Vehicle report

2010 MCI J4500

Compare every MCI J4500 yearNHTSA and EPA records

Service bulletins

27 bulletins

Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.

TSIB 22-12

Service Bulletin/Repair Instructions

MCI has released Technical Service Information Bulletin (TSIB) 22-12 to address concerns with water ingress in remote switch box. The TSIB provides guidance on how to rework the box to inhibit water intrusion and connector corrosion

TSIB 22-03

Service Bulletin/Repair Instructions

Technical Service Information Bulletin describing the replacement of seating backrest attachment hardware with the addition of a mechanical lock nut on specifically equipped buses manufactured prior to model year 2020.

TSIB 21-01

Service Bulletin/Repair Instructions

This Technical Service Information Bulletin (TSIB) describes an update from Meritor for the bolt torque application requirements on hub-to-rotor bolts for the front, drive and tag axles, on specific coaches equipped with Meritor EX225 disc brakes, on either Conventional, PreSet or Unitized Wheel-End hubs.

SB 3139

Service Bulletin/Repair Instructions

This Service Bulletin provides a checklist of actions to perform on a daily, weekly and monthly basis for parked coaches before they are considered ready for driving.

D20M4

Service Bulletin/Repair Instructions

DDC Field service campaign for GHG17 Detroit DD13 engines requiring software reprogramming and new emission label replacement. This field service applies only to MCI (Motor Coach Industries) vehicles.

SB 3118

Service Bulletin/Repair Instructions

This Service Bulletin informs affected owners of 1997-2013 E4500 and 2001-2015 J4500 model coaches equipped with Rear Axle Steering (RAS) system of the importance of maintaining tag axle caster, and provides the procedure to adjust the caster, if necessary.

SB 3105

Service Bulletin/Repair Instructions

This Service Bulletin informs affected customers to routinely inspect the wheelchair power circuit breaker and cable connections for corrosion every 6,000 miles/9,000 km on model year 2009-2017 MCI J4500 model coaches equipped with a Braun wheelchair lift.

SB 3101

Service Bulletin/Repair Instructions

This Service Bulletin informs affected customers that ZF Friedrichshafen AG has released a Service Information bulletin regarding checking axle hubs and wheel heads if an ABS tell-tale lamp is activated during coach operation on MCI J model coaches, and that immediate action is required in such event to prevent an overheat condition.

SB 3099

Service Bulletin/Repair Instructions

This Service Bulletin informs affected customers of the maintenance procedures for the Torca Accuseal clamp utilized on the connection between the after-treatment system (selective catalyst reduction device) and tailpipe; that the clamp is a one time usage clamp; and that a new clamp must be utilized after any service or maintenance is performed in which the existing clamp was loosened or removed on MCI D and MCI J model coaches.

3087

Service Bulletin/Repair Instructions

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

SB 3088

Service Bulletin/Repair Instructions

This Service Bulletin informs customers that MCI has created a procedure outlining the required steps to clean the fixed radiator on model year 2010-2016 MCI J4500 model coaches.

SB-424

Service Bulletin/Repair Instructions

MOTOR COACH IND.: SOME COACHES NEED TO HAVE THE LUBRICATING OIL FILTER BYPASS VALVE AND FUEL PUMP REPAIRED DUE TO VENDOR'S INSTALLATION. MODEL D, J4500. NO MODEL YEARS LISTED. *PE

SB-3082

Service Bulletin/Repair Instructions

MOTOR COACH IND. (MCI): TO CORRECT AN ACTIVE FAULT CODE (2311), EXPERIENCED IN THE ENGINE, A NEW CALIBRATION ECM IS BEING INSTALLED. *PE

SB-402

Service Bulletin/Repair Instructions

MCI: AN INCORRECT PART FOR APPLICATION FOR DIESEL EXHAUST FLUID (DEF) NOZZLE SUPPLY HOSE AND METERING UNIT FITTING RESULTED IN LEAKING DEF, THE ILLUMINATION OF CHECK ENGINE TELL TALE LIGHT ON INSTRUMENT PANEL AND IF NOT ADDRESSED, ENGINE WOULD INITIATE SHUTDOWN SEQUENCE. MODEL J4500. NO YEARS LISTED. *PE

SB-400

Service Bulletin/Repair Instructions

MCI: AN INCORRECT SENSOR WIRING, FOR DEF TANK LEVEL SENSOR, AT PRODUCTION PLANT CAUSES THE CHECK ENGINE LIGHT TO COME ON AND WOULD NEED TO BE REWIRED. MODEL J4500. NO YEARS LISTED. *PE

SB 3077

Service Bulletin/Repair Instructions

This Service Bulletin informs affected customers that MCI was notified by Shaw Development that the diesel exhaust fluid (DEF) tank cap requires routine cleaning to prevent the potential for crystallization build up at the vent, which may result in potential vacuum issues which could result in collapsing of the tank walls on MCI D model coaches, MCI E4500 model coaches and MCI J4500 model coaches.

SB 3074

Service Bulletin/Repair Instructions

This Service Bulletin informs affected customers of the procedures to replace the existing 2007 EPA Cummins engine harness p-clip, in the event that loom damage or chafing has occurred on model year 2008-2011 MCI E4500 model coaches and model year 2007-2011 MCI J4500 model coaches, and that MCI has a parts kit available for purchase.

SB-390

Service Bulletin/Repair Instructions

MOTOR COACH INC: DRIVE AXLE SUSPENSION SUPPORT STRUCTURE MAY ACCUMULATE WATER CAUSING SUPPORT STRUCTURE DAMAGE DUE TO EXPANSION, IN FREEZING TEMPERATURES, WHILE COACH IS BEING OPERATED. MODELS E4500, J4500. NO MODEL YEARS LISTED. *PE UPDATED 12/10/12. *PE

SB-386

Service Bulletin/Repair Instructions

MCI: ON SOME COACHES, DUE TO AN ABSENCE OF WASHER, THE FAN CLUTCH BRACKET BUSHING MAY WALK OUT OF BRACKET AND ALLOW CLUTCH MISALIGNMENT AND BELT FAILURE. *PE

SB-374

Service Bulletin/Repair Instructions

MCI: THE MANUFACTURING PROCESS OF FAN CLUTCH COOLING RING FINS MAY CAUSE COACHES TO EXPERIENCE MISSING PORTIONS AND/OR STRESS CRACKS. NO MODEL YEARS LISTED. *PE

SB-367

Service Bulletin/Repair Instructions

MOTOR COACH INDUSTRIES: ON SOME COACHES, WATER MAY MIGRATE ONTO/INTO THE TRANSMISSION AND/OR THE FILL TUBE, THROUGH THE BREATHER VENT THAT IS LOCATED ON TOP OF TRANSMISSION. NO MODEL YEARS LISTED. *PE

SB-368

Service Bulletin/Repair Instructions

MOTOR COACH INDUSTRIES: BULLETIN INFORMATION ON SOME MOTOR COACHES, AT A HIGH TEMPERATURE THRESHOLD THAT THE DRIVE AXLE WHEEL HUB COVER WOULD BECOME DETACHED DURING THE OPERATION OF THE MOTOR COACH. NO MODEL YEARS LISTED. *PE

SB-3066

Service Bulletin/Repair Instructions

MOTOR COACH INC: BULLETIN PERTAINING TO THE REVISED REPLACEMENT DIRECTIONAL/SIDE MARKER LIGHTS. TO ELIMINATE POTENTIAL CRACKS THAT RESULT IN WATER INTRUSION, REVISED LIGHTS FOAM BACKING WAS REMOVED BETWEEN MARKER LIGHT AND COACH BODY. *PE

SB-357

Service Bulletin/Repair Instructions

MOTOR COACH INDUDSTRIES: INFORMATION ON REPLACING THE COOLANT PUMP THAT MAY HAVE A PROBLEM. *RM

354

Service Bulletin/Repair Instructions

MOTOR COACH INDUSTRIES SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THERE MAY BE A HARSH DOWNSHIFT, RPM FLARE, OR THE TRANSMISSION MAY LOCK. *RM

3053

Service Bulletin/Repair Instructions

MOTOR COACH INDUSTRIES: THERE WAS TRANSMISSION SHIELD INTERFERENCE BY THE ACTUATOR HARNESS. *RM

SB-3043

Service Bulletin/Repair Instructions

MCI: TAG UNLOAD VALVE ASSEMBLY. EFFECTIVE WITH UNIT NUMBER 65614, MCI HAS MADE DESIGN CHANGES TO THE TAG UNLOAD VALVE ASSEMBLY INSTALLATION ON SOME MODEL COACHES. THE LONGER LIFE VALVES WILL IMPROVE THE DURABILITY OF THE TAG UNLOAD VALVE ASSEMBLY. MODELS E4500/J4500 SERIES. NO MODEL YEARS LISTED. *PE

Reading this report

Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.