RGTM-26.AF Expl&Aviator
Over The Air
Quality improvements include: -Rear Gate latch calibration update to permit unlatching via the release button when the system has lost position memory and is stuck in a middle-latch position
Vehicle report
2025 LINCOLN AVIATOR
Service bulletins
130 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 55116
Service Bulletin/Repair Instructions
Some of the following vehicles: * 2025-2026 Expedition/Navigator built on or after 02-Feb-2025 * 2025-2026 F-Super Duty built on or after 02-Feb-2025 * 2025-2026 Explorer/Aviator built on or after 02-Feb-2025 * 2025-2026 Nautilus built on or after 17-Feb-2025 * 2025-2026 F-150 built on or after 16-Jul-2025 may exhibit all of the following symptoms: - "No Key Detected" message displayed on the instrument panel cluster (IPC) - Key fob does not work in the backup slot. - Remote keyless entry (RKE) (lock and unlock from the key fob) functionality will work to lock/unlock the vehicle. If the vehicle exhibits these symptoms, manually enter the vehicle identification number (VIN) into the VIN entry dialog in the Ford Diagnosis and Repair System (FDRS) and then start a session using the Vehicle Communication Module (VCM) II, VCM 3, Vehicle Communication and Measurement Module (VCMM) or later level device with a universal serial bus (USB) cable disconnected from the laptop. Download the "BCM - Body Control Module (BCM) Hardware Test" app
SSM 55118
Service Bulletin/Repair Instructions
Some of the following vehicles: * 2023-2025 F-Super Duty built on or before 02-Feb-2025 * 2024-2026 Ranger/Bronco/Mustang * 2024-2025 F-150 built on or before 15-Jul-2025 * 2024-2025 Nautilus built on or before 16-Feb-2025 * 2025 Explorer/Aviator built on or before 01-Feb-2025 may exhibit all of the following symptoms: - "No Key Detected" message displayed on the instrument panel cluster (IPC). - Key fob does not work in the backup slot. - Remote keyless entry (RKE) (lock and unlock from the key fob) functionality will work to lock/unlock the vehicle. If the vehicle exhibits these symptoms, start the vehicle using both key fobs. If the no crank/no start condition with "No Key Detected" concern is present, reprogram both key fobs and retest. If the no crank/no start condition with "No Key Detected" is still present, replace the body control module (BCM). Refer to Workshop Manual (WSM), Section 419-10. For claiming, use causal part 15604 and labor operation MT55118SSM up to 1.8 hours.
PSCM-26.AA Explorer&Aviat
Over The Air
Quality improvements include: -Power Steering Control Module update to prepare the vehicle for a future BlueCruise enhancement
SSM 55087
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles may exhibit a no crank/no start/discharged battery condition due to an intermittent 12V battery drain that occurs only when ambient outdoor temperature is greater than 90°F (32°C). This may be due to the camera module - rear (CMR) keeping the flexible data rate controller area network 3 (FD-CAN3) awake. To correct this condition, download and run the "CMR - Driver Status Monitor Camera Module ÝCMR¨ Software Update" application using the latest software version of the Ford Diagnosis and Repair System (FDRS) scan tool. For claiming, use causal part 3G592 and labor operation MT3G592SSM up to 1.8 hours.
PHX-26.2.0.8 Expl&Aviator
Over The Air
Quality improvements include: -Android system update
TCU-26.2.11.5 Expl & Avia
Over The Air
Quality improvements include: - Connectivity robustness updates
SSM 55031
Service Bulletin/Repair Instructions
Some 2021-2026 Ford/Lincoln vehicles may exhibit various symptoms including but not limited to the auto start/stop system not operating as intended with a "Check Charging System" message in the instrument panel cluster (IPC) while the charging system is operating properly with no charging related diagnostic trouble codes (DTC) stored. This may be due to someone using an aftermarket programmer to change the body control module (BCM) configuration to disable the auto start/stop system or perform other unsupported programming modifications. To correct this condition on F-150 and Bronco vehicles, download and run the Ford Diagnosis and Repair System (FDRS) application titled "BCM-Charging System Configuration Correction". Running this application will determine if the BCM configuration was modified by the customer and if so, provide the option to return the configuration back to factory settings. For other vehicle models exhibiting concerns related to unsupported aftermarket BCM programming, submit a Technical Support Request (TSR) requesting support to revert the BCM configuration
ECG-26.2.11.5 Expl & Avia
Over The Air
Quality improvements include: - Updates the connectivity settings to remove an outdated ePrivacy sub-menu, ensuring all displayed options are active and relevant.
26E04
Emissions
NEW VEHICLE DELIVERY HOLD - Emissions Recall 26E04 Certain 2021-2025 Model Year F-150, Maverick, Mustang, Ranger, Expedition, Bronco Sport, Explorer, Bronco, Navigator, and Aviator Vehicles Powertrain Control Module Software Update
TSB 26-2302
Service Bulletin/Repair Instructions
This bulletin supersedes 26-2150. Reason for update: To remove the M6 nut from the part list and remove the Steps to install the M6 nut from the Service Procedure. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions: * "Steering Assist Fault Service Required" message displayed in the instrument panel cluster (IPC) * Reduced steering assist * Diagnostic trouble codes (DTCs) U3008:1B and/or U3009:1B stored in the power steering control module (PSCM) This may be due to the PSCM ground connections.
SSM 54948
Service Bulletin/Repair Instructions
Some 2025-2026 Explorer/Aviator/Police Interceptor Utility non-hybrid vehicles built on 06-Feb-2025 and through 13-Dec-2025 may exhibit various drivability symptoms including a rough idle or hesitation shortly after refueling. These symptoms may also be accompanied by liquid fuel in the fuel vapor lines and fuel vapor canister as well as an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0133, P0300, P0301, P0302, P0303, P0304, P0305, and/or P0306 stored in the powertrain control module (PCM). This condition may be due to an intermittently sticking fuel level vent valve on the fuel tank allowing fuel to enter the evaporative emissions system lines and evaporative emissions canister during refueling. If the customer states that the drivability symptoms occurred after recently filling the vehicle, replace the fuel tank (9002) and evaporative emissions canister (9D653). Refer to Workshop Manual (WSM), Section 310-01 to replace the fuel tank. Refer to WSM, Section 303-13 to replace the evaporative emission canister. For claiming use causal part 9002 and labor operations 90
SSM 54938
Service Bulletin/Repair Instructions
Some 2025/2026 Aviator vehicles may exhibit a "Door Fault Service Required", "Transmission Not In Park" and/or "Hill Start Assist Not Available" message in the instrument panel cluster (IPC) with diagnostic trouble code (DTC) B1262:92 stored in multiple door latch control modules (DCME, DCMF, DCMG, and/or DCMH). DTC U0504 may also be stored in the gearshift module (GSM). This may be due to the software in the door latch control modules. To correct this condition, download and run the following applications using the latest software level of the Ford Diagnosis and Repair System (FDRS) scan tool. "DCME - Door Control Module E (DCME) Software Update" "DCMF - Door Control Module F (DCMF) Software Update" "DCMG - Door Control Module G (DCMG) Software Update" "DCMH - Door Control Module H (DCMH) Software Update" For claiming use causal part 54219A65 and labor operation MT54219SSM up to 0.5 hours.
SSM 54902
Service Bulletin/Repair Instructions
For 20202026 vehicles equipped with the 10R60 transmission, a new Transmission Clutch Circuit Leak Test has been introduced in the Ford Diagnosis and Repair System (FDRS). This test utilizes the pressure and vacuum transducer (PVT) when available. Workshop Manual (WSM) updates related to this diagnostic procedure are planned for release in Q4 2026. The new test improves the accuracy of detecting leaks within transmission fluid circuits and replaces the previous air check method. The previous air check procedure has been shown to produce a high rate of false positives, which may lead to unnecessary repairs when no actual leak is present. Accordingly, the air check procedure is not to be used for diagnosing internal transmission hydraulic leaks or as justification for transmission replacement.
SSM 54882
Service Bulletin/Repair Instructions
Some 2025-2026 Explorer/Aviator vehicles may exhibit a no crank/no start/discharged battery condition with diagnostic trouble codes (DTC) B144D:29, B144E:29, B1555:29, B1556:29 and/or U3003:16 stored in the rear gate trunk module (RGTM). The power liftgate may also be inoperative. This may be due to water intrusion into the left and/or right power liftgate motors caused by a loose grommet on the electrical harness at the body pass-through. To correct this condition, install a new power liftgate motor corresponding to the DTC(s) set in the RGTM (B144D:29/B144E:29 Ýleft¨ or B1555:29/B1556:29 Ýright¨). To prevent water intrusion into the new liftgate motor, make sure the grommet on the new motor is seated properly by pushing on the grommet at the body pass-through until it clicks into place. For claiming, use causal part 14B351 (Explorer) or 14B350 (Aviator) and labor operations 12651D and 14350AL (left) or 14350AR (right) or 14350AT (both) <br /><br /> If a vehicle with this concern exhibits water intrusion, corrosion, or unseated grommets in or around the liftgate motor, submit a Global Concern Report
SSM 54878
Service Bulletin/Repair Instructions
Some 2024-2026 Nautilus non-hybrid and 2025-2026 Aviator vehicles equipped with 28 radio speakers (minor feature code IDBBN) and 2025-2026 Navigator vehicles may exhibit a no audio/sound condition with no communication with the audio digital signal processing module (DSP) with U0238 stored in the audio control module (ACM). This may be due to the DSP. To determine if the DSP is the root cause, remove the DSP fuse from the battery junction box (BCMC fuse F40 for Aviator, BCMC fuse F138 for Nautilus, BJB fuse F5 for Navigator). Inspect the fuse for an open and make sure the fuse has proper blade contact. After one minute, reinstall the good fuse. If the concern is still present or a fuse concern is found, refer to Workshop Manual (WSM), Section 415-00 for normal diagnostics. If communication has been re-established with the DSP, install a new DSP ordered from Ford Component Sales using the On-Line 1878 form to correct this condition. Refer to Workshop Manual (WSM), Section 415-00. For claiming, use causal part 18B849 and labor operations 12651D and 12651D13.
SSM 54829
Service Bulletin/Repair Instructions
Some 2024-2026 Nautilus and 2025-2026 Explorer/Aviator vehicles equipped with power autofold exterior mirrors may exhibit concerns with the passenger mirror not automatically folding in or out at times, while the driver side mirror automatically folds properly. This may be due to the software in the driver door module (DDM) and passenger door module (PDM). To correct the condition, reprogram the DDM and PDM using the latest software level of the Ford Diagnosis and Repair System (FDRS) scan tool. For claiming, use causal part 14B291 and labor operation MT14B291SSM up to 0.4 hours.
SSM 54827
Service Bulletin/Repair Instructions
Some 2020-2026 Explorer/Police Interceptor Utility/Aviator vehicles may require replacement of the front drive halfshaft inner/outer CV joint boot for various reasons. If Workshop Manual (WSM), Section 205-04 > Diagnosis and Testing leads to CV joint boot replacement, L1MZ-3A331-G (Explorer/Police Interceptor Utility front inner/outer CV joint boot kit), L1MZ-3A331-H (Aviator front inner/outer CV joint boot kit), L1MZ-3A331-F (Explorer/Police Interceptor Utility front inner CV joint boot kit) and L1MZ-3A331-E (Aviator front inner CV joint boot kit) have been released for service. Refer to WSM, Section 205-04 for Removal and Installation procedures.
SSM 54810
Service Bulletin/Repair Instructions
Some 2024-2026 Nautilus non-hybrid and 2025-2026 Aviator vehicles equipped with 28 radio speakers (minor feature code IDBBN) and 2025-2026 Navigator vehicles may exhibit a no audio/sound condition with no communication with the audio digital signal processing module (DSP) with U0238 stored in the audio control module (ACM). This may be due to the DSP. To determine if the DSP is the root cause, remove the DSP fuse from the battery junction box (BCMB fuse F40 for Aviator, BCMB fuse F138 for Nautilus, BJB fuse F5 for Navigator). Inspect the fuse for an open and make sure the fuse has proper blade contact. After one minute, reinstall the good fuse. If the concern is still present or a fuse concern is found, refer to Workshop Manual (WSM), Section 415-00 for normal diagnostics. If communication has been re-established with the DSP, install a new DSP ordered from Ford Component Sales using the On-Line 1878 form to correct this condition. Refer to Workshop Manual (WSM), Section 415-00. For claiming, use causal part 18B849 and labor operations 12651D and 12651D13.
TSB 26-2185
Service Bulletin/Repair Instructions
This bulletin supersedes 25-2621. Reason for update: add 2026 model year vehicles and Transit, update the causal part number (15604), update the Service Procedure, update the service labor operations for 2023 F-Super Duty, and add service labor operations for Transit. Some vehicles listed in the Model statement above may exhibit a no crank/no start condition where the customer cannot start their vehicle. The vehicle may also exhibit a "No Key Detected" message displayed on the instrument panel cluster (IPC), and no key fob works in the back up slot. The remote keyless entry (RKE) functionality will work to lock/unlock the vehicle.
26B08
Other
Certain 2025 Bronco/Ranger and 2025-2026 Explorer/Aviator 4-wheel drive vehicles equipped with a 10R60 transmission. Transmission Replacement
DDM-26.21.5 Aviator
Over The Air
Quality improvements include: -Prevents window bounce backs after using the one touch up feature
SSM 54800
Service Bulletin/Repair Instructions
Some 2025-2026 Explorer/Aviator and 2026 Expedition/Navigator vehicles may exhibit an intermittent inoperative remote start feature using either the key fobs or the Ford/Lincoln App. This may be due to the software in the body control module (BCM). After replicating the concern, use the Ford Diagnosis and Repair System (FDRS) to monitor the RMTSTRT_F_ARB_LST and RMTSTRT_F_TRGT_NM parameter identification (PIDS) in the BCM. If both PID values show "true" in any of the last 5 saved values, engineering is currently working on a solution for this condition that is expected in Q4 2026. Schedule service appointments for customers once the repair becomes available. If either of the BCM PID values do not show "true" in any of the saved values, refer to Workshop Manual (WSM), Section 501-14 Handles, Locks, Latches, Entry Systems > Diagnosis and Testing > Locks, Latches and Entry Systems > Pinpoint Test R (Explorer/Aviator)/Pinpoint Test V (Expedition/Navigator) for normal diagnostics and repair as necessary outside of this article. For claiming, use causal part 15604 and labor operations 12651D and 12651D45
TSB 26-2196
Service Bulletin/Repair Instructions
This bulletin supersedes 26-2100. Reason for update: To update vehicle symptoms, affected vehicle lines, and model years. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Poor speaker sound quality (static, pop, crackle) while using Apple CarPlay® or Bluetooth audio Poor or muffled outbound phone call sound quality while using Apple CarPlay® or Bluetooth audio This may be due to the software in the accessory protocol interface module (APIM).
SSM 54774
Service Bulletin/Repair Instructions
Some 2024-2026 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit an illuminated malfunction indicator (MIL) lamp with engine over-temperature warning in the message center and poor air conditioning (A/C) performance from the engine cooling fan not running. Diagnostic trouble codes (DTC) B3A1B, P0113, P0217, and/or P0480 may be stored in the powertrain control module (PCM). This may be due to poor engine compartment ground connections at G105, G107, G111 and/or G122. Refer to the Wiring Diagram (WD) > Grounds Cell 010 > Pages 2, 3, 7 and 8. Prior to any Workshop Manual (WSM) diagnostics, verify all listed grounds are tightened to 62 lb-in (7 Nm) to resolve this condition. If symptoms or DTCs return after all grounds are tightened, follow normal WSM diagnostics.
PAC-26.3.3 Aviator
Over The Air
Quality improvements include: -Enhanced audio performance
SSM 54760
Service Bulletin/Repair Instructions
2025-2026 Explorer/Aviator vehicles are no longer equipped with light emitting diode (LED) confirmation on the vehicles key fob indicating that the vehicle has remote started (or not remote started). Factory key fobs with remote start no longer contain an LED feedback indicator. Do not replace the key fob for this condition. This is a normal operating characteristic and no service action is necessary.
SSM 54752
Service Bulletin/Repair Instructions
Some 2025-2026 Aviator vehicles equipped with 28 radio speakers (minor feature code IDBBN) may exhibit a no audio/sound condition with no communication with the audio digital signal processing (DSP) module with U0238 stored in the audio control module (ACM). This may be due to the DSP. To determine if the DSP is the root cause, remove the DSP fuse from the battery junction box (BCMB fuse F40). Inspect the fuse for an open and make sure the fuse has proper blade contact. After one minute, reinstall the good fuse. If the concern is still present or a fuse concern is found, refer to Workshop Manual (WSM), Section 415-00 for normal diagnostics. If communication has been re-established with the DSP, install a new DSP ordered from Ford Component Sales using the On-Line 1878 form to correct this condition. For claiming, use causal part 18B849 and labor operations 12651D and 12651D13. <br /><br /> To confirm a vehicle is built with a certain minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System
SSM 54748
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles may exhibit a no crank/no start/discharged battery condition due to an intermittent 12V battery drain that occurs only when ambient outdoor temperature is greater than 90°F (32°C). This may be due to the camera module - rear (CMR) keeping the flexible data rate controller area network 3 (FD-CAN3) awake. To correct this condition, download and run the "CMR - Driver Status Monitor Camera Module ÝCMR¨ Software Update" application using the latest software version of the Ford Diagnosis and Repair System (FDRS) scan tool. For claiming, use causal part 3G592 and labor operations 12651D and 12651D4.
TSB 26-2150
Service Bulletin/Repair Instructions
This TSB supersedes TSB 26-2035. Reason for update: update the Service Procedure to add figures 1, 2, 5 and 6 to clarify the ground location, update Steps (13-15, 21-22), and update the Parts list according to the type of vehicle variant and repair. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions: * "Steering Assist Fault Service Required" message displayed in the instrument panel cluster (IPC) * Reduced steering assist * Diagnostic trouble codes (DTCs) U3008:1B and/or U3009:1B stored in the power steering control module (PSCM) This may be due to the PSCM ground connections.
SSM 54720
Service Bulletin/Repair Instructions
Various 2020-2026 Ford and Lincoln vehicles equipped with blind spot information system (BLIS) may experience an inoperative blind spot monitoring with a "Blind Spot System Fault" message displayed in the instrument panel cluster (IPC). This may also be accompanied by diagnostic trouble codes (DTCs) B118C:11 and/or B118C:15 stored in the driver door module (DDM), and/or B118D:11 and/or B118D:15 stored in the passenger door module (PDM). This may be due to the wiring connector from the mirror to the BLIS module. If diagnostics lead to an internal mirror wiring harness fault, a new lower level BLIS light pigtail is now released for service. It is not necessary to replace the exterior mirror assembly. Use part number SC3Z-14A411-B to resolve the concern.
TSB 25-2422
Service Bulletin/Repair Instructions
This article supersedes TSB 25-2372 to update the vehicle symptoms.
SSM 54655
Service Bulletin/Repair Instructions
Some 2020-2026 Explorer/Police Interceptor Utility/Aviator vehicles may exhibit a concern of inoperative, rattling, crackling and/or distorted sound from one or more speakers (but not all speakers). This may be due to other components located near the suspect speaker. Workshop Manual (WSM), Section 415-00 > Diagnosis and Testing > Pinpoint Test D (2020-2024 Explorer/Police Interceptor Utility, 2025-2026 Aviator) and Pinpoint Test E (2020-2024 Aviator, 2025-2026 Explorer/Police Interceptor Utility) have been updated with additional direction when isolating the cause of the condition.
TSB 26-2100
Service Bulletin/Repair Instructions
This article supersedes TSB 25-2477 to update the Labor Operation Descriptions. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Poor speaker sound quality (static, pop, crackle) while using Bluetooth audio Poor outbound phone call sound quality while using Bluetooth This may be due to the APIM (accessory protocol interface module) software.
SSM 54614
Service Bulletin/Repair Instructions
Some 2020-2024 Explorer vehicles equipped with a 2.3L engine and 2020-2026 Explorer/Police Interceptor Utility/Aviator vehicles equipped with a 3.0/3.3L engine may require various repairs associated with the fuel tank and/or fuel pump and sender unit. Workshop Manual (WSM), Section 310-00 > Removal and Installation for the fuel tank and fuel pump and sender unit have been revised to eliminate the need to remove the driveshaft as part of the service procedure. Labor times have also been updated to reflect this WSM revision.
SSM 54591
Service Bulletin/Repair Instructions
Some 2024-2026 Nautilus non-hybrid and 2025-2026 Aviator/Navigator vehicles equipped with 28 radio speakers (minor feature code IDBBN) may exhibit a no audio/sound condition with no communication with the audio digital signal processing (DSP) module. Remove the DSP fuse from the battery junction box (BCMC) (F40 for Aviator, F5 for Navigator, F138 for Nautilus). Inspect the fuse for an open and ensure the fuse has proper blade contact. After one minute, reinstall the good fuse. If the concern is still present or a fuse concern is found, continue with normal Workshop Manual (WSM) diagnostics, Section 415-00 Information and Entertainment System > General Information > Diagnosis and Testing. If communication has been re-established with the DSP module, engineering is currently working on a solution for this condition that is expected by Q2 2026. Replacement or reprogramming of the DSP will not resolve this condition. Monitor Professional Technician System (PTS) for additional information and schedule service appointments for customers once the repair becomes available. For claiming, use causal part 18B849
SSM 54592
Service Bulletin/Repair Instructions
For 20172026 vehicles equipped with a 10R transmission, a revision to the Road Testing Vehicle procedure has been made in the WSM, located in Section 307-01 > Diagnosis and Testing. This updated procedure improves the diagnosis of customer reported transmission concerns and aids in locating the proper root cause. During diagnosis and testing, details regarding whether the condition is more prevalent when the vehicle is hot or cold, throttle percentage at the time of occurrence, vehicle speed, the specific shift involved, and whether the issue occurs during transmission engagements (N>R, N>D, R>D, or D>R) should be noted. Engineering requests including these detailed operating conditions that will significantly assist with root cause analysis. Diagnosis, testing, and repair should use established labor times outside this article.
SSM 54581
Service Bulletin/Repair Instructions
Some 2024-2026 Nautilus and 2025-2026 Explorer/Aviator vehicles equipped with power folding mirrors may exhibit concerns with the auto folding mirror functionality not matching the status selected by the switch in the center display screen menu. Examples include auto folding not operating when the switch is enabled and/or auto folding continuing to function when the switch is disabled. This may be due to the software in the driver door module (DDM) and passenger door module (PDM). Power folding mirror operation from the physical button is not affected by this condition. Inform customers that engineering is currently working on a solution for this condition that is expected in Q4 2026. Replacement or reprogramming of the accessory protocol interface module (APIM), DDM, or PDM will not resolve this condition. Monitor Professional Technician System (PTS) for additional information and schedule service appointments for customers once the repair becomes available.<br /><br /> If the vehicle exhibits this condition, submit a Vehicle Concern Report. To submit a report, click on the "Submit Global Concern Report"
SSM 54583
Service Bulletin/Repair Instructions
Some 2025-2026 Nautilus/Aviator/Navigator vehicles equipped with the Google Maps Navigation System (minor feature code HKCGA) may experience a blank/white Google map screen, inoperative live traffic data, inoperative voice assistant, the inability to sign into a Google account in the center touch screen, unable to access the Google Play Store in the center display screen, and/or the inability to connect to other apps in the center display screen. This may be due to the vehicles Connectivity Package not being activated. To verify if the vehicle has an active Connectivity Package (free or paid) enter the vehicle identification number (VIN) in Professional Technician System (PTS) then navigate to the upper blue tab titled Connected Vehicle > Vehicle Software Subscriptions. It will clearly state if the vehicle has a trial or paid subscription, along with the expiration date. The customer can check subscription status from the Connected Services tile located within The Lincoln App. These vehicles come with a free Connectivity Package that lasts for 4 years. To activate the free trial period or to subscribe
TSB 25-2621
Service Bulletin/Repair Instructions
Some vehicles listed in the Model statement above may exhibit a no crank/no start condition where the customer cannot start their vehicle. The vehicle may also exhibit a "No Key Detected" message displayed on the instrument panel cluster (IPC), and no key fob works in the back up slot. The remote keyless entry (RKE) functionality will work to lock/unlock the vehicle.
PHX-25.DC Aviator
Over The Air
Quality improvements include: -Enables the Open on Approach feature on the vehicle
SSM 54556
Service Bulletin/Repair Instructions
All 2024-2025 Nautilus and 2025 Explorer/Aviator/Expedition/Navigator vehicles will have the Alexa Built-In feature removed from the vehicle in Q1 2026 due to the end of life of Amazon Alexa services in all Ford/Lincoln Digital Experience vehicles. Google Assistant will continue to be the default voice assistant in these vehicles. No additional actions should be taken in an attempt to restore Alexa Built-In functionality.
TSB 26-2035
Service Bulletin/Repair Instructions
This TSB supersedes TSB 25-2350 to update the Service Procedure, vehicles affected, and parts list. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions: * "Steering Assist Fault Service Required" message displayed in the instrument panel cluster (IPC) * Reduced steering assist * Diagnostic trouble codes (DTCs) U3008:1B and/or U3009:1B stored in the power steering control module (PSCM) This may be due to the PSCM ground connections.
BCM-25.6.0 Aviator
Over The Air
25C33 Recall Remedy: -Removes the global close feature toggle from the vehicle
SSM 54518
Service Bulletin/Repair Instructions
Some 2024-2026 Nautilus, 2025-2026 Explorer/Aviator and 2025 Expedition/Navigator vehicles may exhibit a concern where during an inbound phone call using CarPlay®, the person in the vehicle cannot be heard. This may be due to the software in the accessory protocol interface module (APIM). Replacement or reprogramming of the APIM will not resolve this condition. Inform customers that engineering is currently working on a software solution for this condition and will be released via a software update delivered over-the-air (OTA) expected by April 2026. The software will update automatically if vehicle connectivity is enabled in the vehicle settings. Schedule a service visit for customers who have disabled vehicle connectivity or who report that they did not receive the update by May 2026. Monitor Professional Technician System (PTS) for additional information.
TCU-25.2.8.5 Aviator
Over The Air
Quality improvements include: -Addresses a loss of connectivity caused by a Cellular Domain Service outage
SSM 54502
Service Bulletin/Repair Instructions
Some 2025-2026 Expedition/Navigator/Explorer/Aviator and 2024-2026 Nautilus vehicles equipped with the Google Maps Navigation System (minor feature code HKCGA) may experience a blank screen for Google Maps or the absence of live traffic data. To correct this condition, refer to the Workshop Manual (WSM), Section 415-00 > Diagnosis and Testing > Information and Entertainment System. The WSM has been updated with improved diagnostics for this condition. To confirm whether a vehicle is built with a specific minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left corner of the Professional Technician System (PTS).
ABS-25.AR Aviator
Over The Air
Quality improvements include: -Addresses a false positive Diagnostic Trouble Code due to high sensitivity that may cause a hard brake pedal and some lamps in the cluster. Issue gets resolved in the next key cycle -Addresses key off load battery usage caused by the Electric brake boost staying active
SSM 54452
Service Bulletin/Repair Instructions
Some 2025-2026 Aviator vehicles may exhibit diagnostic trouble code (DTC) U0103:00:80 stored in the powertrain control module (PCM) when a diagnostic self-test is performed. This may be due to a software update delivered via over the air (OTA). If multiple DTCs are present due to other concerns, diagnose those prior to addressing U0103:00:80. If other DTCs are not present, clear DTC U0103:00:80 before following the workshop manual (WSM) DTC diagnostics. If DTC U0103:00:80 does not return after clearing, no further action is required. Return the vehicle to the customer. If DTC U0103:00:80 does return after clearing, proceed with normal diagnostics in the WSM. Ford Engineering is currently developing a software update to resolve this condition. The software update is expected to be released and delivered via OTA in Q2 of 2026. Monitor Professional Technician System (PTS) for additional information.
PHX-25.1.2.5.5 Aviator
Over The Air
25C33 Recall Remedy: -Removes the global close feature toggle from the center screen
25N19
Other
Customer Satisfaction Program 25N19 Certain 2024-2026 Model Year Corsair and Certain 2025-2026 Model Year Explorer and Aviator Vehicles Windshield Replacement
SSM 54430
Service Bulletin/Repair Instructions
Some 2025 Navigator and 2025-2026 Aviator vehicles equipped with 28 radio speakers (minor feature code IDBBN) may exhibit a no audio/sound condition with no communication with the audio digital signal processing (DSP) module. This may be due to the software in the DSP. To determine if it is a software concern, remove the DSP fuse from the battery junction box (BCMC) (F40 for Aviator or F5 for Navigator). Inspect the fuse for an open and ensure the fuse has proper blade contact. After one minute, reinstall the good fuse. If the concern is still present or a fuse concern is found, continue with normal Workshop Manual (WSM) diagnostics, Section 415-00 Information and Entertainment System > General Information > Diagnosis and Testing. If communication has been re-established with the DSP module, engineering is currently working on a solution for this condition that is expected by Q2 2026. Replacement or reprogramming of the DSP will not resolve this condition. Monitor Professional Technician System (PTS) for additional information and schedule service appointments for customers once the repair becomes available
SSM 54399
Service Bulletin/Repair Instructions
Some 2025 Aviator/Explorer/Police Interceptor Utility vehicles may exhibit diagnostic trouble code (DTC) C1110:56 and/or U3000:96 stored in the power steering control module (PSCM) after programming the PSCM, or may display the following message in Ford Diagnosis and Repair System (FDRS) when performing PSCM programmable module installation (PMI): <br /><br /> "It has been detected that a Model Year 2025 Steering Gear (R1MC - level) is fitted to this vehicle. It is not possible to run the Power Steering Control Module (PSCM) Programmable Module Installation (PMI) application on this Steering Gear. If later software is available, this PSCM can be updated by running the PSCM Software Update application."<br /><br /> This may be due to the calibration in the PSCM. When installing a replacement steering gear, make sure the part number begins with prefix "S1MZ". If DTC U3000:96 previously set after programming the PSCM, continue with normal diagnostics outside this article. Refer to Workshop Manual (WSM), Section 211-02 > Diagnosis and Testing. Improvements have been made to the diagnostics for this DTC.
SSM 54360
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles equipped with 28 radio speakers (minor feature code IDBBN) may have previously exhibited at least one of the following error messages in Ford Diagnosis and Repair System (FDRS) while programming the audio digital signal processing module (DSP):<br /><br /> * "Procedure Unsuccessful - ReadDTCs DTCs present: U2101 (Control Module Configuration Incompatible)"<br /> * "Procedure Unsuccessful - ReadDTCs DTCs present: U2100 (Initial Configuration Not Complete)"<br /> * "Procedure Unsuccessful - FlashSoftware Failed to flash RC5T-14C656-BH"<br /> * "ValidateFlashActionDIDsAgainstModule Update was not successful! FAIL - F10A = >>> SHOULD = RC5T-14C656-BH"<br /><br /> For any programming concerns not listed above, continue diagnosis outside this article. Refer to Workshop Manual, Section 418-01A > General Procedures.<br /><br /> This concern may be due to the software in the DSP. To correct this condition, program the DSP using the latest software level of the FDRS scan tool. For claiming, use causal part 18B849 and labor operations 12651D and 12651D4.<br /><br /> To co
ECG-25.2.8.5 Aviator
Over The Air
Quality improvements include: -Enhanced LincolnWay connectivity
SSM 54313
Service Bulletin/Repair Instructions
Some 2020-2025 various Ford and Lincoln vehicles equipped with blind spot information system (BLIS) may experience an inoperative blind spot monitoring with a "Blind Spot System Fault" message displayed in the instrument panel cluster (IPC). This may also be accompanied by diagnostic trouble codes (DTCs) B118C:11 and/or B118C:15 stored in the driver door module (DDM), and/or B118D:11 and/or B118D:15 stored in the passenger door module (PDM). This may be due to the wiring connector from the mirror to the BLIS module. If diagnostics lead to an internal mirror wiring harness fault, a new lower level BLIS light pigtail is now released for service. It is not necessary to replace the exterior mirror assembly. Use part number SC3Z-14A411-B to resolve the concern.
25B52
Other
Customer Satisfaction Program 25B52 Certain 2025 Model Year Explorer and Aviator Missing Audio Tile – Accessory Protocol Interface Module Software Update
TSB 25-2477
Service Bulletin/Repair Instructions
Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Poor speaker sound quality (static, pop, crackle) while using Bluetooth audio Poor outbound phone call sound quality while using Bluetooth This may be due to the APIM (accessory protocol interface module) software.
SSM 54272
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles may exhibit a condition where the rear windows are locked when the child lock is off, and the rear windows are unlocked when the child lock is on. This may be due to the software in the BCM. To correct this condition, download and run the "BCM - Body Control Module (BCM) Software Update" application using the latest version of the Ford Diagnosis and Repair System (FDRS) scan tool. For claiming, use causal part 15604 and labor operations 12651D and 12651D4.
SSM 54273
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles may exhibit approach detection/welcome lighting inoperative. This may be due to the configuration of the BCM with RU5T-14C184-AGY software. To confirm a vehicle is equipped with a certain software level, review the software information by hovering over the "Diagnostics" tab in Professional Technician System (PTS) and selecting "Vehicle Software". For vehicles with RU5T-14C184-AGY software in the BCM, download and run the "BCM - Body Control Module (BCM) Software Update" application using the latest version of the Ford Diagnosis and Repair System (FDRS) scan tool. For vehicles with any other software level in the BCM, refer to Workshop Manual (WSM), Section 501-14 to continue with normal diagnostics outside of this article. For claiming, use causal part 15604 and labor operations 12651D and 12651D4.
SSM 54254
Service Bulletin/Repair Instructions
Some 2025 Explorer/Aviator vehicles may exhibit a condition where the instrument panel cluster (IPC) displays an unexpected Watch the Road warning while using BlueCruise with no diagnostic trouble codes (DTCs) stored related to the driver-assist systems. This may be due to the steering column tilt angle and/or driver seat position (height and backrest angle). Replacing components is not expected to resolve this issue. Optimize driver head position by adjusting the steering column tilt angle and driver seat position (height and backrest angle) to ensure the driver status monitor camera (DSMC) mounted on top of the steering column has a clear view of the drivers entire face from chin to forehead. Provide both Explorer and Aviator customers with a printout of the Lincoln Aviator Owners Manual page titled, Lincoln BlueCruise > How Does BlueCruise Work. The Explorer Owner's Manual is in process of being updated. If the customers symptom persists after the above adjustments have been performed, continue with normal diagnostics found in the Workshop Manual (WSM), Section 419-03B.
SSM 54233
Service Bulletin/Repair Instructions
Some 2025 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit a "Front Camera Fault Service Required" message appearing in the instrument panel cluster (IPC) with diagnostic trouble code (DTC) C1001:31 setting in the image processing module A (IPMA). This may be due to a loose or partial connection at the front windshield camera, connector C9449 on Explorer/Police Interceptor Utility and C9128 on Aviator. Check and verify this connection prior to starting Workshop Manual (WSM) Pinpoint Tests. If the connection is secure, continue with normal diagnostics.
SSM 54227
Service Bulletin/Repair Instructions
Some 2024-2025 Nautilus and 2025 Explorer/Aviator/Expedition/Navigator vehicles equipped with Ford/Lincoln Digital Experience may exhibit a "Map Source Not Available" message on the instrument panel cluster display (IPC) when using Google Maps via Apple CarPlay®. Google Maps does not yet support displaying the navigation map on the IPC within the Apple CarPlay® environment and this is currently the expected behavior. Replacing or reprogramming the accessory protocol interface module (APIM) will not resolve this condition and no diagnosis or repair is necessary. Inform the customer that a future Google Maps update for iPhone is anticipated to enable this functionality. This update will be delivered directly through the Google Maps app on their iPhone and will not require an over the air (OTA) software update or dealership visit.
TSB 25-2421
Service Bulletin/Repair Instructions
This article supersedes TSB 25-2283 to add production cutoff dates. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Inbound call cannot be heard Wireless charger icon inaccurate Auto hold, auto start-stop, and/or defrost button LED indicators inoperative This may be due to the accessory protocol interface module (APIM) software.
PHX-25.1.2.4 Aviator
Over The Air
Quality improvements include: -Introduces In-Vehicle Voice Feedback in Phoenix screen.
SSM 54137
Service Bulletin/Repair Instructions
Various 2021-2025 Ford and Lincoln vehicles equipped with the rear camera on demand feature may exhibit "Please Check Surroundings For Safety" or "Full View Not Available" messages when the rear camera button is pressed and the vehicle is not in reverse. Inform customers this condition is considered normal operation and does not affect vehicle durability because the full rear view camera image can only be shown when the vehicle is in reverse. No additional diagnosis or service is required for this condition.
TSB 25-2372
Service Bulletin/Repair Instructions
This article supersedes TSB 25-2294 to update the vehicle lines affected. Some of the vehicles listed in the Model statement above may exhibit driver assistance feature warning messages displayed in the instrument panel cluster (IPC). Additionally, some modules may store invalid data/lost communication diagnostic trouble codes (DTCs). This may be due to software in the image processing module A (IPMA).
TCU-25.2.8.4 Aviator
Over The Air
Quality improvements include: -Includes a recovery mechanism for memory data in the Telematics Control Unit
TSB 25-2349
Service Bulletin/Repair Instructions
Some of the vehicles listed in the Model statement may exhibit a random BLIS indicator illuminated in the exterior mirror with no vehicle or objects near the vehicle. This may be due to the radar signal echoing off the bumper cover and through the trailer hitch bar. **Additional information for model section** - Space White/Crystal White Metallic Exterior Paint (Paint Code A3)
SSM 54090
Service Bulletin/Repair Instructions
Some 2021-2025 Ford and Lincoln vehicles equipped with SYNC4/Digital Experience may exhibit an unsuccessful telematics control unit module (TCU) software update or software activation during a universal serial bus (USB) update. This may be due to the vehicle connectivity setting being disabled.
TSB 25-2350
Service Bulletin/Repair Instructions
Some of the vehicles listed in the Model statement above may exhibit all of the following conditions: * "Steering Assist Fault Service Required" message displayed in the instrument panel cluster (IPC) * Reduced steering assist * Diagnostic trouble codes (DTCs) U3008 and/or U3009 stored in the power steering control module (PSCM) This may be due to the PSCM ground connections.
SSM 54051
Service Bulletin/Repair Instructions
Some 2024-2025 Nautilus, 2025 Explorer/Aviator/Expedition/Navigator vehicles may occasionally require a hard reset of the Ford/Lincoln Digital Experience system. To perform a hard reset, press and release the volume button on the center console 5 times within 7 seconds. Some vehicles with older level software may require the volume button to be pressed and held for at least 5 seconds. The Owners Manual is in process of being updated with this information.
TSB 25-2294
Service Bulletin/Repair Instructions
Some of the vehicles listed in the Model statement above may exhibit driver assistance feature warning messages displayed in the instrument panel cluster (IPC). Additionally, some modules may store invalid data/lost communication diagnostic trouble codes (DTCs). This may be due to software in the image processing module A (IPMA).
SSM 53993
Service Bulletin/Repair Instructions
Some 2025 Aviator/Navigator vehicles equipped with a 24 channel audio digital signal processing module (DSP) (minor feature code IDBBN) may exhibit a no audio/sound condition with no communication with the DSP. To confirm a vehicle is built with a certain minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System (PTS). This concern may be due to the software in the DSP. To determine if it is a software concern, remove the DSP fuse, F40 for Aviator or F5 for Navigator, and inspect the fuse for an open and make sure the fuse has proper blade contact. After one minute, reinstall the good fuse. If the concern is still present or a fuse concern is found, continue with normal Workshop Manual diagnostics, Section 415-00 Information and Entertainment System > General Information > Diagnosis and Testing. If communication has been re-established with the DSP, reprogram the DSP using the latest software level of the Ford Diagnosis and Repair System (FDRS) scan tool. For claiming, use causal part 18B849
TSB 25-2283
Service Bulletin/Repair Instructions
This article supersedes TSB 25-2157 to add a customer symptom. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Inbound call cannot be heard Wireless charger icon inaccurate Auto hold, auto start-stop, and/or defrost button LED indicators inoperative This may be due to the APIM (accessory protocol interface module) software.
ECG-25.2.8.4.1 Aviator
Over The Air
Quality improvements include: -Robustness action to ensure Diagnostic Trouble Codes are being set correctly. -Prevents a network communication error that may cause an error message in the center screen
SSM 53973
Service Bulletin/Repair Instructions
Some 2021-2024 Edge/Nautilus, 2021-2025 Bronco/Bronco Sport/E-Series/Escape/Corsair/Expedition/Navigator/Explorer/Aviator/F-150/F-Super Duty/Mustang/Ranger, and 2022-2025 Maverick vehicles may require an A/C compressor clutch assembly replacement be performed for various concerns. Workshop Manual (WSM), Section 412-00 Removal and Installation has been updated to eliminate the need to remove and install the A/C compressor to change out the A/C Compressor clutch assembly.
SSM 53895
Service Bulletin/Repair Instructions
2025 Explorer/Police Interceptor Utility non-hybrid vehicles built on or after 05-Mar-2025 and 2025 Aviator vehicles built on or after 24-Apr-2025 are no longer equipped with the passenger side underbody air deflector. The vehicle is not misbuilt. Do not submit a claim for this condition.
SSM 53890
Service Bulletin/Repair Instructions
Some 2024-2025 Nautilus and 2025 Aviator vehicles equipped with a 12 channel DSP (minor feature code IDBAV for Nautilus or IDBBJ for Aviator) may exhibit a no audio/sound concern or programmable module installation (PMI) incomplete on a replacement DSP. To confirm a vehicle is built with a certain minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System (PTS). This concern may be due to software in the DSP. For vehicles with a no sound concern, reprogram the DSP using the latest software level of the Ford Diagnosis and Repair System (FDRS) scan tool. If the no sound concern continues, refer to Workshop Manual, Section 415-00 for further diagnosis. For error messages during PMI of a replacement DSP, attempt PMI again using the latest software level of the FDRS scan tool. For claiming, use causal part 18B849 and labor operations 12651D and 12651D4.
SSM 53880
Service Bulletin/Repair Instructions
Some 2024-2025 Nautilus, 2025 Explorer/Aviator/Expedition/Navigator vehicles may occasionally require a hard reset of the Ford/Lincoln Digital Experience system. To perform a hard reset, press and release the volume button on the center console 5 times within 7 seconds. Some Nautilus vehicles with older level software, may require the volume button to be pressed and held for at least 5 seconds. The Owners Manual is in process of being updated with this information.
SSM 53863
Service Bulletin/Repair Instructions
Some 2025 Explorer/Aviator vehicles may exhibit driver assistance feature warning messages displayed in the instrument panel cluster (IPC). Additionally, some modules may store invalid data/lost communication diagnostic trouble codes (DTCs). The image processing module A (IPMA) should not store these DTCs. This condition may be due to the software in the IPMA causing no communication on the network. To restore communication/function, download and run the "IPMA - Image Processing Module A (IPMA) Recovery" app in the Ford Diagnosis and Repair System (FDRS) tool, then "Trusted Real-Time Operation Network (TRON) Module Authentication" following FDRS screen instructions. Next, download and run the "IPMA - Image Processing Module A (IPMA) Alignment" app, recheck DTCs and confirm that all warning messages are cleared from the IPC. For vehicles equipped with a 360 degree camera, perform the "360 Degree View Camera Alignment" procedure in Workshop Manual (WSM), Section 413-13. If these steps correct the condition, release the vehicle back to the customer.
SSM 53815
Service Bulletin/Repair Instructions
Some 2025 Explorer/Aviator vehicles may exhibit driver assistance feature warning messages displayed in the instrument panel cluster (IPC).
SSM 53764
Service Bulletin/Repair Instructions
Some 2020 Continental, 2020-2024 Edge/Nautilus, 2020-2025 Explorer/Aviator/Escape/Corsair/F-150/F-Super Duty/Ranger/Transit/E-Series, 2021-2025 Bronco, and 2022-2025 Maverick vehicles may require an engine cooling system flush to be performed for various concerns. Workshop Manual (WSM), Section 303-03 has been updated to eliminate the need to remove and install the radiator assembly to perform a radiator flush.
SSM 53759
Service Bulletin/Repair Instructions
After replacement of any TRON module, the gateway module (GWM) and the TRON capable modules can set diagnostic trouble codes (DTCs) U211A, U211B, U211C, U3034, U3035, U3036, U35D9, U35DA and/or U35DB if the secret authentication security keys are not aligned between the modules, a loss of communication is occurring between modules and/or a module is not responding. This may be a result of missing the new module secret authentication security key obtained when running the Ford Diagnosis and Repair System (FDRS) "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure after replacement. When replacing a TRON capable module, run the FDRS "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure in the GWM tool box, not in the toolbox of the module with the DTC's, to distribute a new set of secret authentication security keys to all TRON-capable modules. Using the specific vehicle identification number (VIN), refer to Workshop Manual (WSM), Section 418-00 and 418-01 for updated DTCs, applicable TRON module listings and pinpoint tests.
25L01
Other
Certain 2025 Model Year Aviator Reserve 200A Series Retail Ordered Vehicles - Rear Heated Seat Refund PROGRAM TERMS
SSM 53688
Service Bulletin/Repair Instructions
Some 2024-2025 Aviator vehicles equipped with air suspension may exhibit a drive malfunction and/or suspension fault message in the instrument panel cluster (IPC) with diagnostic trouble codes (DTCs) B1041 and U2100 stored in the suspension control module A (SUMA). This may be due to the SUMA entering diagnostic service mode following suspension system diagnosis or repair. Clear DTCs using FDRS > "SUMA > Transport and Factory Mode Deactivation" function. For other DTCs refer to Workshop Manual (WSM) > Section 204-05 Vehicle Dynamic Suspension for normal diagnostics.
SSM 53678
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles built on or before 17-Feb-2025 may exhibit a harsh suspension feel and Drive Control Fault Service Required message in the instrument panel cluster (IPC) message center with no applicable diagnostic trouble codes (DTCs) present in the vehicle dynamics control module (VDM). This may be due to the software in the VDM. To correct this condition, update the VDM software to the latest level using the Ford Diagnosis and Repair Tool (FDRS) scan tool. For claiming, use causal part 18B008 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
TSB 25-2157
Service Bulletin/Repair Instructions
Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Inbound call cannot be heard Wireless charger icon inaccurate This may be Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Inbound call cannot be heard Wireless charger icon inaccurate This may be due to the APIM (accessory protocol interface module) software due to the APIM (accessory protocol interface module) software.
OTA PCM-24.10.0 Aviator
Over The Air
Quality improvements include: -Addresses a potential false coolant head temperature DTC that triggers an engine warning light
SSM 53638
Service Bulletin/Repair Instructions
After replacement of any TRON module, the gateway module (GWM) and the TRON capable modules can set diagnostic trouble codes (DTCs) U211A, U211B, U211C, U3034, U3035, U3036, U35D9, U35DA and/or U35DB if the secret authentication security keys are not aligned between the modules, a loss of communication is occuring between modules and/or a module is not responding. This may be a result of missing the new module secret authentication security key obtained when running the Ford Diagnosis and Repair System (FDRS) "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure after replacement. When replacing a TRON capable module, run the FDRS "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure to distribute a new set of secret authentication security keys to all TRON-capable modules. Using the specific VIN, refer to Workshop Manual (WSM), Section 418-00 and 418-01 for updated DTCs, applicable TRON module listings and pinpoint tests.
SSM 53569
Service Bulletin/Repair Instructions
Some 2021-2025 Ford and Lincoln vehicles may exhibit diagnostic trouble code (DTCs) U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement.
SSM 53518
Service Bulletin/Repair Instructions
Some 2025 Explorer/Aviator vehicles built on or before 22-Feb-2025 may exhibit a no crank/no start and/or engine shuts off when placed into gear.
SSM 53519
Service Bulletin/Repair Instructions
Some 2020-2025 Explorer/Aviator vehicles equipped with a 3.0L EcoBoost engine may require removal of the left turbocharger oil supply tube due to various concerns.
25B02
Other
Certain 2025 Model Year Aviator and Explorer Vehicles Equipped With a 2.3L or 3.0L GTDI Engine Powertrain Control Module (PCM) Software Update
OTA TCU-25.2.7.5 Aviator
Over The Air
Quality improvements include: -Robustness action to improve connectivity and location dependent features.
24B81
Other
In some of the affected vehicles, customers may experience intermittent functionality of features such as passive entry, welcome lighting, or the hands-free liftgate upon approaching the vehicle while parked.
SSM 53470
Service Bulletin/Repair Instructions
Some 2025 Explorer/Aviator vehicles may exhibit a no crank/no start and/or engine shuts off when placed into gear.
25-OTA BCM-25.3.0 Aviator
Over The Air
Quality improvements include: -Robustness action to ensure the passive entry feature works properly while approaching the vehicle.
OTA ECG-24.2.5.7 Aviator
Over The Air
Quality improvements include: -Enhanced connectivity experience -Enhanced software update performance -Addresses key off load battery drain caused by modules staying awake after key off
SSM 53456
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles may exhibit a harsh suspension feel and Drive Control Fault Service Required message in the instrument panel cluster (IPC) message center with no applicable diagnostic trouble codes (DTCs) present in the vehicle dynamics control module (VDM).
SSM 53377
Service Bulletin/Repair Instructions
Some 2024 Nautilus and 2025 Aviator vehicles equipped with a 24 channel audio digital signal processing module (DSP) (minor feature code IDBBN) may exhibit a no audio/sound condition with no communication with DSP.
SSM 53373
Service Bulletin/Repair Instructions
Some 2020-2025 Aviator vehicles equipped with auto air refresh option (minor feature code G1DAG) may exhibit a buzzing/clicking/humming/ticking sound from the overhead console (OHC) and/or diagnostic trouble code (DTC) P24AE in the heating ventilation and air conditioning (HVAC) module.
SSM 53374
Service Bulletin/Repair Instructions
Some 2025 Explorer/Aviator vehicles may exhibit a concern where it would require gateway module (GWM) replacement.
SSM 53349
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles may display a “Drive control fault service required” message in the IPC message center with no applicable diagnostic trouble codes (DTCs) present in the vehicle dynamics control module (VDM).
SSM 53351
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles built on 11-May-2024 and through 07-Oct-2024 may exhibit an inoperative approach detection illuminated entry function and/or reduced passive entry functionality. This may be due to the body control module (BCM) configuration.
OTA TCU-24.2.5.9 Aviator
Over The Air
Quality improvements include: -Robustness action to improve connectivity and location dependent features.
SSM 53336
Service Bulletin/Repair Instructions
Some 2023-2025 Explorer/Aviator vehicles equipped with the 3.0L EcoBoost engine and up to 15,000 miles (24,140 km) may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P219A (Bank 1 Air-Fuel Ratio Imbalance) and/or P219B (Bank 2 Air-Fuel Ratio Imbalance) stored in the powertrain control module (PCM) with no effect on vehicle operation.
SSM 53305
Service Bulletin/Repair Instructions
Some 2017-2025 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving.
SSM 53289
Service Bulletin/Repair Instructions
Some 2024-2025 Nautilus and 2025 Explorer/Aviator vehicles may exhibit a concern where during an inbound phone call the person in the vehicle cannot be heard.
SSM 53244
Service Bulletin/Repair Instructions
Approach Detection Illuminated Entry Inoperative And/Or Reduced Passive Entry Functionality - Built On 29-Jul-2024 And Through 07-Oct-2024 Some 2025 Aviator vehicles built on 29-Jul-2024 and through 07-Oct-2024 may exhibit an inoperative approach detection illuminated entry function and/or reduced passive entry functionality.
SSM 53150
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles built on 29-Jul-2024 and through 07-Oct-2024 may exhibit inoperative approach detection with reduced passive entry functionality.
TSB 24-2393
Service Bulletin/Repair Instructions
Some 2025 Explorer/Aviator vehicles built on or before 15-Oct-2024 with a 2.3L/3.0L EcoBoost engine may exhibit an engine over-temperature warning displayed in the IPC and an illuminated MIL with DTC P1299 along with P2C38 or P2C39 stored in the PCM.
TSB 24-2331
Service Bulletin/Repair Instructions
Some 2018-2024 F150/Edge, 2018 MKX, 2019-2023 Nautilus, 2020-2025 Explorer/Aviator, 2021-2024 Bronco, and 2024 Ranger vehicles equipped with a 2.7L EcoBoost or a 3.0L EcoBoost engine may exhibit an engine oil leak from the crankshaft rear seal with retaining plate.
SSM 53070
Service Bulletin/Repair Instructions
Some 2023-2025 Explorer/Aviator vehicles may exhibit an inoperative second row single seat easy entry seat fold switch.
SSM 53004
Service Bulletin/Repair Instructions
Some 2024 Nautilus and 2025 Aviator vehicles equipped with a 24 channel audio digital signal processing module (DSP) (minor feature code IDBBN) may exhibit a no audio/sound condition with no communication with DSP. To confirm a vehicle is built with a certain minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System (PTS).
SSM 52967
Service Bulletin/Repair Instructions
Some of the following vehicles may exhibit a condition where the passive key will not program to the vehicles:
SSM 52980
Service Bulletin/Repair Instructions
Some of the following vehicles may exhibit one passive key that is unable to start the vehicle or activate the passive entry feature; however, all remote keyless entry (RKE) physical button functionality works correctly and the second passive key will have full/correct functionality (including being able to start the vehicle):
OTASUECG-24.2.5.6.2 Aviat
Over The Air
Quality Improvements include: - Prevents unintended no-start after OTA update. - Robustness action to prevent fault scenarios where ECG algorithm is draining the battery when vehicle is parked and only during key off events.
SSM 52930
Service Bulletin/Repair Instructions
When removing blue protective film from interior door panels during electronic predelivery inspection (ePDI) on 2025 Aviator vehicles, use a clean soft cloth and locally available 50% isopropyl alcohol to remove adhesive residue.
SSM 52864
Service Bulletin/Repair Instructions
2025 Explorer/Aviator - Remote Start - No LED Confirmation From The Key Fob After A Remote Start Request
SSM 52840
Service Bulletin/Repair Instructions
2024 Nautilus, 2025 Explorer/Aviator - Wireless Charger Icon Inaccurate
SSM 52841
Service Bulletin/Repair Instructions
2025 Explorer/Aviator Built On Or Before 14-Jun-2024, 2024 Nautilus - Map Is Blank Or Map Feature Is Inoperative When Vehicles Equipped with Google Automotive Services (Minor Feature Code HKCGA And IEPAT)
SSM 52832
Service Bulletin/Repair Instructions
Some 2024-2025 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit an illuminated malfunction indicator (MIL) lamp with engine over-temperature warning in the message center and poor air conditioning (A/C) performance from the engine cooling fan not running.
SSM 52823
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles built on 15-May-2024 and through 15-Aug-2024 may exhibit a vehicle vibration felt at 35-80 mph (55-130 km/h) in the steering wheel and/or seat.
SSM 52814
Service Bulletin/Repair Instructions
2025 Explorer/Aviator vehicles equipped with Vapor Blue (Explorer)/Whisper Blue Metallic (Aviator) exterior paint are equipped with a Titanium engine compartment and under hood finish, which may appear to be primer or unfinished.
SSM 52776
Service Bulletin/Repair Instructions
Some 2020-2025 Explorer/Aviator vehicles may have a concern where the second row outboard manual/power seats do not fold, exhibit excess effort to fold, or do not slide forward/backward easily. Power or manual second row seats must be pushed forward manually during easy entry function since the assist spring will reduce but not eliminate manual effort. Refer to the Owner's Manua
SSM 52758
Service Bulletin/Repair Instructions
Some 2025 Aviator vehicles may have diagnostic trouble code (DTC) B1519:13 stored in the door control module E/F/G/H (DCME, DCMF, DCMG and/or DCMH). If this DTC is identified during ePDI or normal diagnostics for various concerns, this DTC does not affect vehicle durability and no additional diagnosis or service is required for this DTC at this time. Inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition that is expected in Q4 2024. Replacement or reprogramming of these modules will not resolve this DTC.
SSM 52759
Service Bulletin/Repair Instructions
Some 2025 Explorer/Aviator/Police Interceptor Utility vehicles may set diagnostic trouble code (DTC) U211B:87 in the headlamp control module (HCM) when a diagnostic self-test is performed. This may be due to a HCM communication error within a specified timeframe. DTC U211B:87 does not affect vehicle durability with no effect on vehicle operation and no additional diagnostics or service is required for this condition at this time. Inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition that is expected in Q3 2024. Replacement or reprogramming of the HCM will not resolve this condition.
SSM 52760
Service Bulletin/Repair Instructions
Some 2024 Nautilus and 2025 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit a symptom where the vehicle's right (passenger) exterior mirror does not come out of the folded position after the vehicle is unlocked. This may be due to a software concern within the driver's door module (DDM) and passenger's door module (PDM). If the mirror unfolds after pressing the mirror fold button in the vehicle twice, inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition that is expected in Q4 2024. Replacement or reprogramming of the DDM and PDM will not resolve this condition at this time.
SSM 52761
Service Bulletin/Repair Instructions
Some 2025 Explorer/Aviator/Police Interceptor vehicles may exhibit a flashing powertrain malfunction (wrench) indicator while in transport mode with diagnostic trouble code (DTC) P112A stored in the powertrain control module (PCM). This may be due to excessive engine starts while the vehicle is in transport mode
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.