Sprinter Weekly
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
Vehicle report
2011 MERCEDES BENZ SPRINTER
Service bulletins
14 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
LI14.40-N-061091
Service Bulletin/Repair Instructions
Check engine light on with one or more of the following DTCs P18B800, P18B900
LI-47-25N057148
Service Bulletin/Repair Instructions
XENTRY (MERCEDES): ON SOME VEHICLES, UNDER THE ENGINE COVER, THE FUEL HOSE IS LEAKING DUE TO BEING CHAFED AND WOULD NEEDS TO BE REPLACE AND RECONNECT OTHER LINE WITH HOSE BRACKET. MODEL 906 (SPRINTER). *PE
SC-2012120002
Service Bulletin/Repair Instructions
MERCEDES: THE ENGINE CONTROL MODULE (ECM) MAY FAIL FROM FEEDBACK SIGNAL TO VALVE DUE TO HUMIDITY ENTERING EXHAUST GAS RECIRCULATION (EGR) VALVE, CAUSING AN ELECTRICAL SHORT CIRCUIT AND SOFTWARE NEEDS UPDATING. MODEL 2010-2011 906. *PE UPDATED ON 7/11/2013. *KB UPDATED 11/21/13. *PE
LI-27-60-N048766
Service Bulletin/Repair Instructions
XENTRY (MERCEDES): DUE TO FAULT 0002, UNDERVOLTAGE, IN ESM CONTROL UNIT, TRUCK AUTOMATIC TRANSMISSION WOULD ENTER LIMP HOME MODE. MODEL SPRINTER (906). NO MODEL YEAR. *PE
LI27-60N048889
Service Bulletin/Repair Instructions
XENTRY (MERCEDES): SOME TRUCKS MAY EXPERIENCE A NO POWER FLOW AT SELECTOR LEVER POSITION D OR R, WHEN GEAR RANGE IS NOT ABLE TO ENGAGE DUE TO INCORRECTLY ADJUSTED SHIFT CABLE AND SHIFT CABLE NOT ENGAGING AT TRANSMISSION ABUTMENT. MODEL 906 (SPRINTER). NO MODEL YEARS. *PE
VB-47-25-02
Service Bulletin/Repair Instructions
SPRINTER: WHEN CHANGING THE FUEL FILTER, IMPROPER DISASSEMBLY OF LOW PRESSURE FUEL HOSES ON FUEL FILTER WILL BE DAMAGED DUE TO INSERTING SHARP EDGED TOOL BETWEEN HOSE AND FITTING. ALL YEAR MODEL 906 WITH ENGINE 642. *PE
SC-2013040002
Service Bulletin/Repair Instructions
MERCEDES: RADIO REMOTE RECEIVER FOR THE AUXILLIARY HEATER IS OPERATING ON AN UNAPPROVED RADIO FREQUENCY. RADIO REMOTE AND RECEIVER NEED TO BE REPLACED. MODEL 906 YEARS 2007-2011. *KB
LI-27-60
Service Bulletin/Repair Instructions
XENTRY (MERCEDES): ON SOME VEHICLES, AUTOMATIC TRANSMISSION ENTERS A LIMP HOME MODE DUE TO FAULT UNDER VOLTAGE IN ESM CONTROL UNIT. MODEL SPRINTER. NO MODEL YEARS LISTED. *PE
V-B-00.00/02A
Service Bulletin/Repair Instructions
MERCEDES (SPRINTER): SOFTWARE RETROFIT PROCESS. ALL MODEL YEARS. *KB
V-B-47.10/01A
Service Bulletin/Repair Instructions
MERCEDES (SPRINTER): PROCEDURE FOR WHEN DIESEL FUEL TANK IS FILLED WITH INCORRECT FUEL TYPE. ALL MODEL YEARS. *KB
V-B-41.10/02
Service Bulletin/Repair Instructions
MERCEDES (SPRINTER): REMOVAL AND INSTALLATION OF THE DRIVE SHAFT. ALL MODEL YEARS. *KB
SCB-2011040001
Service Bulletin/Repair Instructions
MERCEDES BENZ: 2010-2011 906. THE SHEET METAL THAT RETAINS THE HAND BRAKE LEVER IS NOT UP TO SPECIFICATIONS. THE HAND BRAKE LEVER COULD DETACH. *RM
SCB-2011040002
Service Bulletin/Repair Instructions
MERCEDES BENZ: 2011 906. THE EMISSIONS LABEL MAY NOT HAVE BEEN INSTALLED. *RM
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.