DEALER LETTER
Service Bulletin/Repair Instructions
This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023.
Vehicle report
2009 MITSUBISHI LANCER SPORTBACK
Service bulletins
55 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB-23-00-001
Service Bulletin/Repair Instructions
This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1.5 percent of the vehicle's gross vehicle weight rating (GVWR) or 100 lbs.
TSB-23-00-004
Service Bulletin/Repair Instructions
This Technical Service Bulletin provides instructions and material safety data sheets for removal of rap-film adhesive residue.
TSB-23-11-001
Service Bulletin/Repair Instructions
This TSB provides revisions to the Removal and Installation procedures for the rocker cover due to changes in the quantity of mounting bolts for vehicles equipped with 4B1 series engine. (Service Manual Revision)
TSB-22-54-003
Service Bulletin/Repair Instructions
This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part.
SR-20-003REV_2
Service Bulletin/Repair Instructions
Revision to previous TSB SR-20-003 for the Crossmember recall. Added Warranty information for instances where subframe may fail and cause additional damage to unrelated parts. This bulletin provides directions for inspection and repair of affected vehicles' Crossmembers.
TIN-20-SR-003REV
Service Bulletin/Repair Instructions
Technical Information Notice sent to dealerships to advise ofrevision changes to TSB "SR-20-003REV_2"
MIC-MITS-2020080
Service Bulletin/Repair Instructions
Publications Report for Mitsubishi Motors North America, Inc. - July 2020
ATIN-20-SR-003D
Service Bulletin/Repair Instructions
This ATIN-20-SR-003D supersedes ATIN-20-SR-003C and ATIN-20-SR-003B, providing notification of modifications to the TSB and repair procedure; noting when a Crossmember replacement is required the anti-corrosive agent application is not required.
SR-20-003REV_1
Service Bulletin/Repair Instructions
This bulletin provides directions for inspection and repair of affected vehicles' Crossmembers in the Safety Recall.
ATIN-20-SR-003-C
Service Bulletin/Repair Instructions
This Advanced Technical Information Notice was sent to dealers as an update to ATIN-20-SR-003B informing that due to a parts availability delay of the Crossmember, customer vehicles requiring a replacement of the crossmember are unable to be completed at this time. Additionally, this notice informed dealers that an Interim Owner Notification Letter was mailed to affected owners on July 17th, 2020 to inform customers that MMNA is making every effort to establish a remedy and will contact them again by mail with a follow-up recall notice once parts are in stock and the final remedy is available.
Interim Customer
Service Bulletin/Repair Instructions
This Letter was sent to customers informing them of the launch of Recall SR-20-003, part are currently unavailable; but they will be notified when parts become availble for repairs to begin. This notice also provided customers instruction on how to obtain repairs.
ATIN-20-SR-003-B
Service Bulletin/Repair Instructions
This Advanced Technical Information Notice was sent to dealers informing them of the upcoming recall being released for the inside and outside surfaces of the front cross members used on certain vehicles, if exposed long term to snow melt water and anti-freezing agents, may corrode due to insufficient performance of the rust protection.
TT253
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-19-00-008
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
TSB-18-11-001
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Engine section of the affected Service Manuals to correct the tightening torque for the Fastener Tightening Specifications and the oil pump chain's removal and installation.
TSB-18-16-001
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Engine Electrical section of the affected Service Manuals to correct the tightening torque for the generator assembly removal and installation.
TSB-18-32-001
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Power Plant Mount section of the affected Service Manuals to correct the tightening torque for the crossmember removal service points.
TSB-18-51-001
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Exterior section of the affected Service Manuals to correct the tightening torque for the front bumper assembly and radiator grille, under cover and floor console assembly.
MEDICUpdate517
Service Bulletin/Repair Instructions
This is a message sent to dealers, to inform them that an update for MEDIC will be available.
TT237
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
SRSSensorInvesti
Service Bulletin/Repair Instructions
This is a letter sent to dealers, to inform them that the temporary investigation of Supplemental Restraint System (SRS) Front Impact Sensors investigation has concluded.
TSB-17-14-001
Service Bulletin/Repair Instructions
THIS IS A TECHNICAL SERVICE BULLETIN, SENT TO DEALERS, PROVIDING INSTRUCTIONS FOR MODIFYING THE WIRING HARNESS AND REPLACING THE RADIATOR AND/OR CONDENSER FAN MOTOR AND CONNECTORS, IN CASES WHERE AN INOPERATIVE FAN MAY BE CAUSED BY A MELTED CONNECTOR AT THE RADIATOR FAN MOTOR AND/OR CONDENSER FAN MOTOR.
SRSINVNOV2016
Service Bulletin/Repair Instructions
THIS IS A COMMUNICATION SENT TO DEALERS REQUIRING THEIR ASSISTANCE WITH MMNA'S INVESTIGATION OF POTENTIALLY DEFECTIVE FRONT IMPACT SENSOR(S).
TSB-16-11-003
Service Bulletin/Repair Instructions
THIS IS A TECHNICAL SERVICE BULLETIN (TSB) THAT WAS SENT TO DEALERS. THIS TSB PROVIDES INSTRUCTIONS FOR INSPECTION OF OIL LEAKAGE FROM THE FRONT OIL SEAL ON THE CRANKSHAFT, AND IF CONFIRMED, TO REPLACE THE FRONT OIL SEAL. DEALERS ARE TO ALSO INSPECT AND CLEAN THE RUBBER OF THE CRANKSHAFT PULLEY, AND REPLACE THE CRANKSHAFT PULLEY IF RUBBER IS DAMAGED.
INVESTIGATIONRE
Service Bulletin/Repair Instructions
THIS IS A COMMUNICATION SENT TO DEALERS REQUESTING COOPERATION WITH MMNA'S INVESTIGATION OF POTENTIALLY DEFECTIVE FRONT IMPACT SENSOR(S).
TSB-15-23-003
Service Bulletin/Repair Instructions
THIS TECHNICAL SERVICE BULLETIN, PROVIDED TO DEALERS, PROVIDES INSTRUCTIONS TO REMOVE THE TRANSMISSION AND REPLACE TWO PRIMARY PULLEY SHAFT BEARINGS AND ONE SECONDARY PULLEY SHAFT BEARING, IF A CLICKING NOISE (ALONG WITH WHINING/HUMMING), DIRECTLY RELATED TO VEHICLE SPEED, IS HEARD IN THE PASSENGER COMPARTMENT.
TT218
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT-218
Service Bulletin/Repair Instructions
MITSUBISHI: INFORMATION PROVIDED REGARDING VARIOUS ISSUES AS POWER WINDOW ON DRIVER'S DOOR, A/C COMPRESSOR ISSUES, PISTON SCUFF, DAYTIME RUNNING LIGHT OR INTAKE AND EXHAUST SYSTEM OR REPLACEMENT OF REAR AXLE ASSEMBLY. VARIOUS MODEL YEARS AND VEHICLES. *PE
TSB-15-54-004
Service Bulletin/Repair Instructions
This TSB contains troubleshooting steps for diagnosis of various customer complaints relating to the audio system speakers in Mitsubishi vehicles equipped with original equipment audio components.
TT217
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-15-23-004
Service Bulletin/Repair Instructions
THIS TECHNICAL SERVICE BULLETIN, PROVIDED TO DEALERS, ADDS PROCEDURES FOR DISASSEMBLY, ASSEMBLY AND CLEANING TRANSMISSION COMPONENTS.
TSB-15-23A-002
Service Bulletin/Repair Instructions
THIS TECHNICAL SERVICE BULLETIN, PROVIDED TO DEALERS, CORRECTS THE HYDRAULIC PRESSURE SETTINGS AND UPDATES THE SPECIAL TOOLS USED IN THE CVT HYDRAULIC PRESSURE TEST IN THE INDICATED SERVICE MANUALS.
TSB-15-52A-001
Service Bulletin/Repair Instructions
THIS TECHNICAL SERVICE BULLETIN, PROVIDED TO DEALERS, PROVIDES THE CORRECT TORQUE SPECIFICATION FOR THE 2012 OUTLANDER SPORT SERVICE MANUAL. OTHER MODELS' SERVICE MANUALS ARE UPDATED WITH INFORMATION FOR THE OUTER SEAT BELT ON THE FRONT PASSENGER'S SIDE SEAT TO CLARIFY THE FRONT SEAT BELT INSTALLATION AND REMOVAL PROCEDURE.
TSB-15-15-001
Service Bulletin/Repair Instructions
THIS TECHNICAL SERVICE BULLETIN ADDS THE NON-REUSABLE PARTS INDICATION THAT WAS MISSING FROM THE SERVICE MANUAL FOR CERTAIN EXHAUST FASTENERS.
TSB-14-15-001
Service Bulletin/Repair Instructions
MITSUBISHI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO PROLONGED EXPOSURE TO ANTI-FREEZING AGENTS, FRONT EXHAUST PIPE SEAL RING MAY CORRODE, IN COLD WEATHER STATES, TO CLEAR ICE AND SNOW FROM ROADWAYS. *PE
TSB-14-54-009
Service Bulletin/Repair Instructions
MITSUBISHI: UPDATED INFORMATION INSTRUCTIONS PROVIDED FOR SUB HARNESS IN REPAIRING DRL FUNCTION OF HEAD LIGHT IN VEHICLE'S SERVICE MANUAL. MODEL 2008-2012 LANCER, SPORTBACK, EVOLUTION, OUTLANDER. *PE
TSB-14-54-010
Service Bulletin/Repair Instructions
MITSUBISHI: CORRECTED INFORMATION REGARDING HEADLAMP RLEAY CIRCUIT IN VEHICLE SERVICE MANUALS. MODEL 2009-2014 OUTLANDER, LANCER, LANCER SPORTBACK, LANCER EVOLUTION. *PE
TT201
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT200
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT199
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT198
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT197
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT196
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-13-42A-003
Service Bulletin/Repair Instructions
This TSB supercedes TSB-09-42A-015, issued October, 2009, to update affected vehicles, add Outlander Sport and add FAST Key case part numbers. Remote Keyless Entry (RKE) integrated key case and FAST Key Transmitter case repair kits are now available. If the plastic parts of the key are broken or missing, but the key functions properly, use the appropriate service parts kit instead of replacing the entire key assembly. When replacing only the key case, it is not necessary to program immobilizer, RKE and OSS functions. For integrated RKE keys, once the electronic components are transferred to the new case, the key can be cut to the vehicle's key code.
TT195
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TTIndex12
Service Bulletin/Repair Instructions
This is an index of Tech Talk newsletter articles released in 2012.
TT194
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-13-42A-002
Service Bulletin/Repair Instructions
This Technical Service Bulletin updates the door adjustment procedure in the Body Section of the applicable service manuals.
TT193
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-13-42A-001
Service Bulletin/Repair Instructions
Caution statements regarding the disposal of certain components using coin-type lithium batteries have been incorrect in the service manuals of affected vehicles. This TSB provides updated caution statements.
TSB-13-52B-001
Service Bulletin/Repair Instructions
Caution statements regarding the disposal of certain SRS components have been incorrect in the service manuals of affected vehicles. This TSB provides updated caution statements.
TSB-12-35-003
Service Bulletin/Repair Instructions
This TSB clarifies the stop light switch installation and adjustment procedure in the affected service manuals.
TT192
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT191
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.