Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
M610607
Service Bulletin/Repair Instructions
MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, most of which are not due to the battery itself. For this reason, a battery replacement will permanently eliminate the problem only in the rarest of cases. The energy diagnosis test module helps to localize these causes. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints. Without performing the energy diagnosis test plan, the root cause of a discharged battery cannot be identified. In order to properly repair the vehicle the first time, it is very important that the diagnostic test plan is performed to completion; with all results taken into consideration.
M240118
Service Bulletin/Repair Instructions
AISIN AUTOMATIC TRANSMISISON: RIGHT SIDE OUTPUT SHAFT SEAL REPLACEMENT
12 09 15
Service Bulletin/Repair Instructions
MINI: FAULTY SOFTWARE FOR THE TANK VENTILATION CONTROL DISPLAYS ENGINE THROTTLE REACTION WHEN TEMPERATURE IS HIGH OUTSIDE, AND MORE OBVIOUS IF THE TANK IS ONLY PARTLY FILLED. *MA
11 02 15
Service Bulletin/Repair Instructions
MINI: A MECHANICAL FAILURE AND DME SOFTWARE ERROR OF THE VANOS ACTUATORS CAUSE THE ENGINE TO RUN ROUGH WHICH ACTIVATES THE MALFUNCTION WARNING LIGHT. *MA
SIM-11-10-14
Service Bulletin/Repair Instructions
MINI: SOME VEHICLES HAVE TURBOCHARGER NOISE AND A LACK OR LOSS OF PERFORMANCE, DUE TO RESTRICTION OF TURBOCHARGER OIL SUPPLY, RESULTING IN OIL STARVATION AND SEIZING OF TURBOCHARGER ASSEMBLY. MODEL ALL. *PE
SIM-11-01-12
Service Bulletin/Repair Instructions
MINI: ON CERTAIN MODEL VEHICLES, AN ENGINE OIL LEAK MAY OCCUR, DUE TO THE COMPROMISED OIL PUMP VOLUME CONTROL SOLENOID VALVE, FROM THE UNDERSIDE OF ENGINE. NO MODEL YEARS LISTED. *PE UPDATED 4/19/2013. *KB UPDATED 3/11/14. *PE
SIM-11-03-12
Service Bulletin/Repair Instructions
MINI: WHEN RESEALING ENGINE OIL PAN, ENGINE OIL PAN GASKET REPLACEMENT SHOULD NO LONGER BE USED DUE TO CAUSING SEALING FLANGE BECOMING DEFORMED. MODELS R55, R56, R59, R60, R57, AND R58. NO MODEL YEARS LISTED. *PE
SI-M61-01-12
Service Bulletin/Repair Instructions
MINI: AFTER DRIVE-AWAY LOCKING ACTIVATES, IT IS NOT POSSIBLE TO UNLOCK THE BOOT. *KB
SIM-62-01-11
Service Bulletin/Repair Instructions
BMW: AN INCORRECT SYMBOL FOR THE PARKING BRAKE AND BRAKE SYSTEM INDICATOR WAS INSTALLED. *RM
SIM-65-06-11
Service Bulletin/Repair Instructions
BMW: THE AIRBAG WARNING LIGHT IS ON WITH A FAULT STORED. THE WIRING UNDER THE SEAT MAY BE PINCHED OR DAMAGED. *RM
SIM-17-01-10
Service Bulletin/Repair Instructions
BMW: ENGINE TOO HOT MESSAGE IS DISPLAYED WITH STORED TROUBLE CODES. THE WATER PUMP DOESNT POWER UP. *RM
SIM-11-07-08
Service Bulletin/Repair Instructions
BMW: DESCRIPTION AND SPECIFICATIONS OF CRANKCASE VENTILATION SYSTEM. *RM
SIM-13-06-10
Service Bulletin/Repair Instructions
MINI: TEILECLEARING FOR N14/N18 ENGINE DRIVABILITY AND FUEL SYSTEM. ENHANCED TECHNICAL SUPPORT (TEILECLEARING) PROCESS HAS BEEN DEVELOPED TO HELP IDENTIFY THE ROOT CAUSES OFCUSTOMER COMPLAINTS RELATING TO THE N14/N18 DRIVABILITY AND FUEL SYSTEM *E.G., LONG CRANK, LOSS OF POWER, SES LAMP ON, ETC.). THIS PROCESS CAN ALSO HELP EXPEDITE THE DEFECT ERADICATION PROCESS, ONCE THE ROOT CAUSE HAS BEEN DETERMINED. NO MODEL YEARS LISTED. *PE
SI-M-18-01-09
Service Bulletin/Repair Instructions
MINI: DUE TO A FAILURE IN THE PRODUCTION PROCESS,THE CATALYTIC CONVERTER MAY DETERIORATE CAUSING AN INCREASED LEVEL OF VEHICLE EMISSIONS. THE CATALYST EFFICIENCY FAULT CODE (276A) WILL BE STORED IN THE DME MEMORY, AND THE SERVICE ENGINE SOON LAMP WILL BE ILLUMINATED. VEHICLE DRIVABILITY IS NOT AFFECTED BY THIS TYPE OF THE CATALYST FAILURE. (R55, R56). *PE
SI-M-51-09-08
Service Bulletin/Repair Instructions
MINI: REAR SPLIT DOOR OPENING PROBLEMS. ONE OR BOTH OF THE REAR SPLIT DOORS INTERMITTENTLY HAVE FUNCTIONAL PROBLEMS. THE DOOR(S) MAY NOT UNLATCH WHEN THE LEVER ON THE HANDLE IS PULLED OR THE LATCH MAY RELEASE UNEXPECTEDLY WITHOUT BEING PULLED. *PE UPDATED 7/10/09. *PE
SI-M-63-01-09
Service Bulletin/Repair Instructions
MINI VEHICLES: WHILE DRIVING OR AT IDLE, THE HEADLAMPS FLICKER OR SPORADICALLY MOVE UP OR DOWN BY THEMSELVES. THE HEADLAMP WIRING HARNESS IS DAMAGED DUE TO CHAFFING AT THE ENGINE GROUND POINT. *PE
SI-M63-01-09
Service Bulletin/Repair Instructions
MINI: WHILE DRIVING OR AT IDLE, THE HEADLAMPS FLICKER OR SPORADICALLY MOVE UP OR DOWN BY THEMSELVES. THE HEADLAMP WIRING HARNESS IS DAMAGED DUE TO CHAFFING AT THE ENGINE GROUND POINT. R55 (COOPER CLUBMAN, COOPER S CLUBMAN); R56 (COOPER, COOPER S). *PE
SIM-12-02-09
Service Bulletin/Repair Instructions
MINI: SERVICE ENGINE SOON OR CHECK GAS CAP WARNING IS ILLUMINATED: TANK LEAKAGE. LEAKAGE IS DETECTED IN THE TANK VENTILATION OR EVAPORATIVE SYSTEM. *PE
SI-M-24-02-08
Service Bulletin/Repair Instructions
BMW(MINI): TRANSMISSION - VARIOUS EGS FAULTS CAUSED BY WIRING HARNESS DAMAGE. DIFFICULT TO ENGAGE THE D OR R GEARS FROM PARK POSITION; GEAR SHIFTS ARE EXTREMELY HARSH DURING DRIVE; INTERMITTENTLY THE TRANSMISSION WARNING LIGHT MAY BE DISPLAYED. *PE
SI-M-65-05-08
Service Bulletin/Repair Instructions
MINI: CHECK SVS FUNCTION. ON CERTAIN VEHICLES, THE VOICE INPUT SYSTEM (SVS SA 620) DOES NOT FUNCTION. THE SVS WAS NOT INSTALLED IN THE VEHICLES. *PE