DEALER LETTER
Service Bulletin/Repair Instructions
This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023.
Vehicle report
2009 MITSUBISHI LANCER RALLIART
Service bulletins
40 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB-23-00-001
Service Bulletin/Repair Instructions
This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1.5 percent of the vehicle's gross vehicle weight rating (GVWR) or 100 lbs.
TSB-23-00-004
Service Bulletin/Repair Instructions
This Technical Service Bulletin provides instructions and material safety data sheets for removal of rap-film adhesive residue.
TSB-22-54-003
Service Bulletin/Repair Instructions
This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part.
TT253
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-19-00-008
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
MEDICUpdate517
Service Bulletin/Repair Instructions
This is a message sent to dealers, to inform them that an update for MEDIC will be available.
TT237
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-16-11-003
Service Bulletin/Repair Instructions
THIS IS A TECHNICAL SERVICE BULLETIN (TSB) THAT WAS SENT TO DEALERS. THIS TSB PROVIDES INSTRUCTIONS FOR INSPECTION OF OIL LEAKAGE FROM THE FRONT OIL SEAL ON THE CRANKSHAFT, AND IF CONFIRMED, TO REPLACE THE FRONT OIL SEAL. DEALERS ARE TO ALSO INSPECT AND CLEAN THE RUBBER OF THE CRANKSHAFT PULLEY, AND REPLACE THE CRANKSHAFT PULLEY IF RUBBER IS DAMAGED.
TSB-16-22-001
Service Bulletin/Repair Instructions
THIS IS A TECHNICAL SERVICE BULLETIN, SENT TO DEALERS, TO SUPERCEDE TSB−14−22−002, ISSUED JULY, 2014, TO REVISE SPECIFIC STEPS FOR SELECTING REPROGRAMMING DATA IN THE PROGRAM NEW TRANSMISSION CONTROL MODULE (TCM) AND REPROGRAM 2008 LANCER EVOLUTION & EARLY 2009 LANCER AND LANCER SPORTBACK RALLIART TCM SECTIONS.
TSB-16-22-003
Service Bulletin/Repair Instructions
THIS IS A TECHNICAL SERVICE BULLETIN, SENT TO DEALERS, TO SUPERCEDE TSB−15−22−002, ISSUED JULY, 2015, TO REVISE SPECIFIC STEPS FOR SELECTING REPROGRAMMING DATA IN THE PROGRAM NEW TRANSMISSION CONTROL MODULE (TCM) AND REPROGRAM 2008 LANCER EVOLUTION TCM WITH CORRECT SOFTWARE SECTIONS.
TT218
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-15-22-002
Service Bulletin/Repair Instructions
This TSB provides the necessary steps to complete diagnosis, replace the Mechatronic Assembly, and program the new electronic control unit. This bulletin supercedes TSB-14-22-003, issued September, 2014, to update the labor operation code in Warranty Information.
TSB-15-54-004
Service Bulletin/Repair Instructions
This TSB contains troubleshooting steps for diagnosis of various customer complaints relating to the audio system speakers in Mitsubishi vehicles equipped with original equipment audio components.
TT217
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TIN-15-22-001
Service Bulletin/Repair Instructions
THIS TECHNICAL INFORMATION NOTICE INFORMS DEALERS THAT THE POPULATION OF 2015 LANCER RALLIART AND LANCER EVOLUTION VEHICLES ELIGIBLE FOR TSB-14-22-005, AWC HYDRAULIC UNIT WARRANTY EXTENSION, HAS BEEN IDENTIFIED.
TSB1422005CUSTLE
Service Bulletin/Repair Instructions
THIS IS THE LETTER SENT TO OWNERS OF AFFECTED VEHICLES, INFORMING THEM THAT THE WARRANTY HAS BEEN EXTENDED FOR THE AWC HYDRAULIC UNIT ON THEIR VEHICLE. THERE IS POTENTIAL FOR THE ALL WHEEL CONTROL (AWC) HYDRAULIC UNIT AFFECTED VEHICLES TO CORRODE FROM PROLONGED EXPOSURE TO ANTI-FREEZING AGENTS USED IN COLD WEATHER AREAS TO CLEAR ICE AND SNOW FROM ROADWAYS.
TIN-14-22-001
Service Bulletin/Repair Instructions
MITSUBISHI: LANCER/LANCER SPORTSBACK, RALLIART, AND LANCER EVOLUTION: WARRANTY HAS BEEN EXTENDED FOR VEHICLES THAT HAS BEEN AFFECTED FOR THE AWC HYDRAULIC UNIT FROM FAILURE DUE TO CORROSION. *LJ
TSB-14-22-005
Service Bulletin/Repair Instructions
MITSUBISHI MOTORS: SEE DOCUMENT SEARCH BUTTON FOR OWNERS LETTER. WARRANTY EXTENSION FOR AWC HYDRAULIC UNIT IN VEHICLES 2008-2014 LANCER RALLIART, SPORTBACK, EVOLUTION. *LJ
ATIN-13-SC-004-A
Service Bulletin/Repair Instructions
A service campaign will be launched December 19, 2013 to update the ECM software programming in certain 2008 - 2014 Lancer Evolution, 2009 - 2014 Lancer Ralliart, and 2009 - 2011 Lancer Sportback Ralliart built before September 25, 2013. This service campaign will be conducted in the U.S. and Puerto Rico. A Service Campaign Bulletin outlining the reprogramming procedure will be available December 19, 2013 on MEDIC and MDL. In certain affected vehicles, normal Electric Throttle Valve (ETV) fluctuations may cause actual torque to exceed Permitted Torque at low engine speeds. An improper Permitted Torque threshold may then cause false MIL illumination. A software update optimizes the Permitted Torque threshold value to minimize false MIL illumination.
SC-13-004
Service Bulletin/Repair Instructions
This Service Campaign Bulletin provides field fix procedures for reprogramming the ECM with new software to address false MIL illumination with torque monitor P1241 (2008-2010 models) or P061A (2011-2014 models) stored in memory.
TT201
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT200
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT199
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT198
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT197
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT196
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-13-22-002
Service Bulletin/Repair Instructions
Procedures are now available for W6DGA TC-SST clutch assembly replacement. This TSB provides the necessary steps to complete diagnosis, clutch assembly replacement, and complete "Teach-in" procedures for the TCM. This TSB is used together with the Service Manual, TSB-16-22-003: "TC-SST Transmission and Mechatronic Assembly Diagnosis and Repair," and TSB-13-22-003: "TC-SST Diagnosis and Overhaul - Service Manual Revision," to provide procedures for the complete and accurate diagnosis and repair of the TC-SST transmission.
TSB-13-22-003
Service Bulletin/Repair Instructions
The Mechatronic assembly (valve body and TCM) and the clutch assembly are now available as service parts. This TSB provides instructions for transmission overhaul that were not included in the service manual.
TT195
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TTIndex12
Service Bulletin/Repair Instructions
This is an index of Tech Talk newsletter articles released in 2012.
TT194
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-13-22-001
Service Bulletin/Repair Instructions
Procedures are now available for W6DGA TC-SST Mechatronic Assembly (valve body and transmission control module) replacement. This TSB provides the necessary steps to complete diagnosis, replace the Mechatronic Assembly, and program the new electronic control unit.
TSB-13-42A-002
Service Bulletin/Repair Instructions
This Technical Service Bulletin updates the door adjustment procedure in the Body Section of the applicable service manuals.
TT193
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT192
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-12-13-006
Service Bulletin/Repair Instructions
Some affected vehicles may display ! ENGINE SYSTEM SERVICE REQUIRED on the MID and DTC P0012 may be recorded in ECM memory, but the MIL is not illuminated. An incorrect parameter in the judgment criteria may cause mis-detection of a fault even though the timing chain elongation rate remains within the specified allowance. This TSB provides a procedure to reprogram the ECM, confirm the oil control valve and timing chain are not at fault, and reset the timing chain learned value.
TT191
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-09-13-010
Service Bulletin/Repair Instructions
MITSUBISHI: FUEL RETURN PIPE REMOVAL/INSTALLATION-SERVICE MANUAL REVISION. THE VEHICLES HAVE A REDESIGNED FUEL RETURN PIPE WHICH HAS TWO ADDITIONAL BRACKETS. THIS BULLETIN PROVIDES UPDATED FUEL RETURN PIPE REMOVAL AND INSTALLATION SERVICE MANUAL PROCEDURES FOR THE AFFECTED VEHICLES, AND FOR REPLACEMENT FUEL RETURN PIPES INSTALLED SINCE 9/22/09. *PE
SC-09-001
Service Bulletin/Repair Instructions
MITSUBISHI: ON SOME AFFECTED VEHICLES EQUIPPED WITH TURBOCHARGED ENGINES, CORROSION ON THE INSIDE OF THE HOOD LOCK RELEASE CABLE CAN MAKE IT DIFFICULT TO RELEASE THE HOOD LATCH USING THE LATCH HANDLE. *PE
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.