Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 46085
Service Bulletin/Repair Instructions
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
AS-21534
Service Bulletin/Repair Instructions
FORD: THERE IS EXCESSIVE ENGINE OR EXHAUST NOISE, OR AN EXHAUST ODOR DUE TO AN EXHAUST LEAK. THERE WILL BE NO WARNING CODES OR LIGHTS. 2007-2008 ESCAPE/MARINER. *RM
TSB-09-21-9
Service Bulletin/Repair Instructions
FORD/MERCURY: NEW SERVICE KIT AVAILABLE FOR ACCELERATOR CABLE TO PEDAL CONNECTION. SOME VEHICLES MAY REQUIRE THE ACCELERATOR CABLE TO ACCELERATOR PEDAL CONNECTION REPAIRED. A NEW SERVICE CLIP HAS BEEN RELEASED FOR USE, IN LIEU OF REPLACING THE CABLE AND/OR PEDAL ASSEMBLIES. *PE
20213
Service Bulletin/Repair Instructions
2005-08 ESCAPE/ESCAPE HYBRID/MARINER - 2006-08 MARINER HYBRID - WHEEL SPEED SENSOR RING REPLACEMENT PROCEDURE UPDATE TO WORKSHOP MANUAL. *NJ
08-5-5
Service Bulletin/Repair Instructions
SLOW FUEL FILL AND/OR DTC P0451. *NJ
08-3-1
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) U2062 (HYBRID ONLY). *NJ
20144
Service Bulletin/Repair Instructions
MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN. COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
0748
Service Bulletin/Repair Instructions
SERVICE HARNESS INSTALLATION - CORROSION OF A RESISTOR IN THE BATTERY POWER UNIT. ALSO HAVE AN OWNER'S LETTER. *NJ
19865
Service Bulletin/Repair Instructions
MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
19536
Service Bulletin/Repair Instructions
SLOW FUEL FILL DUE TO CLOGGED VENT. *KB
06166
Service Bulletin/Repair Instructions
POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT. *KB
07111
Service Bulletin/Repair Instructions
COLD CLIMATE SLOW FUEL FILL. *NJ
0756
Service Bulletin/Repair Instructions
ENGINE STALLING ON ENGAGEMENT/STOPPING. *KB
19355
Service Bulletin/Repair Instructions
DRIVEABILITY CONCERNS AND/OR DTCP0340 - INSPECT CRANKSHAFT PULLEY. *KB
19956
Service Bulletin/Repair Instructions
2005-2008 ESCAPE HYBRID AND 2006-2008 MARINER HYBRID VEHICLES ARE NOT E-85 COMPATIBLE. *NJ