetime Audio calls (no video). When a customer is paired by Bluetooth Hands Free and they make a Facetime Audio call the vehicle radio will treat it as a typical Bluetooth phone call. Because Facetime works differently than a typical phone call, the in-vehicle experience may not meet the customer?s expectations.
L-TT-0140-13
Service Bulletin/Repair Instructions
iTunes Radio is a new feature for iPhone 4, 4S, 5, 5S, and 5C running iOS 7 or later. This feature does work with the in-vehicle audio system either via Bluetooth or by USB cable. Details on how to access this feature are described below.
LTT013913A
Service Bulletin/Repair Instructions
Characteristics of Facetime Audio Calls using - All 2012-2014 My Models
LTT014013A
Service Bulletin/Repair Instructions
How to play itunes radio using the vehicle's Audio System
L-TT-0132-13 Rev
Service Bulletin/Repair Instructions
To receive satellite radio functions after the initial trial period has expired, the customer must enter into a contract with XM Satellite Radio Inc. After entering into a contract, registration of an 8-digit XM Radio ID is required. This 8-digit XM Radio ID is found by turning to channel ?0? of the satellite radio.
LTT013213
Service Bulletin/Repair Instructions
XM Re-Registration with Radio Unit Swap 2010-2014 Models with Satellite Radio
LTT013413A
Service Bulletin/Repair Instructions
When an iPhone is linked to the vehicle through Bluetooth, activation of the microphone on the iPhone will result in the vehicle display showing that an outgoing call is being made.
L-SB-0060-13
Service Bulletin/Repair Instructions
Some 2006 ? 2014 model year Lexus vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
LSB006013A
Service Bulletin/Repair Instructions
HVAC Odor Maintenance
LTT013213A
Service Bulletin/Repair Instructions
XM Re-Registration with Radio Unit Swap 2010-2014 Models with Satellite Radio
LTT012113 1
Service Bulletin/Repair Instructions
Navigation and Audio System Update/ Upgrade USB Directory.
L-SB-0051-13
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
L-SB-0052-13
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
L-SB-0053-13
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
L-SB-0049-13
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
L-SB-0050-13
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
LTT000110A
Service Bulletin/Repair Instructions
Oil Viscosity Applicability and Cfhange Interval Guide
LTT012913A
Service Bulletin/Repair Instructions
Window and Windshield kProduct Report Tips - Multiple Vehicles
L-SB-0024-12 Rev
Service Bulletin/Repair Instructions
During the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires remain on the vehicle in the same location and in the same direction of rotation.
L-SB-0046-11 Rev
Service Bulletin/Repair Instructions
Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage conditions. Long-term storage can affect a vehicle?s systems and components. Any problems that are found should be corrected immediately.
L-SB-0153-11 Rev
Service Bulletin/Repair Instructions
2013 ? 2014 model year vehicles are equipped with driver?s side floor mat retaining clips to secure the floor mat in the correct position. In addition, some models may utilize retaining clips for passenger side and rear seat floor mats as well. Follow the appropriate installation procedure to attach the driver?s side, and if applicable, passenger?s side and rear seat floor mats to the vehicle carpet using the floor mat retaining clips during Pre-Delivery Service (PDS).
L-TT-0001-10
Service Bulletin/Repair Instructions
Starting with the 2010 Model Year, Lexus began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil
LTT000110
Service Bulletin/Repair Instructions
Oil Viscosity Applicability and Cfhange Interval Guide
Safety Connect U
Service Bulletin/Repair Instructions
A recent review of our records indicated that your Safety Connect system is not active and needs to be activated in order for services to work.
L-SB-0090-08 Rev
Service Bulletin/Repair Instructions
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, the source of the noise may be the two windshield stoppers bonded to the top of the windshield or the windshield retainers bonded to the lower edge of the windshield. This bulletin provides the recommended repair procedure to eliminate these types of noises from the windshield area.
L-TT-0116-13
Service Bulletin/Repair Instructions
Navigation/ Multi Info Display Day Mode Operation
Lexus Floor Mat
Service Bulletin/Repair Instructions
In the recent Bi-annual Floor Mat reminder letter distributed November, 2012, Lexus indicated that we were developing support materials that will help remind dealership customers and associates of the importance of proper floor mat usage.
LSB002412
Service Bulletin/Repair Instructions
Tire Positioning Before New Vehicle Delivery
LSB-0143-11
Service Bulletin/Repair Instructions
LEXUS: INFORMATION REGARDING THE SEAT COVER REPLACEMENT, EQUIPPED WITH SIDE AIR BAGS, THE MODIFICATIONS THAT MIGHT NEGATIVELY AFFECT SIDE AIR BAG PERFORMANCE CAN RESULT IN SEVERE INJURIES. *PE
LSB000111
Service Bulletin/Repair Instructions
World Standard Automatic Transmission Fluid