TECH TALK 289
Other
Tech Talk is a service newsletter that was sent out to dealers. It covers various topics and reviews the previous months publications.
Vehicle report
2019 MITSUBISHI OUTLANDER SPORT
Service bulletins
59 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TECH TALK 281
Other
Tech Talk is a service newsletter that was sent out to dealers. It covers various topics and reviews the previous months publications.
TSB-24-23-004
Service Bulletin/Repair Instructions
Service Manual Revision - This Technical Service Bulletin provides corrections to the description of special tools used to install the oil seal within the Automatic Transaxle sections of the applicable Service Manuals.
TSB-20-23-001RV4
Service Bulletin/Repair Instructions
Service Manual Revision - This Technical Service Bulletin instructs dealers to diagnose and test drive vehicles exhibiting a shudder or surge condition possibly caused by poor reaction of the hydraulic pressure circuit.
TSB-20-23-001REV
Service Bulletin/Repair Instructions
Service Manual Revision - This Technical Service Bulletin instructs dealers to diagnose and test drive vehicles exhibiting a shudder or surge condition possibly caused by poor reaction of the hydraulic pressure circuit.
TSB-24-23-001
Service Bulletin/Repair Instructions
Service Manual Revision - This Technical Service Bulletin provides the procedure for diagnostic trouble code and on-vehicle service for belt & pulley assembly on certain CVT models.
TIN21-37-001REV3
Service Bulletin/Repair Instructions
This Revised Technical Information Notice provides dealers with the requirements needed to be entered into the Photo Required Condition & Pre-Approval Center (PRC) for a vehicle pulling/drifting and/or with steering wheel off-center concerns.
TSB-22-16-001REV
Service Bulletin/Repair Instructions
This Technical Service Bulletin supersedes TSB-22-16-001REV ("MIL illumination with DTC P030X and loss of power due to Fail Safe Mode") issued August 2023, to update the Affected Vehicle years and provide VIN cut-off information.
TSB-23-13-004
Service Bulletin/Repair Instructions
This Technical Service Bulletin provides instructions to reprogram the ECU with the countermeasure software when the check engine light illuminates with DTC of P0401/ P0400.
DEALER LETTER
Service Bulletin/Repair Instructions
This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023.
TIN-23-54A-001
Service Bulletin/Repair Instructions
This is a Technical Information Notice requesting dealers to report headlight inoperative issues.
TSB-23-00-001
Service Bulletin/Repair Instructions
This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1.5 percent of the vehicle's gross vehicle weight rating (GVWR) or 100 lbs.
TSB-23-00-004
Service Bulletin/Repair Instructions
This Technical Service Bulletin provides instructions and material safety data sheets for removal of rap-film adhesive residue.
TSB-23-23-004
Service Bulletin/Repair Instructions
This Technical Service Bulletin provides service manual corrections to the CVT maintenance procedure.
TIN-23-66-001
Service Bulletin/Repair Instructions
This is a Technical Information Notice informing dealers and parts managers about possible causes after a customer complains that the engine will not start while using the remote start system.
TSB-11-66-001REV
Service Bulletin/Repair Instructions
This Technical Service Bulletin contains technical information and troubleshooting for the accessory Remote Engine Start system for affected vehicles.
TSB-21-52A-002RE
Service Bulletin/Repair Instructions
This Technical Service Bulletin instructs dealers to replace the seat adjuster assembly and power seat harness in affected vehicles with improved countermeasure parts.
TSB-23-33-001
Service Bulletin/Repair Instructions
This TSB provides corrections and additional information for the Front and Rear Suspension inspection procedures. (Service Manual Revision)
TIN-21-37-001REV
Service Bulletin/Repair Instructions
This is a Revised Technical Information Notice advising dealers of the instructions to follow when performing a wheel alignment check and adjustment on an affected vehicle with a customer concern of pulling/drifting and/or steering wheel off-center concerns.
TSB-23-23-001
Service Bulletin/Repair Instructions
This TSB provides the addition of Diagnostic Procedure for CVT Belt Check for vehicles equipped with CVT type F1CJC and W1CJC. (Service Manual Revision)
TSB-22-35-001
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin sent to dealers informing them of updates to the Stoplight Switch Check section, in the Service Brakes portion of the affected Service Manuals.
TSB-22-51-003
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin sent to dealers informing them of updates to the Troubleshooting Procedure for the Windshield Wiper in the Exterior portion of the affected Service Manuals.
TSB-22-54-003
Service Bulletin/Repair Instructions
This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part.
TSB-22-16-001
Service Bulletin/Repair Instructions
This Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL illumination and a loss of engine power due to the vehicle being in fail safe mode. Unstable idling due to poor contact of the ignition coil terminal and DTC P030X may create this concern.
TSB-22-23-001REV
Service Bulletin/Repair Instructions
This Technical Service Bulletin was sent to dealers directing them to diagnose and test drive customer vehicles with F1CJC/W1CJC (CVT-8) transmissions that may exhibit a shudder or surge condition possibly caused by a poor reaction of the hydraulic pressure circuit.
TSB-22-52A-001RE
Service Bulletin/Repair Instructions
This Technical Service Bulletin instructs dealers to apply Nonwoven Fabric Tape between the Seat Back and Urethane Pad when customers report a condition where an abnormal rubbing noise is heard from the Seat Back when a driver and/or passenger is seated in the front seat(s).
TSB-21-52A-002
Service Bulletin/Repair Instructions
This Technical Service Bulletin instructs dealers to replace the seat adjuster assembly and power seat harness in affected vehicles with improved countermeasure parts. Due to a change in the reclining motor, the new longer harness and connector are necessary.
TIN-21-00-004
Service Bulletin/Repair Instructions
This Technical Information Notice was sent to dealers informing them Owner Manuals (OM) are now available electronically beginning with Model Year 2015.
TSB-21-34-001
Service Bulletin/Repair Instructions
This Technical Service Bulletin was sent to dealers informing them a shock absorber oil leak may result in replacement of absorbers unnecessarily when trace amounts of oil are noted to have adhered to the shock absorber.
TIN-21-13-001
Service Bulletin/Repair Instructions
This Technical Information Notice provides additional instructions to dealers when replacing the Valve Cover Gasket due to a customer concern of oil leaking.
TSB-21-54A-001
Service Bulletin/Repair Instructions
This Technical Service Bulletin was sent to dealers providing instructions for repairs to perform to correct a communication error that may occur between the One-Touch Start System (OSS) and Engine Control Unit (ECU) or the Keyless Operating System (KOS) and Engine Control Unit (ECU).
TSB-21-51-001
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin sent to dealers instructing them to replace both sides of the wheel arch molding when customers report a condition in vehicles equipped with a front wheel arch molding displays a gap between the front wheel arch molding and the fender.
TIN-20-52A-002
Service Bulletin/Repair Instructions
Technical Information Notice sent to dealerships that additional circuit codes for the Driver's Seat Slide Sensor Circuits may appear and dealers should check for damage to the driverâs seat slide position sensor harness.
TSB-20-15-001
Service Bulletin/Repair Instructions
This Technical Service Bulletin was sent informing dealers a rattle noise may be heard from the Heat Protector of the Exhaust Manifold and instructs dealers to replace the Heat Protector Assembly with a new part.
TSB-20-54A-001
Service Bulletin/Repair Instructions
This TSB updates the affected Service Manual Data List Reference tables within the Chassis Electrical section. These changes are being made to correct the Left, Right, and Center Reflection Amplitudes within the table.
TSB-20-14-002
Service Bulletin/Repair Instructions
This TSB instructs dealers a condition where the coolant temperature warning light illuminates and a coolant leak is found at the hose connection and to replace the old hose clamp with a countermeasure clamp and to replace the old water hose with a new water hose.
TT-20-00-002
Service Bulletin/Repair Instructions
Tech Talk is a service newsletter that was sent out to dealers. It covers various topics and reviews the previous months publications.
TIN-20-52A-001
Service Bulletin/Repair Instructions
This Technical Information Notice serves as a reminder that if a vehicle arrives with a complaint related to a seat belt tongue not staying in place or that slides down to the floor, always default to searching for applicable TSBs, Tech Talk articles, and TINs first.
TSB-20-42B-002
Service Bulletin/Repair Instructions
A 2019 Outlander PHEV Body Repair Manual was not issued. Use the 2018 Body Repair Manual (MSSP-427B-2018) along with this TSB for complete body repair information on the 2019 Outlander PHEV.
TSB-20-23-001
Service Bulletin/Repair Instructions
Certain vehicles with F1CJC/W1CJC (CVT-8) transmissions may exhibit a shudder or surge condition possibly caused by poor reaction of the hydraulic pressure circuit. With continued driving under these conditions, the CVT belt may slip repeatedly when accelerating, and abrasion powder may enter the hydraulic pressure circuit, causing a warning light to turn on. This TSB instructs dealers to diagnose and test drive vehicles exhibiting this condition. *This TSB may also apply to later model years with F1CJC/W1CJC (CVT-8) transmissions.
TSB-20-42A-002
Service Bulletin/Repair Instructions
This TSB updates the Body section of the affected Service Manuals to add information (including a Caution) to the windshield Removal and Installation procedure for vehicles equipped with Forward Collision Mitigation System (FCM), Lane Departure Warning System (LDW), and Automatic High Beam System (AHB).
TSB-20-52A-001
Service Bulletin/Repair Instructions
This TSB updates the Interior & Supplemental Restraint (SRS) section of the affected Service Manuals to update the disassembly procedure of the front seat assembly with these additional parts: Seat heater harness, Front seat hinge protector, and Slide sensor harness.
TSB-20-31-001
Service Bulletin/Repair Instructions
This bulletin advises that tire chains are NOT approved for use on any 2016 - 2020 Mitsubishi vehicle.
TSB-20-42A-001
Service Bulletin/Repair Instructions
This TSB updates the Body section of the affected Service Manuals to correct the tightening torque of the fixing bolt for the tailgate latch, and to distinguish the different torques for the 2 types of bolts for 2019 model year vehicles.
TSB-19-52A-006
Service Bulletin/Repair Instructions
This is a TSB that was sent to dealers to inform them that due to stress applied intensively onto the left and right rear end portion of the seat cushion by a passenger, the cushion may sink down and rub against the edges of the metal seat frame. This in turn may cause the damaged urethane material to turn to powder and fall on the floor carpet. This TSB provides a repair procedure to replace the damaged seat cushion pad, and apply tape on the frame to help prevent future damage.
TT253
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-19-52A-004
Service Bulletin/Repair Instructions
This is a revised Technical Service Bulletin (TSB) that was sent to dealers, to inform them that this TSB supersedes TSB-17-52A-003, to add Outlander PHEV and additional model years for Outlander and Outlander Sport, and to update parts and procedures to help resolve the power seat movement.
TSB-19-35-002REV
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin that was sent to dealers, to inform them that this TSB supersedes TSB-19-35-002, issued January 2019, to update symptoms in the Purpose section, and to remove Outlander PHEV from the Affected Vehicles.
TSB-19-52A-003
Service Bulletin/Repair Instructions
This is a Technical Service Bulletin that was sent to dealers, informing them of updates to the Interior and Supplemental Restraint System (SRS) section of the affected Service Manuals, to correct the front pillar trim assembly installation procedure.
TT218
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-15-54-004
Service Bulletin/Repair Instructions
This TSB contains troubleshooting steps for diagnosis of various customer complaints relating to the audio system speakers in Mitsubishi vehicles equipped with original equipment audio components.
TT217
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT195
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TTIndex12
Service Bulletin/Repair Instructions
This is an index of Tech Talk newsletter articles released in 2012.
TT194
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TSB-13-42A-002
Service Bulletin/Repair Instructions
This Technical Service Bulletin updates the door adjustment procedure in the Body Section of the applicable service manuals.
TT193
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT192
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
TT191
Service Bulletin/Repair Instructions
This is a service newsletter (Tech Talk) that was sent out to dealers.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.