Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
MAS005186 MCL 26-16
We are informing you that tool p/n 900100024 has been updated with an additional component designed to improve the oil seal installation process on V6 Nettuno engines. This added component helps ensure consistent, accurate positioning of the oil seal in its seat by compensating for dimensional gaps and seal tolerances. It also improves process reliability by helping maintain proper installation conditions, even when tool usage is not optimal.
MAS005189 MTB 26-12
MC20 Seat Strap Button Repair Procedure. This bulletin provides guidance to the Service Network on the procedure required to restore the seat strap button on MC20; this procedure avoids replacement of the complete seat.
MAS005111_A MTB 26-06
Maserati Coolant Fluid Color Change. The previous pink coolant and the new purple coolant are fully compatible and may be mixed without affecting coolant quality, performance, or system behavior.
MAS005131 MCL 26-09
Effective immediately! Rapid Update #819 – MC20 BCM SW Update has been temporarily suspended. This decision follows the identification of potential Drive Mode Selector (DSCM) malfunctions observed on some vehicles after the execution of the RU 819 software update, which is currently under in-depth technical investigation by HQ.
MAS005111 MTB 26-05
Maserati Coolant fluid Color Change from pink to purple.
MAS005125 DS 26-07
This Diagnostic Sheet provides updated diagnostic and repair guidance for a potential wheel hub clicking noise condition on M182 Grecale ICE vehicles (all model years). The procedures outlined are intended to assist technicians in accurately identifying and correcting axle shaft and wheel hub related noise concerns that may be present during low‑speed operation, reversing, or initial vehicle launch.
MAS004816_A MTB 26-04
This bulletin outlines the refinishing procedure for restoring the black coating on exhaust tips affected by peeling or flaking paint. This validated process is intended to avoid unnecessary replacement of the entire exhaust silencer assembly
MAS005093 DS 26-05
This diagnosis sheet is issued to provide guidance for the correct troubleshooting of MC20 transmission anomalies and the newly available lower‑level repair options. Gearbox diagnosis
MAS005068 DS 26-03
R1 Radio Restore Procedure After Software Update, MODELS: MY21+ all models equipped with R1 Radio, up to software version U39.19.
MAS005090 RU 26-06
Certain Maserati vehicles + are involved in a Rapid Update to update the Body Control Module (BCM) Software that exhibit a concern related to the Remote Start timer
MAS005005 MCL 26-04
A new software release “Jakarta 10.04.00” is now available for the MD and MDEVO/MDEVO2/MDEVO3. This update brings: • A new user interface for the software update application. • A cybersecurity layer that protects communication with diagnostic and update servers. Once installed, the cybersecurity layer runs in the background. The main change users will notice is how the software update client looks and behaves. To get the new update app, your diagnostic tools must complete installation of Jakarta 10.04.00 or higher.
MAS005035 MTB 26-01
Maserati has created eight new special tools. These tools are mandatory and will be listed in the ModisCS+ Special Tools Catalog. Please also note that this catalog lists all the special tools already in use that are compatible and required for vehicle maintenance. Therefore, it is important to check this section to ensure the tools are available in your workshop.
MAS004937 MCL 25-05
Management and Maintenance of New Maserati In-Stock Vehicles
MAS004995 MTB 25-47
This bulletin provides updated information regarding the serviceability of the in-tank fuel pumps for MC20, GranTurismo, and GranCabrio.
MAS004996 MCL 25-54
This bulletin provides guidance on proper storage practices for Maserati vehicles in dealer inventory to minimize deterioration of premium interior components (leather, wood and carbon fiber).
MAS004912 DS 25-33
This bulletin provides updated diagnostic and repair instructions for identifying and addressing corrosion-related concerns in the low-pressure fuel pump on all Maserati models equipped with internal combustion engines (ICE).
MAS004918 MTB 25-39
The purpose of this communication is to provide a guideline concerning the execution of ECU software updates (ECUs) and to clarify how the EVO checks the availability of software updates for the ECUs installed in the vehicle.
MAS004902 DS 25-32
This bulletin provides updated diagnostic procedures for identifying and resolving issues related to the parking sensor system on select Maserati models. It outlines steps to verify sensor condition, identify false alerts, and determine when replacement or further support is necessary.
MAS004914 MCL 25-51
The Rapid Update campaigns listed in the attachment will be closed according to the following schedule: Field Action LIST – 1° batch Campaign Number Campaign Description Closure Date 517 MCA TBM FOTA update 4.34 SQDF missing data 20/10/2025 529 MC20 MY22 coolant leakage from water pump (idler replacement) 20/10/2025 549 M161 V8 cavo motore L 20/10/2025 576 MC20 Door striker baseplate detachment 20/10/2025 585 MC20 MY22 Half Shafts Replacement 20/10/2025 Field Action LIST – 2° batch Campaign Number Campaign Description Closure Date 643 M240 sbiancamento guarnizione porta 12/12/2025 669 M189 Air Spring check 12/12/2025 684 M189 Leak from Air Spring - Extension 12/12/2025 689 M182 RFHM Repositioning 12/12/2025 705 M240 Tremec transmission leak 12/12/2025 712 M189 M190 MY24 - Air Suspension Full Customer Protection (ALLUMINUM SOL) 12/12/2025 715 M189 Multi-SW Updates Regrouping (BCM-CVPAMPLGM-BSM-ICS-IPC) 12/12/2025 720 M240 DCSD SW Update 12/12/2025 724 M240 ECM SW Update 12/12/2025 725 M189 M190 Multi-HW 12/12/2025 726 M182 Door to body 12/12/2025 727 GC Wrong TBM EMEA-NAFTA 12/12/2025 728 M189 BEV - Front HalfShaft screws loosening 12/12/202
MAS004875 MCL 25-44
The purpose of this communication is to clarify the correct procedure for checking the navigation system map version during Pre-Delivery Inspection (PDI). This ensures that the installed maps correspond to the vehicle’s destination country. MODELS AFFECTED: All Maserati models equipped with the factory navigation system.
MAS004864 MTB 25-33
This bulletin introduces the serviceability of the oil pump bearing on the V6 Nettuno engine. The bearing can now be replaced individually, eliminating the need for complete engine or long block replacement when noise is traced to this component. Models Involved: • Grecale V6 (All MY) • GranTurismo V6 / GranCabrio V6 (All MY) • MC20 / MC20 Cielo / MC20 Pura (All MY)
MAS004868 DS 25-28
This Diagnostic Sheet serves as a guide and provides a diagnostic path to help determine the root cause of certain HVAC concerns. This Diagnostic Sheet requires a BOL to be submitted. MODELS: Grecale, GT/GC, MC20 (All MY) WHEN DEALING WITH HVAC CONCERNS SUCH AS “AC NOT BLOWING COLD,” DO NOT ASSUME IT IS DUE TO LOW REFRIGERANT.
MAS004834 DS 25-27
This document outlines the correct diagnostic and evaluation procedure when oil traces or leakage are observed on front or rear shock absorbers. It aims to help technicians distinguish between acceptable oil sweating and genuine component leakage requiring corrective action. MODELS INVOLVED: ALL (All MY).
MAS004816 MTB 25-30
This bulletin outlines the refinishing procedure for restoring the black coating on exhaust tips affected by peeling or flaking paint. This validated process is intended to avoid unnecessary. replacement of the entire exhaust silencer assembly. Affected Models (All Model Years) - Quattroporte, Ghibli, and Levante – V8 engines only - MC20 Coupé/Cielo (M240) – with black exhaust finish - Grecale (M182) – with black exhaust finish
MAS004772_A MTB 25-26
Carbon ceramic braking system components are subject to wear, particularly under high-performance driving conditions such as track use. Includes GT2 Stradale During aggressive or high-intensity driving on the track, the braking system can reach extremely high temperatures. This may result in: • Braking noise • Vibrations • Reduced braking performance
MAS004789 DS 25-19
This diagnostic sheet is intended to assist technicians in identifying and differentiating engine oil leaks and sweating.
MAS004330 MCL 25-31
The Rapid Updates (Campaigns) in the list below will be closed starting from June 16, 2025. Claims received after this date will no longer be accepted. 243 275 288 294 306 326 332 333 337 348 353 355 364 366 371 374 379 385 388 390 395 400 447 448 449 451 452 460 461 462 468 471 477 481 484 520 522 523 540 544 546 565 566 587 588 593 595 600 603 607 610 611 615 642 10272 10364 10443
MAS004589_A MTB 25-22
This bulletin provides clear instructions on how to perform a proper tightening torque check. Follow this procedure when requested or when analyzing the root cause of a fastener-related issue.
MAS004438_A MTB 25-16
This Technical bulletin serves as a diagnostic guide for managing oil leaks and instructing related repairs. This Bulletin requires a BOL to be opened as “Support Request”
MAS004746 DS 25-17
This Diagnostic Sheet serves as a guide and provides additional diagnostic info for possible door panel anomalies.
MAS004757 DS 25-16
This Diagnostic Sheet serves as a guide and provides a diagnostic path to help determine the root cause of certain HVAC concerns.
MAS004744 MCL 25-27
We have received several reports regarding issues encountered during the execution of FOTA campaign 740, particularly on MC20 vehicles. Initial analysis indicates that these sporadic issues are occurring on vehicles where the final target software has not yet been installed. Please note that some VINs included in CLR 740 require two separate FOTA updates to complete the campaign, as detailed in the VIN list provided in bulletin MAS004603. The second update can only begin after the first update is successfully completed. Additionally, several hours may pass before the second step is automatically triggered. This delay is dependent on vehicle usage and the availability of network coverage.
MAS003730_A MTB 25-17
The purpose of this communication is to provide a guideline concerning the execution of ECU software updates (ECUs) and to clarify how the EVO checks the availability of software updates for the ECUs installed in the vehicle.
MAS004711 MCL 25-25
The Rapid Updates (Campaigns) in the list below will be closed starting from May 12, 2025. Claims received after this date will no longer be accepted. Effective from the publication date of this document, the Mandatory Flag will be removed for all campaigns listed, allowing for easier management as we approach the closure period
MAS004704 MCL 25-24
After 7 years from the introduction of the Maserati Diagnosi EVO 2 (2nd generation), we inform you that Panasonic can no longer guarantee the repair of the hardware, therefore the swap service (Warranty repair/replacement exchange) may be discontinued during 2025 following the exhaustion of replacement components in stock.
MAS004669 MTB 25-13
Wheel Size Vehicle Config Update Info In case of rim replacement, which may involve the use of tires with a different rolling circumference, please note that a Proxy update is always required to adapt the Vehicle Configuration to the new wheel/tire combination fitted to the vehicle. Also remember that the required pressure can be different depending on the size of wheel rims/tires.
MAS004488 MCL 25-15
This document provides general instructions for the storage of new vehicles, including the new GranTurismo. These instructions should be followed by the personnel responsible for managing Maserati vehicles prior to their final sale to customers. The updates pertain to the maintenance and care of MHEV vehicles equipped with lithium-ion batteries, as well as notes on routine maintenance to be conducted according to the Service Schedule (including engine oil). Additionally, new policies for checking the 12V battery state of charge, applicable only to Grecale, are also outlined.
MAS004620 MCL 25-16
MC20 Coupè & Cielo Pre Delivery Inspection (PDI) process and relevant Check Lists
MAS004460 MTB 25-09
This Technical bulletin serves as a guide and provides additional diagnostic info regarding MC20 engine noise characteristics during tip-in/tip-out maneuvers with the accelerator pedal.
MAS004627 MCL 25-18
We are pleased to inform you that a new Tutorship process has been defined that will cooperate directly with the suppliers of the main components of Maserati’s cars to promptly intercept potential issues, reducing diagnosis times and providing maximum assistance and know-how for the resolution of our clients’ cases. Through the direct support of professional technicians, the Aftersales Tutorship Team with the supervision of the HQ Blue on Line Team will be able to carry out detailed diagnosis on reports coming from the network. If an intervention on a component under Tutorship is needed (see Tutorship List attached), you will have to create a Blue on Line as a Support Request. It’s important that you accurately follow the instructions that you will receive and do not replace a component without authorization.
MAS004589 MTB 25-08
This Technical bulletin serves as a guide and provides info with the aim of providing indications about the proper way to perform a tightening torque check, in the case it is needed or requested. In order to allow a proper and effective analysis of the defective route cause.
MAS004578 MTB 25-05
This Technical bulletin serves as a guide and provides info for certain anomalies reported in by customers on seat linings that can be mistakenly addressed as a product defect.
MAS004438 MTB 25-03
This Technical information bulletin serves as a diagnostic guide for managing engine oil leaks and instructing related repairs.
MAS004472 DS 25-01
This Diagnostic Sheet serves as a guide and provides additional diagnostic info for possible anomalies of parking sensors.
MAS004426 MCL 24-56
This communication is intended to provide important information on the serviceability of the Differential Cover O-rings installed on Maserati MC20 coupè and Cielo versions. In case of oil leakage from the Differential Cover, it is now possible to replace only the O-rings instead of the complete gearbox.
MAS004490 MTB 24-30
his Technical bulletin serves as a guideline and outlines requirements when considering a possible engine replacement on Maserati vehicles. Please refer to Bulletin “MAS004175 PNP 24-01 Light Engine - Long Block Repairs Under Warranty” for further information.
MAS004440 MTB 24-37
his Technical bulletin serves as a guide and provides additional diagnostic info for possible DTCs 81151B and 81141B stored in the ORC. MC20 – DTC 81151B, 81141B Right/Left curtain airbag - circuit resistance over the threshold.
MAS004448 MTB 24-36
This bulletin provides additional info for possible front seat movement issues for front seat movement blocked.
MAS004464 MCL 24-51
As an essential component in the electrical system in Maserati vehicles, the battery plays a crucial role in ensuring reliable performance and safety. To help maintain battery peak condition, and ensure optimal performance, this bulletin covers important warranty policies, and guidelines for testing, maintenance, and diagnosis of batteries using the new E-XTEQ MAXIMUS battery charger/tester. Please refer to the most recently published “BOL Policy” and “Prior Approval Components List” to verify if a BOL Report is required for battery replacement.
MAS004434 MCL 24-53
The Rapid Updates (Campaigns) in the list below will be closed starting from November 18, 2024. Claims received after this date will no longer be accepted. Effective from the publication date of this document, the Mandatory Flag will be removed for all campaigns listed, allowing for easier management as we approach the closure period. Campaign Number Campaign Description Closure Date 514 MC20 MY22 Radiator pipe coolant leakage 11.18.2024 550 M157 V6 Engine Harness Position Check 11.18.2024 574 MC20 Interior Handle Replacement 11.18.2024 575 M182 Air suspension Leak Check 11.18.2024 590 MC20 Door Latch Noise 11.18.2024 596 MC20 Cielo PTCM SW Update 11.18.2024 618 M182 - Radio R1H FOTA SW UPDATE (S27.28) 11.18.2024 646 MC20 Side Mirror Check 11.18.2024 649 MC20 Radiator pipe coolant leakage (ext 514) 11.18.2024 655 MC20 AC pipe connection check 11.18.202
MAS004419 MTB 24-35
This technical bulletin provides guidance and additional information on normal shock absorber operations that are often mistakenly identified as defective. It establishes criteria for inspecting and diagnosing shock absorbers for potential leakage to help prevent the unnecessary replacement of non-defective components
MAS004387 MCL 24-48
MC20 Gearbox BOL Process Update. Support for the MC20 gearbox will now be managed in close collaboration with the supplier of the components listed on the following page. This partnership allows us to quickly identify potential issues, reduce diagnostic times, and provide top-tier assistance and expertise to resolve cases efficiently.
MAS003638 BOL 24-27
This Technical bulletin serves as a guide and provides additional diagnostic info for possible BOTH SIDE DOOR anomalies (i.e. High effort in the opening/closing of the doors, noise on uneven roads, etc.)
MAS004296 MCL 24-49
The Rapid Updates (Campaigns) in the list below will be closed starting from July 22, 2024. Claims received after this date will no longer be accepted.
MAS004283 MCL 24-38
MDEVO Release 9.8.1 new features • New login interface • Active diagnosis introduction for Go direct function (only for BEV vehicles) • MY25 version for all vehicles, Hard Reset function (Active Diagnosis), specs update, general improvements.
MAS003820 MTB 24-24
This Technical bulletin serves as a guide and provides additional diagnostic info for possible DTCs 81151B and 81141B stored in the ORC. BOL required. Airbag warning light on and storage in ORC of DTC 81151B Right curtain airbag - circuit resistance over the threshold or 81141B Left curtain airbag - circuit resistance over the threshold.
MAS004226 BOL 24-20
This Diagnostic Sheet serves as a guide and provides additional diagnostic info on how to diagnose possible engine misfires or irregularities, highlighting the importance of refraining from disassembling the Central (Pre-Chamber) spark plugs unless instructed to do so.
MAS003095 MTB 24-21
This Technical bulletin serves as a guide and provides additional diagnostic info for possible steering wheel vibration when braking. This Bulletin serves as an ADDENDUM to MAS002731
MAS003156
Dignostic Sheet.
MAS003821
Technical Information.
MAS003792
Technical Information.
MAS003928
Circular Letter.
MAS003929
Circular Letter.
MAS003793
Circular Letter.
MAS003891
Technical Information.
MAS003844
Diagnostic Sheet.
MAS003895
Technical Information.
MAS003915
Technical Information - for engine warning light ON and DTCs " ?U113F-00 Lost Communication with Active Exhaust Valve 1? stored in the ECM
MAS003449
Diagnostic sheet for the management of complaints of creaking noise coming from the front are of the vehicle during maneuvering.
MAS003436
Rapid Update 589 to restore the correct functionality of the automatic (A) and or manual mode (M) icons next to recirculation icon via the HVAC display page. After the latest version update of the radio software the recirculation mode automatic (A) and manual mode (M) icons may have mistakenly disappeared from the screen display. It is therefore necessary to restore the display by writing a new vehicle configuration (Proxi Alignment).
MAS003118
Service Campaign 494 - to prevent the detachment of the fender bracket seal.
MAS002842
Service Campaign # 430 - For Subroof Water Infilteration.
MAS002832
Engine Warning Light On.
MAS002706
Technical Tips - Maserati Intelligent Assistant factory reset procedure for Model Tear 21 and later vehicles.
MAS002470
Circular Letter - EVO Software update version Falco 6.4.2 reporting issues.
MAS002429
Circular Letter - Firmware Over The Air short introction and finger ready update procedure
MAS002430
Circulaer Letter - Service Campaign 399: Telematics Box Module update via Firmware Over the Air Update
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.