Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
M610607
Service Bulletin/Repair Instructions
MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, most of which are not due to the battery itself. For this reason, a battery replacement will permanently eliminate the problem only in the rarest of cases. The energy diagnosis test module helps to localize these causes. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints. Without performing the energy diagnosis test plan, the root cause of a discharged battery cannot be identified. In order to properly repair the vehicle the first time, it is very important that the diagnostic test plan is performed to completion; with all results taken into consideration.
M120817
Service Bulletin/Repair Instructions
W10 ENGINE: EMS2K - COMPREHENSIVE COMPONENT OBD READINESS MONITOR NOT COMPLETED: An affected vehicle fails to pass a state Inspection and Emission (I/M) test due to the ÒComprehensive ComponentÓ OBD readiness monitor status is Ònot complete,Ó or it fails complete after performing an applicable repair.
M320214
Service Bulletin/Repair Instructions
This Service Information bulletin supersedes SI 32 02 14 dated August 2014. SUBJECT Installation of Right-Hand Drive Steering Spindle in Left-Hand Drive Vehicle is No Longer Required. Left-hand drive steering spindles are currently available.
12 09 15
Service Bulletin/Repair Instructions
MINI: FAULTY SOFTWARE FOR THE TANK VENTILATION CONTROL DISPLAYS ENGINE THROTTLE REACTION WHEN TEMPERATURE IS HIGH OUTSIDE, AND MORE OBVIOUS IF THE TANK IS ONLY PARTLY FILLED. *MA
SIM-11-10-14
Service Bulletin/Repair Instructions
MINI: SOME VEHICLES HAVE TURBOCHARGER NOISE AND A LACK OR LOSS OF PERFORMANCE, DUE TO RESTRICTION OF TURBOCHARGER OIL SUPPLY, RESULTING IN OIL STARVATION AND SEIZING OF TURBOCHARGER ASSEMBLY. MODEL ALL. *PE
M010113
Service Bulletin/Repair Instructions
Electro-Hydraulic Power-Assist Steering Pump (EHPS) and Cooling Fan: Limited Warranty Extension to 13 Years/150,000 Miles. On affected vehicles, the electro-hydraulic power steering (EHPS) pump can fail.
SI M01 01 13
Service Bulletin/Repair Instructions
MINI: MODELS R50, R52, AND R53 WITH THE ELECTRO-HYDRAULIC POWER-ASSIST STEERING PUMP AND COOLING FANS WILL HAVE AN LIMITED WARRANTY EXTENSION TO 13 YEARS/150,000 MILES. *TA
M010514
Service Bulletin/Repair Instructions
MINI CVT Replacement Parts Warranty Extension: Additional 12 Months with Up to 50,000 Accumulated Miles. A MINI vehicle's CVT assembly or component that was previously repaired and/or replaced by an authorized MINI dealer or BMW center may experience a subsequent failure.
MC-10113
Service Bulletin/Repair Instructions
MINI: WARRANTY COVERAGE EXTENSION/REPAIR EXPENSE REIMBURSEMENT FOR THE ELECTRO HYDRAULIC POWER (ASSIST) STEERING (EHPS) PUMP, WHICH HAS ITS OWN COOLING FAN, ON SOME VEHICLES AND NOT THE ELECTRIC POWER (ASSIST) STEERING (EPS) SYSTEM ON OTHER MINIS. MODELS 2002-2005 COOPER, COOPER S, CONVERTIBLE, CONVERTIBLE S. *PE
SIM-01-01-13
Service Bulletin/Repair Instructions
MINI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. A WARRANTY EXTENSION FOR CERTAIN VEHICLES WITH POTENTIAL PROBLEM WITH COOLING FAN AND THE DURABILITY OF ELECTRO HYDRAULIC POWER (ASSIST) STEERING (EHPS) PUMP. MODELS 2002-2005 R50, R52, R3. *PE UPDATED ON 11/1/2013. *KB UPDATED 3/4/2014 *JS
M120213
Service Bulletin/Repair Instructions
State Inspection and Emission (I/M) Test Fails Due to an Invalid VIN Number. The affected vehicle may fail to pass a State Inspection and Emission (I/M) test due to a noncompliant 17-digit vehicle identification number (VIN) stored in the DME (Digital Motor Electronic). The VIN read-out displayed on the state test printout does not match the actual VIN of the vehicle. If the DME was reprogrammed using the previously available BMW service equipment (e.g., Progman, GT1), it was possible that only the last 7 of the VIN were entered into the DME, and positions 4 through 10 may only contain default characters. For example: The state I/M tester or OBD scan tool may read out WBAAA00000A123456 instead of the correct full 17-digit VIN, WBAZZ03492A123456.
SI-M-13-01-13
Service Bulletin/Repair Instructions
MINI: THERE IS A PROCEDURAL ERROR IN THE REMOVING AND INSTALLING OR REPLACING HIGH PRESSURE PUMP CURRENT VERSION THAT HAS BEEN REPLACED WITH THE CORRECTED REPAIR INSTRUCTION PORTION FOR THE N14 AND N18 ENGINE. MODELS R55, 56, 57, 58, 59, 60, 61. NO MODEL YEARS LISTED. *PE
SI-M61-01-12
Service Bulletin/Repair Instructions
MINI: AFTER DRIVE-AWAY LOCKING ACTIVATES, IT IS NOT POSSIBLE TO UNLOCK THE BOOT. *KB
SIM-12-04-09
Service Bulletin/Repair Instructions
BMW: THE CRIMPING PROCESS OF THE OXYGEN SENSOR COULD LEAD TO AN ELECTRICAL FAILURE INSIDE THE SENSOR. THERE MAY BE A MALFUNCTION LIGHT ON WITH A FAULT CODE STORED. *RM
SIM-65-06-11
Service Bulletin/Repair Instructions
BMW: THE AIRBAG WARNING LIGHT IS ON WITH A FAULT STORED. THE WIRING UNDER THE SEAT MAY BE PINCHED OR DAMAGED. *RM
SIM-11-07-08
Service Bulletin/Repair Instructions
BMW: DESCRIPTION AND SPECIFICATIONS OF CRANKCASE VENTILATION SYSTEM. *RM
SI-M-11-01-09
Service Bulletin/Repair Instructions
MINI: WHEN REPLACING THE CYLINDER HEAD COVER ON A VEHICLE EQUIPPED WITH THE NEW N14 ENGINE, THE COVER WILL LOOK DIFFERENT IN APPEARANCE. THE REPLACEMENT COVER IS NOW EQUIPPED WITH A CRANKCASE VENTILATION SYSTEM PRESSURE RELIEF VALVE. NO MODEL YEARS LISTED. *PE
SI M-65-02-06
Service Bulletin/Repair Instructions
MINI: AIRBAG WARNING ILLUMINATED, FC55: VEHICLES PRODUCED FROM AUGUST 31, 2005 TO APRIL 25, 2006. *PE