Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB 24-2188
Service Bulletin/Repair Instructions
This article supersedes TSB 22-2219 to update the Parts List and Service Procedure to clarify applicable steps by vehicle application. Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.
SSM 51536
Service Bulletin/Repair Instructions
For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
TSB 22-2219
Service Bulletin/Repair Instructions
Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.
TSB 20-2307
Service Bulletin/Repair Instructions
Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure steps to remove and cap the vacuum supply line.
TSB 20-2233
Service Bulletin/Repair Instructions
This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
TSB 19-2026
Service Bulletin/Repair Instructions
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
TSB-08-19-3
Service Bulletin/Repair Instructions
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE
0514
Service Bulletin/Repair Instructions
BRAKE SHUDDER (ROTOR THICKNESS VARIATION) DUE TO THE NEW LOW DUST FRONT BRAKE LINING USED IN PRODUCTION, OR NEW LININGS THAT WERE INSTALLED PER TSB 04-05-02. *TT
06216
Service Bulletin/Repair Instructions
LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT
0637
Service Bulletin/Repair Instructions
LOW TIRE INDICATOR ON - TPMS SYSTEM SENSOR WAKE UP. *TT
06513
Service Bulletin/Repair Instructions
ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE (DTC) PEWEE, P0302, P0303, P0304, P0305, P0306, P0307, P0308, AND P0316. *TT
0652
Service Bulletin/Repair Instructions
HIGH INTENSITY DISCHARGE (HID) - SERVICE FIX. *TT
41711
Service Bulletin/Repair Instructions
HIGH INTENSITY DISCHARGE (HID) HEADLAMPS LEFT HEADLAMP INTERMITTENT OPERATION FLICKER. *EH
041601
Service Bulletin/Repair Instructions
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
0594
Service Bulletin/Repair Instructions
DRIVERS FRONT POWER SEAT WILL NOT MOVE FORWARD OR REARWARD. *TT
05198
Service Bulletin/Repair Instructions
REAR WINDOW WIPER INOPERATIVE. *TT
18815
Service Bulletin/Repair Instructions
A TINY CRACK, OR CRACKS, AROUND THE TRANSFER CASE DRAIN PLUG HOLE. *TT
04105
Service Bulletin/Repair Instructions
AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL. SERVICE TIPS. *TT
042421
Service Bulletin/Repair Instructions
SAFETY BELT RETRACTION SPEED. *TT
051610
Service Bulletin/Repair Instructions
CLUNK/GRIND/THUMP NOISE - FRAME REPAIR PROCEDURE. *TT
18478
Service Bulletin/Repair Instructions
AXLE SEAL LEAKS. *EH
031207
Service Bulletin/Repair Instructions
STEERING WHEEL AT 65 MPH (105 KM/H) OR HIGHER. *TT
05618
Service Bulletin/Repair Instructions
REAR AXLE NOISE REPAIR. *TT
18466
Service Bulletin/Repair Instructions
AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH
18506
Service Bulletin/Repair Instructions
ALUMINUM ALLOY WHEELS PITTING AND OR PEELING CLEANING PROCEDURES. *EH
05310
Service Bulletin/Repair Instructions
SAFETY BELT WEB STOP BUTTON SERVICE. *EH
18398
Service Bulletin/Repair Instructions
A DIAGNOSTIC TROUBLE CODE B2721 (LIFTGATE/DECKLID AJAR OUTPUT SHORT TO GROUND OR OPEN) IN THE POWER LIFTGATE MODULE, WITHOUT ANY ASSOCIATED SYMPTOMS - SERVICE TIP. *TT
18400
Service Bulletin/Repair Instructions
FOUR CORNER LOAD LEVELING AIR SUSPENSION MAY EXHIBIT LEVELING CONCERNS, SUCH AS ONE FRONT CORNER DROPPING. INDIVIDUAL AIR SPRINGS AVAILABLE FOR SERVICE. *TT
18423
Service Bulletin/Repair Instructions
AXLE WHINE HOWL SERVICE WITH INDIVIDUAL PARTS INSTEAD OF AN AXLE ASSEMBLY. *EH
18439
Service Bulletin/Repair Instructions
TINY CRACK OR CRACKS AROUND THE TRANSFER CASE DRAIN PLUG. *EH
050618
Service Bulletin/Repair Instructions
REAR AXLE NOISE REPAIR. *SC
052308
Service Bulletin/Repair Instructions
PARKING AID SYSTEM INOPERATIVE. *AK
052621
Service Bulletin/Repair Instructions
UNINTENDED BRAKE ASSIST. *TT
052624
Service Bulletin/Repair Instructions
VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT
040704
Service Bulletin/Repair Instructions
CLIMATE CONTROLLED SEAT DIAGNOSIS - SERVICE TIPS. *TT
0471
Service Bulletin/Repair Instructions
WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT
04251
Service Bulletin/Repair Instructions
ALUMINUM CORROSION - SERVICE TIP. *TT
041802
Service Bulletin/Repair Instructions
DEPLOYABLE RUNNING BOARDS (DRB) INTERMITTENTLY INOPERATIVE. *TT
04189
Service Bulletin/Repair Instructions
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT
042107
Service Bulletin/Repair Instructions
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
042416
Service Bulletin/Repair Instructions
HEATER HOSE LEAK. *TT
04217
Service Bulletin/Repair Instructions
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
18213
Service Bulletin/Repair Instructions
GRINDING NOISE FROM FRONT AXLE WHEEL HUBS ON ACCELERATION IN 2WD - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 EXPEDITION/NAVIGATOR. *TT
18217
Service Bulletin/Repair Instructions
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT
18228
Service Bulletin/Repair Instructions
TIRE FEATHERING AT LOW MILEAGE. OASIS. VARIOUS MODELS INCLUDING 2005 EXPEDITION. *TT
03198
Service Bulletin/Repair Instructions
CHATTER, SHUDDER, A BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS ON VEHICLES EQUIPPED WITH THE 9.75 INCH OR 8.8 INCH LIMITED SLIP REAR AXLE. *TT
04174
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT
18127
Service Bulletin/Repair Instructions
VARIOUS ELECTRIC CONCERNS. INTERIOR ILLUMINATION, QUARTER WINDOWS, MOONROOF FUNCTION, ACCESSORY DELAY, COURTESY LAMPS, ELECTRO CHROMATIC MIRROR, CLIMATE CONTROLLED SEATS, ELECTRONIC PARK BRAKE RELEASE, FLASHER RELAY, AUDIO SYSTEM, ELECTRONIC HIDDEN ANTENNA MODULE (EHAM), POWER LIFT GATE, AND REAR CLIMATE CONTROL. *TT
18172
Service Bulletin/Repair Instructions
REVERSE SENSING SYSTEM DEFAULTING OFF, SETTING DIAGNOSTIC TROUBLE CODES, OR LOSING COMMUNICATION WITH DIAGNOSTIC SCAN TOOL. *TT
031404
Service Bulletin/Repair Instructions
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
041514
Service Bulletin/Repair Instructions
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT
031501
Service Bulletin/Repair Instructions
INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT
17905
Service Bulletin/Repair Instructions
MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT
04114
Service Bulletin/Repair Instructions
LIFTGATE REVERSING DIRECTION WHEN CLOSING IN HOT AMBIENT TEMPERATURES ABOVE 90 F (32 C). DIAGNOSTIC TROUBLE CODE (DTC) B2825 PRESENT DURING SELF TEST. *TT
17881
Service Bulletin/Repair Instructions
RIDE HEIGHT ISSUES ON AUTOMOBILES WITH AIR SUSPENSION. *TT
17693
Service Bulletin/Repair Instructions
DIAGNOSTIC TROUBLE CODE (DTC) P0320 (IGNITION ENGINE SPEED INPUT CIRCUIT MALFUNCTION). *TT
17698
Service Bulletin/Repair Instructions
POWER RUNNING BOARDS GRINDING, AUTO REVERSING, OR STOPPING MID-WAY WHEN DEPLOYED. *TT
17723
Service Bulletin/Repair Instructions
HIGH INTENSITY DISCHARGE (HID) HEADLAMPS INOPERATIVE IN AUTOLAMP MODE. *TT
17732
Service Bulletin/Repair Instructions
CHECK AIR SUSPENSION MESSAGE WITH DIAGNOSTIC TROUBLE CODE (DTC) C1724, C1873, AND/OR C1889. *TT
17738
Service Bulletin/Repair Instructions
CHARGING SYSTEM WARNING INDICATOR INTERMITTENTLY ON WITH POSSIBLE DIAGNOSTIC TROUBLE CODE (DTC) P0620. *TT
17754
Service Bulletin/Repair Instructions
RETRACTABLE RUNNING BOARDS DO NOT DEPLOY/STOW WITH ENGINE OFF. *TT
17755
Service Bulletin/Repair Instructions
AXLE WHINE AT HIGHWAY SPEEDS (40-60 MPH). *TT
0454
Service Bulletin/Repair Instructions
AIR SUSPENSION COMPRESSOR NOISE. *TT
0457
Service Bulletin/Repair Instructions
POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT
0459
Service Bulletin/Repair Instructions
INTERMITTENT LOSS OF COOLING OR AIRFLOW FROM A/C SYSTEM AT HIGHWAY DRIVES. *TT
0411
Service Bulletin/Repair Instructions
BRAKE DUST - REVISED BRAKE LININGS - VEHICLES BUILT PRIOR TO 12/18/2003. *TT
17598
Service Bulletin/Repair Instructions
REAR AXLE HALFSHAFT SEAL LEAK. *TT
17600
Service Bulletin/Repair Instructions
ENGINE VIBRATION BETWEEN 1100-1330 RPM. *TT
17621
Service Bulletin/Repair Instructions
TIRE PRESSURE MONITORING SYSTEM (TPMS) LOW TIRE OR TIRE VERY LOW MESSAGE AND/OR THE TPMS LIGHT ON. *TT
17632
Service Bulletin/Repair Instructions
AXLE WHINE AT HIGHWAY SPEEDS (40-60 MPH). *TT
17637
Service Bulletin/Repair Instructions
RUNS ROUGH / LACKS POWER / MISFIRE / MALFUNCTION INDICATOR LAMP - LOSS OF COMPRESSION ON VEHICLES WITH OVER 20,000 MILES. *TT
17639
Service Bulletin/Repair Instructions
RIDE HEIGHT ISSUES. *TT
0397
Service Bulletin/Repair Instructions
CLIMATE CONTROLLED SEAT DIAGNOSIS - SERVICE TIPS. *TT *MJ
04149
Service Bulletin/Repair Instructions
DIAGNOSTIC TROUBLE CODE (DTC) P0320 WITH POSSIBLE DRIVEABILITY CONCERNS AND/OR CHARGING SYSTEM WARNING INDICATOR ON WITH POSSIBLE DTC P0620. *TT
04182
Service Bulletin/Repair Instructions
DEPLOYABLE RUNNING BOARDS (DRB) INTERMITTENTLY INOPERATIVE. *TT
17459
Service Bulletin/Repair Instructions
COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW. *TT
17514
Service Bulletin/Repair Instructions
HID HEADLAMPS INOPERATIVE IN AUTOLAMP MODE. *TT
17521
Service Bulletin/Repair Instructions
CLICK/POP/CREAK FROM REAR AXLE. *TT
17411
Service Bulletin/Repair Instructions
TIRE PRESSURE MONITORING SYSTEM (TPMS) MODULE CONFIGURATION - SERVICE TIP. *MJ
17418
Service Bulletin/Repair Instructions
DIAGNOSTIC TROUBLE CODE (DTC) P0320 WITH DRIVEABILITY SYMPTOMS. *MJ
99263
Service Bulletin/Repair Instructions
CORRECT LUG NUT TORQUE SPECIFICATIONS - INCREASE WHEEL NUT AND STUD SIZE - SERVICE TIP. *TT
17316
Service Bulletin/Repair Instructions
FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT
17356
Service Bulletin/Repair Instructions
LOSS OF CLIMATE CONTROL COOLING DURING EXTENDED DRIVING. *TT
17373
Service Bulletin/Repair Instructions
A DIAGNOSTIC TROUBLE CODE (DTC) B2721 (LIFTGATE/DECKLID AJAR OUTPUT SHORT TO GROUND OR OPEN) IN THE POWER LIFTGATE MODULE. *TT
03203
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT
17247
Service Bulletin/Repair Instructions
ACCUMULATION OF BRAKE DUST ON THE WHEELS UNDER REGULATOR DRIVING CONDITIONS. *TT
17249
Service Bulletin/Repair Instructions
RETRACTABLE RUNNING BOARDS DO NOT DEPLOY/RETRACT. *TT
17304
Service Bulletin/Repair Instructions
SEAT CUSHION FOAM DAMAGE/SHREDDING. *TT
03193
Service Bulletin/Repair Instructions
EXCESSIVE MOISTURE IN THE HEADLAMP ASSEMBLY. *TT
03181
Service Bulletin/Repair Instructions
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
17133
Service Bulletin/Repair Instructions
ADVANCETRAC LIGHTING ON WITH DIAGNOSTIC TROUBLE CODE C1277 (STEERING WHEEL ANGLE 1 AND 2 CIRCUIT FAILURE) OR C1278 (STEERING WHEEL ANGLE 1 AND 2 SIGNAL FAULTED) IN THE IVD MODULE. *TT
17136
Service Bulletin/Repair Instructions
RUNS ROUGH/LACKS POWER/MISFIRE - LOSS OF COMPRESSION. *TT
17168
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH ADVANCETRAC STABILITY ASSIST/INTERACTIVE VEHICLE DYNAMICS - IVD) MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE C1998. *TT
17084
Service Bulletin/Repair Instructions
NOISE FROM DOOR CLADDING AT HIGHWAY SPEEDS. *TT
03144
Service Bulletin/Repair Instructions
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
03148
Service Bulletin/Repair Instructions
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
03132
Service Bulletin/Repair Instructions
THIS ARTICLE ADDRESSES THE PROPER PROCEDURE TO CLEAR DIAGNOSTIC TROUBLE CODES C1990 OR C1991 FROM THE VEHICLE DYNAMICS MODULE/4-WHEEL AIR SUSPENSION MODULE. *TT
03134
Service Bulletin/Repair Instructions
ABNORMAL SURFACE RUST ON THE METAL COMPONENTS OF THE 20% AND/OR 40% SECOND-ROW SEATS. *TT
16946
Service Bulletin/Repair Instructions
DIAGNOSTIC TROUBLE CODE C1790 IN AIR SUSPENSION (4WAS/VDM) MODULE. *TT
16975
Service Bulletin/Repair Instructions
STABILITY CONTROL (ADVANCETRAC/IVD) DIAGNOSTIC TROUBLE CODE C1998. *TT
16998
Service Bulletin/Repair Instructions
OPEN FUSE AND LOSS OF BACKLIGHTING IN THE INSTRUMENT CLUSTER. *TT
17001
Service Bulletin/Repair Instructions
ADVANCETRAC MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE C1277 (STEERING WHEEL ANGLE 1 AN 2 CIRCUIT FAILURE) OR C1278 (STEERING WHEEL ANGLE 1 AND 2 SIGNAL FAULTED) IN THE IVD MODULE. *TT
17003
Service Bulletin/Repair Instructions
POWER LIFTGATE AJAR WARNING IN THE MESSAGE CENTER. *TT
17004
Service Bulletin/Repair Instructions
INOPERATIVE POWER LIFTGATE AND RUNNING BOARDS, OR LIFTGATE AJAR MESSAGE, WITH DIAGNOSTIC TROUBLE CODE B1342. BUILT PRIOR TO 11/1/02. *TT
03127
Service Bulletin/Repair Instructions
STEERING WHEEL NIBBLE AT HIGHWAY SPEEDS. VEHICLES PRODUCED BEFORE 6/12/2003 ONLY. *TT
16900
Service Bulletin/Repair Instructions
CLIMATE CONTROLLED (CC) SEAT MAY EXHIBIT PREMATURE SHUTDOWN OF THE CC SEAT WHEN IT IS IN HEAD MODE ON THE SECOND OR SUBSEQUENT HEAT CYCLES. *TT
16923
Service Bulletin/Repair Instructions
CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS. CONCERNS MAY SEEM TO ORIGINATE FROM FRONT AXLE, OR STEERING GEAR. *TT
16926
Service Bulletin/Repair Instructions
STABILITY ASSIST (ADVANCETRAC/IVD) SYSTEMS MAY NOT BE RECALIBRATED PROPERLY USING WDS. *TT
0391
Service Bulletin/Repair Instructions
PROCEDURE TO SEPARATE INBOARD CV JOINT HALFSHAFTS FROM DIFFERENTIAL. *TT
0398
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
16853
Service Bulletin/Repair Instructions
FRONT CALIPER SEEPAGE IN EXTREME TEMPERATURES. ENGINEERING IS INVESTIGATING VIA THE QUICKER SERVICE FIX (QSF). *TT
16854
Service Bulletin/Repair Instructions
FRONT DOOR GLASS MAKING A POPPING NOISE AS IT ENTERS THE HEADER SEAL AT THE TOP OF THE DOOR OPENING AT HIGHWAY SPEEDS. IN THE CASE OF THE NAVIGATOR DRIVER'S DOOR, THE GLASS MAY BOUNCE OFF THE HEADER AND REVERSE TO A MID-POSITION. *TT
16762
Service Bulletin/Repair Instructions
RIDE HEIGHT ANOMALIES ON VEHICLES EQUIPPED WITH AIR SUSPENSION, I.E. FRONT SUSPENSION LOWERING WHILE REAR RISES, DUE TO LEAKING SOLENOIDS.
16806
Service Bulletin/Repair Instructions
FLUID LEAKS FROM THE REAR HALFSHAFT SEAL. 2002-2003 EXPLORER/MOUNTAINEER/AVIATOR ADDED. *TT
0364
Service Bulletin/Repair Instructions
FRONT AXLE GROAN OR HUM, AND/OR A SLIGHT VIBRATION WHEN OPERATED IN 2 HIGH MODE. *TT *JB
16675
Service Bulletin/Repair Instructions
REVERSE TILT-DOWN MIRRORS NOT RETURNING TO THE PRE-REVERSE POSITION AFTER SHIFTING TO REVERSE AND THEN TO DRIVE. *TT *JB
16683
Service Bulletin/Repair Instructions
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
16705
Service Bulletin/Repair Instructions
AIR SUSPENSION DIAGNOSIS. *TT *JB
16726
Service Bulletin/Repair Instructions
FLUID LEAKS FROM THE REAR HALFSHAFT SEAL. *TT *JB
16729
Service Bulletin/Repair Instructions
TRANSMISSION FLUID LEAK BETWEEN THE RADIATOR TRANSMISSION OIL COOLER AND THE TRANSMISSION OIL COOLER FITTING (NOT THE COOLER LINE INTO THE FITTING), WHICH MAY RESULT IN A RESIDUE OF TRANSMISSION FLUID ON THE RADIATOR TANK AROUND THE TRANSMISSION OIL COOLER FITTING. *TT *JB
02208
Service Bulletin/Repair Instructions
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
16297
Service Bulletin/Repair Instructions
MOONROOF WATER LEAK, INOPERATIVE - CONTACT REQUEST IN METRO DETROIT AREA. *TT
16308
Service Bulletin/Repair Instructions
VARIOUS 2003 VEHICLES EQUIPPED WITH PREMIUM CD-6 RADIOS - CD-6 SHUFFLE FEATURE BETWEEN DISCS NOT AVAILABLE. *TT
16309
Service Bulletin/Repair Instructions
HIGH SIDE PRESSURE FLUCTUATIONS ON VEHICLES EQUIPPED WITH A FIXED SCROLL A/C COMPRESSOR. *TT
16336
Service Bulletin/Repair Instructions
DIAGNOSTICS FOR DIAGNOSTIC TROUBLE CODE C1991 IN THE ABS (ANTILOCK BRAKE SYSTEM) MODULE - OMITTED FROM WORKSHOP MANUAL - PROCEDURE PROVIDED. *TT
16366
Service Bulletin/Repair Instructions
A/C EVAPORATOR CORE ICING. *TT
02176
Service Bulletin/Repair Instructions
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
02177
Service Bulletin/Repair Instructions
COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ
16123
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A SERVICE ISSUE WITH THE POWER LIFT GATE OPERATION. ENGINEERING IS INVESTIGATING. *TT
16170
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING TRANSMISSION CONTROL INDICATOR LAMP AND ANY OR ALL TORQUE CONVERTER CLUTCH DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, P1744. *TT
16177
Service Bulletin/Repair Instructions
DIAGNOSTICS FOR DIAGNOSTIC TROUBLE CODE C1440 OMITTED FROM WORKSHOP MANUAL. *TT
16023
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FEATHERING OF THE TREAD EDGES ON NEW TIRES AS RECEIVED FROM THE FACTORY. *TT
16047
Service Bulletin/Repair Instructions
INTERACTIVE VEHICLE DYNBAMICS (IVD) DIAGNOSTIC TROUBLE CODE C1998. *TT
16070
Service Bulletin/Repair Instructions
SOME 4X4S MAY EXHIBIT A FRONT AXLE GROAN OR HUM, AND / OR A SLIGHT VIBRATION WHEN OPERATED IN 2 HIGH MODE. *TT
16075
Service Bulletin/Repair Instructions
DIAGNOSTIC PROCEDURES FOR DIAGNOSTIC TROUBLE CODE C1991 (MODULE CALIBRATION FAILURE) OMITTED FROM THE WORSHOP MANUAL. *TT
16076
Service Bulletin/Repair Instructions
DIAGNOSTICS PROVIDED FOR DIAGNOSTIC TROUBLE CODES C2777 / C2778 (SENSOR CLUSTER CAN BUS FAILURE / SENSOR CLUSTER POWER SUPPLY FAILURE). *TT
16079
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NO-START CONDITION WITH NO FUEL PRESSURE PRESENT AND / OR FUEL PUMP CIRCUIT DIAGNOSTIC TROUBLE CODES P0231 OR P0232. *TT
16083
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CHECK TIRE PRESSURE OR A TIRE LOSING PRESSURE MESSAGE IN THE MESSAGE CENTER. *TT
16085
Service Bulletin/Repair Instructions
SERVICE TIPS ON ON CHECKING FUSES 32, 33 AND 34. *TT
16087
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, AND P1744 (TORQUE CONVERTER CLUTCH). *TT
15951
Service Bulletin/Repair Instructions
THIS SERVICE REMINDER IS IN REFERENCE TO LIFT (JACKING) POINTS. *TT
15937
Service Bulletin/Repair Instructions
INFORMATION ON REPLACING THE LIFTGATE / TRUNK MODULE. *TT
15938
Service Bulletin/Repair Instructions
INFORMATION USED WHEN REPLACING THE DRIVERS SEAT MODULE. *TT
15940
Service Bulletin/Repair Instructions
SUBJECT REGARDING ROOF RACK WIND NOISE. *TT
15809
Service Bulletin/Repair Instructions
INFORMATION ON USING NSG DIAGNOSTIC CARD VERSION 20.1 AND SERVICE CARD VERSION 10.2 WHEN SERVICING. *TT
061510
Service Bulletin/Repair Instructions
AIR SUSPENSION PERFORMANCE - HEIGHT SENSOR LINKAGE ARM DISENGAGING. *KB
062013
Service Bulletin/Repair Instructions
PARKING AID SYSTEM INOPERATIVE - DTC C1983. *KB
062513
Service Bulletin/Repair Instructions
PARKING AID SYSTEM IS INOPERATIVE - DTC C1983. *KB
0749
Service Bulletin/Repair Instructions
HIGH INTENSITY DISCHARGE (HID) HEADLAMPS. *KB