SMB180
Service Bulletin/Repair Instructions
This Service Manual Bulletin Provides Updated Preventive Maintenace Interval for the Crankcase Breather Tube Element on Buses Equipped with a Cummins Diesel ISL 07 or ISL 09 Engine.
Vehicle report
2015 NEW FLYER XD40
Service bulletins
19 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
PMB049
Service Bulletin/Repair Instructions
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
SMB177
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new inspection and replacement requirements for the coolant hoses located above the SDS enclosure on specifically equipped buses.
SMB176
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
ITS6467
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Add Re-enforcement Brackets to the Existing Air Accessory Tank Mounting Bracket.
PMB048
Service Bulletin/Repair Instructions
This Parts Manual bulletin provides information on the part numbers of the engine lift brackets
SMB173
Service Bulletin/Repair Instructions
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
SMB170
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides a correction for the information regarding the replacement of the DEF tank suction filter.
ITS6522
Service Bulletin/Repair Instructions
Technical Instruction to inspect and repair support brackets on an accessory air system reservoir
SMB168
Service Bulletin/Repair Instructions
Service Manula Bulletin provides revised OEM information on the exhaust, after treatment System and DEF tank.
ITS6368
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REWIRE THE VOLTAGE REGULATOR POWER SUPPLY FROM THE BATTERY SIDE TO THE LOAD SIDE OF THE BATTERY DISCONNECT SWITCH.
ITS6406
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO CORRECT INSTALLATION OF STEERING GEARBOX MOUNTING PLATE.
ITS6234
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO INSPECT FRONT MASK SUPPORT BRACKET BOND AND REPAIR IF REQUIRED ON SPECIFICALLY EQUIPPED VEHICLES
ITS6254
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO RECONFIGURE VOLTAGE SENSE CONNECTION WIRING ON SPECIFICALLY EQUIPPED VEHICLES
ITS6216
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REMOVE AND REPLACE DEFROSTER HEATER BLOWER RESISTOR.
SMB-145
Service Bulletin/Repair Instructions
NEW FLYER: INFORMATION REGARDING THE WHEEL FLANGE AND LOWER RADIUS ROAD TO AXLE INSTALLATION WHEREBY CONDITION OF BOLTS NEED CHECKING AND IF ANY DEFORMITY OR DAMAGE TO MOUNTING BOLTS, HAVE THEM REPLACED. NO YEARS OR MODEL LISTED. *PE
ITS5964
Service Bulletin/Repair Instructions
Technical Instruction to Front Height Sensor Rewiring with Shielded Cable.
ITS5940
Service Bulletin/Repair Instructions
Technical Instruction to Rewire DEF Tank Sensor.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.