16735
Service Bulletin/Repair Instructions
VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT
Vehicle report
1996 MERCURY MOUNTAINEER
Service bulletins
55 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
16040
Service Bulletin/Repair Instructions
EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT
15249
Service Bulletin/Repair Instructions
CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING. *TT
14819
Service Bulletin/Repair Instructions
SOME 4X4 VEHICLES MAY EXHIBIT A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT
14847
Service Bulletin/Repair Instructions
CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT
13879
Service Bulletin/Repair Instructions
INFORMATION ON REPLACING A GEM MODULE ON 4X4 VEHICLES EQUIPPED WITH 4.0L SOHC, OHV AND THE NEUTRAL TOW KIT. *TT
00M11
Service Bulletin/Repair Instructions
INFORMATION REGARDING FRONT SWAY BAR LINK . *YH
0083
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR
14048
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR
8164
Service Bulletin/Repair Instructions
INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR
8493
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR
8149
Service Bulletin/Repair Instructions
SUBJECT REGARDING NEUTRAL TOW INOPERATIVE AFTER GEM REPLACEMENT. *TT
13723
Service Bulletin/Repair Instructions
SOME ALL WHEEL DRIVE VEHICLES MAY EXPERIENCE A LOW SPEED WHINING NOISE FROM THE TRANSFER CASE. *MJS
13440
Service Bulletin/Repair Instructions
EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT
13505
Service Bulletin/Repair Instructions
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
7353
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
7360
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A SQUEAK NOISE FROM THE REAR WHILE DRIVING, ESPECIALLY WHEN GOING BUMPS. *TT
7494
Service Bulletin/Repair Instructions
ALL VEHICLES WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF WHAT THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
13388
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED THE NEUTRAL TOW FEATURE, BE AWARE THAT WHEN THE NEUTRAL TOW FEATURE IS ENABLED AND THE CUSTOMER PLACES THE VEHICLE INTO THE NEUTRAL MODE, THE NEUTRAL TOW INDICATOR WILL GO OUT WHEN THE GEM GOES TO SLEEP. *TT
13412
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
13415
Service Bulletin/Repair Instructions
EXHIBITING A SQUEAK TYPE NOISE FROM THE REAR STABILIZER BAR WHILE DRIVING, ESPECIALLY WHEN GOING OVER BUMPS. *TT
13426
Service Bulletin/Repair Instructions
EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT
13180
Service Bulletin/Repair Instructions
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
13222
Service Bulletin/Repair Instructions
INFORMATION REGARDING NEUTRAL TOW KIT AVAILABLE. *MJS
6980
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT THE CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODE PO420. *TT
6997
Service Bulletin/Repair Instructions
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
7083
Service Bulletin/Repair Instructions
INFORMATION REGARDING NEUTRAL TOW KIT AVAILABILITY. *MJS
12905
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
98R03
Service Bulletin/Repair Instructions
SAFETY RECALL LETTER INFORMING OWNERS OF MODIFICATION TO THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM. *TT
995157
Service Bulletin/Repair Instructions
INFORMATION ON MAINTAINING TIRE PRESSURE. *TT
12571
Service Bulletin/Repair Instructions
EXPERIENCING A WHINNING NOISE FROM THE TRANSFER CASE. *TT
5203
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
5249
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
5272
Service Bulletin/Repair Instructions
BRIEF INFORMATION REGARDING ENGINE STALL CONDITION. *TT
12154
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
12174
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
985045
Service Bulletin/Repair Instructions
REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT
985064
Service Bulletin/Repair Instructions
REPEAT MESSAGE REGARDING ENGINE STALLING *TT
985157
Service Bulletin/Repair Instructions
INFORMATION ON SETTING THE TIRE INFLATION PRESSURE FOR 1991 THROUGH 1999 MODEL YEAR VEHICLES IN THE PRE-DELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *TT
98-4732
Service Bulletin/Repair Instructions
STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS..
4623
Service Bulletin/Repair Instructions
BRIEF INFORMATION FOR VEHICLES EXHIBITING ENGINE STALL. *TT
4634
Service Bulletin/Repair Instructions
STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
980318
Service Bulletin/Repair Instructions
CONDITIONS WITH AXLE WIND-UP ON TIGHT TURNS WITH CONTROL TRAC TRANSFER CASE. *YC
980319
Service Bulletin/Repair Instructions
CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC
982540
Service Bulletin/Repair Instructions
CONCERNS WITH BUILT-IN REAR CHILD SAFETY SEAT MAY NOT EASILY ACCOMMODATE SOME CHILDREN. *YC
983074
Service Bulletin/Repair Instructions
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
983092
Service Bulletin/Repair Instructions
REAR CRANKSHAFT SEAL OIL LEAK. *AK
97050110613
Service Bulletin/Repair Instructions
WHEN PERFORMING TSB 97-4-9, DO NOT USE A BAFFLE TO CORRECT HTE ISSUE, USE THE REVISED AXLE COVER PLATE. *TW
BC2302970501
Service Bulletin/Repair Instructions
DTC P0402 IN MEMORY UNDER INVESTIGATION BY ENGINEERING. *TW
BC3092970501
Service Bulletin/Repair Instructions
ENGINEERING IS INVESTIGATING REAR CRANKSHAFT OIL LEAKS. *TW
BC5191961001
Service Bulletin/Repair Instructions
FOR CONCERNS OF STALLING, REFLASH PCM W/ 1996 CALIBRATION (R11 LEVEL). *TT
BC5195961001
Service Bulletin/Repair Instructions
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
BC5200961001
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE UNEXPLAINED MIL LIGHT CODES &/OR IRREGULAR SHIFTING (A4LD). THE -12A581- (95-96) OR -12B637- (97) WIRE LOOM IS COMING INTO CONTACT W/ THE CENTER WIPER ACCESS PLATE LWR CTR. *TT
BC5221961001
Service Bulletin/Repair Instructions
REVISED HOSE PART# F6HZ-9J291-A HAS BEEN DEVELOPED TO REPLACE HOSE THAT SHOWS SIGNS OF DETERIORATION, CRACKS MAY APPEAR IN THE OUTER COVERING OF THE HOSE. *TT
BC5225961001
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE A VIBRATION DURING WIDE OPEN THROTTLE ACCELERATION OR WHILE CRUISING AT HIGHWAY SPEEDS. REVISED FRONT DRIVESHAFT. *TT
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.