M640116
Service Bulletin/Repair Instructions
Customer complains of a musty odor or damp front footwell carpet.
Vehicle report
2007 MINI COOPER S CLUBMAN
Service bulletins
21 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
M610607
Service Bulletin/Repair Instructions
MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, most of which are not due to the battery itself. For this reason, a battery replacement will permanently eliminate the problem only in the rarest of cases. The energy diagnosis test module helps to localize these causes. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints. Without performing the energy diagnosis test plan, the root cause of a discharged battery cannot be identified. In order to properly repair the vehicle the first time, it is very important that the diagnostic test plan is performed to completion; with all results taken into consideration.
M650610
Service Bulletin/Repair Instructions
NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:
M240118
Service Bulletin/Repair Instructions
AISIN AUTOMATIC TRANSMISISON: RIGHT SIDE OUTPUT SHAFT SEAL REPLACEMENT
BMWJUL1316
Service Bulletin/Repair Instructions
MINI Water Pump Class Action Settlement
SIM-11-10-14
Service Bulletin/Repair Instructions
MINI: SOME VEHICLES HAVE TURBOCHARGER NOISE AND A LACK OR LOSS OF PERFORMANCE, DUE TO RESTRICTION OF TURBOCHARGER OIL SUPPLY, RESULTING IN OIL STARVATION AND SEIZING OF TURBOCHARGER ASSEMBLY. MODEL ALL. *PE
SIM-11-01-12
Service Bulletin/Repair Instructions
MINI: ON CERTAIN MODEL VEHICLES, AN ENGINE OIL LEAK MAY OCCUR, DUE TO THE COMPROMISED OIL PUMP VOLUME CONTROL SOLENOID VALVE, FROM THE UNDERSIDE OF ENGINE. NO MODEL YEARS LISTED. *PE UPDATED 4/19/2013. *KB UPDATED 3/11/14. *PE
SIM-11-03-12
Service Bulletin/Repair Instructions
MINI: WHEN RESEALING ENGINE OIL PAN, ENGINE OIL PAN GASKET REPLACEMENT SHOULD NO LONGER BE USED DUE TO CAUSING SEALING FLANGE BECOMING DEFORMED. MODELS R55, R56, R59, R60, R57, AND R58. NO MODEL YEARS LISTED. *PE
SIM-12-07-12
Service Bulletin/Repair Instructions
MINI: THERE IS A SOFTWARE ERROR CAUSING THE SERVICE ENGINE SOON LIGHT TO BE ILLUMINATED THAT IS RELATED TO VALVETRONIC DIAGNOSTICS. MODELS R55, R56, R58, R57, R60, R59. NO MODEL YEARS LISTED. *PE
SI-M51-02-12
Service Bulletin/Repair Instructions
MINI: INSTALLATION OF A HEAT SHIELD FOR THE BONNET INTAKE AIR GRILL. *KB
SI-M61-01-12
Service Bulletin/Repair Instructions
MINI: AFTER DRIVE-AWAY LOCKING ACTIVATES, IT IS NOT POSSIBLE TO UNLOCK THE BOOT. *KB
SIM-62-01-11
Service Bulletin/Repair Instructions
BMW: AN INCORRECT SYMBOL FOR THE PARKING BRAKE AND BRAKE SYSTEM INDICATOR WAS INSTALLED. *RM
SIM-65-06-11
Service Bulletin/Repair Instructions
BMW: THE AIRBAG WARNING LIGHT IS ON WITH A FAULT STORED. THE WIRING UNDER THE SEAT MAY BE PINCHED OR DAMAGED. *RM
SIM-17-01-10
Service Bulletin/Repair Instructions
BMW: ENGINE TOO HOT MESSAGE IS DISPLAYED WITH STORED TROUBLE CODES. THE WATER PUMP DOESNT POWER UP. *RM
SIM-11-07-08
Service Bulletin/Repair Instructions
BMW: DESCRIPTION AND SPECIFICATIONS OF CRANKCASE VENTILATION SYSTEM. *RM
SIM-13-06-10
Service Bulletin/Repair Instructions
MINI: TEILECLEARING FOR N14/N18 ENGINE DRIVABILITY AND FUEL SYSTEM. ENHANCED TECHNICAL SUPPORT (TEILECLEARING) PROCESS HAS BEEN DEVELOPED TO HELP IDENTIFY THE ROOT CAUSES OFCUSTOMER COMPLAINTS RELATING TO THE N14/N18 DRIVABILITY AND FUEL SYSTEM *E.G., LONG CRANK, LOSS OF POWER, SES LAMP ON, ETC.). THIS PROCESS CAN ALSO HELP EXPEDITE THE DEFECT ERADICATION PROCESS, ONCE THE ROOT CAUSE HAS BEEN DETERMINED. NO MODEL YEARS LISTED. *PE
SIM -01-04-10
Service Bulletin/Repair Instructions
BMW: SERVICE ENGINE SOON LIGHT MAY BE ON WITH STORED TROUBLE CODES AND REDUCED ENGINE POWER. THE HIGH PRESSURE FUEL PUMP MALFUNCTIONS. *RM
SI-M-22-01-08
Service Bulletin/Repair Instructions
MINI: A KNOCKING NOISE IS HEARD FROM THE FRONT OF VEHICLE DURING ENGINE LOAD REVERSALS, OR ON UNEVEN ROAD SURFACES. FASTENERS SECURING THE TRANSMISSION MOUNTING BRACKET TO THE BODY ARE NOT TIGHTENED TO THE REQUIRED SPECIFICATION. THE TRANSMISSION MOUNT IS DEFECTIVE. *PE
SI-M-11-01-09
Service Bulletin/Repair Instructions
MINI: WHEN REPLACING THE CYLINDER HEAD COVER ON A VEHICLE EQUIPPED WITH THE NEW N14 ENGINE, THE COVER WILL LOOK DIFFERENT IN APPEARANCE. THE REPLACEMENT COVER IS NOW EQUIPPED WITH A CRANKCASE VENTILATION SYSTEM PRESSURE RELIEF VALVE. NO MODEL YEARS LISTED. *PE
SI-M-63-01-09
Service Bulletin/Repair Instructions
MINI VEHICLES: WHILE DRIVING OR AT IDLE, THE HEADLAMPS FLICKER OR SPORADICALLY MOVE UP OR DOWN BY THEMSELVES. THE HEADLAMP WIRING HARNESS IS DAMAGED DUE TO CHAFFING AT THE ENGINE GROUND POINT. *PE
SI-M63-01-09
Service Bulletin/Repair Instructions
MINI: WHILE DRIVING OR AT IDLE, THE HEADLAMPS FLICKER OR SPORADICALLY MOVE UP OR DOWN BY THEMSELVES. THE HEADLAMP WIRING HARNESS IS DAMAGED DUE TO CHAFFING AT THE ENGINE GROUND POINT. R55 (COOPER CLUBMAN, COOPER S CLUBMAN); R56 (COOPER, COOPER S). *PE
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.